1995 Volvo 960

Defect. THE DRIVER'S SIDE AIR BAG MODULE MAY NOT PROPERLY DEPLOY.

Risk. THIS WOULD RESULT IN REDUCED ACCIDENT/INJURY PROTECTION FOR THE DRIVER IN THE EVENT OF A COLLISION.

Remedy. DEALERS WILL REPLACE THE DRIVER'S AIR BAG MODULE.

TL* THE CONTACT OWNS A 1995 VOLVO 960. THE CONTACT STATED THE VEHICLE HAD AN EXTREMELY STRONG GASOLINE FUEL ODOR. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO BE DIAGNOSED OR REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 17,289. UPDATED 07/21/11 *BF UPDATED 07/28/11

TL* THE CONTACT OWNS A 1995 VOLVO 960. WHILE PULLING INTO HER DRIVEWAY THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING, CAUSING THE CONTACT TO CRASH INTO HER GARAGE DOOR. THE VEHICLE WAS NOT DIAGNOSED BY THE DEALERSHIP AND THERE WERE NO RECALLS FOR THE FAILURE DESCRIBED. THE CURRENT AND FAILURE MILEAGES WERE UNDER 150,000.

MY CAR IS A 1995 960 MODEL VOLVO, ABOUT 6 MONTHS AGO THE LEATHER STARTED PULLING AWAY FROM THE WINDOWS ON ALL FOUR DOORS. IT LOOKS TERRIBLE AND I WOULD LIKE TO GET IT FIX , BUT CANNOT FIND ANYONE THAT IS WILLING TO FIX IT. HELP ME PLEASE!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!! THANKS *TR

IN EARLY MORNING COLD STARTUPS, THERE ARE GAS FUMES THAT ARE PRESENT. THEY EVENTUALLY DISAPPEAR AFTER ABOUT 30 MINUTES OF DRIVING. I KNOW THERE MUST BE A FUEL LEAK ON THIS VEHICLE DUE TO THE STRONG SMELL OF GASOLINE. *TR

SRS LIGHT IS ON AND DOESN'T TURN OFF. IT IS PART OF A RECALL. *TR UPDATED 01-14-08. *KB

FUEL RAIL LEAKING GASOLINE ON ENGINE. SMELL INSIDE CABIN MAKING ME SICK. GARAGE SMELLED AS WELL. AFTER DRIVING, THE SMELL WOULD GO AWAY. *JB

DT: THE CONTACT'S DAUGHTER STARTED THE VEHICLE AND IT ACCELERATED FROM ZERO TO 40 MPH WITHOUT DEPRESSING THE ACCELERATOR. THE FIRST TIME THE VEHICLE HIT A CONCRETE PARKING BARRIER. THE VEHICLE WAS TOWED TO A SERVICE DEPARTMENT. THE SOURCE OF THE PROBLEM COULD NOT BE DETERMINED. THE VEHICLE'S BODY DAMAGE WAS REPAIRED, AND THE VEHICLE WAS RETURNED TO SERVICE. THE ACCELERATION PROBLEM OCCURRED ONCE AGAIN. THIS TIME IT CAUSED THE DRIVER TO CRASH INTO A WALL. IT WAS TAKEN TO A SERVICE DEALER WHO STATED THE INCIDENT WAS CAUSED BY A PROBLEM WITHIN THE ENGINE. *AK UPDATED 12/16/2005 - THE DEALER LATER FOUND THAT THE THROTTLE CABLE HOUSING HAD SEPARATED FROM THE CRIMPED END AT THE THROTTLE VALVE. AS A RESULT THE CABLE HOUSING HAD SLID OUT AND WAS HANGING UP, CAUSING THE VEHICLE TO ACCELERATE WHEN IN GEAR. *NM

WHILE DRIVING 70 MPH ENGINE FAILED . AS A RESULT, POWER STEERING AND POWER BRAKES BECAME INOPERATIVE. NO IMPACT REPORTED. *AK

THE TIMING CHAIN BROKE WHILE DRIVING 30 MPH, WHICH CAUSED LOST OF POWER AND CONTROL. PLEASE PROVIDE ANY FURTHER INFORMATION. *JB

WHILE RELEASING THE BRAKE PEDAL VEHICLE ACCELERATED, AND COLLIDED WITH A TREE AND A VEHICLE. THEN, VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION. HOWEVER THE CAUSE OF THE PROBLEM NOT BEEN DETERMINED. *AK

CONSUMER DISCOVERED A 4 INCH GASH ON INNER SIDEWALL OF PIRELLI TIRE. TIRE SIZE P205/55R/16. *AK THE TIRES SIDEWALL BLEWOUT. *NM

WHILE DRIVING THE VEHICLE AT 30 MPH AND WITH NO WARNING THE VEHICLE ACCELERATED WHICH CAUSED THE CONSUMER TO LOSE CONTROL OF VEHICLE. DEALER HAD BEEN CONTACTED ON TWO OCCASIONS. *AK THE CONSUMER WAS DRIVING WITH BOTH HANDS ON THE STEERING WHEEL WHEN SUDDENLY, WITHOUT WARNING, THE STEERING WHEEL JERKED TO THE RIGHT AND HE/SHE LOSS CONTROL OF THE VEHICLE. THE VEHICLE HAD GONE ONTO THE SIDEWALK(S), SIDE SWIPED OBJECTS, AND COLLIDED INTO A BUILDING. *SCC *JB

COPNSUMER STATES VEHICLE SHUTS OFF WITHOUT WARNING. DEALER NOTIFIED. *AK

BOTH FRONT AIRBAGS IN MY 1995 960 VOLVO STATION WAGON DEPLOYED SPONTANEOUSLY AS I WAS BACKING OUT A DRIVEWAY AT 2 - 3 MPH. *JB

THE ENGINE STALLED WITHOUT WARNING, THE DEALER WAS UNABLE TO DIAGNOSE THE PROBLEM. *JB

THE VEHICLE STALLED WITHOUT WARNING. *NLM

THE FUEL RAIL ON MY 1995 VOLVO 960 LEAKS. IT LEAKS AT THE PLUG ON THE END OF THE RAIL. IT LEAKS A STEADY STREAM OF GAS THAT POURS OVER MY ENGINE. AFTER REVIEWING VOLVO USER FORUMS IT APPEARS THAT THIS IS A COMMON PROBLEM FOR THIS TYPE OF VOLVO. IT IS A SEVERE FIRE HAZARD! WHY HAVEN'T YOU FORCED THE DEALER TO ISSUE A RECALL NOTICE?

CONSUMER STATES VEHICLE'S HEATED SEATS HAS MALFUNCTIONED AND CAN CAUSE A VEHICLE FIRE. DEALER NOTIFIED. TS BOTH HEATERS UNDER THE FRONT SEATS HAVE SHORTED OUT AFTER BURNING. SCC

ON 8/31/2002 MY 1995 VOLVO 950 WAS HIT AT THE LEFT REAR END WHILE MY WIFE AND I WERE TRAVEL EAST BOUND ON HIGHWAY 60 IN CALIFORNIA, STOPPING DUE TO TRAFFIC CONDITION AHEAD. DURING THE REAR END COLLISION IMPACT, THE SEATBACKS OF BOTH FRONT SEATS COLLAPSED REARWARD. WE SUFFERED ARM, NECK, SHOULDER, AND BACK INJURIES BECAUSE THERE WERE NO SEATBACK SUPPORTS. DURING THE COLLISION THE WINDSHIELD AND OTHER WINDOWS, EXCEPT THE LEFT REAR ONE, REMAINED INTACT. WE WERE LUCKY NOT HAVING MORE SERIOUS INJURIES. COLLAPSE OF SEATBACKS REARWARD WOULD HAVE CAUSED MORE SERIOUS INJURIES, OR EVEN DEATH. DT

THE FUEL RAIL HAS A MANUFACTURING HOLE AT ITS FRONT END, WHICH IS PERMANENTLY PLUGGED BEFORE INSTALLATION. IN RECENT WEEKS, THIS PLUG BEGAN LEAKING RAW GASOLINE, WHICH IS UNDER HIGH PRESSURE WITHIN THE FUEL RAIL TO SUPPLY FUEL TO THE FUEL INJECTORS. THE SOURCE WAS NOT IMMEDIATELY EVIDENT, UNTIL JANUARY 25TH, WHEN THE FUMES BECAME SICKENING. AT THAT TIME, WE OBSERVED RAW FUEL DROPLETS LEAKING PAST THIS FUEL RAIL PLUG ON THE ENGINE. WE IMMEDIATELY KILLED THE ENGINE. IN TALKING WITH VOLVO DEALERSHIP PERSONNEL, THEY WERE IMMEDIATELY FAMILIAR WITH THE SITUATION, INDICATING THAT THEY HAD SEEN THIS BEFORE. MY IMPRESSION IS THAT IT IS HAPPENING MANY MORE TIMES THAN IT SHOULD, CONSIDERING THE FIRE HAZARD THAT FUEL CAN BE. OBVIOUSLY, NO ONE WAS GOING TO GIVE ME NUMBERS, BUT MY CONCERN IS OBVIOUS. THE REPLACEMENT FUEL RAIL (P/N 9179348) IS FOR THE S90, SUGGESTING TO ME THAT THE PROBLEM WITH 960 FUEL RAILS IS WIDESPREAD, SUCH THAT A DIFFERENT PART OR A REDESIGN IS NEEDED. THE TWO FUEL RAILS ARE DISSIMILAR, SO ADDITIONAL PARTS ARE REQUIRED TO MATCH THE NEW RAIL TO THE 960 MODEL. IN MY OPINION, THIS ISSUE IS WORTH INVESTIGATING FOR POSSIBLE RECALL. FYI  I DO MOST OF MY OWN AUTOMOTIVE REPAIRS, SO I HAVE FIRST-HAND KNOWLEDGE OF THIS SITUATION.

WHILE DRIVING THE VEHICLE THE CHECK ENGINE LIGHT CAME ON. THE VEHICLE CONTINUED TO FUNCTION NORMALLY AND WAS DRIVEN HOME AND PARKED. ON A LATER TRIP THE SAME DAY THE LIGHT REMAINED ILLUMINATED AND VEHICLE BEGAN TO ACCELERATE ON ITS OWN. I REMOVED MY FOOT FROM THE ACCELERATOR PEDAL AND THE VEHICLE RAPIDLY WENT FROM 30 MPH TO 50 MPH. I WAS ABLE TO SLOW THE CAR DOWN WITH BRAKING AND PULLED OFF THE ROAD. WHEN PUT IN NEUTRAL THE ENGINE RAPIDLY ACCELERATED TO APPROX. 4000RPM, IN PARK IT SLOWED CLOSER TO IDLE. ONCE SHUT OFF THE VEHICLE WOULD NOT START AGAIN UNTIL IT COOLED DOWN, IT THEN ONCE AGAIN BEGAN ACCELERATING ON ITS OWN. THE CHECK ENGINE LIGHT HAS REMAINED ILLUMINATED SINCE THE FIRST INCIDENT.*AK

5/14 - VEHICLE STALLS AS CROSSING INTERSECTION, CHECK ENGINE LIGHT NOW ON. ABLE TO RESTART VEHICLE AND HAD 2 MORE STALLS BEFORE ARRIVING AT DEALER FOR SERVICING. 6/13 - WHILE TRAVELLING UPHILL, APPLIED GAS AND VEHICLE DIED WITH CHECK ENGINE LIGHT ON. AGAIN RETURNED VEHICLE FOR SERVICING. 7/6 - WHILE TRAVELLING ON FLAT ROAD, CAR STALLS WITH CHECK ENGINE LIGHT ON. NUMEROUS STALLS WHILE DRIVING FROM FRIEND'S HOME TO DEALER FOR SERVICING. 7/17 - PICKED CAR UP AT DEALERSHIP, 3 STALLS WITH CHECK ENGINE LIGHT ON BEFORE MAKING IT TO THE MAIN. CAR RETURNED TO DEALER FOR SERVICING. *AK

NO SUMMARY LISTED FOR

FUEL RAIL END CAP SEAL HAS FAILED AFTER ONLY 77,000 MILES. *AK

I WAS DRIVING ON THE HIGHWAY WHEN APPROXIMATELY A 12" SECTION OF MY RIGHT REAR TIRE SEPARATED AND HIT THE BOTTOM OF MY CAR. I HAVE SINCE HAD THE ONE TIRE REPLACED AND WAS CHARGED A PRO-RATED AMOUNT, HOWEVER I STILL HAVE 3 OF THE SAME TIRES ON THE CAR( DOT NUMBER: A3T2 3E6 TIRE SIZE: P205/55R16 )

AFTER MARKET TIRE P205/55R16 DOT#: Y78KPVB096. TREAD ON THE RIGHT TIRE SEPARATED, RESULTING IN A COLLISION.*AK BRIDGESTONE P205/55/R16 *MW

THE AIR GUIDE, SPOILER AND SENSOR ARE NOT DESIGNED OR MOUNTED CORRECTLY TO WITHSTAND LIMITED DRIVING ON MAJOR HIGHWAYS, THE AIR GUIDE AND SPOILER HAVE FALLEN OFF THE VEHICLE WHILE DRIVING ON FOUR OCCASIONS. *MJS

WHEN SITTING IN TRAFFIC FOR AROUND ABOUT A HALF HOUR TO AN HOUR VEHICLE STARTED SMOKING. SMOKE WAS COMING FROM ENGINE COMPARTMENT. COOLING FAN SEIZED UP AND OVERHEATED, AND VEHICLE CAUGHT FIRE. CONSUMER CONTACTED DEALER. PARTS WERE REPAIRED/ REPLACED UNDER INSURANCE POLICY. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

FAILURE AT THIS LOW MILEAGE DOES NOT HAPPEN. THE VEHICLE HAS BEEN PROPERLY MAINTAINED BY CONTINENTAL VOLVO. PROPERLY MAINTAINED VEHICLES DO NOT BURN VALVES AT 74,500 MILES. CAUSE IS A DEFECT IN DESIGN OR WORKMANHIP THAT CAUSED VALVES TO FREEZE OPEN AND BECOME BURNED. *AK

THE CAR WAS PARKED FOR 8 HRS WHEN THE FIRE STARTED IN THE LOCATION OF THE BATTERY/FUEL PUMP. CAR WAS ENGULFED IN FLAMES AND CAR WAS TOTALED. PICTURES ARE DEVASTATING TO LOOK AT. *AK

FUEL INJECTOR FAILED AND FUEL LEAKED INTO EXHAUST SYSTEM. YH

WHEN THE VEHICLE WAS PUT IN DRIVE IT UNEXPECTEDLY SURGED FORWARD, RESULTING IN A MINOR COLLISION. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. *AK

WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE STALLS AND DIES WITHOUT WARNING. THE DEALER HAS ATTEMPTED TO REPAIR THE VEHICLE PRIOR TO THIS INCIDENT AND THE PROBLEM STILL EXISTS. THE MANUFACTURER HAS BEEN NOTIFIED. *AK

THE DRIVER'S SIDE SEAT BELT FREQUENTLY DOESN'T PULL OUT FROM ITS HOLDING ASSEMBLY. THE DEALER WAS CONTACTED 1/4/99. THE DEALER HAS TOLD ME FOR 8 WEEKS THAT NO REPLACEMENT SEAT BELT ASSEMBLES ARE AVAILABLE.

CAR CAUGHT ON FIRE AFTER BEING PARKED FOR 15-30 MINUTES, FIRE WAS UNDER THE HOOD.

WHILE DRIVING A RUMBLING AND PULSATING NOISE APPEARED WHEN PRESSING ON THE BRAKES, AND BRAKES DIDN'T SEEM TO FUNCTION. DEALER CONTACTED ,AND STATED THAT THE DRUMS WERE WARPED DUE TO NORMAL DRIVING AND SHOULD BE REPLACED. *AK

REAR SEAT BELTS HAVE BROKEN.

AUTO KEY ENTRY FAILED.

OWNER HAS ABS BRAKES; BRAKES HAVE EXCESSIVE WEAR AND VEHICLE PULLS TO LEFT WHEN BRAKES ARE USED.VEHICLE HAS BEEN IN THE SHOP NUMEROUS TIMES. ALSO REPLACED ROTORS AND PADS. *AK

STEERING ARM FAILURE, RESULTING IN AN ACCIDENT. *AK

FALSE DEPLOYMENT OF AIR BAG CAUSED ACCIDENT.

SHORT IN ELECTRICAL WIRING RESULTED IN A FIRE; ALSO ALARM/ EMISSION CONTROL/DEVICES/FUEL SYSTEM FAILURES. *AK

VANITY MIRROR SHORTS OUT.

FOUR SETS OF BRAKE ROTORS WARPED.

SEAT BELT DOES NOT FASTEN CHILD SAFETY SEAT PROPERLY, LEAVING THE CENTURY CHILD SEAT LOOSE.

WHILE DRIVING, SOMETHING HIT THE UNDERCARRIAGE OF THE VEHICLE AND CAUSED DEPLOYMENT OF THE DRIVER'S AND PASSENGER'S SIDE AIR BAG. *AK *SLC

WHEN MAKING A TURN, THERE IS A NOISE COMING FROM THE STEERING COLUMN AREA. PLEASE DESCRIBE.*AK

VEHICLE WAS PARKED, TURNED ON IGNITION, PUT IN REVERSE WENT OPEN THROTTLE POSITION RPMS ARE UNKNOWN, IMPACT 6:00, *AK

WIFE WAS INVOLVED IN ACCIDENT AN GOING (80) MPH, RAN INTO A TREE, HIT DEAD CENTER ON BUMPER AND AIR BAGS DID NOT DEPLOY. PLEASE DESCRIBE DETAILS. *AK

PARKING PAWL WHICH LOCKS THE VEHICLE IN IS BROKE IF IN PARK CAN NOT MOVE THE SHIFT OUT OF PARK. TT DEALER TEMPORARILY DISCONNECTED THE SHIFT LOCK OVER RIDE MECHANISM SO THAT THE VEHICLE WOULD BE OPERABLE.*JB