1991 Volvo 740

Defect. SAFETY BELTS ARE DESIGNED TO BE ROUTED UNDER A DIAGONAL CROSS BRACE DURING FASTENING. THE INSTRUCTIONAL LABELS FOR THE BELT ROUTING ARE INADEQUATE, AND CAN RESULT IN INADVERTENT RELEASE OF THE BELT BUCKLE.

Risk. CONSEQUENCE OF DEFECT: SAFETY BELT MISUSE COULD CAUSE THE SEAT OCCUPANT TO FACE GREATER RISK OF INJURY IN A SUDDEN STOP OR VEHICLE ACCIDENT IF AN INADVERTENT RELEASE OF THE SAFETY BELT OCCURRED.

Remedy. INSTALL LABELS TO INSTRUCT THE USER IN PROPER SAFETY BELT ROUTING; ALSO REPLACE SAFETY BELT BUCKLES.

TL* THE CONTACT OWNS A 1990 VOLVO 740GL (NA). WHILE DRIVING 30 MPH, THE DRIVER SIDE AIR BAG DEPLOYED WITHOUT WARNING. THE CONTACT SUSTAINED INJURIES TO BOTH ARMS, THE LEFT SHOULDER, AND BACK THAT REQUIRED MEDICAL ATTENTION. THE CABIN OF THE VEHICLE WAS FILLED WITH AIR BAG DEBRIS. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 248,865. UPDATED 05/03/16*LJ *CN

DT: THE OWNER TRIED TO PARK CAR AND WAS SLOWY GOING INTO THE PARKING SPACE. ALL OF SUDDEN THE CAR ACCERELATED AND IT CRASHED INTO A WALL OF A BUILDING. THEN, CAR SMOKED. OWNER SUSTAINED INJURIES . BEFORE THE CAR TOOK OFF THE OWNER WAS GOING 1-2 MPH. THE AIR BAG DEPLOYED AND INJURED THE OWNER'S ARM.*AK

WHILE DRIVING 40 MPH DRIVER'S SIDE AIRBAG DEPLOYED INADVERTENTLY. DRIVER SUSTAINED INJURIES ARM, CHEST, AND FACE INJURIES. *AK

WHILE DRIVING 45 MPH VEHICLE STALLED. CONSUMER TRIED TO RESTART VEHICLE, AND AFTER 60 SECONDS THE VEHICLE STARTED UP AGAIN. CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC COULD NOT DUPLICATE THE PROBLEM. *AK

THE DRIVER AND PASSENGER SEAT BELTS BROKE FROM THE ANCHORING AT THE BOTTOM DUE TO DETERIORATION OF THE PLASTIC RELEASE BUTTON. *AK *CB *NLM

WHILE DRIVING THE VEHICLE HAD STOP ON A TRAFIC LIGHT AND THEN BEARLY REALESED THE BRAKE PAD AND INPACTED THE FRONT VEHICLE THAT LET THE AIR BAGS DEPLOY. MANUFACTOR WAS CONTACTED AND STATED THAT THE RETRAINT SYSTEM PERFORM PROPERLY AND THERE WAS EVIDENCE OF PRIOR ACCIDENT THAT IT WAS DONE SIX YEARS BEFORE WHERE THE ACCIDENT WAS MAJOR AND AIR BAGS DID NOT DEPLOY. TS

IN MAY 2000, I HAD A PROBLEM WITH MY CAR EITHER NOT STARTING, AND IF IT DID START IT WOULD STALL AT ANY TIME. THIS SEEMS SIMULAR TO THE INCIDENT WITH THE RECENT COURT ORDERED RECALL OF THE FORD VEHICLE WITH THE FAULTY IGNITION UNIT WHICH CAUSES THE CARS TO STALL AT ANY TIME. IN MY SITUATION, I WAS TOLD THAT THE PART THAT WAS ACTUALLY CAUSING THE PROBLEM COULD NOT BE ISOLATED DOWN TO A SINGLE ITEM. THE PROBLEM THAT I WAS HAVING WAS NEVER DUPLICATED BY THE VOLVO DEALER THAT LOOKED AT IT. THEY KNEW FROM EXPERIENCE THAT THE PROBLEM WAS ONE OF THREE COMPONENTS, THE FUEL PUMP RELAY - P/N 3523608, INJECTOR RELAY - P/N 1323592-1, AND THE ENGINE SPEED SENSOR - P/N 2719949. CHANGING THESE PARTS WAS A NORMAL PROCEDURE FOR THIS SITUATION, I WAS TOLD BY THE VOLVO SERVICE ADVISER. AT THE TIME HE ALSO TOLD ME THAT THEY GET 3 TO 4 OF THESE PROBLEMS IN A MONTH, AND HE DIDN'T SEEM CONCERNED FOR THE POTENTIAL DANGER WITH THE CAR CUTTING OFF WHILE DRIVING, OR THE FACT THAT HE WAS CHANGING TWO PARTS THAT DIDN'T NEED TO BE CHANGED. LATER I WROTE THE MANAGER OF THE VOLVO DEALERSHIP REQUESTING A REFUND FOR THE TWO GOOD PARTS THAT WERE CHANGED AND GOT A REPLY FROM THE SAME SERVICE ADVISER. AT THIS TIME THE NUMBER OF TIMES THEY GET THIS PROBLEM PER MONTH ACCORDING TO HIM DROPPED TO 1 INSTEAD OF THE3 TO 4 PER MONTH THAT HE HAD CLAIMED BEFORE. I POINTED OUT TO HIM THAT THE FACT THAT THE PART NEVER FAILS PERMENATELY IS CAUSE TO CONSIDER IT A DEFECTIVE PART. HE SAID THERE'S NOTHING IN THE BOOK THAT STATES

I TOOK MY CAR IN WHEN THE RED LIGHT ON THE DASHBOARD FOR AIR BAG LIGHTS COMING ON. THE FAIRFAX VOVLO DEALER ESTIMATED MY REPAIRS TO BE $1400.00. I FIND THIS OUTRAGEOUS, THE PART ALONE WAS $1100. I WOULD LIKE TO KNOW IF ANYONE ELSE HAS HAD THIS PROBLEM AND OR IS THIS A ONE TIME CASE. I WILL ALSO SEND AN E-MAIL TO VOLVO. *AK

TRANSMISSION FAILED. YH

WHILE SITTING IDLE AT A STOP LIGHT THE SRS LIGHT CAME ON AND STAYED ON.CONSUMER CONTACTED AN INDEPENDENT VOLVE SERVICE CENTER, AND HAD IT DIAGNOSED WITH A FAILURE OF THE AIR BAG CRASH SENSOR. *AK

FALSE DEPLOYMENT OF AIR BAG CAUSED INJURY TO CONSUMER. (ATTORNEY FOR CONSUMER). MJS

VEHICLE WA SIN AN ACCIDENT. UPON IMPACT, AIRBAGS DEPLOYED, BUT DIDN'T INFLATE. *AK

VEHICLE WAS INVOLVED IN A COLLISION AT 5 MPH . AFTER THE VEHICLE WAS AT A COMPLETE STOP AIRBAG DEPLOYED, CAUSING THE DRIVER TO SUSTAIN MINOR INJURIES. THE MANUFACTURER WILL BE NOTIFIED. *AK

SRS LIGHT INDICATES NOT FUNCTIONAL. IN ADDITION, CENTER/REAR SEAT BELT PLASTIC COVER OVER MALE PORTION OF LATCH CONTINUALLY COMES OFF, CAUSING AN INSIDE PART TO FALL OUT.

WATER PUMP FAILED.

VEHICLE WAS STRUCK IN FRONT AND AIR BAG DEPLOYED HALF OF THE WAY AND THEN IT BURNT WITHOUT INFLATING ALL THE WAY.*AK

ASK FOR EXT. 148. HEAD ON ACCIDENT AND AIR BAG DID NOT DEPLOY. SEAT BELT WAS ACTIVE. *AK CONSUMER WAS INJURED IN ACCIDENT. *SLC

CONSUMER WAS DRIVING CAR STARTED SMOKING PULL OVER CAR CAUGHT ON FIRE. TT

WHEN DRIVING COMING TO A STOP AND START BACK UP CAR ACCELERATED THERE IS NO BRAKE. TT