2009 Volkswagen Routan complaints

TL*THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM) HOWEVER, THE PART TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE FAILURE MILEAGE WAS 60,000. UPDATED 4/21/15*CN

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM); HOWEVER, THE PARTS WERE NOT AVAILABLE TO REPAIR THE VEHICLE. THE DEALER WAS CONTACTED AND THEY WERE UNABLE TO SPECIFY WHEN THE PARTS WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL-THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE VEHICLE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 53,000. DJR

OUR 2009 ROUTAN RANDOMLY LOSES POWER AND THE ENGINE ATTEMPTS TO TURN OFF WHILE DRIVING. THIS HAS HAPPENED AT LEAST FIVE TIMES IN THE PAST YEAR. OUR ROUTAN IS PART OF THE IGNITION SWITCH RECALL, WHICH SHOULD FIX THIS PROBLEM, YET MORE THAN SIX MONTHS AFTER THIS POTENTIALLY DEADLY RECALL WAS ISSUED, VOLKSWAGEN HAS NOT OFFICIALLY ISSUED A REPAIR, SO OUR DEALERSHIP WILL NOT REPAIR. WE HAVE CONTACTED VOLKSWAGEN DIRECTLY, AND ALL WE HAVE BEEN TOLD IS "WE ARE STILL WAITING FOR MORE INFORMATION." CONSIDERING VOLKSWAGEN ISSUED THIS SAME RECALL ON THE 2010 ROUTAN MORE THAN THREE YEARS AGO AND SHOULD BE FAMILIAR WITH THE REPAIR, I FIND THIS UNACCEPTABLE. IT IS A LAWSUIT WAITING TO HAPPEN. *TR

WE HAVE HAD SEVERAL OCCASIONS WHERE THE VAN COMPLETELY SHUTS OFF EVEN WHILE RUNNING. REPORTED IT TO OUR LOCAL VW DEALER AND HAVE BEEN TOLD THAT IT MIGHT BE AN IGNITION PROBLEM WHICH IS PART OF A RECALL. WAS INFORMED THAT AT THIS TIME THEY CAN'T REPAIR IT BECAUSE THEY DON'T MAKE THAT PART. HAD IT COMPLETELY SHUT DOWN ON US WHILE IT WAS GETTING SERVICED AT THE DEALER FOR NEW BRAKES. WAS TOLD THAT ALL IT NEEDED WAS NEW BATTERY. PAID FOR IT AND GOT IT TO START ONLY TO SHUT DOWN AGAIN TWO DAYS LATER. TOOK IT BACK AGAIN AND WAS TOLD THAT IT IS NOT THE RECALL ITS SOMETHING ELSE THATS CAUSING FOR THE CAR TO SHUT OFF. NOW THE DEALER SAID THAT THEY WILL PAY FOR THE PART BUT WE PAY FOR LABOR AND WE HAVE 7 DAYS TO AGREE. THEY NEED TO FIX THIS ONGOING PROBLEM. WE ARE NOW CARRYING AROUND $175 JUMPER TO START IT WHEN IT SHUTS OFF. HAVE HAD TO SIGN UP FOR TOW ASSISTANCE PROGRAM JUST IN CASE MY FAMILY IS STRANDED. *JS

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VIN WAS INCLUDED UNDER NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM) BUT THE PART WAS NOT AVAILABLE. THE CONTACT FELT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 3,000.

CATASTROPHIC FAILURE OF TRANSMISSION AT 76K. MAJOR TRANSMISSION WORK DONE APPROXIMATELY 26K. TRANSMISSION REPLACED 6 MONTHS LATER AND STILL HAS ISSUES (SLUGGISH, NON-SMOOTH SHIFT BETWEEN GEARS AT HIGHER CRUISING SPEEDS. VW ENGINEER GERARDO ZELEDON CALLS THIS THE "ROUTAN SHAKE" AND CLAIMS THIS IS NORMAL. APPROXIMATELY 95,000 MILES STEERING BEGAN SEIZING UP WHILE IN MOTION. THIS IS, ACCORDING TO RECALL NOTICE AND SERVICE MANAGER AT FLOW VW WINSTON SALEM NC, A BEHAVIOR RELATED TO A RECALL ON THE IGNITION SWITCH (NTSHA 14V-396). NO PARTS ARE AVAILABLE AND THE CAR IS UNSAFE TO DRIVE. HOWEVER, VW CANNOT FIX THE PROBLEM AND WILL NOT ALLOW US TO USE A LOANER. *TR

WAS DRIVING ON A RESIDENTIAL STREET WHEN THE ENGINE SHUT OFF WITHOUT WARNING. COMPLETELY LOST ALL POWER (STEERING, BRAKES, ETC). WAS ABLE TO PULL OVER TO SIDE OF ROAD THANKFULLY ONLY GOING 25 MPH AND NO TRAFFIC. PUT VEHICLE IN PARK, STARTED UP IMMEDIATELY AND RAN FINE AFTER THAT. RECEIVED RECALL LETTER IN MAIL THE FOLLOWING WEEK STATING THE IGNITION SWITCH CAN TURN OFF WITHOUT NOTICE INCIDENT HAPPENED 2 ADDITIONAL TIMES, SIMILAR CIRCUMSTANCES. SPOKE WITH DEALER AND VW CORPORATE ON 3 SEPARATE OCCASIONS. VOLKSWAGEN STATES THEY DO NOT HAVE A SOLUTION FOR THE RECALL REPAIR AT THIS TIME, NOR WILL THEY DO ANYTHING ABOUT THE POSSIBLE SAFETY ISSUE OF THE VEHICLE SHUTTING OFF AND CAUSING AN ACCIDENT. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT EXPERIENCED A FAILURE RELATED TO THE RECALL, BUT THE SPECIFICS WERE NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

PROBLEMS WITH BRAKING AT 22,837 MILES IN 2010. VEHICLE WOULD SHAKE WHEN GOING DOWN A HILL AND APPLYING BRAKES TO STOP. FRONT BRAKE PADS WERE REPLACED AND ROTORS TURNED . TWO YEARS LATER IN 2012 AT 43,919 MILES BACK ROTORS AND BRAKE PADS WERE REPLACED, ALL 4 TIRES REPLACED, AND FRONT END ALIGNMENT. IN 2013 AT 68,797 MILES 2 OF THE NEW TIRES WERE REPLACED AND ANOTHER FRONT END ALIGNMENT. CAR STOPS SOMETIMES AND WILL NOT COME BACK ON IMMEDIATELY. IN 2014 AT 90,000 MILES, BATTERY DIED AND ANTIFREEZE IN RADIATOR EXPLODED, HAD TO PURCHASE A NEW BATTERY AND A PART FOR THE RADIATOR. HAD TO REPLACE FRONT ROTORS AND BRAKE PADS, 2 TIRES AND HAD ANOTHER FRONT END ALIGNMENT. EXTREMELY LOUD NOISE WHEN DRIVING, MECHANIC SAID IT MAY BE WHEEL BEARINGS. THE ABS AND CHECK ENGINE LIGHT COME ON AND OFF. DRIVER SIDE DOOR DOES NOT LOCK UNLESS YOU PUSH THE LOCK DOWN WITH YOUR HAND. MECHANIC SAYS THE FRONT BRAKE PADS WILL HAVE TO BE REPLACED WHEN TIRES ARE ROTATED THE NEXT TIME (THESE WERE REPLACED WITH THE ROTORS IN JUNE OR JULY 2014). IF YOU LEAN AGAINST BACK SEAT FROM THE TRUNK AREA, IT FALLS FORWARD AND THE MIDDLE SEAT NO LONGER FOLDS DOWN. ALSO, THE DRIVER SIDE WINDOW STALLS WHEN YOU TRY TO ROLL IT UP OR DOWN. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT STATED THAT A FAILURE RELATED TO THE RECALL WAS EXPERIENCED, BUT THE SPECIFICS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 65,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCE A FAILURE.

ON THE SAID DATE, I WAS DRIVING MY CAR WHEN I HEARD A LOUD NOISE COMING FROM THE IGNITION AREA AND THE CAR SUDDENLY AND UNEXPECTEDLY STALLED, I WAS ABLE TO RESTART THE CAR RIGHT AWAY. A MONTH LATER, I HEARD THE SAME NOISE AND THE CAR STALLED AGAIN, WHILE I WAS IN THE MIDDLE OF A VERY BUSY INTERSECTION. IN AUGUST OF 2014, I HAD RECEIVED A RECALL FROM VW INFORMING ME OF A RECALL ( NHTSA 14V-396), I TOOK MY CAR TO THE DEALER WHO HAS NOT BEEN ABLE TO FIX THE ISSUE, IN NOVEMBER, PARTS ARE STILL NOT AVAILABLE FOR THE REPAIRS TO BE PERFORMED. I SPOKE TO THE REGIONAL CASE MANAGER AT VW WHO WON'T DO ANYTHING EITHER. VW IS LETTING ME DRIVE AN UNRELIABLE AND UNSAFE VEHICLE. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE ELECTRICAL SYSTEM WAS FAULTY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT RECEIVED A NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM). AFTER CONTACTING THE DEALER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WERE STILL NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHEN THE IGNITION KEY WAS DISENGAGED, THE DOORS FAILED TO LOCK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE FAILED TO START WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE STARTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM). HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000. UPDATED 01/28/15*LJ

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED AFTER MULTIPLE ATTEMPTS HOWEVER, THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM) AND WERE UNCERTAIN OF WHEN THE REMEDY PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 94,000. UPDATED 1/23/15*CN THE CONSUMER STATED THE VEHICLE STALLED FOR A SECOND TIME. UPDATED 02/20/15*JB

WE'VE HAD MULTIPLE PROBLEMS WITH THE VAN NOT STARTING AND THE DEALER DID NOT DO ANYTHING ABOUT BECAUSE THEY COULD NOT RECREATE THE PROBLEM. WE RECEIVED A RECALL NOTICE IN AUGUST FOR IGNITION PROBLEMS WHICH COULD RESULT IN THE POWER BRAKES AND AIRBAGS SHUT DOWN WHILE DRIVING. I HAVE CALLED TWO DEALERS AND VW CUSTOMER SERVICE AND THEY KEEP SAYING THEY STILL DO NOT HAVE PARTS AFTER 2 MONTHS. *TR

OIL CONSUMPTION SINCE 24000 MILES. VW DEALER NEVER WANT TO ADDRESS THE PROBLEM. KEEP TELL ME THIS NORMAL. NOW I HAVE TO ADD QUARTER OIL EVERY MONTH. ON MORNING CAR WASN'T STARTING AND TOOK TO THE DEALER AND HAD THE IGNITION REPLACED AT 42000 MILES BUT NOW THE KEY GET STUCK ON IGNITION MULTIPLE TIMES. I HOPE THE RECALL WILL FIX THIS PROBLEM. I HAD TO REPLACE BRAKES AT 12000 MILES DUE THE VIBRATION WHILE BRAKES. I HAD MULTIPLES ELECTRICAL PROBLEMS AND SOME WAS REPAIR AFTER COUPLE TRIPS TO THE DEALER. THIS CAR IS A LEMON. WHEN WE WILL HAVE OUR MONEY BACK? *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT AFTER REFUELING, THE VEHICLE FAILED TO START. THE CONTACT HAD TO TRY SEVERAL TIMES BEFORE THE VEHICLE WOULD RESTART. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE IGNITION AND KEYS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

I RECEIVED A SAFETY RECALL LETTER IN 08/2014 FOR MY CAR 2009 VW ROUTAN. THIS IS THE DEFECTIVE IGNITION SWITCH ISSUE THAT HAS BEEN IN THE NEWS FOR MONTHS. THE LETTER SAYS PARTS ARE NOT AVAILABLE AND J WILL BE CONTACTED WHEN THEY ARE AVAILABLE. IT HAS BEEN OVER TWO MONTHS SINCE THE LETTER AND THEY STILL HAVE NOT CONTACTED US FOR THE REPAIR. I HAVE FOUR CHILDREN AND MY WIFE. THIS IS THE ONLY CAR WE HAVE SO WE MUST USE IT. I HAVE NOTHING ELSE IN MY KEY- NOTHING OF ANY WEIGHT. HOWEVER I FEEL THAT IT IS UNSAFE FOR ME TO BE DRIVING THIS CAR AROUND AND THAT VW / CHRYSLER ARE DRAGGING THEIR FEET ON THESE REPAIRS. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE DRIVING 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO MERGE TO THE SIDE OF THE ROAD. THE VEHICLE WAS ABLE TO RESTART AND RESUMED NORMAL OPERATION. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM); HOWEVER, THE PARTS WERE NOT AVAILABLE. THE FAILURE OCCURRED NUMEROUS TIMES. THE MANUFACTURER WAS UNABLE TO STATE WHEN THE PART WOULD BE AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 109,000.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE DEALER WAS UNABLE TO PROVIDE AN EXPECTED DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 02/05/14*LJ THE CONSUMER STATED THE VEHICLE WOULD FAIL TO START. *JS

MY KEY HAS BEEN STICKING IN THE IGNITION INTERMITTENTLY. USUALLY I HAVE TO TURN THE CAR BACK ON TURN THE WHEEL, PUT IT IN GEAR AND BACK IN PARK, ONE OR BOTH OF THOSE THINGS USUALLY FREES THE KEY FROM THE ACC MODE AND ALLOWS ME TO REMOVE IT FROM THE IGNITION. TODAY, I WENT TO START THE VAN AND IT IS DEAD. CLICK. THAT IS ALL IT DOES. IT DOES NOT APPEAR THE BATTERY IS DEAD, AS THE HEADLIGHTS AND INTERIOR LIGHTS COME ON, THE DOOR DINGS, THE MILEAGE COMES UP, ETC. THERE IS A RECALL FOR SOMETHING INVOLVING THE IGNITION, BUT I HAVE NOT BEEN INFORMED BY VW YET AS TO A REPAIR. I HAVE SENT IN FOUR PRIOR COMPLAINTS CONCERNING THIS VEHICLE. I BOUGHT IT USED 7/2010 FROM CARMAX. IT IS UNRELIABLE AND DANGEROUS TO HAVE ON THE ROAD. THE ENTIRE BRAKE SYSTEM NEEDS REPAIRED EVERY 7,000 MILES FOLLOWING A SUDDEN CALIPER SEIZE, THE VAN HAS NUMEROUS ELECTRICAL ISSUES THAT CAUSE THE CAR TO JUST STOP. ONE DAY I HEARD IT RUNNING IN MY GARAGE. I CANT RULE OUT ONE OF MY CHILDREN MESSING WITH THE FOB, HOWEVER, I HAVE DIFFICULTY WITH THE REMOTE STARTER MYSELF? (CLICK2X&HOLD) I DO NOT FEEL SAFE WITH THIS VEHICLE. I WILL NOT DRIVE MY CHILDREN LONG DISTANCES OR TRAVEL ROADS WITH THEM THAT REQUIRE SPEEDS OVER 40 MPH. THE VAN DIED WHILE I WAS DRIVING IT 55-60MPH ON A BUSY HIGHWAY, THE VW DEALERSHIP SAID IT WAS NOT A RECALL ISSUE. I CLEARLY SEE IT IS A RECALL ISSUE FOR SOME ROUTANS, MY RECEIPT READS EXACTLY AS THE SIDE DOOR HARNESS RECALL IS STATED. I WILL BE WORKING WITH VW TO REQUEST REIMBURSEMENT, HOWEVER, I

WHILE DRIVING IN PHOENIX AZ THE VAN BEGAN TO SHAKE AND STEERING BECAME DIFFICULT. (THIS HAS HAPPENED IN THE PAST MULTIPLE TIMES INTERMITTENTLY). LATER THE SAME EVENING BRAKES BEGAN TO SQUEAK AND GRIND. UNTIL THIS DAY THE ONLY ISSUE HAD BEEN THE INTERMITTENT SHAKING WHILE BRAKING. THERE WAS NO SQUEAKING PRIOR TO THE GRINDING. RIGHT REAR CALIPER WAS REPLACED ALONG WITH ALL FRONT/REAR BRAKES ROTORS DRUMS AND HARDWARE. COST=$780.55. *TR

WHILE DRIVING IN JACKSONVILLE FLORIDA ON HIGHWAY, WIPERS SUDDENLY CAME ON, ALL IDIOT LIGHTS BEGAN TO BLINK, HEADLIGHTS BEGAN FLASHING OFF AND ON, BEEPING SOUND LIKE WHEN DOOR IS OPEN, THE VAN SUDDENLY DIED AND I WAS UNABLE TO BRAKE, STEER OR CONTROL VEHICLE. THE VAN WAS TOWED TO VW DEALERSHIP THE PROBLEM WAS FOUND TO BE THE SLIDING DOOR HARNESS WHICH WAS INTERFERING WITH NORMAL OPERATION OF THE ELECTRICAL SYSTEM. REPLACED SLIDING DOOR HARNESS AND FAILED BATTERY. WHEN I QUESTIONED THE FAULTY PART POSSIBLY BEING A RECALL ISSUE I WAS TOLD IT WAS NOT. COST=$624.48 + RENTAL CAR. *IT IS IMPORTANT TO NOTE HERE THAT I HAD JUST CROSSED OVER A VERY LONG LARGE BRIDGE. IF I HAD BEEN GOING UPHILL WHEN THE VAN SUDDENLY DIED I AM CERTAIN I WOULD HAVE CAUSED AN ACCIDENT INFLICTING INJURY OR POSSIBLY DEATH TO EITHER MYSELF OR ANOTHER MOTORIST, AS THERE IS NO SHOULDER ON THE BRIDGE AND I WAS TRAVELING AT 55-60MPH. I COULD NOT CONTROL THE VEHICLE. THIS IS CLEARLY AN ISSUE WITH THESE MINI VANS. THANK GOD I WAS TRAVELING TO WORK AND DID NOT HAVE MY CHILDREN IN THE VAN AS I WAITED 2&1/2 HOURS FOR A TOW. *TR

DRIVING FROM INDIANA TO PHOENIX THE VAN BEGAN TO SHAKE VIOLENTLY WHILE BRAKING DOWNHILL ON MOUNTAINOUS TERRAIN. TEMPERATURE GAUGE WENT UP OVER 200 AND VAN SMELLED WARM. VAN DID NOT OVERHEAT AND PROBLEM SUBSIDED ONCE BACK ON LEVEL GROUND. PURCHASED VAN USED ON JULY 10 2012 WITH APPROX 25,000 MILES. *TR

WHILE DRIVING APPROX 30-35MPH, MY VAN BEGAN TO SMELL HOT AND SMOKE BEGAN TO RISE FROM THE RIGHT FRONT WHEEL WELL. I HAD TWO OF MY THREE CHILDREN WITH ME. I FRANTICALLY TOLD MY 14 YR OLD SON WHO WAS IN THE FRONT PASSENGER SEAT TO GET TO THE BACK AND HELP HIS FOUR YR OLD SISTER OUT OF HER CAR SEAT (WE WERE STILL MOVING) I PULLED INTO A PARKING LOT AND HAD THEM QUICKLY EXIT THE LEFT SLIDING DOOR OF THE VAN. LATER THAT EVENING I WENT BACK TO RETRIEVE THE VAN ALONE AND AS SOON AS THE VAN BEGAN TO MOVE IT MADE THE MOST HORRIBLE GRINDING NOISE I HAVE EVER HEARD. I IMMEDIATELY KNEW IT WAS A SEIZED BRAKE CALIPER, (NOT BECAUSE I AM A MECHANIC. I AM A SPEECH THERAPIST). I KNEW BECAUSE APPROX 4 MONTHS PRIOR THE VAN MADE THE EXACT SAME SOUND WITH NO WARNING WHEN THE RIGHT REAR CALIPER SEIZED AND BOTH FRONT AND BACK BRAKES WERE REPLACED! =$780). I DROVE TO THE CLOSEST BRAKE SHOP WHERE IT WAS REPAIRED THE NEXT DAY. COST=$733.68. I TRAVEL AS A SPEECH THERAPIST. I WAS IN JACKSONVILLE BEACH, FL DURING THIS FIASCO. THE PRIOR BRAKE REPAIR WAS DONE IN PHOENIX, AZ SO I COULD NOT USE THE SAME COMPANY OR QUESTION THE WARRANTY. IT CLEARLY ISN'T A WARRANTY ISSUE. AM I TO BELIEVE IT IS NORMAL TO REPLACE THE ENTIRE BRAKE SYSTEM INCLUDING ROTORS, DRUMS, PADS, DISCS, CALIPERS, BUSHINGS, PIN BOOTS, ETC,,, EVERY 7,000 MILES?? I THINK NOT. I DIDN'T EVEN KNOW ALL THOSE WORDS UNTIL I PURCHASED A ROUTAN. SOMETHING IS WRONG. THESE VANS ARE DANGEROUS. I WILL NOT DRIVE MY CHILDREN LONG DISTANCES OR ON THE INTERSTA

VEHICLE COMPLETELY TURNS OFF WHILE DRIVING, LOSING ALL CONTROL, USE OF BRAKES AND STEERING. IT HAS BEEN 4 WEEKS SINCE THE RECALL WAS SENT OUT AND THERE IS STILL NO FIX AVAILABLE, AND THE COMPANY CAN NOT GIVE ANY OTHER INFORMATION BESIDES THEY ARE WORKING ON IT. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD DECELERATE AND STALLED. THE CONTACT RECEIVED A RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM). THE DEALER STATED THAT THE PARTS WERE NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT NOT TO DRIVE THE VEHICLE SINCE THE PARTS WERE NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN.

THE ELECTRONIC DOOR (SIDE PANEL, PASSENGER, AND DRIVER) DOOR LOCKS STOPPED WORKING. AT ABOUT THE SAME TIME OUR FRONT HEADLIGHTS BEGAN TO INTERMITTENTLY GO OUT DURING OPERATION OF THE VEHICLE, AND THEN STOPPED WORKING ALTOGETHER. THE VEHICLE WAS SUBMITTED TO THE DEALERSHIP AND CUSTOMER WAS INFORMED THAT THE HEADLIGHT BALLAST WAS WORN OUT AND HAD TO BE REPLACED. PARTS WERE ORDERED AND WHEN THE VEHICLE WAS TAKEN IN FOR SAID BALLAST REPLACEMENT ANOTHER MECHANIC STATED THIS WAS NOT A BALLAST ISSUE SINCE THE HEADLIGHTS APPEARED TO TURN ON DURING IGNITION, BUT THEN STOPPED WORKING SHORTLY AFTERWARDS. WE HAD TO WAIT UNTIL THE NEXT DAY FOR A DEALER ELECTRICIAN TO LOOK AT THE VEHICLE. THE ELECTRICIAN DETERMINED A CORRODED CONTROL PANEL WAS CAUSING A SHORT AND LIKELY CAUSING DOOR THE HEADLIGHT, AS WELL AS OTHER ISSUES SUCH AS INCORRECT TIRE PRESSURE AND SPEED INDICATIONS AND POSSIBLE FIRE. NO WATER WAS INTRODUCED TO THE VEHICLE, SO MY QUESTION IS HOW DOES A CONTROL PANEL CORRODE UNLESS THERE IS A FAULTY VOLTAGE ISSUE AND ELECTRICAL DESIGN DEFECT? THE MECHANIC INDICATED THE DEALER GETS A LOT OF THESE ISSUES ON THE ROUTAN BUT THERE IS NO RECALL SO THEY CHARGE $900 FOR THE REPLACEMENT PANEL. VW KNOWS OF THIS ISSUE THAT THEIR OWN MECHANICS INDICATE CAN START ELECTRICAL FIRES! THE COMPANY SHOULD BE INVESTIGATED. *TR

MY WIFE TOOK OUR 2009 VW ROUTAN MINIVAN TO A VW DEALERSHIP TODAY TO REPAIR INOPERABLE ELECTRONIC DOOR LOCKS AND FAULTY HEADLIGHTS (SEPARATE COMPLAIN FILED), AT WHICH TIME SHE WAS INFORMED OF AN IGNITION PROBLEM RECALL. THE IGNITION PART WAS PLACED ON ORDER AND MY WIFE WAS TOLD THE PART HAD TO BE SHIPPED FROM OUT OF STATE AND SHOULD ARRIVE WITHIN FIVE DAYS. MY WIFE ASKED, AND WAS INFORMED THE VEHICLE WAS SAFE TO OPERATE; HOWEVER, I LOOKED UP THE RECALL WHEN I GOT HOME FROM WORK AND DISCOVERED THE RECALL SPECIFICALLY STATES THE ENGINE CAN SHUT OF DURING OPERATION DUE TO ADDED WEIGHT FROM OTHER KEYS OR KEY RINGS ON THE VW KEY FOB. ACCORDING TO THE RECALL, DEALERSHIP AND MAINTENANCE PERSONNEL ARE SUPPOSED TO INFORM CUSTOMERS TO REMOVE ADDED KEYS FROM THE FOB. MY WIFE HAD KEYS ON HER FOB WHICH THE DEALER MECHANIC HAD IN HIS HAND DURING INSPECTIONS, BUT THE MECHANIC NEVER INFORMED HER OF THE RISK, AND ALLOWED HER TO JEOPARDIZE HER LIFE BY DRIVING THE VEHICLE WITHOUT THE REQUIRED SAFETY INFORMATION. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE EMERGENCY BRAKE WARNING INDICATOR ILLUMINATED, WHICH INDICATED THAT IT WAS LOCKED. THE VEHICLE VEERED TO THE RIGHT AND CRASHED INTO A PARKED VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE DEALER PERFORMED AN UNKNOWN REPAIR, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 850.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED FOR THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 02/04/15*LJ

WHILE ENTERING FREEWAY LOUD NOISE THEN ALL INDICATOR LIGHTS CAME ON. VEHICLE QUIT RUNNING IN TRAFFIC. COASTED OFF ROADWAY. INSPECTED ENGINE AND SPACER BETWEEN ENGINE BLOCK AND OIL PAN WAS CRACKED. ENGINE SEIZED AND INTERNAL PARTS CRACKED BLOCK. ENGINE HAD NEW PISTON RINGS AND VALVE SEALS INSTALLED AT 68000 MILES BY DEALER FOR OIL CONSUMPTION ISSUES. OIL CONSUMPTION ISSUE WAS NEVER RESOLVED. *TR

WHEN THE VEHICLE IS TRAVELING NEAR 30MPH OR EVEN HIGHER THAN THAT, WHEN THE BRAKES ARE APPLIED, IT SHAKES VIOLENTLY. THIS CAUSES THE DRIVER TO HAVE TO HOLD THE STEERING WHEEL VERY TIGHTLY TO AVOID LOOSING CONTROL. THE BRAKING SYSTEM IN GENERAL SEEMS TO BE FAULTY AS THE BRAKES AND ROTORS HAVE HAD TO BE REPLACED/CHANGED EVERY TWO TO THREE MONTHS. IT IS VERY EXPENSIVE TO REPLACE THESE BRAKES AND ROTORS AS WELL AS PAY FOR THE LABOR EVERY FEW MONTHS. THIS IS A GREAT CONCERN AND SHOULD BE CONSIDERED FOR A RECALL. *TR

PASSENGER SIDE POWER SLIDING DOOR WIRE HARNESS KEEPS COMING OUT OF PLACE AND GETTING CAUGHT IN DOOR. LOCAL DEALER CLAIMS THIS HAS ALREADY BEEN REPAIRED UNDER THE RECALL BUT IT IS STILL HAPPENING.

THE ENGINE TURNED TO OFF WHILE I WAS DRIVING AND DEPOWERED POWER STEERING AND BRAKES. AT THAT POINT I RESTARTED THE CAR AND WAS ABLE TO DRIVE. TOOK THE CAR IMMEDIATELY TO VW DEALER, KEPT THE CAR FOR 24 HOURS, AND THEY COULD NOT REPLICATE THE INCIDENT SO NOTHING WAS DONE BY THEM. THIS HAPPENED AGAIN AT 93000 MILES ON AUGUST 8, 2014. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE DOORS FAILED TO UNLOCK FROM THE OUTSIDE OF THE VEHICLE. THE CONTACT HAD TO UTILIZE THE MANUAL LOCK THAT WAS LOCATED INSIDE THE DRIVER SIDE DOOR HANDLE IN ORDER TO UNLOCK THE DOORS. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE DEALER STATED THAT THE KEY FOB AND MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT 25 MPH, THE VEHICLE STALLED AS THE TRACTION CONTROL WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED ON TWO OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 41,300.

I WAS ACCELERATING FROM A RED LIGHT WHEN THE HOSE FROM THE COOLING SYSTEM EXPLODED. MY VAN LURCHED FORWARD AND DIED. I HAD PURCHASED AN EXTENDED WARRANTY BUT WAS TOLD THEY WOULD NOT COVER IT. I HAD TO PAY OVER $600 TO GET THE HOSE FIXED. THIS IS JUST THE BEGINNING OF MANY PROBLEMS. *TR

OUR 2009 VW ROUTAN COMPLETELY SHUTS DOWN WHILE DRIVING 3 TIMES NOW. NOT ONLY DOES IT SHUT DOWN, BUT THE STEERING AND BRAKES LOCK AS WELL. ON THE LAST OCCURRENCE, MY WIFE (WITH OUR CHILDREN IN THE CAR) CAME VERY CLOSE TO HITTING A PARKED CAR IN THE STREET. WE HAVE TAKEN IT TO 2 VW DEALERS SO FAR IN CHARLOTTE, NC AND THEY STATE: "WE CANNOT DUPLICATE THE ISSUE." UNFORTUNATELY, THAT IS NOT THE RIGHT ANSWER WHEN YOU HAVE SOMETHING AS DANGEROUS AS THIS HAPPENING TO OUR FAMILY CAR. WE HAVE CALLED VW CORPORATE TO HELP 2ND DEALERSHIP WITH A RESOLUTION, BUT NOTHING HAS BEEN FIXED AT THIS TIME. WE ARE NOT SURE WHAT DO AT THIS POINT, AND SEEMS LIKE BOTH VW AND VW DEALERSHIPS ARE AWARE OF ISSUE, BUT NO ONE WANTS TO TOUCH IT! PLEASE HELP! *TR

THE IGNITION WOULD NOT SHUT OFF AND THE KEY GETS STUCK. HAVE TO PLAY WITH IT SEVERAL TIMES TO GET IT TO SHUT OFF. THE DEALER REPLACED THE IGNITION AS WELL AS OTHER ITEMS IN THE STEERING COLUMN. *TR

SHORTLY AFTER BUYING THIS VAN THE VAN WOULD SHAKE WHEN BRAKES WERE ENGAGED, TOOK IT TO THE DEALERSHIP BUT THEY SAID NOTHING WAS WRONG WITH THE BRAKES. I TOOK IT TO ANOTHER PLACE FOR VERIFICATION AND WAS TOLD MY BRAKES WERE BAD, THE ROTORS WERE WARPED. WENT BACK TO DEALER AND TOLD MGR ABOUT THE SECOND OPINION SO HE HAD THE BRAKES REPLACED. *TR

MY 2009 ROUTAN 3.8L WILL INTERMIT NOT START / I GET CHECK ENGINE LIGHT AND ELECTRICAL LIGHTENING BOLT. ABOUT 3 YEARS AGO IT STARTED AND I WAS TOLD IT WAS MY BATTERY. REPLACED MY BATTERY IT WAS GOOD FOR ABOUT 1YR THEN IT STARTED AGAIN HAD THE BATTERY REPLACED AGAIN THEN ABOUT 1YR LATER IT STARTED AGAIN BUT MY BATTERY IS TESTED GOOD. I WENT THROUGH 2 BATTERIES IN ABOUT 3 YRS. I EVEN HAD MY STARTER CHECKED AND IT TESTED GOOD. MY FRIEND WHO IS A MECHANIC SAID WHY IS THE STARTER NEXT TO THE EXHAUST MANIFOLD IT IS GETTING HOT. WHEN I HAVE ISSUE IN THE LAST YEAR IT TAKE ABOUT 30MIN OR LONGER BEFORE IT STARTS THEN I MIGHT NOT HAVE ANY ISSUES FOR ABOUT 1 OR 2 WEEKS AND SOMETIME I MIGHT HAVE THE ISSUES 2 TIMES IN ONE DAY. I HAVE CHECKED ONLINE AND I AM SEEING MANY PEOPLE ARE COMPLAINING ABOUT THE 2009 VW ROUTAN INTERMIT NOT STARTING. I HAVE CALL VW AND MY VAN IS NOT ON THE LIST FOR THE IGNITION SWITCH RECALL. TODAY 8/5/2014 MY ROUTAN I WILL NOT START AT ALL I AM GOING TO HAVE THE BATTERY CHECKED. *TR

TL* THE CONTACT OWNS 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS.. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 44,000.

I HAVE BEEN EXPERIENCING THE ENGINE DYING SUDDENLY WHILE I AM DRIVING. THERE IS NO WARNING OR ENGINE LIGHTS. EVERYTHING TURNS OFF INCLUDING THE POWER STEERING. THIS IS TERRIFYING. I TOOK MY VEHICLE TO THE DEALER, I HAVE AN EXTENDED WARRANTY. AFTER KEEPING IT TWO DAYS, THEY CLAIM THAT NOTHING IS WRONG WITH THE CAR. I TRIED TO EXPLAIN THE DANGER INVOLVED IN MY CAR SUDDENLY LOSING POWER BUT THE DEALER STATES THERE IS NOTHING THEY CAN DO ABOUT IT. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE BRAKE ROTORS FAILED EVERY 8,000 MILES. THE VEHICLE WAS TAKEN TOA DEALER WHERE THE FAILURE WAS UNABLE TO BE DUPLICATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,329.

YOUR SITE WOULDN'T ALLOW PULL-DOWN FOR AFFECTED PARTS EARLIER, HERE IS PART OF THE E-MAIL REPORT I FIRST SENT DEALER 5/6/14: " ..SOMETHING NEW IS A PROBLEM W/MY ROUTAN BUT I WANT TO CHECK IN PRIOR TO MAKING AN APPT. SINCE WE SO RECENTLY HAD IT IN FOR DIAGNOSTIC CHECK UP. HERE'S WHAT'S HAPPENING IT'S VERY SCARY: 6 TIMES NOW OVER THE LAST 2 WEEKS IT'S JUST CONKED-OUT/SHUT OFF WHILE I'M DRIVING, LEAVING ME WITH NO STEERING, BRAKES OR ANYTHING! FORTUNATELY IT'S HAPPENED IN LOW TRAFFIC AREAS ON FAIRLY STRAIGHT ROADS SO I'VE BEEN ABLE TO COAST TO THE SIDE, BUT I'M GETTING SCARED TO DRIVE MY VAN. YESTERDAY- IT CONKED OUT THREE TIMES...BRINGING KIDS HOME FROM SCHOOL-- AGAIN VERY SCARY, AND ONCE ON A TURN WHICH WAS DIFFICULT BUT LUCKILY NO ONE WAS BEHIND ME... THESE EVENTS... ALL HAPPENED AT LOW SPEED 15-30 MPH AND HAPPEN SO QUIETLY I CAN BARELY TELL IT'S HAPPENED... IT'S LIKE THE KEY/IGNITION SOMEHOW FLICKS ALL BY ITSELF INTO THE ACC POSITION. THEN I HAVE TO WAIT TIL THE VAN STOPS, TURN THE KEY AND VAN ALL THE WAY OFF AND RE-START. THEN IT SEEMS TO START UP FINE. BUT THIS HAPPENED THREE TIMES JUST YESTERDAY P.M.... IT'S DANGEROUS, AND I'M GETTING MORE AND MORE SCARED TO DRIVE MY VAN, BUT I HAVE TO WITH FOUR KIDS AND ACTIVITIES." TODAY 6/30/14 (AGAIN) DEALER FOUND NO PROBLEM. COST TO REPLACE SWITCH $989.00. I RESEARCHED DELPHI, CHINA, AUSTIN MARTIN AND FULLY BELIEVE A COMMONALITY WITH GM RECALL EXISTS. THE ROUTAN IS A VW & CHRYSLER COMPLICATING MY RESEARCH. I'VE FOLLOWED HIERARCHY- DE