2013 Victory Cross Country

Defect. Polaris Industries, Inc. (Polaris) is recalling certain 2010-2017 Victory Cross Country, Cross Country Tour, Cross Roads, Magnum, and Hard Ball motorcycles. If the engine misfires, continued riding may result in heat from the catalytic converter melting the rear brake line and nearby wiring.

Risk. A melted rear brake line can reduce braking performance, increasing the risk of a crash.

Remedy. Polaris will notify owners, and dealers will re-route the brake line away from the exhaust catalyst, free of charge. The recall began on November 8, 2017. Owners may contact Polaris customer service at 1-877-737-7172. Polaris' number for this recall is V-17-02.

Defect. Polaris Industries, Inc. (Polaris) is recalling certain model year 2013-2014 Victory Cross Country, Cross Roads, Hammer Eight Ball, High Ball, Jackpot, Vegas Eight Ball, 2014 Victory Cross Country Eight Ball, Cross Roads Eight Ball, Ness Cross Country, 2015 Victory Gunner, and 2013 Victory Hardball motorcycles. The fuel pump in the affected motorcycles may have been incorrectly crimped during manufacturing, which may result in the fuel pump seizing.

Risk. If the fuel pump seizes, the motorcycle will stall, increasing the risk of a crash.

Remedy. Victory will notify owners, and dealers will replace the fuel pump, free of charge. The recall began on January 14, 2015. Owners may contact Victory consumer service at 1-877-737-7172. Polaris' number for this recall is V-15-01 A/B.

Defect. Polaris is recalling certain model year 2012-2013 Victory motorcycles manufactured from January 3, 2012, through August 15, 2012. A torqueing procedure may have been missed on some throttle cable retention nuts. On certain motorcycles, the throttle cable retention nuts for either the pull or push throttle cable may have not been torqued correctly.

Risk. If the torqueing is missed and the retention nuts are loose, the retention nuts closest to the throttle body can become dislodged and interfere with the throttle function, increasing the risk of a crash.

Remedy. Victory will notify owners and dealers will correctly torque the fasteners free of charge. The safety recall began on October 4, 2012. Owners may contact Victory consumer service department by calling 1-888-704-5290.

C-clip used to hold transmission gears in place has dislodged from the groove it is supposed to be locked into, allowing the gears to travel more than they are supposed to do, which could result in a transmission lockup and subsequent, potentailly, catastrophic accident.

The contact owns a 2013 Victory Cross Country Motorcycle. The contact stated that while riding approximately 8 MPH around a curve, the motorcycle stalled and lost motive and electrical power. The contact stated that he then attempted to restart the motorcycle however, the rear wheel seized once the motorcycle was shifted into gear. The contact kick-started the motorcycle and rode the motorcycle back to the residence where it remained. The contact stated that he had not contacted the dealer or the manufacturer. The contact referenced NHTSA Campaign Number: 15V002000 (Fuel System, Gasoline) however, the VIN was not included. The approximate failure mileage was 30,000.

PASSENGER BACKREST RECALL AND BRAKE LINE DEFECT. WITH BRAKE LINES MELTING !!!

TL* THE CONTACT OWNS A 2013 VICTORY CROSS COUNTRY. WHILE DRIVING VARIOUS SPEEDS, THERE WAS AN ABNORMAL NOISE COMING FROM THE TRANSMISSION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 13,000.

TL* THE CONTACT OWNS A 2013 VICTORY CROSS COUNTRY. WHILE DRIVING AT A SLOW SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V002000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 22,000. THE VIN WAS UNAVAILABLE.

I WAS TRAVELLING DOWN THE ROAD WITH THE CRUISE CONTROL ENGAGED AT APPROXIMATELY 60 MPH. AS I WAS APPROACHING THE INTERSECTION WHERE I NEEDED TO TURN, I PULLED ON THE FRONT BRAKE LEVER TO DISENGAGE THE CRUISE CONTROL, BUT THE CRUISE DID NOT DEACTIVATE. I PULLED ON THE FRONT BRAKE LEVER SEVERAL TIMES AND THE ELECTRONIC CRUISE CONTROL WOULD STILL NOT DISENGAGE. I ENDED UP PRESSING THE CRUISE CONTROL "OFF" BUTTON AND IT FINALLY DISENGAGED. IMMEDIATELY AFTER TAKING THE TURN I SET THE CRUISE AT A LOWER SPEED AND ATTEMPTED TO REPLICATE THE ISSUE. THE ISSUE WAS STILL THERE - REPEATED APPLICATION OF THE FRONT BRAKE LEVER DID NOT DISENGAGE THE CRUISE CONTROL. IT DID DISENGAGE EITHER WHEN THE "OFF" BUTTON WAS PRESSED OR WHEN THE REAR BRAKE LEVEL WAS PRESSED. WHEN THE MOTORCYCLE WAS NEW, PULLING THE FRONT BRAKE LEVER WOULD DISENGAGE THE CRUISE CONTROL. HAD THIS HAPPENED IN AN EMERGENCY SITUATION THERE WOULD HAVE ALMOST CERTAINLY BEEN AN ACCIDENT.

THE LATCHING MECHANISM THAT HOLDS THE RIGHT SIDE SADDLEBAG CLOSED IS WEARING THROUGH. THIS SEEMS TO BE CAUSED BY A DESIGN FLAW THAT HAS THE LATCH AND ITS CATCH ALIGNED SO THAT THE VIBRATION FROM RIDING CAUSES THE MATERIAL TO WEAR. I AM CONCERNED THAT THIS COULD EVENTUALLY CAUSE THE LATCH TO BREAK AND THE SADDLEBAG LID TO COME OPEN WHILE RIDING, WHICH COULD CAUSE A SERIOUS DANGER TO MYSELF AND OTHERS AROUND.

THE RIGHT SADDLE BAG LATCH IS SHOWING SIGNS OF WEAR. IF IT CONTINUES TO WEAR AND BREAKS THE SADDLE BAG LID MAY POP OPEN WHILE RIDING AND IF THERE IS ANY TYPE OF MATERIAL OR CLOTHING IT MAY COME OUT ON TO ROADWAY OR POSSIBLY THE HIGHWAY POSSIBLY CAUSING AN ACCIDENT. I HAVE READ THAT THERE ARE MANY OTHERS HAVING THE SAME ISSUE. I HAVE ALSO SEEN BRAND NEW MOTORCYCLES ON THE SHOW ROOM FLOOR SHOWING SIGNS OF WEAR AND THEY ARE BRAND NEW NO MILEAGE. I ALSO HAVE ISSUE WITH SIGNAL LIGHTS. WHEN ENGAGING THE SIGNAL LIGHT PRIOR TO TAKING A TURN IT SHUTS OFF PREMATURELY. ALSO WHEN PUTTING TURN SIGNAL ON IT SHUTS OFF SOMETIMES IN 15-20 SECONDS AND YOU ARE SLOWING DOWN AND DRIVING STRAIGHT PRIOR TO TAKING A TURN. I HAVE CONTACTED THE DEALERSHIP AND VICTORY ON BOTH ISSUES AND BOTH HAVE NOT BEEN RESOLVED AS OF THIS WRITING. *TR

THE RIGHT SIDE SADDLE BAG LATCH IS WEARING EXCESSIVELY AND IN DANGER OF COMPLETE FAILURE. THAT WOULD CAUSE THE SADDLEBAG LID TO OPEN WHILE GOING DOWN THE ROAD. VICTORY SEEMS TO KNOW THAT THERE IS A PROBLEM BUT WILL NOT FIX IT AFTER THE 1 YEAR WARRANTY IS UP. *TR

BIKE IS PRONE TO STALLING EITHER FROM DOWNSHIFTING OR OPENING THE THROTTLE SUCH AS STARTING OUT FROM A STOP OR LOW RPM SHIFT. I'VE PUT ABOUT 200 MILES ON THIS BIKE AND NOTICED THE BIKE HAS STALLED MORE THAN 10 TIMES WHILE PULLING FROM A STOP, MERGING INTO TRAFFIC, OR MAKING A TURN. THE SUDDEN LOSS OF POWER CHANGES THE CENTER OF GRAVITY AND BALANCE ON THE BIKE AND IN ONE CASE I HAD TO QUICKLY BRACE THE BIKE WHILE BRINGING THE BIKE UNDER CONTROL. THE END EFFECT WAS THE BIKE CRUSHED MY FOOT UNDER THE EXHAUST AS THE BIKE WAS IN A LEAN WHILE TURNING. RESEARCH INTO THIS "STALLING" SHOWS THIS IS A VERY COMMON PROBLEM WITH THIS BIKE. SOMETHING IS WRONG WITH THE ECM / FUEL / AIR MANAGEMENT SYSTEM. I'M CONCERNED THIS PROBLEM HAPPENS WITHOUT WARNING AND COULD RESULT IN A SERIOUS ACCIDENT. SUCH AS BEING REAR ENDED OR STALLING WHILE CROSSING LANES OF TRAFFIC. *TR

I WAS MERGING ONTO A HIGHWAY LEANED INTO THE CURVE RUNNING ABOUT 45 MPH WHEN THE ENGINE POPPED AND DIED. WHEN THIS HAPPENED IT LOCKED UP THE REAR TIRE CAUSING THE BACK END OF THE MOTORCYCLE TO SKID AROUND AND WHEN IT CAUGHT TRACTION IT FLIPPED THE BIKE IN THE OPPOSITE SIDE OF THE WAY I WAS LEANING LAUNCHING ME INTO THE ROAD. I WAS APPLYING THROTTLE GENTLY WHEN THIS OCCURRED AND THE RPM'S WERE AROUND 3000 AT THE TIME. AND I WAS NOT SHIFTING GEARS AT THE TIME. AFTER A COUPLE OF ATTEMPTS I WAS ABLE TO GET THE ENGINE STARTED AGAIN BUT THE BIKE MADE A SCRUBBING SOUND IF I MOVED IT. IT WAS THEN TRAILERED TO THE DEALER AFTER THAT. I HAD THE MOTORCYCLE IN TO THE DEALER ON SEVERAL OCCASIONS BEFORE FOR THE ENGINE POPPING AND STALLING. THIS PROBLEM HAS BEEN REPORTED TO VICTORY AND SO HAVE NUMEROUS OTHER SIMILAR PROBLEMS AND THEY RESPONDED WITH IT BEING RIDER ERROR. POLARIS, THE PARENT COMPANY OF VICTORY IS TURNING A BLIND EYE TO A PROBLEM THAT LEFT UNCHECKED WILL END UP KILLING SOMEONE. A SIMPLE GOOGLE SEARCH WILL FIND YOU A LOT OF OTHER PEOPLE HAVING THE SAME PROBLEM. HERE IS A LINK TO ONE SUCH POST ON THE PROBLEM. HTTP://WWW.THEVOG.NET/THREADS/ENGINE-POPPED-AND-DIED.28491/ SOMETHING NEEDS TO BE DONE SOON BEFORE MORE PEOPLE ARE HURT OR KILLED. *TR

THE RIGHT SADDLE BAG LATCH ON ALL VICTORY CROSS COUNTRY MODELS IS INSTALLED INCORRECTLY CAUSING WEAR THAT IF LEFT UNREPAIRED WILL EVENTUALLY WEAR THROUGH CAUSING THE RIGHT SADDLE TO BE UNSECURED AND A SAFETY HAZARD. VICTORY NEEDS TO RECALL THE RIGHT SADDLE BAG LATCH AND REPAIR IT ON ALL MODELS. *TR

AS I WAS CONDUCTING A PRE-RIDE CHECK, I TURNED THE ENGINE ON, AND WITHIN A FEW SECONDS, IT SHUT OFF BY ITSELF. THIS REPEATED A COUPLE OF MORE TIMES, AND THEN THE ENGINE WOULD NOT START. AFTER ANOTHER COUPLE OF ATTEMPTS, EVEN THE LIGHTS AND ALL THE ELECTRICAL COMPONENTS SHUT OFF WITH NO RESPONSE. THE BIKE HAD COMPLETELY DIED. I HAD IT TOWED TO THE SOUTHERN CALIFORNIA MOTORCYCLE VICTORY DEALER, AND THEY DIAGNOSED THAT THE STARTER SOLENOID HAD MELTED, AND THE CIRCUIT BREAKER HAD BLOWN OUT. IT'S FORTUNATE THAT THIS HAPPENED AT HOME DURING A PRE-RIDE CHECK, AS IT WOULD HAVE CAUSE A SERIOUS CONCERN IF I WERE RIDING THE BIKE. THIS BIKE ONLY HAS ABOUT 3500 MILES ON IT, SO THIS SHOULD NOT HAPPEN. *TR

THE SADDLE BAG LATCH ON THE RIGHT-SIDE SADDLE BAGS WEAR OUT FROM ROAD VIBRATION. IF IT WEARS TOO MUCH, THE LATCH CAN BREAK AND THE LID CAN OPEN AT SPEED. *TR

THE TURN-SIGNAL CANCELLATION IS ERRATIC OR INCONSISTENT. SOMETIMES IT ONLY FLASHES 5 TIMES, SOMETIMES WILL FLASH 20 TIMES WHILE MOVING. THERE IS NO WAY TO DISABLE IT. *TR

HTTP://WWW.THEVOG.NET/THREADS/ENGINE-POPPED-AND-DIED.28491/ ATTACHED IS LINK TO A FORUM OF VICTORY MOTORCYCLE OWNERS WHO DESCRIBE SEVERAL INCIDENTS WHERE THEIR ENGINES HAVE QUIT AND LOCK UP CAUSING THE RIDER TO BE EJECTED. I HAVE A 2013 VICTORY CROSS COUNTRY TOUR AND AM VERY CONCERNED ABOUT MY SAFETY. POLARIS WHO MAKE THE VICTORY MOTORCYCLES SEEMS TO BE IGNORING THE NUMEROUS COMPLAINTS FROM OWNERS. *TR

I WAS MERGING ONTO A HIGHWAY LEANED INTO THE CURVE RUNNING ABOUT 45 MPH WHEN THE ENGINE POPPED AND DIED. WHEN THIS HAPPENED IT LOCKED UP THE REAR TIRE CAUSING THE BACK END OF THE MOTORCYCLE TO SKID AROUND AND WHEN IT CAUGHT TRACTION IT FLIPPED THE BIKE IN THE OPPOSITE SIDE OF THE WAY I WAS LEANING LAUNCHING ME INTO THE ROAD. I WAS APPLYING THROTTLE GENTLY WHEN THIS OCCURRED AND THE RPM'S WERE AROUND 3000 AT THE TIME. AND I WAS NOT SHIFTING GEARS AT THE TIME. AFTER A COUPLE OF ATTEMPTS I WAS ABLE TO GET THE ENGINE STARTED AGAIN BUT THE BIKE MADE A SCRUBBING SOUND IF I MOVED IT. IT WAS THEN TRAILERED TO THE DEALER AFTER THAT. I HAD THE MOTORCYCLE IN TO THE DEALER ON SEVERAL OCCASIONS BEFORE FOR THE ENGINE POPPING AND STALLING. *TR

THE RIGHT SIDE SADDLE BAG LATCH IS SHOWING SIGNS OF WEAR, POSSIBLY DUE TO A FACTORY-MISALIGNED LATCH AND STRIKER HOOP. THE WORN AREA, WHEN SEVERE ENOUGH, WILL BREAK OFF AND CAUSE THE LID TO BE UNSECURED. THIS COULD CAUSE A LOSS OF CARGO AT HIGHWAY SPEEDS. *TR

TL* THE CONTACT OWNS A 2013 VICTORY CROSS COUNTRY MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING 5 MPH AND DOWNSHIFTING, THE MOTORCYCLE STALLED CAUSING THE CONTACT AND PASSENGER TO FALL OFF THE MOTORCYCLE. IN ADDITION, BOTH THE CONTACT AND THE PASSENGER SUSTAINED MINOR INJURIES. THE FAILURE RECURRED ON TWELVE OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1,200. UPDATED 08/27/14*LJ UPDATED 09/16/2014 *JS

TL* THE CONTACT OWNS A 2013 VICTORY CROSS COUNTRY MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING 80 MPH, THE REAR TIRE SEIZED UNEXPECTEDLY. THE CONTACT WAS ABLE TO KEEP THE BIKE UP. THE CONTACT WAS NOT INJURED. THE BIKE WAS TAKEN TO A DEALER. THE TECHNICIAN CONFIRMED THAT THE REAR TIRE HAD SEIZED BUT DID NOT PROVIDE A REASON AS TO WHY THE FAILURE OCCURRED. THE BIKE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 185. UPDATED 11/29/13*LJ