2001 Toyota Sienna complaints

BOTH DRIVER AND PASSENGER SLIDING DOORS WILL NOT OPEN FROM THE INSIDE. THE CHILD LOCKS ARE NOT ON, AND OCCASIONALLY THE DOORS WILL NOT LATCH CLOSED. AFTER FIDGETING WITH THE LOCK AND LATCH, IT WILL EVENTUALLY LATCH. *TR

THE LEFT THIRD-ROW SEAT BELT RETRACTOR ON MY 2001 TOYOTA SIENNA LE FAILED 2 WEEKS AGO, RENDERING THE SEAT BELT INOPERABLE. IT COST OVER $400 TO REPLACE. TWO DAYS AGO, THE RIGHT THIRD-ROW SEAT BELT RETRACTOR FAILED. WE HAVE APPROXIMATELY 87,000 ON THE VEHICLE, WITH NORMAL USE. *TR

I OWN A 2001 TOYOTA SIENNA VAN CE. IN THE PAST 1.5 YEARS ALL DOOR HANDLES HAVE SEPARATED FROM THE CAR. THIS INCLUDES THE DRIVER, PASSENGER, REAR DRIVER, REAR PASSENGER AND TAILGATE DOORS HANDLES. THESE HANDLES ARE MADE FROM PLASTIC AND CRACK AND BREAK OFF AT THE HINGE POINT. I DON'T BELIEVE THE NUMBER OF BREAKAGES OF THESE HANDLES CAN BE CAUSED BY NORMAL WEAR AND TEAR AND CERTAINLY WITH TWO SMALL CHILDREN AND TWO ADULTS MAKING USE OF THE VEHICLE WOULD CONSTITUTE NORMAL WEAR AND TEAR. THIS PROBLEM IS A DEFECT OF DESIGN OR WORKMANSHIP OF THE HANDLE AND THE COST TO REPAIR IS APPROXIMATELY $350 PER HANDLE. IT IS A SERIOUS THREAT SHOULD THEY BREAK AT THE IMPROPER TIME OR FOR EMERGENCY ACCESS TO THE AUTOMOBILE. I HAVE ADDRESSED MY CONCERNS WITH TOYOTA AND THEY DON'T BELIEVE THERE IS A NEED TO CORRECT. PLEASE INVESTIGATE AND RESPOND. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL*THE CONTACT OWNS A 2001 TOYOTA SIENNA. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH, THE HORN WAS ENGAGED AND FAILED TO FUNCTION. THE FAILURE OCCURRED FIFTEEN MINUTES AFTER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS INSPECTED BY TWO INDEPENDENT MECHANICS. THE CONTACT WAS INFORMED THAT THE ELECTRICAL COMPONENTS UNDER THE AIR BAG REQUIRED REPLACEMENT. THE FAILURE CONTINUED TO OCCUR. THE VEHICLE HAD NOT BEEN REPAIRED WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 87,000. THE CURRENT MILEAGE WAS 93,000.

WHEN CHILD LOCK IS ON THE POWER DOOR ON PASSEGER SIDE CAN BE OPENED BY A 4 YEAR OLD. *TR

I WAS DRIVING A 2001 TOYOTA SIENNA. I TURNED LEFT INTO A PARKING SPACE AND PULLED FORWARD. WHILE STILL IN DRIVE, RATHER THAN STOPPING, THE CAR CONTINUED TO ACCELERATE SLOWLY, RAN OVER A WOODEN PARKING BARRIER, AND CRASHED INTO A CONCRETE WALL A FEW FEET AWAY. *TR

PASSENGER SLIDING DOOR WOULD NOT CLOSE/OPEN ELECTRONICALLY OR MANUALLY. THE BUTTON TO TURN OFF THE ELECTRONIC OPEN/CLOSE DID NOT WORK. TOYOTA SERVICE COULD NOT FIX. HAD THEM CUT CABLE SO CAN CLOSE AND OPEN DOOR MANUALLY. UNTIL THE CABLE WAS CUT, DOOR COULD NOT BE USED TO EXIT VAN. *TR

OUR 2001 TOYOTA SIENNA HAS BEEN EXPERIENCING GAS PEDAL PROBLEMS FOR THE LAST TWO YEARS. FROM A STOPPED POSITION, THE GAS PEDAL STICKS UNTIL EXCESSIVE PRESSURE IS APPLIED. WHEN THE ACCELERATOR FINALLY ENGAGES, THE CAR LURCHES FORWARD. THIS PROBLEM MAKES THE VEHICLE FRIGHTENING TO DRIVE. THE FIRST TIME WE BROUGHT THE CAR TO THE TOYOTA SERVICE DEPARTMENT (TOYOTA OF SANTA MARIA, CALIFORNIA) ABOUT THIS ISSUE WAS FEBRUARY 2008 (ODOMETER 101,112). THE SERVICE DEPARTMENT TOLD US THEY COULD NOT DUPLICATE THE PROBLEM BUT SERVICED THE THROTTLE BODY AND LUBRICATED THE EXPOSED THROTTLE CABLES. THE GAS PEDAL RESPONDED BETTER. IN NOVEMBER 2009 WE STARTED EXPERIENCING THE PROBLEM AGAIN AND ON DECEMBER 10, 2009 WE TOOK THE VEHICLE INTO THE SERVICE DEPARTMENT (ODOMETER 111,596). WE REQUESTED A SIMILAR SERVICE TO SEE IF IT WOULD FIX THE PROBLEM BUT THE SERVICE DEPARTMENT CLAIMED TO NOT KNOW WHAT THEY HAD DONE ON THE PREVIOUS VISIT TO 'FIX' THE STICKY GAS PEDAL. THEY COULD NOT DUPLICATE THE PROBLEM AND WE TOOK THE VEHICLE HOME. WITHIN THE SAME DAY THE ACCELERATOR WAS STICKING. WE FELT UNSAFE DRIVING OUR TWO SMALL CHILDREN IN THE VEHICLE AND PARKED IT IN THE GARAGE FOR A MONTH UNTIL WE COULD TAKE IT BACK TO THE SERVICE DEPARTMENT. ON JANUARY 11, 2010 WE BROUGHT IT BACK AND INSISTED THEY FIX THE PROBLEM. THEY COULD NOT DUPLICATE THE PROBLEM. WE WERE ASSURED THAT THERE WAS NOTHING UNUSUAL WITH OUR VEHICLE, PERHAPS JUST SOME CARBON BUILD UP ON THE THROTTLE BODY PLATE. WE DIDN'T FEEL SAFE DRIVING THE

TL*THE CONTACT OWNS A 2001 TOYOTA SIENNA. WHILE THE CONTACT WAS DRIVING 65 MPH HE NOTICED THAT THE CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD, MOMENTS LATER THE CONTACT HEARD A KNOCKING SOUND. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED DUE TO EXCESSIVE ENGINE SLUDGE. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 105,000.

THE ENGINE FAILED AND HAD TO BE REPLACED AT A COST OF $5,000 DUE TO OIL SLUDGE BUILDUP. TRAVELING ON I-4 FROM TAMPA TO ORLANDO THE CHECK ENGINE LIGHT APPEARED THEN WE HEARD A TAPPING FROM THE ENGINE,. I PULLED OFF THE ROAD AND AAA TOWED THE VEHICLE AND A RENTAL CAR COMPANY PICKED US UP. I HAD TWO ELDERLY PASSENGERS (IN THEIR 80'S) WITH WALKERS WHO HAD TO TRAVERSE THE GRASS ALONG THE INTERSTATE TO GET TO THE RENTAL CAR AND WERE NEARLY BLOWN OVER BY PASSING TRUCKS. TOYOTA REFUSED TO HONOR A CLAIM FOR REPAIRS ALTHOUGH THEY HAD AGREED IN A RECENT LOUISIANA LAWSUIT TO COVER SAID REPAIRS FOR 8 YEARS FROM DATE OF PURCHASE. MY FAILURE WAS 8 YEARS AND 10 MONTHS FROM PURCHASE. THE SLUDGE TOOK MUCH LONGER THAN 8 MONTHS TO BUILD UP BUT TOYOTA REFUSED TO HONOR THEIR STATED COMMITMENT TO ASSIST ALL AFFECTED BY OIL SLUDGE DAMAGE (OVER 3,000 COMPLAINTS). THEIR PRODUCT WAS DEFECTIVE AND DANGEROUS AND THEIR DENIAL TO ASSIST WAS DISHONORABLE. *TR

TOYOTA SIENNA BRAKES PEDAL GOES DOWN TO THE FLOOR GIVING NOT ENOUGH BRAKING TO STOP VEHICLE. THE BRAKE WORK HAS BEEN DONE ON THIS MINI-VAN THREE TIMES WITHIN LAST 2~3 YEARS AT TOYOTA DEALERSHIPS SERVICE CENTER BUT THE CONDITION HAS NOT BEEN IMPROVED. THE DEALERSHIP HAS WORKED ON BOTH FRONT(DISC BRAKES) AND REAR(DRUM BRAKES) INCLUDING PART REPLACED AND REPAIRED. BRAKE CYLINDERS AT REAR TIRES REPLACED. THE FRONT DISC HAD BEEN CHANGED WITH BRAKE SHOES. REAR BRAKE ROTOR WAS MACHINED AND BRAKE SHOES HAVE BEEN REPLACED. NONE OF THE OLD PARTS ARE AVAILABLE WITH VEHICLE OWNER. *TR

I HAVE A 2001 TOYOTA SIENNA AND THE BOTH THE REAR SLIDING DOORS HAVE HAD INTERMITTENT ISSUES WITH EITHER OPENING OR CLOSING SINCE AROUND 2003 (ALTHOUGH MORE OFTEN SEEN WITH DRIVER SIDE). WHEN THE ISSUES IS PRESENT THE DOORS WORK FINE WHEN THE AUTOMATIC OPEN/CLOSE IS TURNED OFF. THE ISSUE MAY OCCUR MORE OFTEN WHEN RAINING THEN WHEN DRY. ONE OBSERVANCE OF ISSUE IS THAT WHEN AUTO OPEN IS ENGAGED THE DOOR MAKES A CLICKING SOUND BUT DOESN'T OPEN. THE OTHER OBSERVANCE OF ISSUE IS WHEN THE DOOR IS OPEN AND THE AUTO CLOSE IS ENGAGED THE DOOR STARTS TO CLOSE (MAYBE AN INCH) AND THEN RE-OPENS...THE ONLY WAY TO GET THE DOOR CLOSED IS TO TURN OFF THE AUTO OPEN/CLOSE. WHILE UNDER WARRANTY I TOOK THE VAN TO BE SERVICED TWICE, BUT WAS NOT ABLE TO RE-PRODUCE THE ISSUE AT THE DEALERSHIP...AS SUCH THEY WOULD NOT EVEN LOOK AT IT. *TR

5 MONTHS AGO MY SON WAS DRIVING MY CAR AND IT SUDDENLY ACCELERATED AND HE COULD NOT GET THE CAR TO STOP EVEN WHEN HE PUT ON THE BRAKE. WHEN I GOT THE CAR, I STARTED THE ENGINE AND IT LUNGED FORWARD, BUT I PUT THE CAR IN NEUTRAL AND THE ENGINE JUST RACED. I ULTIMATELY TOOK THE CAR TO MY MECHANIC AND HE TOOK IT SOMEWHERE ELSE WERE THEY REPAIRED THE PROBLEM AFTER TWO ATTEMPTS. MY CAR DID NOT HAVE ANY DRIVER SIDE FLOOR MATS IN IT. *TR

THE DOOR LATCH ON THE PASSENGER SIDE SLIDING DOOR HAS FAILED ON TWO OCCASIONS. THE FIRST TIME WAS IN SEPTEMBER 2007. WE HAD IT REPLACED AT THE DEALERSHIP AT OUR OWN EXPENSE. THEN IT FAILED AGAIN LAST WEEK. THE DEALERSHIP TELLS US IT NEEDS TO BE REPLACED AGAIN. THE LATCH ON THE REAR DOOR HAS ALSO FAILED AND BEEN REPAIRED AT OUR EXPENSE. *TR

WE OWN A 2001 TOYOTA SIENNA VAN. ALL BUT 1 OF 5 DOOR HANDLES ON THIS VAN HAVE BROKEN AND THE DOOR HANDLES ON EACH OF THE 4 DOORS (EXCEPT PASSENGER FRONT) HAVE CRACKED AND BROKEN CLEAN OFF THE DOOR. CURRENTLY, THE DRIVER SIDE IS TAPED ON. I FEEL THAT THIS COULD HAVE HAPPENED TO 1 BY USER WEAR. HOWEVER, I'M NOT INCLINED TO BELIEVE THAT ALL COULD BREAK SO EASILY FROM USER WEAR AND TEAR. THIS CREATES A SIGNIFICANT SAFETY HAZARD IN ACCESSING THE VEHICLE IN EMERGENCY SITUATIONS AS CLEARLY THE ONLY ACCESS WILL BE THROUGH WINDOWS AT SOME POINT. *TR

THANK YOU IN ADVANCE FOR YOUR CONSIDERATION OF THIS COMPLAINT. MY WIFE AND CHILDREN WERE NEARLY INVOLVED IN A SERIOUS ACCIDENT YESTERDAY DUE TO SUDDEN UNCONTROLLED ACCELERATION IN OUR MINIVAN. BEFORE YOU EVEN CONSIDER THAT IT MAY BE DRIVERS ERROR, AS EVIDENCED BY THE MYRIAD OF DISCUSSION ON THIS MATTER ON THE INTERNET, THE PROBLEM WAS CONFIRMED BY THE TOW TRUCK DRIVER AND ME; THE VAN CURRENTLY IS STUCK IN FULL ACCELERATION UPON STARTING---I TESTED THIS NUMEROUS TIMES YESTERDAY AND TODAY. THERE IS NO OBSTRUCTION TO THE THROTTLE CABLE, PEDAL, NOR A FLOOR MAT ISSUE. I HAVE CLEARLY CHECKED THESE ITEMS. THERE ARE NUMEROUS SIMILAR COMPLAINTS ONLINE BUT APPARENTLY THEY HAVE NOT BEEN ACKNOWLEDGED/ADDRESSED BY TOYOTA OR NHTSA. THANKS. *TR

TL*THE CONTACT OWNS A 2001 TOYOTA SIENNA. WHILE CHANGING THE REAR LIGHT BULB, THE CONTACT NOTICED THAT THERE WAS NO SAFETY LATCH TO RELEASE AN OCCUPANT IF THEY BECAME TRAPPED IN THE REAR OF THE VEHICLE. THE CONTACT FEELS THAT THIS IS A SAFETY ISSUE IN THE EVENT OF AN EMERGENCY. SHE IS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER FOR FURTHER INSPECTION. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT DESIGNED WITH THAT FEATURE; THEREFORE, NO COMPENSATION WOULD BE PROVIDED. THE FAILURE MILEAGE WAS 110,000 AND CURRENT MILEAGE WAS 111,000.

THE PASSENGER-SIDE SLIDING DOOR (MANUAL) ON OUR 2001 SIENNA BEGAN HAVING PROBLEMS APPROX. 6 MO. AGO, WITH THE INSIDE BUTTON TO OPEN THE DOOR INTERMITTENTLY STICKING - HAPPENED BOTH IN OPEN & CLOSED POSITIONS. OBVIOUSLY A SAFETY CONCERN, BOTH FOR BEING ABLE TO CLOSE THE DOOR IN ORDER TO DRIVE, AND FOR OPENING THE DOOR PARTICULARLY IN CASE OF AN EMERGENCY. AT THE BEGINNING, A GOOD "WHACK" ON THE DOOR WOULD USUALLY RELEASE THE BUTTON, AND THE DOOR WOULD FUNCTION. NOW, THE DOOR IS NOT WORKING AT ALL - THANKFULLY, IT IS IN THE CLOSED POSITION, BUT IT IS TOTALLY NON-FUNCTIONAL AS WE CANNOT OPEN IT AT ALL. HAD ONE OR TWO EPISODES OF THE DRIVER-SIDE DOOR GETTING STUCK OPEN - THE LATCH HAD A PROBLEM THAT PREVENTED CLOSURE (SEEMED THAT THE LATCH GOT INTO THE "LOCKED" POSITION SOMEHOW WHEN DOOR WAS OPEN, AND THEN WOULDN'T RELEASE IN ORDER TO CLOSE IT). NOW, THE REAR HATCH LOCK/LATCH IS NOT WORKING EITHER. WE CANNOT OPEN THE HATCH, WHICH IS EXTREMELY INCONVENIENT AND ALSO ANOTHER SAFETY CONCERN. IF ANY EMERGENCY WOULD HAPPEN WHICH WOULD REQUIRE US TO EXIT THE VEHICLE QUICKLY (OR IF WE NEEDED TO BE RESCUED FROM THE VEHICLE), THE ONLY DOORS THAT ACTUALLY WORK ALL THE TIME ARE THE TWO FRONT DOORS. THIS IS A HUGE CONCERN TO ME, PARTICULARLY IF WE HAVE PASSENGERS RIDING IN THE 3RD ROW SEATS. WE HAVE NOT YET TAKEN IT TO A DEALER FOR REPAIR - HAVE NOT HEARD OF GOOD OUTCOMES FOR THIS PARTICULAR PROBLEM, AND DON'T WANT TO SPEND A TON OF MONEY. *TR

BOTH POWER SLIDING DOORS FAIL TO WORK. NEITHER DOOR OPENING SWITCH WILL OPEN OR CLOSE THEM. ALSO, RIGHT SIDE WILL NOT EVEN OPEN MANUALLY FROM INSIDE THE VEHICLE! SAFETY ISSUE. REPAIRS FOR THE POWERED DOOR ISSUE WERE ESTIMATED AT $350 FOR THE DOOR COMPUTER + 350 TO INSTALL - PER DOOR! OUTRAGEOUS. AMERICAN CAR COMPANIES HAVE BEEN SLAMMED FOR THIS KIND OF THING. HOW ABOUT TOYOTA? *TR

MY 2001 TOYOTA SIENNA XLE POWER SLIDING DOOR ON THE PASSENGER SIDE (CAME ONLY WITH THIS ONE POWER DOOR) DID NOT WORK PROPERLY. IT DID NOT OPEN BY PRESSING THE BUTTON, IT WORKS TO CLOSE BUT NOT TIGHT. WHEN I CHOOSE TO USE IT MANUALLY, IT IS SO HEAVY THAT THE CHILDREN HAVE NOT ENOUGH STRENGTH TO OPEN IT. THEY HAVE TO EXIT THE CAR FROM THE DRIVER'S SIDE OTHER THAN ON THE CURB SIDE. IT PLACES THE PASSENGERS IN DANGEROUS SITUATION, AS WELL AS TO THE DRIVER IF HE HAS TO COME OUT OF THE CAR TO HELP OPEN THE DOOR AT THE CURB SIDE. MY COMPLAINT IS THAT DOOR SHOULD BE OPERATED AS LIGHT AS THE OTHER DOOR WHEN IT IS IN THE MANUAL MODE AND THE COST TO FIX IS TOO MUCH (ABOUT $2,000) TO AFFORD. *TR

THE POWER SLIDING DOOR ON OUR 2001 TOYOTA SIENNA MINIVAN QUIT WORKING. AFTER A MORNING OF RESEARCH ON THE INTERNET I FEEL COMPELLED TO COMPLAIN AS THIS IS EVIDENTLY A RECURRING PROBLEM. IT CAN BE OPENED MANUALLY WITH MODERATE EFFORT. *TR

TL*THE CONTACT OWNS A 2001 TOYOTA SIENNA. THE CONTACT STATED THAT THE PASSENGER SIDE SLIDING DOOR STOPPED WORKING. THE DOOR DOES NOT OPEN ALL THE WAY WITH THE REMOTE CONTROL OR MANUALLY. THE CONTACT HAS TO FIND A WAY TO OPEN THE DOOR WHEN THIS OCCURS, WHICH IS USUALLY IN RAINY OR SNOWY CONDITIONS. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT IT WOULD COST $2,200 TO REPLACE THE MOTOR AND THE COMPUTER. THE FAILURE MILEAGE WAS 110,000.

2001 SIENNA BOUGHT NEW FROM DEALER. DRIVER SIDE PASSENGER POWER SLIDE DOOR HAD PROBLEMS WITH 'SWITCH' AND ECU 8/2002, 11/2003, 1/2004, 7/2004, 7/2006 4/2007. THOSE ARE JUST THE TIMES I BROUGHT IT IN. OTHER TIMES I JUST LET IT GO FOR A WHILE. TOYOTA FIXED PART UNTIL WARRANTY WAS UP. NOW THEY WANT ME TO PAY TO REPLACE THE PARTS -- PARTS THAT CONTINUE TO FAIL. SLIDING DOOR EITHER DOES NOT OPEN VIA POWER BUTTON, OR WILL NOT CLOSE ALL THE WAY. SAFETY ISSUE WHEN CAN NOT GET DOOR TO CLOSE ALL THE WAY. NOW THE OTHER POWER SLIDER DOOR IS ALSO NOT WORKING. I WROTE TO TOYOTA 5/2007, THEY NEVER EVEN ACKNOWLEDGED MY LETTER. *TR

ENGINE OIL LIGHT CAME ON, THEN CHECK ENGINE LIGHT CAME ON, ENGINE SHUT OFF, NO OIL PRESENT IN ENGINE. *TR

TL*THE CONTACT OWNS A 2001 TOYOTA SIENNA. THE VEHICLE HAS DILL-ACP VALVE STEMS, MODEL TR-413. WHILE DRIVING 65 MPH, THE PASSENGER SIDE TIRE BLEW OUT. THE VEHICLE STRUCK A GUARDRAIL AND WAS DESTROYED. A POLICE REPORT WAS FILED AND THE CONTACT HAS PICTURES AVAILABLE. SHE RECEIVED A SAFETY RECALL NOTICE FOR THE VALVE STEMS ON SEPTEMBER 12, 2008. UPDATED 10/20/08 *BF

THE ORIGINAL EQUIPMENT ALUMINUM ALLOY WHEEL RIMS ON MY TOYOTA SIENNA MINIVAN SHOW FATIGUE BREAKS. WHEN I ASKED A TIRE SHOP TO ROTATE THE TIRES, THEY NOTICED THAT ONE OF THE RIMS WAS SO BAD THAT THEY REFUSED TO PUT THE WHEEL BACK ON THE CAR. THE CRACK IN THIS ONE WAS VERY VISIBLE AND WAS SLIGHTLY VISIBLE IN ANOTHER. I HAVE REPLACED ALL FOUR RIMS, BUT I KEPT THE WORST ONE AND HAVE TAKEN PHOTOS THAT CLEARLY SHOW THAT ONE OF THE SPOKES IS BROKEN OVER MOST OF THE WIDTH OF THE SPOKE. THE CRACK IS VISIBLE FROM THE FRONT AND BACK OF THE RIM. I WOULD LIKE TO FORWARD THESE DIGITAL PHOTOS, IF YOU WILL PROVIDE AN EMAIL ADDRESS. *TR

THE SLIDING DOORS OF OUR 2001 TOYOTA SIENNA XLE ARE NOT RELIABLE OPERATED. SOMETIMES WORK SOMETIME NOT, SOMETIME STUCK, NO SAFETY SENSOR. ONLY A MAN CAN PUSH THE CLOSING DOOR BACK OPEN. IF A CHILD IN THE PATH OF A CLOSING DOOR, MANUALLY PUSHING BACK THE DOOR IS IMPOSSIBLE FOR ME. THE PUSH BUTTON AND THE KEY BUTTON SOMETIMES WORK SOMETIMES NOT SINCE THE FIRST YEAR. WE BROUGHT IN ELMORE TOYOTA MANY TIMES. THEY SAID NOTHING WRONG WITH IT. WE COMPLAINED TO COOPERATE TOYOTA, THEY REFERRED US BACK TO ELMORE TOYOTA, WITH THE SAME ANSWER NOTHING WRONG. WE FEAR FOR THE SAFETY OF OUR CHILDREN. THIS IS OUR LAST RESORT FOR HELP. WHEN WE HAVE MONEY TO REPLACE THIS CAR, THERE WILL BE NO MORE TOYOTA ON OUR LIST. *TR

I PURCHASED THE SEAT AND RECEIVED IT MID-APRIL. I INSTALLED IT USING THE LATCH INTO OUR VAN FOR ABOUT 2 WKS AND THEN IT GOT MOVED TO OUR CAR AND WAS INSTALLED BY THE SEATBELT. WE THEN MOVED IT BACK TO THE VAN INSTALLING IT WITH LATCH FOR A LONG TRIP AND THE LATCH WAS STUCK OPEN SO WE HAD TO INSTALL IT USING THE SEATBELT. (RELATED VEHICLE INFORMATION: MODEL YEAR=2001, MAKE=TOYOTA, MODEL=SIENNA). *TR

I OWN A 2001 TOYOTA SIENNA MINIVAN WITH 76,400 MILES. I HAVE OWNED THIS VEHICLE SINCE IT WAS NEW PURCHASED IN LATE 2000. # . ANYHOW, MY WIFE WAS DRIVING THE CAR NEAR OUR HOME ON AUGUST 2, HIT THE BRAKES MODERATELY HARD TO AVOID STRIKING A DEER, AND THE RIGHT FRONT BRAKE DISINTEGRATED. IT WAS REPLACED TODAY BY CHIPPEWA AUTO, LOCATED NEAR HERE. THEY TOLD ME, AND GAVE ME THE PIECES, THAT THE RIGHT FRONT ROTOR BROKE LOOSE FROM ITS MOUNTING AND BROKE IN HALF, BECAUSE OF CORROSION. FURTHERMORE THE LEFT FRONT ROTOR WAS IN DANGER OF DOING THE SAME, AND WAS CRACKED LOOSE FOR 2/3 OF IT CIRCUMFERENCE. I COULD SUPPLY YOU THE PIECES FOR BOTH ROTORS, OR I COULD SEND SEVERAL DIGITAL PHOTOS BY E-MAIL. THIS IS UNACCEPTABLE AND SHOULD NEVER HAVE HAPPENED, ESPECIALLY FROM SOMEBODY LIKE TOYOTA AND THEIR VAUNTED QUALITY PROGRAM. IS THERE A RECALL ON THIS? IT COST ME $235.48. PAUL GARNER *TR

WATER LEAKS INTO FRONT PASSENGER AND DRIVER AREAS AND SETTLES AND SOAKS ON FRONT CARPET. IT ENTERS THROUGH THE ROOF AREA OR DOOR SEALS. HAPPENS WHEN EVER IT RAINS. *TR

TL*THE CONTACT OWNS A 2001 TOYOTA SIENNA. THE CONTACT STATED THAT SHE NOTICED WATER ON THE FLOOR OF THE FRONT PASSENGER SIDE WHEN IT WOULD RAIN. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 94,000.

REPEATED FAILURE OF POWER SLIDING DOOR ON 2001 SIENNA VAN. DEALER HAS ATTEMPTED TO FIX ON SEVERAL OCCASIONS SINCE TIME OF PURCHASE BUT FAILED. VEHICLE IS NOW OUT OF WARRANTY AND WILL COST OVER $500.00 TO REPAIR. THIS IS A SAFETY ISSUE SINCE THE DRIVERS SIDE DOOR DOES NOT ALWAYS FULLY CLOSE. ACCORDING TO NHTSA ODI TECHNICAL BULLETINS THIS HAS BEEN AN ONGOING PROBLEM SINCE 2001. TOYOTA SHOULD BE REQUIRED TO RECALL THE VEHICLES AND PAY FOR THE REPAIRS SINCE THIS IS A COMMON PROBLEM WITH THE 2001 MODEL AND A POTENTIAL SAFETY ISSUE FOR CHILDREN AND ADULTS. *JB

2005 TOYOTA SIENNA DRIVER SIDE DOOR MADE A LOUD POP WHEN OPENING. CUSTOMER STATED SHE TOOK IT TO THE DEALER AND THEY TOLD HER IT WOULD COST 300 TO 400 DOLLARS. CONSUMER WOULD LIKE TO KNOW HOW MANY SIENNA'S HAVE THIS PROBLEM. *KB THE DEALER INFORMED THE CONSUMER, THAT THE WELD ON THE DOOR HINGE WAS BROKEN. THE CONSUMER TOOK THE VEHICLE TO A COLLISION CENTER AND WAS TOLD THE PRICE WOULD BE $250.00 DOLLARS. THE DEALER DID AGREE TO PAY HALF OF THE COST. *JB

LEFT OUR HOME ABOUT 1045A. PUT VAN INTO "DRIVE" AFTER PULLING OUT OF DRIVEWAY IN REVERSE. UNABLE TO STOP WITH THE BRAKES AT STOP SIGN, APPROX 0.1 MILES FROM START. CAR BEGAN TO ACCELERATE ON IT'S OWN, THROUGH THE STOP SIGN, THROUGH A RIGHT HAND TURN, THROUGH A LEFT HAND TURN. ACCELERATOR PEDAL WAS "STUCK" AND COULD NOT GET IT LOOSE. BRAKES HAD NO EFFECT, INCLUDING ATTEMPTS AT EMERGENCY BRAKE USE. WENT UP A HILL HOPING TO SLOW THE VAN, BUT VAN INCREASED ACCELERATION. TREE WAS HIT WITH CENTER OF FRONT BUMPER. AIR BAGS DID NOT DEPLOY. ENGINE CONTINUED TO "REV" AFTER IMPACT. EXITED VEHICLE. RIGHT FRONT TIRE EXPLODED, SEVERELY DAMAGING RIGHT FRONT QUARTER PANEL AREA/COMPONENTS. *TR

SLIDING DOOR LATCHES GET STUCK SOMETIMES IN THE OPEN AND SOMETIMES IN THE CLOSED POSITION. WHEN DOORS ARE CLOSED WE ARE UNABLE TO PUSH THE BUTTON INSIDE OR USE THE OUTSIDE HANDLE TO RELEASE THE LATCH AND OPEN THE DOOR. IF THE DOOR IS OPEN WHEN THIS HAPPENS WE ARE THEN UNABLE TO CLOSE THE DOOR AS IT WILL NOT LATCH. WHEN THE DOOR REMAINS OPEN THIS IS AN OBVIOUS SAFETY ISSUE AND THE VAN IS UNDRIVEABLE AS DOING SO WOULD PUT THE PASSENGERS AT RISK. WHEN THE DOOR IS STUCK IN A CLOSE POSITION IT MAKES EXITING THE VEHICLE DIFFICULT WHICH WOULD BE A SAFETY ISSUE IF THERE WERE AN EMERGENCY AND A QUICK EXIT WERE NECESSARY. IT ALSO MAKES IT EXTREMELY DIFFICULT TO FASTEN OR RELEASE A CHILD FROM A SAFETY SEAT LOCATED IN THE BACK 2 ROWS OF SEATS. THE BACK HATCH LATCH HAS ALSO BROKEN. A LIGHT SQUEEZE OF THE HANDLE WHILE TRYING TO OPEN THE HATCH CAUSED SOMETHING TO SNAP (A SMALL PLASTIC PIECE FELL OUT) AND SINCE THIS IS THE ONE AND ONLY HANDLE/LATCH TO OPEN THE HATCH I AM NO LONGER ABLE TO USE THE HATCH NOR OPEN IT TO SEE WHAT PART NEEDS TO BE REPLACED. THE TWO SIDE DOORS WORK OCCASIONALLY BUT THE BACK HATCH IS NOW COMPLETELY UNUSABLE. SIMPLY PUT I HAVE HAD 3 OUT OF MY FIVE DOORS FAIL WITHIN A MONTH WHICH I FIND ABSURD. PLEASE NOTE THE VEHICLE IS IN GOOD SHAPE OTHERWISE AND HAS NEVER BEEN IN AN ACCIDENT. 2001 TOYOTA SIENNA LE/XLE

TL*THE CONTACT OWNS A 2001 TOYOTA SIENNA. WHEN THE CONTACT ATTEMPTS TO ADD FUEL TO THE VEHICLE, THE GAS PUMP WOULD CLICK AS IF THE TANK WAS FULL. HOWEVER, THE VEHICLE'S FUEL GAUGE INDICATED THAT THE TANK WAS EMPTY. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY CHANGED THE CHARCOAL FILTER. THE FAILURE CONTINUED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT REPAIR SHOP WHO WAS ABLE TO REPAIR THE FAILURE. THE SHOP REPLACED THE FUEL ROLLOVER VALVE. THE CONTACT STATED THAT SIX MONTHS LATER, THE FAILURE RECURRED. THE CURRENT AND FAILURE MILEAGES WERE 61,000.

TWO ISSUES ON MY 2001 TOYOTA SIENNA WITH 113K MILES: 1) REAR LATCH HANDLE BROKE APART WHILE ATTEMPTING TO OPEN THE REAR HATCH. THE PART THAT BROKE IS PLASTIC. THE BREAK OCCURRED WHILE TRYING TO OPEN THE LATCH UNDER NORMAL OPERATING CONDITIONS. CONSEQUENCE OF THIS PART FAILURE: UNABLE TO OPEN THE REAR HATCH. CORRECTION: TOYOTA DEALER HAD TO REPLACE THE ENTIRE MECHANISM (COSTING ME $200). 2) WHILE INVESTIGATING THE BROKEN LATCH ISSUE, I OBSERVED THAT THE MECHANISM THAT PHYSICALLY LATCHES THE REAR DOOR (TO THE MINIVAN BODY) WAS LOOSE. THE THREE SCREWS THAT SECURE/ATTACH THIS LATCHING MECHANISM IN PLACE WHERE BACKED HALF-WAY OUT. FAILURE: NO FAILURE HAD OCCURRED. HOWEVER, IF THE THREE SCREWS LOOSENED MORE, I FEAR THAT THE REAR HATCH COULD OPEN WHILE THE VAN WAS IN OPERATION. CORRECTION: TOYOTA DEALER TIGHTENED THE THREE SCREWS. *TR

AT 54,525 MILES, THE CHECK ENGINE LIGHT CAME ON. IT WAS DIAGNOSED AS "REPLACE AIR/FUEL SENSOR B1 S1." FAILURE CAUSED EXCESSIVE DAMAGE BECAUSE THE SENSOR FUSED INTO THE REAR EXHAUST MANIFOLD. DIAGNOSTIC TESTING $ 49.00 SENSOR REPLACEMENT PART 227.52 " " LABOR 150.00 REAR EXHAUST MANIFOLD 154.21 REAR EXHAUST MANIFOLD GASKET 29.27 REPAIR WAS NOT DONE AT A TOYOTA DEALERSHIP. I AM REPORTING THIS SO THAT TOYOTA WILL CHANGE THE DESIGN. FAILED PART SHOULD NOT DAMAGE SURROUNDING STRUCTURES. SUGGEST RECALL ON THIS PART IF TOYOTA CONTINUES TO USE THIS DESIGN. *NM

CAR HAD BEEN DRIVEN FOR 15 MINUTES, BRAKES WORKED, WAS PARKED FOR 30 MINUTES AND UPON PULLING OUT OF DRIVEWAY REALIZED BRAKES DID NOT FUNCTION. WAS ABLE TO BRAKE THE CAR WITH PARKING BRAKE. NO ACCIDENT ENSUED, CALLED TOW TRUCK AND BROUGHT IT TO SERVICE CENTER. WAS TOLD THAT VACUUM HOSE CAME UNATTACHED, SO POWER ASSISTED BRAKES WERE NOT WORKING. *JB

I HAD TWO INCIDENTS OF TIRE FAILURE ON THE HIGHWAY WHERE THE TIRES JUST CAME APART AT SPEEDS OF 70 MPH. THE FIRST TIRE HAD ABOUT 40K MILES ON IT AND THE 2ND TIRE HAD 50K MILES ON IT. I HAD A CLOSE CALL, BUT NO ACCIDENT. *NM

DT*: THE CONTACT STATED THAT THE VEHICLE'S SLIDING SIDE DOOR REMAINED LATCHED AND ONCE THE DOOR BECOMES LATCHED IT IS VERY DIFFICULT TO REOPEN. THE VEHICLE WAS MANUFACTURED WITH A REMOTE LOCKING DEVICE. THE DEALER DETERMINED THAT THE VEHICLE'S PUSH BUTTON NEEDED TO BE REPLACED. THE CONTACT EXPRESSED THAT THE PROBLEM COULD BE ELECTRICAL FAILURE. THE VEHICLE HAS NOT BEEN FIXED DUE TO COST.*AK

DT*: THE CONTACT STATED WHILE DRIVING 35 MPH A VEHICLE PULLED OUT AT AN INTERSECTION RESULTING IN THE CONTACT'S VEHICLE HITTING THE OTHER VEHICLE IN THE SIDE. THERE WAS PRE-IMPACT BRAKING. THIS WAS A FRONTAL IMPACT. THE FRONT END OF THE VEHICLE WAS PUSHED UP TO THE ENGINE, HOWEVER THE AIR BAGS FAILED TO DEPLOY. THE SEAT BELTS WERE IN USE HOWEVER INJURIES WERE SUSTAINED TO THE DRIVER. THE AIR BAG WARNING LIGHT DID NOT ILLUMINATE. THE DEALERSHIP AND MANUFACTURER HAVE NOT BEEN ALERTED. THE POLICE WERE ALERTED TO THE SCENE AND A REPORT WAS FILED. THE POLICE REPORT STATED THERE WERE NO INJURIES. UPDATED 07/28/06. *JB

2001 TOYOTA SIENNA LE, PURCHASED NEW, STARTED HAVING PROBLEMS. "CHECK ENGINE" LIGHT CAME ON WHEN VEHICLE HAD APPROXIMATELY 25,000 PLUS/MINUS MILES. UNDER WARRANTY, TOYOTA DEALERSHIP REPLACED THE OXYGEN SENSOR WITHOUT A CHARGE. HOWEVER, DURING THIS PROCESS, THE "BEEP" SIGNAL YOU HEAR WHEN LOCKING-UNLOCKING THE VEHICLE WITH REMOTE KEY WAS DISAPPEARED. THIS IS ALSO FIXED UNDER WARRANTY. THE "CHECK ENGINE" LIGHT CAME ON AGAIN WHEN THE VEHICLE HAD ABOUT 35,000 MILES. TOYOTA DEALERSHIP SAID IT IS DUE TO A DIRTY VACUUM HOSE, THEY CLEANED IT WITH A CHARGE LITTLE OVER $100.00. THE NEXT DAY THE "CHECK ENGINE" LIGHT CAME ON AGAIN, THIS TIME THE TOYOTA DEALERSHIP SAID THEY NEED TO REPLACE THE CHARCOAL CANISTER (PARTS FREE, BUT WE HAVE TO PAY LABOR--ABOUT $100.00). THIS THING CAUSES EXTREME MENTAL DISTRESS, TIME, MONEY, SECURITY ETC.*JB

THE ENGINE OF MY TOYOTA SIENNA 2001 WITH AN IDENTIFIED OIL SLUDGE PROBLEM SEIZED WHILE DRIVING AT HIGHWAY SPEEDS. VEHICLE COULD NOT BE CONTROLLED AND MY TODDLER THREW UP IN FEAR AS WE TRIED TO AVOID BEING SMASHED INTO WHILE THE CAR COASTED TO A STOP. MECHANIC REPEATEDLY SAID CAM SEIZED, METAL FILINGS FOUND, AND "COULD NOT THINK OF ANY OTHER REASON BUT THE SLUDGE PROBLEM." TOYOTA REFUSED TO REPAIR THE VEHICLE UNDER UNLIMITED MILEAGE, 8-YEAR WARRANTY. CAR IS PRESENTLY WITH DEALER AND MAY BE EXAMINED BY ENGINEERS FROM NHTSA (DEALER AGREED ON 12/22/05). THIS FAILURE WAS PREDICTED BY ANOTHER DEALER. CAR ALWAYS SMOKED--BLAMED ON "NEW ENGINE BREAK IN", "LACK OF MAINTENANCE", ETC. LATER TOYOTA SENT LETTER ABOUT THE ISSUE. THIS TIME DEALER AGREES MAINTENANCE WAS EXCELLENT. *NM

THE VAPOR VALVE, WHICH USUALLY STOPS THE REFUELING WHEN THE GAS TANK IS FILLED UP, HAS BEEN FAULTY. IN ESSENCE, WHEN TRYING TO FILL UP A GAS, THE PRESSURE IN THE GAS TANK BUILDS UP AND STOPS THE GAS PUMP FROM REFUELING EVERY 1 TO 2 GALLONS IT HAS TAKEN US MANY GARAGE VISITS, INCLUDING TOYOTA DEALERS, TO IDENTIFY THE PROBLEM CORRECTLY. TOYOTA USA REFUSED TO COVER THE PROBLEM SINCE THEY CLAIMS THAT OUR CAR IS OUT OF WARRANTY (TOYOTA SIENNA LE 2001). WE ONLY CONTEND THAT THIS DEFECT WAS DUE TO THE FAULTY ORIGINAL INSPECTION AT THE FACTORY AND ASK THAT TOYOTA SHOULD BE RESPONSIBLE FOR ITS OWN PRODUCTS. *JB

DT: THE CONTACT OWNS A 2001 TOYOTA SIENNA. THE FUEL AIR SENSOR FAILED. ALSO, FUEL SENSOR FAILED IN CONTACT'S SON'S 2001 TOYOTA HIGHLANDER WHICH HAD THE SAME MILEAGE. CALLED TOYOTA, AND THEY SAID THERE WERE NO RECALLS . HAD BOTH PARTS REPLACED, $282.00 EACH. NOW THE IGNITION HAS FAILED. *AK *NM

THE VEHICLE LEARCHED FORWARD FROM A AN IDLING POSITION WHILE IN PARK UP AN INCLINED DRIVEWAY

ON 8/18/05 MORNING THE SHIFTER LEVER BEHIND THE STEERING WHEEL WAS BROKEN LOOSE THAT I HAD NO CONTROL OF THE GEARS. THEN I BROUGHT MY VAN TO STEVENS CREEK TOYOTA (SAN JOSE, CA) WHERE I BOUGHT THE SIENNA VAN FOR REPAIR. AFTER THE TOYOTA TECHNICIAN OPENED UP FOR INSPECTION, I LATER WENT THERE TO TOOK SOME PHOTOS OF THE CONDITIONS, I FOUND OUT THAT THE MAIN CAUSE FOR THE MALFUNCTION OF THE SHIFTER WAS A BIG PIECE OF CAST IRON (APPROX. 1/2" THICK) THAT SERVES AS A MAIN FRAME OR BRACKET FOR ALL OTHER COMPONENTS IN THE ASSEMBLY FOR SUPPORT OF THEIR MOVING MECHANISM BROKE IN HALF ( HAVE PHOTOS TO PROVE IT) LITERALLY. SINCE IT APPEARS AS A "DEFECTIVE PART" OF THE SHIFTER AND NOT A "WEAR & TEAR" CONDITION, I 'VE REQUESTED TOYOTA CORP. (BOTH LOCAL & HEADQUARTES) TO REPLACE IT WITH FREE OF CHARGE. THE REQUEST WAS DECLINED DUE TO WARRANTY POLICY BEYOND 30,000 MILES/ 3 YEAR. THEN TOYOTA CORP. ISSUED ME A CASE NO.:2005-0818-0778 (FILED 8/18/05).I ALSO ASKED SERVICE REPRESENTATIVE, AUTO MECHANICS, AND TOYOTA CORP. AGENT THAT HAVE THEY SEEN OR HEARD ANYTHING SIMILAR LIKE MY CASE, NOBODY COULD CONFIRM IT IS A COMMON PROBLEM OF "WEAR & TEAR" BEYOND WARRANTY PERIOD. THE QUESTION IS HOW A CONSUMER LIKE MYSELF GET PROJECTED FROM THE "DEFECTIVE PART" THAT A DRIVER DEFENDS HEAVILY FOR MANEUVERING OF THE VEHICLE HAS NO CONTROL OVER THE GEARS? FORTUNATELY, THE INCIDENT DIDN'T HAPPEN WHILE I WAS DRIVING ON THE FREEWAY WITH MY WIFE AND (3) YOUNG KIDS OR GET STUCK IN THE MIDDLE OF THE RAILROAD WITH RUNN

WHEN DRIVING ON HIGHWAY I-87 OUR MOONROOF IN OUR MINIVAN STARTED TO BLOW OFF. LUCKILY MY HUSBAND WAS IN THE PASSENGER SEAT AND COULD HOLD THE GLASS WHILE I PULL OFF. WE IMMEDIATELY CALLED TOYOTA OF CLIFTON PARK TO TELL THEM AND TOOK IT THERE THE FOLLOWING MORNING. THEY GAVE US TWO OPTIONS, ONE FULL REPLACEMENT AT A COST OF APPROX 1,340 + TAX OR TO HAVE THEM ATTEMPT TO REPLACE THE GLUE AND WE WOULD HAVE TO LET IT "CURE" FOR A FEW DAYS. WE DIDN'T DRIVE IT FOR APPROX 8 DAYS AND TWO DAYS AFTER DRIVING IT, IT FLEW OFF AGAIN, THIS TIME I WAS ALONE AN COULDN'T GRAB IT AND IT BLEW OUT AND HIT ANOTHER VEHICLE CAUSING PROPERTY DAMAGE TO THAT CAR. WE TOLD TOYOTA ORIGINALLY THAT IT HAD TO BE A MANUFACTURING DEFECT, YOU DON'T DRIVE AROUND AND EXPECT THE WINDOWS TO BLOW OUT OF YOUR CAR. THEY SAID BECAUSE WE WERE OVER OUR 50000 MILES THEY WOULDN'T BE RESPONSIBLE. NOW IN ADDITION TO THEM NOT TAKING RESPONSIBILITY FOR A DEFECTIVE MOONROOF, THEY ALSO GAVE US BAD ADVISE ON FIXING IT. THEY TOLD US ONLY ONE VERY EXPENSIVE OPTION AND THEN ONE VERY CHEAP. NOTHING IN BETWEEN WAS OFFERED AND AFTER TALKING TO OUR INSURANCE ADJUSTER, THERE WAS MANY OTHER WAYS TO FIX THE VEHICLE (ONLY REPLACE THE GLASS, GET ONE FROM A JUNK YARD ETC) BUT THEY DIDN'T OFFER THOSE LESS EXPENSIVE REPAIRS SO OF COURSE WE TRIED THE GLUE. AFTER METLIFE SENT AN ENGINEER FROM AN INDEPENDENT COMPANY DID WE FIND OUT THEY USED AN APPOXY THAT ISN'T MEANT FOR FIXING SUNROOF'S OR CARS. *JB

DT: CONSUMER WAS DRIVING 2001 TOYOTA SIENNA VAN WHEN IT STOPPED AT A REST STOP, HIS 13 YEAR OLD SON WAS UNABLE TO GET OUT OF SEAT BELT. THE SEAT BELT WOULD NOT RELEASE, THE SEAT BELT KEPT GETTING TIGHTER AND TIGHTER UNTIL IT STARTED TO RESTRICT THE SON'S BREATHING. IN ORDER TO GET THE SEAT BELT LOOSE CONSUMER HAD TO CUT THE BELT. THE PART OF THE SEAT BELT THAT WOULD NOT RELEASE WAS THE RETRACTOR. THE BOY WAS WRAPPED IN THE SEAT BELT, BUT THE LATCH WAS UNDONE. HE WAS WRAPPED IN SUCH A WAY THAT HE COULD NOT GET LOOSE DUE TO THE RETRACTOR PULLING ON THE BELT. CONSUMER SAYS THAT THE RETRACTOR WOULD CONTINUE TO WIND UP WHEN HE WAS WORKING ON GETTING HIS SON LOOSE, BUT HE COULD NOT GET THE RETRACTOR TO RELEASE TO ALLOW HIM TO UNWRAP HIS SON, WHO SUSTAINED BRUISES AROUND WAIST.*AK