2019 Toyota Highlander complaints

Transmission failure. Unexpectedly failed while driving. Failure to accelerate before total failure. Repaired with used transmission since new ones are unavailable. Called Toyota to report the failure. No acknowledgement of any failure mechanism.

While driving down the road about 30mph on a paved road, heard a loud bang from the back. Stopped and inspected. The stability button shot off the door into the door jam, the door panel coming off, and the weather stripping separating from the door. The passenger rear airbag went off. Nothing visible on outside. Everything mechanically like it should be. 55,000 miles on car. Bought new from dealership. Done all maintenance and safety recalls. Vehicle is at dealership getting inspected.

While driving, my vehicle experienced a sudden transmission failure. The vehicle began to lose power and was unable to shift properly, making it difficult and unsafe to continue driving. I had the vehicle inspected and the transmission is currently being rebuilt. The mechanic performing the rebuild has stated that the failure was caused by a faulty build and a manufacturer defect, not normal wear and tear. I am currently awaiting written documentation from the mechanic confirming this, which will be submitted once received.

My Toyota was just in the shop for 100,000 mile service and investigation of whining noise upon acceleration. Was notified that the transmission needs replaced and will cost over $7500 . Transmissions are supposedly on back order. Upon further investigation, discovered there is a known issue with 2017-2019 Highlander transmissions that Toyota failed to issue a recall and failed to notify owners of these models. Repairs have not been made as transmissions are on backorder due to the magnitude of the issue.

On Sunday, February 1st 2026 during sub-freezing temperatures The vehicle's 8-speed automatic transmission (UA80) experienced a complete mechanical failure while driving. This resulted in a sudden and total loss of vehicle propulsion, requiring the car to be towed. Prior to the failure, the vehicle's AWD system indicator light was illuminated. The failure was diagnosed by Alexandria Toyota on February 3rd of 2026 as a catastrophic internal transmission failure requiring full replacement of the transmission Assembly with cooler (see attached quote). This defect causes an unreasonable safety risk by potentially stranding the vehicle in moving traffic or causing a crash due to unexpected loss of power.

Transmission starting making a whining noise failing at 106,950 miles. Inspection by transmission shop shows issue related to UA80E/F transmissions. Concerns or increased inspection for transmission were never mentioned during prior maintenance with dealerships or any notices sent out to owners. No warnings or codes recorded on system ECO. •Toyota Tech Tip T TT 0410 •Bulletin T SB 0160 18 •Bulletin T SB 0008 21 •Bulletin T SB 0122 20 •Bulletin T SB 0087 23

Transmission has High pitch when accelerating

Bought car in April 2025. Has 80,000 miles. Transmission failed.

1. What component or system failed or malfunctioned? System: Power Train: Automatic Transmission Specific Component: UA80 8-Speed Automatic Transmission (Internal Failure) Available for Inspection: Yes, the vehicle is currently available. 2. How was your safety or the safety of others put at risk? While merging onto the highway, the transmission failed to upshift, resulting in a sudden and unexpected loss of acceleration. The vehicle could not reach or maintain highway speeds (speed limit). This created an immediate hazard as I was unable to keep up with the flow of traffic, forcing me to make an emergency exit across multiple lanes while moving significantly slower than other vehicles. The loss of motive power increased the risk of a high-speed rear-end collision. 3. Has the problem been reproduced or confirmed by a dealer? Yes. The problem was confirmed by Heritage Toyota Service. The technicians confirmed an internal transmission failure. A secondary consultation with a transmission specialist (AAMCO) also identified the failure as a known mechanical defect common to this transmission model. 4. Has the vehicle been inspected by the manufacturer... or others? Yes, it has been inspected by the authorized Toyota Dealership listed above. I have also reported the issue to Toyota Brand Engagement (National), but a corporate field inspection (DSPM) has not yet been performed. 5. Were there any warning lamps... or other symptoms? Symptoms: A distinct whining noise from the engine/

The transmission is whining and is going out it is shifting hard now.

Transmission failed catastrophically at 133,000 miles while vehicle was in operation at a busy intersection. Vehicle became immobilized and unable to move. Unable to safely exit vehicle due to traffic. Stranded for 60-90 minutes with multiple vehicles nearly striking the disabled vehicle, creating a serious safety hazard. Police were called but failed to show up. Prior to failure: Vehicle exhibited loud whining noise during initial startup that would sometimes lessen or stop. This symptom appeared sometime within the last 1,000 miles of operation. Toyota dealer service at 132k miles noted transmission fluid was "Ok" during routine maintenance. At 133k miles transmission failed catastrophically. Independent transmission service center reports burnt-smelling transmission fluid indicating severe thermal damage and transmission failure. Problem confirmed by two independent service centers. Transmission is available for inspection upon request. Vehicle is not drivable.

128,000 Miles and the transmission is making a whining sound that progressively gets worse with acceleration. Also has occasional erratic shift associated with no throttle response. Sound is obnoxiously loud on the freeway deeming it almost undriveable.

The car started making a wining noise while accelerating. The car was brought to my local dealer where I always have my service done and they said I need a new transmission. The cost will be approx. $9,300.00. The car has less than 84,000 miles on it and is just 6 years old. Every recommend service has been done to date.

Vehicle experienced sudden loss of power and severe hesitation from a stop. Acceleration is extremely weak from approximately 0–20 mph, then returns to normal once moving. Traction control system automatically disables itself and check engine light illuminates. Vehicle feels unsafe when pulling into traffic or intersections due to delayed acceleration. Diagnostic trouble codes retrieved: P0740 (Torque Converter Clutch Actuator Stuck On), P0745 (Pressure Control Solenoid A Stuck Off), and P2713 (Pressure Control Solenoid D Stuck Off). Dealer recommended full transmission replacement costing over $11,000 at only 79,000 miles. Dealer stated this failure is common on this model. Similar failures have been reported by other owners of Toyota vehicles equipped with the UA80 8-speed automatic transmission. No recall currently exists for this issue. This condition presents a safety concern due to delayed acceleration when entering traffic and loss of traction control functionality. Vehicle is being driven minimally until repaired.

2019 highlander has a winding sound coming from engine area, no warning lights turned on but winding sound only occurs when in drive and accelerating. vehicle has 90000 miles and winding sound started around 80000 miles. i brought highlander to toyota service and they stated they heard the sound but didnt diagnose it.

On Monday December 15, 2025 our transmission failed as we began to drive up a small grade in between two sets of railroad tracks at the intersection of Cary, Ushers and Coons Crossing Road in the county of Saratoga, NY. If it had failed on one of the two sets of tracks it may have endangered us. On December 17, 2025 Northway Toyota in Latham, NY diagnosed the transmission failure at their dealership. I had attached the appropriate documents. The only warning for failure was a whining sound a few days leading up to the failure, but we thought it was a normal sound from the engine which we have subsequently learned was a sign of a failing transmission as we investigated prior complaints from others.

In early January 2026 there was rough/delayed shifting, whining noises, and fluid leaks. Probably linked to the faulty UA80E/F transmission type. The check engine light came on 1/15/26, I took it into a local repair shop. The mechanic flushed and changed the transmission fluid, replaced all of the spark plugs and the serpentine belt. I picked it up on 1/16/26. There was still shuddering, strange sounds (whining/grinding), and hesitation. On 1/20/26 I drove it and the rough/delayed shifting, whining noises, hesitation and burning smell started happening. The car completely broke down on the freeway and wouldn't drive at all. I had to slowly pull over to the shoulder of the freeway and have the car towed to the repair shop. They inspected it and said I need a new transmission, and it cannot be fixed. I believe the next steps are to have it towed to the toyota dealership to have it looked at.

I am experiencing a turbine whining noise from my transmission while under load. This has been reported to be an issue that stem from incorrect assembly of the locking washer to the locking nut in the UA80F 8 speed transmission. Toyota only provided extended warranty to 2017-2018 vehicles but not all vehicles that were manufactured with the same exact transmission. This whine is a sign of premature transmission failure that can occur at any given time while driving which is an extreme safety hazard. Please do something to force Toyota to be held accountable of their poor manufacturing and fix this safety hazard via recall. There is a law suit from James LeBoutheller pertaining to this issue.

Radio head unit keeps resetting. While using navigation. Disturbing driving. Something it will continually loop resetting. Can not determine consistent cause. Would like a free replacement and or upgrade including navigation

Transmission failure resulted in sudden loss of power while driving, creating a safety risk in traffic. Vehicle was unable to accelerate and required immediate repair. Put myself and my children at risk, as the car suddenly died while I was driving it. Prior to this, there were not issues. Has been routinely maintained and only has approx 83k miles. Toyota agreed that the transmission is the only issue with my car but won't cover the cost to replace it (10k) or the cost of a loaner vehicle. I have been without a car for almost a month while the (refurbished) transmission is on backorder.

Good Morning, I purchased a 2019 Toyota Highlander at a Toyota dealership and the transmission has died at 68,000. It died while driving in heavy traffic with my kids in the car. Toyota has completed an inspection of the transmission and determined that it needed to be replaced. They also said that because the transmissions are in back order due to all of the failures, I would have to wait 45-60 days to get a remanufactured transmission. I've also heard that they are replacing these transmissions with the same ones that are failing and only offering a 1 year warranty. Ive already spoke with Toyota Brand engagement and they told me that there was nothing that they could do.

Transmission began to manifest gear shifting issues. Took to mechanic shop to have diagnosed and found premature wear. The recommendation was to replace this transmission. However there are no factory replacements for this transmission and the only alternative is a used transmission replacement. Parts can't be sourced for even a rebuild. This vehicle has 96k miles on it. In review of recommended, routine services for this vehicle, transmission service is not recommended due to being a "sealed" transmission. Apparently this is a known issue as documented by Toyota under TSB "CSP ZJC". In this particular situation there have not been any warning lights. Replacement quote for a used transmission was $15,000 on 01/12/2025.

Initially had issues with acceleration with RPM’s going high with car moving very slowly. Five days after that started, car broke down 3 times in one trip & would not drive or go in reverse. Per dealership, the car needs a new transmission even though it’s only a 2019 with 110,000 miles.

Transmission stopped working while I was driving. Could not drive the car.

We began to hear a whine coming from the front of our 2019 Highlander. The tone of the whine got higher as we picked up speed. We went immediately for a preliminary review at the dealer who indicated that it was a known transmission problem in several model years, and the whine would only become more pronounced. We further understood that the very same transmission in our 2019 Highlander has been covered by a recall in years just prior and after 2019, but not for our particular VIN. Nevertheless, it is obvious to even the Toyota dealer mechanic that it is the same issue. The car has been carefully used and maintained since purchasing it new--it only has approximately 74,000. We expect our transmission fix or replacement to be covered.

With under 80,000 miles, my 2019 Toyota Highlander XLE needed a full transmission replacement. Noticed some rough gear changes for about 2-weeks (mostly changing from Park to Drive), then on my drive home from work, the RPM spiked high and all the sensor lights came on (AWD, Check Engine, etc). I drove the rest of the way with hazard lights in limp-mode. Took my car into a Toyota dealer service center (Kenosha WI), they did not make any repairs - just disabled the sensor lights and did a test drive - ended up keeping a 2nd day and replaced transmission fluid since they were seeing oddities with shifting. Within 1 week, the same thing happened. This time, I could hardly make it above 20 mph, basically no acceleration. Received 2 quotes from independent transmission specialists / repair shops - both confirmed I needed a new transmission. They said the car is unsafe to drive until it is replaced. This was right near my 6-year 100,000 warranty. Perhaps a few months beyond 6 years. Toyota opted not to make any repairs / improvements. Left the car in unsafe condition for me and my kids. Toyota then quoted $16,346 for a new transmission. Other quotes I received were $10,000 LESS than Toyota, using new Toyota parts. Seemed like price gauging to me.

After 3 weeks of inconsistent shifting with the automatic transmission and whining and clunking, the car failed to go into gear at all yesterday 1/5/26 while driving near Dulles airport. I had it towed, was told the transmission failed and then I found that this is a systemic design issue with the 2017-2022 cohort of gas V6, 8 speed, AWD Highlanders. Repair will be between $5K and $10K.

Per my mechanic (fyi: 56k miles on vehicle): I test drove the vehicle and can hear a noticeable whine type noise when accelerating the noise goes away when getting off throttle. I put it on lift and the noise is coming from the transmission pump and sounds like cavitation. I checked the fluid level and it was overfull, very dark and has some very fine metal debris in the fluid. Something is coming apart inside the transmission has caused a catastrophic failure. The transmission will need replaced. I called Toyota to check availability and these transmission are on a restricted order. The dealer would need to call corporate Toyota to see what is needed to even order one. Usually a restricted order means they are on the edge of a back-order or having problems with the part and are working on a resolution or update. I did not see any recalls, service campaigns, or technical service bulletins for this transmission, but it sounds like the 2017-2021 V6 AWD UA80F transmissions are having issues. It is a long shot, but given the low mileage, you could try contacting Toyota to see if there is anything they can do for you. I know the factory warranty is 60 months or 60,000 miles on the powertrain. You are out on the time, but if they are having a known issue, then maybe they will help you.

The contact owns a 2019 Toyota Highlander. The contact stated that while driving on several occasions at various speeds, the contact heard abnormal buzzing sounds coming from underneath the vehicle. The vehicle was taken to a dealer; however, the failure could not able to be replicated. The contact stated that a day or two days later, while stopped at an intersection, and attempting to accelerate, the vehicle failed to accelerate as intended. There were no warning lights illuminated. The vehicle was pulled over to the side of the road and restarted; however, the failure persisted. The vehicle was towed to a dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 59,000.

Transmission problems at 62000 miles high pitched whine with acceleration

The car randomly shuts off, while waiting in line or when the break is depressed. The vehicle won’t start, battery is completely dead and then comes back randomly.

What component or system failed or malfunctioned, and is it available for inspection upon request? 12V battery How was your safety or the safety of others put at risk? Vehicle unable to start. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Inspected by independent service center. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning of impending failures. 2/17/2020, vehicle purchased new from Toyota of Morristown (NJ). 2/23/2023, vehicle's (3 year old; 1 week outside of warranty) original OEM 12V battery failed and was replaced with Toyota OEM 12V battery (Part #2880031291) by independent service center ($376.61). 12/18/2025, vehicle's (less than 2 year old) replacement Toyota OEM 12V battery failed and was replaced with Toyota OEM 12V battery by independent service center ($407.88).

2019 Toyota Highlander with approx 178000 miles, UA80E transmission sudden failure while traveling approximately 30 mph, on city street. Manually pushed vehicle to safety away from traffic and unto a parking lot. That same evening drove vehicle about 20 feet to a more secure parking spot. VEHICLE HAS NOT BEEN MOVED SINCE 12/15/25. No leaks, no spills etc EXTREMELY DANGEROUS.

The transmission failed while going up a steep hill the car lost power and shut off. Could have caused seriously property and body damage if traffic or people were around. Luckily no accident happened but could certainly cause an accident if the circumstances are different. Please make an official complain so this could be fully investigated.

Premature failure of UA80F transmission with 80,000 miles on vehicle which has been regularly serviced and maintained. Failure symptoms demonstrated match documented cases exactly resulting in the ultimate and complete failure of the transmission resulting in the vehicle being towed in to the dealer for a repair. Repair bill upwards of $10,000 however being told parts not available leaving me with a 40k vehicle that is unable to be repaired.

Our transmission is making a high pitched whining sound when accelerating.

At around 107,000 miles, we started hearing griding/whining noises from the engine compartment. After multiple inspections from 3 different auto shops a Toyota dealership confirmed the transmission and transfer case had failed and needed to be completely replaced. There were NO warning lamps, messages or other symptoms besides the griding/whinig noise prior to the failure. After the Toyota dealership diagnosed the issue, we stopped using the vehicle until Toyota could make the necessary repairs for the vehicle to be safely driven. The Toyota dealership made the necessary repairs that we paid for on 10/28/25. We are aware that this is a known defect by Toyota on the UA80 Transmission and Technical Service Bulletins have been released. We demand a recall and our out of pocket repair cost money back of $12,623.31.

8-speed automatic transmission failing. Noticeable whining sound that increases with acceleration, however no warning lights or messages. Metal shavings found in fluid upon inspection by independent mechanic. This is exactly in line with the lawsuit, filed in the U.S. District Court for the Central District of California by plaintiff [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle is relatively new 2019 and mileage is low 45000 car was humming for no reason for a day or two and its well maintained, today at busy thoroughfare it stalled at intersection of ave u and another street and was behaving erratically due to know manufacture defect of Toyota Transmission UA80E/F that causes sudden stall and thank god have. I stalled on highway it would have been a catastrophe. I want NHTSA to acknowledge danger this poses to drivers if suden loss of power occurs suddenly hoping for a solution to this dangerous manufacture defect.

Adaptive cruise control issue and transmission issue transmission is whining. Vehicle taken to the dealer and I am told nothing is wrong with the vehicle.

•What component or system failed or malfunctioned, and is it available for inspection upon request? Transmission and power train failure during normal operation. Vehicle was occupied by mother and two small children. Vehicle produced a whining noise, delay in shifting and power failure. No warning lights appeared to give any indication of failure prior to occurring. Vehicle is available for inspection. •How was your safety or the safety of others put at risk? Vehicle stalled during normal operation. No warning indicators were present. No ability to proceed to shoulder. Traffic hazard in middle of road. Possibility of being rear ended increased. Exiting the vehicle in traffic to determine fault increase probability of being struck. Two young children seated to the rear should vehicle be rear ended due to sudden stop could cause catastrophic injuries or death. •Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, vehicle was taken and diagnostic conducted by Glendora Toyota. Vehicle was kept overnight. Dealer determined that vehicle had a transmission failure. Multiple articles and bulletins by Toyota indicating and acknowledging transmission failures in 2019 Toyota Highlander. •Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Vehicle has only been inspected by Glendora Toyota service personnel. •Were there any warning lamps, messages or other symptoms of the problem prior to th

My vehicle has noise in the transmission when accelerating. They should give a voletin. thanks

Issue 1: I reported transmission issued to the dealership/service center where I purchased the car. They assured me its just the electronic transmission trying to find the right gear while driving. Continued to complaint about the jerks and shifting. Dealer warranty expired, then they agreed that I needed a new transmission. Fortunately I had an outside extended warranty otherwise they'd probably would have waited until that ended too. Status post the transmission, tuning, sensor replacements, spark plug replacement, and TPMS replacements all in one service. Prior to my warranty expiring, AWD, engine light and hard transmission shifts began with the new transmission. Returned repeatedly from April to November with no resolution. However, they did have me pay to replace sensors I had replaced in April several times and obtain a new battery. Issue 2: After "new" batter the car's electrical issues worsened resulting in a power failure while driving at 75 miles an hour and losing complete control of the vehicle. The power failure shut down the electronic shifter, power steering, All Wheel Drive, Traction control in raining conditions and ultimately the power assisted brakes. returned the vehicle to the service department for additional "testing" after taking a video of the fault messages were the car electrical systems shut down to auto start stop function warning light. I'm a skill driver and was able to avoid crashing during the incidents. The photos are from the latest day I d

My vehicle was taken into Toyota dealership for diagnostics after experiencing a whine noise from transmission after driving. Toyota confirmed that I will need a new transmission. After researching I found that there is a defect in the transmissions for my specific type. It has been reported for years but Toyota has not addressed. Since it is a transmission failure this could lead to a breakdown while driving on highways and could risk my safety and other drivers. The estimated repair cost are currently above $8K.

Owners of 2017–2022 Toyota Highlanders, 2017–2020 Siennas, and 2018–2020 Camrys are experiencing serious transmission issues—including high-pitched whining, erratic shifting, clunks, hesitation, and premature failure. These vehicles are equipped with the UA80F (AWD) and UA80E (FWD) 8-speed automatic transmissions. Toyota quietly acknowledged the problem in Technical Service Bulletins T-SB-0160-18, T-SB-0008-21, and a limited Customer Support Program (CSP ZJC)—but only offered coverage to a narrow group of VINs. Thousands of other affected vehicles were left out, even though they show the same exact symptoms.

This is the second time this year 2025 my Toyota Highlander 2019 stalled fist in the middle of of intersection and second on the drive thru in in&out. Suddenly my car died. Tried to turn on followed the on screen instructions but the car failed to turn on. The first time it happened in the middle of the intersection while waiting for the light to change, after the issue I when straight to a car shop and oreilly they have this machine to check any possible issues and he said nothing shows in his machine but he think it’s the battery but I told the guy my battery and on the car shop Midas same result no major issue found and one of the technicians says It could be the auto shot off features, that must be manually turn off since this will automatically turn on. The second incident in In&Out the car died suddenly, tried to turn the car but it was on Drive so change to stop then tried to turn on multiple times but faulted , the crews decided to help us push the car out of the drive thru since we are blocking all the customers car, the steering wheel so stiff could hardly turn. We can’t change gear from stop, I was told to push off and on manual break foot pedal and this this help able to change gear to neutral, so we can push the car out of the drive thru. No message or failure message in the screen. We just push the car in the parking lot. Tried to turn on but failed. One of in&out staff was so kind to help us, he has a portable jumpstart and the car able to start. Able to drive

Transmission failure. Vehicle is at this time still operational however the transmission has developed the ever so common whining sound and sluggish shifting. Upon fluid inspection metal filings can be seen and replacement has been recommended by repair shop. The whining has been evident for some time but after investigating this issue decided to have inspected. This inspection was just completed on 11/14/25

Our 2019 Toyota Highlanders transmission is gone. The car has 83,000 miles. I have been researching online and found out that Toyota is very much aware of the problem. They're refusing to help me. They're basing it on our VIN#. No recalls. I just want them to acknowledge that the issue needs to be addressed NOW.

The contact owns a 2019 Toyota Highlander. The contact stated that while driving approximately 35 MPH, there was an abnormal whining sound coming from the vehicle. There was no warning light illuminated. The contact previously owned a 2017 Toyota Highlander and heard the same whining sound coming from the transmission. The contact stated that when the 2017 Toyota Highlander was taken to the dealer where the vehicle was purchased, the contact was offered a trade of the 2017 Toyota Highlander for the 2019 Toyota Highlander. Following the failure of the 2019 Highlander, the vehicle was taken to two different dealers to be diagnosed. The first dealer had not diagnosed the vehicle but stated that the vehicle was operating normally. The vehicle was taken to another dealer, who diagnosed the vehicle and determined that the transmission needed to be replaced. The vehicle was not repaired. The contact researched the failure online and determined that the 2017 Highlander and the 2019 Highlander had the same model transmission, UA80F - CVT transmission. The manufacturer was informed of the failure and informed the contact that the vehicle was no longer under warranty. The failure mileage was approximately 133,000.

Loud ear-piercing noise when vehicle is started. Noise lasts about five seconds.