1999 Toyota 4Runner complaints

-STARTED THE VEHICLE. -MOVED FORWARD A FEW FEET -STARTED TO TURN STEERING WHEEL LEFT, NOTICED STEERING WAS HEAVIER THAN NORMAL AS WELL AS UNUSUAL NOISE -CAR JERKED AND SHOT LEFT... TRIED TO STEER TO AVOID HITTING OBSTACLES BUT WAS UNABLE TO DUE TO THE EXTREME HEAVINESS OF THE STEERING WHEEL. DUE TO THIS INCIDENT THE VEHICLE WAS TOWED DIRECTLY TO THE SHOP FOR REPAIRS -MECHANIC IMMEDIATELY NOTICE UNUSUAL SEPARATION OF THE RACK AND PINION. *TR

RAN OUT OF FUEL WHILE DRIVING IN HEAVY TRAFFIC. WE NEARLY GOT REAR ENDED! FUEL GAUGE SHOWED PLENTY OF GASOLINE. FUEL GAUGING SYSTEM FAILED. *TR

TL*THE CONTACT OWNS A 1999 TOYOTA 4RUNNER. THE CONTACT STATED THAT THERE IS A HOLE IN THE BOX FRAME OF THE VEHICLE DUE TO THE CONSTRUCTION OF THE FRAME. WATER SEEPS IN THROUGH THE FRAME, CAUSING IT TO RUST FROM THE INSIDE OUT. THE VEHICLE WAS TAKEN TO THE DEALER FOR ROUTINE MAINTENANCE AND THEY INFORMED HER OF THE FAILURE. THE VEHICLE WAS DIAGNOSED BY TWO REPAIR SHOPS AND THEY BOTH CONFIRMED THAT THE FAILURE WAS DUE TO THE DESIGN OF THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 143,000. UPDATED 09/29/08. *LJ UPDATED 09/29/08. *JB

#1 STARTER STUCK TWICE-EVEN REMOVED KEY AND ENGINE KEPT CRANKING. #2 FUEL GUAGE REAES FULL WHEN EMPTY AND VISE VERSA. #3 P0171 ENGINE CODE KEEPS THROWING #4 BRAKES FADE WHEN APPLIED HARD. HAVE REPLACED PADS AND ROTORS AND STILL FADE. *TR

THIS IS THE 4TH TIME IN 4 YEARS THAT MY 4RUNNER HAS HAD A LEFT REAR AXLE SEAL PROBLEM. THE VEHICLE ONLY HAS 69,000 MILES ON IT, SO THIS PROBLEM ARISES ABOUT EVERY 11- 15K MILES. EACH TIME THE SEALS AND BREAKS HAVE TO BE CHANGED. THE AXLE SHAFT WAS REPLACED LAST TIME, BUT I AM STILL HAVING THE SAME PROBLEM. THERE ARE TONS OF PEOPLE WITH THIS VERY EXPENSIVE RECURRING PROBLEM AND ITS RIDICULOUS THAT TOYOTA KNOWS ABOUT IT BUT DON'T DO ANYTHING. *TR

BODY IS RUSTING SEVERELY. REAR HATCH WILL NOT OPEN. BUMPERS HAVE DISINTEGRATED. FRAME RUSTED AWAY FROM BODY AND HAD TO BE REPAIRED. *TR

MY GAS GAUGE HAS FAILED LIKE MANY OTHERS I HAVE READ ABOUT ON THE INTERNET. SEEMS TO BE A SERIOUS PROBLEM WHICH HAS CAUSED MANY WRECKS. *TR

I HAVE 99 4 RUNNER AND AS I WAS DRIVING DOWN THE HIGHWAY MY VEHICLES ENGINE DIED, I HAD TO CUT ACROSS TRAFFIC WITHOUT POWER BRAKES OR STEERING. I SPOKE TO THE DEALER ABOUT MY PROBLEM AND THEY GAVE ME AN ESTIMATE OF AROUND $1000 DOLLARS, IF U LOOK ON THE INTERNET THERE SEEMS TO BE A LOT OF PEOPLE WITH THIS SAME ISSUE,I THINK THERE NEEDS TO BE A RECALL CONCERNING THIS ISSUE BECAUSE IT IS POSSIBLE TO CAUSE A COLLISION UNDER CERTAIN CIRCUMSTANCES. THANKS *TR

I HAVE A BIG PROBLEM WITH MY FUEL GAUGE, IT IS EXTREMELY INACCURATE. SOMETIMES IT'LL TELL ME I HAVE MORE GAS THAN I DO, AND OTHER TIMES IT'LL TELL ME I HAVE LESS. APPARENTLY THIS IS A BIG PROBLEM AMONG 99 4RUNNERS, AND I'D REALLY LIKE TO GET THIS FIXED. I RAN OUT OF GAS ON THE FREEWAY THINKING I HAD HALF A TANK LEFT AND ALMOST CAUSED A WRECK. THANKS IN ADVANCE. *TR

TL*THE CONTACT OWNS A 1999 TOYOTA 4RUNNER. THE CONTACT STATED THAT THERE IS AN 18 INCH STRIP OF FABRIC UNRAVELING ON THE DRIVER'S SIDE SEAT BELT. THE MORE HE USES IT, THE FASTER IT COMES APART. THE FABRIC IS HOLDING ON BY A THREAD. THE LOCAL DEALER STATED THAT BECAUSE THE VEHICLE HAS SO MANY MILES, THEY WOULD NOT REPAIR THE FAILURE. THE CURRENT MILEAGE WAS 269,978 AND FAILURE MILEAGE WAS 230,000.

MY DAUGHTER WAS DRIVING HOME FROM SCHOOL, APPROXIMATELY A 3 MILE DRIVE, HER 1999 4 RUNNER BEGAN JERKING AND THEN THE ENGINE DIED. SHE WAS ABLE TO RESTART IT AND DRIVE FOR SEVERAL HUNDRED YARDS WHEN IT DID THE SAME THING. THIS TIME THE CAR WOULD NOT RESTART. MY WIFE WENT TO PICK HER UP AND SHE WAS ABLE TO RESTART THE CAR AGAIN AND DRIVE APPROXIMATELY THE SAME DISTANCE WHEN IT DIED AGAIN, THIS TIME THE CAR WOULD NOT RESTART. I HAD TO HAVE IT TOWED AND ITS CURRENTLY AT A REPAIR STATION WAITING TO BE DIAGNOSED. I'VE HEARD THERE IS A SERVICE BULLETIN REGARDING A FUEL PICKUP TUBE/SENSOR PROBLEM BUT I HAVEN'T BEEN ABLE TO FIND IT. WHY HASN'T TOYOTA HAD A RECALL YET? *TR

1999 TOYOTA 4RUNNER, REPEATED FUEL GAUGE FAILURE: INCORRECTLY STATES AMOUNT OF FUEL IN TANK (CHANGING DURING THE SAME DRIVING TRIP); REPORTS AN EMPTY TANK WHEN FULL AND AN 1/8 TO A 1/4 TANK FILL WHEN EMPTY; ALL OF WHICH RESULT IN EVENTS WHERE THE VEHICLE IS RUN OUT OF GAS. MULTIPLE EXPENSIVE ATTEMPTED FIXS BY THE DEALER WITHOUT SUCCESS. *TR

PURCHASED NEW - NOW AT 135K MILES. HAVE REPLACED 1 OR BOTH REAR AXLE SEALS AT LEAST 5 TIMES -- FIRST REPLACEMENT WAS ON MY DIME -- REMAINDER HAVE BEEN UNDER WARRANTY. THEY REPLACED AN AXLE LAST TIME, BUT IN LESS THAN 2K MILES SYMPTOMS RETURNED (LEAKS ON WHEELS, STICKING REAR BRAKES). SURE, IT DOESN'T "COST" ME ANYTHING, EXCEPT MY TRUCK IS IN THE SHOP 1-2 DAYS EACH TIME! *TR

I BOUGHT THIS TIRE FROM A FIRESTONE COMPANY. I WAS DRIVING ON THE I-60 EAST COMING FROM WORK. ALL OF A SUDDEN I HEARD A LOUD NOISE AND IMMEDIATELY MY CAR STARTED TO SHAKE VIOLENTLY. IT WENT OUT OF CONTROL, STIRRED TO THE LEFT AND HIT THE HIGHWAY SEPARATOR (A CONCRETE ROAD BLOCK). THE FRONT OF MY CAR DIRECTLY WENT CRASH INTO THAT CONCRETE BARRIER IN A PERPENDICULAR POSITION, MAKING A FULL FRONTAL CONTACT, THAT RELEASE BOTH FRONT AIRBAGS. MY WINDSHIELD CRACKED AND MY FRONT CAR AREA IS TOTALED. I CAME OUT OF THERE WITH NECK, HEAD, BACK AND CHEST INJURY. *TR

TOYOTA 99 4RUNNER FUEL GAUGE ALWAYS READS EMPTY, REQUIRES REPLACEMENT OF EXPENSIVE CIRCUIT BOARDS IN INSTRUMENT CLUSTER TO REPAIR. TOYOTA DEALER QUOTED $1050 TO REPAIR ON 9/24/07. *JB

TL*THE CONTACT OWNS A 1999 TOYOTA 4RUNNER. ON MAY 9, 2005, THE VEHICLE'S LOWER BALL JOINTS FAILED AND THE TIRE DETACHED FROM THE VEHICLE. THE FAILURE OCCURRED WHILE DRIVING 35 MPH. THE VEHICLE WAS TOWED. THERE WERE NO WARNING INDICATORS BEFORE THE FAILURE OCCURRED. THE CONTACT STATED THAT THE VEHICLE WAS PURCHASED IN FEBRUARY OF 2004. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 161,000 AND FAILURE MILEAGE WAS 135,000.

I WAS DRIVING MY 1999 TOYOTA 4-RUNNER, DOWN THE ROAD WHEN ALL OF A SUDDEN I HEARD A GRINDING NOISE, INSTANTLY THE ENGINE STARTED TO SHAKE AND THEN LOUD GRINDING NOISE, THE CAR QUIT AND OIL EVERYWHERE. I HAD THROWN A ROD. NO WARNING AT ALL. SERVICE MAINTENANCE MAINTAINED. NO REASON FOR THE ENGINE TO BLOW! *TR

THIS EMAIL IS REGARDS TO THE INACCURACY OF THE FUEL GAUGE ON MY 99 TOYOTA . I WAS LEFT STRANDED LAST NIGHT OUTSIDE OF THUNDER BAY WITH NO FUEL EVEN THOUGH THE GAUGE READ WELL OVER 1/4 TANK LEFT. IN -35 CELSIUS WIND CHILL CONDITIONS. NOTHING HAS BEEN DONE TO CORRECT THIS FAILURE. *NM

WHILE DRIVING 20 MPH HAD A FRONTAL IMPACT WITH A LARGE TREE IN WHICH THE FRONT END WAS CRUSHED. UPON IMPACT, DRIVER'S AND PASSENGER'S AIRBAGS DID NOT DEPLOY, WHICH DID NOT PROTECT THE OCCUPANTS IN THE CRASH. PLEASE PROVIDE FURTHER INFORMATION. *NM

ERRATIC FUEL GAUGE, DANGER OF RUNNING OUT OF FUEL ON A DANGEROUS SITUATION. *NM

DT: THE CONTACT STATED THE VEHICLE STALLS AND THE DEALER HAS BEEN UNABLE TO RESOLVE. THE CONTACT IS UNSURE IF THIS IS THE ENGINE AND THE TRANSMISSION. THE VEHICLE ALSO HAS A CONTINUOUS KNOCKING SOUND, AND A INTERMITTENT STALLING PROBLEM. ALSO THE VEHICLE HAS A VIBRATION WHEN IT IS ACCELERATING OVER 50 MILES PER HOUR.

THE FOG LIGHTS HAVE GONE OUT SEVERAL TIMES. I HAVE NEW LAMPS REPLACED AND THEY GO OUT IN A FEW WEEKS. THIS HAS BEEN AN ISSUE SINCE I PURCHASED THE CAR NEW IN '99. *NM

HAVE A 1999 4RUNNER WHICH SUFFERED RIGHT REAR AXLE GASKET FAILURE AT 59000 MILES. SAME 4RUNNER SUFFERED LEFT REAR AXLE GASKET FAILURE AT 110000 MILES. HAVE OWNED SEVERAL 4RUNNERS (DIFFERENT YEARS) THAT HAVE NEVER HAD REAR AXLE PROBLEMS. HAS ANYONE ELSE HAD SAME PROBLEM. BOTH PROBLEMS WERE DIAGNOSED AT DEALER AND WERE CONSIDERED SAFETY HAZARDS BECAUSE GREASE WAS LEAKING ONTO REAR BRAKE PADS. WOULD ADVISE OTHER OWNERS OF THIS YEAR TO HAVE REAR AXLE SEALS EXAMINED BY DEALER FOR SAME PROBLEM. OTHERS HAVE HAD SAME PROBLEM AND HAVE POSTED REAR AXLE SEAL FAILURES ON WWW.TOYOTA-4RUNNER.ORG. *JB

(1) HIGH PITCHED ENGINE SQUEAK; ASSUMED WORN BELT. (2) MAIN PULLEY KEY LOCKING MAIN PULLEY TO CRANK SHAFT HAD SHEARED INTO TWO PIECES. ONE PIECE LOST. PULLEY MOVED OUT OF POSITION, STRESSING BELT AND CAUSING NOISE. REMAINING PIECE OF THE KEY WAS EMBEDDED AND FUSED INTO THE CRANK SHAFT. PULLEY KEY IS $ PART. OBVIOUSLY, NOT DURABLE ENOUGH FOR CRITICAL ENGINE PART, WHICH WHEN FAILS CAN RUIN THE ENTIRE ENGINE. EVEN 500 X THE $ COST WOULD BE WORTH HAVING TITANIUM OR TUNGSTEN STEEL PART THAT WOULD NEVER FAIL. TOYOTA IS CUTTING CORNERS, SACRIFICING QUALITY IN THE NAME OF PROFIT. I RISKED HAVING TO REPLACE THE ENGINE -- A $9,000 CONSIDERATION. (3) FORTUNATELY OLD MILL TOYOTA (OMAHA, NEBRASKA. WAS ABLE TO REMOVE THE FUSED PART AND SAVE THE ENGINE. A PROPERLY ENGINEERED PART, EVEN AT MUCH GREATER COST, WOULD HAVE PROTECTED ME FROM THIS RISK.*AK

REAR BRAKE FAILURE DUE TO LEAKING REAR AXLE GREASE SEALS WHICH THROW GREASE ONTO REAR BRAKE SHOES. CAUSING INCONSISTENT AND UNSAFE BRAKING. ACCORDING TO TOYOTA OF AUBURN CALIFORNIA, REPAIRS SIMILAR TO THIS ARE BEING PERFORMED ON SIMILAR VINTAGE TOYOTA FOUR RUNNER MODELS ON A WEEKLY BASIS. THE AVERAGE REPAIR COST IS $850. THIS APPEARS TO BE A VEHICLE MANUFACTURERS DEFECT NOT A STANDARD MAINTENANCE ISSUE AND COULD RESULT IN INJURIES OR DEATH. *JB *NM

1999-TOYOTA 4-RUNNER STARTED TO CONVULSE,SEIZE, AND SHAKE UNCONTROLLABLY, OIL WAS POURING OUT ALL OVER THE FREEWAY. THE CAR WAS NOT CONTROLLABLE IN FREEWAY TRAFFIC AT FREEWAY SPEEDS. THE CAR WAS PERFECTLY MAINTAINED. TOYOTA REFUSED TO EVALUATE THE PROBLEM. INDEPENDENT EXPERT DIAGNOSED A "HOLE IN THE BLOCK FROM A DEFECTIVE CONNECTING ROD WHICH HAD SHOT THROUGH THE ENGINE WALL" TOYOTA REFUSES ANY RESPONSIBILITY!! *JB

DT: THE CONTACT STATED WHEN THE VEHICLE WAS STARTED IT REVVED VERY FAST. THE CONSUMER REMOVED THE KEY BUT THE VEHICLE WAS STILL ON AND THE ENGINE WAS STILL REVVING. SMOKE STARTED COMING FROM UNDER THE HOOD. THE VEHICLE WAS ON FIRE , AND THE FIRE DEPARTMENT WAS CALLED. A FIRE REPORT TAKEN. THE VEHICLE WAS TOWED TO THE DEALERSHIP THE FOLLOWING MORNING. THE WATER PUMP, STARTER, AND THE BELTS WERE DESTROYED. THE FIRE STARTED IN THE STARTER. THE VEHICLE HAS BEEN REPAIRED. *AK UPDATED 1/25/2006 - *NM

I WAS DRIVING MY 1999 TOYOTA 4RUNNER WHICH I HAD JUST PURCHASED WITH 104,000 MILES ON IT. I WAS DRIVING IN THE FAST LANE ON I-695 WHEN THE CAR STARTED LOSING POWER AND SLOWING DOWN VERY FAST. I BARELY CROSSED THREE LANES OF TRAFFIC TO GET TO THE SHOULDER. THE GAS GUAGE READ JUST UNDER 1/2 FULL, BUT ACCORDING TO A TSB, THE GUAGE AND SENDER UNIT SHOULD HAVE BEEN REPLACED. I HAD NO WARNING FROM THE CAR TO TELL ME MY GAS TANK WAS FULL. RUNNING OUT OF GAS ON THE HIGHWAY IS DANGEROUS. I DON'T UNDERSTAND WHY THIS ISN'T A RECALL - WHY THIS ISN'T CONSIDERED A DEFECTIVE PRODUCT. THE DEALER WANTS TO CHARGE ME TO FIX IT, BUT I CAN'T AFFORD IT. I WAS USING MY ODOMETER TO KEEP TRACK, BUT THE OTHER DAY, I RAN OUT AGAIN WHILE DRIVING IN MY NEIGHBORHOOD. I THINK WITH THE A/C ON, IT MUST USE MORE GAS. I'M VERY UPSET.

DT: CONSUMER STATED THE REAR AXLE SEAL FAILED TWICE WHICH CAUSED THE REAR BRAKES TO FAIL. THE VEHICLE HAS BEEN REPAIRED ONCE WHILE UNDER WARRANTY AND IT NEEDS TO BE REPAIRED AGAIN, BUT THE VEHICLE WAS NO LONGER UNDER WARRANTY. *JB....REAR AXLE SEALS LEAKED FLUID. *AK *SB

VEHICLE STALLS AND DIES ON HIGHWAY ALMOST CAUSING WRECK. FIND OUT THERE IS NO FUEL IN TANK EVEN THOUGH FUEL GAUGE READS 1/3. TOYOTA SAYS TSB EL010-00 ADDRESSES KNOWN DEFECTIVE 1999 AND 2000 FUEL GAUGES AND ALSO ADDRESSES SOME GAUGES INACCURATELY READING EMPTY WHEN 4 GALLONS REMAIN, BUT MY VEHICLE CURRENTLY HAVE 72545 MILES AND OUT OF WARRANTY SO TOYOTA WILL NOT PAY FOR FIX. NO ENGINE, NO STEERING, NO BRAKES, LOTS OF TRAFFIC. I AM IN THE NAVY AND WILL BE DRIVING FROM FLORIDA TO SAN DIEGO NEXT MONTH ENROUTE TO JAPAN IN OCTOBER. I CALLED TOYOTA CORPORATE AND THEY SAID THEY KNOW ABOUT IT BUT SINCE IT'S ONLY A TSB AND NOT A RECALL, THEY CAN'T DO ANYTHING TO FIX IT UNLESS I PAY FOR IT MYSELF. THESE ARE KNOWN DEFECTS SINCE THE TRUCK GOT OUT OF THE TAHARA PLANT IN JAPAN FOR SALE TO THE U.S.

THE CONSUMER SMELLED A GASOLINE ODOR COMING FROM THE VENT AREA. THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR AN INSPECTION. THE MECHANIC INFORMED THE CONSUMER THAT THE FUEL RAIL NEEDED TO BE REPLACED. PLEASE FILL IN ADDITIONAL INFORMATION. *JB

THE GAS GAUGE WOULD READ FULL WHEN IT WAS ACTUALLY EMPTY, AND VISA VERSA. THEN THE SKIN OF THE DASH BOARD BY THE TACHOMETER BUBBLED FROM THE HEAT OF THE CIRCUIT BOARD OVER HEATING. I CALLED TOYOTA AND WAS TOLD THERE WAS NO BULLETIN ON THIS PROBLEM AND THEY REFERRED ME TO THE DEALERSHIP WHO ALSO DENIED THAT A BULLETIN EXISTED CONCERNING THE PROBLEM. I WENT TO AN AUTO REPAIR BUSINESS WHO RESEARCHED THE PROBLEM AND FOUND A BULLETIN FROM TOYOTA REGARDING MY PROBLEM (REF: BULLETIN EL010-00). I CALLED TOYOTA BACK AND THEN WAS TOLD SORRY BUT YOUR OUTSIDE THE WARRANTY TIME LIMIT. THERE SHOULD HAVE BEEN NOTIFICATION MADE TO THE CONSUMER BY TOYOTA REGARDING THIS MATTER. MY THE CIRCUIT BOARD OVERHEAT CAUSING THE BUBBLING AND COULD HAVE CAUSED A FIRE HAD I CHOSE JUST IGNORE THE GAUGE PROBLEM. TOYOTA HAS CHOSEN THE IGNORE THE PROBLEM IN HOPES THAT IT WILL NOT BE REPORTED AND AT THE EXPENSE OF THE CONSUMER.

VEHICLE STALLS AND DIES ON FREEWAY ALMOST CAUSING WRECK. FIND OUT THERE IS NO FUEL IN TANK EVEN THOUGH FUEL GAUGE READS 1/2. TOYOTA SAYS TSB EL010-00 ADDRESSES KNOWN DEFECTIVE 1999 AND 2000 FUEL GAUGES AND ALSO ADDRESSES SOME GAUGES INACCURATELY READING EMPTY WHEN 4 GALLONS REMAIN, MY VECHICLE IS OUT OF WARRANTY SO TOY WILL NOT PAY FOR FIX. NO ENGINE, NO STEERING, NO BRAKES, LOTS OF TRAFFIC...*AK.

RELATED TO: MOST OF THE VEHICLE WHICH HAD POWER SEATS ON THE PASSENGER SITE. LAST EVENING, I LAID MY CELL PHONE AND WALLET ON THE PASSEGER SEAT BEFOR I STARTED THE ENGINE, WHILE I WAS BACKING OUT FROM THE PARKING LOT, I MADE A SMALL TURN, THIS MOVEMENT CAUSED MY CELL PHONE AND WALLET SLIDED DOWN TOWARD THE RIGHT SIDE ENDED UNDER THE RIGHT SEAT. SO I STOPED THE CAR AND BENDED OVER THE RIGHT SIDE TO GET THEM OUT WITH MY RIGHT HAND, SINCE THEY WERE UNDER THE SEAT, I WAS NOT ABLE TO EVEN REACH THEM. THEN I USED MY LEFT HAND, TRIED REACH THEM FROM UNDER THE SEAT. GUES WHAT HAPPENED? SINCE MY RIGHT HAND STILL ON THE RIGHT SITE OF THE SEAT, IT ACCIDENTLY PUSHED THE SEAT MOVE FORWARD BUTTON, THE SEAT WAS MOVING FORWARD WHILE MY LEFT HAND STILL UNDER THE SEAT. BECAUSE THERE IS A MATEL OBJECT WAS UNDER, IT HURT MY LEFT HAND BADLY, LUCKILY I REALIZED I WAS PUSHING THE BOTTON, I RELEASED IT ON TIME, SO THERE'S NO SERIOUS INJURE. HAD I NOT RELEASE MY RIGHT HAND ON TIME, I WOULD HAVE GOT A REAL SERIOUS INJURY. SO PLEASE START SOME OF YOUR INVESTIGATION. IF POSSIBLE MAKE A RECALL RECOMMENDATION TO THOSE VEHICLE WILL CAUSE THE SAME SAFTY THREAD. THANKS. YAN FANG CAO

CONSUMER COMPLAINED ABOUT VEHICLE VIBRATING WHEN APPLYING THE BRAKES. CONSUMER REPLACED THE FRONT PADS AND BOTH FRONT ROTORS. WITHIN TWO WEEKS THE PROBLEM RECURRED. DEALER WAS CONTACTED. *AK

MY VEHICLE: 1999 TOYOTA 4RUNNER LIMITED W/ PORT INSTALLED AUTO DIMMING MIRROR THE + AND - WIRE THAT GOES TO THE AUTO DIMMING MIRROR WERE ACCIDENTALLY SHORTED ALMOST CAUSING A FIRE. HERE'S THE PROBLEM AS TO WHY IT'S A FIRE HAZARD: IT TURNS OUT THAT WHEN THE MIRROR WAS INSTALLED (EITHER PORT OPTION OR DEALER OPTION ON LIMITED'S AND SR5'S W/ SUNROOFS - NOT INSTALLED IN JAPAN), THEY JUST RAN A WIRE (ACTUALLY TWO - A GROUND AND A "HOT" WIRE MATED TOGETHER) DOWN TO THE DRIVER SIDE KICK PANEL AND "HOPPED" THE HOT WIRE ONTO A HOT LEAD OF THE POWER ACCESSORY CIRCUIT COMING FROM THE DRIVER SIDE DOOR. THIS CIRCUIT IS ON A 30 AMP SLOW-BURN FUSE. THIS CREATES A VERY DANGEROUS SITUATION IF THE WIRES TO THE MIRROR WERE TO CROSS SOMEHOW - AS THEY DID FOR ME. THE FUSE WILL NOT IMMEDIATELY BLOW AND THE WIRES CAN GET HOT ENOUGH TO IGNITE THE INSULATION OR SURROUNDING MATERIAL BEFORE THE SLOW-BLOW FUSE WILL EVENTUALLY BREAK THE CIRCUIT. THIS CAN TAKE AS LONG AS 10 SECONDS DEPENDING ON CURRENT AND HEAT GENERATED IN THE SLOW-BURN FUSE. *JB

GAS GAUGE GIVES A FALSE READING. I TRAVEL TO IOWA OFTEN AND I KNOW WHEN TO GET GAS SO THAT I CAN MAKE IT HOME. DURING ONE TRIP I STOPPED TO TO GET GAS AND NOTICED THAT THE GAS GAUGE INDICATE MORE GAS THAN I SHOULD HAVE. HAD I TRAVELED A DIFFERENT ROUTE AND RELIED ON THE GAUGE, I WOULD HAVE RAN OUT OF GAS AND GOT STRANDED, OR WORSE. MY CAR MIGHT HAVE DIED ON THE FREEWAY AND MIGHT HAVE CAUSED MAJOR ACCIDENTS. SOMETIMES IT TELLS ME I HAVE 3/4 FULL TANK WHEN IT SHOULD BE ONLY 1/4.*AK

EXPERIENCING SEVERE VIBRATION WHEN BRAKING AT SPEEDS OVER 50 MPH. STEERING WHEEL VIBRATES AND CONTROL IS DIFFICULT. IDENTIFIED AS WARPED ROTOR. TOYOTA DEALER WANTS TO CHARGE TO REPLACE FRONT CALIPER/ROTOR WITH LARGER DESIGN. CLAIMS THAT ITS COMMON TO HAVE IT FAIL SHORTLY AFTER WARRANTEE COVERAGE. (FAILED AT 50000, COVERAGE TO 36000) PURCHASED VEHICLE WITH 17000 MILES AND ROTORS/PADS LOOK GOOD.*AK

WHILE PULLING OUR 1999 4-RUNNER WITH 39,000 MILES INTO A PARKING STALL, THE BRAKE PEDDLE WENT ALL THE WAY TO THE FLOOR WITHOUT STOPPING, RESULTING IN A MINOR ACCIDENT WITH NO INJURIES. A SERVICE TECHNICIAN (NOT FROM TOYOTA) EXAMINED THE VEHICLE AND NOTHING UNUSUAL WAS OBSERVED. HOWEVER, DURING A ROAD TEST, THE PEDDLE WENT ALL THE WAY DOWN AGAIN WHEN HE ATTEMPTED TO STOP. HE PUMPED THE BRAKES AND THEY "CAUGHT" AND STOPPED THE VEHICLE. A TOYOTA DEALER HAS NOT BEEN ABLE TO DUPLICATE THE PROBLEM. A FIELD SERVICE REPRESENTATIVE FROM TOYOTA EXAMINED THE VEHICLE TODAY AFTER WHICH, WE WERE CALLED TO PICK UP THE VEHICLE. OTHER THAN A VISUAL INSPECTION AND ROAD TEST, TOYOTA HASN'T DONE ANYTHING. I DON'T BELIEVE THAT I SHOULD DRIVE THIS VEHICLE ON THE ROAD BUT THAT'S EXACTLY WHAT TOYOTA IS TELLING ME TO DO.*AK

WHILE DRIVING ON THE FREEWAY AT 65 MPH VEHICLE SUDDENLY SPUTTERED AND STALLED. CONSUMER'S VEHICLE WAS ALMOST REAR ENDED BY ANOTHER VEHICLE IN THE ONCOMING TRAFFIC, BUT CONSUMER WAS ABLE TO PULL OFF THE FREEWAY. DEALERSHIP INDICATED THE FAILURE WAS DUE TO A FAULTY SENDING UNIT IN THE FUEL TANK. IT WAS READING FULL WHEN THE TANK WAS EMPTY. *AK THE OLD STYLE SENDING UNIT WAS OBSOLETE AND NOT AVAILABLE. *SC

1999 4 RUNNER SR5. MY COMPLAINT IS THAT I HAVE HARD STARTING, INTERMITTENT (POOR, ROUGH) IDLE AND SOME TIME NOT IDLE. AT HIGH ELEVATION, I HAVE EXTREMELY POOR GAS MILEAGE. I HAVE HAD SEVERAL DEALER SERVICES INVESTIGATE THE PROBLEM. DEALERS WERE NOT ABLE TO ISOLATE PROBLEM. HOW I DEALT WITH IT OVER THE YEARS. NEVER USED THE VEHICLE OTHER THAN AT SEA LEVEL AND PUMP THROTTLE WHEN IDLE WAS NOT ABLE TO BE RETAINED. *JB

"THREW A ROD" WHILE HWY DRIVING. ENGINE SEIZED. ALL SCHEDULED MAINTENANCE ON TIME INCLUDING OIL CHANGES. LAST OIL CHANGE 2 MONTHS PRIOR. NO WARNING.

I BOUGHT A CERTIFIED USED CAR FROM A TOYOTA DEALER BACK IN SEP. 2002 FOR $24,000.THEY DIDN'T GIVE ME A MASTER KEY (MASTER KEY IS ONE OF THE INSPECTION POINT CHECK)AND THEY DIDN'T GIVE ME A CAR JACK.THEY TOLD ME THAT THIS CAR HAS NEVER BEEN IN AN ACCIDENT BEFORE.THE CHECK ENGINE LIGHT CAME ON JULY 10 2003 I LOOKED AT ENGINE AND UNDERNEATH THE CAR.I NOTICED THE POOR WORKMANSHIP ON FRONT AND REAR BUMPER,SOME MUDD GUARDS ARE MISSING AND THE VIN LABLES LOOKS LIKE IT WAS PEELED OFF BEFORE AND THE ONES ON THE DOORS AND HOOD DOESN'T LOOK AUTHENTIC.

THE TIRES WERE DISINTEGRATING AND CAUSED THE VEHICLE TO RIDE EXTREMELY ROUGH AND CHOPPY. *AK THE TIRES FELT LESS SMOOTH. FIRESTONE ADMITTED THAT THE TIRES FELT CHOPPY AND REFUSED REPLACEMENT. THE PROBLEM WORSENED AS TIME WENT ON. *SC *JB

INCONSISTENT FUEL GUAGE READINGS, CAUSING ME TO RUN OUT OF FUEL WHEN GUAGE READS 1/4 TANK. SINCE IT WASN'T A RECALL, BY THE TIME I FOUND OUT THAT THERE WAS A TECHINICAL SERVICE BULLETIN OUT, MY 1999 TOYOTA 4RUNNER WAS OUT OF WARRANTY, SO THEY REFUSED TO FIX IT UNLESS I PAID. I'VE BEEN LUCKY SO FAR THAT I HAVEN'T RUN OUT OF FUEL IN A HAZARDOUS SITUATION. I E-MAILED TOYOTA AND THEY STILL WOULDN'T GIVE ANY COMPENSATION, MY VIN WAS ON THE LIST OF VEHICLES THAT HAVE THIS PROBLEM, TSB EL010-00 FUEL GAGE INACCURACY ADRESSES. I SINCE FOUND OUT I WASN'T THE ONLY ONE WHO HAS HAD THE SAME EXPERIENCE DEALING WITH THEM ON THIS ISSUE. *AK

FUEL GAUGE GIVING ERRATIC READING. REPORTING EMPTY WITH 6 GALLON LEFT.

1999 TOYOTA 4RUNNER SUV PARKED IN A PARKING LOT FOR A FEW HOURS LOCKED WITH WINDOWS CLOSED. ELECTRICAL EVENT OPENED DRIVER WINDOW AND CAUSED SPONTANEOUS FIRE WHICH STARTED INSIDE PANEL OF DRIVER'S DOOR. *LA

AFTER THE VEHICLE WAS PARKED FOR OVER 4 HOURS THE ELECTRICAL WIRING INSIDE THE DRIVER'S DOOR CAUGHT ON FIRE. THIS FAILURE ALSO CAUSED THE ELECTRIC WINDOW TO ROLL DOWN INTO THE DOOR. THE CONSUMER MANAGED TO PUT THE FIR OUT. THE DEALERSHIP WAS NOTIFIED, BUT THE PROBLEM WAS NOT RESOLVED.*AK

CONSUMER STATES THAT WHEN HIT IN THE FRONT CENTER OF VEHICLE THE AIR BAGS DID NOT DEPLOY. DEALER NOTIFIED. *AK

WHILE DRIVING FROM BALTIMORE TO WASHINGTON D.C. ON I-95 SPD APPROX 65 MPH. MY 1999 TOYOTA 4RUNNER, STARTED SHAKING VIOLENTLY. SUDDENLY I HEARD A LOUD CRASH, THE CLUTCH PEDAL WENT TO THE FLOOR, AND I ALMOST LOST CONTROL OF THE VEHICLE. I CAUTIOUSLY MOVED THE VEHICLE OVER TO THE SHOULDER OF THE ROAD, AND COME TO FIND THAT MY TRANSMISSION HAD LITERALLY FELL OUT FROM UNDER THE 4RUNNER. EVEN THE TRANSFER CASE FELL OFF THE VEHICLE. I HAVE ALL OF MY MAINTANENCE RECORDS, AND THE TOYTA DEALERSHIP THAT SERVICED MY VEHICLE REFUSED TO TAKE RESPONSIBILITY, TELLING ME THAT MY VEHICLE WAS OK, THEN IT BREAKING. EVEN TOYOTA CORP. WILL NOT EVEN CONSIDER ANY ASSISTANCE HELPING WITH MY VEHICLE. WHAT SHOULD I DO?*AK