Filed May 6, 199613,545 vehiclesThomas Built Buses, Inc.
Defect. THE DOOR HINGES WERE NOT SHIELDED AND CAN SNAG EXITING CHILDREN'S CLOTHING OR ACCESSORIES.
Risk. WHEN A PASSENGER'S CLOTHING BECOMES CAUGHT IN THE HANDRAIL, AND THE BUS DRIVER CLOSES THE DOOR AND PUTS THE VEHICLE IN MOTION, THE INDIVIDUAL IS SUBJECT TO BEING DRAGGED BY THE BUS. THIS CAN RESULT IN SERIOUS INJURY OR DEATH.
Remedy. DEALERS WILL INSTALL HINGE PADS TO PREVENT THE SNAGGING OF PASSENGER'S CLOTHING.
Filed Mar 26, 19964,500 vehiclesThomas Built Buses, Inc.
Defect. PASSENGER'S CLOTHING CAN UNKNOWINGLY BECOME CAUGHT IN THE HANDRAILS AT BUS DOORS WHEN EXITING THE BUS.
Risk. WHEN A PASSENGER'S CLOTHING BECOMES CAUGHT IN THE HANDRAIL, AND THE BUS DRIVER CLOSES THE DOOR AND PUTS THE VEHICLE IN MOTION,THE INDIVIDUAL IS SUBJECT TO BEING DRAGGED BY THE BUS. THIS CAN RESULT INSERIOUS INJURY OR DEATH.
Remedy. REPLACE OR REPOSITION THE HANDRAILS TO STOP CLOTHING FROM BEING CAUGHT.
Filed Mar 29, 199387,000 vehiclesThomas Built Buses, Inc.
Defect. PASSENGERS CLOTHING CAN UNKNOWINGLY BECOME CAUGHT IN THE HANDRAILS AT BUS DOORS WHEN EXITING THE BUS.
Risk. WHEN A PASSENGER'S CLOTHING BECOMES CAUGHT IN THEHANDRAIL, AND THE BUS DRIVER CLOSES THE DOOR AND PUTS THE VEHICLE IN MOTION, THEINDIVIDUAL IS SUBJECT TO BEING DRAGGED BY THE BUS. THIS CAN RESULT IN SERIOUSINJURY OR DEATH.
Remedy. REPLACE OR REPOSITION THE HANDRAILS TO STOP CLOTHING FROM BECOMING CAUGHT.
Filed Jan 3, 19927,500 vehiclesThomas Built Buses, Inc.
Defect. THE CENTER ACTUATOR THAT RELEASES TWO CATCHES VIA TWO PULL RODS CAN BECOME NON-FUNCTIONAL FROM POOR OR IMPROPER MAINTENANCE, LACK OF LUBRICATION, CORROSION, OR A COMBINATION ALL THREE CAUSES.
Risk. WHEN THE CENTER ACTUATOR IS NON-FUNCTIONAL, THE WINDOWIS VERY DIFFICULT TO OPEN, AND WOULD NOT FUNCTION AS AN EMERGENCY EXIT IN CASEOF A VEHICULAR ACCIDENT.
Remedy. REMOVE THE OLD CENTER ACTUATOR AND INSTALL AN IMPROVED ACTUATOR.
Filed Oct 1, 1991407 vehiclesThomas Built Buses, Inc.
Defect. THE FUEL SHUT-OFF SOLENOID IN THE CUMMINS 6C ENGINE MAY BE FAULTY, CAUSING SPONTANEOUS INTERRUPTION OF FUEL FLOW TO THE ENGINE DURING NORMAL OPERATION. THIS RESULTS IN LOSS OF POWER TO DRIVING WHEELS, POWER STEERING, AND OTHER POWER ASSISTED OPERATING SYSTEMS.
Risk. LOSS OF ENGINE POWER AND SECONDARY LOSS OF POWER ASSISTEDSYSTEMS REDUCES STEERING CONTROL, BRAKING ABILITY, VISUAL SYSTEMS AND OTHERPOWER ASSISTED OPERATING SYSTEMS, RESULTING IN INCREASED RISK OF VEHICLEACCIDENT.
Remedy. WHERE NECESSARY, REPLACE THE SOLENOID SPRING, ADJUST SOLENOID, REPLACE WIRES, AND VERIFY MAXIMUM POWER REQUIREMENTS TO THE SOLENOID.
Steering › Linkages › Drag › Link › Connection91V159000
Filed Sep 12, 1991800 vehiclesThomas Built Buses, Inc.
Defect. THE STEERING LINKAGE (DRAG LINK) BETWEEN THE STEERING GEAR PITMAN ARM AND THE STEERING ARM ON THE AXLE MAY HAVE BEEN IMPROPERLY FASTENED.
Risk. THE DRAG LINK COULD BECOME DISCONNECTED AT EITHER ENDWHICH RESULTS IN LOSS OF STEERING CONTROL AND THE POTENTIAL FOR AN ACCIDENT.
Remedy. INSTALL CORRECT PINS AND PROPERLY TIGHTEN THE CASTELLATED NUTS.
Filed Apr 15, 19911,393 vehiclesThomas Built Buses, Inc.
Defect. DRIVER'S SAFETY BELT IS TOO SHORT TO MEET LENGTH REQUIREMENTS OF FMVSS 209.
Risk. SHORT SAFETY BELTS WOULD DISCOURAGE DRIVER FROM USINGTHEM. SEAT OCCUPANT NOT USING SAFETY BELT WOULD NOT HAVE ADEQUATE PROTECTION INCASE OF A SUDDEN STOP OR ACCIDENT.
Remedy. REPLACE THE BELT ASSEMBLY WITH A COMPLIANT VERSION.
Filed Nov 23, 19901,083 vehiclesThomas Built Buses, Inc.
Defect. THE SEAT DO NOT COMPLY WITH ENERGY ABSORPTION REQUIREMENTS OF FMVSS 222.
Risk. THE REAR FACING SEATS HAD ONLY ONE THIRD OF THE REQUIREDENERGY ABSORPTION; A PASSENGER USING THIS SEAT COULD BE INJURED IN A SUDDEN STOPOR AN ACCIDENT.
Remedy. INSTALL NEW FOLDUP SEATS WITH APPROPRIATE FASTENERS.
Filed Oct 4, 1990300 vehiclesThomas Built Buses, Inc.
Defect. THE COMBINATION OF TYPE 2 ELR SEAT BELT AND SUSPENSION TYPE DRIVER'S SEAT CAUSES SAFETY BELT CINCHING WHICH BECOMES SEVERE ENOUGH TO DISTRACT OR HINDER DRIVER FROM NORMAL OPERATION OF BUS.
Risk. DISTRACTION OF DRIVER COULD RESULT IN AN ACCIDENT.
Remedy. INSTALL SEAT BELT THAT INCORPORATES SOME ANTI-CINCHING FEATURES AND A NEW SET OF TETHER STRAPS FOR SUSPENSION SEAT.
No unusual pattern of severe incidents in the complaint record.
Complaint counts track how many cars were sold and how long they have been on the road as much as they track quality. A common model from 2013 has had a decade to accumulate reports; a rare one from last year has not. The signal worth weighing is in the severity columns, in whether the same component keeps appearing, and in whether the manufacturer eventually opened a recall for it.
Recall repairs are free for as long as the recall stands. Check whether a specific car still has open work at NHTSA's VIN lookup.
Most recent recall on file: May 6, 1996. Source: NHTSA Office of Defects Investigation.