2020 Tesla Model 3 complaints

We were driving back from suffolk virginia along [XXX] - which has two lanes in both directions. It was a sunny day with clear skies. I had cruise control enabled. There were no other cars visible on the road in either direction in front or behind us. Suddenly and without warning the car slammed on the breaks - "phantom breaking". If somebody was behind us it could have easily been a crash. We continued our journey somewhat shaken, and 10 - 15 mins later it did the same thing in similar circumstances. We contacted Tesla who said we should press a button to record an event when it happened again. On a later day it did and we sent them the information. They contacted us back and said that nothing was wrong with car. Since then I feel the cruse control is basically dangerous, so I refuse to use it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The 2020 and older models of the tesla has bad control arms an should be a recall they are charging us over $1,500 for an issue that happens to so many teslas

Hi there, it seems like a lot of model 3 Tesla owners year 2020 have been hit with a thousand plus dollars repair for the super bottle that controls the HVAC. Some at 37,000 miles. It looks like Tesla knows this is a faulty part they will cause issues. Thus they limit the warranty to 4 years only or 50,000 miles whichever comes first. Most cases was the four year warranty that runs out and the very next month we have issues with the super bottle replacement. It looks like they have now it started making a more sturdy part. So for us with older models we are hit with expensive repairs. If you do not change the super bottle the car drives on very limited speed limits which can be dangerous if you need to make a quick fast maneuver. Basically you're not able to drive the car anywhere but only to your neighborhood grocery store!! Not only that if you do not fix the car quickly it will start damaging surrounding parts costing you even more. I'd like to know if there is a possible recall that Tesla would cover the cost.

When the seat moves forward I get a warning about the restraint error and turn the airbag off. When I slide the seat back the error goes away.

I am reporting a critical safety incident involving my vehicle, which occurred during rush hour on a busy highway with no traffic lights or stop signs. While waiting in the left turn lane at a center divide, my emergency autopilot braking system activated unexpectedly, causing my car's left front side to encroach into oncoming traffic. Despite my attempts to move the car, it became immobile. I attempted to reset the car by turning it off and on, but the vehicle’s computer system malfunctioned entirely. With oncoming traffic traveling at speeds of 70 mph, I had no choice but to exit the vehicle for safety. I left the car in the center divide. This incident was extremely frightening, and I am deeply concerned about the potential dangers posed by the malfunctioning autobraking system. Thank you for your attention to this serious matter.

Concern: message appeared on the tesla screen "DIR_a126 Power reduced" Repair solution: Internal seal in battery coolant bottle was faulty and not letting coolant flow properly to rear drive unit. Tesla warranty: states that battery coolant does not need to be replaced for the life of the vehicle.

Passenger seat occupancy sensor malfunction which sometimes turns off passenger airbag even though adult passenger is sitting in the seat. Possible no airbag deployment upon crash. Car was brought into service center and sensor was replaced but same issue popped up again 2 yrs later. Car is out of warranty and service center refused to look at the car without first charging $1k. Intermittent airbag light, intermittent passenger airbag off indicator even with adult in seat and seatbelt on.

While driving I attempted a turn and heard many horribly loud clunking noises and was unable to steer car. I looked under the front of the car and saw the left front tire turned to the left (the right front tire was straight) and there was a piece on the ground which was determined to be the lower control arm. The two bolts were missing so it became disconnected. Thankfully I was in a parking lot at a slow speed so no injuries. The car was towed to a repair shop who analyzed the problem. There was no warning given on the car’s computer system, just sudden loud clunking sounds when the car became inoperable. One day later I located one of the two bolts in the driveway.

A few months ago after an update, my turn signal functionality was completely replaced by AI. This results in me driving either with the blinker engaged when I don’t want it to be, or not engaged when I want it to be. To correct the usually incorrect AI is distracting, and often causes even more incorrect blinker usage. I find this to be dangerous.

Received several "Steering Assist Reduced" alerts when stopped in traffic last week, followed immediately by the failure of the power steering after each alert. Power steering resumed after a soft restart. Tried to make appointment at Tesla Service Center last Friday to get this addressed, but they said they had no appointments available and would not be able to diagnose my vehicle until today, August 12, 2024.. In the interim, the power steering went out again while on the freeway, forcing me to exit and restart the vehicle again. This is a clear danger to myself and my passengers. After receiving the results of the diagnosis today, they informed me that both the steering rack and harness would need to be replaced at the cost of nearly $5,000. The technician showed me some corrosion in one of the electrical connections where there had been water intrusion. I told him this was surprising since the car is relatively new and it would seem that Tesla would have sealed this connections to resist the relatively dry rainy seasons we experience here in Southern California.

The contact owns a 2020 Tesla Model 3. The contact stated that on several occasions while driving with the cruise control feature activated at various speeds, the brakes applied inadvertently. The contact also stated that the cruise control feature failed to operate as intended after dark, after deactivating inadvertently. Additionally, the contact stated that the front and rear cameras displayed phantom images and failed to work as intended. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Safety restraints are malfunctioning

I have taken my vehicle into Tesla to have the issue fixed twice. They don't know what's happening or how to fix it. My car is randomly taking the wheel and steering me into other cars / off the road. It happens once a month or so, I have a newborn baby I drive in the car and I don't feel safe driving. I've recorded the incident and Tesla Service said "that should not be happening unless I'm using auto pilot" which I never do. I've looked into lemon law but I did not purchase the car from tesla directly, I bought it from a used car dealership. I'm not sure what to do, I can't sell the car because I would still owe $10,000 after the sale. Please help anyway you can, I'm desperate for anything.

Found the front body controller to be internally faulted

While driving on cruise control at highway speeds (75-80mph) on I-80 the car braked VERY hard and unexpectedly MANY times. There were no other cars around me, weather clear, road straight. No obstacles noticed to cause this reaction. If a car had been behind me I would have caused him to rear-end me because there was no apparent reason for the severe braking. I reported four incidents of this type to the Tesla during the drive which I believe were date/time stamped so they could diagnose (using the "report" function). I matched these with my own observations which I also provided to the service department. I have had the car diagnosed by Tesla and they claim they could not duplicate the problem and/or fix the problem.

Got a front passenger safety restraint system fault issue that Tesla wants me to pay for repair.

Driving at highway speed (75 mph) using Autopilot & car rapidly applied hard braking. There were no obstacles, shadows or anything visible that should have caused this. It occurred twice over two days in different locations. If anyone had been behind me too close they would have collided with me. No other vehicle I’ve owned have done this with their implementation of adaptive cruise & lane assist. My car used to use radar and I never had this issue until vision based detection was implemented. It’s occurred numerous times over the years, but no this rapid of braking.

The Tesla is reflecting an error “DIR_a126” that is reducing the speed below the speed limit and with no rhyme or reason. Tesla services are not available and the problem is intermittent. Additionally, based on research it is found to not have consistent resolutions and reasonings

I was traveling on autopilot in left lane with autopilot engaged on 06/13/2024 on HW 101 at around 9:40am my car all of the sudden slammed on brakes and dropped speed from around 65mph to 30mph before I was able to react and recover speed. Reached out to Tesla on their app about this and they are sending me estimate of $275 to check it out

Front passenger safety restraint system fault error Received. Airbag icons appeared and apparently safety airbags disabled. No passengers were sitting when error received. Contacted Tesla to report safety concern and was advised charges were due to vehicle outside of 50k warranty. Is safety equipment only valid to work under the warranty?

An alert stated: "RCM_a056 Front passenger safety restraint system fault." Upon bringing car to Tesla service center, Tesla stated: "Confirmed concern through vehicle logs. Found vehicle needing passenger ocs retrofit to resolve issue. Customer declined repair." They wanted over $1,200.00 for a faulty seat sensor because they claimed they couldn't replace the seat sensor without replacing the entire airbag system on the passenger side. They explained to me that they changed the airbag systems in their newer Model 3s and refused to stock or replace components in their older Model 3s.

Subject: Non-Functional Left Rear Tail Light Due to Condensation Build-Up in Tesla Vehicle Dear NHTSA, I am writing to report an issue with my Tesla vehicle concerning the left rear tail light. The tail light has stopped functioning, and I believe this failure is due to condensation build-up within the light assembly. When I previously reported the condensation to Tesla, I was informed that it was normal and not a cause for concern. However, it now seems that this persistent condensation has led to the failure of the tail light. This issue raises significant safety concerns, as fully functional tail lights are essential for safe driving. *Especially during automated self-driving which disregards the alert of a nonfunctional tail light. * I am seeking your assistance in addressing this problem and ensuring that it is properly investigated. I am concerned that other Tesla owners might experience similar issues, which could compromise vehicle safety. Thank you for your attention to this matter. I look forward to your guidance on the next steps. Sincerely, [XXX] [XXX] VIN: [XXX] --- INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My car is experiencing a passenger seat safety restraint error, which is a safety issue.

An error 'Front passenger safety restraint system fault' came up that seems to be a very common issue with someone people paying $1500 to nothing to fix.

I have had an Alert notification, and reading through online, it seems there might be a consistent issue. Alert Notification: RCM_a056 Front passenger safety restraint system fault

Upper control arm is creaking, extremely common problem, we need to demand a recall

For the fourth time the seat sensor has failed in the driver seat. when the seat sensor fails the car no longer auto connects blue tooth media play from the phone but also no longer detects an occupant in the vehicle. this causes the vehicle to go in to park while driving at low speeds without a seat belt, i.e. moving the vehicle in the garage, and it also prevents the car from recognizing when the occupant has left the car and leaves it powered on the whole time. the first three times they repaired it under warranty and it has not failed for the fourth time in four years. I have asked if the sensor function can be deactivated and they said that it can not and needs to be continuously replaced. the service representative told me that the item is secured by adhesive and getting in to and out of the car can cause it to bend and kink which is what happened to mine - and he also said given the heat in Florida its understandable the adhesive wont stick.

At 04/12/2024 7:17pm EST the alert "Steering assist reduced. Steering may require increased effort" appeared while driving and remained for the duration of the drive. In the event log this was listed as "UI_a020 Steering assist reduced". The alert disappeared after the car was parked for a while and restarted. This alert also occurred multiple times earlier in the year (and mentioned when the car was brought in for an unrelated service issue) but I had not recorded the date and time so Tesla was not able to capture a log. It eeappeared on two occasions after 4/12, including once on 4/19/2024 at 6:47pm EST. In some, but not all instances, the steering wheel did require considerably more force to turn after the alert appeared. I scheduled a service request with Tesla on 4/13/2024 (for a service date of 4/24/2024) and received a repair estimate on 4/18/2024 with a remote diagnosis. The repair suggested was a steering rack replacement. I dropped off the car at the service center on 4/24 but because of a shipping delay on the part, the repair was completed Tuesday 4/30. I am attaching the initial estimate as well as the final invoice from Tesla.

I was burned on back and buttocks by Tesla car seat warmer

There is an issue with the front passenger restraint safety system. I got a warning that I need to replace the Occupant Classification System (OCS) of Front Passenger Seat due to faulty wiring.

I am writing to express my concern regarding the recurring issue with the control arms and sway bar in the 2020 Tesla Model 3. It has come to my attention that Tesla acknowledges this issue, which manifests as creaking sounds during various driving conditions such as climbing into the car, traveling at low speeds, and navigating over speed bumps or uneven terrain. What's particularly troubling is that when I brought my car into them Tesla acknowledged that they are aware of the prevalence of this issue across many of their vehicles, yet they continue to charge consumers for repairs, even if their vehicle is not included in the recalled VINs. This policy unfairly burdens consumers who experience the same issue but are denied coverage under the recall. I urge the NHTSA to investigate this matter thoroughly to ensure consumer protection and fairness in addressing safety concerns in Tesla vehicles. It's essential that manufacturers uphold their responsibility to rectify known issues without imposing undue financial burdens on consumers.

The door handles on the chrome version of the Tesla Model 3 begin to delaminate after several years of use. They delaminate along the door handle seam which creates an extremely sharp edge that can cut fingers. I've had the rear handle on my own model 3 rear door cut my kids finger when they tried to get into the back seat. Because the car is technically out of warranty Tesla will not cover repair without significant cost. There is no warning sign or notification other than when you reach to pull the handle and the sharp chrome edge cuts you, the one door with this issue now has the handle partially protruding since the handle can no longer sit flush. There are several threads where similar chrome version model 3 owners have had the exact same issue occur with the exact same safety risks. Tesla has only repaired the ones that fell under factory warranty. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Front subframe assembly broken Turn signals don't register input Lateral and compliances links broken

My vehicle is 4 years old. 3 weeks after the expiration of my original warranty, the front suspension now squeaks loudly when driving at low speeds. This issue matches the known manufacturing defect described in Tesla’s 2021 service bulletin, “Reseal Front Upper Control Arm Ball Joints.” We never received this bulletin from Tesla, and we were never given the option of resealing the joints. As a consequence, the ball joints have now failed and both upper control arms must be replaced, at a cost to me of $330. I asked if Tesla can waive these repair costs due to the bulletin and widespread manufacturing defect, but Tesla declined, stating: “Your vehicle is not listed as an affected VIN for this bulletin. In order for a repair bulletin to be covered under the vehicle warranty the condition has to be reported within the warranty period. Once no longer under warranty, it is not covered.” Even though my VIN was not included, clearly it should have been since the ball joints have failed. Also, if this is a known car defect, why should it matter when the problem starts to appear in order for Tesla to take full responsibility and fix it? They are shifting costs to consumers for their own, known, widespread manufacturing defects. Additionally, if I had been informed about the bulletin in 2021, resealing the joints at that time would have been easier & far cheaper than replacing both arms now. It’s my understanding that Senators Markey (MA) and Blumenthal (CT) expressed concern that thi

I took delivery of this Tesla Model 3 last month and have been using it often for my commute. Tesla’s “Traffic Aware Cruise Control” is dangerous and has put my life at risk multiple times now when driving on the highway at night. It slams on the brakes as if it is about to crash when nothing is ahead. It also slammed the brakes when passing a semi truck that was accelerating from being stopped on the shoulder. If anyone was behind me, they would have crashed into me. This “phantom braking” only happens at night. I would disable it immediately but it is not able to be disabled! This is the most frustrating part. I have a long commute on the interstate at night and really need cruise control, and now I am constantly worried when commuting that the car will slam the brakes. The fact that I can’t revert to an old fashioned cruise control with no sensors and no cameras is absurd and extremely dangerous. What component or system failed or malfunctioned, and is it available for inspection upon request? I don’t believe anything “failed”. I believe Tesla’s software is not ready for the real world and this “traffic aware cruise control” should be a beta feature that drivers can use at their own risk. How was your safety or the safety of others put at risk? Unexpected, random slamming of the brakes at highway specs on the interstate at night. In all situations that the “phantom braking” has happened, I would have been rear ended if someone was following behind me. Has the problem been

Front passenger safety restraint system fault

A crack appeared on the interior of the windshield, with no marks of any exterior impact and no external crack or other mark on either surface of the windshield. The crack originated directly from the windshield positioned camera/rear view mirror.

I AM STILL WAITING FOR TESLA TO MAKE THIS REPAIR. I HAVE CONTACTED A SERVICE CENTER SEVERAL TIMES AND TRIED TO MAKE AN APPOINTMENT ONCE. TESLA CANCELLED THE APPOINTMENT AND KEEPS TELLING ME THEY HAVE NOT RECEIVED THE PARTS TO MAKE THE REPAIR. IT HAS BEEN OVER A YEAR AND A HALF SINCE TESLA ANNOUNCED THE RECALL AND IT HAS FAILED TO REPAIR MY CAR. MY UNDERSTANDING IS THAT THE HARNESS CAN SHORT OUT AND CAUSE A FIRE.

I received a message on the screen saying there was a problem with the OCS and that it needed to be serviced immediately. I take it to Tesla service and they tell me they will need to do the following: 1. Replace MODULE - OCS FILTER 2. Retrofit SBR in OCS Equipped Front Passenger Seat - Remove and Replace 3. Replace FIRST ROW SEAT HARNESS 4. Replace FIRST ROW - SEAT BELT REMINDER SENSOR BOX CLIP 5. Replace FIRST ROWOCCUPANCY SENSOR 6. Replace FIRST ROWHARNESS ASSEMBLY -OCCUPANTCLASSIFICATION SYSTEM - RIGHTHAND 7. Replace Front PassengerAirbag And Update VehicleConfiguration - Remove and Replace To have all of this done, I paid $1,850. Nothing is covered under warranty. I have 64,000 miles on my car. It has never been in a wreck and I have taken good care of it. From what I understand, this is a common problem with Tesla’s.

Many Tesla owners have received notifications about a "Front Passenger Safety Restraint System Fault". It seems that there might be a defect with the car, given the number of people impacted and the severity of not having proper safety restraint. I am very careful with my car, and it has not been involved in any accidents, so I think Tesla should do a recall to make sure all Front Passenger Safety Restraint System is functional

After receiving fault RCM_a094 I discovered that the seatbelt wiring harness had detached. When I took the vehicle in for repair, I was told it was caused by the wire being "tugged" on. Since I have never used the seatbelt in any capacity other than how it was intended, I believe this is a design flaw with the restraint system.

I had done a software update and my horn no longer works. Also the 2 steering wheel buttons don’t work anymore.

1.) Steering wheel,yes. 2.) I lost steering at 50 MPH with my twp daughter in backseat. 3.) Car was towed BACK to Tesla (it eas there 3 days ago for 2 front upper control arms replacement) 4.) car not inspected by anyone other than Tesla. 5.) yes 2 warnings “steering assist reduced”and “lane departure disabled”.

Braking and Stopping - Braking system - Improperly functioning braking systems. I experienced a problem with the brake pedal, brake calipers, and/or any component of a Model 3 braking system. “Model 3 has an anti-lock braking system (ABS) that prevents the wheels from locking when you apply maximum brake pressure. This improves steering control during heavy braking in most road conditions…Forward Collision Warning and Automatic Emergency Braking do not operate when driving at very low speeds (see Collision Avoidance Assist on page 128). Do not rely on these features to warn you, or to prevent or reduce-the impact of a collision. (Tesla owners Manuel71-73) I stop on a downward slope with my foot on the brake to wait for a gate to open in my apartments. I let go of the brake and the vehicle remained steady until it started rolling. When it started rolling, I jam my foot on the brake but the brake is engaged (locked). The vehicle accelerates, the brakes and steering wheel is locked giving no control over the vehicle. The vehicle drives through the gate and into a wall. The airbags deploy and I get out immediately for caution of explosion and shock. I call a tow truck and made a claim with USAA. I got a concussion and multiple injuries on my body. I’ve been getting medical treatment for 6-8 months. USAA didn’t help as they deemed the accident was my fault and totaled the vehicle. I bought the vehicle for more than what’s it’s worth. I have loan payment that I can NOT pay. This wa

I received a software update from Tesla which caused my car to display wanting signals that would beep repeatedly while my car was parked and while driving. The on screen messages stated “Gear Box Fluid Recommended” and “Adaptive Air Suspension Needs Service”. When I reached out to Tesla they told me to not worry about those alerts because a bug in their software update caused the issue and I did not actually require those services. They admitted that they were aware of this bug and that I was not the only customer experiencing this issue. They gave me two options. Either schedule a service appointment or wait until the next software update. I scheduled an appointment because I could not drive my vehicle safely with alerts beeping every second that I was driving. A software update appeared on my screen before my appointment and it seemed to fix the problem for about 24 hours. The next day I woke up to my screen being black and the car not being responsive or displaying any information. This caused a major concern because I could not even tell how fast I was driving. The car is still driveable. I just have no information or access to any functions of the vehicle. So I scheduled another appointment with Tesla. Who determined the entire computer system needed to be replaced. Since my car is out of warranty they want me to pay out of pocket. I do not believe this is a responsibility of mine since the software update is what destroyed my computer. Tesla is responsible for making s

In March 2023, my vehicle was in a major front end collision on the passenger side and the airbag did not deploy. In January 2024, a warning light appeared on my car’s screen that reads “Safety Restraint System Fault” I then took the vehicle to a Tesla service center who determined that the front passenger airbag and OCS needed to be replaced to maintain compatibility….

My Model 3 intermittently has the steering wheel locked in position, which sometimes resolves temporarily after rebooting the car. I always get a steering assist reduced error on the car, regardless of rebooting. It also no longer has lane keep capabilities or Autopilot, which involve the car automatically moving the steering. I have not gotten this inspected by a dealer or service center. The issue first appeared yesterday, after I tried to pull out of a parking lot, but I had trouble since my wheel would not turn. I will be going to a service center next week. After the errors began, I have not meaningfully driven the car, since locking of the wheel while driving is very dangerous. A handful of errors showed up on the screen (Cruise Control disabled, Traction Control Disabled, Stability control disabled, Steering assist reduced), and I did not have any regenerative braking applying. I returned safely to my parking spot. After multiple reboots of the car (pressing both wheel buttons), I found that sometimes after putting my car into Drive, my steering wheel was locked. Other times, I could turn my steering wheel without issue, but I would always receive the Steering assist reduced error.

The ac and window defroster stopped working. I got it fixed and it was because of a loose connector. I added supporting document below. They said it might be because of vibration.

Issue with heater and cooler where it suddenly stops working. Not even fan turns on. It makes the car unsafe to drive and transport a baby. This is a kwon issue

Since the recall for Autopilot / Full Self Driving which required driver alerts (often called steering wheel nag), the alerts are now so frequent and reoccuring that it forces you to stare at the screen and not the road. If you look at the road, both hands on the steering wheel, every few seconds, as little as 10 seconds since the previous, the screen begins to flash (only at the top) indicating that you must now slightly shift your hands. These are often hard to see unless you stare at the screen and give no other noticable indicator. Recently I was just awarded a strike for not adjusting to it, about 30 seconds after the previous indication and it had no audible sound or indication the only warning apparently was a visual one. The screen is not in front of the driver like a heads up display, its off to the side. Other vehicles warn you not to use the on screen displays while driving, even tesla, so why does this feature force you to stare at the screen your entire drive. It seems unsafe to force -constant- checks of the screen from the driver to determine if you're in autopilot compliance.