2008 Suzuki GSX1300R

Defect. Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2008-2012 AN400, AN400A, DL1000, GSX1300R, 2008-2009 GSF1250S and GSF1250SA, 2008 GSX1300BK and GSX1300BKA, 2008-2010 GSX650F, GSX-R600, GSX-R750, VLR1800, VLR1800T, and 2009-2010 SFV650 and VZ1500 motorcycles. Due to a problem with the circuit board for the regulator/rectifier power module, the motorcycle may not sufficiently charge the battery and the motorcycle may stall.

Risk. If the engine stalls while riding, there would be an increased risk of a crash.

Remedy. Suzuki will notify owners, and dealers will replace the regulator/rectifier, free of charge. The recall is expected to begin March 4, 2016. Owners may contact Suzuki customer service at 1-800-444-5077. Suzuki's number for this recall is 2A56 to 2A64.

Defect. Ohlins Racing AB (Ohlins) is recalling certain steering dampers kits manufactured with an incorrectly machined bracket. These dampers were sold for use as aftermarket equipment on Yamaha R1, R6, and FZ6, Suzuki TL1000 R and GSX1300R, Honda CB600RR, and Ducati Monster 1000, 748, 848, 916, 996, and 998 motorcycles. Also included are universal steering damper kits with part numbers SD 000 through SD 005. The affected brackets may crack.

Risk. If there is a crack in the steering bracket, at low speeds it may cause the steering to lock, leading to personal injury or a crash.

Remedy. Ohlins will notify the distributors and provide their customers with a new bracket. The recall began in November 2013. Owners may contact Ohlins USA at 1-828-692-4525. Note: This recall is an expansion of recall 13E-034.

Defect. SUZUKI IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 MOTORCYCLES MANUFACTURED FROM JULY 2007 THROUGH SEPTEMBER 2009, EQUIPPED WITH REGULATOR/RECTIFIER ASSEMBLIES, SUZUKI PART NUMBERS 32800-41F11, 32800-15H10, 32800-05H11, 32800-41G10, 32800-15H00, 32800-18H00, 32800-05G10, 32800-10G10, 32800-05H20, OR 32800-06G01. SOME REGULATOR/RECTIFIER ASSEMBLIES WERE PRODUCED WITH INSUFFICIENT ADHESION BETWEEN THE POWER MODULE (CIRCUIT BOARD) AND THE RECTIFIER CASE THAT CONTAINS A HEAT SINK TO DISSIPATE HEAT. DUE TO INSUFFICIENT ADHESION, HEAT GENERATED ON THE POWER MODULE CIRCUIT BOARD CAN CAUSE THE CIRCUIT BOARD TO DEFORM, AND LIFT OF THE CASE.

Risk. THIS CONDITION CAUSES EXCESSIVE HEAT ON THE CIRCUIT BOARD AND UNCONTROLLED ELECTRIC CURRENT OUTPUT, WHICH CAN RESULT IN INSUFFICIENT CHARGING CURRENT BEING PROVIDED TO THE MOTORCYCLE BATTERY. THIS CAN CAUSE DISCHARGE OF THE BATTERY AND CAN LEAD TO ENGINE STALLING AND/OR A NO-START CONDITION. ENGINE STALLING WHILE RIDING CAN INCREASE THE RISK OF A CRASH.

Remedy. SUZUKI WILL NOTIFY OWNERS AND SUZUKI DISTRIBUTORS WILL REPLACE THE REGULATOR/RECTIFIER WITH AN IMPROVED PART FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 2, 2011. OWNERS MAY CONTACT SUZUKI AT 1-714-572-1490.

TOOK MY MOTORCYCLE IN DURING THE INITIAL IN 2008. INSPECTION, NOTHING DONE.JUNE 22,2016 MADE A RIGHT TURN TO GET ON EXPRESSWAY, THE ENGINE DIED.TOWED THE BIKE HOME, TEST BATTERY ALL OK. WIGGLED THE WIRE COMING FROM THE IGNITION AND THE BIKE STARTED.SUZUKI AND THE DEALER REFUSE TO FIX THE RECALLED DEFECTIVE PART. THERE APPERASTO BE A SHORT IN THE WIE COMING FROM THE IGNITION.

I RECEIVED A SAFETY RECALL LETTER FROM SUZUKI,AND THEIR DISTRIBUTOR SUZUKI DEL CARIBE,INC. AROUND FEB/2010, THE SAFETY RECALL ID #79259 , DURING THE SAME MONTH AND YEAR 02/2010, I TAKE MY MOTORCYCLE TO THE SUZUKI PREMISES IN PR AND THEY REPLACED THE RECTIFIER, THEN AFTER A YEAR I TAKE THE MOTORCYCLE BACK WITH THE SAME PROBLEM,THEY REPLACED,THEN ABOUT MONTH AGO,THE REPLACEMENT PART FAILED AGAIN,NOW SUZUKI,ESTABLISH THAT MY MOTORCYCLE IS NOT UNDER SAFETY RECALL CAMPAIGN,AND REJECT TO REPLACE THE PART IN QUESTION,I HAVE MADE SEVERAL ATTEMPTS BUT THE RESULTS HAVE BEEN FRUITLESS,PLEASE I ONLY WANT THAT THE DEFECTIVE PART BE REPLACE.

TL*THE CONTACT OWNS A 2008 SUZUKI GSX 650FS (NA). WHILE DRIVING LESS THAN 50 MPH AND ATTEMPTING TO SWITCH FROM FIFTH TO SIXTH GEAR, THE VEHICLE DID NOT ENGAGE. THE CONTACT HEARD A LOUD CLUNKING SOUND. THE REAR TIRE LOCKED AND EJECTED THE OCCUPANT FROM THE VEHICLE. THE CONTACT SUSTAINED INJURIES TO HIS ELBOW, WHICH REQUIRED STITCHES, IN ADDITION TO BACK INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT IS STILL AWAITING A DIAGNOSTIC. THE FAILURE AND CURRENT MILEAGES WERE 2,188.

WHEN RIDING AT A STABLE SPEED, MOTORCYCLE WILL LOSE POWER AND SPEED WITH NO CHANGE IN THROTTLE POSITION. THIS OCCURS IN 3RD THROUGH 6TH GEAR, 6500-7500 RPMS, IN SPEEDS RANGING FROM 30-75 MPH. THIS PROBLEM RESULTS IN A DECREASE IN SPEED FROM 3-6 MPH BEFORE BIKE RECOVERS. UPON RECOVERY, BIKE WILL JERK FORWARD, CAUSING A VERY UNSAFE INCREASE IN SPEED. WHEN THIS HAPPENS WHILE TURNING OR TRYING TO TAKE EVASIVE MEASURES, IT AMOUNTS TO A VERY SERIOUS SAFETY ISSUE. THIS OCCURS ON THE 2008 SUZUKI GSXR-600. *TR

WHEN RIDING AT A STABLE SPEED, MOTORCYCLE WILL LOSE POWER AND SPEED WITH NO CHANGE IN THROTTLE POSITION. THIS OCCURS IN 3RD THROUGH 6TH GEAR, 6500-7500 RPMS, IN SPEEDS RANGING FROM 30-75 MPH. THIS PROBLEM RESULTS IN A DECREASE IN SPEED FROM 3-6 MPH BEFORE BIKE RECOVERS. UPON RECOVERY, BIKE WILL JERK FORWARD, CAUSING A VERY UNSAFE INCREASE IN SPEED. WHEN THIS HAPPENS WHILE TURNING OR TRYING TO TAKE EVASIVE MEASURES, IT AMOUNTS TO A VERY SERIOUS SAFETY ISSUE. THIS OCCURS ON THE SUZUKI GSXR-600, NOT THE GSXR-1300R BUT THERE IS NO WHERE TO DESIGNATE THIS ON THE FORM. *TR

MY MOTORCYCLE STARTED MAKING LOUD ENGINE NOISES AT AROUND 900 MILES. I TOOK IT TO THE DEALER WHERE I PURCHASED IT TO HAVE IT LOOKED AT. THE MECHANIC HEARD THE NOISE AND THOUGHT IT MAY BE THE CAM CHAIN. THEY REPLACED THE 2ND AND 3RD GEAR BEARINGS, PUT THE BIKE BACK TOGETHER AND IT WAS STILL MAKING THE LOUD ENGINE NOISE THAT I TOOK IT IN FOR. THE DEALER TOLD ME TO TAKE THE BIKE, RIDE IT AND THEY WOULD HAVE ME BRING IT BACK WHEN THE REPRESENTATIVE FROM THE COMPANY CAME TO LISTEN AND LOOK AT THE BIKE. I TOOK THE BIKE HOME FROM THE DEALER AND THE ENGINE BLEW UP ON MY WAY HOME. I HAD TO PUT MY LEG DOWN TO AVOID LAYING THE BIKE DOWN AND INJURED MY KNEE. THE DEALER CAME TO PICK UP THE BIKE AND A REP. FROM THE COMPANY CAME TO LOOK AT THE DAMAGE BUT THEY REFUSE TO FIX THE PROBLEM EVEN THOUGH IT IS UNDER WARRANTY AND IT WAS A MONTH OLD WHEN I STARTED HAVING THE PROBLEM. I HAVE BEEN GOING BACK AND FOURTH WITH THE DEALER AND COMPANY THAT MADE THE BIKE AND HAVE HAD NO RESULTS. *THE BIKE IS A SUZUKI GSX-R 750. IT DID NOT GIVE ME THAT OPTION IN THE MODEL SECTION OF THIS COMPLAINT. *TR

THE PROBLEM HAS BEEN LABELED THE HERKY JERKIES. WHILE RIDING AT ANY RPM WHEN THE REAR WHEEL SPEED MATCHES ENGINE SPEED THE THROTTLE SHUTS OFF ABRUPTLY WITH NO WARNING, THROWING YOU FORWARD OVERLOADING THE FRONT WHEEL. WHEN THE WHEEL SLOWS ENOUGH THAT THE ECU CALLS FOR FUEL IT DELIVERS A LARGE AMOUNT OF FUEL AND THE BIKE JERKS FORWARD UNLOADING THE FRONT WHEEL CAUSING AN UNRECOVERABLE FRONT WHEEL SLIDE (WHILE LEANED OVER IN A TURN). THERE IS A LARGE AMOUNT OF PEOPLE INCLUDING MYSELF WORKING ON THE PROBLEM, WE HAVE DISCOVERED WAYS TO MASK THE PROBLEM BUT NO RESOLUTION TO DATE. SUZUKI HAS RECEIVED MANY COMPLAINTS AND IS NOT DOING ANYTHING ABOUT IT. I HAVE CALLED IN NUMEROUS TIMES STARTING SOME TIME AROUND MARCH. I HAVE BEEN WORKING WITH PEOPLE ON GIXXER.COM IT'S A FORUM FOR GSX R OWNERS AND THERE ARE MANY THREADS CONCERNING THIS ISSUE. I / WE ARE HOPING THAT YOUR ORGANIZATION WILL BE ABLE TO SOLICIT A RESPONSE FROM SUZUKI, SEEING AS THOUGH THEY ARE IGNORING US. THIS IS A VERY BIG PROBLEM AND CAN LEAD TO MANY MOTORCYCLE CRASHES...SEEING HOW IT HAPPENS SO FAST...IF THIS HAPPENS IN A TURN WHEN THE BIKE IS AT A LEAN THE RIDER WILL GO DOWN AND NO ONE WANT TO SEE A FELLOW RIDER GET HURT BECAUSE OF BIKE ERROR THAT COULD HAVE BEEN PREVENTED. *TR