2002 Subaru Legacy

Defect. Airtex Products LP (Airtex) is recalling certain model E8598M, E8518M, E8600M, E8596M, and E8597M fuel pumps manufactured July 26, 2013, and July 29, 2013 and used as aftermarket replacements on Subaru Baja's, Outback's and Legacy's. The affected fuel pumps were sold or installed into the aftermarket applications on or after July 26, 2013, and may may leak fuel from the base of a fuel line connection when the gas tank is full.

Risk. A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy. Airtex will notify owners, and will replace the fuel pump, free of charge. Recall is expected to begin on January 2, 2014. Customers may contact Airtex at 1-800-880-3056. The recall is expected to begin during January 2014. This recall is being conducted by Airtex, not by Subaru.

Defect. ON CERTAIN PASSENGER SEDANS, WAGONS, AND SPORT UTILITY VEHICLES, THE CRUISE CONTROL CABLE COULD COME OUT OF ITS TRACK ON THE CRUISE CONTROL LEVER AND LODGE ON THE CONTROL LEVER TAB WHEN THE ACCELERATOR PEDAL IS RELEASED. IF THIS CONDITION OCCURS, THE THROTTLE WILL NOT RETURN TO THE IDLE POSITION AND WILL REMAIN IN AN OPEN POSITION.

Risk. IF THIS OCCURS DURING VEHICLE OPERATION, THE DRIVER COULD LOSE CONTROL OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.

Remedy. DEALERS WILL INSTALL A CRUISE CONTROL CABLE RETAINING CLIP TO THE CRUISE CONTROL LEVER TAB ON THE THROTTLE SHAFT IN ORDER TO PREVENT THE CRUISE CONTROL CABLE FROM COMING OUT OF ITS TRACK. OWNER NOTIFICATION BEGAN ON APRIL 12, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783.

Defect. THIS RECALL APPLIES TO CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. CERTAIN REAR SUSPENSION SUBFRAME COMPONENTS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE ROAD SALTS FOR A PERIOD OF SEVERAL YEARS, COULD RESULT IN RUST-OUT OF THE COMPONENT AND POSSIBLE BREAKAGE OF THE SUBFRAME.

Risk. IF SUCH BREAKAGE OCCURS WHILE THE VEHICLE IS BEING OPERATED, CONTROL OF THE VEHICLE COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.

Remedy. DEALERS WILL CLEAN AND RUST-PROOF THE REAR SUSPENSION SUBFRAME. OWNER NOTIFICATION BEGAN JULY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.

Defect. CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS WERE PRODUCED WITH AN IMPROPERLY MANUFACTURED TRANSMISSION PARKING ROD. WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE "P" (PARK) POSITION, THE TRANSMISSION PARK MECHANISM, THAT IS INTENDED TO HOLD YOUR VEHICLE, MAY NOT ENGAGE.

Risk. THE VEHICLE COULD THEN MOVE/ROLL WITHOUT PRIOR WARNING, INCREASING THE RISK OF A CRASH.

Remedy. DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION PARKING ROD ASSEMBLY. OWNER NOTIFICATION JANUARY 8, 2003. AN INTERIM OWNER NOTIFICATION WILL BE SENT DURING NOVEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.

Defect. ON CERTAIN PASSENGER VEHICLES, THE BRAKE MASTER CYLINDERS MAY NOT FUNCTION PROPERLY IN AMBIENT TEMPERATURES BELOW FREEZING 32 DEGREES FAHRENHEIT AND LOWER).

Risk. AT THESE TEMPERATURES, THE BRAKES MAY NOT RELEASE AFTER BEING APPLIED, EVEN WHEN THE DRIVER'S FOOT IS NO LONGER ON THE BRAKE PEDAL. THIS CAN OCCUR WITHOUR PRIOR WARNING, POSSIBLY RESULTING IN A CRASH.

Remedy. DEALERS WILL REPLACE THE MASTER CYLINDERS. OWNER NOTIFICATION BEGAN MARCH 21, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.

To whom it may concern. I’ve purchased a second hand vehicle from New Jersey I live in California. It is 2002 Subaru outback H-6 3.0 with 52,000 miles. Upon delivery I took it to orange coast Subaru for general inspection when it was brought to my attention that there’s an open recall from 2004 stating excessive corrosion in the rear sub frame. It applies on vehicles in cold wet states where New Jersey is one of them. Service advisor assure me that all is fine and they marked it as resolved. Upon inspection when I received the car back to my horror the sub frame is corroded to the point of disintegration. I took it back in and I’ve reached out to Subaru of North America where they look into it and concluded that the factory warranty is expired, 5 years 60k miles and they will not fix the recall. Base on my research there’s no expiration on manufacture recall and I’m not sure why they will not take care of it . Please help me navigate this matter. Thank you kindly [XXX] The person at Subaru headquarters info is; [XXX] Subaru of America, Inc. Customer Advocacy Department 1-800-SUBARU3 (1-800-782-2783) Direct: [XXX] [email protected] Case number [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Extreme gas smell in cold weather until car heats up when running heat/defrost. Known issue in other models that warranted a recall.

The contact owns a 2002 Subaru Legacy. The contact stated that while driving at approximately 15 MPH, there was an abnormal sound of metal fragments dropping. The vehicle was seen by an independent mechanic where it was diagnosed that the underneath of the vehicle was rusted. The contact was unaware of what parts had detached from the vehicle or needed to be replaced. In addition, the vehicle was accelerating independently. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 169,000.

UN-FENDERED VEHICLES - I SEE WAY TOO MANY VEHICLES ALLOWED TO BE THE OUTFITTED WITH WIDE TIRES OUTSIDE OF THE VEHICLES FENDERS. HEY! I THOUGH TIRES ARE SUPPOSED TO BE COVERED BY THE VEHICLE'S FENDERS SO THEY WOULDN'T THROW OFF ROCKS, SPRAY OR DEBRIS INTO THE AIR AT OTHER VEHICLES ON THE HIGHWAY. THOSE OBNOXIOUS BRIGHT-BLUE HEADLIGHTS. SINCE WHEN DO OUR REGULATORS ALLOW HEADLIGHTS THAT BLIND OTHER DRIVERS ON THE HIGHWAYS AT NIGHT WHEN SWITCHED ON LOW-BEAM? THESE MIGHT BE GREAT FOR THE OTHER DRIVER BUT THEY'RE HELL ON SOMEONE'S RETINAS AT NIGHT IF THEY HAVE THE TEMERITY TO BE DRIVING OUT AHEAD. SURELY WE HAVE THE TECHNOLOGY TO ENFORCE THIS AT THE BRAKE TAG STATION. RAIN-X - WHY DO YOU ALLOW ITW GLOBAL BRANDS TO PUT THIS CRAP ON PEOPLE'S WINDSHIELDS? YOU CAN'T REMOVE IT AND THE ONLY WAY TO KEEP IT FROM SMEARING AND OBSCURING YOUR NIGHT-TIME VISION IS TO USE MORE OF IT. IT'S LIKE GLOBAL BRANDS IS CO-OPTING PEOPLE'S PRIVATE PROPERTY OR HELPING TO BLIND THEM ON THE HIGHWAYS. IF YOU USE THE STUFF AS INTENDED TO BEAD-UP RAIN INSTEAD OF USING WIPERS, YOU'RE BREAKING STATE LAW THAT SAYS YOU MUST USE HEADLIGHTS AND WIPER IN THE RAIN. SPEEDERS - WHAT IS WITH ALL THESE PEOPLE WHO DRIVE ON THE HIGHWAYS LIKE THEY'RE ON METH? DON'T WE HAVE SPEED LIMITS? CAN'T GOVERNMENT USE THE MONEY FROM SPEEDING FINES? ROAD SPRAY - WHY AREN'T TRACTOR TRUCKS AND TRAILERS NOT REQUIRED TO MINIMIZE THE BLINDING WATER SPRAY THEY MAKE ON WET HIGHWAYS? THERE ARE FENDERS AND WHEEL COVERS DESIGNED TO DO THIS.

WHEN THE VEHICLE STARTS GOING AROUND 55 - 60 MPH, THE CAR STARTS SHAKING VIGOROUSLY. THE WHEEL ALSO SHAKES WHICH ALSO CONCERNS ME. MOREOVER, WHEN I START TO SLOW THE CAR DOWN, A RATTLING NOISE CONSTANTLY SHAKES MY CAR INCLUDING MY WHEEL FROM SIDE TO SIDE. I THINK THERE MIGHT BE AN ALIGNMENT PROBLEM WITH MY VEHICLE SINCE MY CHECK ENGINE LIGHT TURNS ON AND OFF FREQUENTLY.

I CHECKED UNDER THE CAR AND THE REAR SUSPENSION IS SO RUSTED IT IS UNSAFE TO DRIVE . I LOOKED ON THE INTERNET AND IT IS A COMMON ISSUE. WITH THE AMOUNT OF UNSAFE CARS DRIVING AROUND WITH THIS ISSUE I WOULD SAY THE BALL WAS REALLY DROPPED ON THE ORIGINAL RECALL

I HAVE NOTICED AN INORDINATE NUMBER OF CARS WITH LED TAIL LIGHTS THAT THE BREAK AND/OR TAIL LIGHTS DO NOT WORK. NOTHING SPECIFIC FOR MAKE OR MODEL BUT IT IS DANGEROUS! I WOULD REALLY LIKE TO SEE IF IT IS BEING CHECKED OUT.

I OWN A 2002 SUBARU LEGACY IN WESTERN NEW YORK, I RECENTLY WAS TOLD THERE WAS AN ISSUE THAT WAS RECALLED BACK IN 2004 BUT MY CAR WAS NEVER NOTIFIED OR ADDRESSED OF THE ISSUE WITH CORROSION. THE RECALL ( NHTSA CAMPAIGN NUMBER: 03V153000 ) I WAS DRIVING ON THE HIGH WAY WHEN I HIT A SMALL BUMP AND THE BACK END OF THE SUBARU DROPPED AND THE TIRE STARTED TO SHRED CAUSING ME TO LOOSE CONTROL OF THE CAR , THANK GOOD THE CAR CAME TO A REST IN THE MEDIAN AND NO CRASH OR FATALITIES OCCURRED.

THE FUEL LINES LEAK OUT RAW GASOLINE ONTO THE HOT ENGINE ANY TIME IT IS COLD OUTSIDE. I HAVE REPLACED THE FUEL LINE BUT IT STILL LEAKS WHEN COLD. THIS IS A VERY GREAT FIRE HAZARD.

TL* THE CONTACT OWNS 2002 SUBARU LEGACY. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WOULD BE AN ODOR OF FUEL ENTERING INTO THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13E065000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.

A STRONG FUEL SMELL BEGAN ENTERING THE CAR THROUGH THE HEATING VENTS ON THE CAR. THIS HAS ONLY BEEN NOTICEABLE SINCE THE TEMPERATURE DROPPED BELOW 25 DEGREES FAHRENHEIT. THERE WAS A ALSO A NOTICEABLE TRAIL OF GASOLINE IN THE SNOW FOLLOWING THE CAR. *TR

ANY TIME IT IS COLD, AROUND 32F OR LOWER, WHETHER THE VEHICLE IS RUNNING OR NOT, THERE IS A TERRIBLE FUEL SMELL INSIDE THE CABIN. I HAVE ACTUALLY WITNESSED FUEL EVAPORATING OUT MY WINDOW. I CAN'T IMAGINE THIS IS A SAFE CONDITION AND A SHORT INTERNET SEARCH REVEALED THAT THIS IS A VERY COMMON PROBLEM. I DON'T UNDERSTAND WHY SUBARU DOESN'T HAVE TO PAY TO FIX THIS GLARING SAFETY ISSUE. *TR

TL* THE CONTACT OWNS A 2002 SUBARU LEGACY. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE HYDROPLANED DUE TO WET ROAD CONDITIONS AND CRASHED INTO A CABLE GUARDRAIL. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 99,500.

THE REAR SUSPENSION IS RUSTY THAT IT HAS RUST HOLES THROUGH IT AND THIS IS ALSO THE THAT HOLDS THE DRIVE IN PLACE I HAVE LOOK AT OTHER SUBARUS AND THEY ARE THE SAME WAY IF THAT BREAKS IT COULD CAUSE VARY BAD CRASH. *TR

TL* THE CONTACT OWNS A 2002 SUBARU LEGACY. THE CONTACT STATED THAT AFTER THE ENGINE WAS SHUT OFF, THE EXTERNAL LIGHTS REMAINED ILLUMINATED. THE CONTACT ATTEMPTED TO TURN THE LIGHT SWITCH OFF. HOWEVER, THE LIGHT REMAINED ON CAUSING THE BATTERY TO DIE. THE BATTERY WAS REMOVED FROM THE VEHICLE IN ORDER FOR THE LIGHTS TO SHUT OFF. THE PROBLEM RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT TAKEN TO A MECHANIC FOR A DIAGNOSIS. THE VEHICLE WAS NO REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 400,000.

TL* THE CONTACT OWNS A 2002 SUBARU LEGACY. THE CONTACT STATED THERE WAS A STRONG GASOLINE ODOR COMING FROM INSIDE AND OUTSIDE OF THE VEHICLE. THE CONTACT ALSO STATED THAT WHEN HE TURNED ON THE HEATER OR DEFROSTER, THE FUMES WERE EXTREMELY STRONG. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 215,000.

IN VERY COLD WEATHER (<20-25 DEGREES F) THERE IS A RAW FUEL SMELL THAT FILLS THE INTERIOR CABIN. THIS OCCASIONALLY IMPROVED WHEN THE ENGINE WARMS UP BUT RETURNS WHEN RESTATING THE CAR. THIS IS VERY CONCERNING FOR A DEFECT THAT MAY LEAD TO FIRE. *TR

WHEN STARTING THE VEHICLE "COLD" IN COLD OUTDOOR TEMPERATURES (10 F OR BELOW) THERE IS A VERY STRONG SMELL OF RAW GASOLINE IN THE PASSENGER COMPARTMENT OF THE VEHICLE. THE ODOR IS COMING INTO THE PASSENGER COMPARTMENT VIA THE HEATING/COOLING VENTS; IF THE HEATING/COOLING FAN IS TURNED OFF THE PASSENGER COMPARTMENT DOES NOT BECOME FILLED WITH GASOLINE FUMES. THE ODOR IS STRONG ENOUGH THAT I AM CONCERNED ABOUT THE POSSIBILITY OF A FIRE. THE ODOR IS STRONG ENOUGH THAT AFTER DRIVING THE VEHICLE AFTER A COLD WEATHER START MY CLOTHING SMELLS LIKE GASOLINE. THIS HAS BEEN A RECURRING PROBLEM WHENEVER THE VEHICLE IS STARTED IN COLD WEATHER. THE PROBLEM OCCURRED TONIGHT AT A TEMPERATURE OF 0 F. THE PROBLEM HAS BEEN OCCURRING SINCE BEFORE THE DATE ABOVE, BUT I DID NOT REALIZE I COULD FILE A COMPLAINT UNTIL NOW. CONTINENTAL MOTORS, AUTHORIZED SUBARU SERVICED REPORTED ON THE PROBLEM AFTER VEHICLE WAS SERVICED ON 2012 DEC 14: "199 CAR DESIGNED TO RUN RICH WHEN VERY COLD. NO PROBLEM FOUND. NO FUEL LEAK NOTED." I AM A FORMER VW MECHANIC AND I KNOW THAT WHEN A VEHICLE RUNS RICH THERE SHOULD NOT BE GASOLINE FUMES IN THE PASSENGER COMPARTMENT - SUBARU'S EXPLANATION IS ILLOGICAL. *TR

TL* THE CONTACT OWNED A 2002 SUBARU LEGACY. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, SMOKE EMITTED FROM THE FRONT DRIVER SIDE DOOR PANEL AND THE DOOR CAUGHT ON FIRE. THE CONTACT MANEUVERED TO THE SHOULDER AND NOTIFIED THE FIRE DEPARTMENT. THE FIRE DEPARTMENT APPEARED ON THE SCENE TO EXTINGUISH THE FIRE. THE VEHICLE WAS DESTROYED AND TOWED TO AN INDEPENDENT REPAIR SHOP. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 103,000.

NHTSA REF # 302836, SAFETY ISSUE, BRAKES ROTORS RUST TO POINT OF FAILURE, SUBARU SERVICE TOLD ME THEY WERE A SAFETY CONCERN. VIN [XXX], 2002 SUBARU LEGACY L, 43,351 MILES, REPAIR PARTS, SUBARU, FRONT BRAKES PN'S 26296AE220 & 26300AE00C, REAR BRAKES PN'S 26700AE04C & 26696AE020 REPLACED ON ALL 4 WHEELS. I HAVE NEVER HAD TO REPLACE BRAKES ON ANY OF THE MANY VEHICLES I HAVE DRIVEN OVER FORTY PLUS YEARS OF DRIVING. THE SERVICE REP LOOKED TO SEE IF THERE WAS A RECALL WHICH TELLS ME THEY HAVE HAD SAFETY RECALLS. I ORIGINALLY WENT TO THE DEALER TO HAVE MY OIL CHANGED AND WHILE IN THE WAITING ROOM A SALES PERSON CAME OUT AND SPOKE TO A PRIEST WHO OWNED A 2008 OUTBACK AND THE SALES PERSON ASK IF HE WANTED TO TRADE HIS VEHICLE BEFORE IT NEEDED BRAKE WORK. MY EXPERIENCE TELLS ME THAT MY BRAKING DISTANCE WAS COMPROMISED BY MANY FEET OF STOPPING DISTANCE. THE TOTAL COST OF REPAIR WAS $966.48. I HAVE ALL THE DOCUMENTS TO VALIDATE STATEMENTS MADE ON THIS COMPLAINT. I CALLED SUBARU OF AMERICA, THEY WE NOT INTERESTED IN MY COMPLAINT IF IT DID NOT MEET ONE OF THEIR TWO CRITERIA WHICH WERE, WAS THE CAR IN WARRANTY OR WAS THERE A RECALL, THEY WERE NOT INTEREST IN UNDERSTANDING A SAFETY PROBLEM, THEY DID OFFER ME $500 FOR A NEW SUBARU . REFERENCE NUMBER FOR SUBARU WAS REF # 1-1103069413. BRAKE ROTOR DESIGN IS OBSERVING THE LAWS OF PHYSICS AND OVER DESIGNING THE ROTOR SO THE HEAT AT FULL LOAD IS NOT SO GREAT TO CAUSE BRAKING FADE AND CONTINUOUS OVERHEATING OF THE BRAKES CAUSING THEM TO RUST. COMPL