2005 Saturn Ion

Defect. UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original ignition switch. The weight on the key ring and/or road conditions or some other jarring event may cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.

Risk. If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.

Remedy. UCI-FRAM Group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by GM dealers as part of NHTSA recall 14V-047, free of charge. UCI-Fram's purchasers should contact UCI-FRAM Group at 1-800-890-2075. GM vehicle owners requiring additional information on that recall campaign should contact GM at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac) or 1-800-553-6000 (Saturn).

Defect. General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Risk. If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy. General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

Defect. General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Risk. If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy. GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

Defect. This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Risk. If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy. GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Defect. SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds …

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 …

Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to …

This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the customer is having that is unwanted. The vehicle may receive an incoming call just like any other phone. Typically the …

Electric Power Steering Assist

Electric Power Steering Assist

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

SATURN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-POWER STEERING ASSIST. SOME VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST, WHICH COULD OCCUR AT ANY TIME WHILE DRIVING THE VEHICLE. IF THE POWER STEERING ASSIST IS LOST, A CHIME WILL BE HEARD AND THE …

This vehicle has an electrical issue from time to time seemingly out of nowhere. There is no power steering it just shuts off sometimes it’ll stay off for an hour sometimes it’ll stay off for weeks and I can’t figure out how to fix it. It randomly fixes itself same can be said for the air conditioning And the driver side, headlight all of these electrical functions, seemingly turn themselves up or down for no apparent reason.

The contact owns a 2005 Saturn Ion. The contact stated that the ignition key was stuck inside the ignition key slot, and the vehicle failed to start. The cause of the failure was not yet determined. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 14V171000 (ELECTRICAL SYSTEM). The dealer was not contacted regarding the failure. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 167,000.

My key is stuck in the I can take it out the o2 seners not reading

The ignition cylinder was replaced in my vehicle because the key would not turn in the ignition to start the car. It is actually, the fourth time this has happened. I understand that there have been two recalls on this issue in the past. The reason it was recalled is because the ignition has turned to the off position killing the car's engine while the driver is driving on the road which has caused serious accidents. I was lucky not to get into an accident from this. The last replacement has lasted almost ten years. However, my issue is that General Motors apparently keeps manufacturing a defective part. This is unacceptable because I had to pay $585.02 to have this work done due to the fact that the dealerships apparently are not required to replaced it at no charge to the vehicle owner. It could also be a potential safety issue again.

Hello I am reaching out to complain about Courtesy Chevrolet - San Diego. I’ve been trying to get my car serviced in order to fIx the recalls. Unfortunately I have not been successful. I called the dealer to make an appointment but the dealer told me that the car has been discontinued and they can’t find the parts. The suggested to call somewhere else.

When pressing the gas pedal 2/3 of the way down the pedal got stuck causing the engine to rev high while driving forward. I had to put the car in neutral, shut the engine off and manually get the gas pedal unstuck by reaching down to the floor and pulling the pedal upwards with my hands. Also I had no floor mats in my car for the pedal to get stuck on. This has happened on multiple occasions.

Power steering intermittently fails at random and steering wheel suddenly becomes immovable nearly causing serious accidents and endangerment to myself, my family, and others drivers on the roads.

Headlights are to deem even on high beems.cant see anything coming or the on coming traffic can't see me coming.

I turn my turn signals on and nonthing happens in the Frontline bulbs are brand new doesn't matter back turn signal work,front turn signal dont.this has been happening since forever my inlaws didn't know we didn't know until they gave car.so don't know how long seems like forever

My 2015 Saturn ION was on a Recalled Warranty issued and concerning faulty ignition Switch problem. I have brought my car in (5) times since (2014) and it has occurred again in (2021) and G,M, dealer Mauer Chevrolet has refused to honor warranty recall stating that Gm has sent them letter to not service any more Saturn's ION with this problem due to cost. they refused to take my car in with key stuck ignition switch. I have filed complaint with MN. Attorney General office Consumer Division and they agreed that my consumer rights had been violated but Mauer Chevrolet still refuse's to fix my problem. My car has been sitting for over (3) months due to this problem. I need your assistance and hope you intervene as this has caused stress ,hardship and depression being without a car. Car dealer is Mauer Chevrolet located inInver Grove Heights, MN. 1055 50th Street, 55075. (651-455-6283). Mauer Chevrolet has retained their attorney to assist them, so I need help, also. Please HELP!

2005 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH PROBLEM. THE CONSUMER STATED THE KEY WOULD FREQUENTLY BECOME STUCK IN THE IGNITION. THE DEALER MADE MULTIPLE REPAIR ATTEMPTS BUT, THE FAILURE RECURRED. THE CONSUMER REQUESTED TO HAVE THE VEHICLE REPAIRED UNDER RECALL.

It says I have 0 I repaired recalls. I have had the powers steering fail 2x. More importantly, the ignition cylinder locks up and I can’t get my keys out. I have to wait most times after turning the car off - for 3-5 minutes through a series of clicking noises in the ignition before the key will release. It is concerning because sometimes I have to get out immediately and the keys don’t release. The car automatically locks itself and if I don’t roll the window down- I become locked out. It yesterday had a issue with ignition all together and I wonder if it’s related. I was made aware again there were many recalls on this issue and hoped to get it repaired. However it now states there are none unrepaired. I’m wondering if it is a ongoing problem with the vehicle, it’s repair parts etc and if it’s just not been addressed because it’s so old that so few are left on the road. Thank you. This is a increasing problem and a daily or every time I drive it issue now. I worry too the power steering will just go out in the interstate.

The contact owns a 2005 Saturn Ion. The contact stated that while operating the vehicle, the power steering malfunctioned, and the steering wheel became very difficult to turn in either direction. During the failure, the power steering message was displayed. The cause of the failure was not yet determined. The vehicle was not repaired. The local dealer was notified of the failure. The manufacturer was not contacted. The contact stated that the vehicle was previously repaired under the NHTSA campaign number: 14V153000 (Steering) but the failure occurred. The failure mileage was 167,000.

TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE LOSS MOTIVE POWER WITHOUT WARNING. THE CONTACT STATED THAT STEERING ASSIST AND GAUGES WERE IN OPERABLE. THE CONTACT COASTED TO THE SIDE OF THE ROAD AND RESTARTED THE VEHICLE. THE CONTACT STATED THAT SEVERAL OF THE ELECTRICAL FUNCTIONS RETURNED HOWEVER, THE ELECTRICAL FUNCTIONS FAILED INTERMITTENTLY. THE POWER STEERING ASSIST WARNING LIGHT ILLUMINATED INTERMITTENTLY WHEN THE POWER STEERING ASSIST WAS INOPERABLE. OCEAN CREST CHEVROLET BUICK GMC CADILLAC (855 ALTERNATE HWY 101, WARRENTON, OR 97146, (866)607-2902) WAS CONTACTED AND INFORMED OF THE FAILURE. THE DEALER SUGGESTED THAT THE VEHICLE BE TAKEN IN TO BE DIAGNOSED WHICH WAS STILL PENDING. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

DASH LIGHTS GO OUT AND ALL SYSTEMS ARE YOU FUNCTIONING PROPERTY

TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT UPON ACTIVATION OF THE HEADLIGHTS, THE HEADLIGHTS WERE DIM CAUSING POOR FORWARD VISIBILITY WHILE DRIVING AT NIGHT OR IN LOW LIGHT CONDITIONS. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 09E012000 (EXTERIOR LIGHTING) HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

TL* THE CONTACT OWNED A 2005 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED INTO A TREE. DURING THE CRASH THE PASSENGER SIDE OF THE VEHICLE WAS SEVERELY DAMAGED BUT NO AIR BAGS HAD DEPLOYED. THE DRIVER SUSTAINED AN INJURED NECK AND WAS TRANSPORTED TO THE HOSIPITAL. A POLICE REPORT WAS TAKEN AT THE SCENE. THE VEHICLE WAS DESTROYED AND TOWED AWAY. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE INCIDENT. THE FAILURE MILEAGE WAS 174,000.

TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT THE STEERING WHEEL WOULD MOVE UNCONTROLLABLE. THE VEHICLE WAS TOWED TO THE DEALER (GLENN H. WRIGHT, BS 1517 W GARVEY AVE N, WEST COVINA, CA 91706 (626) 962-6061) BY ROADSIDE ASSISTANCE AND LEFT AT THE DEALER FOR 6 DAYS. THERE WAS NO DIAGNOSTIC TESTING PERFORMED AND THE VEHICLE WAS NOT REPAIRED. HOWEVER, THE FAILURE RECURRED AND THE VEHICLE WAS UNSAFE TO DRIVE. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING) AS A POSSIBLE SOLUTION TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT NO FURTHER ASSISTANCE WAS TAKEN THE CONTACT WAS PROVIDED A CASE NUMBER. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.

TL* THE CONTACT OWNED A 2005 SATURN ION. THE CONTACT'S SON OBSERVED AN ORANGE GLARE COMING FROM THE BACK OF THEIR HOUSE. THE FAMILY RAN OUTSIDE TOGETHER AND DISCOVERED THAT THE SON'S VEHICLE WAS ON FIRE. THE FIRE DEPARTMENT WAS DOWN THE STREET, BUT TOOK TWENTY MINUTES TO ARRIVE AT THE SCENE. THE CONTACT'S NINETEEN YEAR OLD SON EXTINGUISHED THE FIRE WITH WATER FROM THE HOUSE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOTALED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 217,000.

DAYTIME RUNNING LIGHT TURN SIGNAL DONT WORK FOR THE PASSENGER SIDE WHICH CAN CAUSE A SAFETY PROBLEM TO OTHER DRIVERS

VEHICLE WAS STATIONARY WHEN PROBLEM OCCURRED. FUEL INTAKE AND RETURN LINES IN FRONT OF THE REAR DRIVERS SIDE WHEEL FLAKING BADLY AND RUSTED THROUGH, ABOUT AN 8 INCH SECTION OF LINE WAS FLAKING AND RUSTED THROUGH. FUEL LINE WAS RUBBED WHEN PUTTING ON NEW OEM EXHAST AND BROKE THROUGH THE LINES. GAS WAS LEAKING BAD ENOUGH THAT IT WAS DEEMED NOT SAFE TO DRIVE AS THESE LINES ARE ABOUT 5 INCHES AWAY FROM THE EXHAUST.

DRIVER LIGHTS WILL NOT WORK SWITCHED BULB AND CHECKED FUSES

12-13-2018. TOOK MY DAUGHTER TO SCHOOL. SHUT THE CAR OFF WENT INTO THE SCHOOL AND CAME OUT AND STARTED THE CAR FROM PARKED POSITION TURNED THE CAR AROUND WAS ON A SIDE STREET TO CROSS HIGHWAY 13 WAS READY TO TURN ONTO HIGHWAY 13 AND NO POWER STEERING, THIS WAS PART OF A RECALL THAT GM ISSUED AND THIS NEW PART DIDN'T EVEN LAST 38,000 MILES. T

"TAKATA RECALL" I PUT MY KEY IN THE IGNITION. THE CAR STALLED FOR A QUICK SECOND THEN CAME ON GULLY. AS I REVERSED OUT OF MY DRIVEWAY AND WENT TO MAKE A SLIGHT LEFT I NOTICED MY STEERING WHEEL HAD LOCKED UP. I WAS ABLE TO SLOW TURN THE WHEEL AS I HAD TO MANUALLY STEER. I PULLED OVER AND PARKED. THIS IS NOT SAFE.

I HAD THE RECALL FIXED IN 2015. THE SAME ISSUES THAT I HAD BEFORE HAVE RETURNED. WHEN DRIVING AND THE TANK IS FULL, I WILL GET A SERVICE ENGINE LIGHT AND THE TANK GAUGE WILL READ EMPTY. IT WAS FINE WHEN I BEGAN DRIVING . UPON RESTARTING THE CAR THE ERROR GOES AWAY. WHEN I PUT MY CAR IN PARK AND TRY TO TURN OFF MY IGNITION I HAVE TO PUT HE SHIFTIER IN PARK SEVERAL TIMES BEFORE I CAN REMOVE MY KEY. TODAY CAR RAN GREAT WHEN TRYING TO MOVE MY CAR AFTER STARTING MY CAR MY POWER STEERING WAS GONE. AGAIN UPON TURNING OFF MY CAR AND RESTARTING IT , THE POWER STEERING RETURNED. I CALLED THE GM RECALL NUMBER AND A CASE WAS CREATED BUT I WAS TOLD THAT THERE WERE NOT ANY CURRENT RECALLS ON MY CAR. THE SERVICE NUMBER IS 8-4833918801. BUT WAS TOLD THAT ALL REPAIRS ARE MY RESPONSEABILITY.

I WAS ALMOST INVOLVED IN AN ACCIDENT DUE TO THE STEERING WHEEL GOING VERY HARD WHILE I WAS TRYING TO MAKE A TURN. A MECHANIC LOOKED AT THE CAR AND SAID THAT IT DOES NOT HAVE A POWER STEERING FLUID COMPARTMENT TO ADD POWER STEERING FLUID.

I WAS DRIVING HOME ON A CITY STREET WHEN I NOTICED MY KEY POPPED OUT OF THE IGNITION HALF WAY, I FELT MY VEHICLE LOSING POWER, I COULDN'T ACCELERATE, THERE WAS A BUS COMING UP BEHIND, I TRIED TO PUSH THE KEY BACK IN BUT WAS UNABLE TO MOVE IT, I COULDN'T ACCELERATE AND WAS LOSING POWER, MY ONLY OPTION WAS TO PULL OVER THE SIDE OF THE ROAD, IT WAS VERY DIFFICULT TO STEER, I PUT MY HAZARD LIGHTS ON BECAUSE I DIDN'T KNOW IF I WAS GOING TO GET HIT FROM BEHIND, I CONTINUED TO PULL OFF THE ROAD, I HAD TO STOP THE VEHICLE AND PUT IN PARK, I WAS VERY CONFUSED AS TO HOW THIS HAPPENED, I HAD TO COMPOSE MYSELF, CALLED MY MOM AND TOLD HER WHAT HAPPENED, SHE IMMEDIATELY LOOKED ONLINE FOR ANY RECALL ISSUES AND CAME ACROSS THE GM IGNITION SWITCH RECALL FOR SATURN ION 2003-2007. MY MOM CALLED THE GM CUSTOMER SERVICE, P# 800-222-1020 AND INFORMED THEM ABOUT THE ISSUE RELATED RECALL. THEY SHOW THE RECALL WAS ADDRESSED ON THIS VEHICLE IN 2014 AND SAID NOTHING THEY CAN DO. SHE ALSO CALLED THE DEALER BOUCHER CHEVROLET OF WAUKESHA, P# 262-347-4107, WHERE WE PURCHASED THE VEHICLE AND THEY WOULD HAVE TO LOOK AT IT AND SEE IF SAME ISSUE OTHERWISE WE WILL GET CHARGED FOR FIXING IT. I TOOK THE VEHICLE TO BERGSTROM CHEVROLET IN MADISON, WI WHERE THEY WANTED TO CHARGE ME $100.00 FOR FIXING IT EVEN IT RECALL RELATED ISSUE. I AM AFRAID TO DRIVE MY VEHICLE FOR FEAR OF GETTING KILLED ON THE ROAD WHEN I HAVE NO CONTROL OVER MY VEHICLE AT HIGH SPEEDS. I HAVE TO COMMUTE TO WORK ON THE FREEWAY EVERY WEEK. IF THE

LA QUINTA CHEV/CADDILAC REPLACED MY IGNITION PER THE GM RECALL A COUPLE OF YEARS AGO AND NOW THE IGNITION IS LOCKING UP AGAIN. WHAT CAN I DO?

I HAVE HAD ISSUES WITH MY CAR EVEN AFTER I HAVE HAD SOME RECALLS DONE TO IT. THE BIGGEST ISSUE IS WHEN I AM DRIVING OR STATIONARY WITH MY CAR ON, THE CAR RUMBLES AND FEELS LIKE IT IS TUGGING BACKWARDS. THE CYLINDER 2 KEEPS MISFIRING (P0302). I HAVE SEEN SEVERAL SATURN IONS THAT ARE HAVING THE SAME ISSUE. OVER THE PAST FOUR YEARS THIS HAS BEEN A PROBLEM CONSISTENTLY. THERE ARE PERIODS WHERE IT DOESN'T HAPPEN MUCH AND SOMETIMES IT HAPPENS EVERY TIME I DRIVE. FURTHERMORE, MY CAR STILL DOESN'T TURN ON/OFF ALL THE WAY SOMETIMES AND THE IGNITION SWITCH MESSES UP.

TL* THE CONTACT OWNS A 2005 SATURN ION. WHILE DRIVING OUT OF A PARKING SPACE AT A LOW SPEED, THE STEERING WHEEL SEIZED AND WAS UNABLE TO TURN IN ANY DIRECTION. AFTER THE VEHICLE WAS TURNED OFF AND RESTARTED, THE CONTACT WAS ABLE TO MANEUVER THE STEERING WHEEL NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER (MARITIME CHEVROLET, 985 POST ROAD, FAIRFIELD, CT 06824) AND THE TECHNICIAN STATED THAT THERE WAS NO RECALL. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST BECAUSE THE VIN WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS 207,000.

TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THERE WAS A STRONG FUEL ODOR COMING FROM THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED BEFORE OR AFTER THE FAILURE. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT BELIEVED THE FAILURE WAS RELEVANT TO NHTSA CAMPAIGN NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 115,000. THE VIN WAS NOT PROVIDED.

KEYS CAN NOT BE REMOVED FROM THE IGNITION OF THE 2005 SATURN ION. RESEARCH INDICATED THAT GM HAS THIS PROBLEM ACROSS SEVERAL OF ITS SMALL CAR BRANDS AND MODELS. THE INABILITY TO REMOVE THE KEYS CAUSES THE BATTERY TO DRAIN. IT ALSO LEAVES THE CAR VULNERABLE TO THEFT AS THE CAR CAN BE STARTED AGAIN. GM ALLEGEDLY RECOGNIZES IT AS A PROBLEM WITH UPWARDS OF 88,000 VEHICLES. ARTICLES WRITTEN BY MIKE COLIAS IN AUTOMOTIVE NEWS INDICATED THAT GM, BEING VERY WELL AWARE OF THE ISSUE PROMPTED GM TO OFFER A "SPECIAL COVERAGE ADJUSTMENT" IN WHICH THEY WOULD REPAIR THE CAR FOR FREE, BUT NOT RECALL THE AFFECTED CARS. A LOCAL GM DEALER WAS NOT AWARE OF THIS SPECIAL COVERAGE ADJUSTMENT AND WAS NOT WILLING TO REPAIR THE CAR FOR FREE, ALTHOUGH THEY DID SAY THEY WOULD DO MORE RESEARCH ON THE PROBLEM. THE PROBLEM ONLY SURFACES WHEN THE CAR IS STATIONARY AND IT WILL SHUT OFF. BUT IF GOING AWAY WITH THE CAR OR STOPPING FOR GAS OR ERRANDS FORCES YOU TO LEAVE THE KEYS IN THE CAR, IN ADDITION TO DRAINING THE BATTERY IT BECOMES A LARGE TARGET FOR THEFT.

DRIVING HOME FROM WORK SUDDENLY I HAD EXPERIENCED SUDDEN LOSS OF POWER STEERING. RESEARCH ONLINE INDICATES THIS MAKE MODEL AND YEAR HAS A KNOWN ISSUE WITH THIS PROBLEM. HOWEVER USING VIN SEARCH I FIND NO RECALL INFORMATION. WHAT ARE MY OPTIONS IF I BELIEVE IT'S A MANUFACTURER ISSUE?

COLLEGE AGED DAUGHTER OWNS AND DRIVES A 2005 SATURN ION WITH APPROXIMATELY 115,000 MILES. WE NOTICED A WET SPOTS ON THE GROUND ON THE DRIVERS SIDE NEAR THE REAR PASSENGER DOOR WHEN CAR IS STATIONARY (PARKED) BUT NEVER DETECTED AN ODOR. TOOK VEHICLE TO NISSAN DEALERSHIP IN MARYLAND SINCE WE WERE UNAWARE THAT GM OWNS SATURN. HOWEVER, WE WERE TOLD BY NISSAN THAT FUEL LINES NEED TO BE REPLACED BECAUSE THE VEHICLE IS LEAKING GASOLINE AND REPAIRS SHOULD BE DONE IMMEDIATELY BECAUSE IT IS BOTH UNSAFE AND DANGEROUS.

WHEN DRIVING MY CHECK GAS CAP LIGHT COMES ON, AS WELL AS THE COOLANT LIGHT COMES ON WITHIN 5 MINUTES OF DRIVING THE VEHICLE. THIS HAS BEEN HAPPENING SINCE 2013, IT HAPPENS DURING DRIVING ON A HWY, IN THE CITY EVERYWHERE THE CAR IS DRIVEN, I PUSH THE RESET BUTTON AND IT CLEARS HOWEVER IT COMES BACK WITHIN 5 MINUTES....

CAR STOPPED IN MIDDLE OF STREET WHILE GOING OVER A DIP AT 25MPH AND SPEEDOMETER WENT UP TO 50MPH AFTER COMING TO A COMPLETE STOP AND VEHICLE WOULDN'T MOVE. BUT IF YOU PUT VEHICLE INTO DRIVE IT WILL SHOW AS IF YOU ARE GOING 20MPH WHILE YOU JUST BARLEY PUT IT INTO DRIVE.

TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT WHEN HE STARTED THE VEHICLE, HE NOTICED AN ABNORMAL FUEL ODOR WITHOUT WARNING. IN ADDITION, ONCE THE CONTACT REACHED HIS DESTINATION HE OBSERVED FUEL LEAKING OUT FROM UNDER THE REAR PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER NOR THE DEALER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 250,000.

TL* THE CONTACT'S DAUGHTER OWNS A 2005 SATURN ION. EACH TIME THE VEHICLE WAS PARKED, THE CONTACT NOTICED OIL SPOTS ON THE GROUND. UPON FURTHER INSPECTION, THE CONTACTED HUSBAND NOTICED THAT THE FUEL LINE WAS CRACKED AND LEAKED FUEL IN THE FRONT OF THE REAR DRIVER?S SIDE WHEEL. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT WAS CONCERNED THAT THE FUEL LEAKAGE COULD CAUSE A FIRE. THE CONTACT CALLED THE DEALER (GUY'S BUICK GEMS, 1316 N MILDRED ST, RANSOM, WV 25438 304-725-3448) AND WAS INFORMED THAT THERE NO RECALLS WERE ON THE VEHICLE. THE DEALER WAS UNABLE TO SCHEDULE AN APPOINTMENT AND STATED THAT THEY WOULD CALL THE CONTACT BACK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

THE DRL AND TAIL LIGHTS FLICKER AT HIGH SPEED WHEN CAR IS RUNNING!

TL* THE CONTACT OWNS A 2005 SATURN ION. AFTER STARTING THE ENGINE AND SWITCHING THE SHIFTER TO REVERSE, THE POWER STEERING MALFUNCTIONED AND THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN. DURING THE INCIDENT, THE POWER STEERING FAILURE MESSAGE WAS DISPLAYED. AFTER TURNING THE ENGINE OFF AND BACK ON, THE VEHICLE OPERATED NORMALLY. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 195,000.

TL* THE CONTACT OWNS A 2005 SATURN ION. WHILE STARTING THE VEHICLE, AN ABNORMAL NOISE WAS HEARD AND THE VEHICLE SHUT OFF. WHILE THE KEY WAS REMOVED FROM THE IGNITION, THE VEHICLE STARTED INDEPENDENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.

TAKATA RECALL WHEN I SLOW DOWN MY LIGHTS DIM VERY LOW. IT MAKES IT HARD TO SEE AT NIGHT.

TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT THE STEERING WHEEL FAILED BECAME HARD TO TURN WHILE DRIVING IN REVERSE. THE POWER STEERING INDICATOR ILLUMINATED. THE CONTACT WAS ABLE TO RESTART THE ENGINE AND RESUME NORMAL STEERING FUNCTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

AS SOON AS YOU TURN THE KEY ON THE FUEL PUMP STARTS PUMPING FUEL OUT OVER THE LEFT REAR WHEEL WITH OUT STARTING THE CAR.I HAVE READ THAT THE 2006 AND UP SATURNS HAVE A RECALL ON THE FUEL PUMPS BUT NOT THE 2005 WHY. WILL THEY RECALL THE 2005 MODELS IN THE FUTURE.

WHILE TRAVELING ON HIGHWAY, I STOPPED AND FILLED UP GASOLINE AND I NOTICED A CONTINUING STRONG GAS SMELL IN CAR. THOUGHT I SPILLED GAS ON MYSELF BUT LATER UPON INSPECTION IN MY GARAGE, I FOUND GAS DRIPPING FROM PLASTIC FUEL LINE (UNDER CAR, RIGHT BEHIND DRIVER'S DOOR). DUE TO DANGER, I IMMEDIATELY SET UP APPOINTMENT WITH POLAR CHEVROLET, WHO DECIDED THE FUEL LINE NEEDED REPLACEMENT. COST WAS $623.44

ENGINE FAILED AT 125,000 MILES. ENGINE SPECIALIST DETERMINED CYLINDER #4 OIL STARVATION AS THE CAUSE. OIL CHANGE INTERVALS HAVE ALWAYS BEEN APPROXIMATELY 7500 MILES. ENGINE STALLED OUT AND WOULD NOT CRANK TO RESTART. ENGINE WILL NEED TO BE REPLACED. COST: APPROXIMATELY $4,000.

TL* THE CONTACT OWNS A 2005 SATURN ION. WHILE DRIVING APPROXIMATELY 30 MPH, THE POWER STEERING SEIZED AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRIC POWER STEERING MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

TL* THE CONTACT OWNS A 2005 SATURN ION. WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL BECAME HARD TO MANEUVER. THE POWER STEERING AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND RESTARTED THE VEHICLE, BUT THE FAILURE OCCURRED ONCE MORE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 97,200.

THIS HAS HAPPENED SEVERAL TIMES IN RECENT MONTHS, BUT HERE IS WHAT HAPPENED THIS MORNING: I WAS ON THE INTERSTATE, GOING ABOUT 60MPH, AND I SPED UP TEMPORARILY TO PASS THE SEMI NEXT TO ME SO THAT I COULD MERGE INTO THE RIGHT LANE AND CATCH THE NEXT EXIT. UPON MERGING, I RELEASED THE GAS PEDAL BUT IT DID NOT COME BACK NATURALLY WITH MY FOOT AND INSTEAD WENT TO THE FLOOR AND MY CAR STARTED ACCELERATING AS I EXITED THE INTERSTATE ONTO A FLYOVER RAMP. I IMMEDIATELY HIT MY BRAKES AND WAS ABLE TO REGAIN CONTROL OF THE SPEED, BUT IT SCARED ME, ESPECIALLY AS THE FLYOVER RAMP REQUIRES A SLOWER SPEED ALONG THE CURVE. TO THE BEST OF MY RECOLLECTION, IN ALL CASES WHERE THIS HAS HAPPENED, I HAVE BEEN GOING AT LEAST 35 MPH WHEN IT HAPPENED, AND MY CRUISE CONTROL WAS ON BUT NOT ACTIVE (IN OTHER WORDS I HAD IT AVAILABLE TO ME BUT IT WAS NOT CURRENTLY SET AT ANY PARTICULAR SPEED). I HAVE SEEN MULTIPLE SIMILAR COMPLAINTS IN FORUMS ONLINE, BUT I AM NOT AWARE OF A RECALL. THIS IS OBVIOUSLY AN EXTREMELY DANGEROUS ISSUE, ESPECIALLY AT HIGH SPEEDS IN DENSE TRAFFIC. PLEASE INVESTIGATE FURTHER -- I CANNOT AFFORD TO HAVE MY MECHANIC REPLACE ALL THE POSSIBLE FAULTY PARTS WITH OTHER POTENTIALLY FAULTY PARTS, AND I WOULD HATE TO BE THE CAUSE OF AN ACCIDENT BECAUSE THE CAR WAS OUT OF MY CONTROL THROUGH NO FAULT OF MINE.

TL* THE CONTACT OWNS 2005 SATURN ION. THE CONTACT STATED THAT THE IGNITION KEY FAILED TO DISENGAGE FROM THE VEHICLE CAUSING THE CONTACT TO HAVE TO RESTART THE VEHICLE SEVERAL TIMES BEFORE IT COULD BE REMOVED. THE CONTACT MENTIONED THAT THE FAILURE CAUSED THE BATTERY TO BECOME INOPERABLE ON MORE THAN ONE OCCASION. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 88,256.