Paccar Incorporated: Latches/Locks/Linkages › Doors › Latch
Paccar Incorporated reported this defect to federal regulators on Feb 7, 2008 and put the number of vehicles at risk at 6,169. The repair is free for as long as the recall stands.
The defect
PACCAR IS RECALLING 6,169 MY 2008 KENWORTH T300, T660, T800, T2000, W900 AND C500 VEHICLES AND MY 2008-2009 PETERBILT MODELS 365, 367, 384, 387, 388, 389 AND 389 KITS. CERTAIN DOOR LATCH ASSEMBLIES ON THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS." THE ROTOR IN SOME OF THESE DOOR LATCH ASSEMBLIES DID NOT RECEIVE THE PROPER HEAT TREATMENT AND MAY BE SOFT.
The risk
IN THE EVENT OF A CRASH, FORCE COULD CAUSE THE ROTOR TO CRACK AND THE DOOR WOULD NOT HAVE PRIMARY OR SECONDARY CLOSING SECURITY WHICH COULD POSSIBLY LEAD TO INJURY OF THE VEHICLE OCCUPANT.
The remedy
PACCAR IS WORKING WITH TRIMARK AND WILL INSPECT AND REPLACE THE DOOR LATCH IF IT IS FOUND TO BE DEFECTIVE. THE RECALL BEGAN ON MARCH 14, 2008. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440 OR PETERBILT AT 1-940-591-4196.
22 model years covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2009 Peterbilt 330 | 0 | 4 | 0 | 0 |
| 2009 Peterbilt 367 | 0 | 13 | 0 | 0 |
| 2009 Peterbilt 384 | 0 | 10 | 0 | 0 |
| 2009 Peterbilt 386 | 1 | 10 | 0 | 0 |
| 2009 Peterbilt 387 | 2 | 9 | 0 | 0 |
| 2009 Peterbilt 388 | 0 | 15 | 0 | 0 |
| 2009 Peterbilt 389 | 0 | 12 | 0 | 0 |
| 2009 Peterbilt 389k | 0 | 2 | 0 | 0 |
| 2008 Kenworth C500 | 0 | 9 | 0 | 0 |
| 2008 Kenworth T2000 | 2 | 14 | 0 | 0 |
| 2008 Kenworth T300 | 0 | 7 | 0 | 0 |
| 2008 Kenworth T660 | 2 | 14 | 1 | 1 |
| 2008 Kenworth T800 | 1 | 25 | 0 | 0 |
| 2008 Kenworth W900 | 1 | 20 | 0 | 1 |
| 2008 Peterbilt 365 | 0 | 18 | 0 | 0 |
| 2008 Peterbilt 367 | 0 | 18 | 0 | 0 |
| 2008 Peterbilt 384 | 0 | 11 | 0 | 0 |
| 2008 Peterbilt 386 | 4 | 14 | 0 | 0 |
| 2008 Peterbilt 387 | 4 | 14 | 0 | 0 |
| 2008 Peterbilt 388 | 0 | 17 | 0 | 0 |
| 2008 Peterbilt 389 | 3 | 12 | 0 | 0 |
| 2008 Peterbilt 389k | 0 | 3 | 0 | 0 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 08V065000.
Full record for the 2009 Peterbilt 330 → · Recalls carrying a do-not-drive advisory → · Where this data comes from →