2022 Ram 3500 complaints

The engine stopped while driving with no warning and provided no opportunity to exit the travel lane of the road. No warning lights were illuminated on the dashboard and all gauges appeared normal leading up to the event. This event is extremely frustrating, but I am thankful that it didn't happen on the interstate as there is no telling what the outcome may have been......... Leading up to the event, I had been driving on the interstate around 70mph for about 180 miles since the last restart. I exited the interstate and made it about 3/4 miles on a secondary road and the engine died without warning and the truck came to a quick stop in the lane of travel. No abnormal sounds were observed, just a sudden unwelcome deacceleration that did not provide enough time to exit the lane of travel. It was like stepping on the brakes. I attempted to restart the truck and the starter would not crank the engine and briefly pulled enough voltage to kill all the electronics. I attempted starting it again with a jump box attached and met the same result. The computers freaking out from the low voltage during the starting attempts wouldn't allow me to put the truck in neutral to move it out of the lane of travel. A police officer called for the tow truck on rotation since I was stuck in a live travel lane. The truck was towed to the Dealer on 8/19/2024 after the service department had closed and still would not turn over when removed from the tow truck. There were no signs of any fluids leakin

The contact owns a 2022 Ram 3500. The contact stated while driving 70 MPH, the hood was raising up and down. The vehicle was taken to the dealer; however, the contact was informed that it was a design flaw by the manufacturer. The contact was informed that there was no fix for the issue. The contact stated that the vehicle was not driven often; however, when the vehicle was driven it was normally a 600-mile trip. The contact was concerned that the hood would unlatch while driving. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 27,000.

My truck experienced a total transmission failure while at Highway Speed towing a 5th wheel camper on Interstate I95. This transmission failure is a known issue and has a TSB 21-002-23. A k1 clutch clip becomes dislodged and the transmission will not function. Being stranded and unable to move on a busy highway is unsafe and terrifying. Aisin Transmission and RAM are well aware of this failure however I was never notified about the potential failure nor has a recall been issued. The failure occurred instantly with no warning in a vehicle with 16,000 miles and less than 2 years old. My vehicle has been repaired and the failure was confirmed as the K1 clutch clip failure. There should be an immediate recall for this known failure to be repaired prior to being stranded on the side of the highway, 400 miles from home with my wife and kids. It's shameful RAM has ignored this problem!

The transmission wont shift gears. We were stranded at a campsite. The problem has been confirmed by Santa Rosa Ram. Inspection by RAM directly is unknown. Loud clanking noises were heard many days before the final failure.

While towing a camper 5 hours from home. Traveling approx 5-10 MPH in slow moving traffic the 2022 Ram 3500 HO with Aisin Transmission made a loud and sudden pop. It lost all forward power as if it went into neutral. Barely using momentum to limp the truck off the side of a busy highway during rush hour with my family on board.

Transmission had 2 loud clunk, while stopped, and shifting into drive, lost all forward gears. Reverse works. Truck has 17000 miles.

On June 5th, 2024 while pulling a travel trailer on vacation, we stopped for a short break and left the truck running. When we went to get back on the highway, I put the truck in gear and nothing happened. Truck would only shift into reverse with a violent bang. Would not go forward. Unhooked my trailer and shifted into REVERSE a few times and finally got the truck to inch forward at HIGH RPM. Towed to a Ram dealer and they confirmed a snap ring failure caused the forward clutches to go out. Truck is still awaiting repairs 445 miles from home.

The Deisel Exhaust Fluid (DEF), SUPPLY LINE (part #57008975AA) has been replaced on my truck 4 times in 113 k miles. It now needs replaced again. The last 2 times were less than 5000 miles each. It is a plastic line that runs from the DEF tank and passes nearby the exhaust filter which is very hot. A RAM dealer in Georgia told me they have sold/replaced many of these lines. When cracked, they leak DEF in large volumes on the ground which then becomes contaminated.

I was driving coming to a stop for a red light and it turns green. As I go to press on the gas my dashboard lights up with error codes stating a 4WD System error of some kind. As I go to press on the gas the truck loses power and acceleration and starts making a horrible clunking noise. I took it to the dealer because it seems like a transmission issue. This is a 2022 Ram 3500 with 9300 miles at time of failure. I would hate to see what happens if I was towing a large load to lose power all of a sudden risking my life and others around me. Based on what I have researched it seems like a K1 Snap Ring issue to the T. Waiting on the "official" diagnosis from the dealer.

When pulling onto the interstate on ramp (45 mph) the truck attempted to shift up when all transmission power failed. The engine ran fine, just no power. I was able to safely pull to the shoulder and park . s Shifting from drive to neutral to park and back to drive still did not resolve the issue. I put the truck in park and shut off the engine . The transmission fluid temp, color and level was ok. I restarted the truck and shifted to reverse with no problem then to neutral and drive. It felt that the transmission engaged and I slowly crept forward. I slowly accelerated and was able to resume speed. No subsequent loss of power has been encountered, BUT the truck now has slippage from 1st to 2nd gear and occasionally 3rd. Had I been on the interstate this has a potential for serious accident incident. This is the first time this has happened. I had bought the truck used and certified from the dealer in Pennsylvania. There is currently 28k miles on the truck. There were and still no warning or codes to indicate a problem This occurred [XXX] 2024. No dealer, tech or shop has looked at this issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My truck experienced the K1 snap ring failure at 3,600 miles.

This vehicle left me stranded due to Aisen transmission failure with only 2000 miles on the vehicle. Has been at dealer for 3 months awaiting rebuild due to faulty clip. Why is nothing being done? Why am I not getting a new transmission? or better yet forced buy back

Discovered that the passenger side seat belt warning chime does not operate when someone is sitting in the passenger side front seat. I contacted the manufacturer just now who told me no one will be in contact with me, they just take the information. I asked the value of their customer care and they responded I don’t know. A case number was assigned but again, I was informed no one will make contact. I would think this is a safety law violation especially since we live in California. I need help here please.

Transmission went out. Lost 1-4th gear. It was the K1 snap ring in the transmission. Lost power going up a mountain in a National Park exhaust brake either to slow vehicle. Check engine light came on

The dealer and manufacture have not been able to fix emissions issue. It has cause severe fuel saturation in oil and has cause severe motor damage. No one cares and they brush it off as no big deal.

K1 Clutch Snap Ring failure in the AS69RC Aisin transmission. I loss all forward motion on [XXX] in Iowa City. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My trucks transmission experienced a complete failure, it is currently at the dealership awaiting parts and repair The failure renders the truck without any forward power almost immediately with only reverse left functioning, we were fortunate that it broke down in a residential neighborhood and not the freeway. The truck was towed to the local dealership, they tore down the transmission and confirmed a K1 snap ring failure and that it would be covered under wtty. I got a malfunction indicator light a few days prior then a message on the dash "4 wheel drive system temporarily unavailable" about 10 miles before complete failure. CSN 71A appears to have been issued and sent to some truck owners to advise snap ring replacement as a preventative measure, however my truck was not included in the CSN campaign, not sure why

Concerned that my truck may be affected by the Aisin K1 snap ring failure problem currently being investigated by NHTSA. I have no way of knowing whether or not my transmission is reliable long term, nor can I prove to a future buyer that it is safe and reliable. Not only does this issue affect my trust in using the truck, but it also has a significant negative impact on the resale value of the truck. Buyers are aware that 2022 Aisin trucks have issues and this makes the vehicle harder to sell.

I am very concerned that my trucks Aisin transmission may fail while towing heavy loads at highway speeds as this seems to be an issue with my model year and month it was built.

1, The Aisin AS68RC transmission failed. The dealership had to ship the defective complete back to Aisin . 2. On [XXX] with only 2,886K miles while on Interstate [XXX] in Boston Massachusetts . I just entered the highway and was getting into the middle lane getting up to high way speed. The Tachometer shot up in rpm’s and there was no more forward gear. I was doing about 50-60mph. I had to cost from the middle lane to the brake down lane with my 20’ trailer in tow in heavy traffic. Once in the brake down lane I was able to go in reverse but couldn’t go forward. Loud clunking when put into gear and trying to move forward. 3. The vehicle was towed to the dealership from [XXX] that night to Herb Chambers Millbury Ram and confirmed transmission failure. 4. Aisin sent a complete transmission assembly to the dealership for installation. So the dealership inspected it. 4. There were NO warning lights before transmission failure. I did notice the truck felt Rough over 40 mph before transmission failure since I picked it up brand new from the dealer. Absolutely NO warning light/ indicator prior to Transmission failure!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Emissions system is performing DPF filter regeneration every 100-150 miles.

Driving south on [XXX] just south of Greenville, SC. With no warning the truck wouldn't go, upon quickly diagnosing I determined I had no transmission. Luckily was able to make it to the emergency lane and come to a safe stop. Also was pulling a fifth wheel camper at the time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Sudden loss of forward gears. Failure happened on highway at highway speeds. Had to carefully maneuver the truck off the road. Failure in both towing and unloaded operation. Truck will not shift in or out of drive (1-4) but reverse is still functional. Diagnostic trouble code P0731-00 and P0734 "Gear 1 and 4 Shift Incorrect Ratio". Both the dealer and RAM confirm this transmission failure. RAM has realeased a TSB which covers this failure but hasn’t released a recall.

February 19,2024. Towing a bumper pull toy hauler approximately 10,000 pounds, just merged onto a two lane highway when the check engine light came on and truck jerked a couple times, I pulled to side of highway where there is not much of a shoulder. I placed it in park, sat a few seconds then into drive when I noticed no forward motion in drive. I turned truck off a few minutes, restarted, check engine light still on, no movement in drive mode. I did have reverse functioning. This was very dangerous situation, high speed two lane highway, small shoulder, many large RVs and 18 wheeler trucks flying by. 5 weeks truck is at dealer, they say it’s done, they attempt to bring it to me at the shop, then tell me check engine light on, throwing multiple codes. They still have truck, tell me they will find out issue asap.

The contact owns a 2022 Ram 3500. The contact stated while driving 30 MPH and towing an RV, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the failure persisted, after which the contact became aware that the vehicle was only able to shift into reverse. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired due to parts not being available. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 17,000.

On [XXX] I was driving my newly purchased 2022 Ram 3500 on [XXX] near Mead, CO when my check engine light illuminated and I immediately lost forward driving gears. I was able to coast safely to the side of the highway. I purchased this truck new on [XXX] from Perkins Motors in Colorado Springs. After stopping on the side of [XXX], I attempted to continue forward but had no power. I placed the truck in reverse and felt a sudden jerk. I then placed the truck in park and shut it off. The truck had 1,043 miles on the odometer when the transmission failed. I waited on the side of the highway for 15 hours to be towed 110 miles to the Ram dealership closest to my home. My truck spent 5 weeks at the dealership waiting on parts. Colorado Springs Ram service department informed me that the snap ring in the K1 clutch kit had failed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My vehicle was affected by the Customer Satisfaction Notice 71A: Aisin K1 Snap Ring Failure. I saw an article that an investigation was being opened into this issue. I can provide data from my experience if it is helpful.

The contact owns a 2022 Ram 3500.The contact received notification of NHTSA Campaign Number: 23V060000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

DEF fluid froze leaving crystals that obstructed computer reading of DEF tank. This would have forced vehicle into emergency 5 mile an hour limp mode. Taken to local Dodge/Ram dealer that had nearly THIRTY other diesel trucks with same problem ahead of me. Once repaired to OEM specs, the service manager stated it will happen again. Dodge/Ram acknowledges this has been an issue for years. In Alaska winters this situation could very well be life threatening!!

Truck lost all forward gears while driving down the highway, only had 6418 miles on it

HIGH PRESSURE FUEL PUMP WENT OUT. I KNOW THEY HAD A RECALL ON THIS BEFORE. TRUCK IS DOWN AND IT WILL COST TO MUCH TO REPLACE FUEL SYSTEM

When in reverse in dark conditions rear camera view is "white washed" making visibility impossible.

The contact owns a 2022 Ram 3500. The contact stated that while driving at various speeds, the transmission suddenly downshifted, causing the vehicle to decelerate abruptly. Additionally, while driving the vehicle, the engine temperature gauge increased to high, with a burning plastic odor and smoke fumes entering the cabin of the vehicle. The vehicle was taken to the local dealer and the PCM was reprogrammed, and the temperature sensor was replaced; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was 32,000.

Truck has 61423 miles. Started to hear a slight grinding noise from front brakes 70 miles ago. Started to get worse. Suddenly pedal went to floor and lost all front brake pressure and rear brakes did about nothing to help stop. Limped truck back to my garage. Upon inspection, front left outer pad was completely gone. Caliper was directly making contact with rotor. Inner pad still has plenty of use left. Inner pad has the metal piece to make the noise to alert you that your pads need to be replaced. I can supply pictures of caliper missing 3/16" of material and remaining pad surface.

The transmission failed while driving in a remote area 600 mi from home. Check engine light came on. Truck was in the shop for over 50 days. The truck had less than 3,000 miles on it when the transmission failed.

Aisin Transmission Failure at 10,462 miles. Date of failure 09/09/2023. No warning lights, messages or other symptoms Vehicle was towed to Dealership on 09/12/2023 Failure confirmed by Champion Dodge, 907 S Clinton Street, Athens, AL 35611 / 8002395692

I purchased a FACTORY Trailer Tire Pressure Monitoring System for my fifth wheel. Factory TTMS system allows up to 5-6 different trailers per vehicle. TTMS allows owner to enter minimum PSI per trailer. The RAM factory system does not work as advertised. I paired wheel sensors to TTMS in vehicle and set minimum PSI to 100. When I shut vehicle off the preset reverts back to factory 50 PSI. Also TTMS recognizes 3 wheel sensors 50% of the time. The other 50% dashboard shows red lines instead of trailer tire pressure. I brought vehicle to dealership after creating a case file with Ram care #87574156. Case file was created due to numerous complaints of Ram HD forum 2019-2022 model years. Ram care notified dealer that no repair authorized without trailer being present. My Ram dealer parking lot is barely large enough for my Ram 3500. I notified Ram care and dealer that the issue was with vehicle software and not trailer sensors. After weeks of inaction from Ram care I was notified that the dealer must remove aftermarket trailer tire pressure monitoring system at my expense (6 hours labor) and only then could they repair system. I attempted to explain that I paid $500 for the FACTORY system but Nikkita from Ram care would not listen. Ram care has my VIN they easily check my vehicle options but their priority was to close case file and hope I would go away quietly. Ran care repeatedly closed my file claiming they couldnt contact me. All but three of my calls went to voicemail. I call

The contact owns a 2022 Ram 3500. The contact received notifications of NHTSA Campaign Numbers: 22V835000 (Power Train) and 23V060000 (Electrical System) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2022 Ram 3500. The contact received notification of NHTSA Campaign Number: 23V060000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

I was traveling in my new 3 month old 3500 Ram with, at the time of failure, 3000 miles on the odometer. Starting from a standstill on level ground. I lost all forward momentum. I lost forward gears 1-4 due to what is now known as the K1 clutch snap ring failure. I was traveling cross country and had to leave my truck at a dealership over 1000 miles from home. ruined vacation and had to catch a flight back home . It took 6 months to get my truck back.

The contact owns a 2022 Ram 3500. The contact stated that while driving at an undisclosed speed, the electronic overlay was inoperable and disabled the steering. The contact was able to safely drive the vehicle off to the shoulder of the roadway. The vehicle was taken to the dealer and diagnosed with a failed steering gear box. The contact was informed that the steering gear box needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 30,000.

Backup camera is unusable do to the brightness on the screen.

Driving vehicle and lost power went into limp mode had no gears forward Truck would not go over 1500 rpm Check engine light came on Kept saying 4 wheel drive not available but was in 2 wheel drive Hear clunk when shifting but no gears respond! Occurred when driving definitely a safety issue

-What component or system failed or malfunctioned, and is it available for inspection upon request? A: Transmission -How was your safety or the safety of others put at risk? A: I was never contacted by RAM regarding the possibility of a catastrophic power loss c/o transmission failure for my RAM truck. While driving E/B on Interstate 15 in the # 2 lane at highway speeds and going up a grade, the vehicle suffered complete forward momentum loss and only engine revving was occurring, while losing forward momentum & speed. I had to negotiate several, extremely busy/heavy traffic tractor-trailer filled traffic lanes to make it to the emergency shoulder of the roadway before losing all forward momentum and miraculously did not have a collision with high-speed heavy traffic. -Has the problem been reproduced or confirmed by a dealer or independent service center? A: I took my RAM to a nearby dealership. Based upon my description of the event and their subsequent vehicle inspection it was revealed and confirmed that somehow my RAM was erroneously, or purposely circumvented from the current transmission failure recall. The dealership discovered the issue with my transmission failure was identical to an in-progress NHTSA bulletin: 71A with TSB 21-00-2-23 (Attached PDF) and subsequently performed the repair free of charge. -Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? A: No, it was inspected and serviced by only by an autho

The contact owns a 2022 Ram 3500. The contact received notification of NHTSA Campaign Number: 23V060000 (Electrical System) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

My Ram 2022 3500 truck has18,888 miles and the transmission has to be replaced. I had it in for a recall and asked them to check the transmission for shifting issues. I was informed that the transmission needed to be replaced. I pull a 38 foot Fifth Wheel approximately 15 thousand pounds. If the transmission would have failed on the road it could be catastrophic. Dodge is replacing the transmission with the same one with no fix for the problem that inherently causes the failure which has been many. The repair order# is 459891. The part # is R8447797AA. I was given a case # by Ram Care 87401824. I feel stuck spending 100K for a new truck and don’t feel safe putting back on the road risking the safety of my family and others. I have previously had a Commercial Drivers License and have driven trucks for over 40 years. Transmission failure at high speed can be catastrophic.

Received a recall from FCA regarding exhaust module and sensor not installed. They offered a 12 month warranty. But damage to diesel exhaust filter has already happened. Owners should be given a lifetime warranty. This was an expensive truck and a replacement filter is $8,000 which I will be on hook for after my warranty is over. Recall Y43

Transmission failed. 8,500 miles on the truck

The contact owns a 2022 Ram 3500. The contact stated while driving 10 MPH and depressing the accelerator pedal, the vehicle failed to respond. The contact stated that the gear shifter was in drive (D); however, the vehicle operated as if the transmission was in neutral (N). The check engine warning light was illuminated. The contact was able to veer to the side of the road after persistently depressing the accelerator pedal. The contact stated that the transmission was stuck in fifth gear. The vehicle was towed to the residence. The local dealer was notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 1,945.

Transmission went out, under 20k miles. The dealership has had the vehicle for over two months and they are still waiting for parts.