2005 Nissan Titan complaints

CRACKS IN BOTH (LEFT & RIGHT) EXHAUST MANIFOLDS ON THE SAME MANUFACTURING WELD. NOISE INCREASE, LOSS OF FUEL ECON. REPLACED BOTH MANIFOLDS AT COST OF APP. $2,000.00. *TR

AT ALMOST 60,000 MILES TRUCK REAR STARTED MAKING INTERMITTENT CLANKING SOUND ,TOOK TO LOCAL MECHANIC AND WAS INFORMED THAT THE REAR END HAS FAILED METAL PARTICLES FOUND IN OIL. CONTACTED NISSAN DEALER AND SAID TO BAD WARRANTY IS OVER I WILL HAVE TO PAY TO GET REPLACED. *TR

I HAVE A 2005 NISSAN TITAN P/U IN WHICH THE DOOR HANDLE CABLES GET FROZEN IN THE WINTER MONTHS. I FEEL THAT THIS IS HUGE SAFETY ISSUE THAT NISSAN HAS FAILED TO ADDRESS AS A RECALL! I CANNOT GET IN OR OUT OF MY VEHICLE EXCEPT THROUGH THE DOOR WINDOWS WHEN THIS HAPPENS. I HAVE ALREADY HAD THIS VEHICLE IN TO MY DEALERSHIP ON 2/15/08 TO GET REPAIRED, BUT THEY HAD TO ORDER OTHER PARTS THAT THEY SAID THEY DIDN'T KNOW THAT THEY NEEDED. THEY DIDN'T ORDER THEM OVERNIGHT AND THERE WAS NO SENSE OF URGENCY ON THEIR PART TO RECTIFY THE PROBLEM! IT STILL IS NOT REPAIRED. *TR

REAR END WENT ON MY 2005 NISSAN TITAN COSTING ALMOST $4000 TO HAVE REPLACED. I DO NOT DRIVE OFF ROAD, ONLY TOW A 3500LBS BOAT 1/2 A MILE TWICE A YEAR. *TR

REAR AXLE SEAL FAILURE ON BOTH AXLES. *TR

REAR AXLE SEAL LEAK. *TR

I'D LIKE SOMEONE TO CALL ME. *TR

I TOOK MY VEHICLE IN FOR A MAINTENANCE SERVICE WHEN THE DEALERSHIP INFORMED ME OF THE TROUBLED REAR DIFFERENTIAL. *TR

I OWN A 2005 NISSAN TITAN CREW CAB AND WHEN THE TEMPS DROP BELOW FREEZING THE DOOR HANDLES OR LATCHES FREEZE UP AND YOU CAN NOT SHUT THE DOOR, YOU HAVE TO HOLD THEM CLOSED WITH YOUR HAND WHILE DRIVING. THERE WAS NOTHING THAT I DID LEADING UP THE THE FAILURE OTHER THAN MAYBE WASH MY TRUCK. I WAS TOLD THAT THERE WAS NO RECALL FOR THIS PROBLEM AND THAT I WOULD HAVE TO PAY $500 OUT OF POCKET FOR SOMETHING THAT COULD END UP KILLING A CHILD. I TOOK A FRIEND OF MINES CHILD TO SCHOOL TODAY AND THE DOOR OPENED AND WHEN I CLOSED IT EVIDENTLY DID NOT LATCH BECAUSE THE CABLE WAS FROZE UP. GOOD THING THAT HE WAS IN A CAR SEAT AND BUCKLED IN CAUSE WHEN I TURNED THE CORNER THE DOOR FLEW OPEN. THIS IS RIDICULOUS AND SOMEONE NEEDS TO STEP IN AND DO SOMETHING BEFORE SOMEONE GETS HURT. *TR

PURCHASED 2005 NISSAN TITAN TRUCK ON 2/1/2005. ON 4/21/05 WITH 6,000 MILES, TRUCK SHOOK/SHIMMIED WHEN APPLYING BRAKES. UNDER WARRANTY, NISSAN DEALER REPLACED FRONT PADS AND RESURFACED THE FRONT ROTORS. ON 6/23/05 WITH 11,000 MILES, TRUCK AGAIN SHOOK/SHIMMIED WHEN APPLYING BRAKES. STILL UNDER WARRANTY, NISSAN DEALER REPLACED FRONT AND REAR PADS AND ROTORS AGAIN! ON 1/14/08, NEEDED TO REPLACE THE CRAPPY GOODYEAR WRANGLER SR-A (P265/70R18) TIRES THAT CAME WITH THE TRUCK (ALSO HAD 3 FLAT TIRES) EVEN THOUGH I ROTATED THEM REGULARLY (LESS THAN 40,000 MILES). TODAY, THE TIRE CENTER INDICATED I NEEDED NEW BRAKES. CALLED NISSAN DEALER AND AM AGAIN TAKING THE TRUCK INTO SERVICE TO CORRECT AND GET NEW ROTORS/PADS. BY THE WAY, THE WARRANTY ON MY TRUCK FOR THIS REPAIR RUNS OUT ON 2/1/08. GOING FORWARD, I WILL HAVE TO BE RESPONSIBLE TO PAY. THIS STINKS! HOW COME THERE HASN'T BEEN A RECALL AND CORRECTIVE PROCEDURE IMPLEMENTED? $37,000 VEHICLE! *TR

I PURCHASED THIS 2005 NISSAN TITAN NEW. DURING A RECENT OIL CHANGE AND SERVICE AT 34,150 MILES I NOTICED FLUID LEAKING ONTO THE BOTH SIDES OF THE REAR BRAKE ROTOR ASSEMBLIES. AT FIRST I THOUGHT IT WAS BRAKE FLUID BUT UPON CLOSER EXAMINATION I DISCOVERED IT WAS GEAR LUBE FROM THE REAR AXLE. IT WAS LEAKING PAST THE SEALS AND DOWN THE BACKING PLATES AND DRIPPING ONTO THE WHEEL AND SOME OF THAT OIL BEING SLUNG ONTO THE BRAKE ROTORS THEMSELVES. I STOPPED DRIVING THE TRUCK SINCE I FELT THIS IS NOW A SAFETY ISSUE AND CALLED THE DEALER. THEY ADVISED ME TO BRING TRUCK IN FOR INSPECTION WHICH I DID ON 1/3/08 AT 34,206 MILES. THEY CONFIRMED SEALS ARE LEAKING AND ORDERED PARTS. I ASKED THEM TO MAKE A NOTE ON THE SERVICE ORDER THAT I HAVE STOPPED DRIVING TRUCK UNLESS NEEDED. THEY THEN CALLED AND TOLD ME PARTS ARE IN AND TRUCK WAS BROUGHT IN FOR REPAIR ON 1/14/08 AT 34,361 MILES. THE PARTS THAT WERE REPLACED UNDER WARRANTY ARE AS FOLLOWS; QTY-2 P/N:43070-7S200 AXLE SPACER, QTY-2 P/N:40210-7S210 REAR BEARING, QTY-2 P/N:43252-7S200 OIL SEAL, QTY-2 P/N:01541-0001U SNAP-RING AND QTY-1 999MP-DF100P SYNTHETIC DIFF FLUID. I AM VERY HAPPY THAT NISSAN REPAIRED AND COVERED THIS UNDER WARRANTY. BUT, I AM VERY DISAPPOINTED THAT THIS TYPE OF FAILURE OCCURED AT SUCH LOW MILEAGE. *TR

REAR SEAT BELTS (LEFT & RIGHT) HAVE NO HEIGHT ADJUSTMENTS WHICH CAUSE MY GRANDMOTHER & MOTHER (BOTH ARE SHORT ABOUT 5 FT TALL) TO NOT USE THE SEAT BELT CORRECTLY OR NOT TO USE IT AT ALL BECAUSE THE BELT IS RUBBING THEIR NECKS CAUSING SLIGHT RED BURNS ON THEIR NECKS EVERY TIME THEY USE IT. *TR

REAR END FAILURE, BROUGHT TO DEALER AND REPLACED NO QUESTIONS ASKED. VEHICLE HAD TO BE TOWED TO DEALER FOR SERVICE. *TR

KNOCK NOTICED ON TAKE OFF. INTERMITENT. ON DAY OF FAILER ONE HUGE BACK ON TAKE OFF FROM STOP SIGN AND EVERY STOP THERE AFTER, WAS VERY CLOSE TO DEALER SHIP, LIMP IT THERE TO GET CHECKED OUT. REAR END FAILER WAS THE PROBLEM, COMPLETE REAR END REPLACEMENT BY DEALERSHIP UNDER WARANTEE. FAILER AT 26000 MI. *CN

TL*THE CONTACT OWNS A 2005 NISSAN TITAN CREW CAB. WHEN IT BECOMES REALLY COLD IN THE SINGLE DIGITS, THE DRIVER'S SIDE FRONT DOOR DOES NOT OPEN WHEN THE RELEASE BUTTON IS RELEASED ON THE REMOTE OR ON THE DOOR PANEL. THE CONTACT CAN HEAR IT CLICKING, BUT HE CANNOT OPEN THE DOOR. HE CAN PULL OUT THE HANDLE, BUT IT DOES NOT DISENGAGE THE LOCKING MECHANISM. THE FAILURE IS CONSTANT AND DEPENDENT UPON THE TEMPERATURE. THE VEHICLE IS NO LONGER UNDER WARRANTY AND THE DEALER STATED THAT THE CONTACT WAS RESPONSIBLE FOR THE REPAIR. THE CURRENT MILEAGE WAS 49,200 AND FAILURE MILEAGE WAS 49,150.

DVR REAR AXLE SEAL LEAK (WHICH SATURATED BRAKE PADS LEADING TO POSSIBLE SEVERE PROBLEM, BUT WAS CAUGHT BEFORE ANY SITUATION) AT 28,XXX MILES, REAR AXLE SEAL LEAK PASS. SIDE (WARRANTY OPTIONED TO REPLACE WHOLE REAR END AXLE ASSEMBLY AT 36,200 MILES, REAR AXLE SEAL LEAK BOTH SIDES INCLUDING 3RD MEMBER SEAL AT 60,XXX MILES, REAR END RING AND PINION "GRENADED" AT 61,XXX MILES (EXTENDED WARRANTY STILL UNSURE ON COVERAGE DUE TO LACK OF REAR END MAINTENANCE RECORDS, I. E. - LUBE CHANGE) (REQUIRED MAINTENANCE IS EVERY 30,000 MILES, I HAVE NOT PUT 30,000 MILES ON THE VEHICLE BEFORE A MAJOR ISSUE.)*CN

I HAVE A NISSAN TITAN AND THE OTHER DAY I WAS TAKING OFF MY RECEIVER HITCH WHEN I NOTICED THAT MY REAR AXLE SEAL WAS LEAKING BAD, BUT IT HAS NOT BEEN LEAKING FOR LONG CAUSE I CHECKED IT OUT THE WEEK BEFORE. I HAVE TO TAKE IT IN AND SEE WHAT THE NISSAN DEALER SAYS. *TR

AT 16,000 FIRST AXLE SEAL LEAK. THEN AT 74000 MILES SECOND LEAK. FIRST WAS FIXED BY NISSAN AND SECOND LEAK WAS TOLD COULD NOT BE FIXED,COMPLETE REAR DIFFERENTIAL HAD TO BE REPLACED OIL GETTING ON BRAKES AND REARS THAT COULD POSSIBLY BREAK EASILY COULD BE A SAFETY CONCERN. SEEMS TO BE A COMMON PROBLEM WITH SOME TITAN TRUCKS. THIS IS THE FIRST REAR DIFFERENTIAL I HAD GO IN 48 YEARS OF DRIVING AND ATTRIBUTE THIS TO A BAD DESIGNED AND COST CUTTING BY NISSAN. *TR

TL*THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 20 MPH, THE CONTACT HEARD A LOUD POP. THE VEHICLE BEGAN TO JERK AND WAS IMMEDIATELY PULLED OFF THE ROAD. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE REAR DIFFERENTIAL FAILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 72,000.

REAR AXLE SEAL LEAKING PASSENGER SIDE, LEAKING ALL OVER REAR DISC BRAKE. *TR

TOWING 5000 LBS TRAILER FOR 15 HOURS. REAR DIFFERENTIAL FAILED AND LOCKED UP IN A TURN. AFTER THAT THE VEHICLE COULD NOT MAKE ANY TURNS FASTER THAN ABOUT 2 MPH SAFELY WHILE THE DIFFERENTIAL WAS LOCKED. VEHICLE IS AT THE DEALER HAVING THE REAR DIFFERENTIAL REPLACED UNDER WARRANTY. *JB

LOUD POP COMING FROM UNDERNEATH TRUCK DURING BACKING UP AND TURNING. LATER SAME DAY NOTICE REPEATED LOUD POPS DURING TIGHT TURNS TO THE LEFT. DROVE SLOWLY TO NISSAN DEALER THIS MORNING WITH POPS HAPPENING DRIVING STRAIGHT. DEALER LISTENED TO POPS AND WITHOUT ANY FURTHER DIAGNOSIS TOLD ME THEY WILL ORDER NEW DIFFERENTIAL UNDER WARRANTY. FAILURE OF REAR DIFFERENTIAL IN MY OPINION AT ONLY 52,221 MILES IS UNACCEPTABLE. MY POWER TRAIN WARRANTY WILL RUN OUT AT 60,000. DEALER WILL PROVIDE 12 MONTH 12,000 MILE WARRANTY ON NEW DIFFERENTIAL AND CLAIMS THAT IT WILL BE COVERED UNTIL 64,221 MILES. I AM NOW WORRIED THAT THE NEW UNIT COULD FAIL UNEXPECTEDLY AND CAUSE FUTURE EXCESS DAMAGE AND A POSSIBLE STRANDING OR WORSE AN ACCIDENT AT SPEED. I HOPE THAT IT DOESN'T TAKE MY DEATH OR SOMEONE ELSE?S TO HAVE THE FAILURE RATES LOOKED AT BY YOUR ORGANIZATION. *JB

LOUD POP COMING FROM UNDERNEATH TRUCK DURING BACKING UP AND TURNING. LATER SAME DAY NOTICE REPEATED LOUD POPS DURING TIGHT TURNS TO THE LEFT. DROVE SLOWLY TO NISSAN DEALER THIS MORNING WITH POPS HAPPENING DRIVING STRAIGHT. DEALER LISTENED TO POPS AND WITHOUT ANY FURTHER DIAGNOSIS TOLD ME THEY WILL ORDER NEW DIFFERENTIAL UNDER WARRANTY. FAILURE OF REAR DIFFERENTIAL IN MY OPINION AT ONLY 52,221 MILES IS UNACCEPTABLE. MY POWER TRAIN WARRANTY WILL RUN OUT AT 60,000. DEALER WILL PROVIDE 12 MONTH 12,000 MILE WARRANTY ON NEW DIFFERENTIAL AND CLAIMS THAT IT WILL BE COVERED UNTIL 64,221 MILES. I AM NOW WORRIED THAT THE NEW UNIT COULD FAIL UNEXPECTEDLY AND CAUSE FUTURE EXCESS DAMAGE AND A POSSIBLE STRANDING OR WORSE AN ACCIDENT AT SPEED. I HOPE THAT IT DOESN'T TAKE MY DEATH OR SOMEONE ELSE?S TO HAVE THE FAILURE RATES LOOKED AT BY YOUR ORGANIZATION. *JB

I SAW SOME FLUID LEAKING FROM MY LEFT REAR AXLE, OIL ON THE ROTOR. I TOOK IT TO THE DEALER AND THEY TOLD ME I NEED A WHOLE NEW AXLE, THE DIFFERENTIAL, AXLE, EVERYTHING. IT IS ON ORDER AND UNDER WARRANTY. *TR

TRUCK WAS REAR ENDED ON HIGHWAY, SUBSEQUENTLY 10 MONTHS LATER A LEAF SPRING POPPED AND WENT THROUGH BED OF TRUCK. BROUGHT IN TO HAVE REPAIRED AND SHACKLE FOR LEAF SPRING ASSEMBLY ON BACK ORDER WITH NISSAN. HAVE BEEN WAITING 24 DAYS AND COUNTING FOR THIS PART WITH NO HELP FROM NISSAN CONSMER SERVICE. HAVE MADE APRROX 15 PHONES WITH ONLY 1 RETURNED CALL WITH NO ANSWER TO STATUS OF PART. *JB

BOTH REAR AXLE SEALS ARE LEAKING. *TR

REAR END SEALS LEAK LEADING TO REAR DIFFERENTIAL FAILURE AND OIL SPRAYED ONTO REAR BRAKE ASSEMBLY. *TR

RIGHT REAR AXLE SEAL LEAK IN REAR DIFFERENTIAL OF VEHICLE.

2005 NISSAN TITAN LEFT REAR AXLE SEAL FAILURE. ON THE MORNING OF 8-21-2007 I NOTICED OIL INSIDE MY LEFT REAR WHEEL. I CLIMBED UNDER THE TRUCK AND COULD SEE CLEARLY WHERE IT HAD LEAKED OUT THE END OF THE AXLE. THE PREVIOUS DAY I HAD BEEN TRAVELING BACK TO MY HOME FROM A 6 HOUR TRIP. I FILLED UP WITH GAS ABOUT 3 HOURS AWAY FROM HOME-I DID NOT SEE ANY OIL IN REAR WHEEL (GAS CAP IS NEXT TO WHEEL). PROBLEM HAD TO HAPPEN AFTER FILL-UP-THIS IS A MAJOR PROBLEM BECAUSE I WAS TRAVELING AT NIGHT,70 MPH ON INTERSTATE. IF ALL FLUID HAD OF LEAKED OUT ,THAT COULD BE CATASTROPHIC AT THAT TIME. ALSO I DO NOT THINK THAT IT IS SAFE FOR DIFF OIL TO BE LEAKING ON REAR BRAKE DISKS. I KNOW THAT NISSAN IS HAVING PROBLEMS WITH THESE SEALS ON TITAN TRUCKS AND THINK THEY SHOULD BE MADE TO COME UP WITH A LASTING REPAIR BEFORE SOMEBODY GETS KILLED OR INJURED. MY LOCAL DEALER REPLACED THE LEAKING SEAL. *TR

REAR DIFFERENTIAL FAILURE AT 48,000 MILES. DEALER REPLACED REAR DIFF AND AXLE UNDER WARRANTY. *TR

I WAS ABOUT TO PULL INTO A MAIN THOROUGH FARE FROM A SIDE STREET GOING ACROSS ALL LANES TO TURN LEFT. WHEN I PRESSED ON THE ACCELERATOR OF THE VEHICLE I FELT A SUDDEN JUDDER FROM THE REAR AND A BIG CUT IN POWER. I ALMOST GOT HIT. I WAS ABLE TO CONTINUE GOING BUT THERE WAS POPPING NOISES COMING FROM THE REAR. THE DEALERSHIP IS REPLACING THE REAR AXLE AND DIFF. THEY WILL FURNISH ME PICTURES OF THE OLD UNIT. *TR

FAILURE OF DIFFERENTIAL ON MY 2005 NISSAN SE CREW CAB P/U. THE DIFFERENTIAL JUST FAILED AFTER ENGAGING THE 4WD ON THE FLY GOING ABOUT 25MPH ON A LEVEL SERVICE NOTHING OUT OF THE ORDINARY, IT JUST FAILED. MY VEHICLE HAD HARDLY EVER BEEN USED OF ROAD AND ONLY HAS A 35,000 MILES ON IT. I DON'T DRIVE IT HARD AND IT IS EXCEPTIONALLY MAINTAINED. THIS MAKES ME WONDER IF I SHOULD HAVE PURCHASED A TOYOTA TUNDRA OR A CHEVY SILVERADO. *TR

THE REAR AXLE OF MY 2005 NISSAN TITAN FAILED AND WAS REPLACED BY THE LOCAL DEALER. I DO NOT REMEMBER THE EXACT DATE. THE DATE I GAVE IS APPROXIMATE. *JB

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL. *TR

REAR AXLE SEAL FAILURE, LEAKING FLUID ONTO BRAKES. *JB

NORMAL DRIVING. TWO LEFT REAR AXLE SEAL LEAKS THAT LEAKED SO BAD THE BRAKES HAVE FAILED. POWER STEERING PUMP LINE LEAKED OUT ALL THE POWER STEERING FLUID. FAILED RACK AND PINION STEERING. *JB

MY 2005 NISSAN TITAN REAR DIFFERENTIAL JUST BLEW OUT AT 43,000 MILES. THIS TRUCK IS PRIMARILY DRIVEN ON ROADS, NEVER HARSH OFF-ROAD USE. USED TO PULL A 5300# BOAT. TRUCK IS EQUIPPED WITH THE FACTORY INSTALLED TOW PACKAGE. *TR

TL*THE CONTACT OWNS A 2005 NISSAN TITAN. HE NOTICED THE REAR END OF THE VEHICLE WOULD SHAKE. THE DEALER STATED THAT FLUID LEAKED WHICH CAUSED THE REAR DIFFERENTIAL SEALS TO FAIL AND THE TRANSAXLE TO CORRODE. THE CURRENT MILEAGE WAS 64,070 AND THE FAILURE MILEAGE WAS 62,000. UPDATED 09/06/07 *TR

REAR DIFFERENTIAL FAILURE BOTH REAR WHEELS LOCKED UP SPIDER GEAR FAILURE HAD TO REPLACE ENTIRE END AXEL ASSEMBLY. *TR

REAR AXLE SEALS LEAKING FLUID ONTO REAR BRAKES, REAR DIFFERENTIAL FAILURE FROM LEAKS. *TR

REAR AXLE SEALS LEAKING LUBRICATING FLUIDS ONTO REAR BRAKES. *JB

REAR AXLE SEAL LEAKING ONTO BRAKE ROTOR. *AK

ENTIRE SIDEWALL BLEW OUT. IT LOOKS LIKE THE SIDEWALL WAS CUT OUT IN A CIRCLE.

CLANKING NOISE IN REAR END. TOOK TO DEALER AND DIAGNOSED AS A REAR END ABOUT TO FAIL. REAR AXLE ASSEMBLY REPLACED.*AK

2005 NISSAN TITAN CREW CAB. REAR WHEEL DRIVE. NORMAL DRIVING ABOUT 15,000 MILES ON TRUCK. REAR END OF TRUCK BEGAN EXHIBITING A WHINE SOUND. TOOK THE TRUCK TO THE DEALERSHIP. AND THEY REPLACED THE REAR END, STATING THERE WERE NUMEROUS REPORTS OF PROBLEMS WITH THEM. *AK

LEAKING WHEEL SEAL ON RIGHT OUTBOARD AXLE

THE FRONT DIFFERENTIAL HOUSING CRACKED ON A 2005 NISSAN TITAN 4*4. TRUCK HAS 48,000 MILES AND HAS BEEN DRIVEN UNDER NORMAL CONDITIONS THIS ENTIRE TIME. DEALER IS TRYING TO AVOID COVERING IT UNDER WARRANTY. ESTIMATED REPAIR COSTS > $2,000.

REAR AXLE FAILURE. CLUNKING NOISE IN REAR AXLE UNDER ANY TYPE OF ACCELERATION. *AK

IHAVE A 2005 NISSAN TITAN AND THE REAR SEALS HAS STARTED TO LEAK ON THE REAR BRAKE AND ROTORS.THIS COULD POSSIBLE CAUSE FIRE OR LOST OF BRAKES.IN ADDITION TO THE LEAK ,THE RIGHT REAR AXLE STICK OUT MORE THAN THE LEFT.DEALER SAID THERE WAS NO CHANCE OF THE WHEEL COMING OFF AND REFUSE TO FIX IT AS A FACTORY DEFECT. MY TRUCK HAS 87000 MILES.DRIVEN OVER 5000MI BEFORE I NOTICE THE LEAK.I CUMMUTE 120 MI. DAILY TO AND FROM WORK , WHICH ACCOUNT FOR THE MILIAGE.I DID VERY LITTLE TOWING.

2 REAR END FAILURES ON 05 NISSAN TITAN. *TR