1994 Nissan Pathfinder

Defect. ON CERTAIN LIGHT DUTY PICKUP TRUCKS, THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.

Risk. THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.

Remedy. DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE. OWNER NOTIFICATION BEGAN MAY 22, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

Defect. THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.

Risk. THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.

Remedy. DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE.

WENT TO REPLACE FRONT STRUT ROD BUSHINGS AND FOUND NEARLY RUSTED THROUGH STRUT/TENSION ROD THAT CONNECTS THE LOWER CONTROL ARM TO THE FRAME ON THE DRIVER'S SIDE. THE ARM WAS BENT AT THE RUSTED SECTION AND WAS NEAR FAILURE. THIS POTENTIAL FAILURE MAY HAVE CAUSED LOSS OF STEERING CONTROL. THIS IS NOT THE FIRST RUSTED STRUT/TENSION ROD I HAVE FOUND ON PATHFINDERS. WE HAVE A 1992 WITH THE SAME PROBLEM. THERE ARE ALSO OTHER OWNERS REPORTING THIS SAME PROBLEM WHEN THEY REPLACE THE BUSHINGS. *TR

TOOK MY 1994 PATHFINDER FOR FRONT BRAKE SERVICES. THE MECHANIC INSPECTED MY TRUCK AND FOUND THE FRAME COMPLETED RUSTED AND COULD NOT PLACE ON REGULAR LIFT. I WAS TOLD THAT ENTIRE FRAME NEEDS TO BE REPLACED OR REBUILT. I WAS TOLD THAT NISSAN HAS RECALL ON PATHFINDER. I FOLLOWED UP WITH NISSAN AND WAS TOLD THAT 1994 WAS NOT ON RECALL LIST, BUT RECALL ARE FOR 1996 TO 2003 PATHFINDER. I TRY TO AVOID HIGHWAY RATTLER AND SHAKE TOO MUCH, SO I TRY TO DO CITY DRIVING. *TR

TOOK VEHICLE INTO REPAIR SHOP GETTING IT READY FOR INSPECTION. WAS TOLD BY SHOP THAT THE ENTIRE REAR FRAME OF VEHICLE IS RUSTED OUT AND IS NON-REPAIRABLE. IT NEEDLESS TO SAY WILL NOT PASS INSPECTION. THEY INFORMED ME THAT THIS IS A COMMON PROBLEM ON THIS MAKE AND MODEL. I CONTACTED THE MANUFACTURER AND THEY ARE NOT GOING TO DO ANYTHING EVEN THOUGH THIS IS A MAJOR SAFETY ISSUE WITH LOOSING THE REAR WHEELS AND CONTROL OF VEHICLE. (TOYOTA HAD SAME ISSUE WITH FRAMES SAME YEARS AND ISSUED A RECALL) LIVES ARE AT STAKE WITH THIS ISSUE AND NISSAN SHOULD BE MADE TO CORRECT ISSUE OR COMPENSATE OWNERS. DOING A SEARCH ON THE INTERNET ON THIS ISSUE I FOUND HUNDREDS OF POSTS FOR THE EXACT SAME PROBLEM ON SAME YEARS. WHAT CAN BE DONE. I NOW HAVE A WORTHLESS VEHICLE. NOTE: I PURCHASED THIS VEHICLE LESS THAN A YEAR AGO. MY MECHANIC SAID THAT IT WILL BE SUICIDAL DRIVING THE CAR, AND HE CAN'T REPAIR IT. *TR

NOTICED SAGGING BUMPER AND TOOK 1994 PATHFINDER IN FOR REPAIRS. MECHANIC TOLD ME THE REAR FRAME WAS RUSTED BEYOND REPAIR. POKED HIS FINGER THROUGH THE FRAME WITH NO EFFORT. CAR HAS BEEN CARED FOR AND HAD UNDERCOATING APPLIED. MECHANICS SAY THEY SEE THIS EXACT PROBLEM QUITE OFTEN. INTERNET SEARCH WILL REVEAL HUNDREDS OF SIMILAR CASES, INCLUDING CAR FALLING APART WHILE MOVING. *TR

TL*THE CONTACT OWNS A 1994 NISSAN PATHFINDER. WHILE THE VEHICLE WAS PARKED, THE CONTACT OBSERVED THAT THE FRONT DRIVER'S AND PASSENGER SIDE MAIN FRAME EXHIBITED SEVERE CORROSION AND RUST. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR INSPECTION, BUT THEY WERE UNABLE TO ASSIST WITH THE REPAIR. PHOTOGRAPHS WERE TAKEN OF THE VEHICLE AND FORWARDED TO THE MANUFACTURER FOR FURTHER INVESTIGATION. THE CONTACT STATED THAT THERE WERE NO RESOLUTIONS WITH THE MANUFACTURER. THE VEHICLE IS CURRENTLY NOT BEING DRIVEN DUE TO THE SAFETY HAZARD. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 103,195. UPDATED 07/17/09. *LJ UPDATED 07/17/09.*JB

TL*THE CONTACT OWNS A 1994 NISSAN PATHFINDER. WHEN THE CONTACT TOOK HIS VEHICLE IN FOR INSPECTION, HE WAS INFORMED THAT THE ENTIRE FRAME WAS RUSTED BEYOND REPAIR. THE INSPECTOR WAS ABLE TO PUSH HIS FINGER THROUGH WHAT USED TO BE A STEEL PART OF THE FRAME. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER. HE SPOKE WITH THE MANUFACTURER AND THEY STATED THAT THEY COULD NOT ASSIST. THE CURRENT AND FAILURE MILEAGES WERE 135,166.

TOOK VEHICLE INTO REPAIR SHOP GETTING IT READY FOR INSPECTION. WAS TOLD BY SHOP THAT THE ENTIRE REAR FRAME OF VEHICLE IS RUSTED OUT AND IS NON-REPAIRABLE. IT NEEDLESS TO SAY WILL NOT PASS INSPECTION. THEY INFORMED ME THAT THIS IS A COMMON PROBLEM ON THIS MAKE AND MODEL. I CONTACTED THE MANUFACTURER AND THEY ARE NOT GOING TO DO ANYTHING EVEN THOUGH THIS IS A MAJOR SAFETY ISSUE WITH LOOSING THE REAR WHEELS AND CONTROL OF VEHICLE. (TOYOTA HAD SAME ISSUE WITH FRAMES SAME YEARS AND ISSUED A RECALL) LIVES ARE AT STAKE WITH THIS ISSUE AND NISSAN SHOULD BE MADE TO CORRECT ISSUE OR COMPENSATE OWNERS. DOING A SEARCH ON THE INTERNET ON THIS ISSUE I FOUND HUNDREDS OF POSTS FOR THE EXACT SAME PROBLEM ON SAME YEARS. WHAT CAN BE DONE. I NOW HAVE A WORTHLESS VEHICLE. NOTE: I PURCHASED THIS VEHICLE LESS THAN A YEAR AGO AND IT HAD A NEW PA INSPECTION ON IT. SHOP SAYS THIS FRAME ISSUE SHOULD HAVE BEEN EASILY SEEN AND VEHICLE SHOULD NOT HAVE PASSED INSPECTION. *TR

I NOTICED DURING ROUTINE MAINTENANCE THAT THE ENTIRE REAR FRAME OF MY VEHICLE IS ROTTED OUT, THIS SEEMS TO BE A VERY UNSAFE DEFECT. NOT DRIVABLE AT THIS TIME BECAUSE OF THE CHANCE OF FRAME FAILURE. *TR

TL*THE CONTACT OWNS A 1994 NISSAN PATHFINDER. UPON ROUTINE INSPECTION, IT WAS FOUND THAT THE CAST IRON WAS RUSTED IN THE VEHICLE FROM THE INSIDE OUT. THE INSPECTION STATION FAILED THE VEHICLE AND STATED THAT IF THE CONTACT DROVE OVER A BUMP TOO HARD, THE VEHICLE COULD SPLIT INTO TWO PIECES. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 130,000.

POWER DOOR LOCKS LOCK AND UNLOCK WHILE I AM DRIVING. "CLICK" "CLICK-CLICK" WHEN I AM DRIVING ALONE AND NOT TOUCHING ANY DOOR CONTROLS. DRIVER DOOR LOCK JAMS EASILY. CANNOT UNLOCK THE DOOR FROM THE OUTSIDE. INTERIOR PLASTIC PARTS. GASOLINE DOOR KNOB BY DRIVER'S SEAT. BROKEN QUICKLY. HINGE TO THE COMPARTMENT BETWEEN DRIVER'S AND PASSENGER SEAT.. BROKEN ALMOST IMMEDIATELY. INTERIOR PLASTIC LOCKS ON DOORS FELL OFF.

POWER DOOR LOCKS LOCK AND UNLOCK WHILE I AM DRIVING. "CLICK" "CLICK-CLICK" WHEN I AM DRIVING ALONE AND NOT TOUCHING ANY DOOR CONTROLS. DRIVER DOOR LOCK JAMS EASILY. CANNOT UNLOCK THE DOOR FROM THE OUTSIDE. INTERIOR PLASTIC PARTS. GASOLINE DOOR KNOB BY DRIVER'S SEAT. BROKEN QUICKLY. HINGE TO THE COMPARTMENT BETWEEN DRIVER'S AND PASSENGER SEAT.. BROKEN ALMOST IMMEDIATELY. INTERIOR PLASTIC LOCKS ON DOORS FELL OFF. *TR UPDATED 11/1/07 *TR

BRIDGESTONE SPARE TIRE BLEW OUT WHILE ATTACHED TO THE TIRE CARRIER ON THE BACK OF TH 1994 NISSAN PATTHFINDER. FORTUNATELY THE CAR WAS PARKED IN MY DRIVEWAY AND NO-ONE WAS NEARBY. THE TIRE WAS RUINED, AND THE TIRE COVER WAS DESTROYED. *AK

DT*: THE CONTACT STATED WHILE A GENERAL MAINTENANCE INSPECTION WAS PERFORMED BY AN INDEPENDENT REPAIR SHOP, IT WAS DETERMINED THE VEHICLE FRAME ALONG BOTH REAR AXLES WAS CORROSIVE AND THE FRAME NEEDED TO BE RESTORED. THE MANUFACTURER WAS ALERTED.

FRAME IN REAR WHEEL AREA RUSTED THROUGH ON BOTH DRIVER AND PASSENGER SIDES. UNDER COATING HAD HIDDEN THIS UNTIL A SMALL CRACK HAD APPEARED. NISSAN CANADA WAS CONTACTED BY PHONE WHO INDICATED THAT NO ACTION WOULD BE TAKEN FOR VEHICLES OVER 5 YEARS OLD. *JB

DURING A ROUTINE AUTOMOBILE CHECK UP MECHANIC NOTICED THE BODY FRAME WAS RUSTED. MANUFACTURER WAS NOTIFIED VISA E-MAIL.*AK THE FRAME OVER THE REAR WHEELS HAD RUSTED BEYOND REPAIR. THE CONSUMER STATED IT WAS NOT VISIBLE BECAUSE OF THE UNDER COATING. *JB

TRANSMISSION FAILURES ON 1994 PATHFINDER VEHICLE. * BF SINCE THE VEHICLE TRANSMISSION HAS BEEN REPLACED THE VEHICLE HAS BEEN TAKEN BACK 5 TIMES FOR VARIOUS PROBLEMS. *NM

COMPLETELY CORRODED FRAME AFT, BEGINNING AT THE FRONT OF BOTH REAR WHEEL WELLS. *PH THE FRAME CORRODED TO THE POINT THAT THE CONSUMER COULD PUT A FINGER THROUGH THE CORRODED AREAS. *NM

THERE IS A LARGE HOLE IN THE FRAME OF THE VEHICLE DUE TO RUST. CONSUMER IS AN AUTO REPAIR MECHANIC, AND BELIEVES VEHICLE IS UNSAFE TO DRIVE. *AK

AT ANY SPEED VEHICLE WAS VERY LOUD, AND THE EXHAUST SOUNDED AS IF T MARBLES WERE RATTLING AROUND. A RECALL WAS ISSUED FOR VEHICLES OF SAME MAKE/MODEL AND CERTAIN YEARS, BUT THE CONSUMER'S VEHICLE WAS NOT INCLUDED. THE BOLTS TO THE EXHAUST MANIFOLD OVERHEATED AND BROKE OFF INTO THE MANIFOLD COVER. MANUFACTURER AND THE DEALER WERE AWARE OF THE PROBLEM.*AK

UPON TAKING IN THE VEHCILE FOR ROUTINE MAINETENCE, OIL CHANGE, TIRE ROTATION, & WINETRISE SPECIAL. WAS INFORMED THAT MY EXAUSHT MANIFOLD BOLTS WERE BROKEN AND NEEDED REPLACING, AFTER THE VEHICLE WENT THROUGH TWO MAJOR INSPECTIONS NOT OVER A YEAR AGO. 1) FOR PURCHASEING A USED VEHICLE AND 2) FOR OUT OF PROVINCE INSPECTION. NISSAN CANADA KNOWS ABOUT THIS PROBLEM BUT REFUSES TO DO ANYTHING ABOUT THIS PROBLEM.*AK