2010 Mitsubishi Lancer Evolution

Defect. Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2007-2010 Outlander, 2008-2010 Lancer, 2009-2010 Lancer Evolution, and 2010 Lancer Sportback vehicles equipped with sunroofs. The sunroof glass may detach from the sunroof assembly, becoming a road hazard to other vehicles.

Risk. If the sunroof glass detaches from the assembly while driving, it can become a road hazard, increasing the risk of a crash.

Remedy. MMNA will notify owners, and dealers will replace the sunroof glass assembly, free of charge. The recall began on February 27, 2018. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-18-003.

Defect. Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2009-2011 Lancer vehicles manufactured March 16, 2009, to March 30, 2011, 2010-2011 Lancer Sportback vehicles manufactured June 17, 2009, to December 1, 2010, 2010-2011 Lancer Evolution vehicles manufactured July 14, 2009, to January 7, 2011, 2009-2011 Outlander vehicles manufactured February 10, 2009, to June 22, 2011, and 2011 Outlander Sport vehicles manufactured August 26, 2010, to November 19, 2010. In the affected vehicles, the blower motor may fail.

Risk. Failure of the blower motor may reduce the performance of the windshield defroster, diminishing the driver's visibility and increasing the risk of a crash.

Remedy. Mitsubishi will notify owners, and dealers will replace a suspect blower motor, free of charge. The recall began on June 15, 2015. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-15-003.

Defect. Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2009-2010 Mitsubishi Lancer vehicles manufactured January 12, 2009, to July 6, 2010, 2009-2010 Outlander vehicles manufactured January 12, 2009, to August 27, 2010, 2010 Lancer Sportback vehicles manufactured June 17, 2009, to June 8, 2010, and 2010 Lancer Evolution vehicles manufactured July 14, 2009, to August 4, 2010. The affected vehicles have an electronic control unit (ECU) that controls the head lights, tail lights, and windshield wipers. Due to a manufacturing error, the voltage inside this ECU may be unstable.

Risk. Unstable voltage could result in intermittent failure of the vehicle's head lights, tail lights, and windshield wipers. If the headlights and/or windshield wipers fail, the driver could have reduced visibility. If the tail lights fail, the vehicle could be less visible. Either condition increases the risk of a crash.

Remedy. Mitsubishi will notify owners, and dealers will replace the affected ECU, free of charge. The recall began on June 15 ,2015. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-15-002.

Defect. Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2008-2011 Lancer, Lancer Evolution, and Outlander; 2009-2011 Lancer Sportback, Lancer Rilliart, and Lancer Sportback Ralliart; and 2011 Outlander Sport vehicles. The affected vehicles, manufactured with 4B1 engines, have an engine pulley and belt arrangement for turning the alternator, the cooling fan and the power steering pump (if equipped). These pulleys may experience unusual wear and allow for belt detachment.

Risk. If the drive belt detaches, the battery may discharge, resulting in an engine stall, increasing the risk of a crash.

Remedy. Mitsubishi will notify owners, and dealers will replace the drive belt with a rubber belt. Drive pulleys that are excessively worn will be replaced. These repairs will be performed free of charge. The recall began on October 15, 2014. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-14-009.

Defect. Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2008-2013 Lancer Evolution vehicles manufactured from December 12, 2007, through March 5, 2013. In the affected vehicles, the clutch master cylinder can fail.

Risk. Failure of the clutch master cylinder reduces the ability to shift the vehicle into or out of gear, increasing the risk of a crash.

Remedy. Mitsubishi will notify owners, and dealers will replace the affected clutch master cylinders free of charge. The recall began on November 12, 2013. Owners may contact Mitsubishi at 1-888-648-7820. Mitsubishi's campaign number for this recall is SR-13-009.

I HAD SOME WARNING LIGHTS COME ON FOR THE ASC AND ABS SYSTEMS BEING DISABLED. I TOOK IT TO THE DEALER AND THEY SAID THE ABS PUMP WAS FAULTY AND NEEDED TO BE REPLACED FOR OVER $3000. I LOOKED ONLINE AND FOUND SEVERAL OTHER PEOPLE WITH THE SAME ISSUE OF THE BRUSHES IN THE ABS PUMP STICKING. THAT SAME ABS PUMP IS USED IN SOME BMW AND JEEP MODELS WITH NUMEROUS PEOPLE REPORTING THE SAME ISSUE. THE ASC AND ABS SYSTEMS SEEM LIKE CRITICAL SAFETY SYSTEMS THAT SHOULD BE COVERED FOR REPAIRS DUE TO THE FAILURE OF A DEFECTIVE COMPONENT. I WOULD APPRECIATE SOMEONE LOOKING INTO THIS OBVIOUS SAFETY ISSUE. THANK YOU.

TL* THE CONTACT OWNS A 2010 MITSUBISHI LANCER EVOLUTION. WHILE DRIVING HIGHWAY SPEEDS ABOVE 40 MPH, THE VEHICLE BECAME VERY UNSTABLE AND 'FOUR WHEEL DRIVE DISABLED' DISPLAYED. THE VEHICLE WAS TAKEN TO NIMAY MITSUBISHI (1011 KENNEDY AVE, KILOMETER 2.5, 787-622-0200) WHERE IT WAS DIAGNOSED THAT THE ALL WHEEL CONTROL HYDRAULIC UNIT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 41,000.

ON-DASH WARNING LIGHT OF "4WD SYSTEM SERVICE REQUIRED" CAME ON. THIS WARNING IS INDICATIVE OF A ACTIVE CENTER DIFFERENTIAL (ACD) PUMP FAILURE, GENERALLY DUE TO CORROSION FROM TREATED WINTER ROAD SURFACES AND/OR THE INABILITY TO HANDLE COLD-WEATHER CLIMATES. CAR WAS PREVIOUSLY SERVICED UNDER A TECHNICAL SERVICE BULLETIN (TSB) TO DELAY ACTIVATION OF THE ACD PUMP FOR THIS EXACT REASON 2 YEARS PRIOR TO FAILURE. MITSUBISHI HAS YET TO CORRECT THIS MANUFACTURING DEFECT AND IS CURRENTLY REFUSING TO HONOR WARRANTY SERVICE OF FAILED PUMPS UNDER THEIR 5-YEAR / 36,000-MILE POWERTRAIN WARRANTY, STATING THAT THE PUMP IS NOT REQUIRED FOR THE VEHICLE TO OPERATE SAFELY AND PROPERLY. IN CONTRAST, A WORKING ACD PUMP DIRECTLY EFFECTS THE VEHICLE'S HANDLING, TRACTION & STEERING - AND ALL 3 DRIVING PARAMETERS IMMEDIATELY BEHAVE DIFFERENTLY WHEN THE PUMP SHUTS DOWN IN SELF-PROTECTION MODE OR HAS FAILED COMPLETELY. THIS VEHICLE HAS A DRIVER-SELECTED SETTING FOR TARMAC (PAVEMENT), GRAVEL/RAIN & SNOW CONDITIONS - THESE SETTINGS ARE COMPLETELY DISABLED WHEN THE ACD PUMP HAS FAILED, OR IS FAILING (ON-DASH WARNING WITH PUMP IN SELF-PROTECTION MODE). THIS ISSUE EFFECTS SEVERAL MODELS (LANCER, LANCER EVOLUTION, RALLIART, ETC.) FROM MODEL YEAR 2008 TO 2014, AND HUNDREDS OF INSTANCES OF THIS ISSUE HAVE BEEN DOCUMENTED IN ONLINE FORUMS (AND PROBABLY SEVERAL-FOLD THAT AMOUNT THAT HAVEN'T BEEN DISCUSSED ONLINE). PLEASE LOOK INTO THIS ISSUE IMMEDIATELY, THANK YOU.

BAD INJECTOR CAUSED CYLINDER FAILURE OR VALVR CONSTANT VALVE TICK. BLOWN SPARK PLUGS CAUSED PISTON MELTDOWN CAUSING FOR THE PISTONG ROD TO SHOOT THROUGHT THE BLOCK CAUSE A FIRE TO THE ENGINE.. LUCKLY I STOP THE FIRE TOOK IT TO A DELAERSHIP TO VERIFY THE CAUSE OF THE DAMAGE BUT THE TECHNICINAS TOLD ME THAT THERES NOTHING THEY COULD DO BECAUSE THE BATTERY DIE THERE FOR IT RESET THE COMPUTER MODULE ERASING ALL THE DATA WITH THE PROBABLE CAUSE AND NOTHING WAS DONE AFTER THAT.. BOUGHT A NEW ENGINE AND NOW AFTER 20,000 MILES I GET THE SAME ISSUE BUT MITSUBISHI DOSE NOT WANNA BE RESPOSIBLE FOR A REPLACE ENGINE TO WHICH THEY REPLACE.

TRANSFER CASE IN THIS CAR OMITS A LOUD WHINING NOISE WHEN DRIVING FORWARD. NOISE INCREASES IN VOLUME THE FASTER THE CAR IS GOING. THIS WHINE IS DUE TO THE WEARING OF THE GEARS BECAUSE OF A FAULTY DESIGN. WHEN THE TRANSFER CASE WHINE HAPPENS, IT HAS A HIGH PROBABILITY OF LOCKING UP WHICH WILL CAUSE ALL WHEELS TO STOP SPINNING POTENTIALLY CAUSING A SERIOUS ACCIDENT AND POSSIBLY DEATH. *TR

AYC/ACL PUMP FAILURE. ERROR CODE C161E. SEEMS TO BE A LARGE NUMBER OF THESE ISSUES FROM OTHER OWNERS.

WHILE DRIVING NORMALLY THE MESSAGE "4WD SYSTEM REQUIRE SERVICE" CAME UP. I BOUGHT THE CAR USED 40K MILES AND NOW IT ONLY HAS 43K MILES. I HAVE DRIVEN MILDLY SINCE I BOUGHT IT AND HAVE NEVER ABUSED THE CAR. I HEARD IT'S CAUSED BY AYC ACD PUMP FAILURE, ACD C161E. *TR

ACD C161E WAS READ IN THE ECU. IT'S AYC ACD PUMP FAILURE. I DIDN'T DRIVE HARD. I DROVE NORMALLY WHICH I USUALLY DO. AND 4WD SERVICE REQUIRED COMES ON. I SEARCHED A LOT ABOUT THE ISSUE. MITSUBISHI SHOULD HAVE A RECALL ABOUT THIS ITS A COMMON PROBLEM FOR EVO I READ. *TR

ACTIVE YAW CONTROL PUMP THAT IS PART OF THE CAR'S ALL WHEEL CONTROL SYSTEM IS FAILING. PUMP IS NOT COVERED BY MANUFACTURER POWER TRAIN WARRANTY EVEN THOUGH IT'S PART OF THE POWER TRAIN. DUE TO LOCATION OF THE PUMP, IT GETS SPRAYED WITH WATER ON THE ROAD. THIS CAUSED THE PUMP TO FAIL PREMATURELY DUE TO CORROSION. *TR

THE ACD / AYC PUMP FAILED. CAN BE DANGEROUS TO LOSE AWD SYSTEM. NOT COVERED UNDER WARRANTY. *TR

WHILE DRIVING THE VEHICLE IN WARMER WEATHER, A WARNING (4WD SYSTEM SERVICE REQUIRED) IS DISPLAYED ON THE DASH AND THE S-AWC AWD SYSTEM IS DISABLED. THE ACTIVE CENTER DIFFERENTIAL AND TORQUE BIASING REAR DIFFERENTIAL ARE DISABLED, WHICH GREATLY REDUCES HANDLING AND CAUSES THE VEHICLE TO REACT DIFFERENTLY THAN NORMAL IN EMERGENCY SITUATIONS. THIS IS THE RESULT OF A FAILING ACD/AYC HYDRAULIC PUMP. MITSUBISHI WILL NOT COVER THESE PUMPS UNDER THE POWER TRAIN WARRANTY, EVEN THOUGH IT IS A VERY COMMON PROBLEM. THE PUMPS CORRODE INTERNALLY AND ARE UNABLE TO BUILD AND MAINTAIN PRESSURE. *TR

STARTED UP ONE DAY AND WENT TO DRIVE IT AND THE ALL WHEEL DRIVE PUMP HAD FAILED, CAUSED A SIGNIFICANT CHANGE IN THE HANDLING OF THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2010 MITSUBISHI LANCER EVOLUTION. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 13V446000 (POWER TRAIN) HAD SURPASSED A REASONABLE TIME FOR REPAIR. THE DEALER WAS CONTACTED FOR REPAIR BUT HAD NOT REPAIRED THE VEHICLE IN A TIMELY MATTER. THE CONTACT STATED THAT THE DEALER WAS UNWILLING TO GIVE A SPECIFIC TIME FRAME WHEN THE REPAIR WOULD HAVE BEEN COMPLETED. THE MANUFACTURE WAS CONTACTED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

INDICATED POSSIBLE CLUTCH FAILURE/CLUTCH PEDAL STICKING ISSUES TO LOCAL DEALERSHIP. CLUTCH WENT OUT BEFORE I WAS ABLE TO BRING THE VEHICLE IN FOR SERVICE. I WAS CHARGED $2700 OUT OF POCKET FOR A COMPONENT THAT SHOULD HAVE BEEN COVERED UNDER MY WARRANTY. I WAS ISSUED A SAFETY RECALL JUST RECENTLY FOR FAULTY CLUTCH MASTER CYLINDER ISSUES FOR MITSUBISHI MOTORS. DURING MY ARBITRATION WITH THE DEALERSHIP BACK IN NOVEMBER 2012, THE DEALERSHIP HAD DEEMED THERE WAS NO MANUFACTURER DEFECT, WHEN IN FACT THERE WAS A COMPONENT THAT WAS AFFECTING THE PROPER ENGAGEMENT AND DISENGAGEMENT OF MY CLUTCH. I AM CURRENTLY EXERCISING ALL AVENUES IN SEEKING A REFUND FOR REPAIRS. WHEN I SPOKE WITH MITSUBISHI THEY TOLD ME THAT ITS IS NOT PART OF THE SAME ASSEMBLY WHEN INDEED IT IS; SHARING THE SAME FLUIDS AND LINES THIS COMPONENT WAS THE SOLE FAILURE POINT RESULTING IN MY POWER TRAIN DAMAGE. *TR

THE S-AWC (SUPER ALL-WHEEL CONTROL) LIGHT CAME ON AND WAS TAKEN TO THE DEALERSHIP THAT SAME DAY. MITSUBISHI FLASHED THE ECU AND THE PROBLEM WAS FIXED. I RECENTLY NOTICED THE LIGHT BLINKING WHILE THE VEHICLE IS BEING OPERATED. I CONTACTED MY LOCAL DEALERSHIP AND THEY INFORMED THE PART IS NOT COVERED BY DRIVE TRAIN WARRANTY AND MY VEHICLE IS NOT COVERED BECAUSE IT OLDER THAN 3 YEARS. THE VEHICLE WAS PURCHASED NEW IN JANUARY 2010; THIS MAKES IT 3 YEARS 10 MONTHS OLD AT TIME OF INCIDENT WITH LESS THAN 36K ON THE ODOMETER. *TR

4WD SERVICE REQUIRED LIGHT APPEARED. LIGHTS STAYS ON FOR A FEW DAYS. WENT TO MITSUBISHI DEALER SERVICE AND AWC PUMP HAS FAILED. IM AT 50,000 MILES AND CAR IS 4 YEARS OLD, SO IM WITH IN THE 5YR/60K MILE DRIVETRAIN WARRANTY, AND WARRANTY WILL NOT COVER IT. IT IS OBVIOUSLY A DRIVETRAIN PROBLEM. LET ALONE IT HAS HAPPEND FREQUENTLY TO THESE CARS. *TR

TURNING INTO A PARKING LOT AND I RECEIVED A "SERVICE AWD SYSTEM" MESSAGE. CAUSED BY THE ACD/AYC PUMP BEING FAULTY WHICH IS APPARENTLY A KNOWN PROBLEM WITH THESE CARS AS CORROSION HAPPENS TO THE EXPOSED PUMP. OPTIONS INCLUDE A $2000-3000 REPLACEMENT OF THE PUMP OR REBUILD ONE AND HOPE IT DOESN'T HAPPEN (WHICH MIGHT SINCE IT IS EXPOSED) AGAIN. REALLY HOPE MITSUBISHI RECALLS THIS ITEM SINCE IT IS A COMMON PROBLEM WITH ALL EVOLUTIONS. *TR

ON-DASH WARNING LIGHT OF "4WD SYSTEM SERVICE REQUIRED" CAME ON. THIS WARNING IS INDICATIVE OF A ACTIVE CENTER DIFFERENTIAL (ACD) PUMP FAILURE, GENERALLY DUE TO CORROSION FROM TREATED WINTER ROAD SURFACES AND/OR THE INABILITY TO HANDLE COLD-WEATHER CLIMATES. CAR WAS PREVIOUSLY SERVICED UNDER A TECHNICAL SERVICE BULLETIN (TSB) TO DELAY ACTIVATION OF THE ACD PUMP FOR THIS EXACT REASON 2 YEARS PRIOR TO FAILURE. MITSUBISHI HAS YET TO CORRECT THIS MANUFACTURING DEFECT AND IS CURRENTLY REFUSING TO HONOR WARRANTY SERVICE OF FAILED PUMPS UNDER THEIR 5-YEAR / 36,000-MILE POWERTRAIN WARRANTY, STATING THAT THE PUMP IS NOT REQUIRED FOR THE VEHICLE TO OPERATE SAFELY AND PROPERLY. IN CONTRAST, A WORKING ACD PUMP DIRECTLY EFFECTS THE VEHICLE'S HANDLING, TRACTION & STEERING - AND ALL 3 DRIVING PARAMETERS IMMEDIATELY BEHAVE DIFFERENTLY WHEN THE PUMP SHUTS DOWN IN SELF-PROTECTION MODE OR HAS FAILED COMPLETELY. THIS VEHICLE HAS A DRIVER-SELECTED SETTING FOR TARMAC (PAVEMENT), GRAVEL/RAIN & SNOW CONDITIONS - THESE SETTINGS ARE COMPLETELY DISABLED WHEN THE ACD PUMP HAS FAILED, OR IS FAILING (ON-DASH WARNING WITH PUMP IN SELF-PROTECTION MODE). THIS ISSUE EFFECTS SEVERAL MODELS (LANCER, LANCER EVOLUTION, RALLIART, ETC.) FROM MODEL YEAR 2008 TO 2014, AND HUNDREDS OF INSTANCES OF THIS ISSUE HAVE BEEN DOCUMENTED IN ONLINE FORUMS (AND PROBABLY SEVERAL-FOLD THAT AMOUNT THAT HAVEN'T BEEN DISCUSSED ONLINE). PLEASE LOOK INTO THIS ISSUE IMMEDIATELY, THANK YOU. *TR

EVERY MITSUBISHI LANCER EVO X KEEPS HAVING THE SAME PROBLEM WITH OUR ACD/AYC PUMP FAILURE THAT WILL COST ME/OWNER A STAGGERING 2000 TO 3000 DOLLARS TO FIX. THIS IS CLEARLY SHOW HOW THE PART IS REALLY WEAK AND SHOULD BE UNDER WARRANTY TO FIX IT. PLEASE HELP US HAVE THE MITSUBISHI PAY FOR THIS CRAPPY PART INCLUDED ON AN EXPENSIVE CAR. HOPE YOU HERE MY VOICE. *TR

BOUGHT MY VEHICLE AS A CERTIFIED PRE-OWNED VEHICLE WITH 37,213 MILES ON IT. AT 43,000 MILES, VEHICLE BEGAN HAVING MALFUNCTIONS WITH THE ALL WHEEL CONTROL SYSTEM AND ELECTRONIC STABILITY CONTROL HYDRAULIC PUMP. THIS SHOULD BE AN ITEM COVERED UNDER THE 5 YEAR/60,000 MILE WARRANTY, HOWEVER, MITSUBISHI STATES THAT IT IS NOT COVERED, EVEN THOUGH IT IS PART OF THE POWER-TRAIN, AND REQUIRED TO WORK FOR VEHICLE STABILITY AND SAFETY. MITSUBISHI HAS CONTINUED TO REFUSE TO WARRANTY THE PUMP. THIS IS NOT AN ISOLATED ISSUE, AND THERE HAVE BEEN DOZENS, MAYBE HUNDREDS OF OTHER CARS WITH THE EXACT SAME MALFUNCTION, MANY OF THESE WERE TURNED AWAY BY MITSUBISHI EVEN WHILE THEY WERE UNDER THE POWER-TRAIN WARRANTY. *TR