2003 Mini Cooper complaints

TL* THE CONTACT OWNS A 2003 MINI COOPER. THE CONTACT STATED THAT THE TRANSMISSION WILL SHIFT INTO THE DRIVE GEAR. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY, AND A TECHNICIAN CONCLUDED THAT HE NEEDED TO REPLACE THE CVT TRANSMISSION, AT AN EXPENSE OF $ 8,300.00. NO REPAIRS WERE MADE. THE MANUFACTURER WAS NOTIFIED, BUT NO ASSISTANCE WAS PROVIDED. THE FAILURE AND CURRENT MILEAGES WERE 88,000. UPDATED 10/21/09. *LJ THE REPAIR SHOP DISCOVERED THE CVT DRIVE BELT HAD SHREDDED WHICH SENT METAL THROUGH THE TRANSMISSION. THERE WERE NO PARTS AVAILABLE, THE ONLY OPTION WAS FULL TRANSMISSION REPLACEMENT. UPDATED 10/20/09

MY CAR WILL SUDDENLY ONLY GO ABOUT 5 MPH. THIS HAS HAPPENED SEVERAL TIMES. WE HAVE TAKEN IT TO THE MECHANIC AND HE THINKS HE HAS IT FIXED AND THEN IT HAPPENS AGAIN. NOW THEY ARE SAYING IT NEEDS A NEW TRANSMISSION FOR $8,400. THEY CAN'T REBUILD ONE, THEY CAN'T BUY A REBUILT ONE. THE CAR HAS LOW MILES AND THE TRANSMISSION SHOULDN'T BE GOING OUT. I BELIEVE MINI COOPERS HAVE A FLAWED TRANSMISSION AND THE COMPANY CONTINUES TO PUT MORE FLAWED TRANSMISSIONS INTO CARS AND WE THE CUSTOMERS ARE GETTING '!@#$%. *TR

OUR MINI COOPER REPEATEDLY STALLED WHILE IN HEAVY TRAFFIC RESULTING IN SEVERAL NEAR DEATH EXPERIENCES. NO FAULT CODE OR CHECK-ENGINE LIGHT EVER APPEARED. UPON TAKING THE CAR INTO THE DEALERSHIP, WHILE UNDER WARRANTY, THE PROBLEM AND OUR CONCERNS WERE DISMISSED WITHOUT REMEDY. FINALLY, AFTER BEING IN THE MOUNTAINS ON WINDY ROADS A CLICKING NOISE BEGAN. SINCE NO FAULT OR CHECK-ENGINE LIGHT APPEARED, WE ASSUMED THE CAUSE OF THE NOISE TO BE FROM SOMETHING MINOR AND OPTED TO DRIVE THE CAR TO THE NEAREST MECHANIC, A FIVE MILE DRIVE. SHORTLY BEFORE ARRIVING TO THE MECHANIC, THE MINI UNEXPECTEDLY BECAME QUITE DIFFICULT TO CONTROL. LUCKILY WE WERE ABLE TO GET OFF THE FREEWAY, UPON WHICH THE TRANSMISSION COMPLETELY STOPPED WORKING ' REQUIRING THE CAR TO BE PUSHED TO THE MECHANIC. AGAIN, NO CHECK-ENGINE LIGHT CAME ON AS A WARNING AND NO FAULT CODES WERE STORED. BMW'S MINI COOPER CVT TRANSMISSION POSES A SIGNIFICANT SAFETY HAZARD TO DRIVERS. RESEARCH INDICATES BMW IS AWARE OF THE DEFECTIVE TRANSMISSION, WHICH EXPLAINS WHY BMW OPTED TO NO LONGER USE THE CVT TRANSMISSION IN LATER MODELS. THANK YOU FOR TAKING THE TIME TO RECTIFY THE SITUATION TO KEEP MINI OWNERS & OTHER DRIVERS SAFE. OURS IS JUST ONE OF MANY SIMILAR EXPERIENCES WE'VE RECENTLY LEARNED OF WHILE RESEARCHING THE DISMAL TRACK RECORD OF BMW'S CVT TRANSMISSIONS IN EARLY MINI COOPERS. *TR

I HAVE A 2003 MINI COOPER WITH AUTOMATIC CVT TRANSMISSION AND HAVE HAD RECURRING PROBLEMS WITH THE CVT SINCE I PURCHASED THE VEHICLE. BELOW IS A SUMMARY OF SERVICE VISITS, REPLACEMENT OF THE CVT IN 2007, AND THE CURRENT STATUS OF THE CVT AS INOPERABLE. I HAVE ALL INVOICES DETAILING WORK DONE. 10/9/02 - I PURCHASED A NEW 2003 MINI COOPER WITH AUTOMATIC CVT TRANSMISSION FROM BARON BMW IN MERRIAM, KS. 12/02 - MINI USA SENT ME LETTER RE: CHASSIS #TE13495 THAT SOME AUTOMATIC CVT TRANSMISSIONS HAD BEEN FILLED WITH THE INCORRECT TRANSMISSION OIL AND TO SCHEDULE AN APPOINTMENT TO HAVE IT FLUSHED AND REPLACED ASAP. 12/27/02 - BARON FLUSHED AND REPLACED FLUID. I ALSO COMPLAINED THAT THE CAR HAD DIED TWO TIMES AND RAN ROUGH. MILEAGE 1,760. 7/2/03-I TOOK MINI IN COMPLAINING "WHEN GOING FROM REVERSE TO DRIVE CAR HAS A HARD LURCH" AND BARON'S INVOICE STATES "TEST DROVE CAR AND FOUND IT WAS VERY HARSH GOING INTO GEAR AND LURCHED WHEN IT WAS COLD". 2ND AUTO TRANS CONCERN WAS "CAR HAS ALMOST DIED AT LOW IDLES A FEW TIMES". BARON REPROGRAMMED THE CAR UNDER WARRANTY. MILEAGE 6,465. 7/23/07-CUSTOMER GOODWILL PROVIDED BY BARON MINI AND REPLACED THE TRANSMISSION AT NO COST ALTHOUGH WARRANTY WAS UP. MILEAGE 49,512. 9/11/07-I TOOK MINI IN AGAIN COMPLAINING OF ROUGH IDLE AND CAR WANTS TO DIE AT STOPS. MILEAGE 51,167. 8/13/09- MINI WAS HAVING A HARD TIME SHIFTING OUT OF 1ST GEAR. IT WOULD ONLY DRIVE 15-20 MPH AT UP TO 3,000 RPMS. I CALLED BARON AND WAS TOLD THE CURRENT TRANSMISSION HAD A TWO YEAR WARR

MY 2003 MINI COOPER HAS A CRACKED WINDSHIELD THAT RESULTED FROM STRUCTURAL PROBLEMS. IT IS L-SHAPED AND IT STARTED AT THE BOTTOM MIDDLE OF THE WINDSHIELD. *TR

TRANSMISSION FAILED WITH NO WARNING OR SYMPTOMS. *TR

CVT TRANSMISSION FAILURE. *TR

I BOUGHT A 2003 MINI COOPER AND ABOUT A WEEK AND A HALF AGO, THE CLUTCH HYDRAULIC SYSTEM HAS SPRUNG A LEAK. UPON INSPECTION OF THE HYDRAULICS, THE MECHANIC NOTICED THAT THE CLUTCH CONTROL ROD WAS MOVING IN A FUNNY WAY. HE SAYS THAT THEY WILL HAVE TO DROP THE TRANSMISSION TO SEE THE ACTUAL PROBLEM AND THAT REMOVING THE TRANSMISSION ALONE WILL COST ME 1000.00 DOLLARS WHICH I DO NOT HAVE AT THE MOMENT. THE CAR ONLY HAS 67,000 MILES ON IT AND THE CLUTCH WENT WITHOUT ANY WARNING. ALSO, I AM TOLD THAT IF THE CLUTCH DOES NEED TO BE REPLACED, IT WILL COST ME 1800.00 DOLLARS, WHICH AGAIN, I DO NOT HAVE. *TR

AUTOMATIC TRANSMISSION ON MY 2003 MINI COOPER BLEW OUT WITHOUT ANY WARNING. THE CAR WOULD NOT MOVE. THE CAR HAD JUST ABOUT 37,000 MILES ON IT AND WAS REGULARLY MAINTAINED AT THE DEALERS SHOP. *TR

SPONTANEOUS ENGINE BAY FIRE IN 2003 MINI COOPER WITH 60,000 MILES. VEHICLE WAS DRIVEN NORMALLY TO WORK, TURNED OFF, PARKED, LOCKED AND LEFT. UNATTENDED CAR CAUGHT FIRE SEVERAL MINUTES LATER. SEATTLE CITY FIRE DEPARTMENT RESPONDED TO EMERGENCY CALL, BUT FIRE SELF-EXTINGUISHED WITHIN 10 MINUTES. SOOT COVERED ENGINE BAY AND ACRID SMOKE PERMEATED VEHICLE. INSPECTION REVEALED MELTED CONNECTION BETWEEN WIRING HARNESS AND POWER STEERING PUMP, REQUIRING REPLACEMENT OF PUMP, COOLING FAN, WIRING AND OTHER PARTS. INTERNET COMMUNITIES OF MINI OWNERS CONTAIN NUMEROUS REPORTS OF SUDDEN ENGINE BAY FIRES IN 2002 AND 2003 MINI COOPERS CAUSED BY ELECTRICAL SHORTS LINKED TO FAULTY POWER STEERING PUMPS OR FANS. FREQUENTLY THESE FIRES OCCUR AFTER THE CAR HAS BEEN SWITCHED OFF. THEY ALWAYS RESULT IN MODERATE VEHICLE DAMAGE AND MAJOR REPAIR COSTS (MINE IS ESTIMATED @ $1,600). OCCASIONALLY THEY RESULT IN TOTAL VEHICLE LOSS AND / OR ADDITIONAL PROPERTY DAMAGE. HAD THIS FIRE OCCURRED IN MY HOME GARAGE AT NIGHT THE RESULTS COULD HAVE BEEN CATASTROPHIC; IF THIS KIND OF INCIDENT (SUDDEN POWER STEERING PUMP FAILURE + ELECTRIC FIRE) WERE TO OCCUR ON A FREEWAY AT SPEED IT COULD EASILY RESULT IN FATALITIES. BMW / MINI USA HAS REPORTEDLY QUIETLY REIMBURSED INDIVIDUAL OWNERS WHO HAVE SUFFERED SPONTANEOUS FIRES, BUT HAS NOT ACKNOWLEDGED THE WIDESPREAD NATURE OF THE PROBLEM -- WHICH IS RIDICULOUS. AS I DISCOVERED WHILE RESEARCHING MY INCIDENT, IF YOU GOOGLE "MINI COOPER FIRE" OR "MINI POWER STEERING PUMP FAILURE

2003 MINI COOPER TRANSMISSION FAILURE. REPLACEMENT COST APPROX 7500.00 THIS IS A KNOWN DEFECT AND THERE IS A MULTITUDE OF PROBLEMS ASSOCIATED WITH THIS. I BOUGHT MINE USED. NO DISCLOSURE OF IT DURING THE SALE. IT SHOULD BE AT LEAST BE FLAGGED FOR THE CONSUMERS PROTECTION. DEALERS, MANUFACTURES WILL NOT EVEN DISCUSS IT. IT IS A HORRIBLE SITUATION TO BE IN. *TR

MY 2003 MINI COOPER HAS TRANSMISSION FAILURE IT FELL TO PIECES AT 61,000 MILES AFTER IMPECCABLE ENGINE MAINTENANCE FOR NO APPARENT REASON THEN I FOUND ONLINE THAT MANY MINI OWNERS HAD SIMILAR PROBLEMS AT THE SAME TIME APPROXIMATELY 4 YRS AFTER BUYING THE MINI SCAM THAT THEY SELL THIS FAULTY CAR JUST GLAD IT DIDN'T CAUSE AN ACCIDENT. *TR

I HAVE A 2003 MINI COOPER. THE TRANSMISSION (CVT TRANSMISSION) FIRST FAILED AT AROUND 40,000 MILES AND THE DEALER WAS ABLE TO REPLACE IT UNDER THE WARRANTY. SINCE THEN EVERY FEW MONTHS THE TRANSMISSION WILL FAIL AND SO FAR IT'S BEEN THE 4TH TIME THAT THE DEALER TRIED TO REPLACE THE TRANSMISSION AND STILL FAILS. IT SEEMS LIKE THE PROBLEM CANNOT BE FIXED ONCE AND FOR ALL, NOW MY CAR HAS 81,000 MILES ON IT AND I FEEL BAD TO SELL THE CAR KNOWING I AM JUST PASSING THE PROBLEM ON TO SOMEONE ELSE. I CAN HAVE IT FIXED AT NO CHARGE AS I AM COVERED BY WARRANTY HOWEVER IF I SELL IT, THE NEXT BUYER WILL NOT BE PROTECTED AND WILL FACE ENDLESS FIX AND MONEY TO WASTE, NOT TO MENTION THAT IT'S $8000 EACH TIME TO REPLACE A TRANSMISSION. *TR

I BOUGHT A NEW 2003 MINI COOPER WITH A 3 YEAR 36K WARRANTY 6/26/03. WHILE UNDER WARRANTY AND RECEIVING RECOMMENDED MAINTENANCE THROUGH THE DEALER, THE CAR REQUIRED REPAIR OF THE DRIVER'S SEAT WHICH WAS FROZEN IN THE RECLINED POSITION. SHORTLY AFTER THE WARRANTY EXPIRED, AND 10,481 MILES AFTER A DEALER MAINTENANCE CHECK, THE BRAKE LIGHT INDICATOR BEGAN FLASHING. I TOOK IT IMMEDIATELY TO THE DEALER. I WAS TOLD THE ENTIRE BRAKE SYSTEM NEEDED REPLACEMENT FOR $886.60. AT THE SAME SERVICE VISIT, I WAS TOLD THE FRONT STRUTS NEEDED REPLACEMENT TO THE TUNE OF $1600. MY MALE FRIENDS WHO ARE MECHANICALLY INCLINED AND/OR ENGINEERS SAID THAT ONE WOULD NEED TO BE DOING STUNTS IN A CAR TO NEED THAT KIND OF REPAIR AT 50,293 MILES. IT WAS NOT CLEAR WHY THE INDICATOR ONLY TELLS WHEN BRAKES ARE TOTALLY SHOT, OR WHY THE MOST RECENT SERVICE CHECK HAD NOT SHOWN WORN PADS AND DISKS. LATER, AT 53,007 MILES, THE DRIVER'S SIDE WINDOW FAILED AND THAT COST $497.51 TO REPLACE. AT 62,516 MILES THE AIR CONDITIONING SYSTEM DIED WHICH COST $1173.58 TO REPLACE. THE AUTOMATIC DOOR LOCK ON THE DRIVER?S SIDE DOES NOT WORK AND LORD KNOWS HOW MUCH THAT REPAIR WILL COST. NOW AT 69K, THE MANUAL TRANSMISSION NEEDS REPLACEMENT. MY PRESENT MECHANIC (CHEAPER AND MORE RELIABLE THAN DEALERSHIP) SAYS THE REPLACEMENT OF THE TRANSMISSION AND CLUTCH WITH A REMANUFACTURED SYSTEM WILL BE >$4000. THIS IS AN OUTLANDISH AMOUNT OF REPAIR AND REPAIR COST FOR A $19,000 CAR WITH 70K MILEAGE. I HAVE HAD 2 PREVIOUS HONDAS THAT WERE CHEA

MY AUTOMATIC TRANSMISSION (CVT) BROKE WHILE PULLING AWAY FROM A STOP SIGN. CAR WAS WELL MAINTAINED, DEALER SERVICE ONLY. MILEAGE WAS ONLY 54K. *TR

MY CAR'S RIGHT REAR CONTROL ARM HAD BROKEN IN HALF. THIS ARM PREVENTS THE TIRE FROM SWINGING SIDEWAYS. LUCKY FOR ME, I WAS GOING SLOWLY AT THE TIME. THE CONTROL ARM CONSISTS OF TWO 1/4" PIECES OF METAL WITH HOLES IN THEM AT EVENLY SPACED POINTS. BOTH OF THE METAL ARMS WERE BROKEN IN LINE WITH THE HOLES THAT WERE PART OF THE MANUFACTURED DESIGN. I PAID $1900 FOR AN EXTENDED WARRANTY THROUGH UNIVERSAL UNDERWRITERS(NOW CALLED ZURICH) AT MINI OF CONCORD, CALIFORNIA. CONTROL ARM REPLACEMENT IS LISTED AS COVERED. THEIR REASON FOR NOT COVERING IT IS BECAUSE IT HAS A SLIGHT BEND IN IT (I DON'T SEE IT) AND IT IS BECAUSE OF THAT IT EVENTUALLY BROKE. THE METAL THAT MAKES UP THIS ARM IS NO MORE THAN 1/4" THICK: POORLY MADE, ESPECIALLY WHEN COUPLED WITH THESE HOLES THAT ARE IN IT. THIS PART SHOULD BE MADE TO WITHSTAND IMPACT. TO ME IT IS OBVIOUS THIS IS A MANUFACTURING DEFECT AND I AM APPALLED THAT NEITHER THE DEALER OR THE INSURANCE COMPANY THAT I BOUGHT MY EXTENDED WARRANTY FROM WILL PAY FOR IT. I COULD HAVE BEEN KILLED HAD I BEEN ON THE FREEWAY WHEN THIS HAPPENED. I HAVE GONE FROM A MINI LOVER TO ONE WHO WILL SELL IT AFTER I'M ABLE TO AFFORD TO REPAIR IT. I AM CURRENTLY PRICE COMPARING IN PRIVATE REPAIR SHOPS. *TR

I OWN A 2003 MINI COOPER WITH A CVT AUTOMATIC TRANSMISSION. THE CAR HAS 80000 MILES ON IT AND THE CVT FAILED COMPLETELY. THERE IS NO ALTERNATIVE BUT TO GET A NEW REPLACEMENT WITH AN "UPDATED" 2005 MODEL WHICH I HAVE BEEN QUOTED FROM 2 PLACES $8000 FOR PARTS AND LABOR. THIS IS MY COMPLAINT. IF THEY KNOW THERE IS A PROBLEM WITH THE CVT WHY HAVE THEY NOT CONTACTED ME? PLEASE CONTACT IF YOU NEED FURTHER DETAILS. *TR

BATTERY FAILURE. BATTERY HAS FAILED FOR THE THIRD TIME SINCE CAR BRAND NEW IN FEB, 2003. ON EACH OCCASION THE VEHICLE WOULD NOT START AFTER HAVING GIVEN NO WARNING. THE FIRST FAILURE WAS IN 2005 AT 26,000 MI., THE SECOND IN 2007 AT 51,000 MI., THE THIRD IN 2008 AT 68,000 MI. EACH FAILED BATTERY WAS A MANUFACTURER'S BRAND (MINI). *TR

BOTH PASSENGER AND DRIVERS SIDE WINDOWS ARE STUTTERING WHEN I TRY TO ROLL THEM UP OR DOWN. THIS IS WHEN I AM EVEN ABLE TO GET THEM TO WORK. FOUND THAT WHEN THE WEATHER IS HOT, THEY WON'T WORK AT ALL!! MEANING I AM HAVING TO WAIT FOR IT TO COOL DOWN TO ROLL THE WINDOWS DOWN IF I AM LUCKY AND HAVE ON ONE OCCASION GOT STUCK IN MY VEHICLE BECAUSE THE CAR DOOR HANDLE ALSO WOULD OPEN THE DOOR FROM THE INSIDE AND I COULDN'T OPEN THE WINDOW TO OPEN THE DOOR, WHICH WAS VERY DANGEROUS SINCE I HAD A CHILD WITH ME. THIS HAS BEEN OCCURRING MORE AND MORE FREQUENTLY AND JUST GOT MY DOOR REPAIRED AND STILL HAVING ISSUES WITH THE WINDOWS MAKING IT IMPOSSIBLE TO DO ANYTHING THAT REQUIRES A DRIVE THROUGH, OR AT MY PREVIOUS APT YOU HAD TO ENTER A CODE TO GET INTO THE GATED COMMUNITY AND I HAD TO GET OUT OF MY CAR TO DO THIS, AND I LIVE IN COLORADO, AND IT GETS VERY COLD. THIS SHOULD BE A RECALL, DUE TO MANY FORUMS AND OTHER MINI OWNERS EXPERIENCING THE SAME ISSUES! FROM FORUMS SHOWS THAT EVEN REPLACING THE MOTOR WON'T FIX THE ISSUE, WHAT A WASTE OF MONEY!! THIS NEEDS TO A RECALL ONCE AGAIN, CAN'T AFFORD TO KEEP GETTING THIS FIXED AND DISHING OUT MONEY, ESPECIALLY WHEN I HAVE A KID WITH ME FROM TIME TO TIME. UNACCEPTABLE. *TR

AIR BAG CHECK LIGHT IS ON. NO AIR BAG WAS DEPLOYED, NO CRASH WAS INVOLVED. THIS IS ON GOING PROBLEM WITH THE MINI COOPER WHICH SHOULD HAVE A RECALL. IF NOT REPAIRED AIR BAG MAY NOT DEPLOY IN A CRASH. *TR

TL*THE CONTACT OWNS A 2003 MINI COOPER. THE CONTACT HAD THE TRANSMISSION REPLACED THREE TIMES. IN ADDITION, THE BRACKETS THAT SUPPORT THE MUFFLER HAVE ROTTED. UNDERNEATH THE HOOD, THE BRACKETS THAT SUPPORT THE HORN HAVE ALSO ROTTED. THE CONTACT WILL TAKE THE VEHICLE TO THE DEALER AGAIN FOR ANOTHER REPAIR. THE FAILURE AND CURRENT MILEAGES WERE 68,600.

THE CVT FAILED IN MY 2003 MINI COOPER AT 67,000 MILES. THE REPAIR COST OFFERED BY DEALER STARTED AT 7400 THEN WHEN TOLD I HAD READ ABOUT NUMEROUS OTHERS HAVING THE SAME PROBLEM THE COST BECAME 5900. ALSO FOUND OUT THE COMPANY STOPPED USING THIS TRANSMISSION IN 07 MODELS DUE TO PROBLEMS. NEED RE-CALL AND OR REIMBURSEMENTS. *TR

FAILED CVT TRANSMISSION IN THE MIDDLE OF AN INTERSECTION. CAR HAD TO BE PUSHED TO THE SIDE OF THE ROAD AS ENTIRE SYSTEM WAS LOCKED AND ENGINE DIED; COULD NOT MANUALLY MOVE SHIFT OUT OF DRIVE. MILEAGE WAS AROUND 12,000 ABOVE WARRANTY. DEALERSHIP QUOTED $7200 TO REPLACE TRANSMISSION - NO COVERAGE UNDER WARRANTY. I COULD NOT AFFORD THE REPAIR, SO TURNED THE CAR BACK TO MANUFACTURER AS A VOLUNTARY REPO. THIS WAS DEVASTATING. CAR WAS IN EXCELLENT CONDITION OTHERWISE. *TR

TL*THE CONTACT OWNS A 2003 MINI COOPER. UPON TAKING THE VEHICLE IN FOR AN OIL CHANGE, IT WAS DISCOVERED THAT THE DRIVER SIDE STRUTS NEEDED TO BE REPLACED. APPROXIMATELY FOUR MONTHS LATER, THE PASSENGER SIDE STRUT NEEDED TO BE REPLACED. THE FRONT AND REAR BRAKES WERE ALSO REPLACED AND THE VEHICLE HAD AN OIL PAN LEAK. THE DRIVER'S AND PASSENGER SIDE WINDOW MOTORS FAILED AND NEEDED TO BE REPLACED. THE CURRENT MILEAGE WAS 12,900 AND FAILURE MILEAGE WAS 10,000.

CVT TRANSMISSION ON 2003 MINI COPPER FAILED AT 87,000 MILES. THE COST TO REPLACE IS QUOTED BY THE DEALER AT $7400. COME TO FIND OUT THAT THIS IS A RECURRING ISSUE WITH THIS TRANSMISSION TO THE POINT THAT IT SHOULD BE CONSIDERED A RECALL ISSUE. *TR

2003 MINI COOPER, 66,000 MILES AND THE TRANSMISSION NEEDS REPLACED. THE COST IS GOING TO BE 8,500.00. *TR

MY TRANSMISSION FAILED ON MY MINI-COOPER ONCE WHEN IT WAS IN WARRANTY AND I HAD TO PAY TO HAVE IT FIXED, ONCE AGAIN, AND IT WAS JUST OUT OF WARRANTY AND I PAID 3000$ TO HAVE IT FIXED AND ONCE AGAIN WHEN THE 2ND TRANSMISSION WAS IN WARRANTY AND MINICOOPER FIXED IT. THIS CAR WAS A LEMON AND MINI NEVER ACCEPTED RESPONSIBILITY FOR THE DEFECTIVE TRANSMISSION PROBLEMS. *TR

BOUGHT THE CAR IN 2003 BRAND NEW AND HAD COMPLAINED TO THE SERVICE DEPT WHEN IN FOR REPAIRS THAT THE TRANSMISSION FELT ODD. IT WOULD JERK AT LOW SPEEDS, BETWEEN 5 AND 10. THEY SAID THIS WAS NORMAL FOR THE CVT AND IT SHOULD GO AWAY ONCE THE TRANSMISSION WAS ACCUSTOMED TO THE WAY I DRIVE. IN 2006 MY HUSBAND WAS GIVING BLOOD IN MANCHESTER, NH AND WHILE HE WAS DOING THAT I WENT TO THE MALL FOR A FEW HOURS. AS I WAS RETURNING TO PICK HIM UP I CAME TO A YELLOW LIGHT THAT I COULD NOT MAKE IT THROUGH. I STOPPED THE CAR, LIKE NORMAL NOT A HARD STOP, AND HEARD A CLANK NOISE ALMOST AS IF I HAD HIT SOMETHING IN THE ROAD. THE LIGHT TURNED GREEN AND I PRESSED ON THE ACCELERATOR TO GO AND NOTHING WOULD HAPPEN EXCEPT MY RPMS WOULD GO UP. I WAS ON A SLIGHT HILL AND BEGAN TO COAST BUT I WASN'T SURE IF I WAS COASTING OR IF THE CAR WAS JUST GOING REALLY SLOW, UNTIL I STARTED IN AN UPHILL AND THE CAR STOPPED. I TRIED TO TURN OF THE CAR AND TURN IT BACK ON, CRAZY LOGIC THAT SOMETIMES DOES THE TRICK, AND THERE WAS NO CHANGE. I PUSHED THE CAR INTO A DRIVEWAY AS I WAS ON A 2 LANE ROAD AND BLOCKING TRAFFIC AND CALLED AAA TO HAVE THE CAR TOWED. THE CAR WAS TOWED TO MINI OF PEABODY. WHEN THEY CALLED ON MONDAY THEY SAID THAT THE CVT HAD FAILED, THEY FOUND THE CHAIN AND LINKS IN THE OIL PAN AND THAT IT WOULD HAVE TO BE REPLACED. I ASKED HOW MUCH THE REPLACEMENT WOULD BE AND THEY TOLD ME PARTS AND LABOR WOULD BE $7700. WHEN I WAS TOLD THAT I TALKED TO THE SA ABOUT THE OTHER PEOPLE THAT HAD PROBLEMS WITH TH

ON 9/2/08 I BROUGHT MY 2003 MINI COOPER TO THE DEALER FOR SERVICE. I WAS HEARING A NOISE FROM THE FRONT THAT CLOCKED AT LOW SPEED. I THOUGHT IT WAS A BAD CV JOINT AND ASKED THE SERVICE WRITER TO VERIFY AND GIVE ME A ESTIMATE. WHEN THEY WERE DONE IT WAS DETERMINED THE NOISE WAS COMING FROM THE TRANSMISSION AND IT WOULD NEED TO BE REPLACED. THE ESTIMATE WAS $7613.00 PLUS TAX. I DROVE HOME AND SPENT SOME TIME RESEARCHING THE CVT TRANSMISSION IN THE MINI COOPERS AND FOUND WHAT APPEARS TO BE A HIGH FAILURE RATE. A LOOK AT SEVERAL FORUMS FOR MINI'S SHOWS POSTINGS OF PROBLEMS SIMILAR TO MINE IN COOPER MODELS WITH MILEAGES FROM 34,000 TO 113,000 ALL WITH CVT TRANSMISSIONS. THE REPLACEMENT COSTS WERE SIMILAR TOO. THERE WERE MANY COMMENTS FROM FORUM USERS TO AVOID BUYING A USED MINI COOPER WITH A CVT, "AVOID IT LIKE THE PLAGUE" WAS ONE COMMENT. MINI NO LONGER USES THIS TRANSMISSION. MAYBE THE FAILURES MADE THEM LOOK TO ANOTHER SOURCE, I DO NOT KNOW. I ALSO CONTACTED A PERSON WHO IS GATHERING NAMES, 50 SO FAR, TO FILE A CLASS ACTION LAWSUIT AGAINST MINI TO TRY AND RECOUP THE MONEY SPENT REPAIRING A FAULTY TRANSMISSION. THAT IS JUST 50 PEOPLE WHO KNEW HOW TO CONTACT HER TO BE ADDED TO THE LIST. AS OF RIGHT NOW THESE PEOPLE ARE STILL LOOKING FOR AN ATTORNEY TO REPRESENT THEM. THERE MUST BE MORE, AND 50 TRANSMISSIONS IS ALOT OF MONEY. IF A INVESTIGATION IS DONE BY THE NHTSA AND A RECALL IS INITIATED THEN MAYBE THESE PEOPLE CAN BE REIMBURSED BY MINI. I FIND IT UNUSUAL THAT A TRANSMISSION SH

AUTOMATIC TRANSMISSION (CVT) FAILED. IT WILL COST $8000 (MINI/BMW DEALER QUOTE) TO REPLACE. I NOTICED THERE WERE MANY COMPLAINTS OF THIS PROBLEM ON THE INTERNET MANY RECOMMENDED TO FILE A COMPLAINT ON THE NHTSA WEBSITE. *TR

ON AUG. 9, 2008, I NOTICED THAT THE STEERING ON MY 2003 MINI COOPER WAS EXTREMELY TIGHT WHEN I STARTED THE CAR. AS I DROVE IT, IT LOOSENED UP. THE NEXT DAY, AUG. 10, THE SITUATION WORSENED--EVERY TIME THE CAR WAS STOPPED, THEN STARTED, THE STEERING TIGHTENED. THERE WAS NO LOOSENING UP AT ALL. I BROUGHT THE CAR TO A LOCAL PEP BOYS TO SEE IF ANYTHING COULD BE DONE. THEY DIAGNOSED A POSSIBLE PSP FAILURE. THEY COULDN'T DO ANYTHING AS ONLY MINI HAS THE SCHEMATICS FOR THIS REPAIR. I CALLED THE MINI DEALERSHIP IN PEABODY, MA FIRST THING MONDAY AND GOT AN APPT. FOR TODAY, AUG. 14. SINCE I HAVE NO OTHER VEHICLE, I HAD TO DRIVE THE CAR WHEN NECESSARY. SOMETIMES THE STEERING WAS FINE. OTHER TIMES, IT WAS VERY DIFFICULT TO STEER. THE DEALERSHIP REPLACED THE FAULTY PSP TODAY. THEY ACKNOWLEDGED A COMPLETE FAILURE. I'VE OWNED SEVERAL CARS WITH MORE MILEAGE ON THEM THAN THIS ONE (IT CURRENTLY HAS 60K AND IS FIVE YEARS OLD) AND NEVER EXPERIENCED ANY PSP PROBLEMS, NEVER MIND AN OUTRIGHT FAILURE. *TR

THE POWER STEERING PUMP ON MY MINI COOPER CAUGHT ON FIRE. *TR

I OWN A 2003 MINI COOPER WITH 67K MILES ( OUT OF WARRANTY). TWO WEEKS AGO WHILE DRIVING UP A HILL TO MY HOME, THE TRANSMISSION WOULD NOT GO INTO GEAR. I COULD BARELY MAKE IT UP THE HILL AND HAD TO CHANGE TO THE SLOW LANE AND PULL OFF THE ROAD. AFTER DOING MUCH SEARCHING ON THE INTERNET, I FOUND THAT MANY WERE HAVING THIS PROBLEM. THIS IS A MAJOR DRIVE CHAIN COMPONENT THAT SHOULDN'T GO OUT AT 67K. THE CVT TRANSMISSION SEEMS TO BE FLAWED AND ACKNOWLEDGED BY THE MANUFACTURER AS THEY DO NOT PUT THESE TRANSMISSIONS INTO THE NEWER MODELS. ALSO IT SEEMS, EVEN OUT OF WARRANTY MINI'S GET TRANSMISSIONS REPLACED; WITH THE OWNER ONLY HAVING TO PAY FOR LABOR IF THE OWNER CAUSES A "STINK" OR ALLUDES TO MAKING PROBLEMS FOR MINI. IF THE MANUFACTURER REALLY BELIEVED THE CVT TRANSMISSION WERE NOT FAULTY, I BELIEVE THEY WOULD STICK TO THEIR POSITION WITH ALL CUSTOMERS, INSTEAD OF MAKING EXCEPTIONS. MINI SHOULD BE ORDERED TO RECALL CARS WITH THE CVT TRANSMISSION. *TR

THE POWER STEERING PUMP STOPPED WORKING ALL OF A SUDDEN. I WAS DRIVING TO WORK WHEN IT WENT OUT, AND I FREAKED OUT. I COULD HARDLY TURN THE STEERING WHEEL. I TURNED OFF THE CAR AND STARTED IT BACK UP, AND IT STARTED WORKING AGAIN. THIS HAPPENED FOR ABOUT A WEEK WHERE IT WOULD KICK ON EVERY ONCE IN A WHILE, AND THEN IT WENT OUT FOR GOOD. I HAVE BEEN QUOTED FOR AROUND $1000 TO GET IT REPAIRED. I HAVE BEEN DRIVING AROUND WITH THIS ISSUE FOR ALMOST A YEAR NOW. THE ONLY GOOD THING, IS THAT IT HAS GREATLY STRENGTHENED MY ARM MUSCLES... *TR

I WAS DRIVING HOME ONE DAY WHEN SEVERAL LIGHTS LIT UP IN MY CAR. I WAS SCARED BECAUSE THESE LIGHTS WERE: LOW TIRE PRESSURE, LOW BRAKE PADS, TRACTION CONTROL LIGHT, & ABS BREAK LIGHT. I PULLED OVER AND SHUT OFF THE CAR, AND WHEN I TURNED IT BACK ON, THEY STILL WERE LIT UP. I AM NOT SURE WHAT CAUSED THIS AS I WASN'T DRIVING ERRATICALLY, JUST NORMAL. I STILL DO NOT KNOW WHY EXACTLY THEY ARE ON, HOWEVER I FIGURE IT IS SOMETHING TO DO WITH THE COMPUTER. *TR

PURCHASED 2002 MINI COOPER IN 3/03 AT MINI STERLING IN VA. MOVED TO PA, SERVICING CAR UNDER WARRANTY AT THE NEAREST DEALERSHIP, OTTO'S MINI IN WEST CHESTER (50 MI AWAY). MINOR ISSUES CORRECTED UNDER WARRANTY, WHICH EXPIRED IN LATE 2005. IN JULY 2007, AT 78,000 MILES, WHILE DRIVING ON LOCAL EXPRESSWAY CAR SUDDENLY LOST ABILITY TO DRIVE IN GEAR AND I PULLED OVER (LUCKILY SAFE - TRAFFIC WAS MOVING AT 60-70 MPH). ENGINE RAN BUT CAR WOULD NOT GO INTO GEAR. ALL SIGNS POINTED TO MAJOR TRANSMISSION PROBLEM. CAR TOWED TO TRANSMISSION SHOP IN YORK (NEAREST RECOMMENDED SHOP) WHO CONFIRMED TRANSMISSION ISSUE. CALLED MINI OF TOWSON (NEAREST DEALER) FOR QUOTE ON REPLACING TRANSMISSION - IT WAS $7800! CAR WAS ONLY WORTH $12,000-$13,000 AT THAT TIME - REPAIR WAS OVER 50% OF CAR VALUE. LOCAL SHOP TRIED FIX IT WITH REBUILT TRANSMISSION. TURNED INTO 7 MONTH NIGHTMARE AS MULTIPLE REBUILT TRANSMISSIONS DIDN'T WORK DUE TO COMPUTER CODE ISSUES, SO CAR TOWED TO MINI OF TOWSON TWICE TO SEE IF THEY COULD CORRECT ISSUES, BUT EACH TIME DEALER ONLY OFFERED TO FIX WITH NEW TRANSMISSION FROM THEM AT $7800. TRIED TRADING CAR TO THEM FOR NEW MINI, BUT THEY ONLY OFFERED ME $4000 FOR THE CAR, SAYING THEIR COST TO FIX WAS STILL $6000. LOCAL SHOP FINALLY GAVE UP, REFUNDING MY DEPOSIT AND RETURNING CAR WITH REBUILT TRANSMISSION THAT WILL ONLY DRIVES IN LOW GEAR AT 20 MPH. NOW HAVE MINI IN MY GARAGE (WITH BALANCE ON CAR LOAN) THAT SHOULD BE WORTH $10,000 BUT IS UNUSABLE. MINI IS REFUSING TO DO ANYTHING ABOUT THIS

PURCHASED 2003 MINI COOPER IN 3/03 AT MINI STERLING IN VA. MOVED TO PA, SERVICING CAR UNDER WARRANTY AT THE NEAREST DEALERSHIP, OTTO'S MINI IN WEST CHESTER (50 MI AWAY). MINOR ISSUES CORRECTED UNDER WARRANTY, WHICH EXPIRED IN LATE 2005. IN JULY 2007, AT 78,000 MILES, WHILE DRIVING ON LOCAL EXPRESSWAY CAR SUDDENLY LOST ABILITY TO DRIVE IN GEAR AND I PULLED OVER (LUCKILY SAFE - TRAFFIC WAS MOVING AT 60-70 MPH). ENGINE RAN BUT CAR WOULD NOT GO INTO GEAR. ALL SIGNS POINTED TO MAJOR TRANSMISSION PROBLEM. CAR TOWED TO TRANSMISSION SHOP IN YORK (NEAREST RECOMMENDED SHOP) WHO CONFIRMED TRANSMISSION ISSUE. CALLED MINI OF TOWSON (NEAREST DEALER) FOR QUOTE ON REPLACING TRANSMISSION - IT WAS $7800! CAR WAS ONLY WORTH $12,000-$13,000 AT THAT TIME - REPAIR WAS OVER 50% OF CAR VALUE. LOCAL SHOP TRIED FIX IT WITH REBUILT TRANSMISSION. TURNED INTO 7 MONTH NIGHTMARE AS MULTIPLE REBUILT TRANSMISSIONS DIDN'T WORK DUE TO COMPUTER CODE ISSUES, SO CAR TOWED TO MINI OF TOWSON TWICE TO SEE IF THEY COULD CORRECT ISSUES, BUT EACH TIME DEALER ONLY OFFERED TO FIX WITH NEW TRANSMISSION FROM THEM AT $7800. TRIED TRADING CAR TO THEM FOR NEW MINI, BUT THEY ONLY OFFERED ME $4000 FOR THE CAR, SAYING THEIR COST TO FIX WAS STILL $6000. LOCAL SHOP FINALLY GAVE UP, REFUNDING MY DEPOSIT AND RETURNING CAR WITH REBUILT TRANSMISSION THAT WILL ONLY DRIVES IN LOW GEAR AT 20 MPH. NOW HAVE MINI IN MY GARAGE (WITH BALANCE ON CAR LOAN) THAT SHOULD BE WORTH $10,000 BUT IS UNUSABLE. MINI IS REFUSING TO DO ANYTHING ABOUT THIS

2003 MINI COOPER, TRANSMISSION PROBLEMS. DEALERS STATES IT WOULD COST SEVEN THOUSAND DOLLARS TO REPLACE AND FIX. WITH THE CAR ONLY WORTH DOUBLE THAN THAT IT IS AN SHAMEFUL ACT ON MINI FOR DOING THIS TO CUSTOMERS. SOUNDS OF RATTLING AND TRANSMISSION SLIPPING, DEALER STATES IT IS A REGULAR PROBLEM WITH THE COOPER BUT THERE IS NO RECALL OF ANY SORT. *TR

I BOUGHT THIS VEHICLE USED IN MARCH 2008. LUCKILY IN MASSACHUSETTS THEY HAVE A LAW REQUIRING WARRANTIES FOR ALL USED CARS FOR X NUMBER OF MILES/MONTHS DEPENDING ON MILEAGE AT TIME OF SALE AND ALL THAT. I HAVE ALREADY HAD THE MUFFLER RE-WELDED INTO PLACE WHERE ITS MOUNTS FAILED. THE ONLY REASON IT DIDN'T FALL OFF IS BECAUSE MINI INCLUDED A SAFETY "CATCH" BAR FOR WHEN/IF THIS HAPPENS. BUT MY BIG PROBLEM NOW IS THAT THE POWER STEERING PUMP HAS GONE OUT; IT HAPPENED VERY SUDDENLY. THE REPAIR COULD BE DONE OUTSIDE OF THE DEALERSHIP BUT I'M AFRAID TO TAKE A GERMAN MADE MACHINE OF THIS QUALITY TO A CHOP-SHOP AND HOPE THEY CAN GET IT DONE. I CALLED A VW DEALERSHIP WHERE I BOUGHT IT AND THEY SAID THEY WERE UNSURE THEY KNEW HOW TO DO THE REPAIR. *SHIVER* MINI IN BOSTON WANTS $900-1000.00 TO DO THE REPAIR AS THE PART IS ABOUT $800 AND THE TIME INVOLVED WILL BE ABOUT 2 HOURS AT $125 PER HOUR. PRAY FOR ME, PLEASE! *TR

1. THE MALFUNCTION HAPPENS SPONTANEOUSLY 2. THE POWER STEERING PUMP MALFUNCTIONS AND CAUSES THE STEERING WHEEL TO BE STIFF PLACING ME OR ANYONE ELSE DRIVING/ON THE ROAD IN DANGER DUE TO THE RELUCTANCE OF THE WHEEL TO TURN. 3. THE DEALERSHIP OFFERED NO MONETARY SUPPORT BUT INSTEAD TOLD ME THERE WAS NOTHING I COULD DO ABOUT IT BUT TO REPLACE IT AND ATTEMPTED TO CHARGE ME $1000 DOLLARS IN CASH. INSTEAD I TOOK THE CAR TO AN INDEPENDENT MECHANIC AND WAS CHARGED $700. A RIDICULOUS PRICE TO PAY FOR MY SAFETY. *TR

POWER STEERING FAILURE. *TR

CVT (CONTINUOUSLY VARIABLE TRANSMISSION) FAILURE. *TR

TL*THE CONTACT OWNS A 2003 MINI COOPER. WHILE DRIVING 40 MPH IN FIRST GEAR, THE TRANSMISSION BEGAN TO RANDOMLY MAKE WHIRLING NOISES. HE TOOK THE VEHICLE TO THE MECHANIC AND WAS INFORMED THAT THE TRANSMISSION NEEDED TO BE REPLACED; HOWEVER, THEY DID NOT EXPLAIN WHAT CAUSED THE FAILURE. THE VEHICLE IS CURRENTLY REPAIRED AND A NEW TRANSMISSION WAS INSTALLED. THE CONTACT BELIEVES THAT A TRANSMISSION SHOULD NOT HAVE TO BE REPAIRED WITHIN FIVE YEARS. THE FAILURE MILEAGE WAS 34,000.

I WAS DRIVING HOME FROM WORK AND THE MINI COOPER WOULD NOT ACCELERATE ANY LONGER. FORTUNATELY, I WAS ABOUT A MILE AWAY FROM HOME AND CALLED FOR HELP. WE HAD TO PUSH THE CAR ALL THE WAY HOME. COME TO FIND OUT, MANY PEOPLE HAVE BEEN HAVING THE SAME PROBLEM WITH THE MINI COOPER TRANSMISSION. THEY NOTED SOMETHING ABOUT THE CVT TRANSMISSION THAT MINI TRIED EXPERIMENTING WITH. I'VE READ MANY STORIES WHERE MINI CARS JUST STOPPED IN THE MIDDLE OF THE HIGHWAY. MANY MINI TRANSMISSIONS HAVE BEEN GIVING OUT AROUND 70,000 TO 80,000 MILES WHICH IS UNORTHODOX FOR A TRANSMISSION. THE COST TO REPLACE THE TRANSMISSION WAS APPROX 8,000. *TR

MY CAR WAS PARKED AFTER BEING DRIVEN FOR 20 MILES OR SO. WITHIN TEN MINUTES OF BEING PARKED, MY OFFICEMATE RAN INTO THE OFFICE SAYING MY CAR WAS SMOKING. IT WAS ACTUALLY ON FIRE. THE FIRE DEPARTMENT CAME AND PUT OUT THE FIRE. MY MECHANIC SAYS THAT IT IS A FAILURE OF THE POWER STEERING PUMP. I NEED TO REPLACE IT, THE FAN, AND MOST OF THE WIRING AROUND THE PART. RIGHT NOW, I'M TRYING TO FIND A WIRE FOR HIM THAT MINI WILL NOT GET HIM. IT IS IN THE PROCESS OF BEING CORRECTED. *TR

MY CVT IN MY 2003 MINI COOPER FAILED AT 85000 MILES.. SUDDENLY AND IT SEEMS A RARER LARGE PERCENT ARE FAILING. WITH AN AVERAGE REPLACEMENT PRICE OF $7000.. FOR A CAR THAT COST $21,000.. NEVER HAD A TRANSMISSION FAIL LIKE THIS.!! CAR WAS TOWED TO DEALER.. APPRO 1.4 MILES AWAY AND WE WERE GIVEN A LIFT HOME... APPROX 24 MILES AWAY. WE ARE WAITING TO HEAR WHAT THE REPAIR COST WILL BE BUT RESEARCH GAVE ME THE NUMBER ALREADY OF $7000. TO BE HONEST.. I CANT AFFORD THAT !!! *TR

TL*THE CONTACT OWNS A 2003 MINI COOPER. WHEN THE CONTACT WOULD TURN OFF THE VEHICLE, SHE COULD STILL HEAR THE MOTOR FAN RUNNING. SHE TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE POWER STEERING HOSE AND FAN NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED BECAUSE THE WARRANTY EXPIRED, AND THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. ALSO, ALL OF THE WINDOWS ON HER VEHICLE WOULD SPONTANEOUSLY OPEN. SHE TOOK THE VEHICLE TO THE DEALER AND A TECHNICIAN DEACTIVATED THE CONVENIENCE POWER SYSTEM FOR THE POWER WINDOWS. AFTER THE REPAIR, THE FAILURES CONTINUED. THE CONTACT CALLED THE MANUFACTURER, BUT THEY DID NOT PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 73,000.

2 TRANSMISSIONS NEEDED TO BE REPLACED WITHIN 1 1/2 YEARS. 1ST TRANS WAS REPLACED IN NOVEMBER 2006 AFTER EXPERIENCING GRINDING NOISE IN THE FRONT END OF THE CAR. ON FRIDAY MAY 2, 2008 HEARD A POP WHILE TURNING LEFT AND EXPERIENCE THE GRINDING NOISE. DEALER NOW STATES THAT IT'S THE TRANSMISSION AND WANT $5,000 TO REPLACE. I COMPLAINED THAT THIS IS THE SECOND ONE IN 1 1/2 YEARS AND WAS TOLD THAT A CALL WAS PLACED TO THE ENGINEER AND WAITING FOR THEIR RESPONSE ON WHETHER THEY WILL COVER THE COSTS. *TR

CVT FAILURE AT 37,000 MILES DEALER ESTIMATES COST AT $8,400 TO REPLACE (THERE IS NO REPAIR OPTION). *TR

OVERHEATING OF POWER STEERING PUMP. *TR