2004 Mercury Grand Marquis complaints

TAKATA RECALL: TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT THERE WAS A SUDDEN LOSS OF POWER STEERING ABILITY, WHICH RANDOMLY PROGRESSED WITHOUT WARNING. THE CONTACT STATED THAT WHEN THE STEERING WHEEL WAS TURNED LEFT OR RIGHT, THE CONTACT HAD TO APPLY FORCE TO PREVENT THE STEERING WHEEL FROM GOING STRAIGHT SEVERAL TIMES. IN ADDITION, THE AIR BAG WARNING LIGHT RANDOMLY FLASHED. THE VEHICLE WAS TO BE TAKEN TO A DEALER FOR INSPECTION AND DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. WHILE DRIVING 25 MPH, THE HEADLIGHTS FAILED. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 174,000.

THE BRIGHT HEADLIGHTS WILL WORK ONLY WHEN I HOLD THE LEVER ON THE COLUMN IS HELD BACK WHILE DRIVING.

HEADLIGHTS GO OFF WITHOUT WARNING WHILE DRIVING OR STATIONARY. THEY MAY OR MAY NOT COME BACK ON. HAS HAPPENED MANY TIMES AND NOW EVERYDAY. THE LIGHTS WORK FOR THREE - FIVE MINUTES THEN GO OFF. THE MECHANIC SHOP SAYS IT IS A FAULTY LIGHT CONTROL MODULE.

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. WHILE DRIVING AT APPROXIMATELY 75 MPH, THE HEADLIGHTS FAILED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.

HEADLIGHTS FLICKER ON AND OFF WITHOUT WARNING. I HAVE TO HOLD MY BRIGHT LIGHTS SWITCH TOWARDS ME IN ORDER TO SEE ON THE ROAD AT NIGHT ON MY WAY TO AND FROM ANY GIVEN DESTINATION WITHOUT WARNING. I'VE HAD IT FIXED BUT DIDN'T FIX THE PROBLEM BECAUSE IT CONTINUES TO HAPPEN.

I RECEIVED A CUSTOMER SATISFACTION PROGRAM LETTER ON APRIL 14 2014, REGARDING MY LIGHTING CONTROL MODULE. THE MODULE WENT OUT ON JUNE 30 2015. I HAD THE LETTER BUT I FORGOT ABOUT IT UNTIL I WAS LOOKING UP SOME PAPERS JUST RECENTLY. OF COURSE I HAD IT FIXED BY A PRIVATE GARAGE ON 6/ 30/ 2015. IT ONLY HAD 61,416 MILES . ON IT AT THAT TIME. I CAN NOT SEE WHY I CAN NOT BE REIMBURSED FOR THE REPAIR NOW. IT COST ME $387.02. I HAVE BEEN A FORD CUSTOMER SINCE 1956.

VEHICLE HEADLIGHTS WORK INTERMITTENTLY . CRUSE CONTROL DOES NOT RESET OR TURN ON WHEN SUPPOSED TO. THIS IS ALSO AN INTERMITTENT PROBLEM, SOMETIMES RESETTING, AND SOMETIMES NOT. HEADLIGHTS WOULD SOMETIMES NOT TURN ON WHEN DRIVING UNLESS PULLING TURN SIGNAL ARM TOWARD STEERING WHEEL AND HOLDING. HIGH BEAMS ONLY WOULD WORK.

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. WHILE DRIVING APPROXIMATELY 40 MPH, THE HEADLIGHTS BECAME INOPERABLE AT NIGHT. THE CONTACT STATED THAT THE FAILURE RECURRED DAILY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. THE VIN WAS NOT AVAILABLE. UPDATED 11/25/15*LJ THE CONSUMER STATED THE HEAD LIGHTS WERE REPLACED. UPDATED 01/29/16

MY 2004 MERCURY GRAND MARQUIS HAS EXTREMELY TIGHT STEERING ISSUE. ESPECIALLY TIGHT ON LEFT TURNING. THE CAR ONLY HAS 51,900 MILES. SAW FORD HAS RECALLED 2005 TO 2011. NOT SURE WHY THEY DON'T RECALL 2003 AND 2004. THEY ARE THE SAME GENERATION. THE PROBLEM WAS FOUND IMMEDIATELY AFTER PARKED 2 DAYS. FORTUNATELY IT IS NOT ON HIGHWAY. CAN'T IMAGE WHAT SAFETY PROBLEM IT WILL CAUSE.

LIGHTING CONTROL MODULE HAD BAD SOLDER JOINT. LIGHTING CUT OFF IN MIDDLE OF THE DESERT AT 65+ MPH. I PAID 300+ FOR A NEW LCM.

I AM HAVING A DIFFICULT TIME MOVING MY STEERING WHEEL ON MY 2004 MERCURY GRAND MARQUIS. IT STARTED WITH SOME NOISY OPERATION OF THE STEERING WHEEL. ONCE I CAN GET THE STEERING WHEEL TO MOVE THE CAR DOESN'T WANT TO TURN. I AM A AFRAID TO DRIVE IT ON THE ROAD. FROM WHAT I HAVE READ THERE IS A ISSUE WITH A COMPONENT OF THE STEERING SYSTEM AND YOUR DEPARTMENT IS INVESTIGATING IT. I HAD A 2009 MERCURY GRAND MARQUIS THAT A STEERING PART RECALLED.

I WAS DRIVING IN A SMALL TOWN ON SMALL STREET WITH NO STREET LIGHTING. I WAS ABOUT 15 MILES PER HOUR AND STARTED TO BRAKE FOR A STOP SIGN. HEADLIGHTS FLASHED AND WENT OUT. I TURNED MY HEADLIGHTS OFF AND THEN TURNED THEM BACK ON AND THEY WERE GOOD. AFTER MAKING A LEFT TURN FROM THE STOP SIGN ABOUT 100 FEET MY LIGHTS WENT OUT. IT TOOK A WHILE TO FIND IN THE DARK A PLACE TO PULL OVER. I TRIED TURNING MY ENGINE OFF COMPLETELY, AND WHEN I STARTED IT BACK UP, NO LIGHTS. I PLAYED AROUND WITH MY LIGHT LEVERS AND FINALLY FOUND THAT IF I DEPRESSED AND HELD THE FLASH LEVER MY LIGHTS WOULD WORK. I HAD ONE HECK OF A TIME TRYING TO MAKE TO LEFT TURNS AND HOLD DOWN LEVER TO GET HOME.

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. WHILE THE VEHICLE WAS COMING TO A STOP, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE SPEED AND RPMS INCREASED WITHOUT WARNING. THE CONTACT CONTINUED TO DEPRESS THE BRAKE PEDAL; HOWEVER, THE VEHICLE FAILED TO RESPOND. THE CONTACT POWERED THE VEHICLE OFF AND NOTICED BLUE SMOKE EMITTING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000. MA 09/25 UPDATED 12/05/2017*CN

MAIN HEADLIGHTS STARTED GOING OUT. PROBLEM FIRST NOTED AFTER DRIVING THROUGH HEAVY RAIN ON 7/9/15. HEADLIGHTS WILL COME ON, BUT GO OFF WITHOUT WARNING AFTER VARYING PERIODS OF TIME. WILL FLASH ON HIGH-BEAM BUT NOT STAY ON. ALL OTHER EXTERIOR AND INTERIOR LIGHTS WORK NORMALLY.

I JUST RECENTLY PURCHASED THIS VEHICLE FROM A SMALL DEALER ON 6/30/15. ON 7/8/15, AT ABOUT 8PM, I WAS DRIVING HOME FROM A LONG TRIP FOR WORK, GOT ABOUT 20 MILES INTO MY 70 MILE DRIVE, WHEN IT SEEMED LIKE THE ROAD IN FRONT OF ME WAS DARKER THAN IT SHOULD HAVE BEEN, I MADE SURE MY HEADLIGHT SWITCH WAS ON HEADLIGHT MODE. IT WAS ACTUALLY ON AUTOMATIC MODE, SO SWITCHED IT TO REG HEADLIGHT MODE. I WAS NOT USE TO THIS NEW CAR YET, HAVING NOT DRIVEN IT MUCH AT NIGHT YET AND JUST THOUGHT IT WAS MY IMAGINATION, THAT THEY WERE NOT ON AS THEY SEEMED TO HAVE WORKED PREVIOUSLY. I KEPT DRIVING AS I COULD STILL SEE THE ROAD IN FRONT ON ME BUT IT WAS DEFINITELY GETTING DARKER AND DARKER AND NOW CARS COMING FROM THE OTHER DIRECTION WERE FLASHING ME, SO I HAD A FEELING THAT THEY WERE NOT WORKING. WHEN IT WAS SAFE TO DO, AFTER TRYING UNSUCCESSFULLY TO GET THE HEADLIGHTS WORKING BY TURNING THE SWITCH DIAL, I IMMEDIATELY FOUND A SOMEWHAT SAFE SPOT TO PULL OVER. I GOT OUT, LOOKED IN THE FRONT AND SURELY THEY WERE NOT WORKING BUT ONLY IN FLASH MODE. I TURNED CAR OFF, CHECKED FUSES, WAITED ABOUT 10 MORE MINUTES, THEN STARTED CAR AGAIN. THEY FINALLY CAME ON, SO I TOOK ADVANTAGE OF THE SITUATION AND MADE A DASH TOWARDS HOME AGAIN, WHICH WAS PROBABLY ANOTHER 35 MILES OR SO. I DO HAVE AAA, IF I NEEDED TO USE IT BUT JUST WANTED TO GET HOME. I MADE IT HOME SAFELY, THANK GOD BUT THIS SEEMS TO BE INTERMITTENT, AS THEY WORK SOMETIME AND OTHER TIMES THEY DON'T. I WAS WONDERING IF THERE IS ANY RECALL ON THIS MA

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. WHEN TURNING THE VEHICLE, THE STEERING WHEEL SEIZED AND THEN RETURNED TO NORMAL. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE INTERMEDIATE SHAFT WAS BINDING UP AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE HEADLIGHTS FAILED WITHOUT WARNING. THE CONTACT WAS ABLE TO MANEUVER TO THE SIDE OF THE ROAD AND WAITED UNTIL THE HEADLIGHTS RE-ILLUMINATED. THE FAILURE RECURRED MULTIPLE TIMES. THE CONTACT WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE HEADLIGHT CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,500.

I STARTED MY CAR AFTER DARK AND DID NOT HAVE ANY HEADLIGHTS. ALL THE OTHER LIGHTS WORKED. THE ONLY WAY I COULD MAKE THE HEADLIGHTS FUNCTION WAS BY HOLDING THE HIGH BEAM SWITCH ON THE SIGNAL LEVER TOWARD ME ALL THE WAY HOME, OVER 1 HOUR.. WHEN I GOT HOME I LOOKED ON THE INTERNET TO SEE IF THIS WAS A COMMON PROBLEM AND IT IS WITH THIS YEAR AND MODEL CAR. IT IS A SAFETY ISSUE AND THE MANUFACTURER SHOULD WARN AND ADDRESS THIS PROBLEM.

I WAS DRIVING IN LOW LIGHT CONDITIONS WITH THE HEADLIGHT SWITCH IN THE 'ON' POSITION AND NOTED NO LIGHTS, I PULLED TO THE SIDE OF THE ROAD AND NOTED ALL OTHER LIGHTS BRAKE/TAIL/RUNNING WERE IN WORKING ORDER. AFTER A BRIEF OUTAGE THE LIGHTS CAME BACK ON - AND I CONTINUED ON. LATER THAT EVENING APPROXIMATELY 11P, IN THE DARK, I WAS TO RETURN HOME. THE HEADLIGHTS FAILED TO LIGHT AFTER SEVERAL ATTEMPTS AND I HAD TO DRIVE HOME WHILE HOLDING MY HIGH BEAM SELECTOR IN THE FLASH TO PASS POSITION. AFTER APPROXIMATELY 7 MILES THE HEADLIGHTS CAME BACK ON AND I MADE IT HOME. I CHECKED THE INTERNET AND FOUND A 'CUSTOMER SATISFACTION' CAMPAIGN, THOUGH NOT A RECALL. I CALLED THE DEALERSHIP AND EXPLAINED THE ISSUE, THEY HAD ME IN THE NEXT DAY, REPLACED THE PART AND HAD ME BACK ON THE ROAD IN UNDER AN HOUR, AT NO COST. THE PART ALONE IS $260 ON INTERNET SITES, AND I'VE HEARD OF DEALER CHARGING 600-7000 DOLLARS FOR THE REPAIR - PRIOR TO THE CAMPAIGN. I'M SATISFIED AND HOPE IT IS FIXED FOR GOOD NOW.

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. WHILE DRIVING AT AN UNKNOWN SPEED, THE STEERING FAILED WITHOUT WARNING. THE DEALER DIAGNOSED THAT THE UPPER INTERMEDIATE SHAFT FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000. UPDATED 8/10/15*CN THE CONSUMER STATED THE VEHICLE WAS REPAIRED. UPDATED 11/30/2015 *JS

STEERING WHEEL SUDDENLY HARDER TO TURN. *TR

VEHICLE STEERING BECAME STIFF. BROUGHT TO LOCAL DEALERSHIP AND THE LOWER STEERING SHAFT AND INTERMEDIATE STEERING SHAFT WERE SEIZED FROM COLUMN. HAD TO HAVE BOTH STEERING SHAFTS REPLACED. DEFINITELY WAS DANGEROUS AND ACCIDENT COULD HAVE OCCURRED. TOTAL COST OF REPLACEMENT WAS $882.55. VEHICLE WAS REPAIRED AT SARAT FORD, 245 SPRINGFIELD ST., AGAWAM, MA 01001, 413-786-0430. IT IS MY UNDERSTANDING THAT THERE WAS A SAFETY REVIEW FOR THIS PROBLEM THAT WAS INITIATED IN THE FALL OF 2014. WHAT WAS THE END RESULT OF THE REVIEW? DO YOU ANTICIPATE A RECALL FOR THIS ISSUE? THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN IN FOR SERVICE AND IT WAS DETERMINED THAT THE UPPER INTERMEDIATE DRIVE SHAFT WAS STARTING TO SEPARATE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 88,000.

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. WHILE ATTEMPTING TO TURN THE STEERING WHEEL LEFT OR RIGHT, IT WAS EXTREMELY TIGHT. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE STEERING SHAFT NEEDED TO BE REPLACED. THE CONTACT VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V704000 (STEERING) AND 13V385000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 38,157. UPDATED 7/9/2015

WHILE DRIVING DOWN THE ROAD THE HEADLIGHTS JUST GO OUT AND DON'T COME BACK ON. *TR

HEADLIGHTS SUDDENLY GO OUT WHILE DRIVING AT NIGHT. SWITCHING BETWEEN SETTINGS DOES NOT BRIGHT THEM BACK ON. THE ONLY WAY TO HAVE ANY HEADLIGHTS ON AT ALL IS TO PULL AND HOLD THE BAR THAT TURNS ON THE BRIGHTS. *TR

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. WITHOUT WARNING, THE LOW BEAM HEADLIGHTS FAILED TO WORK WHILE OPERATING THE VEHICLE. THE CONTACT HAD TO USE THE HIGH BEAMS AND THE DAYTIME RUNNING LAMPS EACH TIME THE FAILURE OCCURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

I RECENTLY(2 MONTHS) RETURNED MY 2003 GRAND MARQUIS DUE TO THE HEADLIGHTS GOING OUT INTERMITTENTLY. MY MECHANIC EXPLAINED THAT THERE WAS A RECALL FOR THE FAILURES OF THE LCM. THE DEALERSHIP REPLACED THE DEVICE IN JANUARY. LAST NIGHT WHILE I WAS DRIVING IN THE DARK, THE LIGHTS WENT OUT AGAIN. THIS WILL AGAIN NEED TO BE REPLACED. ARE THEY USING FAULTY PARTS FOR THE RECALL? THIS IS VERY DANGEROUS AND I AM LUCKY TO BE ALIVE TO EVEN TYPE THIS TODAY. *TR

I NOTICED A LOUD GROANING SOUND FROM MY CAR ANYTIME I TURNED LEFT OR RIGHT. I TOOK IT TO AN INDEPENDENT SHOP, WHICH FLUSHED THE POWER STEERING SYSTEM AND REPLACED THE POWER STEERING PUMP. AFTERWARDS, THE CAR'S STEERING WAS EVEN WORSE, TURNING FAILED MULTIPLE TIMES, WOULD NOT TURN LEFT OR RIGHT WITHOUT EXCESSIVE FORCE. I FEAR FOR THE SAFETY OF MYSELF AND MY 4-YEAR-OLD WHILE OPERATING THE CAR. IT IS STILL AT THE SHOP, NOW THEY WILL REPLACE RACK AND PINION SHAFT, AND/OR LOWER INTERMEDIATE SHAFT, TOTALING NEAR $2000. I CANNOT AFFORD TO PAY, NOT WHEN THERE IS A RECALL FOR GRAND MARQUIS' 2005-2011, MANUFACTURED MARCH 4, 2004-2011 (RECALLS 13S08, 14S25) FOR THE EXACT SAME ISSUES. PLEASE HELP, MY CAR WAS MANUFACTURED WITHIN THIS WINDOW, ON APRIL 30, 2004. *TR

I LEFT THE HOUSE AFTER DARK TO PICK UP MY HUSBAND FROM WORK. WHEN I GOT TO HIS JOB I TURNED THE CAR OFF BECAUSE I WAS EARLY. WHEN HE GOT TO THE CAR AND I RESTARTED IT THE HEADLIGHTS DID NOT COME ON. THEY CAME BACK ON AFTER I USED THE TURN SIGNAL ABOUT 2 MINUTES LATER. AFTER THAT WE NOTICE THAT OCCASIONALLY THE LIGHTS WOULD GO OFF WHILE DRIVING AT NIGHT BUT WOULD COME BACK ON AFTER A COUPLE OF MINUTES. UNTIL ONE NIGHT WHEN THEY STOP WORKING ALTOGETHER. IT STAYED THAT WAY TILL WE TOOK IT TO A DEALERSHIP WHERE THEY INFORMED US THAT THEY WERE AWARE OF IT HAPPENING TO OTHER CARS BUT THE PIECE THAT WE NEEDED WAS ON BACK ORDER AND WE WOULD HAVE TO WAIT FOR ONE AND A HALF MONTHS. WHILE WE WERE WAITING THE ONLY WAY TO HAVE HEADLIGHTS WHILE DRIVING WAS TO HOLD THE HIGH BEAMS STICK BECAUSE IT WOULDN'T EVEN WORK IF YOU PUSHED THE HIGH BEAMS TO THE ALWAYS ON POSITION. *TR

TL*THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. THE CONTACT STATED WHILE TURNING, THE STEERING FAILED WITHOUT WARNING AND WOULD NOT RESPOND. THE FAILURE RECURRED ON A DAILY BASIS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE STEERING ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 77,083.

2004 MERCURY GRAND MARQUIS. CONSUMER WRITES IN REGARDS TO HEADLIGHTS FAILED TO COME. *SMD CONSUMER SENT ADDITIONAL CORRESPONDENCE. *SMD THE CONSUMER RECEIVED A LETTER FROM FORD ANNOUNCING A RECALL PROGRAM (14N01). THE LETTER STATED THERE MAYBE A POSSIBILITY THAT AN ELECTRONIC MODULE LIGHTING CONTROL MODULE THAT SUPPLIES POWER TO THE HEADLIGHTS MAY FAIL. THE CONSUMER STATED SHE BEGAN NOTICING THE HEADLIGHT FAILURE IN JUNE. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DETERMINED THE PROBLEM WAS COVERED BY THE RECALL PROGRAM. THE DEALER ORDERED THE REPLACEMENT. HOWEVER, THE MANUFACTURER WAS UNABLE TO PROVIDE A DATE, AS TO WHEN THE PART WOULD BE AVAILABLE. *JB

STEERING HAS BECOME PROGRESSIVELY MORE DIFFICULT OVER THE PAST TWO MONTHS. INITIALLY THE TIGHT STEERING WOULD GO AWAY AFTER DRIVING, OR ONLY BE SLIGHTLY NOTICEABLE. HOWEVER AT THIS POINT, THE WHEEL CAN ONLY BE TURNED BY APPLYING SIGNIFICANT FORCE, AND THEN WHEN THE WHEEL DOES TURN, IT DOES SO IN A JERKY FASHION.

HEADLIGHTS GO OUT UNEXPECTEDLY AND W/O WARNING. THIS HAS HAPPENED AT ALL DIFFERENT SPEEDS, IN A PARKING LOT 5-10MPH, ON ROADWAY 30-45MPH AND ON THE HIGHWAY65-70MPH. LIGHTS WILL COME BACK ON JUST AS UNEXPECTEDLY W/O APPARENT CAUSE. HAVE SHUT DOWN AND RESTARTED CAR WITH NO EFFECT, TURNED LIGHT SWITCH ON/OFF, NO EFFECT AND THEN THEY WILL TURN ON AFTER SEVERAL MINUTES WHILE PARKED. SOMETIMES THE LIGHTS WILL TURN ON AND OFF SEVERAL TIMES BEFORE STAYING LIGHT. *TR

I HAVE ESCAPED QUITE A FEW ACCIDENTS ON MY WAY HOME. WITH THE NEW TIME CHANGE, I LEAVE WORK RIGHT AT DUSK. THE LIGHTS WILL NOT COME ON. I LIVE WAY OUT IN THE COUNTRY AND HAVE TO DRIVE 15 MILES OUT. I HAVE TO SWITCH TO MY HIGH BEAM WHEN A CAR IS COMING MY WAY, AND I BLIND IT AND OTHER CARS AS WELL. I AM SOOOO TIRED OF THIS. I AM GOING TO CAUSE A TERRIBLE ACCIDENT !!!! I TOOK MY RECALL LETTER TO THE FORD CAR DEALERSHIP HERE IN TOWN MONTHS AND MONTHS AGO. I KEEP CALLING FOR AN UPDATE, AND THEY SAY THAT THE PART HAS NOT COME IN. WHAT CAN I DO? *TR

MY LIGHTS WILL NOT COME ON THEY JUST SWITCH OFF SOMETIMES. I HAVE THE HOLD THE BRIGHTS JUST FOR THE LIGHTING TO GET HOME... *TR

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT AFTER TURNING THE STEERING WHEEL, IT FAILED TO RETURN TO THE CENTER. ADDITIONALLY, THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING COLUMN WHEN MAKING A TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE RACK AND PINION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.

TL- THE CONTACT STATED 2004 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT NHTSA ACTION NUMBER: PE08066 (EXTERIOR LIGHTING) HAD EXCEEDED THE REASONABLE AMOUNT OF TIME FOR REPAIR. THE DEALER STATED THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE DELAY. THE VEHICLE WAS NOT REPAIR. THE CONTACT HAD MENTION HE HAD EXPERIENCED THE FAILURE ON MULTIPLE OCCASION. HE STATED WHILE DRIVING AT VARIOUS SPEEDS SPONTANEOUSLY BOTH FRONT AND REAR TAIL LIGHTS FAIL TO ILLUMINATE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000. AZ

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE WINDOW SWITCH WAS INOPERABLE. THE SWITCH WAS PREVIOUSLY REPLACED TWICE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 86,000. UPDATED 11/21/14*CN UPDATED 8/13/2015 *JS

THE LEFT HAND (DRIVER SIDE) HEAT SHIELD THAT COVERS THE EXHAUST MANIFOLD HAS COMPLETELY RUSTED AT THE BOLTING POINTS CAUSING THE COVER TO DISLODGE AND DRAG AGAINST THE STEERING SHAFT . SEVERAL TIMES WHILE TURNING AT INTERSECTIONS, ESPECIALLY WHEN MAKING LEFT TURNS, THE STEERING WOULD TEMPORARILY LOCK UP FOR A FEW SECONDS MAKING TURNING EXTREMELY HAZARDOUS. ONCE I ALMOST STRUCK ANOTHER VEHICLE DUE TO THE STEERING BEING LOCKED WHILE TURNING. I INITIALLY SUSPECTED LOW POWER STEERING FLUID BUT FLUID CHECKED CORRECT AND PUMP SEEMS TO BE WORKING FINE. I DID NOT NOTICE THE RUSTED COVER PINNED BETWEEN THE STEERING SHAFT AND MANIFOLD UNTIL I REMOVED THE ENGINE COVER AND AIR INTAKE TUBING TO ACCESS THE SPARK PLUGS. I REMOVED THE RUSTED SHIELD AND THE CAR TURNS JUST FINE NOW. I HAVE THE RUSTED SHIELD AVAILABLE FOR INSPECTION IF NEEDED. THANKS *TR

I WENT TO DRIVE MY CAR FROM MY HOME PARKING SPACE AND WHEN TRIED TO TURN THE WHEEL IT WOULDN'T TURN. I TRIED AGAIN AND GOT THE STEERING WHEEL TO TURN SOME AMOUNT BUT IT WAS PRETTY HARD TO DO. AS I TURNED THE WHEEL A LITTLE MORE IT EASED UP A BIT AND THEN BECAME HARD AGAIN. PART OF TURNING THE WHEEL IS QUITE HARD AND THEN PART IS A LITTLE MORE NORMAL. THE STEERING SEEMS VERY BAD AND HARD TO CONTROL. I HAD NO PREVIOUS PROBLEMS AND HAVE NOT SUFFERD ANY DAMAGE FROM DRIVING. I WAS AFRAID SOMETHING WAS LODGED IN THE ENGINE COMPARTMENT SO I CHECKED AND COULD SEE NOTHING OUT OF THE ORDINARY. I PARKED THE CAR AND DROVE MY OTHER CAR FOR THE WEEK. SOMETHING IS PHYSICALLY WRONG WITH THE CAR STEERING AND I FEEL IT IS UNSAFE TO DRIVE ON ANY ROAD. I'M AFRAID IT WILL BREAK WHILE DRIVING. THE CAR IS NOT DRIVEN VERY MUCH AND IS IN PRETTY NICE SHAPE. *TR

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE STEERING SHAFT WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 194,000.

I WAS DRIVING ALONG AND STARTED TO TURN UP A STREET AND IT TOOK 2 LANE'S BECAUSE THE STEERING CALM. FROZE UP AND HARD TO TURN. I TOOK IT TO THE FORD DEALER AND THEY TOLD ME ALL THE 2004 FORD GRAND M. HAVE THE SAME PROB. . HOWEVER ,THEY HAVE NOT BEEN RECALLED ONLY THE 2005 - 2011. I HAD IT FIXED BECAUSE I NEED MY CAR. ITS THE LOWER STEERING SHAFT. BY THE WAY THE CAR ONLY HAS 33890 MILE'S. I ONLY DRIVE IT TO CHURCH ON SUNDAY'S AND TO THE FOOD STORE ONCE A WEEK SO IT SITS A LOT, HOWEVER NOT THE PROB. FROM SITTING, JUST CRAPPIE PART'S. *TR

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT THE HEADLIGHTS FAILED. THE CONTACT MENTIONED THAT BOTH. THE LOW AND HIGH BEAM LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE LIGHTING CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 69,000.

2004 MERCURY GRAND MARQUIS. CONSUMER WRITES IN REGARDS TO VEHICLE HEADLIGHTS TURN OFF RANDOMLY AND CONSUMER UNABLE TO TURN THEM BACK ON. *SMD THE CONSUMER STATED THE PART NEEDED, WAS ON A 3 MONTH BACK ORDER. *JB

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE ACCELERATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 162,000.

HEADLIGHTS RANDOMLY TURN OFF WHILE DRIVING. FORD STATES THIS IS NOT A SAFETY ISSUES, IT IS! CAN'T BE DRIVING WITHOUT HEADLIGHTS; CAN CAUSE ACCIDENTS, TICKETS, FAILURE TO PASS STATE INSPECTIONS, ETC. FORD HAS ISSUED CUSTOMER RELATIONSHIP CAMPAIN 14N01, BUT THE PART TO FIX THIS PROBLEM IS ON BACK ORDER, AND THEY ARE UNABLE OR UNWILLING TO GIVE ANY TIME FRAME ON WHEN PART WITLL BE AVAILABLE. *TR

TL* THE CONTACT OWNS A 2004 MERCURY GRAND MARQUIS. THE CONTACT RECEIVED A MANUFACTURER'S RECALL REGARDING THE HEADLIGHT MODULE AND WAS INFORMED THAT THE PART NEEDED TO REMEDY THE VEHICLE WAS UNAVAILABLE. THE DEALER DID NOT KNOW WHEN THE PARTS WOULD ARRIVE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED HEADLIGHT FAILURE ON MULTIPLE OCCASIONS. THE VIN WAS UNAVAILABLE. THE NHTSA CAMPAIGN NUMBER WAS NOT FOUND. THE FAILURE MILEAGE WAS UNKNOWN.

1ST INCIDENT: HEADLIGHTS WENT OFF ABOUT 2 MINUTES AFTER STARTING CAR AND BEGINNING TO DRIVE . WOULD NOT TURN ON AGAIN WHILE DRIVING OR WHEN CAR WAS STOPPED AND RUNNING. TURNED OFF CAR AND TRIED AGAIN. HEADLIGHTS WORKED FOR ABOUT 30 SECONDS. CONTINUING THIS PATTERN AFTER 2 WEEKS. HEADLIGHTS DO COME ON WHEN HIGH BEAM 'FLASH' LEVER IS HELD IN ON POSITION.. HAVE NOT TESTED HOW LONG THEY WILL STAY ON. *TR