2002 Mercury Cougar

Defect. FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.

Risk. THE NUTS INCLUDED IN THE PACKAGING FOR THESE BALL JOINT ASSEMBLIES ARE MISSING THE INTENDED PREVAILING TORQUE (SELF-LOCKING) FEATURE. IF THE INCORRECT NUT WAS TO BECOME LOOSE, THE JOINING MEMBERS MAY LOOSEN LEADING TO A SEPARATION OF THE BALL JOINT. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. FEDERAL MOGUL WILL NOTIFY OWNERS AND REPLACE THE PARTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 22, 2008. OWNERS CAN CONTACT FEDERAL MOGUL AT 877-489-6659.

Defect. CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Risk. LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Remedy. AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Defect. ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.

Risk. THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.

Remedy. THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. THE CAMPAIGN BEGAN ON APRIL 16, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

AIRBAG WARNING LIGHT COMES ON. NO ACCIDENT, STATIONARY AND IN MOTION. I DO NOT SEE A RECALL REFERENCE AIRBAG? WITH THE COMPLAINTS I READ ON YOUR SITE ABOUT THE AIRBAGS, THERE SHOULD BE A RECALL???????????

I AM CURRENTLY HAVING PROBLEMS WITH THE FUEL PUMP DRIVER MODULE. I REPORTED THE PROBLEM TO FORD IN OCT 2018. FORD STATED THAT THE 10 YEAR RECALL ENDED AND PER THEIR RECORDS THE ISSUE WAS RESOLVED AS FUEL MODULE WAS REPLACED BY DEALER DON KNOTT FORD, CARSON, CA. DON KNOTT FORD IS NO LONGER IN BUSINESS. THE AFOREMENTIONED DEALER I BELIEVE WAS INVOLVED IN UNETHICAL BUSINESS PRACTICES. I WAS NEVER INFORMED OF SUCH A RECALL AND DEALER NEVER CHANGED MODULE, I DO NOT HAVE DOCUMENTATION & WOULD LIKE SUCH FOR MY RECORDS. I AM ORIGINAL OWNER OF VEHICLE AND THE PERIODIC INADVERTENT SURGING OF VEHICLE WHEN STOPPED/STATIONARY AT A STREET LIGHT BEGAN 6 MONTHS AGO. I CANNOT 100% SAFELY DRIVE THIS VEHICLE AT THIS TIME. FORD HAS NOT PROVIDED ME DOCUMENTATION OF THE ALLEGED REPAIR AND/OR DOCUMENTATION INFORMING ME OF RECALL. I WOULD LIKE TO HAVE A COPY OF THIS DOCUMENTATION AND/OR HAVE FORD CHANGE THE MODULE SO THE SURGING CAN STOP. YOUR CONSIDERATION AND REVIEW WOULD GREATLY BE APPRECIATED. LASTLY, FORTUNATELY I HAVE A 2ND VEHICLE THAT I HAVE BEEN USING. THANK YOU FOR YOUR ANTICIPATED REVIEW OF THIS MATTER. YOURS TRULY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE CAR WAS PARKED IN MY DRIVEWAY. UPON STARTING THE CAR, AT THE MOMENT I TURNED THE KEY THE DRIVER SEAT AIRBAG DEPLOYED.

I HAVE FOUND 3 RECALLS FOR MY CAR, THEY ARE ALL THE EXACT PROBLEMS I AM HAVING, BUT WHEN I SEARCHED FOR OPEN RECALLS IT SAID NONE ARE OPEN FOR MY CAR. I NEED MY CAR REPAIRED AND THE RECALLS COMPLETED.

MY CAR WAS STOLEN

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. WHILE DRIVING UNKNOWN SPEEDS, THE HEADLIGHTS DIMMED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE PROTECTED WIRING COVER WAS DETERIORATING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 165,000.

NHTSA CAMPAIGN NUMBER:04V421000 MANUFACTURER FORD MOTOR COMPANY WAS DRIVING ON A MAIN CITY ST. MY AUTO STOPPED WITH NO POWER IN THE LEFT LANE OF BUSY 4 LANE ST. WOULD NOT START IN NEUTRAL OR PARK, MAN PUSHED IT INTO THE CTR. LANE OUT OF TRAFFIC AREA. POLICEMAN CAME AFTER I CALLED 911, AFTER A FEW MINUTES HE SUGGESTED TAKING KEY OUT STEPPING ON BRAKE THEN INSERTING KEY BACK IN IGNITION, DID THAT AND IT STARTED RIGHT UP, AND HE FOLLOWED ME TO MY ST. AND I GOT SAFELY HOME. PRIOR TO THIS SHUT DOWN INCIDENT IT HAD STALLED GOING DOWN A HILL HOWEVER PUT IT IN NEUTRAL AND IT STARTED UP AGAIN. THIS INCIDENT COULD HAVE CAUSED A SERIOUS ACCIDENT, PRIOR TO THIS INCIDENT IT HAD BEEN CUTTING OUT FOR A COUPLE OF MONTHS WHICH I THOUGHT WAS CHEAP GAS, SO CHANGED TO TECTRON. I HAVE CALLED FORD ON 3/15 TWICE AND THEY SAID THEY CAN NOT DO ANYTHING ABOUT IT, I THEN RESEARCHED THIS ONLINE AND FOUND THIS SITE AND WANT TO POST EXACTLY WHAT HAPPENED TO ME AS SHOWN BY THE NHTSA ON RECALL ETC. IT DOES SHOW IT IS FOR THE ORIG OWNER, I AM THE 2ND. OWNER HOWEVER THIS HAS OCCURRED WITHIN THE 15YR. LIMITATION YOU HAVE POSTED FOR COMPLAINTS EXPLAINED TO FORD THAT IT MAY HAVE TAKEN THIS LONG FOR THE FILTER TO REACT IN THIS MANNER.

SINCE PURCHASING 2002 MERCURY COUGAR IN JANUARY 2010 THE VEHICLE HESITATES, SURGES, AND STALLS AT ANY RATE OF SPEED. INITIALLY THE PROBLEM WAS RARE, THEN GRADUALLY OCCURRED MORE FREQUENTLY. THIS NOW HAPPENS AT LEAST WEEKLY, SOMETIMES SEVERAL TIMES PER DAY. THIS ISSUE HAS ENDANGERED ME MORE TIMES THAN I CAN CURRENTLY RECALL. REPLACED ALTERNATOR, BATTERY, EGR VALVE AND SENSOR, IAC VALVE, AND CATALYTIC CONVERTER. THE ISSUE PERSISTS.

DRIVING ON FREEWAY, CAR NEXT TO ME CAME INTO MY LANE TOWARDS MY CAR, I HIT MY BRAKES RESULTING IN MY VEHICLE SWERVING AND HITTING THE MEDIAN HEAD ON AT HIGH SPEED, AIR BAGS DID NOT DEPLOY UPON IMPACT. *TR

I'M HAVING THE SAME ISSUE WITH MY 2002 MERCURY COUGAR AS EVERYONE ELSE, BUT WHEN I PUT MY VIN NUMBER INTO THE SEARCH, THERE ARE NO RECALLS LISTED FOR IT. I DON'T THINK THAT ITS RIGHT THAT MY LIFE BE PUT IN SERIOUS DANGER BECAUSE OF AN APPARENT DESIGN ISSUE. THIS CAR IS LOSING ALL POWER AND SHUTTING DOWN. IT DOESN'T MATTER HOW FAST YOU ARE GOING, IT HAPPENS AT ALL SPEEDS. WE THOUGHT THE ALTERNATOR WAS BAD, HAD IT REPLACED AND THE BATTERY AT THE SAME TIME. THE SAME DAY, THE CAR LOST ALL POWER AGAIN AND DIED OUT GOING 60 MPH ON THE HIGHWAY. ALL THE GAUGES START GOING CRAZY AND THE LIGHTS DIM AND EVENTUALLY EVERYTHING INCLUDING THE CAR JUST QUITS. MERCURY/FORD, NEEDS TO BE RESPONSIBLE FOR THIS COFFIN THAT I'M TRYING TO DRIVE AND FIX THE PROBLEM FOR ME AND EVERYONE ELSE FOR FREE. I'VE DONE SOME ONLINE RESEARCH ON THIS, AND IT SEEMS LIKE THERE ARE A TON OF PEOPLE WITH THE SAME PROBLEM FROM YEARS 99 TO 02. *TR

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT WHILE SHE DRIVING AT 30 MPH, THE VEHICLE HESITATED AND JERKED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE FUEL PUMP. HOWEVER, THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER 04V421000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 29,000.

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 50 MPH, SHE WAS NOTIFIED BY ANOTHER DRIVER THAT THE FRONT OF THE VEHICLE WAS ENGULFED IN FLAMES. THE CONTACT BEGAN TO COAST ONTO THE EMERGENCY LANE AND REMOVED A CHILD PASSENGER FROM THE VEHICLE HOWEVER, THE VEHICLE STALLED. THERE WERE NO INJURIES DUE TO THE FAILURE. THE FIRE DEPARTMENT WAS CONTACTED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO A JUNK FACILITY. THE FAILURE WAS NOT DIAGNOSED TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN 04V421000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 142,000.

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE MADE A KNOCKING NOISE AND STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC WAS UNABLE TO DIAGNOSE THE PROBLEM. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

I WAS ON MY WAY TO WORK AND ABOUT ONE MILE FROM MY DESTINATION THE ENGINE JUST STOPPED. I LET IT SIT ABOUT TWENTY MINUTES AND IT FINALLY STARTED AGAIN. THIS HAPPENED SEVERAL DAYS OF SHUTTING OFF WHILE I WAS ON THE ROAD DRIVING. LUCKILY I WAS AT A PLACE WHEN I COULD PULL OVER ON THE SIDE OF THE ROAD AND GET OUT OF THE LINE OF TRAFFIC EXCEPT FOR ONE TIME WHEN I WAS AT A STOP LIGHT AND IT SHUT OFF AND I SAT AND WAIT AND IT FINALLY STARTED AGAIN AND I WAS ABLE DRIVE IT TO A SAFE SPOT. I TOOK IT TO A MECHANIC AND HE TOLD ME THE COMPUTER NEEDS TO BE REPLACED. THE ONLY PLACE THAT COULD REPLACE THE COMPUTER WAS THE DEALER. I TOOK IT TO THE DEALER AND AFTER BEING AT THE DEALER FOR THREE DAYS THEY SAID THAT THE IGNITION NEED REPLACING. THEY REPLACED THE IGNITION AND AFTER THREE MORE DAYS THERE AND WHILE THEY WERE WORKING ON OTHER REPAIR PARTS THAT THEY SAID I NEEDED DONE THE ENGINE SHUT OFF ABOUT TWO MORE TIMES. ON MARCH 13, 2014 THEY TOLD ME THAT ALL REPAIR WORK HAD BEEN COMPLETED AND THE ENGINE SHUTTING OFF WAS SOLVED. THE TOTAL BILL CAME TO CLOSE TO $3,000.00. I AM PLANNING ON PICKING UP THE VEHICLE ON MONDAY, MARCH 17, 2014 WHEN I WILL HAVE THE MONEY TO PAY THEM. I HEARD ABOUT CARS ENGINES SHUTTING OFF WHILE DRIVING ON THE RADIO (WTOP). I JUST WANTED TO REPORT HOW MY VEHICLE WAS HAVING THE SAME OR SIMILAR PROBLEM. I AM A BIT NERVOUS ABOUT DRIVING THIS VEHICLE IF THIS COULD POSSIBLE HAPPEN AGAIN. THE RADIO REPORT WAS ABOUT GM VEHICLES I HAVE A MERCURY AND THIS HAPPENED TO MY CAR. *T

MY DAUGHTER HAS A 2002 MERCURY COUGAR AND IS RISKING HER LIFE AS WELL AS OTHERS LIVES EVERY TIME SHE GETS INSIDE THAT CAR. HER COUGAR HER BEEN HAVING ISSUES FOR MONTHS NOW, AND EVEN THOUGH WE HAVE SPENT HUNDREDS OF DOLLARS TRYING TO MAKE THE CAR SAFER FOR HER, NOTHING IS WORKING. OUR LAST STRAW WAS THREE DAYS AGO, WHEN THE CAR STALLED ON HER ON THE HIGHWAY. SHE WAS TRAVELING ABOUT 45 MILES PER HOUR, WHEN THE CAR STALLED AND SHUT OFF LEAVING HER STRANDED WAITING FOR THE TOW TRUCK. HER CAR, FOR MONTHS, HAS BEEN SURGING WHILE AT COMPLETE STOPS, AND HAS BEEN SHUTTING OFF WHILE AT A STAND STILL. WE'VE TRIED FIXING MANY THINGS, BUT NOTHING SEEMS TO BE FIXING THE ISSUE. AFTER DOING EXTENSIVE RESEARCH, I HAVE COME TO REALIZE THAT MANY OTHERS ARE HAVING THE SAME ISSUES. CAN SOMEONE DO SOMETHING ABOUT THIS PLEASE?? ITS CLEARLY AN ON-GOING ISSUE AND IS COSTING PEOPLE LOTS OF MONEY. HER CAR IS CURRENTLY BACK AT THE DEALERSHIP WHERE WE PURCHASED THE CAR, AND IS UNDERGOING DIAGNOSTICS. WE WERE ALREADY TOLD THAT HER CAR WAS NOT INCLUDED IN THE RECALL, AND WE WILL HAVE TO PAY FOR EVEN MORE WORK, OUT OF POCKET. PLEASE HELP.. WHY WAS IT NOT INCLUDED IN THE RECALL, SEEING THAT IT IS HAVING THE SAME PROBLEMS?! *TR

THE CAR GETS A STALLING SENSATION WHEN AT A RED LIGHT, OR A COMPLETE STANDSTILL. IT FEELS LIKE ITS STUTTERING AND UNABLE TO KEEP POWER. CHANGED EGR VALVE, 2 IDLE CONTROL CHANGES, ALONG WITH A TRANSMISSION FLUSH WAS DONE. NOTHING SEEMS TO BE FIXING THE ISSUE. THE CAR ACTS UP AND STALLS IN COLD TEMPERATURES. STALLED AT A RED LIGHT TWICE. HAS BEEN TAKEN TO DIFFERENT CAR SHOPS ON NUMEROUS OCCASIONS. NO ENGINE LIGHT COMES ON. *TR

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH IN A DRIVEWAY, THERE WAS A SUDDEN INCREASE IN THE ACCELERATION. THE VEHICLE FAILED TO DECELERATE EVEN AS THE CONTACT APPLIED THE BRAKES. THE CONTACT WAS UNABLE TO CONTROL THE FAILURE AND CRASHED INTO A HOUSE. THE CONTACT SUSTAINED A FRACTURED LEFT WRIST. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE SUSTAINED SEVERE FRONT END DAMAGES. THE VEHICLE WAS TOWED TO A POLICE IMPOUND LOT. THE MANUFACTURER WAS NOT NOTIFIED OF THE ACCELERATION FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE STALLED AS THE BATTERY, ENGINE, AND OIL WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,600.

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT HAD THE VEHICLE TOWED TO A REPAIR SHOP FOR INSPECTION WHERE THEY STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED AND THEY STATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALL. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 10/11/12*LJ UPDATED 10/16/2012 *JS

I WAS DRIVING MY 2002 COUGAR AND THE VEHICLE BEGAN TO LOSE POWER, THE CHECK ENGINE LIGHT AND THE FUEL LIGHT CAME ON. THE VEHICLE CAME TO A COMPLETE STOP IN THE MIDDLE OF THE ROAD. I HAVE ALSO EXPERIENCED THE VEHICLE SURGING WHILE AT A COMPLETE STOP. I CONTACTED THE SERVICE MANAGER AT MY LOCAL DEALER AND THE ONLY RESOLUTION HE COULD PROVIDE ME WAS TO HAVE A TECHNICIAN DRIVE IT AND SEE IF IT WOULD HAPPEN AGAIN. EVEN THOUGH I EXPLAINED THERE HAVE BEEN NUMEROUS COMPLAINTS ABOUT THE ISSUE BY OTHER DRIVERS ON LINE, HE SAID THERE WAS NOTHING HE COULD DO. MY VIN NUMBER IS NOT INCLUDED IN THE RECALL "BATCH" OF VEHICLES. I COULD PAY THE $100 DIAG FEE IN THE EVENT MY VEHICLE DOES NOT REPEAT THE COMPLAINT. EITHER WAY, I WOULD BE PAYING FOR THE REPAIRS OUT OF POCKET. *TR

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT SHE OPENED THE SUN ROOF AND WAS UNABLE TO GET THE SUN ROOF TO CLOSE. THE VEHICLE WAS TAKEN TO A PERSONAL MECHANIC FOR DIAGNOSIS AND THE SUN ROOF WAS CLOSED. THE CONTACT WAS TOLD BY THE MECHANIC THAT THE MOTOR WAS FINE BUT SHE NEEDED TO REPLACE THE SWITCH. THE SWITCH WAS REPLACED AND ONE WEEK AFTER HAVING IT REPAIRED, THE SUN ROOF WOULD NOT CLOSE. THE DEALER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 59,000 AND THE CURRENT MILEAGE WAS 63,000. UPDATED 8/24/12 *CN

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE SUDDENLY DECREASED TO 10 MPH. THE VEHICLE WAS TAKEN TO A DEALER AND THEY ADVISED HER THAT ALL THREE CATALYTIC CONVERTERS WERE CLOGGED AND THE FDM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED FOR THE FDM BUT NOT THE CATALYTIC CONVERTERS. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 72,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. WHILE DRIVING AT APPROXIMATELY 20 MPH THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED THE FUEL DELIVERY MODULE NEEDED TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 04V421000 (FUEL SYSTEM, GASOLINE) THAT MAY BE RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,028.

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT WHEN APPLYING THE ACCELERATOR, THE VEHICLE WOULD HESITATE, LOSE POWER AND THEN SURGE ABNORMALLY. THE DEALER WAS CONTACTED AND ADVISED THAT THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 04V421000 (FUEL SYSTEM, GASOLINE) BUT THE CONTACTS VIN WAS NOT INCLUDED. THE MANUFACTURER WAS CONTACTED WHO CONFIRMED THAT HER VIN WAS NOT INCLUDED IN THE RECALL LIST. NO FURTHER ASSISTANCE WAS OFFERED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 116,000.

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD STALL OR SURGE FORWARD. THE MANUFACTURER WAS NOTIFIED, AND THE CONTACT WAS INFORMED THAT VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 04V421000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 110,000, AND THE CURRENT MILEAGE WAS 115,000.

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE WOULD HESITATE TO ACCELERATE FROM STOPS AND INTERMITTENTLY JERK WHILE SHIFTING GEARS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE IN THE PROCESS OF DIAGNOSING THE FAILURE. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 04V421000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 56,000.

2002 V6 MERCURY COUGAR CHUGS AND STALLS OUT AT OR BELOW HALF TANK OF GAS. ENGINE LIGHT DIAGNOSTIC READ OUT INDICATES REPLACING FUEL PUMP, REGULATOR, PRESSURE SENSOR, OR O2 SENSOR. HAVE REPLACED FUEL PUMP HOWEVER ISSUE REMAINS. CALLED FORD REGARDING RECALL IN AUG 2004, BUT AM TOLD THAT MY VIN# WAS NOT AFFECTED BY THIS RECALL. READING THE DESCRIPTION OF THE RECALL SOUNDS ALL TOO FAMILIAR THOUGH. *TR

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT WAS DRIVING APPROXIMATELY 60-65 MPH WHEN THE VEHICLE BECAME HESITANT AND WOULD DECELERATE INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE HE WAS ADVISED THAT THE AIR CONDITIONING CLUTCH WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED YET THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO A SECOND DEALER WHERE UNKNOWN REPAIRS WERE MADE. THE VEHICLE WAS REPAIRED SEVERAL TIMES BUT TO NO AVAIL. MOST RECENTLY, THE CONTACT WAS ADVISED THAT THE FUEL PUMP WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 04V421000 (FUEL SYSTEM, GASOLINE) AND WAS ADVISED BY THE DEALER AND THE MANUFACTURER THAT HIS VEHICLE WAS NOT INCLUDED. THE CONTACT STATED THE CONSEQUENCE STATED IN THE RECALL WAS THE SAME EXACT FAILURE HE HAD EXPERIENCED SINCE 2003. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 105,000.

MY 2002 MERCURY COUGAR HAS LOST POWER, SHUTTERED, MISFIRED, AND ESSENTIALLY BROKE DOWN THE SAME WEEK I PAID IT OFF! MY 2002 MERCURY COUGAR WAS INCLUDED IN THE RECALL SO I TOOK IT TO A LOCAL DEALERSHIP AND THEY SAID MY VIN NUMBER WAS NOT PART OF THE RECALL? HUNDREDS OF PEOPLE HAVE COMPLAINED ABOUT THIS PROBLEM AND FORD IS REFUSING TO FIX CERTAIN VIN NUMBER THAT THEY CLAIM ARE NOT AFFECTED, HOW IS THIS POSSIBLE? THERE ARE AWAY TO MANY 2002 COUGARS WITH THE SAME PROBLEM. FORD IS REFUSING TO FIX THE PROBLEM AND NOW I HAVE A CAR THAT DOES NOT RUN. THIS CAR HAS HAD A PROBLEM WITH STALLING AND SHUTTERING SINCE DAY 8 OF PURCHASE. *TR

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE WOULD STALL INTERMITTENTLY WITHOUT WARNING. SHE WAS ABLE TO LOCATE A RECALL FOR THE EXACT SAME FAILURE FOR HER YEAR, MAKE AND MODEL VEHICLE. THE DEALER STATED THAT HER VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN AND ANY REPAIRS WOULD BE AT HER EXPENSE (NHTSA CAMPAIGN ID NUMBER 04V421000: FUEL SYSTEM, GASOLINE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 72,000.

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT OPENED HER SUNROOF AND THE LIFT ON THE PASSENGER SIDE DID NOT OPEN. THE CONTACT INFORMED THE DEALER AND THEY STATED THAT SHE WOULD HAVE TO HAVE THE LINER AND MOTOR REPAIRED. AFTER RESEARCHING THE PROBLEM SHE HAS FOUND SEVERAL CONSUMERS THAT HAS EXPERIENCED THE SAME FAILURE. THE MANUFACTURER WAS NOT CONTACTED AS OF YET. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 141000 AND THE APPROXIMATE CURRENT MILEAGE WAS 144500.

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. HE STATED THAT THE VEHICLE BEGAN TO HESITATE AND LOSE POWER. THE FAILURE WAS IDENTICAL TO NHTSA CAMPAIGN ID NUMBER: 04V421000; HOWEVER, THE MANUFACTURER INFORMED THE CONTACT THIS HIS VIN DID NOT APPLY TO THE RECALL. THE CURRENT AND FAILURE MILEAGES WERE 127,000. UPDATED 12/30/09 *CN THE FUEL FILTER WAS REPLACED. UPDATED 12/30/09*JB

2002 COUGAR EXHIBITS "ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS". YOUR WEBSITE SHOWS A EXTENDED WARRANTY FOR THIS AS OUR MECHANIC SAYS WE NEED A NEW FUEL PUMP. FORD DENIES THE CAR IS COVERED. *TR

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT THE FUEL DELIVERY MODULE (FDM) REDUCED AND EVENTUALLY BLOCKED THE FLOW OF FUEL TO THE ENGINE. THE VEHICLE LOST POWER WHILE DRIVING 50 MPH. THE VEHICLE WAS REPAIRED TWICE, BUT THE FAILURE STILL PERSISTS. THE MANUFACTURER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 04V421000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 112,000 AND CURRENT MILEAGE WAS 113,184.

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CLIP ON THE DRIVER'S SIDE OF THE SUN ROOF FAILED AND PREVENTS THE SUN ROOF FROM CLOSING PROPERLY. THE CONTACT RESEARCHED THE ISSUE AND FOUND THAT IT WAS A VERY COMMON FAILURE. SHE CALLED THE DEALER AND WAS INFORMED THAT THE FAILURE WAS COMMON AND SHE WOULD BE RESPONSIBLE FOR THE REPAIRS. THE CONTACT BELIEVES A RECALL SHOULD BE ISSUED. THE CURRENT AND FAILURE MILEAGES WERE 99,000.

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. WHILE DRIVING APPROXIMATELY 45 MPH ON NORMAL ROAD CONDITIONS, THE CONTACT HEARD A LOUD NOISE AND EXPERIENCED A LOW POWER RESPONSE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THERE WAS ALSO ENGINE HESITATION AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED INTERMITTENTLY ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND THEY STATED THAT THE FUEL DELIVERY MODULE FAILED. THE TECHNICIAN STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 04V421000 (FUEL SYSTEM, GASOLINE), ALTHOUGH THE FAILURES WERE IDENTICAL. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 88,500 AND CURRENT MILEAGE WAS 89,000.

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE WOULD OFTEN FAIL TO ACCELERATE AND INCREASE IN RPM'S. IN ADDITION, THE VEHICLE WOULD FREQUENTLY STALL. ONCE THE VEHICLE WAS TURNED OFF, IT WOULD RESTART IMMEDIATELY. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC BECAUSE THE WARRANTY WAS NO LONGER VALID. THE MECHANIC DIAGNOSED THE CAUSE OF THE FAILURE AS A FAULTY FUEL INJECTOR. THE VEHICLE WAS REPAIRED, BUT THE FAILURE STILL PERSISTS. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V421000 (FUEL SYSTEM, GASOLINE), ALTHOUGH THE FAILURES WERE IDENTICAL. THE MANUFACTURER WAS UNABLE TO PROVIDE ASSISTANCE. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 98,000.

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT THE REAR SEAT BELTS FAILED TO PROPERLY SECURE THE CHILD SAFETY SEAT OR AN OCCUPANT. HE STATED THAT THE FAILURE COULD POSSIBLY BE DUE TO THE LATCH. THE VEHICLE HAS NOT YET BEEN TAKEN TO AN AUTHORIZED DEALER. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 66,600.

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. WHILE DRIVING 15 MPH, THE VEHICLE BEGAN TO HESITATE AND THEN STALL. OCCASIONALLY, ONCE THE VEHICLE IS STARTED, THE ENGINE REVS RANDOMLY AND LOUDLY, AND DOES NOT RUN SMOOTHLY. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CONTACT DISCOVERED NHTSA CAMPAIGN ID NUMBER 04V421000 (FUEL SYSTEM, GASOLINE), BUT HIS VIN WAS NOT INCLUDED IN THE RECALL. HE BELIEVES THAT IF THE FAILURES ARE IDENTICAL, HIS VEHICLE SHOULD BE INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 61,500 AND CURRENT MILEAGE WAS 63,000. UPDATED 07/15/08 *BF UPDATED 07/15/08. *JB

I HAVE A 2002 MERCURY COUGAR THAT HAS SEVERE STALLING, ROUGH IDLE AND EXTREME SURGING WHILE DRIVING OF AT IDLE. THE VEHICLE HAS STALLED WHILE MY DAUGHTER WAS DRIVING MANY TIMES. I DID A SEARCH AND FOUND CAMPAIGN #04V421000 ON YOUR WEBSITE AND THIS CAR EXHIBITS ALL THE SIGNS DETAILED OUT IN THE CAMPAIGN. I CALLED MY DEALER (DAVE KNAPP FORD) AND THE SERVICE MANAGER DID A VIN SEARCH AND SAID THIS VEHICLE WASN'T INCLUDED IN THIS CAMPAIGN. MY COMPLAINT IS THAT MY VEHICLE FITS THESE SYMPTOMS TO A "T" AND THAT, I BELIEVE THAT IS SHOULD BE COVERED, ESPECIALLY IF IT'S A KNOWN PROBLEM! BY THE WAY, THIS HAS BEEN OCCURRING FOR SEVERAL MONTHS NOW AND I AM FEARING FOR MY DAUGHTERS SAFETY. THANK YOU. *TR

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE BEGAN TO LOSE POWER WHILE DRIVING, WHICH MADE IT DIFFICULT TO STEER THE VEHICLE. HE EXPERIENCED DIFFICULTLY PULLING THE VEHICLE TO THE SIDE OF THE ROAD. AFTER APPROXIMATELY 15 MINUTES, THE VEHICLE WAS ABLE TO BE RESTARTED AND OPERATED NORMALLY. HE DROVE THE VEHICLE HOME AND LATER CALLED THE DEALER. THE DEALER ADVISED HIM TO BRING IN THE VEHICLE AND THEY MADE REPAIRS AT THE COST OF $697. THE FAILURE WAS IDENTIFIED AS BEING INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V421000 (FUEL SYSTEM, GASOLINE). THE FAILURE COULD CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED AND CAUSE THE ENGINE TO STALL. THE FAILURE MILEAGE WAS 84,000 AND CURRENT MILEAGE WAS 86,000. UPDATED 07/16/08*LJ THE BUSHINGS AND CLUTCH WERE WORN. THE FUEL PUMP AND FUEL SENDER WERE REPLACED. THE ENGINE LIGHT WAS ON. THE DEALER REPLACED A LEAKING INTAKE. UPDATED 07/16/08

ENGINE HESITATION, LOSS OF POWER, SURGING AND STALLING LEADING TO NEAR MISSES IN TRAFFIC ,AT STOP LIGHTS & WHILE TURNING A CORNER. FORD AND THEIR DEALERS CLAIM THAT THEIR RECALL # 04V421000 HAS EXPIRED AND DOES NOT APPLY. *TR

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. WHILE IDLING, THE ENGINE REVS AND THE VEHICLE ACCELERATES ON ITS OWN. THE DEALER STATED THAT NO RECALLS WERE AVAILABLE; HOWEVER, THE CONTACT DISCOVERED NHTSA CAMPAIGN ID NUMBER 99V194000 (VEHICLE SPEED CONTROL). IN ADDITION, THE CHECK ENGINE LIGHT REMAINS ILLUMINATED FOR WEEKS AT A TIME. NHTSA CAMPAIGN ID NUMBER 04V421000 (FUEL SYSTEM, GASOLINE) WAS REFERENCED. THE CONTACT STATED THAT WHEN THE VEHICLE IS STARTED AND THE DOORS ARE SHUT, THE POWER DOOR LOCKS AUTOMATICALLY LOCK. ALSO, THE DOORS AUTOMATICALLY LOCK WHILE DRIVING. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 99V226000 (LATCHES/LOCKS/LINKAGES: DOORS:LATCH). THE CURRENT MILEAGE WAS 114,000 AND FAILURE MILEAGE WAS APPROXIMATELY 50,000.

PURCHASED THIS USED VEHICLE -- 3 DAYS LATER, CAR WOULD NOT START -- MOTOR TURNED OVER, IF WAS NOT GETTING GAS. BROUGHT GAS TO THE CAR, IT HAD ONLY 1/4 OF A TANK, PUT MORE GAS IN, IT EVENTUALLY STARTED. TOOK IT FOR A DIAGNOSTIC TEST -- FUEL PUMP NOT FUNCTIONING CORRECTLY. RECALL 04N02 WAS ISSUED FOR THIS MODEL/YR CAR, NOT THIS VEHICLE VIN NUMBER, THEREFORE FORD WILL NOT STAND BEHIND THIS CAR PROBLEM AND PAY TO HAVE IT FIXED. *TR

AUTOMATIC TRANSMISSION FAILURE AT 85,000 MILES UNDER NORMAL OPERATION AND MAINTENANCE. *TR

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT THE ENGINE HESITATES AS IF THERE IS NO GAS FLOW. THE DEALER STATED THAT A DIAGNOSIS WAS NEEDED; HOWEVER, THE CONTACT STATED THAT A PREVIOUS DIAGNOSIS DID NOT FIND ANY FAILURES. THE REPAIR SHOP CHANGED THE ENGINE OIL, REPLACED THE FILTER, AND CLEANED THE FUEL INJECTION, BUT THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER IS AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN RECALL NUMBER 04N02. THE FAILURE MILEAGE AND DEALER INFORMATION WERE UNAVAILABLE. THE CURRENT MILEAGE WAS 106,881.

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT WAS UNABLE TO START THE VEHICLE AFTER IT WAS PARKED OVERNIGHT. THE DEALER STATED THAT THE FUEL PUMP CAUSED THE FAILURE. AS OF DECEMBER 28, 2007, THE DEALER HAD NOT REPLACED THE FUEL PUMP. THE DEALER STATED THAT HIS VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 04V421000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE CURRENT AND FAILURE MILEAGES WERE 45,000.

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE SHUTTERED RAPIDLY, THE CHECK ENGINE LIGHT ILLUMINATED, AND THE VEHICLE COMPLETELY STALLED. THE LOCAL DEALER RESET THE P-CODES. SEVERAL MONTHS LATER, THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO ANOTHER DEALER. THE DEALER STATED THAT HER VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V421000 (FUEL SYSTEM, GASOLINE). THE VEHICLE HAS NOT BEEN REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 50,000 AND CURRENT MILEAGE WAS 69,000.

I HAVE FIRESTONE FIRE HAWK TIRES ON MY 2002 MERCURY COUGER XR. THE TIRE MODEL NUMBER IS 215-50-17. MY CAR HAS 44,000 MILES ON IT. I BOUGHT IT NEW AND I HAVE HAD 5 FLAT TIRES ON THE FRONT TWO TIRES OF MY CAR. THE REAR TIRES HAVE 44,000 MILES ON THEM. EACH TIME I GET A FLAT TIRE, THE TIRE IS SHREDDED IN THE INSIDE AND I HAVE BEEN LUCKY THAT I WAS DRIVING IN THE CITY NOT GOING VERY FAST. I HAVE BEEN TOLD EVERY TIME THAT MY TIRE PRESSURE MUST BE LOW AND THEREFORE CAUSED A FLAT. I GOT MY 5TH FLAT TIRE IN 4 YRS ON 11/22/07 (THANKSGIVING). MY TIRES HAD JUST BEEN CHECK WHEN I GOT MY OIL CHANGE TWO WEEKS BEFORE, BUT I STILL GOT A FLAT TIRE. I HAD JUST BEEN DRIVING ON A HWY GOING 65MPH AND I AM THANKFUL IT DIDN'T HAPPEN THEN, I AM DISABLED AND THE ROAD I HAD BEEN DRIVING ON WAS IN THE MIDDLE OF NO WHERE. SOON AFTER I RETURN TO TOWN I GOT A FLAT TIRE. MY HUSBAND WAS THEN IN THE CAR WITH ME. I TOOK THE TIRE IN TO POMPS TIRES THE SAME PLACE I HAVE ALWAYS TAKEN THEM, AND THE TIRE WAS AGAIN SHREDDED. I AM NOT SURE IF ANYONE ELSE HAS HAD THIS PROBLEM BUT I TRULY THINK THESE TIRES ARE DEFECTIVE AND DANGEROUS. *TR

LOSS OF POWER, SURGING, SO I TOOK TO DEALER THEY CHANGED FUEL PUMP SUPPOSEDLY AND FILTER AND TRANSMISSION FLUID. ONE WEEK LATER I TOOK IT BACK BECAUSE IT CONTINUED TO DO THE SAME, THEY SAID THEY CHECKED A WIRE TO FUEL PUMP AND CHANGED A SPARK PLUG, AND HERE IT IS ANOTHER WEEK WITH THE SAME SYMPTOMS. *TR