2014 Mercedes-Benz ML350

Defect. Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2012-2014 ML550, 2012-2015 ML350, AMG ML63, 2015 ML250, ML400, 2016 GLE450, GLE300, 2016-2018 GLE350, GLE550, 2016-2019 GLE400, 2017-2019 AMG GLE43, and 2016-2020 AMG GLE63 vehicles. Water might accumulate in the spare tire wheel well and damage the fuel pump control unit, which could cause an engine stall while driving.

Risk. An engine stall while driving increases the risk of a crash.

Remedy. Dealers will install a water drain plug, inspect for water intrusion, and replace the fuel pump control unit as necessary, free of charge. Owner notification letters were mailed February 15, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's numbers for this recall are 2023010002 and 2023010003.

Defect. Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2013-2017 vehicles due to a software fault that may cause the date and time for the emergency call system (eCall) to differ from the actual date and time, potentially relaying an inaccurate vehicle location. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V787-4620.pdf

Risk. An inaccurate vehicle location may delay emergency responders, increasing the risk of injury.

Remedy. MBUSA has initiated an Over the Air (OTA) remote update. MBUSA will also notify owners, and dealers will check software for a successful OTA or update the communication module software as needed, free of charge. The recall began December 23, 2019. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2019120008.

Defect. Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2012-2014 ML350 Bluetec 4Matic and ML550 4Matic, 2012-2015 ML63 AMG 4Matic and ML350 4Matic, 2013-2016 GL350 Bluetec 4Matic, GL550 4Matic and GL63 AMG 4Matic, 2017 GLS350d 4Matic, GLS450 4Matic, GLS550 4Matic and GLS63 AMG 4Matic, 2015 ML400 4Matic, 2016 GLE400 4Matic, GLE350 4Matic, GLE63 AMG 4Matic, GLE63S AMG 4Matic, GLE450 4Matic Coupe and GLE63S AMG 4Matic Coupe, 2015-2016 GL450 4Matic and 2013-2014 GL450 4Matic vehicles equipped with the Active Curve System (ACS). In certain driving conditions, if the oil level in the ACS reservoir is below the minimum level, the oil may foam and leak out of the vent holes in the reservoir cap.

Risk. The leaking oil in the presence of an ignition source can increase the risk of a fire.

Remedy. MBUSA will notify owners, and dealers will correct the oil level as necessary and replace the reservoir sealing cap to prevent oil foam from leaking out, free of charge. The recall began August 30, 2018. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2018070015.

Defect. Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2016 AMG GT-S, GLC300, CLA250 and GLE300d 4Matic vehicles, 2013 C250, E350 BlueTec and G63 AMG vehicles, 2008-2014 C300 vehicles, 2013-2014 C300 4Matic and ML350 4Matic vehicles, 2009 C350 vehicles, 2014 CLS550, E350 4Matic, E350 Coupe 4Matic, E350 Wagon 4Matic, GLK350 and SL550 vehicles, 2012 CLS550 4Matic vehicles, 2012-2016 E350 vehicles, 2016-2017 GL450 4Matic vehicles, 2012-2014 ML350 4Matic BlueTec vehicles, 2015 S550, S550 4Matic and C300 4Matic Sedan vehicles, 2015-2016 C300 Sedan vehicles, and 2017 SL63 AMG vehicles. Various control units on these vehicles may have been updated with incorrect software, potentially affecting the correct deployment of the air bags in the event of a crash.

Risk. If the air bags do not deploy as intended in the event of a crash, there would be an increased risk of injury in the event of a crash.

Remedy. MBUSA will notify owners, and dealers will update software in the affected control units, free of charge. The recall began April 21, 2017. Owners may contact MBUSA customer service at 1-800-367-6372.

Turn signals stop functioning during drive cycles. This functionality is lost for the remainder of the current drive cycle and can be restored with a key cycle. It does not occur every drive cycles and is unpredictable.

The contact owns a 2014 MERCEDES-BENZ E350. The contact stated while driving 60 MPH on the freeway, there was a popping noise coming from the sunroof and discovered it was shattered. The vehicle was not taken to the dealer or an independent mechanic for diganoses .The vehicle was not repaired The manufacturer was not notified of the failure. The approximate failure mileage was 108,000 .

The contact owns a 2014 Mercedes-Benz ML350. The contact stated that while driving at 35 MPH and accelerating above 40 MPH, the vehicle failed to accelerate above 40 MPH before it lost automotive power. The vehicle was driven back to the residence. The vehicle was diagnosed by the dealer, and the failure was associated with NHTSA Campaign Number: 22V955000 (FUEL SYSTEM, DIESEL, FUEL SYSTEM, GASOLINE); however, the VIN was not associated with the recall repair. The vehicle was repaired out of pocket. The manufacturer was notified of the failure. The failure mileage was 115,000.

Today at 1/27/25 630 pm my vehicle caught fire.i was told that the vehicle was subject to the Active Curve System (Recall 18V272) and Fuel Pump (Recall 23V010).

It seems that this vehicle was not included in a brake booster recall which included this model from 2005 through 2015. The brakes are not working properly, and brake fluid has entered the master brake cylinder damaging the seal. It is extremely unsafe to operate this vehicle in this condition. Somehow, this vehicle was not included in the recall, but definitely should have been.

As we were driving 50mph, the car stalled and lost all power. The dashboard lights all lit up and the car wouldn't start. I don't get unnerved easily and it was fairly intense not being able to move your car out of traffic. After about 5 mins, the car would start again only to stop a minute or so later. After taking the car to the dealer, the issue stemmed from the fuel pump electronics board getting wet in the spare tire wheel well where water was accumulating. This was part of the recall and the dealer installed a drain and replaced the board. HOWEVER, this issue again happened nearly one year later in our next rainy season. After taking it to the dealer, they said WE would need to replace the electronics board ourselves. We asked about the recall and they said they fixed the issue by installing the drain plug and there was nothing else they could do for us. Even the service adjuster was upset and very sympathetic to our plight as the car was obviously not fixed. Even though the drain plug was installed, the water was still acumulating in the wheel well. It seems apparent to me, and several others who have complained about the same issue, that the recall fix has not addressed the main issue of why the water is coming in and why it's still not draining. Unfortunately we're going to have to fork over $1200 to have it fixed. My ask to the NHTSA is that this issue be readdressed with Mercedes. I would like them to be notified that the recall does not address the underlying issu

Vehicle: 2014 Mercedes-Benz ML350 VIN: [XXX] I have experienced repeated failures of the Blind Spot Assist / driver-assist system since purchasing this vehicle. When I first purchased the ML350 in Texas, the vehicle already showed warning messages (“Blind Spot Assist Inoperative / Pre-Safe Function Limited”). The dealer attempted repairs before delivery, but the defect persisted. After moving to New York, the problem continued. On June 26, 2023, I took the vehicle to The Automaster Mercedes-Benz in Shelburne, VT. Their diagnosis confirmed water intrusion into the blind spot radar sensors, consistent with Mercedes-Benz TSB LI54.71-P-056477. Both left and right sensors and wiring require replacement. This is a safety defect because Blind Spot Assist and Pre-Safe features are disabled without warning, increasing risk of collision when changing lanes. Many other owners have reported the same issue, and Mercedes has issued a TSB acknowledging the defect, but no recall has been provided. I request that NHTSA investigate this recurring safety problem and require Mercedes-Benz to provide coverage or a recall for affected vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2014 Mercedes-Benz ML350. The contact stated that upon starting the vehicle, the blind spot warning light illuminated. The contact was unable to identify if another vehicle was nearby. The vehicle was taken to an independent mechanic who determined that the blind spot detection system was inoperative. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 170,001.

Driver side airbag malfunction without notice .serious bodily injury incase of an accident.

I purchased a used Mercedes-Benz from Freehold Mitsubishi in early 2024. Within hours, serious safety issues appeared, including a check engine light, cylinder misfire, EVAP leak, traction control failure, and blind spot assist malfunction. The vehicle’s ECM and wiring harness were later found damaged due to oil leaks and electrical shorts. Despite multiple repair attempts, the vehicle was returned in worse condition and remains unsafe to drive. I am reporting these issues due to their potential risk to vehicle safety.

The contact owns a 2014 Mercedes-Benz ML350. The contact stated while the vehicle was idling in the driveway, the vehicle stalled. The contact stated that AAA added fuel to the vehicle, and the vehicle was able to restart and operated as needed. The contact stated that the vehicle was taken to the dealer for the recall repair of NHTSA Campaign Number: 22V955000 (Fuel System, Diesel, Fuel System, Gasoline), and the dealer installed a water drain plug on the vehicle. The contact stated that the check engine warning light was later intermittently illuminated. The vehicle was taken to Complete Performance, where it was diagnosed with fuel pressure failure. The contact replaced the gas cap; however, the failure persisted. Additionally, the contact stated while driving 45 MPH, the vehicle stalled while there was sufficient fuel in the fuel tank. The contact was able to pull over to the side of the road. The vehicle was able to restart after fuel was added to the vehicle. An unknown dealer was notified of the failure and informed the contact that the fuel pump was not previously replaced during the recall repair of NHTSA Campaign Number: 22V955000( Fuel System, Diesel, Fuel System, Gasoline). The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 60,000.

I purchased my car used at the Mercedes dealership in Tyler Texas June 2023. I took all my savings and paid cash and was told that the car was impeccable shape and there were no current issues and all the service records were up to date. November 2023 is when everything started happening and my engine light came on. It was revealed to me by a service tech that I was sold the vehicle with an existing major oil leak /seals broke. Etc. SEE Attached invoices. I have endured driving down the road and my car just giving out and losing power steering. The car has been sputtering and there have been misfires, fauled fuel injectors, coils, s and spark plugs, oil leaks, fuel pump leaking gasoline in the engine and smoke coming from the hood. I thought my car was going to start on fire it smelled like a hot electrical wires and gasoline. My nerves are frayed from this car because of how many times it has broke down. I have missed work because of the car, I'm behind on my home bills, I missed my airline flight to see my sick father, I have had to pay for rental cars, all due to this vehicle. I am very concerned for my safety in this vehicle and I would like the vehicle fixed at the expense of Mercedes or my money back. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I purchased four brand new "GoodYear" tires with this location in February 2024. Within two months of this purchase, I experienced two flat tires in which both times I had to pay $87 and some change. Addtionally, within a year, two of the tires became bald, indicating premature wear. Tragically, this month, the bald tires contributed to a car accident, resulting in damages of my vehicle and loss of time from work. This incident has caused significant distress and has raised serious concerns about the quality of the tires and the services provided from this location. I have attempted to resolve this matter directly with the service center and cooperate office. To this day, no adequate response has been addressed to resolve my concerns. I'm glad to live to be able to tell my story and advocate for others!!! Tire Size 255/50R19`

ML350 engine stalled while driving on an expressway and would not turn back on. ML350 needed to be towed where it was determined that water accumulated in the spare tire wheel well, leading to the fuel pump short circuiting. This is directly related to NHTSA campaign 22V955000. That recall repair was completed prior to this incident. Per the technician, the recall repair installed a water drain plug to prevent the water accumulation. This repair effectively failed - the drain plugs malfunctioned and were not allowing water to drain. MBUSA deny’s responsibility for the failing drain plug - stating that the trunk weatherstripping is the root cause, not the failing drain plug. This is an unacceptable response and worth of the recall being expanded. The fuel pump control unit can still short out if MBUSA’s poor excuse of a recall fix fails as it did with mine.

See attached document for complaint

The contact owns a 2014 Mercedes-Benz ML350. The contact had received notification of NHTSA Campaign Number: 22V955000 (Fuel System, Diesel, Fuel System, Gasoline). The vehicle was taken to a dealer and the recall repair was performed. Soon after the recall repair, while the contact's wife was driving 25 MPH, the vehicle stalled. The contact was unaware if any warning lights had illuminated during the failure. The vehicle was towed to an independent mechanic where it was discovered that there was moisture in the spare tire wheel well. The moisture damaged the fuel pump control unit which was linked to the recall. The contact attempted to reach the manufacturer but was unsuccessful. The vehicle was taken back to the dealer but was not repaired and remained in dealer possession. The failure mileage was unknown.

I bought my vehicle into Mercedes Benz for a recall related to water collection in spare tire well which can cause a fuel pump control malfunction, NHTSA recall # 22V955. A few days ago, my vehicle could not start and I found water in my spare tire well. My OBD scanner tells me it is related to the fuel pump. I informed Mercedes Benz and they would not fix it. Obviously the work performed did not correct the recall. I'm writing here hoping I can get connected to the right channel to get this resolved as my vehicle is currently unusable. Thanks.

Blind spot assists and turn signals go out without warning. This model should have been included in the previous recall for timing. Having the same issues as other recalled cars.

The contact owns a 2014 Mercedes-Benz ML350. The contact stated while driving at various speeds, the vehicle hesitated while accelerating and sometimes sputtered before accelerating. The contact stated that there was water inside the spare tire wheel well. The vehicle was taken to the local dealer to be repaired under NHTSA Campaign Number: 22V955000 (Fuel System, Gasoline, Fuel System, Diesel). During the recall repair the water drainage plug was installed but the fuel pump was not replaced even though the vehicle had experienced the failure listed in the recall. The manufacturer was notified of the issue but no assistance was offered. The failure mileage was 185,000.

Traveling on my way home from Arizona and as my back was hurting turned on heated seats…I also had air conditioning running due to dogs in back seat…I started noticing what felt like a pinching sensation where my butt and legs meet…Stopped thr car at next rest area and noticed butt really hurt when I slid out of car…felt back there and area and hurt like heck..got into my Rv that a friend was driving and looked at it!! 2nd degree blisters/burns from heated seats!! I thought “what the heck?”as I didn’t have any marks on the seat!! Clearly the temperature spiked and causes the burns!’ I looked it up and see that MB has had a long history of this…and major litigation. But no recall!! I have pictures!! (But for obvious reasons can’t send here) I had a miserable ride home and the pain continues! It is embarrassing but I want to make sure other unsuspecting people don’t have this happen! Plus, I want it fixed…!