2007 Mercedes Benz ML320

Defect. Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2006-2012 ML, GL, and R-Class vehicles. Please refer to MBUSA's recall report for specific vehicle model details. Moisture may accumulate and cause corrosion in the brake booster housing unit, which can result in reduced brake performance or brake failure.

Risk. Reduced brake performance or brake failure can increase the risk of a crash.

Remedy. Owners are advised not to drive their vehicles until the remedy has been performed. Dealers will remove the rubber sleeve, inspect the brake booster, and as necessary, replace the brake booster. All repairs will be performed free of charge. Owner notification letters were mailed on May 24, 2024. Owners may contact MBUSA customer service at 1-800-367-6372. MMUSA's number for this recall is 2024050001/2. This recall is an expansion of previous recall number 22V-315.

Defect. Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2006-2012 ML-Class, GL-Class, and R-Class vehicles. Please refer to MBUSA's recall report for specific vehicle model details. Moisture may accumulate and cause corrosion in the brake booster housing unit, which can result in reduced brake performance or brake failure.

Risk. Reduced brake performance or brake failure can increase the risk of a crash.

Remedy. Owners are advised not to drive their vehicles until the remedy has been performed. Dealers will remove the rubber sleeve, inspect the brake booster, and as necessary, replace the brake booster. All repairs will be performed free of charge. Owner notification letters were mailed June 30, 2022. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's numbers for this recall are 2022050014, 2022050015 2022090006, & 2022090007.

My 2007 MB ML320 CDI has problem with water entering where spare tire located,after rain or when i use car wash.It builds inside so much water that module for for fuel pump stopped working,all wires were corroded,I paid for repairs from my pocket because MB dealership refused to fix my vehicle even they new MB ML/GL models have issue with water entering spare tire area.Now I find out they have recall with over323,000 ML/GL models.Recall number22v-955.I would like to file this complaint because dealership refuses to cover my previous repairs.Water still entering trunk area,and I have to constantly drain and vacuum trunk area.I hope you will have another recall or add older MB ML/GL to recent recall list.Thanks.

The vehicle would suddenly stop shifting or shift into neutral. This could happen at freeway speeds, where it would suddenly not have any power and just coast or it could be stuck in 4th at a stoplight and not be able to move.

Premature line corrosion on all of the steel hard lines. The brake lines are corroded and blistered and one of the lines are leaking fluid.

STS light on with message saying Right curtain airbag malfunction visit workshop

The contact owns a 2007 Mercedes-Benz ML320. The contact received notification of NHTSA Campaign Number: 22V315000 (Service Brakes, Hydraulics) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2007 Mercedes-Benz ML320. The contact was made aware of NHTSA Campaign Number: 22V315000 (Service Brake, Hydraulic) however, the part to do the recall repair was not yet available. The local dealers Mercedes-Benz of Seattle (2025 Airport Way S, Seattle, WA 98134:(206) 324-5959) and Mercedes-Benz of Lynnwood (17800 Hwy 99, Lynnwood, WA 98037:(425) 409-2574) were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

TL* THE CONTACT OWNS A 2007 MERCEDES-BENZ ML320. WHILE THE CONTACT WAS MERGING INTO HIGHWAY TRAFFIC, WHITE AND GRAY WAS SEEN UNDER THE HOOD OF THE VEHICLE. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND TURNED OFF THE ENGINE. PRIOR TO THE FAILURE, THE VEHICLE HESITATED WHILE DRIVING. THE CONTACT POINTED OUT THAT THE VEHICLE WAS EQUIPPED WITH A DIESEL ENGINE. THE VEHICLE WAS TOWED TO THE DEALER (MERCEDES-BENZ OF ANNAPOLIS, 324 6TH ST. ANNAPOLIS, MD 21403, (888) 261-7620) WHERE IT WAS DIAGNOSED WITH CATASTROPHIC ENGINE FAILURE. THE EXHAUST MANIFOLD RUPTURED, WHICH CAUSED THE ENGINE WIRING HARNESS TO MELT. THE DEALER INFORMED THE CONTACT THAT 'THE VEHICLE WAS DONE'. THE CONTACT'S INSURANCE COMPANY WAS NOTIFIED AND THE VEHICLE WAS AWAITING INSPECTION TO DETERMINE IF THE VEHICLE WAS A TOTAL LOSS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 224,000. *TT

SEAT BACK WARMER OVERHEATS/BURNS SMALL BURN - THE DRIVERS SIDE SEAT SEAT WARMER BURNED A WHOLE THROUGH THE MATERIAL AND THROUGH MY WIFE JACKET CAUSING A SMALL BURN ABOVE HER LEFT LEG. BASICALLY A THERMAL INCIDENT IN WHICH THE SEAT HAS A HOLE THE SIZE OF A QUARTER BURNED THROUGH THE SEAT COVER. WAS DRIVING HOME FROM WORK.

YEARS AGO, WHILE DRIVING THROUGH NEW MEXICO, MY DASH AND COMMAND CENTER FLASHED OFF AND REBOOTED. IT WAS A LITTLE CONCERNING BECAUSE WE WERE USING THE GPS EXCLUSIVELY FOR OUR DIRECTIONS. THERE WAS ALSO A TRANSMISSION WARNING LIGHT THAT CAME ON WARNING US TO GET TO THE NEAREST DEALER, WITHOUT SHIFTING GEARS. THIS HAPPENED PERHAPS 10-15 TIMES UNTIL I WAS ABLE TO DETOUR TO THE MB DEALER IN ALBUQUERQUE - ABSOLUTELY WONDERFUL PEOPLE. THEY TOLD ME THAT IT WOULD SOUND STRANGE BUT THE PROBLEM WAS CAUSED BY A FAULTY GLOW PLUG SENSOR OR MODULE - WHICH THEY DIDN'T HAVE IN STOCK. SINCE OUR DESTINATION WAS L.A., THEY CALLED AHEAD TO MB OF BEVERLY HILLS (BH), (ALSO WONDERFUL PEOPLE) TO CHECK IF THEY HAD ONE. THEY (MB OF BH) COULDN'T FIND ANY OTHER TROUBLE CODES EXCEPT A FEW POWER SPIKES SO THEY REPLACED THE ALTERNATOR, UNDER WARRANTY. THEY EVEN RUSHED IT DUE TO A FAMILY EMERGENCY BACK HOME. IT HAPPENED ON THE WAY BACK SEVERAL TIMES, THEN DIDN'T HAPPEN AGAIN UNTIL I DROVE TO COLORADO IN 2013. IT HAPPENED REPEATEDLY WHILE THERE. I CALLED THE MB DEALER IN DENVER WHO WAS SUPPOSED TO HAVE THE SERVICE DEPARTMENT CALL ME BACK - THEY NEVER DID. I WONDER IF IT HAS SOMETHING TO DO WITH A CHANGE IN ALTITUDE OR LOWER HUMIDITY (ELECTROSTATIC DISCHARGES)- PERHAPS EXTENDED DRIVING AS I DROVE 1,200 + MILES TO CO IN 20 HOURS STOPPING ONLY TWICE FOR FUEL AND ONCE FOR A HOTEL. ANY IDEAS FOLKS? *JS

TL* THE CONTACT OWNS A 2007 MERCEDES BENZ ML320. THE CONTACT WAS DRIVING 55 MPH WHEN THE CHECK ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE DEALER STATED THAT THE EMISSION CONTROL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THERE WAS NO DEFECT FOUND WITHIN THE VEHICLE. THE FAILURE AND CURRENT MILEAGE WAS 82,000.

TL* THE CONTACT OWNS A 2007 MERCEDES-BENZ ML320 CDI. THE CONTACT STATED THAT THE FUEL TANK FAILED. WHILE A SERVICE STATION ADDED FUEL TO THE VEHICLE, HE NOTICED THAT FUEL WAS LEAKING TO THE GROUND. THE VEHICLE WAS THEN TAKEN TO THE DEALER. THE DEALER INSPECTED THE FUEL TANK AND FOUND A CRACKED ON THE FUEL TANK. THE DEALER STATED THAT THE FUEL TANK WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 110,000.

I PURCHASED A USED 2007 MERCEDES ML320 CDI ON MARCH 12. AFTER A WEEK OF DRIVING - I INSPECTED THE ENGINE COMPARTMENT (I USUALLY DO). I NOTICED ENGINE OIL DRIPPING (SMALL BUT NOTICEABLE AMOUNT) ON THE SERPENTINE BELT. I DID NOT THINK IT WAS URGENT - SO I TOOK PICTURES SO I CAN SEND IT TO MY SELLER TO CLAIM WARRANTY. ON MARCH 23, I WAS DRIVING WITH MY FAMILY ON I-65. SUDDENLY, STEERING BECAME VERY HARD. IT WAS A CURVING HIGHWAY SO I WAS FORCED TO GO INTO OTHER LANES. LUCKY, TRAFFIC WAS NOT HEAVY SO I DID NOT SWERVE INTO ANY OTHER VEHICLE. I WAS ABLE TO WRESTLE WITH THE STEERING WHEEL ON TIME TO MOVE AWAY SAFELY. ALSO, AT THE SAME TIME WE LOST STEERING, THE BATTERY LIGHT WENT ON. AFTER STOPPING, WE POPPED THE HOOD AND IMMEDIATELY NOTICED THE SAME BELT MENTIONED EARLIER HAD DISINTEGRATED INTO SEVERAL PIECES. WE CALLED FOR A TOW VEHICLE. MERCEDES BENZ FIXED THE PROBLEM FOR $300 AND ASSURED ME THAT THERE IS NO OIL LEAK. 200 MILES LATER, I GOT HOME - AND SAW THE SAME LEAK, SAME SPOT. OIL WAS DRIPPING FROM THE TURBO TO INTERCOOLER HOSE JOINT (WHICH WAS JUST ABOVE THE SERPENTINE BELT). I DID SOME RESEARCH ON THE INTERNET AND THE ONLY SIMILAR ISSUE I FOUND LED TO DTB S-B-09.20/29. I ASKED MERCEDES, BUT THEY SAY ITS NOT COVERED UNDER WARRANTY. SO I AM CURRENTLY RESEARCHING TO FIX THIS PROBLEM PERMANENTLY. *TR

DRIVER HEATED SEAT BACK CUSHION BURNED A HOLE THROUGH THE SEATBACK AND DRIVER'S COAT CAUSING HER TO SWERVE OFF ROAD ... NO COLLISION. CAR HAS 23,000 MILES AND WAS ONLY DRIVEN A MILE BEFORE INCIDENT. *TR

DEAR NHTSA, MY '07 MERCEDES ML-320-CD WAS BOUGHT 'NEW'. THE DEFECT OF A RUN-AWAY, HI RPM REVVING-UP OF THIS DIESEL ENGINE WAS FIRST EXPERIENCED APPROX 21/2 MONTHS AGO. IT HAPPENED SHORTLY AFTER HAVING IT PARKED AT A LOCAL SHOPPING CTR FROM WHICH I DROVE IT ONTO THE MAIN STREET ATA MODERATE SPEED OF LESS THAN 20 MPH. SUDDENLY THE ENGINE REVVED UP TO MAYBE 5 OR 6 000 RPM CAUSING THIS SUV ACCELERATE BEYOND CONTROL. I HAD TO USE BOTH OF MY FEET ON THE BRAKE PEDAL BEFORE PULLING OVER ONTO THE CURB WHERE I TURNED OFF THE IGNITION . AFTER THAT, THIS SUV WOULD NOT RESTART AGAIN FOR A WHILE, LIKE 20 OR 30 MINS. SINCE MY RESIDENCE WAS ONLY ABOUT 2 MILES AWAY , AND AFTER RE-STARTING IT I CHANCED DRIVING IT HOME. I HAVE REPORTED THIS INCIDENT TO THE MERCEDES HQ AT MONTVALE NJ VIA THE BUILT-IN SATELLITE SYSTEM AND SUBSEQUENTLY TO THE LUBBOCK, TX MERCEDES SERVICE CTR WHILE BEING THERE. THEY FOUND NOTHING WRONG AND SENT ME ON MY MERRY WAY BACK TO MY RESIDENCE IN ROSWELL, NM, ABOUT 200 MILES AWAY. I KEPT DRIVING THIS VEHICLE VERY CAREFULLY , OF CURSE AND LO AND BEHOLD IT HAPPENED AGAIN ON 19 JUL '09 WHILE ON A TRIP TO PHOENIX VIA ALBUQUERQUE. WELL, I HAD A TRIP INTERRUPTION AND DELIVERED IT TO THE DEALERSHIP IN ABQ WHERE I BOUGHT IT FOR YET ANOTHER SERVICE CALL. THEY KEPT IT FOR 3WEEKS AND INFORMED ME THAT THE LEMON LAW DOES NOT APPLY AND A BUYBACK WAS NOT POSSIBLE. I AM PERSONALLY PETRIFIED USING IT TO THE EXTEND THAT I HAVE REFUSED DRIVING IT ANYMORE, I CAN NOT AFFORD HAVING AN ACCIDENT WI

ON 2/16/09 WHILE OUT DRIVING WE SMELLED AN ELECTRICAL BURNING ODOR INSIDE OUR 2007 ML320CDI JUST AS WE ARRIVED AT OUR DESTINATION. WE LOOKED AROUND THE VEHICLE AND UNDER THE HOOD TO TRY AND FIGURE OUT WHAT WAS BURNING AND FOUND NOTHING UNUSUAL. THE ODOR WAS GONE BY THE TIME WE GOT BACK IN THE VEHICLE. WE CONTINUED TO DRIVE THE VEHICLE WITH NO PROBLEMS AND NO ODORS UNTIL 2/21/09. ON THIS DAY WHILE RUNNING ERRANDS MY HUSBAND GOT OUT OF THE DRIVERS SEAT, CLOSED THE DOOR WHILE I REMAINED IN THE CAR AND I SAW THE DRIVERS SEAT BACK (NEAR THE DRIVER'S DOOR) START SMOKING. THE ELECTRIC HEATED SEATS WERE ON AT THE TIME. I IMMEDIATELY TURNED OFF THE HEAT TO THE SEATS AND THEN SHUT THE VEHICLE OFF. THERE WAS A BURN HOLE, ABOUT THE SIZE OF A NICKEL, IN THE SEAT CUSHION. ON MONDAY I CALLED OUR MERCEDES DEALERSHIP TO REPORT THE PROBLEM AND THEY TOLD ME TO BRING THE VEHICLE IN AS SOON AS POSSIBLE, BUT DO NOT USE THE HEATED SEATS UNTIL THEY CAN MAKE A REPAIR. WE TOOK THE VEHICLE TO THE DEALER ON 3/5/09. THE SERVICE ADVISOR TOLD US THEY HAVE SEEN SOME PROBLEMS LIKE THIS WITH THE SEAT BOTTOMS, BUT NOT THE SEAT BACK. WE WERE TOLD WE WOULD BE ABLE TO PICK UP THE REPAIRED VEHICLE ON 3/6/09. ON 3/6/09 WE WERE CALLED BY THE SERVICE ADVISOR AND TOLD THE SEAT BACK HAD TO BE ORDERED FROM GERMANY AND IT WILL TAKE AT LEAST 2 WEEKS FOR THEM TO RECEIVE IT. WE PICKED UP THE VEHICLE ON 3/6/09 AND ARE WAITING FOR THE PART TO COME IN. NO ONE WAS INJURED BY THE BURNING SEAT, BUT SOMEONE COULD HAVE BEEN BURNED.

TL*THE CONTACT OWNS A 2007 MERCEDES BENZ ML320. WHILE DRIVING 60 MPH, ALL OF THE INTERIOR AND INSTRUMENT PANEL LIGHTS ILLUMINATED AND THEN THE ENGINE STOPPED. THE STEERING DIMINISHED AND IT BECAME VERY DIFFICULT TO MANEUVER THE VEHICLE. THE CONTACT PULLED OFF THE ROAD AND THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER STATED THAT THE CRANK SHAFT SENSOR FAILED AND THEY REPLACED THE COMPONENT. THE CONTACT SPOKE WITH MERCEDES, BUT THEY WERE OF NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE 5,400. THE CONSUMER ALSO ADDED BRAKING WAS DIMINISHED AS WELL. UPDATED