2003 Mercedes Benz ML320

LOSS OF POWER STEERING FLUID, IT APPEARS TO BE FROM THE HOSE CONNECTION TO THE RADIATOR DURING DRIVING AND WHILE STATIONERY. THIS ISSUE WAS PREVIOUSLY RECALLED, I BELIEVE TWICE. DEALER REQUESTED $125 DIAGNOSTIC CHARGE. MB USA INFORMED IN A PHONE CONVERSATION, THAT THIS PROBLEM WAS ALREADY FIXED OCTOBER 2008 UNDER RECALL, AND THE WARRANTY EXPIRED AND I SHOULD FIX ON MY OWN COST.

MY WIFE DROVE THE VEHICLE TO WORK ONE DAY AND WHEN SHE WAS PULLING OUT OF THE PARKING LOT ONTO A BUSY STREET, THE YELLOW TRIANGLE WITH EXCLAMATION POINT STARTED TO FLASH AND ENGAGED THE BRAKES. MY WIFE QUICKLY PULL OVER TO THE SIDE OF THE STREET AND MADE HER WAY BACK INTO THE PARKING LOT WHILE THE BRAKES WHERE ENGAGING. MY WIFE WAS UNABLE TO DRIVE THE VEHICLE HOME FROM WORK. WE LET THE VEHICLE SIT FOR SEVERAL MINUTES AND I WAS ABLE TO GET THE VEHICLE MOVING BUT THE BRAKES WERE ENGAGING AGAIN. I WAS ABLE TO GET THE VEHICLE BACK HOME. I HAVE TAKING THE VEHICLE TO SEVERAL SHOPS AND ALL THE SHOPS ARE SAYING THAT THERE IS AN ISSUE WITH THE TRACTION CONTROL SYSTEM. WHEN DRIVING THE VEHICLE FROM ONE OF THE SHOPS, AS SOON AS I PULLED OUT OF THE SHOP'S PARKING LOT THE BRAKES ENGAGED AND THE YELLOW TRIANGLE WITH EXCLAMATION WAS FLASHING. IT DID THIS FOR ABOUT 15 SECONDS CAUSED THE APPROACHING VEHICLE FROM THE REAR TO SLAM ON THEIR BRAKES TO AVOID REAR ENDING ME. THE VEHICLE HAS BECOME UNSAFE TO DRIVE BECAUSE WE JUST DON'T KNOW IF WHEN IT DOES THIS. IT HAPPENS RANDOMLY USUALLY AFTER THE VEHICLE AS BEEN SITTING OFF FOR A SEVERAL HOURS.

TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ ML320. THE CONTACT STATED THAT THE VEHICLE ACCELERATED INDEPENDENTLY AND THE RPMS REVVED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER MULTIPLE TIMES, BUT THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

BAS LIGHT TURNS ON WHILE DRIVING ON THE FREEWAY AND THE CAR SHUTS OFF ON FREEWAY WHILE DRIVING. THE GAS PEDAL DIDN'T WORK SO I PULLED OVER. I FEEL LIKE ITS A DANGEROUS TO DRIVE AND PUTTING OTHER DRIVER IN DANGER SO I STOPPED DRIVING IT. THERE WAS A RECALL FOR 2000-2002 ML320 BUT MY CAR IS 2003 AND ITS DOING THE SAME ISSUES THAT THE 2000-2002 ML320

WHILE DRIVING, WENT OVER BUMP IN ROAD, AND TRUCK IMMEDIATELY LOST SPEED. PRESSURE ON GAS PEDAL WEAKEND. THERE WAS ABSOLUTELY NO ACCELERATION. I PULLED OVER AFTER ALMOST BEING HIT, AND TURNED VEHICLE OFF. RESTARTED AND PULL OVER INTO AUTOZONE TO HAVE THEM HOOK IT UP TO DIAGNOSTIC READER. IT CAME BACK WITH SEVERAL CODES, THAT ALL STATED "THROTTLE PEDAL POSITIONER MALFUNCTION" I HAVE BOUGHT AND REPLACED THIS ITEM 4 TIMES SINCE THIS INCIDENT, AND THE PROBLEM STILL EXISTS. I AM FORCED TO DRIVE THE VEHICLE BECAUSE I HAVE TO GET BACK AND FORTH TO WORK, BUT I'M ALWAYS VERY AFRAID THAT THIS PART IS GOING TO MALFUNCTION WHILE IN A BUSY INTERSECTION OR STREET, AND I ALONG WITH MY KIDS ARE GOING TO BE KILLED. IT HAPPENS AT LEAST TWO TO THREE TIME A WEEK, SOMETIMES MORE. *TR

TL* THE CONTACT OWNS A 2003 MERCEDES BENZ ML320. WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKES WERE ENGAGED NUMEROUS TIMES BEFORE THERE WAS A REDUCTION IN THE SPEED. THE CONTACT SMELLED AN UNUSUAL ODOR INSIDE OF THE VEHICLE. IN ADDITION, ON SEPARATE OCCASIONS A BURNING ODOR OF BRAKES EMITTED THROUGHOUT THE VEHICLE WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS UNABLE TO DETECT A PROBLEM. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

2003 ML 320 ROLLS BACK IN DRIVE. *TR

I HAD TAKEN MY MERCEDES ML320 IN FOR RECALL WORK #2003040005 AT MOTOR WORKS IN HOFFMAN ESTATES IL. FOR POWER STEERING PUMP RECALL AND THEY WANTED TO CHARGE ME APPROX. $6,000.00 FOR THIS SERVICE WHICH SHOULD BE FREE. I'VE TRIED TO CONTACT MERCEDES AND MOTOR WORKS WITH NO RESPONSE THE CLAMPS THAT CONNECT THE POWER STEERING HOSES COME OFF QUITE OFTEN RESULTING IN LOSS OF CONTROL, I GUESS I SHOULDN'T EXPECT MUCH FOR A $40,000.00 CAR!! *TR

I HAVE A 2003 MERCEDES ML 320 THAT HAS POWER STEERING FLUID PROBLEMS. THIS IS DUE TO A RECALL ISSUED BY MB FOR FAULTY HOSING, PIPING AND CONNECTIONS. I HAD LOSS OF STEERING CAPABILITY WHILE DRIVING WHICH LEAD ME TO STEER OFF THE ROAD DURING RAINY CONDITIONS. *TR

CAR MAKES A "WASHING MACHINE" TYPE NOSE WHEN THE STEERING WHEEL IS TURNED. MERCEDES DEALER EVALUATED AND FOUND THE STEERING GEAR BOX/RACK & PINION IS "WORN" AND SHOULD BE REPLACED. ALTHOUGH DEALER RECOMMENDED REPLACEMENT OF PART THEY DID ADD A LUBRICANT TO POWER STEERING FLUID TO "ELIMINATE" THE NOISE (WHICH IS STILL THERE PRESENTLY). WARRANTY COMPANY REFUSES TO REPLACE RACK & PINION BECAUSE THEY STATE PART IS STILL FUNCTIONING AS INTENDED. HOWEVER, IF PART COMPLETELY FAILS AND THE STEERING GOES OUT, I COULD BE INVOLVED IN AN ACCIDENT, POSSIBLY CAUSING DEATH OR INJURY. *TR

TL*THE CONTACT OWNS A 2003 MERCEDES BENZ ML320. THE CONTACT EXITED AN OFFRAMP AT 10 MPH AND THE VEHICLE CAME TO A COMPLETE STOP. WHEN SHE ATTEMPTED TO ACCELERATE, SHE LOST ALL POWER STEERING ABILITY. SHE WAS ABLE TO DRIVE HOME AND LATER HAD THE VEHICLE TOWED TO THE DEALER. THE DEALER STATED THAT THERE WAS A LEAK IN THE POWER STEERING UNIT AND ONE OF THE O-RINGS NEEDED TO BE REPLACED. THE VEHICLE IS CURRENTLY AT THE DEALER, BUT THE CONTACT FEELS THAT IT IS A MANUFACTURER DEFECT. THE CURRENT AND FAILURE MILEAGES WERE 62,000.

2003 MERCEDES BENZ ML320 DEFECTS WITH TRANSMISSION AND COMPUTER UNIT. CONSUMER STATES THAT THE VEHICLE HAS BROKEN DOWN TWICE BECAUSE OF THESE DEFECTS AND THINKS THIS VEHICLE SHOULD BE CONSIDERED A LEMON. *KB

THE HEATED SEAT IN MY 2003 MERCEDES ML320 BURNED THROUGH MY LEATHER SEATS AND LEAVING A SMALL MARK ON MY LEFT THIGH. MY INJURY HEALED; HOWEVER, THERE IS STILL A BURNT MARK ON MY SEAT. AFTER EXPLAINING IT TO MERCEDES AND MY EXTENDED WARRANTY SERVICE, BOTH DECIDED TO HELP ME STATING IT WAS A COSMETIC DEFECT. NOW I'M STUCK WITH A DRIVER SIDE SEAT THAT HAS 3 CM HOLE IN IT ALONG WITH HEATED SEATS THAT MERCEDES SUGGEST THAT I SHOULD NEVER TURN ON, EVEN THOUGH I PAID EXTRA FOR IT. *JB

I OWN A 2003 MERCEDES ML320, WHILE I WAS DRIVING W/THE HEATED SEATS ON I STARTED TO NOTICE A BURNING ODOR. THE ODOR GOT STRONGER & IT SMELT LIKE BURNING PLASTIC. I NOTICED MY REAR WAS STARTING TO GET A TAD TOO WARM SO I PUT MY HAND DOWN ON THE SEAT & ALMOST BURN MY HAND. I IMMEDIATELY TURNED OFF THE SEAT WARMER & CALLED MERCEDES THE FOLLOWING MORNING TO ARRANGE FOR SERVICE. WHEN I ARRIVED AT MERCEDES THE MANAGER INFORMED ME THAT THIS WAS NOT THE FIRST INCIDENT & THAT A GENTLEMENS SUIT HAD BEEN REPLACED B/C IT BURNT THROUGH HIS CLOTHING. I ASKED WHY MERCEDES HAD NOT PUT OUT A RECALL & HE INFORMED ME THAT IT WAS CHEAPER TO JUST REPLACE THE ONE'S WITH PROBLEMS. MY SEATS WHERE REPLACED FREE OF CHARGE & THE OLD ONE'S DISCARDED BY MERCEDES.

DRIVER'S SEAT HEATER SHORTED OUT WHILE VEHICLE WAS BEING DRIVEN. THE EVENT OCURRED SO QUICKLY AND WAS SO SEVERE THAT IT BURNED THROUGH THE LEATHER SEAT UPHOLSTERY AND A VERY HEAVY PAIR OF DENIM JEANS I WAS WEARING ALMOST IMEDIATELY AND UNEXPECTEDLY. THE CONSEQUENCES ARE PRETTY MUCH OBVIOUS AND COULD RANGE FROM SEVERE BURNS, TO THE VEHICLE BURNING TO CAUSING A SERIOUS ACCIDENT BECAUSE OF THE SPONTANEOUS HAPPENING. NO RESPONSE FROM MERCEDES BENZ TO DATE.*AK

WHILE DRIVING DRIVER'S HEATED SEAT CAUGHT ON FIRE. MANUFACTURER OFFERED TO REPLACE THE VEHICLE WITH A NEWER MODEL.*AK

AIR BAG LIGHT CAME ON INTERMITTENTLY. CONSUMER WAS INFORMED THAT WHEN THAT LIGHT WERE ON THE AIR BAG DID NOT WORK. THE SENSOR WASA REPLACED. HOWEVER, THE PROBLEM RECURRED.*AK

WHEN FILLING THE VEHICLE WITH FUEL, THE FUEL GAUGE DOES NOT GIVE A PROPER READING. MANUFACTURER SERVICED THE VEHICLE 6-7 TIMES, BUT COULDN'T FIND THE CAUSE OF THE PROBLEM. *AK

WHILE PARKING VEHICLE ACCELERATED. CONSUMER APPLIED THE BRAKE PEDAL BUT THE BRAKES FAILED. THIS CAUSED CONSUMER'S VEHICLE TO COLLIDE WITH THE VEHICLE IN FRONT. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE CAUSE HAD NOT BEEN DETERMINED. *AK

WHILE DRIVING THE VEHICLE HEATED SEATS CAUSED SECOND DEGREE BURNS TO THE DRIVER'S BOTTOM. THERE WAS NO DAMAGE TO THE VEHICLE'S SEAT. THIS PROBLEM ALSO CAUSE SOME REDNESS TO ANOTHER DRIVER'S BOTTOM. *NM AFTER VISITING DOCTOR FOR TREATMENT OF BURNS, TOOK VEHICLE TO DEALER THE SAME WEEK. WAS INFORMED BY THREE DIFFERENT MECHANIC'S PROBLEM COULD NOT BE FOUND OR RESOLVED. "PICTURES ENCLOSED" THE VEHICLE SEATS WERE HEATED.