2006 Lincoln Navigator

Defect. CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECTLY MANUFACTURED AUTOMATIC TRANSMISSION PARKING PAWL GUIDE PLATE.

Risk. THIS COULD CAUSE THE PARKING LOCK SYSTEM NOT TO ENGAGE, AFTER THE TRANSMISSION IS PLACED IN THE PARK ("P") POSITION. IF THE VEHICLE WAS PARKED ON AN INCLINE, AND THE PARKING BRAKE WAS NOT ENGAGED, THIS COULD RESULT IN A VEHICLE ROLLAWAY CONDITION.

Remedy. DEALERS WILL REPAIR AND REPLACE THE AUTOMATIC TRANSMISSION GUIDE PLATE. THE RECALL BEGAN ON NOVEMBER 18, 2005. OWNERS MAY CONTACT LINCOLN AT 1-800-248-0186.

Defect. ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.

Risk. AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.

Remedy. DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.

Defect. ON CERTAIN SPORT UTILITY VEHICLES, THE FRONT AND REAR TIRES ON THE DRIVER'S SIDE OF AFFECTED VEHICLES MAY HAVE BEEN DAMAGED AT THE CENTER TREAD DURING PRODUCTION.

Risk. OVER TIME, THE DAMAGE MAY BE SUFFICIENT TO ALLOW BELT CORROSION ULTIMATELY LEADING TO A TREAD SEPARATION, WHICH COULD RESULT IN A CRASH.

Remedy. DEALERS WILL INSPECT ALL FOUR TIRES (TO ENSURE INSPECTION OF THE LEFT HAND SIDE TIRES THAT MAY HAVE BEEN ROTATED TO THE OTHER SIDE OF THE VEHICLE) FOR TIRE TREAD DAMAGE AND, IF NECESSARY, REPLACE THE DAMAGED TIRE. THE RECALL BEGAN ON JULY 13, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Fuel gauge says zero miles to empty and will not take any gas more than a few gallons before kicking pump off. Gauge shows it's over heating but if you turn ignition off and turn right back on it resets and is fine. Codes come back saying nothing about fuel or cooling, but only something about speed control in the hub. Sounds like an electrical issue but no where to be found.

AIR BAGS SHOCKS. *TR

IT STARTS SHAKING THEN IT SAYS ENGINE FAIL SAFE MODE AND THEN TURNS OFF WHILE DRIVING

TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE STOPPED AT A STOP SIGN AND ATTEMPTING TO MOVE FORWARD, THE ACCELERATOR PEDAL WAS DEPRESSED HOWEVER, THE VEHICLE HESITATED. THE CHECK ENGINE WARNING LIGHT THEN ILLUMINATED. THE CONTACT ALSO STATED THAT WHILE ATTEMPTING TO PARK THE VEHICLE ON ANOTHER OCCASION THE VEHICLE STALLED. ADDITIONALLY, ON ANOTHER OCCASION WHILE DRIVING AT APPROXIMATELY 30 MPH, THE ACCELERATOR WAS DEPRESSED HOWEVER, THE VEHICLE FAILED TO RESPOND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE SPARK PLUGS AND CATALYTIC CONVERTER NEEDED TO BE REPLACED. (NORTH PARK LINCOLN LOCATED AT 9207 SAN PEDRO AVENUE, SAN ANTONIO, TX 78216) WAS CONTACTED AND INFORMED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,400.

THE SUSPENSION ON THIS SUV IS EXTREMELY DANGEROUS I HAVE REPLACED THE SUSPENSION AIRBAGS OH RINGS COMPRESSORS MULTIPLE TIMES AND EACH TIME IT TURNS COLD AND I LIVE IN ARIZONA THE CAR DROPS AND ON ABLE TO DRIVE IT DUE TO EXTREME VIOLENT SHAKING TO WEAR THE CAR SEEMS LIKE IT'S GOING TO ROLL OVER SOMETHING NEEDS TO BE DONE WITH THE SUSPENSION ON THIS VEHICLE LINCOLN NEEDS TO OWN UP TO THIS MISTAKE

TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. THE CONTACT STATED THAT IT WAS DIFFICULT TO START THE VEHICLE. AAA WAS CONTACTED FOR ASSISTANCE. WHILE ATTEMPTING TO JUMP START THE VEHICLE, THE TOW TRUCK OPERATOR NOTICED ELECTRICAL SPARKS IN THE REAR FUSE PANEL. THE BATTERY WAS DISCONNECTED AND THE CONTACT WAS INFORMED TO HAVE THE VEHICLE DIAGNOSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUSE PANEL NEEDED TO BE REPLACED BECAUSE THE WIRES WERE MELTED. THE FUSE BOX WAS REPLACED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

A NOTIFICATION APPEARED ON THE SCREEN TO CHECK SUSPENSION WHILE DRIVING ON THE FREEWAY AT LEAST 65 MILES PER HOUR.

TAKATA INFLATORS DO NOT WORK IN COLD WEATHER. BELOW A CERTAIN TEMPERATURE THE CAR BEGINS TO BOUNCE UNCONTROLLABLY. MAKES FOR A DANGEROUS SITUATION WHEN DRIVING AND THIS BEGINS TO OCURR.

TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. WHILE DRIVING VARIOUS SPEEDS, THE AIR SUSPENSIONS MALFUNCTIONED. THE CONTACT STATED THAT THE AIR SUSPENSIONS WERE LOWERED TO THE POINT WHERE THE CONTACT COULD NOT STEER THE VEHICLE OR MAKE SHARP TURNS. ALLEN VISUAL FORD IN MONROE, GEORGIA WAS MADE AWARE OF THE FAILURE AND REPLACED THE AIR SUSPENSIONS, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.

TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. WHILE DRIVING APPROXIMATELY 35 MPH AND ATTEMPTING TO CHANGE LANES, THE LEFT LANE SUDDENLY STOPPED AND THE CONTACT REAR ENDED THE PRECEDING VEHICLE. THE PASSENGER AIR BAG DEPLOYED, BUT THE DRIVER SIDE AIR BAG DID NOT DEPLOY. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE ANN COLLISION REPAIR CENTER WHO REPAIRED THE FRONT END, RADIATOR SUPPORT, AND THE HOOD OF THE VEHICLE. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 177,000.

TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. WHILE THE VEHICLE WAS STOPPED, THE CONTACT SMELLED BURNING RUBBER AND PLASTIC. THE CONTACT NOTICED SMOKE AND FLAMES EMERGING FROM BOTH THE FRONT DRIVER AND PASSENGER SIDES. THE FIRE DEPARTMENT WAS NOT CALLED AND THE CONTACT EXTINGUISHED THE FIRE. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO BAYWAY LINCOLN (12333 GULF FWY, HOUSTON, TX 77034) WHERE IT WAS DIAGNOSED THAT THE FUEL AND BRAKE LINES HAD OVERHEATED AND CAUGHT FIRE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.

IN COLD WEATHER THE CARS AIR SUSPENSIONS STOPS WORKING AND THE CAR STARTS BOUNCING ALL OVER THE PLACE WHILE DRIVING. THIS TO ME IS DANGEROUS ESPECIALLY ON WHEN OCCURRING ON LONG TRIPS. THIS IS A COMMON PROBLEM THAT I AM SEEING ALL OVER THE INTERNET.

TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. WHILE THE VEHICLE WAS STOPPED, THE AIR BAGS INADVERTENTLY DEPLOYED WITHOUT WARNING OR IMPACT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 91,000.

LINCOLN NAVIGATOR VEHICLES EQUIPPED WITH 5.4L ENGINES. THE FUEL RAIL CROSS-OVER HOSE MAY CONTAIN WEAK AREAS. AS A RESULT, THE HOSE MAY CRACK, WHICH COULD CAUSE A FUEL ODOR AND/OR FUEL LEAK

"CLOCK SPRING RECALL" MY AIR BAG EXPLODED WHEN I STARTED THE VEHICLE AND PUT IT IN DRIVE. VEHICLE FILLED WITH SMOKE, RECEIVED GASHES TO MY LEFT ARM AND WATCH WAS BLOWN OFF MY WIRST. HAD CAR TOWED TO FORD DEALER. THEY DETERMINED CRACK IN WIRE ON CLOCK SPRING CAUSED THE AIR BAG TO EXPLODE . FORD RECALLED F150'S AND LINCOLN MARK LT FOR THE CLOCK SPRING AND PAID FOR DAMAGES ON A LINCOLN NAVIGATOR THAT HAD THE AIR BAG EXPLODE JUST LIKE MY EXPERIENCE DUE TO THE CLOCK SPRING. REFER TO NHTSA ID 10569242. FORD MOTOR CO HAS DENIED ANY HELP FOR DAMAGES.

AIR SUSPENSION ON MY VEHICLE BEGINS TO BOUNCE IN COLD WEATHER. APPARENTLY THIS IS A COMMON ISSUE. IT IS DUE TO A FAULTY O-RING. I WAS ON A LONG DISTANCE TRIP AND RAN INTO COLD WEATHER AND THE CAR STARTED BOUNCING UNCONTROLLABLY. I FEEL THIS COULD BE VERY DANGEROUS IN CERTAIN CONDITIONS

SUSPENSION IS MAKING NOISES, AND THE RUNNING BOARD IS RUSTY AND BOLTS CAME OUT OR BROKE OFF, AND THERE IS A CRACK IN IT, HAD I NOT BEEN HOLDING ON WHEN I GOT OUT OF CAR I WOULD HAVE FALLING. I HAD IT CHECK AND THE OTHER SIDE IS RUSTY ALSO AND ABOUT TO COME OFF.

I WAS DRIVING AT ABOUT 40 MPH ON A TWO LANE ROAD AND MY NAVIGATOR JUST SHUT OFF. I LOOKED AT THE INSTRUMENTS AND IT SAID ENGINE FAIL SAFE MODE. I PULLED OVER AS BEST I COULD AND PLACED THE VEHICLE IN PARK AND TURNED IT BACK ON. LUCKILY I WAS ONLY ABOUT 3 MINUTES AWAY FROM HOME. I READ THE MANUAL AND IT MENTIONED COOLANT. I CHECKED THE COOLANT BUT IT IS COMPLETELY FULL. I'VE BEEN READING ABOUT THIS ISSUE AND IT SEEMS AS IF THERE'S A FLAW. I'VE READ ABOUT HOW PEOPLE TAKE THEIR CARS IN AND HAVE DIFFERENT DIAGNOSIS AND THE ISSUE DOES NOT GET FIXED. I WILL BE TAKING MY VEHICLE IN TO FORD BUT I'M WORRIED THAT I'M GOING TO BE CHARGED A LOT OF MONEY AND IT MAY NOT EVEN REPAIR THE ISSUE. THERE ARE MANY COMPLAINTS ABOUT THE ENGINE FAIL SAFE MODE WITH VEHICLES SHUTTING OFF ON THE HIGHWAY. I'M AFRAID TO DRIVE MY CAR EVEN AFTER I TAKE IT IN TO FORD. IF I'M ABLE TO I WILL UPLOAD MY BILL ONCE I SEE FORD.

WE HAVE HAD OUR NAVIGATOR IN MANY OF TIMES WE HAVE HAD ALL OF THE PARTS IN THE SUSPENSION CHANGED. WE HAVE ALSO PUT IN A NEW COMPRESSOR. DROVE JUST FINE IN THE SUMMER SPRING AND FALL. ONCE WE GOT OUR 1 ST COLD DAY WE HAVE NO SUSPENSION AGAIN. THIS IS MY ONLY CAR AND ITS A FAMILY CAR. TRACTION DOES NOT WORK WHEN THE SUSPENSION IS OUT. ON SLIPPERY ROADS TRUCK IS ALL OVER THE ROAD. THERE IS NOTHING THE DEALER CAN DO THEY HAVE DONE EVERYTHING THEY CAN AND IT STILL DOES NOT WOR . I AM AFRAID I WILL GO OFF THE ROAD WITH MY KIDS IN THE SUV. ALSO WITH NO SUSPENSION MY BACK IS NOW OUT JUST DRIVING IT TO THE STORE. SOMETHING NEEDS TO BE DONE OR LINCOLN SHOULD BUY ALL OF THEM BACK. WE HAVE LESS THEN 90,000 ON THE SUV. WHEN ASKED WHEN THIS HAPPENED IT HAPPENS EVERY DAY ITS COLD OUT.

TL* THE CONTACT OWNED A 2006 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE AT A COMPLETED STOP, ANOTHER VEHICLE CRASHED INTO THE REAR END OF THE VEHICLE. AS A RESULT, THE CONTACT CRASHED INTO THE VEHICLE THAT WAS AHEAD. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED MINOR INJURIES TO THE BACK AND LEGS THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 189,000. THE VIN WAS NOT AVAILABLE. UPDATED 04/07/16*LJ UPDATED 05/14/18*JB *CN

THE MOTOR RUNNING BOARDS, THE ALUMINUM PIECE THAT SUPPOSE TO HOLD THE RUNNING BOARDS TO THE VEHICLE, BROKE OFF WITHOUT ANY WARNING. HOW DOES THIS HAPPEN? I AM DRIVING, STOP AT THE LIGHT AND MAKE A LEFT TURN, AND ALL OF A SUDDEN I HEAR THESE SOUND LIKE MY RUNNING BOARD ARE SLIDING OUT. I PULL OVER AND THE ENTIRE RUNNING BOARD IS HANGING OUT COMPLETELY AWAY FOR THE VEHICLE. LUCKILY THERE WAS NO OTHER CARS BESIDE ME. I HAD TO PUSH IT BACK IN AND DROVE VERY SLOWLY SO IT WOULD NOT FALL BACK OUT AND HIT ANOTHER CAR. THIS IS DANGEROUS AND COULD HAVE CAUSE A SERIOUS CAR ACCIDENT. THE RUNNING BOARD NEEDS TO BE CHECKED ON ALL 2006 LINCOLN NAVIGATORS AS SOON AS POSSIBLE.

TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. WHILE DRIVING AT 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER SEVERAL ATTEMPTS. THE CONTACT STATED THAT THE ISSUE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ALTERNATOR FAILED. THE ALTERNATOR WAS REPLACED, BUT THE FAILURE PERSISTED. THE VEHICLE WAS BROUGHT TO THE DEALER A SECOND TIME AND THE ALTERNATOR WAS AGAIN REPLACED. THE CONTACT STATED THE ISSUE STILL PERSISTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT THE VEHICLE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 48,000.

TL*THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. THE CONTACT STATED THAT A PASSENGER STEPPED ON THE BRACKET TO ENTER THE VEHICLE AND IT FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT PASSENGER'S SIDE BRACKET NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 145,000.

TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE FAIL SAFE MODE WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. ALSO, THE STEERING WHEEL SEIZED AND THE BRAKES FAILED. THE VEHICLE RESTARTED IMMEDIATELY. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.

2006 LINCOLN NAVIGATOR, WITH JUST OVER 100,000 MILES ON VEHICLE. VEHICLE SHUT DOWN IMMEDIATELY AFTER GIVING AN ENGINE FAILED SAFETY MODE ERROR ON DASH. FORTUNATELY MY WIFE WAS DRIVING IN THE NEIGHBORHOOD AND DOING 25 MPH. MUSCLED IT OVER TO THE SIDE OF THE ROAD AND RESTARTED THE VEHICLE. THIS IS ABOUT THE 4TH TIME THIS HAS HAPPENED IN THE 5 YEARS WE HAVE OWNED THE VEHICLE. THE OTHER TIMES THE VEHICLE WAS BEING DRIVEN AROUND 45 MPH ON 4 LANE HIGHWAYS/ROADS. WE HAD A 2003 EXPEDITION THAT HAD THE SAME PROBLEM. FORD MOTOR COMPANY DEFINITELY HAS A DESIGN ISSUE THAT IMPACTS SAFETY AND THEY DO NOT WANT IT KNOWN. *TR

WAS DRIVING ON THE HIGHWAY AND THE VEHICLE WENT INTO ENGINE FAILSAFE MODE. WAS ABLE 2 PULL OVER AND TURN ENGINE OFF AND RESTART WITH NO PROB. THIS HAS HAPPENED AT LEAST 10 MORE TIMES SINCE ALWAYS ON ACCELERATION LUCKILY I WAS NOT IN ACCIDENTS. MOST OF THE SHUT OFFS HAVE BEEN IN HIGHWAY DRIVING CONDITIONS AT SPEEDS OVER 55 MPH. AFTER RESEARCH SEEMS THIS IS HARD 2 DIAGNOSE BUT FORD IS AWARE OF THIS ISSUE. SEEMS AS THOUGH IT'S USUALLY THE THROTTLE BODY BUT CAN ALSO BE THE FUEL MODULATOR. OTHER PEOPLE HAVE BEEN IN ACCIDENTS I'M JUST LUCKY I HAVEN'T. *TR

2006 LINCOLN NAVIGATOR WAS PARKED. ENTERED VEHICLE AND INSERTED KEY IN IGNITION. I CRANKED THE VEHICLE, SAT BACK TO HAVE THE CAR WARM UP. ABOUT 5 SECONDS AFTER CRANKING THE VEHICLE, AIR BAG INADVERTENTLY DEPLOYED WITHOUT INCIDENT. CAR WAS FILLED WITH WHITE SMOKE. CONTACTED LOCAL FORD/LINCOLN DEALERSHIP AND WAS TOLD THEY HAD NEVER HEARD OF A VEHICLE AIRBAG DEPLOYING WITHOUT INCIDENT. CONTACTED FORD/LINCOLN CORPORATE OFFICE AND THEY OFFERED TO PAY FOR THE DIAGNOSTIC AT LOCAL FORD/LINCOLN DEALERSHIP. DIAGNOSTIC REVEALED NO ACCIDENT DATA, AND A DEFECTIVE CLOCKSPRING MECHANISM IN THE STEERING WHEEL....SAME PROBLEM AS PREVIOUS RECALLS IN 2006 FORD F150 AND LINCOLN MARK LT, WHICH OBVIOUSLY SHARE PARTS WITH MY VEHICLE. FORD/LINCOLN OFFERED TO PAY FOR THE REPAIRS, LESS A $200 DEDUCTIBLE BECAUSE, AS THEY STATED MY VEHICLE WAS NOT COVERED UNDER THE RECALL EVEN THOUGH IT'S THE SAME PROBLEM THAT OTHER VEHICLES WERE RECALLED FOR. *TR

TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE AND VIN WAS NOT AVAILABLE.

SUSPENSION GOES OUT FREQUENTLY FOR OVER 2 YEARS AND EVERYTHING HAS BEEN CHECKED OUT AND FORD SAYS NOTHING IS WRONG AFTER EACH REPAIR. I DON'T UNDERSTAND THE RULES TO GETTING A VEHICLE REPLACED BUT MY CONCERNS ARE ABOVE AND BEYOND THE RULES AND SHOULD BE CONSIDERED FOR OUR SAFETY AND WELL BEING. WE HAVE BEEN IN THE SHOP AT LEAST 7-10 TIMES DURING THIS TIME. ALL GOES BACK TO SAME ISSUE - SUSPENSION IN JUNE OF 2009 WE PURCHASED A 2006 LINCOLN NAVIGATOR FOR NEARLY $30,000, WITH THE UNDERSTANDING THAT IF WE TOOK REASONABLE CARE OF THE CARE THAT THIS WOULD BE A DEPENDABLE,RELIABLE VEHICLE FOR OUR FAMILY OF 5. SINCE EARLY 2010 WE HAVE HAD NOTHING BUT ONGOING PROBLEMS WITH THE SUSPENSION SYSTEM IN THIS CAR. WE HAVE GONE NEARLY TWO MONTHS AND $4,000 IN CAR BILLS DURING THIS TIME DRIVING OTHER CARS FROM DEALERS WHILE THEY HAVE BEEN WORKING ON OUR VEHICLE. STARTED WITH BUYING A NEW CONTROL MODULE, THEN RIDE HEIGHT SENSORS, AND ON TO THE LATEST BUYING A NEW AIR COMPRESSOR. CAR BROKE DOWN ON VACATION AND THEY SAID CONTROL MODULE (WHICH WAS JUST REPLACED) AND NEEDED TO ORDER IT SO WE WOULD HAVE BEEN STRANDED IN FLORIDA FOR NEARLY A WEEK AND THIS WOULD HAVE BEEN THE 3RD NEW CONTROL MODULE PUT INTO OUR CAR. SO FORD PUMPED US UP WITH AIR AND PUT SOMETHING IN CAR FOR NEARLY $700 AND ENSURED US THAT WILL GET US BACK TO MICHIGAN SAFELY UNTIL WE COULD GET THE NEW MODULE. MADE IT 2 HOURS INTO OUR TRIP AND THE SUSPENSION DROPPED OUT ON US AGAIN. BEEN NEARLY 2 YEARS WITH THE SAME ISSUE. OUR CAR HAS

TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THE ENGINE FAIL SAFE MODE WARNING LIGHT ILLUMINATED AS THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED AND BEGAN TO FUNCTION NORMALLY. THE VEHICLE WAS NOT TAKEN TO A MECHANIC AND WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.

DURING NORMAL DRIVING CONDITIONS, THE CAR GAVE IN RAPID SUCCESSION A NUMBER OF WARNINGS AND THE CAR BEGAN TO RUN ROUGH AND SHIFT ERRATICALLY. ONE RELATED TO THE STABILITY CONTROL SYSTEM AND THE OTHER WAS A "ETC ENGINE FAILSAFE MODE". AFTER RESTARTING THE CAR THE STABILITY CONTROL ERROR PERSISTED. THE DEALER REPLACED SENSOR ASSEMBLY 6L2Z*3C187*AA FOR ~ $1000 FOR THE PART AND LABOR + THE BATTERY AND INDICATED NO OTHER CODES WERE STORED RELATING TO THE FAIL SAFE WARNING. THE FAIL SAFE WARNING RETURNED A FEW WEEKS LATER AND THE DEALER WAS UNABLE TO REPLICATE OR CAPTURE ANY CODES OVER A 2 DAY PERIOD. *TR

DROVE THE VEHICLE OFF ROAD, HIT A SEVERE POTHOLE, AIR RIDE SUSPENSION HAS CONSTANTLY FAILED AND FORD HAS NEVER REPAIRED IT. *TR

ENGINE WAS MISSING WHEN TRYING TO ACCELERATE OR PASS VEHICLES. DANGEROUS SITUATION WHEN TRYING TO PASS ON HIGHWAYS AND INTERSTATES. TOOK 2006 LINCOLN NAVIGATOR IN FOR NEW SPARK PLUGS. DEALER SAID ALL 8 PLUGS BROKE OFF AND ONE DAMAGED THE HEAD AND NOW NEED NEW HEAD DUE TO BROKEN SPARK PLUG. COST WILL EXCEED $3,000. SPOKE WITH 6 LOCAL MECHANICS AND ALL AGREED THIS IS A BIG PROBLEM. WHY SHOULD I PAY FOR FORD'S FAULTY DESIGN? *TR

2006 LINCOLN NAVIGATOR, 60,000 MILES ON CAR. CAR SHUT DOWN AFTER GIVING AN ENGINE FAILED SAFETY MODE ERROR ON DASH WHILE ON FOUR LANE BUSY HIGHWAY TRAVELING 40-45 MPH. COASTED TO SIDE OF ROAD (NO BERM AVAILABLE). .. WAITED 5 MINUTES. RESTARTED CAR AND LIMPED INTO GARY YEOMAN FORD DEALER. I WAS TOLD THE THROTTLE CONTROL BODY & MOTOR ASY #3L3Z*9E926*A WAS BAD AND WAS NOT COVERED UNDER THE EXTENDED WARRANTY I PURCHASED ON THE CAR IN 2009. REPAIR BILL WAS $900 OUT OF POCKET. CHECKED ONLINE AND THIS IS A KNOWN ISSUE FOR FORD EXPEDITIONS & LINCOLN NAVIGATOR ENGINES AND YET FORD DOES NOTHING TO FIX. DOES SOMEONE HAVE TO DIE TO GET FORD TO REPAIR THESE DEFECTIVE PARTS? NOTHING MORE DANGEROUS THAN A CAR THAT SHUTS DOWN IN HEAVY TRAFFIC TRAVELING AT HIGH SPEEDS. *TR

TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT APPLIED PRESSURE TO THE ACCELERATOR PEDAL AND THE VEHICLE EXHIBITED AN ABNORMAL CRANKING NOISE FROM THE FRONT END. THE CONTACT STATED THAT THE FAILURE WOULD ALSO OCCUR WHEN APPLYING THE BRAKES AND WHEN DRIVING AT LOW SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 36,000.

ENGINE SHUT DOWN AT 45 MILES AN HOUR. FAIL-SAFE LIGHT ILLUMINATED FOLLOWED BY A LOSS OF POWER STEERING. COASTED CAR TO THE SIDE OF ROAD AND TURNED KEY TO OFF POSITION. THE ENGINE IMMEDIATELY RESTARTED WITH NO OTHER PROBLEMS. THIS CAR HAS 79,000 MILES ON IT AND I HAVE OWNED IT SINCE NEW. THIS HAS NOT HAPPENED SINCE THE CAR WAS NEW. THE DEALER TOOK THE PROBLEM SERIOUSLY, BUT CAN NEVER FIND A PROBLEM. IT SEEMS TO BE A COMPUTER PROBLEM WITH THE FAIL-SAFE MODE. *TR

TL*THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 40-45 MPH WHEN THE SAFE ENGINE MODE WARNING LIGHT ILLUMINATED AND THEN THE VEHICLE IMMEDIATELY STALLED. THE ENGINE RESTARTED AND RESUMED OPERATION. THE VEHICLE WAS TAKEN TO THE DEALER FIVE TIMES REGARDING THE SIMILAR FAILURE. THE TECHNICIAN REPROGRAMMED THE COMPUTERIZED SYSTEM SOFTWARE AND THE FUEL PUMP WAS REPLACED AT A DIFFERENT TIME. THE FAILURE PERSISTED AFTER THE REPAIRS. ALSO, MOST RECENT THE TEMPERATURE WARNING INDICATOR ILLUMINATED DURING THE ENGINE MALFUNCTION. THE VEHICLE WAS CURRENTLY AT THE DEALER FOR DIAGNOSTIC TESTING AND A TROUBLE CODE WAS NOT DETECTED. THE DEALER WAS UNABLE TO LOCATE THE PROBLEM. THE MANUFACTURER HAD BEEN NOTIFIED IN WHICH THERE WERE NO RESOLUTIONS. THE FAILURE MILEAGE WAS UNKNOWN.

I AM HAVING CONTINUOUS PROBLEMS WITH MY 2006 LINCOLN NAVIGATOR. FOR A VEHICLE OF THIS QUALITY, I NEVER DREAM OF SO MANY PROBLEM. I HAD MY SUSPENSION SYSTEM FIX LAST YEAR AT THE DEALER. 1 YEAR HAS PASS NOW IT IS GONE OUT AGAIN. I HAD MY CATALYST CONVERTER FIX AT THE DEALER ABOUT 2 YEARS AGO. 1 YEAR LATER THEY ARE GONE OUT AGAIN. NOW I AM RIDING AROUND WITH A BOUNCING NAVIGATOR AND A SLUGGIST RUNNING NAVIGATOR WITH PLENTY OF FUMES. I JUST DON'T HAVE THE FUNDS FOR CONTINUOUS REPAIRS FOR THE SAME SERVICE. DO THE MECHANICS KNOW WHAT THEY ARE DOING? I AM REALLY FRUSTRATED WITH THIS VEHICLE AND THE SERVICE I HAVE RECEIVED. BOUNCING AROUND IN A 40,000 + VEHICLE IS EMBARRASSING. PLEASE HELP. I HAVE TO BUM A RIDE AT TIME. I HAVE TO TRAVEL , A LOT AND RENT A CAR. THIS IS GETTING OLD AND EXPENSIVE. THE DEALER WANT FIX IT BECAUSE THEY SAY IT IS OUT OF WARRANTY, EVENTHOUGH I HAVE PAID TO HAVE IT FIXED BEFORE. THIS IS NOT COSTUMER SERVICE. HELP! *TR

2006 NAVIGATOR WOULD KEEP MISFIRING EVEN AFTER COILS WERE REPLACED. DEALER FIRST REPORTS IT WAS A VALVE. AFTER INSPECTION VALVE WAS NOT THE PROBLEM BUT A BURNT HEAD WAS THE CAUSE. HEAD WENT TO OUTSIDE SHOP FOR REPAIR BUT THE SHOP SAYS NOW THAT THE PROBLEM MIGHT BE LOWER IN THE ENGINE. A NEW ENGINE IS BEING SUGGESTED BY THE DEALER BUT THE WARRANTY COMPANY MAY NOT PAY. CAR HAS 44000 MILES CURRENTLY. *TR

2006 LINCOLN NAVIGATOR. FAIL SAFE MODE COMES ON WHILE DRIVING AND SHUTS VEHICLE DOWN. THIS HAS HAPPENED TWICE AND ALSO EXACT SAME INCIDENT TO FRIEND IN DIFFERENT STATE WITH SAME 2006 NAVIGATOR. DECIDED TO REPORT AFTER I CALLED LINCOLN AND THEY HAD RECORD OF MY CALL IN DECEMBER 2009 AND JANUARY 2010 BUT NO RECORD OF THE WORK PERFORMED TO CORRECT THE PROBLEM OR THE DANGEROUS INCIDENT. IT HAPPENED AGAIN SEPTEMBER 23, 2010 AFTER IT WAS SUPPOSED TO HAVE BEEN FIXED BY CHANGING A SENSOR. THIS IS EXTREMELY DANGEROUS!! CAR SHUTS DOWN AND MY WIFE WAS ALMOST REAR ENDED AT HIGHWAY SPEEDS. ON GOOGLE SEARCH OF "LINCOLN NAVIGATOR FAIL SAFE MODE PROBLEMS" THERE ARE 1380 RESULTS. GOES TO OVER 2500 WHEN 2006 IS REMOVED. DURING FIRST "FIX" FORD DEALERSHIP REPLACED A SENSOR BUT THE DETAILS ARE NOT DOCUMENTED IN MY FILE ON THE FORD/LINCOLN COMPUTER SYSTEM. THIS COULD BE HOW FORD/LINCOLN IS AVOIDING A MAJOR RECALL FOR A EXTRAORDINARILY DANGEROUS PROBLEM. *TR

2006 LINCOLN NAVIGATOR WITH POWER DEPLOYING RUNNING BOARDS. BOTH SIDES HAVE FAILED DUE TO THE STRUCTURAL SUPPORT POST CORRODING TO THE POINT OF MECHANICAL FAILURE. WHEN THIS FAILS A PASSENGER STEPPING ON IT CAN BE HURT DUE TO A FALL SO IT IS A SAFETY ISSUE. AGAIN THIS IS A STRUCTURAL FRAME MEMBER THAT IS FAILING CATASTROPHICALLY DUE TO CORROSION. *TR

SPARK PLUG IN 2006 LINCOLN NAVIGATOR POPPED OUT! SERVICED BY FORD/LINCOLN/MERCURY AND SAID NOTHING WAS WRONG WITH IGNITION SYSTEM. SPARK PLUG REPLACED AND CARS IS BARELY DRIVABLE. IT OFTEN STALLS AT IDLE RPM. *TR

2006 LINCOLN NAVIGATOR, 50,000 MILES ON CAR. CAR SHUT DOWN AFTER GIVING AN ENGINE SAFETY MODE ERROR ON DASH WHILE ON FOUR LANE BUSY HIGHWAY TRAVELING 40-45 MPH. COASTED TO SIDE OF ROAD (NO BERM AVAILABLE). CARS RACING BY. WAITED 5 MINUTES. RESTARTED CAR AND LIMPED INTO TEAM FORD OF MARIETTA GEORGIA DEALER. I WAS TOLD THE THROTTLE CONTROL BODY & MOTOR ASY #8L3Z*9E926*A WAS BAD AND WAS NOT COVERED UNDER THE $1,000 EXTENDED WARRANTY I PURCHASED ON THE CAR IN 2006. REPAIR BILL WAS $800 OUT OF POCKET. CHECKED ONLINE AND THIS IS A KNOWN ISSUE FOR FORD EXPEDITIONS & LINCOLN NAVIGATOR ENGINES AND YET FORD DOES NOTHING TO FIX. DOES SOMEONE HAVE TO DIE TO GET FORD TO REPAIR THESE DEFECTIVE PARTS? NOTHING MORE DANGEROUS THAN A CAR THAT SHUTS DOWN IN HEAVY TRAFFIC TRAVELING AT HIGH SPEEDS. *TR

WHENEVER THE CAR IS WASHED OR IF IT SNOWS OR RAINS THE CAR EXPERIENCES SPONTANEOUS ELECTRICAL ACTIVITY WHEN NO KEY OR PERSON IS PRESENT USING ANY ASPECT OF THE VEHICLE. FOR EXAMPLE, AFTER WASHING THE CAR, THE VEHICLE WILL DRIVE PERFECTLY FINE, BUT UPON BEING PARKED, SOMETIMES HOURS AFTER BEING PARKED, THE VEHICLE WILL THEN BE OBSERVED TRIGGERING POWER SEATS, AIRBAG WARNING LIGHTS, AND CLICKING SOUNDS CAN BE HEARD. THE VEHICLE HAS HAD A POWER WINDOW MOTOR BURN OUT AND A WIRING HARNESS RELATED TO THE POWER SEATS CORRODE AND FAIL COSTING OVER $700 IN REPAIRS. WE BELIEVE THE REASON FOR THESE PROBLEMS IS DUE TO THE WINDSHIELD LEAKING ON TO SOME KIND OF ELECTRONIC CONTROL DEVICE SUCH AS THE GEM MODULE AND THEN CAUSING THE DEVICE TO SHORT CIRCUIT AND TRIGGER VARIOUS ELECTRONIC LIGHTS/SWITCHES. MORE RECENTLY, THE VEHICLE WAS LEFT OUTSIDE FOR TWO WEEKS WITH NO USE AND SEVERAL FEET OF SNOW FELL ALONG WITH SOME RAIN AND THE VEHICLE'S BATTERY IS NOW COMPLETELY DISCHARGED DUE TO THE ELECTRONIC PROBLEMS/MOISTURE LEAKAGE. *TR

TL*THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE VEHICLE SUDDENLY STALLED AND CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP FOR A DIAGNOSTIC TEST BUT THE DEALER COULD FIND NO PROBLEMS. ANOTHER DEALER INFORMED THE CONTACT THAT THE POWER STEERING, TRANSMISSION AND ENGINE NEEDED TO BE REPAIRED AS THE STEERING ALSO MALFUNCTIONED. THE FAILURE MILEAGE WAS APPROXIMATELY 12,000. THE CURRENT MILEAGE WAS APPROXIMATELY 42,000.

TL*THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. DURING ROUTINE MAINTENANCE AND A TUNE-UP, HE RECEIVED A CALL FROM THE MECHANIC STATING THAT THEY BROKE PART OF THE SPARK PLUG INTO THE ENGINE CYLINDER WHILE TRYING TO CHANGE THEM. THE DEALER WOULD NOT ASSUME LIABILITY FOR THE REPAIR. THE NECESSARY REPAIRS WERE PERFORMED ON THE VEHICLE AT THE OWNER'S EXPENSE. ON A SEPARATE OCCASION, WHILE DRIVING AT SPEEDS OF LESS THAN 35 MPH THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY FOUND THE FUEL PUMP COMPUTER MODULE FAILED. THE VEHICLE WAS REPAIRED AT THE OWNER'S EXPENSE. THE FAILURE MILEAGE WAS 96,000 AND THE CURRENT MILEAGE WAS 100,000. UPDATED 11/22/10 *BF UPDATED 11/23/10

THE LINCOLN DEALERSHIP BROKE 5 OF MY 8 SPARK PLUGS WHILE TRYING TO CHANGE THEM. I WAS TOLD THAT I HAVE TO PAY SINCE THIS HAS HAPPENED. THIS IS A KNOWN PROBLEM WITH FORD ENGINES. PLEASE REFERENCE THE FOLLOWING LINK. HTTP://WWW.FORDPROBLEMS.COM/SPARK-PLUG-EJECTED-FROM-ENGINE.SHTML. *TR

TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. WHILE DRIVING APPROXIMATELY 65 MPH THE "ENGINE FAIL SAFE MODE" WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. HE APPLIED PRESSURE ON THE ACCELERATOR PEDAL, AND RECEIVED LOW VEHICLE POWER. HE PULLED TO THE SIDE OF THE ROAD AND RESTARTED THE ENGINE TO RESUME NORMAL VEHICLE OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE FAILURE WAS CONTRIBUTED TO THE ENGINE THROTTLE SWITCH. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS 57,000. THE CURRENT MILEAGE WAS 61,000. THE VIN WAS UNAVAILABLE.

THE REAR DRIVER SIDE TIRE VALVE CORE WAS COMING OUT (ALMOST COMPLETELY). IT WAS STICKING OUT SO FAR THAT I WAS UNABLE TO SCREW TIRE VALVE CAP ON COMPLETELY. BY SCREWING THE VALVE CAP TIGHTLY WOULD ACTUALLY CAUSE THE VALVE CORE TO BE PUSHED IN WHICH WOULD ALLOW THE AIR TO ESCAPE FROM THE TIRE. I HAVE BEEN TOLD THAT THIS IS A COMMON PROBLEM WITH THE TIRE VALVES WHICH HAVE THE TIRE PRESSURE SENSOR ATTACHED TO THEM. *TR

TL*THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. ON JULY 17, 2009, WHILE DRIVING APPROXIMATELY 23 MPH, THE CONTACT FELT THE STEERING PULL TO THE RIGHT. SHE ATTEMPTED TO KEEP IT CENTERED AND THEN HEARD A LOUD NOISE. THE FRONT PASSENGER SIDE OF THE VEHICLE INSTANTLY COLLAPSED AND SHE CRASHED INTO A PARKED VEHICLE. THE CONTACT STATED THAT THE WHEEL WAS BROKEN IN THE CENTER AND THE TIRE WAS DETACHED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW YARD AND THE INSURANCE COMPANY WILL CONDUCT AN INVESTIGATION. THE CONTACT INJURED HER RIGHT KNEE. THE CURRENT AND FAILURE MILEAGES WERE 80,000.