2021 Kia Sorento Hybrid

Defect. Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Risk. A fire while parked or driving can increase the risk of injury.

Remedy. Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.

Defect. Kia Motors America (Kia) is recalling certain 2021-2022 Sorento Hybrid and 2022 Sorento Plug-in Hybrid vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioner(s) may explode upon deployment.

Risk. An exploding seat belt pretensioner can project metal fragments into the vehicle, striking vehicle occupants and resulting in injury.

Remedy. Dealers will secure the seat belt pretensioners with a cap, free of charge. Owner notification letters were mailed August 17, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC241. This recall expands and replaces NHTSA recall number 22V-127. Vehicles already repaired under the previous recall will need to have the new remedy completed.

Recall SA512 was previously completed on my vehicle. The problem is happening again. Since there are no open recalls, I am unable to get it fixed under the recall.

On [XXX] we were driving the Kia at slow speed due to snow on the road when a warning light came on which we think said hybrid vehicle failure pull over. The car stopped and the traffic lane with the engine off. The car would not start and we were exposed to traffic. Fortunately, we were on a country road at the time about a mile from our house and we were not struck by following vehicle when the car shut off and stopped in the traffic lane. If we had been on a beltway with 60 or 65 mph traffic obviously the result would’ve been quite different. Because I felt the vehicle was not safe to drive. I had it towed to the Kia dealer in Salisbury Pocahontas Kia, who have not been able to duplicate the problem and have also not been able to tell us what was wrong with the Kia to cause this problem in the first place. Unless there is a clear reason why this happened And it can be fixed then we have no reason to believe this would not happen again and endanger our safety. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

There is a malfunction in the vehicles.computer system that gives a warning about low coolant level for the hybrid battery. It's been been seen by the KIA dealer and the issue keeps arriving.

For a few days ( especially if is a HOT day (over 80F) ) my 2021 Kia Sorento Hybrid with 15,421 miles on it displays a "Refill Inverter Coolant" message. I checked the coolant level and is OK. After my research, it seems that the factory put the wrong Blue inverter coolant instead Red (all other KIA hybrid cars have Red coolant) . I found out that there is a KIA Technical Service Bulletin SA515 that addresses this issue. Called a few dealers in GA and I have been told that they need the cars for 7-10 days for investigation. Why???? when there is a Service Bulletin.. On top of this, I have been told that I need to rent a car at my expense and fight with KIA Corp to be reimbursed. This is Outrageous!!!!!! Other dealers do not have the required Vaccum Pump to flush the system or they can schedule me after 25 days. A safety Recall shall be issued and put pressure on KIA to address this issues before a catastrophic inverter fault occurs

My Kia Sorento will shift from drive to first or second gear’s several times. I’ve been told by the dealership that I’m probably touching the shifter accidentally, I disagree. My opinion is that this is a safety concern because it slows the vehicle down. My vehicle also at times does not accelerate. These two issues are intermittent.

UNKNOWN. The “Replace Inverter Coolant” warning message repeatedly comes on for unknown reasons and may be quickly reset to the “Ready to Drive” status by turning the vehicle off, opening the driver side door, putting my foot on the break pedal, turning the vehicle back on and closing the door before the system readiness cycle is completed. While this is not perhaps an injury issue to anyone, it is a nuisance issue which KIA apparently refuses to issue a recall to fix. The reliability of the Inverter Coolant monitoring system is important to the driving public of KIA vehicles and a system that is unreliable should not be tolerated. This issue is also known to exist on numerous other KIA manufactured and marketed models.

Intermittent message on dash "Refill inverter coolant" Been to dealer 6x and no fix. Reported to KIA corporate to work with dealer Have been without this car several days

The contact owns a 2021 Kia Sorento Hybrid. The contact received notification of NHTSA Campaign Number: 22V703000 (Trailer Hitches); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

My Kia 2021 Hybrid EX has a message warning to "refill inverter coolant". Took it to dealer and they said it's a software issue, but no remedy is available.

I have 2021 Kia Sorento Hybrid, which a regular message stating that it needs to refill inverter coolant fluid keeps coming up, even though the car coolants level is full. This is not a new problem for the all the Kia users that have this model. Also, Kia and their network of dealerships have known of this problem for over 1 yr and their standard answer is" we know its a software program, and will get back to you once the software code is fixed". Basically, they are dismissing the complaints and issues from the car owners. Also, this is poses a security and safety concern, since the warning light/message takes over the entire center console/display. Other relevant safety and security warnings/functionality is obstructed by it. Please force Kia to make this a mandatory recall for all Hybrid owners. There are thousands of customers impacted.

Refil inverter fluid warning light is on constant, this doesn’t allow the driver to access any digital information while vehicle is on. The vehicle is also having issues with the entertainment consul, Bluetooth connection issues along with the ability to access apple car play. Dealership says it’s Kia and nothing is being done. Various forums with others having similar issues.

Vehicle has a constant, unresolved error reporting that Inverter Coolant level is abnormal. Occurs daily. Dealership is unable to determine whether it is an issue. Has been taken to the dealership 2 times in the last 3 months. The warning also occupies the dashboard screen and cannot be dismissed, preventing me from viewing any vehicle details (engine temperature, tire pressure, digital speedometer)

Refill inverter coolant warning on dashboard. Took it onto local dealer, no problems located. May be a sensor issue.

Inverter fluid light has been coming on and staying on for over a month. It impedes the view of the digital display. The dealership has no fix nor any rental vehicles to bring my vehicle in. I have had this vehicle for 14 months. No one can tell me if this consistent light is harming my vehicle nor is there an urgency to repair. Unacceptable in a 40 grand vehicle

There is a constant error happening daily where a warning shows “refill inverter coolant” it takes up the main display and no dealer has a fix

Inverter coolant refill light will not turn off. This is available for inspection. This could be a possible fire risk. Issue has been confirmed at dealership. Components have been inspected by manufacturer. Issue started around 23,000 miles.

There is a warning message stating "Refill Invertor Coolant" that keeps coming up. The coolant is already full and the car functions normally. However, the warning message can only be cleared for a few seconds before it returns. The message covers up other information on the display such as digital speed and driving warnings such as lane departure. I feel this is an unsafe condition. The dealer I talked to said they are aware of the issue and trying to resolve it on another customer's car. At this time they are unable to resolve the issue.

The inverter coolant refill light will illuminate at all times even with the system serviced. Kia has serviced the system but has no solution on how to stop the light. The light also blocks out any other warning that may happen on the dash. With the light illuminated while driving, it is impossible to determine if the system is empty to cause a fire or just a faulty light. The dealership has confirmed the faulty warning light. There are no computer codes associated with the warning light.

The contact owns a 2021 Kia Sorento. The contact stated that while driving at an undisclosed speed, the fluid inverter level indicator warning light was illuminated. The vehicle was taken to the dealer; however, the dealer informed the contact that there was no known repair available for the failure. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The failure mileage was 7,650.

I have a ‘21 Sorento hybrid. The refill inverter coolant warning light keeps coming on. The first time it happened was on a road trip. A local dealer told me to check coolant levels and when it was full, told me it was safe to drive. I had it looked at as soon as I got home. By that time, the light had gone off. They flushed and refill the coolant. It happened again within 3 weeks. I took it in again. The dealer inspected said nothing was wrong with vehicle. Safe to drive. Also said I was the second one of these they’d seen. They were told corporate is working on a fix. I starting a ticket with Kia customer service. It’s been 9 days and no response from them. I am counting on the dealers being correct and that it is safe.