2011 Kia Optima Hybrid

Defect. Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.

Risk. An engine compartment fire while parked or driving can increase the risk of injury.

Remedy. Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.

Defect. Kia Motors America (Kia) is recalling certain 2012-2013 Sorento, 2012-2015 Forte and Forte Koup, 2011-2013 Optima Hybrid, 2014-2015 Soul, and 2012 Sportage vehicles. An engine compartment fire can occur while driving.

Risk. An engine compartment fire increases the risk of injury.

Remedy. Kia will notify owners, and dealers will inspect the engine compartment for fuel and/or engine oil leaks, perform an engine test and make any repairs, including engine replacement, as necessary, free of charge. In addition, Kia dealers will update the Knock Sensor Detection System (KSDS) software, free of charge. The recall began January 27, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC200.

Defect. Kia Motors America (Kia) is recalling certain 2010-2013 Kia Forte, Forte Koup, 2011-2013 Kia Optima and 2011-2012 Kia Optima Hybrid and Sedona vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags and seat belt pretensioners from deploying.

Risk. If the frontal air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.

Remedy. Kia will notify owners. For model year 2011 Sedona vehicles, Kia will instruct dealers to verify the ACU part number and, if necessary, install an extension wire harness kit between the ACU Connector and the Vehicle Harness Connector. For all other affected vehicles, Kia will instruct dealers to install the extension wire harness kit. The recall began September 28, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC165.

The contact owns a 2011 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2011 Kia Optima Hybrid. The contact stated while driving 50-60 MPH, there was smoke coming out from underneath the hood of the vehicle. The check engine warning light and other unknown warning lights were illuminated. The vehicle was taken to an independent mechanic, where the engine was cleaned and the spark plugs were replaced; however, the failure recurred while driving. The contact was able to pull into a parking lot and park the vehicle. The vehicle was towed to the residence. The vehicle was then towed to the local dealer and failed to restart. The dealer informed the contact that the vehicle could not be serviced because it was out of warranty. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) and to Kia Campaign Number: SC200. The manufacturer was not notified of the failure. The failure mileage was approximately 131,000.

The contact owns a 2011 Kia Optima Hybrid. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, and the message "Stop Vehicle" was displayed. The contact stated that the vehicle had stalled and shut off on several occasions. The vehicle was towed to the local dealer who was unable to determine the cause of the failure. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 30,000.

The contact owns a 2011 Kia Optima Hybrid. The contact stated while the vehicle was parked, after starting the vehicle, the steering wheel became stiff. The “Steering Assist Fault” messages were displayed. The vehicle was taken to an independent mechanic where it was diagnosed that the steering gear had failed. The dealer was contacted for a second opinion, but a diagnostic test was not performed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000.

The contact owns a 2011 Kia Optima Hybrid. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

WHILE DRIVING (IN FORWARD MOTION), WITHOUT ANY PRESSURE BEING APPLIED TO EITHER THE BRAKE OR PARKING BRAKE, THE VEHICLE BEGINS TO SLOW ITSELF RAPIDLY LOSING ACCELERATION.; A RUMBLE CAN BE HEARD THERE IS CONSISTENT BEEPING NOISE AND THE VEHICLE BEGINS TO VIBRATE SLIGHTLY. A YELLOW TRIANGLE WITH AN EXCLAMATION POINT AND THE WORDS CHECK BRAKE APPEARS IN THE DRIVERS DISPLAY; ATTEMPTS TO ACCELERATE INCREASES THE RPMS BUT THE VEHICLE CONTINUES TO SLOW RAPIDLY. NOT IDLE AS IF IT WERE NOT IN GEAR, BUT JUST AS IF THE DRIVER WAS BREAKING SUDDENLY. THE ONLY KNOWN METHOD OF CORRECTING THIS IS TO TURN THE VEHICLE OFF AND RESTART IT. HOWEVER, THIS STOPS WORKING AS A SOLUTION AFTER A FEW DAYS AND THE PROBLEM PERSISTS. WHEN THE VEHICLE RESTARTS YOU CAN FEEL THE BRAKE PEDAL RELEASE. THIS HAS OCCURRED RANDOMLY AT LEAST 20 TIMES IN THE PAST BEFORE UNTIL EVENTUALLY IT COULD NOT BE DRIVEN AT ALL. AT SPEEDS RANGING FROM 25 MPH ON NEIGHBORHOOD STREETS TO 70 MPH ON BUSY FREEWAYS. I SINCERELY FEAR THAT IF NOT CORRECTED IT WILL LEAD TO A (POTENTIALLY FATAL) VEHICLE COLLISION. I ALSO TOOK THE VEHICLE TO A NEAR-BY KIA DEALER SERVICE DEPARTMENT IN CA. AFTER MONTHS THE CAR WAS RETURNED AND IT CONTINUED TO HAVE THE SAME ISSUE WITHIN A DAYS. THEY WERE UNABLE TO DIAGNOSE OR DUPLICATE THE MALFUNCTION AS ALSO. I HAVE VIDEO OF THIS AS WELL. THIS NEEDS TO IMMEDIATELY BE CORRECTED AND THE TECHNICIANS NEED TO KNOW WHAT THE PROBLEM IS AND HOW TO FIX IT RATHER THAN EXPERIMENTING ON OWNERS VEHICLES FOR MONTHS OR WEEK

MY ACTIVE AIR FLAPP SYSTEM IS DEFAULTING AND TRANSMISSION GOING OUT. NOT TO MENTION THE HESITATION WHEN ACCELERATING

MY 2011 KIA OPTIMA HYBRID HAD AN ENGINE FAILURE, CAR KEPT STALLING SO BOUGHT A 300 DOLLAR BATTERY. WELL THE CAR STALLED AGAIN WHILE DRIVING, TOOK IT TO THE KIA SERVICE CENTER JUST TO TELL ME THE ENGINE WAS BLOWN. THERE'S BEEN SEVERAL CONSUMER COMPLAINTS ABOUT ENGINE FAILURE ON THESE VEHICLES SO WHATS TAKING LONG TO RECALL THESE ENGINE MISHAPS. CALLED CUSTOMER CARE AND WAS INFORMED WITH NO HELP WHATSOEVER. SEVERAL CONSUMERS HAVE COME OUT OF POCKET FOR THESE NEGLECTED ENGINE FAILURES AND NOTHING IS BEING DONE.

TOOK MY CAR TO THE DEALER IN CAMP SPRINGS, MARYLAND TO HAVE AN ANALYSIS DONE AND TO INSTALL A NEW AIR BAG RECALL FROM DMV. ONE OF THE ISSUES WAS TO CHECK MY FLUIDS AND TO SEE WHY MY CAR HESITATES AND MAKES A CLANKING NOISE AFTER DRIVING A PERIOD OF TIME. NOW, IT DIDN'T HAPPEN ALL THE TIME. JUST WHEN IT WAS DRIVEN FOR A FEW HOURS STRAIGHT. ONE OF THE DEALERS SERVICE REP REPORTED THAT THE ENGINE WAS BURNING OIL. AFTER READING THE REPORT, I WOULD CONSTANTLY CHECK THE OIL. WHEN I FIRST NOTICE THE CLACKING NOISE, I WOULD CHECK THE OIL. THERE WAS PLENTY OF OIL IN THE CAR, HOWEVER, MY COOLANT CONTAINER WAS LOW. PURCHASED COOLANT FOR THE VEHICLE. A MONTH LATER, THE CONTAINER WAS ALMOST EMPTY AGAIN. APPARENTLY, THE COOLANT WAS LEAKING INTO THE ENGINE. NOW I HAVE AN ENGINE PROBLEM.

ECU MALFUNCTION CAUSING MISFIRE IN CYLINDER ONE RESULTING IN IGNITION COIL MELTING AND AND CAUSING ELECTRICAL FIRE IN ENGINE BAY WHILE IN MOTION ON LOCAL STREET. VEHICLE IS NOW INOPERABLE.

OUR CAR BEGAN EXHIBITING A CLACKING NOISE WHEN DRIVING THAT WOULD WORSEN WITH ACCELERATION. WITHIN 1-2 DRIVES, IT QUICKLY PROGRESSED TO BE QUITE LOUD AND CONSTANT, SO WE TOOK IT TO OUR LOCAL DEALERSHIP. WE WERE INFORMED THAT OUR ENGINE HAD THROWN A ROD AND WOULD NEED TO BE COMPLETELY REPLACED. WE ARE JUST OUTSIDE THE 100,000 MILE WARRANTY AND BOUGHT THE CAR BRAND NEW IN 2012 (YES, THE YEAR AFTER THE MODEL DATE, TAKING ADVANTAGE OF THE PRICE BREAK IN BUYING OLD STOCK), SO IT IS STILL A FAIRLY YOUNG ENGINE TO BE HAVING THIS PROBLEM. IT APPEARS OTHER NON-HYBRID KIA AND HYUNDAI MODELS FROM THE SAME YEAR ARE HAVING THE SAME PROBLEM AND HAVE BEEN RECALLED, BUT NOTHING ON THE HYBRID VEHICLES, DESPITE THAT WE WERE ALSO TOLD THIS HAS BEEN A COMMON PROBLEM.

ENGINE MISFIRE IN CYLINDER # 1. THE ENGINE BEGAN TO SMOKE, CHECK ENGINE (P0301) ILLUMINATED. IGNITION COIL WAS MELTED NOW CAR DOES NOT START. ENGINE FAILURE. THIS HAPPENED ON A SHORT TRIP TO THE STORE LIMPED THE CAR BACK HOME. KIA REFUSES TO RECALL THIS OPTIMA ENGINE BECAUSE ITS A HYBRID ALTHOUGH IT HAS FAILED AND HAS BEEN RECALLED ON MULTIPLE SAME YEAR KIA OPTIMAS DUE TO METAL DEPOSITS IN THE ENGINE FROM FACTORY.

THERE'S A CLUNKING IN THE STEERING . FROM WHAT I'VE FOUND ON THE FORUMS THIS IS A COMMON PROBLEM . IT APPEARS TO BE A PLASTIC COUPLER IN THE STEERING MOTOR THAT DETERIORATES CAUSING A METAL ON METAL GRINDING. I NOTICED THIS WHILE TURNING AT AT STREET CORNERS OR CHANGING LANES ON HIGHWAY. NHTSA NUMBER: 10090941. THIS APPARENTLY HAS BEEN REPORTED BEFORE . WANTED TO MAKE SURE MY INFO WAS INCLUDED .

TL* TAKATA RECALL. THE CONTACT OWNS A 2011 KIA OPTIMA HYBRID. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V363000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. SMITHTOWN KIA (726 MIDDLE COUNTRY RD, ST JAMES, NY 11780, (631) 724-8008) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

THE ENGINE HAS EXPERIENCED WHAT OTHER KIA ENGINES HAVE. ENGINE OIL WAS EITHER BLOCKED OR RAPIDLY BURNT UP, CAUSING THE ENGINE TO SPIN A ROD BEARING, THUS NEEDING A NEW ENGINE. LUCKILY I STOPPED DRIVING IMMEDIATELY, PREVENTING A FIRE; AS HAS HAPPENED IN OTHER KIA VEHICLES. SADLY, KIA IS REFUSING TO WARRANTY OR RECALL THE HYBRID ENGINES, EVEN THOUGH MANY ARE EXPERIENCING THE SAME ISSUES.

TL* THE CONTACT OWNS A 2011 KIA OPTIMA HYBRID. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V363000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. SMITHTOWN KIA (726 MIDDLE COUNTY RD, ST JAMES, NY) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AS THE CONTACT WAS CONCERNED WITH DRIVING A VEHICLE WITH A SAFETY DEFECT. THE CONTACT STATED THAT THE MANUFACTURER OFFERED NO ASSISTANCE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

WHILE DRIVING, THE ENGINE BEGAN MAKING A LOUD CYCLICAL KNOCKING SOUND. WE HAD IT TOWED TO THE LOCAL KIA DEALER WHOSE REPORTED DIAGNOSIS WAS "CHARACTERISTIC OF ROD BEARING FAILURE" AND WE WERE INFORMED THAT THE ONLY REMEDY WAS TO HAVE THE ENGINE REPLACED. INFORMED BY LOCAL DEALER THAT KIA HAD DECLINED THE CLAIM TO HAVE IT REPLACED AND THAT THE ONLY COURSE OF ACTION WAS TO TAKE IT UP WITH KIA CONSUMER AFFAIRS. AFTER MULTIPLE CONVERSATIONS WITH KIA CONSUMER AFFAIRS (INCLUDING A 2 WEEK TIME LAPSE DURING WHICH THEY WOULD TAKE OUT CALLS BUT NOT NOTIFY US OF DECISIONS MADE UNLESS WE CALLED THEM), WE WERE FINALLY INFORMED THAT EVEN THOUGH ALL OTHER 2011 KIA OPTIMAS HAD BEEN RECALLED UP TO 125,000 MILES, FOR "ROD BEARING FAILURE" AND THUS HAD THEIR ENGINES REPLACED, OUR 2011 KIA OPTIMA WAS NOT COVERED FOR ROD BEARING FAILURE BECAUSE IT WAS A HYBRID. THEY WOULD NOT ASSIST IN ANY WAY WITH REPLACING THE ENGINE EVEN THOUGH THIS IS A WELL DOCUMENTED ISSUE WITH KIA OPTIMAS. THE LOCAL DEALER OFFERED A USED ENGINE FOR THE WHOPPING PRICE OF $5474.17 WITH NO WARRANTY OR TO REBUILD THE ENGINE WITH PARTS THEY WOULD HAVE TO ORDER FROM KOREA FOR A WHOPPING TOTAL OF $5710.75. THE LATTER OPTION WOULD INCLUDE A 12,000 MILE WARRANTY BUT WOULD REQUIRE A LENGTHY WAIT ON THE PARTS TO ARRIVE FROM KOREA. EVIDENTLY, KIA DOES NOT KEEP NEEDED PARTS IN THE ENTIRE UNITED STATES WHICH SOUNDS SKETCHY AT BEST. AFTER MUCH DELIBERATION AND AGONY, WE WILL SELL THE CAR FOR SCRAPS. WE CANNOT RISK SPENDING ALMOST $6000 O

DRIVING ON RAMP TO I10 IN CHANDLER AZ , SUDDENLY I'VE LOST POWER ON THE CAR, NO WARNING LIGHTS ON OR ANY SOUND HEARD .I COAST TO THE EMERGENCY LINE AND TRY TO START THE ENGINE AGAIN BUT NOTHING HAPPENED. AAA TOW THE CAR TO KIA DEALER AND THEY SAID THE ENGINE IS SEIZED. ONLY 64000 MILES . NO WARNING LIGHTS ON , NO ENGINE CHECK LIGHT ON .

TL* THE CONTACT OWNS A 2011 KIA OPTIMA HYBRID. THE CONTACT STATED THAT THE VEHICLE MADE AN ABNORMAL NOISE AND EXPERIENCED A LOSS OF ENGINE POWER. THE VEHICLE WAS TOWED TO CROWLEY KIA (223 BROAD ST, BRISTOL, CT) WHERE THE ENGINE WAS DEEMED DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 108,000.

CAR STALLED ALL OF SUDDEN WITH SHUDDER ON ROUTE 7 IN VIRGINIA AND THEN IMMEDIATELY WAS YAKEN INTO PARKING LOT FOR SAFETY REASONS. IN TRYING TO PARK CAR WOULD NOT SHUT OFF. THE CAR WAS ON FOR ABOUT FIFTEEN MINUTES THEN RANDOMLY STOPPED. AFTER ANOTHER TEN MINUTES CAR WOULD NOT START AND THEN RANDOMLY STARTED. CAR WAS ASAP DRIVEN WITH ENGINE SHUDDER BACK TO HOME DRIVIEWAY AND PARKED FOR SAFETY. CAR NOW AGAIN WOULD NIT SHUT DOWN AND KEPT RUNNING. ON BITH TIMES WHILE CAR REFUSED TO SHUT DOWN THE GAUGE SHOWED CEHCK ENGINE EPS LIGHT AND INDICATED THAT CAR NEEDS TK BE PUT IN PARK MODE EVEN THOUGH CAR WAS JN PARK MODE. GEARBOX WOULD NOT SHIFT AND CAR DID NOT RECOGNIZE LOWER GEAR MODES AS IT KEPT SAYING CAR IS NOT IN P. DEALER WAS CONTACTED AND THEY SAID THEY WERE CLOSED DUE TO WEEKEND. WILL NOW NEED TO TOW THE CAR AS IT WILL NOT START SINCE PREVIOUS INABILITY TO SHUTOFF PROBABLY HAS KILLED BATTERY.