2011 Keystone Montana High Country

Defect. KEYSTONE HAS REVISED THEIR REMEDY PROCESS AND IS AGAIN RECALLING CERTAIN 2009-2011 VEHICLES WITH THE “GENERATOR READY” OPTION, OR WITH STANDARD GENERATOR. SEE THE LIST ABOVE FOR THE AFFECTED MODELS. SOME IOTA ITS-50R TRANSFER SWITCHES ARE EXPERIENCING FAILURES WHEN EXPOSED TO HIGH ELECTRICAL LOADS. THE FAILURE IS CAUSING CONNECTIONS AND WIRING IN THE TRANSFER SWITCH TO DEGRADE AND OVER HEAT.

Risk. CONTINUED USE OF THE VEHICLE WITHOUT REPLACING THE TRANSFER SWITCH MAY DAMAGE OTHER APPLIANCES, INCREASE THE RISK OF A FIRE, PERSONAL INJURY, AND PROPERTY DAMAGE.

Remedy. KEYSTONE WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE TRANSFER SWITCH, FREE OF CHARGE. THE REMEDY FOR THE PREVIOUS RECALL (10V-594) WAS TO INSPECT AND TIGHTEN THE SWITCH CONNECTIONS. THE SAFETY RECALL BEGAN ON FEBRUARY 24, 2012. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.

Defect. KEYSTONE IS RECALLING CERTAIN FIFTH WHEEL TRAILERS WITH A GENERATOR READY OPTION. IF THE TRANSFER SWITCH IS NOT INSTALLED TO THE PROPER SPECIFICATIONS, THE ELEVATED ELECTRICAL LOADS ASSOCIATED WITH THE RECREATIONAL VEHICLE USE IN HIGHER AMBIENT TEMPERATURES MAY CAUSE OVERHEATING OF THE LUGS AND DEGRADING OF THE ELECTRICAL CONNECTIONS.

Risk. OVERHEATING OF THE CONNECTIONS COULD RESULT IN A FIRE.

Remedy. DEALERS WILL INSPECT AND REPLACE THE TRANSFER SWITCH IF NECESSARY FREE OF CHARGE. THE SAFETY WAS SUPERCEDED BY CAMPAIGN 11V-577. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.

Defect. KEYSTONE IS RECALLING CERTAIN RECREATIONAL VEHICLES AND FIFTH WHEEL TRAILERS EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Risk. THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy. KEYSTONE IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN ON DECEMBER 10, 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR KEYSTONE AT 866-425-4369.

Defect. KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2011 RECREATIONAL VEHICLES EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.

Risk. A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.

Remedy. DEALERS WILL ISOLATE AND PERFORM A DROP PRESSURE TEST ON THE OVEN SUPPLY TUBE AND IF THE TUBE LEAKS IT WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2010. OWNER MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.

OWNER REPORTS THAT VEHICLE EXHIBITS A SIDE-TO-SIDE TILT (DRIVER-SIDE IS 1-1/2" LOWER THAN PASSENGER SIDE) DUE TO UNEVENLY DISTRIBUTED SIDE-TO-SIDE LOADING. OWNER REPORTS RESULTS OF WEIGHING UNLOADED WEIGHING VEHICLE BY RIGHT AND LEFT SIDE: RIGHT SIDE: 3880 LBS; LEFT SIDE 4760 LBS (TOTAL 8640 LBS). TOTAL IS 9360 LBS. WHEN TRAILER LOADED -- WEIGHT DISTRIBUTION LOADED WAS NOT MEASURED. OWNER REPORTS NO OBSERVED CONCERNS REGARDING VEHICLE HANDLING. AXLE CAPACITY= 10,400 LBS (5200 LBS X 2). UPDATED 12/12/11*LJ UPDATED 12/23/11