2016 Jeep Wrangler complaints

The contact owns a 2016 Jeep Wrangler. The contact stated while starting the vehicle, there was an abnormal sound coming from the vehicle. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer but there was no failure found however, the dealer performed an oil change. The vehicle continued to experience the failure with the abnormal sound being more pronounced. The contact took the vehicle to an independent mechanic to be diagnosed. The contact was informed that the cylinders needed to be adjusted. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 93,000.

The sway bar on the 2016 Jeep Rubicon sway bar engages and you lose ability to steer. This has happened on the expressway to us, several time. I have read about this issue, there was a class action lawsuit that did not go anywhere. This is very dangerous to the people driving and also to people around them. I

The contact owns a 2016 Jeep Wrangler. The contact stated while driving 35 MPH, the front passenger’s side brakes locked up without warning. The contact stated that the brakes were smoking while driving. The contact was able to drive the vehicle to the residence. The vehicle was not diagnosed. The dealer was contacted and stated that the vehicle needed to be diagnosed. The contact replaced the front brake lines however, the failure recurred. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 32,000.

The contact owned a 2016 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, another vehicle driving at high speeds rear-ended the contact's vehicle, causing her vehicle to flip over twice; however, no air bags were deployed. The contact sustained a fractured tibia, fibula, and pelvis that required 6 surgeries with 1 surgery pending medical attention. A police report was filed. The vehicle was towed to a tow yard. The vehicle was deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was unknown.

By way of introduction, I am a seventy-five year old retired Arizona Highway Patrol officer, having left that service in 1992. In October 2016, I purchased new, a Jeep Wrangler Unlimited Rubicon from York Chrysler in Prescott, Arizona, VIN: [XXX]. Sometime after the purchase, the vehicle began to have a disturbing, recurring problem. While in normal operation, the engine will stop. It is as if the ignition has been turned off. The drill I have developed is, while the Jeep is coasting, to shift to Neutral, re-start the engine, shift to Drive, and proceed. Sometimes, the Check Engine Light activates, and sometimes, although less frequently, this is accompanied with the Electrical Stability Control (ESC) Off indicator light. The first time I documented the phenomenon with a visit to the dealership was 17 May 2023. However, I believe that the problem had happened several times prior to that date. Since then, the vehicle has exhibited this problem numerous times; sometimes at a stop, more often while proceeding in normal operation. The engine has stalled several times on the Phoenix, Arizona, freeway system during heavy traffic. Today, the engine stalled again, but would NOT re-start while coasting. I was forced to come to a complete stop, shift to Park, re-start, shift to Drive, and proceed. Often after a re-start, the transmission has difficulty in going into gear, even while in Drive. I have been advised at the dealership that the problem has occurred many times, to many driver

The airbags did not go off when I was struck from the front. Impact was 40 to 50MPH. AAA insurance carrier says its a complete loss with over $31,000 worth or repairs. They are salvaging the Jeep. The Jeep is at my home and available for inspection until AAA insurance takes it away. I was the only one in the Jeep when it was hit. With only the seatbelt to restrain me it severely twisted my body to the left. I have head, neck, back pain with 6 herniated disks. I have dizziness, nausea and loud nonstop ringing in the ears. Airbags have not been inspected by anyone. Only the damages were inspected by the insurance carrier. No warning lights, messages or symptoms prior to the accident.

As I drive, the car loses the ability to accelerate. It then passively stalls and the automatic steering locks up. All electrical inside the car still stays on. I put the car in park and it restarts on the first key turn. It has happened up to 3 times in a trip, but it is inconsistent when it happens (not necessarily every trip and not at specific speeds (it happeneded going 70 on the highway as well as going 25 in a neighborhood)). When I brought it to the dealership. I was told unless they could make it happen, they couldn't fix it. They also said even if they could make it happen, they couldn't be sure what it was. The onboard computer that sends error codes indicated different things that have been replaced (computer parts, sensors) and nothing has worked.

I have a 2016 Jeep Wrangler that I purchased in 2017. The vehicle does not have over 45,000 miles on it...yet it would not crank.....when it finally cranked, within a few feet it completely shut down....the dealer stated that it was the TIPM. that needs to be replaced.....after reading the complaint comments on several sites...I wanted to know why this part has not been recalled to date. This repair is very costly to me, and during these hard economic times, this process has been extremely stressful. The dealer stated that it might take up to 4 weeks to get my jeep back..this is soooo unfair that I would have to incorporate an additional cost that should have been recalled already.....Recall this Jeep wrangler asap please!!!..Thank you, [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Internal manual transmission problem. Cannot put jeep in 3rd gear. Burning smell

75,000 MILES, ENGINE TICKING ON COLD START, ENGINE LIGHT FOR CYL 2 MISFIRE, ENGINE CHUGS AND HAS LOW ACCELERATION. DEALER REPLACED ROCKER ARM UNDER OWNER'S EXTENDED WARRANTY. DID NOT FIX PROBLEM AND NOW ARE DISASSEMBLING ENGINE. READ MANY OTHER CUSTOMERS WITH SAME PROBLEM, CLASS ACTION LAW SUIT IN PROGRESS. MANUFACTURER KNOWS ABOUT PROBLEM BUT WILL NOT TELL OWNERS.

Windshield broke and it happened previously with a older jeep pebble on the highway likely kicked up and hit the windshield I believe because the windshield is flat there is an increased risk of breakage.

2016 Jeep Wrangler intermittently misfires then immediately loses power and dies. Also loses power steering at the same time. It almost caused an accident and is a big safety concern. Now I drive in the right lane in case I have to hurry and pull off the side of road. I turn the key off, but then start it right back up and it drives fine. But then will happen again random. No dash board warning lights ever come on. Been to the dealer twice- 1st time they updated pcm software, this time they changed spark plugs and coil pack. Help. *also, first started happening at 104,500 miles .. took to dealer for the issue, it is still happening and currently at 107,500; happens randomly whether at 25mph or 50 mph

Engine has failed. Had it inspected by two mechanics and they said the same thing, there are broken internal components possibly due to defective components.

Oil cooler housing cracked and leaking oil over entire engine which could cause a fire. Dealership has confirmed the part is damaged. No warning lamps or messages were triggered. Others have experienced the same problem with multiple replacements. Vehicle has been at the dealership now since 2/1/2023 waiting for Chrysler / Mopar Warranty to give the authorization to repair.

My 2016 jeep wrangler, is having major issues. My seatbelts completely stopped working last week February 3, 2023. I had left the mechanics because I had the back window replaced, and the back hood of my jeep wrangler. When pulling out of their driveway, I realized my seatbelt was very tight, but I still got to hook it. When I got home from my drive one and a half hours away, I went to use my car and the seat belts would not work. Driver side and passenger side seat belts have completely seized. Has my jeep wrangler 2016 had any recalls. My son died December 10, 2019. I have never had any other problems with my jeep wrangler. I believe in jeep and the company who makes them. The body shop told me to get rid of my jeep. I cannot do that and since my son died in my jeep wrangler and drug dealers threw him in the back seat, letting him die after they stuck him with a needle full of fentanyl. Please help I do not want to part with my jeep wrangler. I am sure with the Vin number you will be able to trace anything that has gone on with my Jeep! I could have missed many recalls because my son was very sick, from 2016 until his death 2019. I purchased the car brand new in 2016 in upstate New York. Please tell me how I can get help so my seatbelt will work again and the airbag can be inspected. It must be a recall issue I can’t think of anything else and I need your help. I now live in Port Charlotte, Florida, and I am near my daughter. This jeep wrangler has been very good to us. It

The headlamp assembly lenses have become warped and frosted due to excessive heat from the bulb and defective heat dissipation from the headlamp assembly . Poor visibility at night, as light output is significantly diminished creating a safety hazard..

My 2016 Jeep Wrangler that has 48K miles was running and in park. After about 20 minutes of being in the park position my ABS and Traction Control Light came on. I took my Jeep to my local Autozone to have the code read and it came back with C1032 and C102B. I had the sensor replaced and ensured that the connections were clean of any debris. Once sensor was changed it took about 20 minutes to clear the ABS and Traction Control light from the dash. I drove my Jeep later that night and all seemed fine until I attempted to stop at a speed of 5-10mph. At that time the ABS kicked in on my vehicle but no warning lights illuminated. I once again checked the newly changed sensor along with the wiring to ensure there was no breaks in the connections and I found none. Not sure why my ABS engages at at such a low speed after a new sensor was installed.

While driving my Jeep Wrangler on the highway going speeds of >60 mph for longer than 20 minutes the vehicles check engine and traction control light illuminate and I lose passing capability in the Jeep. Once the vehicle is turned off and on 3 times the system seems to reset itself. Because of this the only way the dealership can read the codes is if the lights are illuminated. I have taken the Jeep to 2 different Jeep dealerships while the lights were on and both have claimed that the "system needed to be reset". Once they do that the Jeep seems to run fine and the lights are gone. However, it is still happening whenever my speed goes 60 mph or more for a short period of time. Due to this problem I am not comfortable but sometimes must take my Jeep on the highway and without fail the same warning lights illuminate and the passing power is gone. I have reported this problem to Jeep itself and was told to take it to another Jeep dealership which I did and the same maintenance was performed but yet the same problem exists. This failure is a hazard to not only the driver but those around due to the vehicles lack of passing power when on a highway where speeds are at a minimum of 65mph.

My wife was involved in an injury accident 12/02/2023 due to failure of the ABS Module not activating and the Air bag system not deploying. She was cut off by a hit and run driver. She slammed on the brakes went into an uncontrollable skid lost control on the Highway went off the road tumbled end over end 4 times no air bag deployment. No ABS or Air bag warning lights were on both systems failed.

The camshaft and lifters failed with no check engine light. Upon inspection the left bank cams and lifters were in need of replacement and a pinhole was found in the radiator.

The contact owns a 2016 Jeep Wrangler. The contact stated while driving at an undisclosed speed, she heard a tapping sound under the hood of the vehicle. No warning light was illuminated. The dealer was notified of the failure and indicated that the rocker arm and the camshaft needed to be replaced. The vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was 70,218.

Oil Housing Unit crack. Just bought vehicle used. Weather dropped to 28 degrees and oil housing unit cracked. All oil poured out of vehicle and would not hold any oil when more was added. Took vehicle to Jeep dealer and they confirmed that the PLASTIC piece that was the original part cracked and that this is a very common problem for 2014-2017 Jeeps due to the part being plastic. Part is not covered under any warranty and will cost $1200 to repair. I'm told that the replacement parts have been updated and are no longer made of plastic due to the high instance of problems. All research shows that this was to be a recall but that it has not been made official. This is a huge safety concern as the oil completely drained from the vehicle upon crack. Had I not been in my own driveway and driving down the highway, this would have caused major issues, engine failure and very possibly an accident. We were planned to be on a 6hr road trip moments before this occurred in the driveway. This part needs to be recalled and replaced by the manufacturer since it is a common and known problem with many Jeeps manufactured during that time frame.

This Jeep is a right hand drive wrangler. Airbag light, traction control light came on, and my horn quit working. Cruise control quit working, and then my antilock brake system was malfunctioning. I couldn't figure out why. So I went to both the Jeep dealership, and the local autozone where they scanned my Jeep for codes, and it's saying a bad clockspring. They said there is a known recall for 2016 models, but mine isn't included. They said to figure out why this Jeep is not included. . Why is my Jeep not included in the already known recall for the bad clock springs?

The contact owns a 2016 Jeep Wrangler. The contact stated while driving 40 MPH, the contact attempted to blow the horn and no sound came from the horn. The contact stated that the steering wheel became difficult to steer and the controls on the steering wheel were inoperable. The vehicle was taken to the dealer and the contact was informed that the steering column and the clockspring needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and stated that the vehicle was not under recall. The failure mileage was 13,000.

I started my Jeep. After a few minutes I could smell smoke and something burning. The alarm started going off, wipers came on, radio etc. smoke came inside cab . I tried to shut everything off but it wasn’t working. I started seeing flames around the hood. My husband was able to disconnect the battery and the fire died out. Insurance would not cover it and said it was electrical. The fuse box was melted and wire harnesses. The vehicle was right by our garage and could’ve caught our house on fire. My son and I were in the vehicle when the fire started. Thank God we weren’t hurt. I did report this but was told it wasn’t Jeeps fault. A week later another jeep caught fire in the small town I live in. Something isn’t right.

Parked vehicle outside corner of home at 9:00 pm. Awoken by loud popping and hissing sounds at 4:45AM. Looked outside to notice a bright orange hue by vehicle. Realizing the car was on fire, we called 911 and proceeded to use garden hose to water down both the vehicle and the home that the car was next to, in order to try to prevent the house from also catching fire. Vehicle was not moved nor accessed during those 7 overnight hours. It was locked and we were all asleep. There were two other vehicles parked next to and behind the vehicle that caught fire - those two other vehicles sustained no damage to them. The house sustained some minimal siding warping from the heat of the fire. Fire chiefs reviewing the damage in person as well as viewing photos have stated that it appears to be battery or fuse box related as that side of the engine's damage was greatest as well as the battery and fuse box being completely destroyed by the fire. No warning lights or indications of system failures or malfunctions prior to parking the car. Vehicle was towed away from scene by insurance company. Unsure if vehicle is still at that lot or not. Insurance deemed vehicle totaled and issued check for losses.

I HAVE HAD TO REPLACE MY ABS MODULE ALREADY. THE JEEP ONLY HAS 41,700 MILES ON IT. I AM JUST REPORTING IN CASE THIS COMES UP DOWN THE ROAD

P0302 code popped up all four rocker arms on left cylinder need to be replaced. Jeep had normal oil change 50k miles

I had an error message for the thermostat last week had that replaced. Now there is a puddle of oil coming from the oil coolant assembly. Replaced the thermostat awaiting mechanic for the oil coolant issue now.

Front driver side brake calliper locked while driving causing the vehicle to stir hard to one side and the wheel to overheat. After replacement, a few weeks later, the back left did the same this time causing the vehicle to pull, drive hard and smoke to be emitted from the wheel. Now several months later the front passenger side needs to be replaced too.

This in regard to my 2016 Jeep Wrangler. For the second time in less than 37,000 miles I have had a wheel speed sensor go out. (The first time, as I reported on an earlier NTSB complaint form, was the left front speed sensor.) This time it was the right rear speed sensor. I was driving in traffic when the ABS and Traction Control lights came on, along with my Jeep Wrangler braking on it's own. The lights would clear, only for it to have it happen again a few miles down the road. I took it in to a repair shop and their computer scan reported the right rear wheel speed sensor failed. I had the right rear speed sensor replaced which cured that problem. I have had wheel speed sensors fail twice in less than 37,000 when I have never experienced it even once in any other vehicle. Having your vehicle brake unexpectedly on it's own in Florida traffic is scary!

Experiencing illumination of the airbag warning lamp. Upon further investigation the technician may found one or more of B1B Diagnostic Trouble Codes. Current "recall" or "extended warranty applies to 2011 to 5/2/2016. My vehicles build date is 6/2016. My question is was the faulty part possible used after 5/2/2016 in Toledo where my vehicle was built. The airbag clock spring seems to have been a issue for awhile. I seen "recalls" all the way back to 2007. I just wanted to figure out my vehicle is being excluded from the "extended warranty" when I am have the same issues as a vehicle built just one month before mine.

My airbag light is on all the time and my horn stopped working.

Was in a 4way stop approaching it actually .I was going eastbound the other motorist was going south bound. He made a right turnouts west bound lane but he took it without slowing down for stop sign he didn't stop at all .he drove onto my front bumper side head on at a fast rate ofspeed.his airbags deployed my did not. I had my seat belt on but my airbags did go off.i got jerked around violently my head has not stopped from hurting and been dizzy and nauseous lately

Track bar mount welds sheared of the axle housing at 70 mph after hitting a pothole. Vehicle shot to the right almost putting me into a guard rail. Would have been a terrible accident if I did hit said guard rail. No warning lamps or indicators.

The contact owns a 2016 Jeep Wrangler. The contact stated while starting the vehicle, the ABS warning light illuminated. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and informed the contact that they could not assist as there was no recall associated with the VIN. The failure mileage was approximately 102,000.

Cold start, engage reverse and the engine idles really low and sometimes stalls. If I move the shifter to neutral the engine revs back up and does not stall. Rolling down the driveway and then engage reverse the problem does not occur. The issue has been getting worse whether its in the dead of winter or summer.

Driving at 50 MPH on high-speed concrete highway during a thunderstorm, my ABS and traction control lights came on and stayed on for a few minutes. In those few minutes, my car started slowly fish-tailing, so I pulled on to the side of the interstate. I turned off the engine completely and restarted, as well as other resets, to try to turn the ABS and traction control lights off. I started on to the highway again and got up to 50 MPH again with both lights still on. Again, my vehicle started shifting in the lane, so I pulled off the highway again and turned the car completely off. After a few more minutes, I restarted the vehicle engine, both lights remained on, and I got on to an asphalt surface for the remainder of my trip. Within half a mile, both lights turned off and the vehicle felt more secure on the road way. For the remainder of my drive, both lights remained off, but I did go through at least 4 standing puddles of water with no other issues with traction.

The contact owns a 2016 Jeep Wrangler. The contact stated that the air bags, seat belts, and ABS warning lights remained illuminated. The vehicle was not diagnosed or repaired. The VIN was not included in NHTSA Campaign Number: 16V288000 (Air Bags). The manufacturer was not notified of the failure. The failure mileage was 130,000.

I ran into a truck that stopped in the middle of the road, The impact was hard. My airbags didnt deploy. My chest is hurting

The contact owns a 2016 Jeep Wrangler. The contact stated that upon the approach of a stop sign with his foot on the brake pedal, the engine had begun to rev without warning. With the brake pedal depressed to the floorboard, the vehicle continued to lurch forward as the contact clipped the vehicle in front of him. As the engine continued to rev, the contact immediately shut off the ignition. A police report was not filed and no injuries were reported. Both the contact and the other driver were able to drive away from the scene. The dealer was notified and an appointment was made for a diagnostic. The contact called the manufacturer and was informed that he would receive a callback, the contact had yet to hear back from the manufacturer. The vehicle had yet to be repaired. The failure mileage was approximately 71,000.

Torque Convertor is going bad. On a cold start, when you put Jeep in reverse, it will stall. This started around 50k miles. At first, I thought I did something wrong. Then it started happening more often. I contacted Jeep, but they said they could not do anything because the Powertrain warranty was expired by a couple thousand miles. This is dangerous when I have to back out of my driveway in the morning as it will stall and can take a few times for it to restart. There has been no warning lights or codes that pull up on my OBD2 scanner that would lead me to knowing what the issue is.

Vehicle stalls while driving. sometimes can restart. sometimes takes a few minutes to restart. no issues prior. no known cause. on freeway doing 65 mph then lost all power. it was difficult to get to safety and i couldn’t move all the way off the road. it’s happened twice.

2016 JEEP WRANGLER. CONSUMER WRITES IN REGARDS TO DEFECTIVE TIRE PRESSURE MONITOR. THE CONSUMER STATED, ON MULTIPLE OCCASIONS, THE TIRES DEVELOPED CRACKS IN THE SIDEWALLS.

2016 Jeep JKU 78,000 miles NOT driveable because front end wobbles and steering wheel vibrates. Increasing to 60 MPH stops the wobble. This happened to me twice and someone else driving my vehicle. Had new tires installed and front end aligned - thought it was fixed but then the problem became worse. I just got back home after a 20 mile drive and the shaking and wobbling was horrific. I did not feel safe in this vehicle. Upon returning home the right front wheel began smoking so I grabbed a fire extinguisher just in case. The right front wheel was extremely hot to the touch. After cooling off and no fire, I conducted a visual inspection of the right front brake caliper and noticed it had circular markings on caliper in 3 different areas. I am not going to drive this vehicle again until the dealership can fix it.

The contact owns a 2016 Jeep Wrangler. The contact stated while driving 40 MPH, the brakes failed to operate as intended. There was no warning light illuminated. The vehicle was driven to a stop and the contact smelled rubber burning with a little bit of smoke. The vehicle was driven to an independent mechanic and was repaired. The failure recurred and the vehicle was taken back to the independent mechanic. The contact was informed that the ABS module was sticking and needed to be replaced however, parts were on back order. The manufacture was not notified of the failure. The failure mileage was 60,000.

Air bag light on saying it needs a clock spring I was just driving and light came on

The contact owns a 2016 Jeep Wrangler. The contact stated that upon replacing the engine oil himself, he noticed that oil was leaking onto the transmission. The contact stated that there was no smell of oil burning or any smoke coming from the oil leak. There were no warning lights illuminated. The vehicle was taken to the dealer where it was diagnosed that the oil filter housing was cracked. The dealer replaced the oil filter housing and repaired the vehicle; however, while the mechanic was test driving the vehicle, the vehicle caught on fire under the hood. There were no injuries sustained. The fire was extinguished with the assistance of the fire department. A fire department report was filed. There was no police report. The manufacturer was notified of the failure and sent an inspector who diagnosed that the fire started under the hood. The contact stated that he believed the fire started out as an electrical fire. The manufacturer advised the contact that the vehicle could not be repaired under warranty; and that the repair would be at his own expense. The vehicle was not repaired. The failure mileage was approximately 65,700.

The oil cooler housing exploded in my 2016 Jeep Wrangler. I put my car into reverse- I backed up and tried to put the car into drive. The car would not shift out of neutral for several minutes- 2 quarts of oil spilled onto the ground. My car eventually made its way to drive and has been steadily leaking oil since.

Torque Converter was replaced due to internal failure. Vehicle had 62k miles when torque converter was replaced. Issue arouse around 40k when vehicle would die when placed in reverse after cold start. AutoNation dealership did not cover cost since vehicle had went over 2k of the power train warranty. When I researched online, I came to realize that this is a common problem within the JK models which is upsetting to pay out of pocket cost for defect parts from the manufacturer.