2006 Itasca Meridian

Defect. WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Risk. THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy. WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

Defect. WINNEBAGO IS RECALLING 1,699 MY 2005-2009 WINNEBAGO JOURNEY, TOUR AND ITASCA MERIDIAN AND ELLIPSE MOTOR HOMES BUILT ON THE FREIGHTLINER XC CHASSIS. THE CHASSIS CONTAINS STEERING FILTERS THAT CAN PLUG DUE TO FAILURE OF THE SCREEN ADHESION TO THE FILTER HOUSING CAUSING A RISE IN RETURN LINE PRESSURE POTENTIALLY LEADING TO A HOSE SEPARATION FROM THE FILTER OR STEERING GEAR FITTING RESULTING IN A SUDDEN LOSS OF STEERING FLUID AND POWER ASSIST.

Risk. SUDDEN LOSS OF STEERING ASSIST WITHOUT WARNING INVOLVING A MOTOR HOME COULD BE A PROBLEM FOR CERTAIN DRIVERS INCREASING THE RISK OF A CRASH.

Remedy. FREIGHTLINER IS CONDUCTING THIS RECALL AND WILL REPLACE THE AFFECTED FILTERS WITH A LARGER FILTER (PLEASE SEE 07V570). OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712 OR WINNEBAGO AT 1-641-585-3535.

Defect. ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC STEPS, THE STEPS MAY HAVE BEEN MANUFACTURED WITH DEFECTIVE STEP CONTROL UNITS.

Risk. THE DEFECTIVE CONTROL UNITS COULD DEVELOP AN ELECTRICAL SHORT ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE, POSSIBLY RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

Remedy. DEALERS WILL INSPECT THE KWIKEE STEP AND REPLACE THE STEP CONTROL UNIT, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 23, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.

Defect. ON CERTAIN MOTOR HOMES, THE CINCH BOLT, WHERE THE STEERING COLUMN CONNECTS TO THE INTERMEDIATE SHAFT, WAS IMPROPERLY TIGHTENED. THIS COULD RESULT IN THE BOLT THREADS BEING STRIPPED, CONCEIVABLY NOT PROVIDING A TIGHT JOINT.

Risk. IF THE JOINT IS LOOSE, THE INTERMEDIATE SHAFT HAS THE POTENTIAL TO SLIP OFF THE SPLINE SHAFT OF THE STEERING COLUMN CAUSING LOSS OF STEERING CONTROL. THIS COULD RESULT IN PERSONAL INJURY OR VEHICLE AND PROPERTY DAMAGE.

Remedy. DEALERS WILL INSPECT AND REPLACE THE CINCH BOLT AND NUT. THE RECALL BEGAN NOVEMBER 4, 2005. OWNERS MAY CONTACT WINNEBAGO AT 641-585-6939.

Defect. ON CERTAIN MOTOR HOMES, THE ROOF VENT FOR THE OPTIONAL 4-DOOR REFRIGERATOR WAS INCORRECTLY LOCATED.

Risk. THIS CAN ALLOW EXCESSIVE HEAT BUILDUP WHICH HAS THE POTENTIAL TO IGNITE SURROUNDING MATERIALS, RESULTING IN PERSONAL INJURY AND/OI VEHICLE AND PROPERTY DAMAGE.

Remedy. DEALERS WILL RELOCATE THE ROOF VENT. THE RECALL BEGAN ON SEPTEMBER 9, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-6939.

I HAVE DISCOVERED A SEVERED WIRE ON THE BRAKE PEDAL ASSEMBLY OF THE FREIGHTLINER CHASSIS ON WHICH OUR 2006 ITASCA MERIDIAN MOTORCOACH IS BUILT. PICTURES ARE AVAILABLE SHOWING THE BROKEN WIRE ON THE BRAKE PEDAL ASSEMBLY UNDER THE FLOOR. APPARENTLY THE GREASE FITTING ON THE STEERING COLUMN SHAFT WAS THE MECHANISM THAT SNAGGED THE WIRE. THE BRAKE PEDAL ASSEMBLY AND THE STEERING COLUMN SHAFT ARE IN "VERY" CLOSE PROXIMITY AND THERE IS NO SHIELDING OR PROTECTION FOR THE WIRING ON THE BRAKE PEDAL ASSEMBLY. FREIGHTLINER CUSTOM CHASSIS CUSTOMER SUPPORT INDICATED THAT HAD BOTH WIRES BEEN SEVERED THE VEHICLE WOULD HAVE LOST BRAKING. *NM