Owners filed 1 complaints about this vehicle with federal regulators, most often about the tires. It has been recalled 5 times.
What fails
Component
Reports
Crashes
Fires
Injuries
Tires
1
0
0
0
5 safety recalls
Part 573 reports
Equipment › Recreational Vehicle/Trailer04V100000
Filed Feb 27, 200483,312 vehiclesInternational Truck & Engine Corporation
Defect. ON CERTAIN CONVENTIONAL TRUCKS EQUIPPED WITH PRO-SLEEPER BERTHS, WATER INTRUSION CAN BE FOUND IN THE BUNK CONTROL PANEL AREA AND POOL IN THE TOPS OF THE DOME LIGHT, TV/VCR, AND OR REFRIGERATOR POWER SWITCHES.
Risk. THE CIRCUIT BOARDS IN THE SWITCHES COULD HEAT UP , POSSIBLY PRODUCE A FLAME OR FIRE, AND CAUSE PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Remedy. DEALERS WILL INSTALL A WATER SHIELD OVER THE BACK OF THE ENTIRE BUNK CONTROL PANEL. OWNER NOTIFICATION BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
Service Brakes, Air › Slack Adjusters01V023000
Filed Feb 1, 20012,855 vehiclesInternational Truck And Engine
Defect. VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH AIR BRAKE HALDEX AUTOMATIC SLACK ADJUSTERS, LONG STROKE BRAKE CHAMBERS, AND DANA BRAKES. THE AUTOMATIC SLACK ADJUSTER ANCHOR BRACKETS CAN FAIL DUE TO FATIGUE FRACTURE AND COMPLETELY SEPARATE, CAUSING THE SLACK ADJUSTERS TO FUNCTION AS MANUAL SLACK ADJUSTERS.
Risk. IF THE SUPPORT BRACKET FOR AN AUTOMATIC SLACK ADJUSTER FAILS, THE BRAKES AT THAT WHEEL END WILL NOT AUTOMATICALLY ADJUST. AS THE BRAKE LININGS WEAR, THE VEHICLE WILL HAVE REDUCED BRAKING CAPACITY, INCREASING THE RISK OF A CRASH.
Remedy. DEALERS WILL INSTALL A NEW BRACKET ON EACH SUSPECT SLACK ADJUSTER. OWNER NOTIFICATION BEGAN FEBRUARY 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
Suspension96V124004
Filed Aug 1, 199621 vehiclesInternational Truck And Engine
Defect. THE EQUALIZING BEAM SHAFT OF THE TANDEM AXLE SUSPENSION WERE MANUFACTURED FROM AS-ROLLED SAE4140 STEEL RATHER THAN THE SPECIFIED ANNEALED SAE4140. THESE SHAFTS CAN FRACTURE INSIDE THE BEAM AT THE TOE OF THE WELD.
Risk. VEHICLES ARE SUBJECT TO VEHICLE TILT AND POSSIBLE ROLLOVER IN THE EVENT THAT BOTH EQUALIZING BEAMS, ON THE SAME SIDE OF THE VEHICLE, EXPERIENCE A SIMULTANEOUS SHAFT FAILURE. AFFECTED SUSPENSIONS CAN ALSO DROP AND CONTACT THE ROAD SURFACE GENERATING SPARKS WHICH COULD IGNITE FLAMMABLE MATERIAL.
Remedy. OWNER NOTIFICATION IS BEING CONDUCTED BY NEWAY ANCHORLOK. DEALERS WILL INSPECT AND REPLACE ALL SUSPENSION SUSPENSION BEAMS WITH SUSPENSION BEAMS CONTAINING APPROPRIATE SHAFTS.
Equipment › Recreational Vehicle/Trailer95V182000
Filed Sep 25, 19951,843 vehiclesInternational Truck And Engine
Defect. STRAPS HOLDING THE SLEEPER UPPER BUNK IN THE RAISED POSITION CAN RELEASE WITHOUT WARNING.
Risk. IF THE RESTRAINING STRAP RELEASES SUDDENLY, THE BUNKFALLS WITHOUT WARNING AND CAN STRIKE AN OCCUPANT SITTING IN THE LOWER BUNK CAUSING PERSONAL INJURY.
Remedy. DEALERS WILL MODIFY THE ATTACHMENT OF THE UPPER BUNK RESTRAINING STRAP TO THE UPPER BUNK AND REAR WALL OF THE SLEEPER AND INSTALL A NEW REDESIGNED BUNK RESTRAINING STRAP.
Power Train › Driveline95V174000
Filed Sep 14, 1995651 vehiclesInternational Truck And Engine
Defect. THE DRIVELINE COULD HAVE LITTLE TORQUE OR NO TORQUE ON THE DRIVELINE NUT THAT RETAINS THE YOKE AT THE CENTER BEARING OR BEARINGS IF THE VEHICLE IS EQUIPPED WITH MULTIPLE CENTER BEARINGS.
Risk. THE LOW TORQUE CONDITION CAN CAUSE THE DRIVELINE TO SEPARATE RESULTING IN PERSONAL INJURY OR PROPERTY DAMAGE FROM PARTS BEING THROWN FROM THE VEHICLE OR SCATTERED ON THE ROADWAY.
Remedy. DEALERS WILL DISCONNECT THE DRIVELINE AT THE REAR OF THE CENTER BEARING(S), TORQUE THE YOKE NUT AND RECONNECT THE DRIVELINE.
What owners reported
Newest filings
Tires
Filed Mar 3, 1996GA
GOODYEAR TIRES HAVE SLITS ON SIDE, CAUSING THE VEHICLE TO PULL TO THE LEFT/RIGHT. *SD
No unusual pattern of severe incidents in the complaint record.
Complaint counts track how many cars were sold and how long they have been on the road as much as they track quality. A common model from 2013 has had a decade to accumulate reports; a rare one from last year has not. The signal worth weighing is in the severity columns, in whether the same component keeps appearing, and in whether the manufacturer eventually opened a recall for it.
Recall repairs are free for as long as the recall stands. Check whether a specific car still has open work at NHTSA's VIN lookup.
Most recent recall on file: Feb 27, 2004. Source: NHTSA Office of Defects Investigation.