2015 Hyundai Veloster

Defect. Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.

Risk. An engine compartment fire while parked or driving can increase the risk of injury.

Remedy. Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.

Defect. Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Veloster, 2012 Santa Fe, 2011-2013 Sonata Hybrid, and 2016 Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which over time can result in engine damage.

Risk. A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.

Remedy. Hyundai will notify owners, and dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System (KSDS). Repairs will be performed free of charge. The recall began March 31, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 198.

Climate control module burnt out (highly common problem). Replaced it along with new connection and it melted the control switch and fried the connector again. Hyundai has acknowledged this very common issue but still hasn't done a recall for the cheap wiring in the vehicle. Ive had smoke come out of my dash the 1st time. They dont sell the control know individually so you have to buy the whole console and they dont sell new connector so you have to buy the entire wiring harness and either take the dash off yourself to replace or take it in to be fixed and pay the hefty price for it. Please make them fix this because im very surprised someone's car hasn't caught fire yet.

2015 Hyundai Veloster Turbo (original owner). The vehicle has three severe safety defects: TRUNK/HATCH LATCH FAILURE: The hatchback lift support/latch fails, refusing to stay open. It unexpectedly fell, which has caused repeated, severe impacts to my head and neck, resulting in an injury requiring surgery. I must manually prop it open with a mini ball to load cargo. ENGINE & TURBO FAILURE / OIL CONSUMPTION: History of engine acceleration issues and turbo failures since 4,000 miles. At 44,000 miles, the turbo completely failed, the car started to whine, then rattle, and completely turned off. Dealer (Hyundai Escondido) forced a $2,200 out-of-pocket replacement despite being under warranty, citing a lack of at-home oil change receipts. The vehicle now has a documented, rapid oil leak and excessive consumption issue that the dealer refuses to repair, despite being reported prior to warranty expiration. SEAT BELTS: The front and rear seat belt latches are malfunctioning, intermittently releasing on their own, failing to release properly, or failing to latch securely, compromising the safety of a [XXX] passenger. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2015 Hyundai Veloster. The contact stated that upon starting the vehicle and shifting into gear, the vehicle failed to respond and became inoperable. There was no warning light illuminated. The vehicle was taken to the dealer, and the rear axle was replaced, the transmission fluid was flushed and refilled, and a shift analyzer software update was performed; however, the failure recurred days later. The vehicle was taken back to the dealer, where it was determined that the wheel speed sensor had failed. Upon investigating the failure online, the contact advised the dealer to inspect the crankshaft position sensor; however, the dealer informed the contact that the failure was related to the transmission. The contact was informed that the failure could not be duplicated. The vehicle was not diagnosed or repaired, and the contact was advised to retrieve the vehicle. The manufacturer was notified of the failure and covered the cost of the rear axle replacement under a goodwill assistance program. Several cases were filed, and the contact sent a video of the failure to the manufacturer. The failure mileage was approximately 62,000.

The climate control fan knob suddenly stopped working. I smelled a burning smell on the interior of the car. I pulled the panel off and noticed that the plug to the climate control harness was burnt. I can no longer utilize the climate control system.

I am reporting a safety-related engine defect involving sudden internal engine failure, excessive oil consumption, persistent bearing knock, and overheating of the catalytic converter. The vehicle repeatedly triggered Bank 1&2O2 sensor fault codes due to oil blow-by and thermal overload. A certified mechanic documented the engine is failing internally and that the cat. converter has been damaged as a direct result of engine defect. The failure pattern is consistent with known Hyundai engine defect investigations involving bearing wear, oil consumption, stalling, and fire risk. The overheating cat. converter presents a significant safety hazard, including potential engine seizure. I purchased the vehicle used in March 2025. I am the third owner. Despite maintaining the vehicle responsibly (Regular oil changes), the engine failure progressed rapidly. Hyundai Motor America has denied a goodwill repair solely on the basis of mileage, even though the defect clearly originated long before my ownership and aligns with previously identified safety-related engine issues. Additionally, Hyundai's records show that this vehicle had an engine-related recall active during prior ownership period; the recall was never performed by the Hyundai dealership that sold the vehicle to the previous owner. This raises concerns about improper recall handling and whether the defect should have been corrected before the vehicle was resold. Given the safety implications, the documented defect pattern, an

I took my car to Gilroy Hyundai November 11, 2025 at 10:30 a.m. because my engine was not running normal, it shook lightly while driving at an incline and the engine light would not shut off. they charged me $284.99 to tell me what needed to be fixed, engine was not looked per Ernesto Garcia. Ernest told me they go by mileage, not actually checking the engine. He also stated that the mechanic drove it and it was fine. December 28, I was driving from Chico, CA back home to Morgan Hill, CA and the car shook and just died and left me on the side of Highway 505 Winters/San Francisco. I had it towed to Moorehead Automotive in Fairfield, CA and they said this car needs a new engine. I still owe 7,000.00 on this car and have had trouble with both Hyundai and Power (the additional insurance I purchased when i bought this car.)

The contact owns a 2015 Hyundai Veloster. The contact stated that while driving at an undisclosed speed, the vehicle hesitated. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic who performed a tune-up on the vehicle. The contact stated that several days after the tune-up, the failure reoccurred. The contact stated that while the vehicle was stopped at a traffic light, the vehicle hesitated and sounded as if the vehicle was going to stall. The vehicle was taken back to the independent mechanic, who diagnosed that the engine was losing pressure and needed to be replaced. The vehicle was not repaired due to the cost. The contact stated that before the vehicle had the tune-up, the engine was consuming an excessive amount of engine oil. The contact had not noticed any oil stains on the ground. The check engine light was occasionally illuminated. The manufacturer was not made aware of the failure. The failure mileage was approximately 72,000.

The contact owns a 2015 Hyundai Veloster. The contact reported that oil was leaking out of the exhaust. The vehicle was sputtering and running rough while driving at various speeds, and hesitated while accelerating. The check engine warning light was illuminated. The vehicle was taken to the dealer, who was unable to diagnose the failure. The dealer informed the contact that metal shavings were found in the oil pan during the oil change. The contact stated that the Oxygen sensors and catalytic converter were replaced; however, the failure persisted. The vehicle was contacted and advised the contact to return the vehicle to the dealer. The manufacturer was not informed of the failure. The failure mileage was unknown.

Excessive engine oil consumption causing fouled spark plugs engine stalling. Engine was replace due to defective rod bearings at 98 000 mile under warranty and recall. Engine now ha 130,000 miles piston rings have failed. Stalled on busy freeway almost causing mutual crash.I have an appointment at the Hyundai delership October 28th 2015. Hyundai replaced one defective engine with another.

The contact owns a 2015 Hyundai Veloster. The contact stated that the vehicle was taken to a local dealer for a recall repair; however, after leaving the dealer, while driving approximately 30-40 MPH, the vehicle stalled. The vehicle failed to shift into gear. The vehicle sat for two hours before being restarted and slowly driven to the place of employment, and was then driven to the residence. The contact was unable to determine if there were any warning lights illuminated. The contact called the dealer and was provided with information for towing services and a diagnostic test. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 176,000.

ABS, EPS, check engine light appeared on dashboard then car’s steering wheel stiffed and car lost power. Vehicle’s hood smells burnt and has fumes come out after driving for 10-20minutes. My safety and my family’s was endangered as this happened while driving on the road. Not at a stop sign or a red traffic light but while driving. The dealer has refused to inspect/address the issue without having me paid close to $2,500.00 for other repairs.

The climate control switch melted. Available for inspection I was getting smoked out by plastic fumes. Researched this issues with all data No No lights.

Motor started knocking yesterday 4/8/25 which was immediately followed by multiple dash sensors for oil and battery. As I pulled over to get assistance at a Jiffy Lube, the car stalled and wasn’t drivable but they also confirmed that the car should not be driven for risk of blowing the engine. Will be taking my vehicle in for an evaluation as soon as I am able to get it towed for further inspection and diagnostics.

Spun rod bearings. Noticed that was the issue with play in piston doing a screwdriver test and noticing thru under the oil pan before tear down. Had to pry the bearing off with pliers and hit with a screwdriver to remove. I have plenty of photos and videos

I HAVE A RECALL ON THE HYUNDAI 2015 VELOSTER FOR FOUR YEARS SINCE THE LAWSUIT THAT YOU TOLD HYUNDAI CORP TO PUT LIFETIME WARRANTY ON DEFECTIVE CARS THGEY HAVE DONE NOTHING TO RESOLVE THE PROBLEM. MY CAR AGAIN IS BROKE DOWN TO OIL AROUND SPARKPLUGS I WENT THROUGH THE SAME PROBLEM IN OCT 2023 WHICH THEY PUT A GASKET ON IT AND CHARGE ME 505.00 DOLLARS. NOW THEY ARE MAKING IT HARD TO FIND A ENGINE TO REPLACED THE MANUFACTURED DEFECT ENGINE IN IT. DEBRIS IN CRANKSHAFT AND THEN SOLD WHICH CAUSE THE CONNECTING ROD PROBLEM PREMATURE. I NEED MY CAR AND CAN'T AFFORD ANOTHER PLEASE HELP ME GET THIS RESOLVE

Spontaneous rod knocking, hindered performance which in tern poor acceleration, which could become a safety risk especially when commuting on a freeway. High risk of motor vehicle accidents or could lead to a fatal incident if left stranded on major roadways and railroad crossings.

My car 2015 Hyundia Veloster has been under recall since 2021 for connecting rod failure in engine and oil leaking around spark plugs that could cause a fire plus what the other recall is. Hyundai Corp refuses to repair my car, it has ksds, oil consumption, refuse to do engine inspection, wanting to charge me for items related to a recall. my car as stated with you before eating oil, poor compression stalls knock loses power i recently had to pay 3200.00 for catalytic converters so i would have a car only to find out it could happen again due to recall number198. i need someone to help me get this resolve. why should have to replace my engine when it under recall and you can't sell your car due to that? i have been fighting Hyundai Corp for two years i had oil around my spark plugs in 2023, black spark plugs 2024

The contact owns a 2015 Hyundai Veloster. The contact stated that while driving at an undisclosed speed, there was an abnormal knocking sound and smoke coming from the engine compartment. The vehicle then lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle was able to be restarted. An unknown warning light was flashing before the vehicle had lost power; however, there were no warning lights illuminated once the vehicle was restarted. The vehicle was taken to the dealer, who was unable to duplicate the failure and had not provided the contact with a specific diagnostic report. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 20V746000 (Engine), but the VIN was not included. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 44,000.

I HAVE BEEN TRYING FOR OVER A YEAR TO GET MY ENGINE REPLACED IT IS RECALL AND NO DEALER SHIP IN MACON GA OR MILLEDEGVILLE GA HAS DONE NOTHING BUT CHARGE ME UN NECESSARY MONEY. THE FIRST THING OIL CONSUMPTION, STALLS WHEN GOING OUT IN THE ROAD, LOST OF COMPRESSION, CLOGG MY CATALYTIC CONVERTERS WHICH COST ME 3200.00 WHICH I WAS TOLD IS GOING TO HAPPEN AGAIN WITH THE FAIL ENGINE. THE OTHER VISITS WERE AT DEALSHIP TOO OIL IN SPARK PLUGS STALLING OUT LUCKY TO GET IT HOME THAT TIME OCT 2023 AT MILLEDEGVILLE HYUNDAI THE OTHER TIME THERE ENGINE LIGHT CAME ON GASKET REPLACED AGAIN BLACK SPARK PLUGS 505.00 AND 405.00 ADDITIONAL MONEY CAN YOU PLEASE HELP ME . MY CAR IS STILL STALLING, NO COMPRESSION,OIL CONSUMPTION NUMBER 198

AC Fan control switch has melted and filled car with smoke. Fan control switch has overheated. The switch has melted and will not work at all.

The Hvac heater control assembly and panel shorted out and melted all the components (wiring harness, connector, temperature control knob). All these parts need replaced. There's no AC, heat or defrost, etc...until this is fixed. Also this is a 16 year old drivers vehicle and could have resulted in a much worse incident if she had been driving it when it occurred.

Nothing has been done for the recall engine, Hyundai recall 198 which states damage engine can increase the risk of fire or engine stall increasing the risk of a crash. why is Hyundai selling cars that are recall for engines . as stated before oil consumption, jerks, no compression, going up hills is rough, cabin gets warmer than usual Hyundai Corp told me that the clogged catalytic converters were no cause by engine failure is this correct i have to pay for them. i have the recall for the brakes finally making a appt can you help me my engine is getting worse i'm afraid to drive it.

My car is recall for connecting rod bearing failure hyundai gave us a extended warranty for this 15 years or 150,00 miles plus i have 20 year 200,00 mile warranty too my engine has oil consumption a quart every 2- 3 weeks been in the Hyundai shop October 2023 for oil around spark plugs jerking engine trying to stall i had my car tow they did a tune up charge me for towing and spark plugs said it was part of engine failure. next in 04/24 engine light came on compression has been getting worse over two years car tow was told catalytic converters were clogged which is not covered so there another bill on me which i think at 124 plus mileage was due to engine problems but Hyundai Corp denied this of course. They want me to drive the car until the engine light flashes in middle of nowhere all i want is my recall engine fixed so i will feel safe in my car there was a lawsuit on the connecting rod bearing failure RECENTLY nothing has been done i can't afford another car at my age

The connection to my AC control knob burned up and my AC only works between 2 & 3. This could have easily caused a fire as the connection and the knob are melted and burned. How has there not been a recall for this issue as there are many complaints that have been reported on this issue. This is a safety hazard!

On 06/252024 I was driving on my way home and my cars climate control were unresponsive and I smelt something burning. I arrived home removed the center console of my vehicle and noticed the AC control plug had melted and was burnt.

Problem with car engine has been recall for several years, brakes have been recall for 2-3 years now my emissions are mess up from recall engine which now i do not have a car to drive, being a heart patient, veteran, it is hard without one and i can't afford a new one i have done all Maintenace and everything on my end to keep it going. engine eats oil, loses compression on road knocking had in shop twice still no fixing the problems my engine light is on i have been told by dealer my car can catch on fire from brakes and engine getting hot in the cabin jerks tried to cut out on me several times afraid to drive it anymore. hyundai is putting everything off until it blows us up i guess. can you help me? i wrote to hyundai corp and sent contacts through the computer no response back wiper doesnt work or gps all broke in it, never use the back wiper but once,also clogged catalytic converters confirm by hyundai dealership

I noticed the engine was losing oil constantly and the exhaust was emitting black smoke often, I had to refill the oil about once a month, eventually the car broke down and took it to a Hyundai dealership. They said they needed to perform a leakdown/compression test on the car, and $585 to perform a diagnostic. Then they said the leak down/compression test showed the exhaust valves had broken and they would need to do a long block replacement. Also mentioned they needed to have Hyundai allow them to release that long block as it is part of a recall on other vehicles. Later was told Hyundai did not approve it under the warranty.

The contact owns a 2015 Hyundai Veloster. The contact stated while driving at undisclosed speeds, the vehicle started to decelerate independently, and there was a ticking sound coming from the engine. The contact discovered NHTSA Campaign Number: 20V746000 (Engine). The vehicle was towed to the dealer; however, the failure could not be duplicated. The recall repair was not performed. The manufacturer was not made aware of the issue. The failure mileage was approximately 135,000.

This has happened on 4 different occasions. I'm on the highway and my speedometer slams to zero and everything involving the brakes lights up in my dash. The car continues to drive but it's pretty worrisome as I drive 70mph around alot of traffic. I have been able to pull over every time but it's still beyond unacceptable. I've had my Veloster a little under a year and I don't know if the other recall involving the motor being replaced was taken care of. It was a recall associated with my VIN. I have a video of it happening but for some reason I try to upload it on the app and it won't allow me to. It is the proper format.

The safety recall on my vehicle has been open for nearly 7 months with a risk of fire. There is still no status as to when my vehicle can be serviced to prevent this risk of fire. I find this lack of urgency completely unacceptable considering the risk.

I was on the highway and looked at my speedometer and the mph was at 0. The abs and the brake light warnings came on and I couldn't accelerate and hardly brake. I pulled to the shoulder immediately. Took a couple hundred feet to finally stop. It was a very scary moment thinking my brakes have gone. I put it in park waited a moment turned it off... waited about 5 mins and it turned over just wanted to get it home

15 Warranty repairs with less than 60K mileage that were discovered for the vehicle’s history. To date I have replaced: Catalytic Converter (Discovered this is a common issue with the vehicle) Infotainment Front Struts Rear Shocks Motor mounts Driver Side window motor (Previously repaired by Hyundai Replaced by Hyundai 1/7/2020 at 56k miles, malfunction a 2nd time) Windshield Wiper Motor (Previously repaired by Hyundai Replaced by Hyundai 10/7/2019 at 54K miles, malfunction a 2nd time) a/c motor blower Oxygen Sensor Fuel Injectors (common issue) Driver Side/Passenger Side control arms Windshield Wiper hoses due to dry rot All 4 ignition coils Battery Leads

The contact called on behalf of his girlfriend who owns a 2015 Hyundai Veloster. The contact stated while his girlfriend was driving approximately 60 MPH, the check engine warning light illuminated. The contact stated that the vehicle decelerated independently, and the driver pulled over to the side of the road and turned off the vehicle. The vehicle was restarted and driven to an independent mechanic and was diagnosed with engine failure. The vehicle was taken to an unknown dealer where it was diagnosed with engine failure. The vehicle was not repaired. The contact stated that the failure was related to an unknown NHTSA Campaign Number related to the engine. The manufacturer was contacted and confirmed that the VIN was not included in the unknown recall. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 130,000.

Engine runs too lean had T/B and104898 MAss airflow and O2 sensors replaced less than a year ago still same problem also consuming too much oil,

Vehicle blows fuses when plugging multiple items also burns up items such as car heater (plug in one) and other devices.

The contact owns a 2015 Hyundai Veloster. The contact stated that while driving at various speeds, the engine temperature increased, and the check engine warning light illuminated before the engine failed and the vehicle stalled. The vehicle was later driven to the local dealer who diagnosed that the head gasket was faulty and needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was taken back to the dealer who diagnosed and determined that the catalytic converter was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact stated that the engine was previously replaced under a Manufacturer Service Campaign. The failure mileage was 129,000.

The contact owns a 2015 Hyundai Veloster. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

HVAC system has failed twice, upon inspecting, connections are melted. This is a fire RISK. Fuses constantly blow. Check engine light constantly comes on and after having auto zone diagnose, issues include Power Train System (P2261), anti-lock brake system - Wheel Speed Sensor (all 4) show invalid/No Signal. Constant knocking noise under the engine which related to the Rod bearing recall. This car is a FIRE and SAFETY HAZARD waiting to happen. My outlets barely produce power, my lights flicker constantly, my battery has been replaced multiple times, as well as the HVAC once.

HVAC system wiring is melted, only works intermittently between knob #3-4. check engine light comes off and on for Wheel Speed Sensor (all 4) Invalid/No Signal. Fuses consistently blow. Multiple complains have been made by other 2015 Hyundai Veloster Turbo owners. In addition to these issues being a HUGE fire risk, there was a new fire risk safety recall issued in sept 2023 with no resolution. Hyundais only current resolution for this is to “park away from structures in the meantime”, and will send a letter out once resolved. The HVAC system has been replaced once prior.

The car I bought in February in a used car lot was, per the salesperson, in excellent condition, had recently done oil changes, and had allegedly no failures. After less than 3k miles, I got stalled on the freeway with a knocking noise; Frank Hyundai mechanics diagnosed it with a CVV oil sensor red flag. I then paid for the repairs after getting denied from both my Hyundai warranty and my extended warranty. This was neglect when I drove that car for just a few months, like a weekend car, less than 3k miles. The car was still stalling on the freeway, shooting smoke, and the check engine light came on. I miraculously made it in one piece to work; however, the car had to be towed back to Frank Hyundai, where, to this day, they still have not been able to repair or precisely diagnose my vehicle, so I have been without my vehicle for almost a month and a half. I'm pretty sure I'm not the only one with this problem; I think it's unfair to pay for the past owner's negligence.

I bought this vehicle from a used car lot in February 2023, not 2022, and drove it under 3k miles; when I took it, it had 86k miles, and the check engine light came on. I took it to FRANK HYUNDAI, where, to this day, have not been able to help me; all this time, I, the consumer, had to chase down the repair guy assigned to my car and, only to be vaguely told it was sludge and metal shedding. It might be my misuse or neglect when I had driven the damn thing before even recommended servicing or an oil change was needed. I also called Hyundai Motors corporate, where a case manager suggested a goodwill repair, but nothing had been done. I would appreciate any help NHTSA could provide as there are campaigns on this model car with engine rod failures, and the damn extended warranty should apply to subsequent owners.

Engine blinking and smell burnt while driving, ABS button turn on automatically

The contact owns a 2015 Hyundai Veloster. The contact stated while driving at slower speeds and depressing the brake pedal, it seemed the ABS engaged, and the vehicle slowed down significantly. Additionally, the brakes were dragging. The contact stated that upon depressing the brake pedal again, the vehicle operated as needed. The contact stated that the failure occurred intermittently. The check engine warning light was illuminated. Additionally, the contact stated that the brake pads had shown premature wear and tear. The vehicle was taken to the dealer, where the brake calipers, rotors, and brake pads were replaced; however, the failure recurred after 4,500 miles driven. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 12,500

My cars lights (headlights, gage cluster lights, dash lights, radio screen light, etc..) and screen for my radio and back up camera, all turn off by themselves, for maybe 1 second or 2, while driving. This happens randomly, no warning, no special conditions, just out of nowhere, and for no reasons. Since I bought the car in September of 2020 (used, as is) it has done it now 7 or 8 times, with tonight being the most recent occurrence. I don't know how to have it checked or verified by a technician because there's no forewarning before it happens. It's completely random and unexpected. It's very scary, especially with my children in the car.

Engine had no oil, starting making a knocking noise.

Engine failure outside of normal warranty period. However oil consumption is the cause. Hyundai allows for 1quart of oil loss every 1000 miles. There should be no oil loss. Before I could get an oil consumption test my motor started knocking. The dealership was supposed ask for goodwill assistance but never did. They found no compression in cylinder 4 and stated since it wasn’t a rod bearing failure they would not cover it. Also they are using third party BBB to turn down complaints which should be a violation of the consumers rights. They are paid by Hyundai to reject claims.

99% sure the vehicle’s rod bearing is what is knocking

The car was repaired at a Hyundai dealership less than a month prior to the incident. I was driving down a road with no one around besides me and my passenger when all of a sudden Orange sparks start flying out the sides of the car, I slow down and pull over as fast as I could, then I noticed fire on the passenger side and hurried us out the car. It proceeded to burn away until the firefighters came.

Rattling noise is occurring when accelerating and on cold start. This has been occurring for quite some time.

Rod bearing in the fourth piston is failing and there is an existing TSB for this problem on this year (2015) of Veloster however Hyundai is saying that it doesn't cover this engine model so we are going to be out $7,000 for a new engine. Seems like the engine is the same only difference is the turbo so seems like this model should be part of the TSB as well. The problem has been confirmed by a mechanic at his shop C&C automotive in Fayetteville AR