2017 Hyundai Tucson complaints

Under 40,000 took vehicle in to check because of hesitation when accelerating. They checked and could not duplicate issue so sent me on my way. Reached 70,000 and hesitation is worse. Getting and merging on highway, turning from stop, and feels like it’s going to stall when going up inclines. No incident yet just notifying maybe something wrong with other peoples.

The rear driver's side door will not open, neither with the remote nor manually from both the inside and outside. Without enabling rear passengers to exit the car during an emergency is very much a safety issue. No warning lamps or messages.

I was driving on [XXX] and the acceleration just started to drastically slow down. I was able to get to the shoulder where the car completely died and wouldn’t cut back on and I had it towed to South Bay Hyundai in Torrance. They said it’s engine failure but they haven’t completed the full inspection yet. I have been using Uber and need a car rental because I can’t afford to sustain this huge inconvenience indefinitely. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

All of the lights on the dashboard and check engines light were illuminated. The speedometer would not work and the stick shift would stick in park causing me to have to release the shift lock manually to drive. The failure mileage was 59,450.

My transmission has failed fully. It cannot even reverse. I took my car into Hyundai several times to check on the issue and they said the same thing, that the transmission slipping is a standard issue for dual clutch. I told them over and over that this is different. I did some research as to how to have them cover it and have it changed but the dealership said nothings wrong. Fast forward and now my cars transmission is fully gone and it probably won’t be covered when I know that it should have been part of the recall ! Just this year I’ve spent $5000 on repairs for this vehicle and now I’m looking at another $5000 for only a 7 year old vehicle. If that does not constitute a lemon I don’t know what does.

Car is using an abnormally large amount of oil. I reported to Hyundai. They sent me to a Hyundai dealership for an Oil Consumption Test. They confirmed that I do not have an oil leak under the automobile. The dealer is telling me “it’s completely NORMAL TO BURN THROUGH 1 QUART OF OIL FOR EVERY 1,000 MILES”. That would leave my automobile with only two quarts of oil after driving 3,000 miles. The owner’s manual does not state any of this. Now I am paying a significant amount of money on Oil Consumption Tests of which they are telling me I might need several before they MIGHT fix the problem. This 2017 Hyundai Tucson is one of the models and years affected.

The engine developed a knocking sound at 97,018 miles. When it was checked, it did not have any oil in it at all, regardless of there not being an oil leak in the system. The car received regular service. When we took it to Hyundai they did a test and confirmed that it was burning oil. This engine malfunction put my [XXX] daughter, the primary driver, at risk for engine failure while driving it. The engine light and knocking sound happened with no warning. Yes, the problem was confirmed by the Reed Hyundai of Kansas City. They told us that the car needs a new engine and that they bear no responsibility for the malfunction. The engine lights and sounds happened simultaneously. The vehicle was immediately stopped and towed to the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car suddenly stopped accelerating. There were no signs that something was wrong prior. I was driving on the highway when I felt a loss of power, then my check engine light started blinking. The car entered “limp mode” and the engine started knocking. The code it was showing was for a knock sensor, I replaced that and it still would not accelerate. There is something wrong with the rod bearings and I was told by the dealership that this is a common problem with the type of engine they use in these vehicles.

In August 2024, the engine of the vehicle suddenly started making a very loud knocking noise, with no previous warning lights. We did not feel it was safe to drive. We saw online that a recall was underway by Hyundai for 2017 Tucsons due to problems with the rod bearings, where metal spreads throughout the engine. There is the potential for the engine to catch fire, and a complete engine replacement is recommended. This was confirmed by the dealership where we bought the vehicle, Boucher Hyundai of Waukesha, which told us they are replacing the engines in many of these vehicles. However, our VIN was not included in the recall, although the problem is identical to what is described in the recall. We had the car towed to the dealership; after confirming the problem, the dealership filed a claim with Hyundai seeking to add our VIN to the recall. We included all of the maintenance records since we bought the vehicle in January 2021 with 64K miles. Hyundai rejected the claim, citing a gap in the maintenance records from 64,000-124,000 miles. The dealership questioned that, since they had submitted our maintenance records and there were no gaps. Hyundai again denied the claim, citing a gap in the maintenance records from 17,000-29,000 miles - before we owned the vehicle. We called Hyundai customer service seeking an explanation; they said that the decision is made by Hyundai Motor America, a different entity, which only the dealership can contact, not vehicle owners. The customer s

The contact owns a 2017 Hyundai Tucson. The contact stated while driving at an undisclosed speed, the vehicle stalled with no warning light illuminated. The contact did not have to restart the vehicle. The vehicle was taken to the dealer where it was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 80,964.

Engine light notification was not present before, during or after the complete engine failure of the vehicle while driving. Per dealership, they are unable to find a replacement motor and are going to rebuild the engine.

Rear driver side door suddenly will not open from outside or inside. A rear passenger would be essentially trapped in the car should an incident/accident happen. I googled and it seems this is a well known issue affecting several model years of Hyundai, including my 2017 model. I do not see a recall for this extremely dangerous issue.

I change the oil every 2000 miles and use what it states. Second oil change that noticed the oil drained out of the vehicle was close to nothing. First of all no warning indication oil was that low. It vibrates when it’s still and when you accelerate it tugs. Took it to the dealership where purchased extended warranty. Temporary fix is combustion cleaning with re seat piston rings then a valve cleaning and pcv replacement. Permanent solution replace the engine which warranty won’t cover since it’s technically not broken. Charging me ridiculous amount money for temporary fix. What if the oil goes else where or doesn’t notified low oil. It can catch on fire or all of sudden stops. I have my two babies with me in the car always it’s our family car. Vehicle has been inspected by dealership not inspected by police insurance representatives or others. No indication no warning signs pop up of low oil. It’s consuming too much oil which it’s going to other places in the engine which can cause fire risk. I’m trying to prevent the engine cause a fire or risk to myself or my family.

The engineer lost all oil and immediately started making a knocking noise.

Unable to open passenger door on driver side. Unable to open from the outside or the inside.

Automobile is consuming a huge amount of oil. The vehicle does not have an oil leak.

Was driving down highway and vehicle lost power and shut off. Brought car to mechanic shop they ran a diagnostic and tore down the engine to see what the problem was. They found the problem was with oil consumption and carbon buildup. Oil was leaking through the pistons,piston rings into the combustion chamber, which in part was causing oil to go through the exhaust system. They found oil in the exhaust pipes and the catalytic converter and the exhaust manifold. The catalytic converter had to be replaced because it was clogged with all the oil that was leaking through the exhaust system from the combustion chamber. They found carbon buildup on the pistons, the piston rings and inside the combustion chamber

The contact owned a 2017 Hyundai Tucson. The contact stated that the vehicle was unoccupied and parked at the residence for a couple of days, he received a call from a neighbor informing that there was a fire at his residence. The contact was not home at the time and upon arrival, he observed the vehicle engulfed in flames. The fire then quickly spread from the vehicle to the stand-alone garage and driveway causing damage. The contact and a neighbor attempted to extinguish the fire but were unsuccessful. The fire department extinguished the fire. A police report was filed. The vehicle was towed by the insurance company to the salvage lot where a forensic specialist was pending an investigation per the manufacturer and was yet to produce any information. The contact mentioned that the vehicle burned leaving only the framing remains. The manufacturer was notified of the failure. The failure mileage was approximately 110,000.

Paint is peeling off of the door handles, the roof, and the mirrors. There is no reason for a 2017 to have this issue. It started 6 months after I bought the car in 2022. I called them Hyundai customer center with no help.

The contact owns a 2017 Hyundai Tucson. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle was taken to an independent mechanic where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The dealer was contacted and made aware of the failure. The contact was informed of NHTSA Campaign Number: 21V727000 (Engine); however, the contact was informed that the VIN was not associated with the recall. The vehicle was scheduled for an upcoming diagnostic test. The contact stated that the vehicle was taken to the dealer in 2023 due to the failure; however, the contact was informed that the repair was not covered under recall or unknown programs. The contact stated that he was advised to keep up with scheduled maintenance on the vehicle. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

The engine appears to have a malfunction, particularly related to acceleration and oil consumption. The vehicle is available for inspection upon request. The vehicle experiences sudden jerking during acceleration, which can lead to loss of control and increase the risk of a collision. Additionally, stalling can occur unexpectedly, posing a significant hazard, especially in traffic. Yes, the issue has been confirmed by a local dealership, where they noted the jerking during acceleration and the high oil consumption. Yes, the vehicle has been inspected by the dealership, but it has not been inspected by the manufacturer or insurance representatives. There were no warning lamps or messages prior to the incidents. The symptoms first appeared approximately 8 months ago and is ongoing.

I reported a problem with my engine to the Clay Cooley Hyundai dealership (Mesquite) in April 2022. I told them that my oil was burning a lot faster than normal. My car was currently under warranty at the time, which would have covered a new engine replacement. The dealership instructed me to do “oil consumption” tests and had me come in every 1000 miles to see if there were any oil leaks. Once I completed the tests, they told me to do another round of testing, which I thought was odd. I ended up doing tests from April-October 2022, and by the time I was finished my warranty expired. They said that my engine was fine and good to drive. I took my car to the same dealership in August 2024 with the same issue and that my engine wasn’t accelerating. They are now telling that there is a problem with my engine and charging me a new one for $10k. It would've been covered under my warranty in 2022, but they had me drive over the warranty limit so that a new engine wouldn’t be covered anymore. After doing research, there was a Class Action lawsuit about the engine for my vehicle. The problem is damage to the engine’s connecting rod bearings. You could hear a knocking sound from my engine. This issue has been happening from 2022-2024. I had to do oil changes more frequently. After consulting with a local auto care shop, they said it was a manufacturing problem. Hyundai put me back on the road with an unsafe car. The engine should have been fixed back in 2022. Hyundai Corporate is only

The engine started to lose power and then completely died the engine and oil lights came on the car would restart for about 30 sec but would not move when put into drive it broke down on [XXX] extremely dangerous road road with traffic moving above 55 mph I was broke down in the center lane after I called a tow truck and placed a call to the WSP in fear of getting killed on this road this caused extreme anxiety and loss of wages due to this trauma This is the 3rd time this same vehicle broke down The first time I had it towed to the dealership in Bellingham WA where they said it was a cracked spark plug ? And charged $650 to replace still under warranty the 2nd time this vehicle broke down I towed to a certified mechanic it was a burnt valve the repair cost was $4000 and didn't appear to fix the engine knocking noise and was hesitant a short lived band side for a faulty engine that Hyundai did not include this model in class action lawsuit same engine as other recalled motors but they left this car out because they sold so many INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Hyundai Tucson. The contact stated that while his girlfriend was driving approximately 50 MPH, the engine started knocking, and the vehicle stalled. The contact stated that several unknown warning lights were illuminated. The contact stated that the engine was consuming one quart of oil every week. The vehicle was towed to an independent mechanic who determined that the engine was blown. The vehicle was towed to the local dealer, where it was diagnosed that the drive belt was frayed, the crank pulley was deteriorating, and that there was a misfire in cylinder #4. The catalytic convertor DTC code: P0240 was displayed, the exhaust was burned, and there was excessive oil consumption. The manufacturer was contacted, and the contact was informed that there was no warranty coverage on the vehicle. There was no assistance provided. The failure mileage was approximately 100,000.

The engine is consuming extreme amounts of oil. 1-2 quarts a week. The oil light does not alert that oil is low and could cause a very dangerous situation. My car was running and just stopped while driving because oil had coated the spark plugs. Hyundai refused to honor my warranty. They want the car for 6 months to put new motor and only after I pay $1000 for a cleaning when they even admitted it was a known problem and I should "try to sell the car as fast as possible and not mention the oil consumption" I've continued trying to get them to correct this since November 2023

My engine in 2023 was burning oil excessively, which caused my CAT to become clogged. I was unable to drive the vehicle and had to have both replaced by Hyundai. I paid partial for the CAT. A year later now in 2024, this “new” engine is doing the same and my new CAT is clogged again. I had to add oil continuously. Now they are refusing to fix anything

On [XXX] my daughter was driving in Meridian Ms and when she was at a red light the 2017 Hyundai Tuscon that she was driving started shaking and all the lights on the dashboard came on and she couldn't drive because it wouldn't move. She called a tow truck to have it taken to Firestone. When they looked at it, they said the reading was spark plugs and fuel injectors that needed to be replaced. After they did that, the car still would not work. We paid 1300.00 dollars for them to do this. We then had it towed to Hyundai in Flowood Ms. We learned that the whole engine needs to be replaced. We Take very good care of our cars and this shouldnt be happening. I see that there is an extended warranty for 2017 tucsons with engine failures, but our particular engine is not included in this. We have a turbo 1.6. I asked Hyundai why these particular motors are not included and they didnt know. I found alot of people are having the same engine issues as I am and i think Hyundai needs to help me out. The replacement cost of this is going to be about $10000.00 dollars. My car only has 84000.00 miles on it. Hyundai knows that there are problems with these vehicles but refuse to be any help what so ever. I just dont understand why my engine isn't included in their 150000.00 mile warranty. I dont know where else to turn for help. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine began to sputter then immediately shut down as I was driving. After parking safely, there were traces of metal in the oil & the oil was a milky color. Ran the code and it came up as an issue with the rod bearings.

Took my 2017 Hyundai Tucson 1.6t engine into the service center on 8/21 for a check engine light and Bluelink notification of "A possible condition with your Engine Control System has been detected" that came on Sunday 8/18. Service center diagnosed P0326 ($159.00) From the service center: We have pulled code P0326 for an issue with the knock sensor readings. The vehicle can sue an oil change as is due and there is a gasket leak which sounds like it is from turbo or manifold gasket which is causing that rattling noise you're hearing. Below is the three itemized recommendations for this vehicle. 1) Knock sensor replacement -$635 +taxes installed 2) Oil change recommended $ 85 +taxes 3) Turbo gasket replacement $205 + taxes installed. I bought my car in 2020 and only have 53,000miles on it and was told it's out of warranty so this isn't covered - even though the 2017 Tucson's are recalled/warranty for life for engine issues for the same exact reasons mine was brought in for. This is my second hyundai, which I have always loved; however, I am disappointed in the quality of car not being up to standard due to manufacturing, and I am paying the price for it. The10yr/100k mile and 5yr/60k mile warranty advertising is misleading and deceiving. If I could go back, I wouldn't have bought a hyundai

Engine Failure cause by failed connecting rod bearing. Engine will need to be fully replaced to correct failure.

Engine Failure cause by failed connecting rod bearing. Engine will need to be fully replaced to correct failure. SAME ISSUE AS RECALL 21V-727: Connecting Rod bearing inside the engine may wear prematurely, resulting in internal engine damage. Please help :-(

The contact owns a 2017 Hyundai Tucson. The contact stated that while at a complete stop, the vehicle hesitated and sputtered upon the depression of the accelerator pedal. Upon inspection of the engine compartment, the contact discovered that the oil level was low. The vehicle was taken to a dealer where the contact was initially informed that the failure was normal with similar vehicles. The contact stated that the failure persisted, and the vehicle failed to start with the oil warning light illuminated. The contact checked the oil level, and the oil was full. The vehicle eventually started with the check engine and air bag warning lights illuminated. The vehicle was taken back to the dealer where the vehicle was diagnosed with engine failure. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 120,000.

After I have to various amounts of weight in the rear of the vehicle, the vehicle rattles in the rear. Trying to stop said vehicle is very unstable. The left front of the vehicle dips when brakes are applied. And the rear of said vehicle makes a lot of noise.

Check engine light came on after regular maintainer of car and a new timing belt was put on. Engine is making knocking noise and running not smooth at all. Car burns oils at a very high rate and is almost out of oil at 3,000 miles when I am told typical cars like this should last close to 5000 miles. Again I am getting regular maintenance and oil changes. Car had a little over 100,000 miles and 1 previous owner.

The contact owns a 2017 Hyundai Tucson. The contact stated that while driving at various speeds, the vehicle had suddenly decelerated and would not properly accelerate. Upon inspection, the contact discovered that the engine oil level was extremely low due to excessive oil consumption. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 149,000.

The vehicle has 83,000 miles. It burns through 10 quarts of oil per 5,000 miles. No oil or check engine light comes on. Twice It has been dry when having the oil changed. Additionally, the vehicle suddenly started to jerk and misfire, the check engine light came on. I was within a block of my home and was able to return home. This would have been extremely dangerous in traffic. I have changed the coils and plugs, but it continues to hesitate and run unevenly, just like so many other reports.

The problem began in mid to late April 2024 with the Tucson shuddering in the driveway while moving forward slowly. This vehicle has a 1.6L turbo with a dual clutch transmission. The mileage was around 96,000 miles. Once on the road, it ran fine. Approximately a month later the check engine light came on and it began hesitating upon acceleration. It would change to the next gear, accelerate and slam me against the seat! Whenever I try to accelerate too fast, it hesitates and loses power until it "catches" and starts speeding up. This is very dangerous especially when accelerating from a complete stop or after a turn. It also has trouble going up a hill and has actually died out 3 times while attempting to go uphill at a low speed. I am the second owner and it is out of warranty. I have contacted the local Hyundai dealer but their shop does not have a very good reputation and is always backed up for 3+ weeks. They also charge $230 or more to hook up their code reader!! I've already taken it to 2 other shops where that was done at no charge. The code was P073F - Unable to engage gear 1. Of course the only option I've been given is to replace the transmission for $3000 or have it rebuilt for $4100. This problem makes it very dangerous to continue driving it. I get the oil changed every 5000 miles. Of course it's almost paid for but I'm afraid if I try to trade it in I'll be lucky to even get enough to pay it off. I have been endlessly researching this online for recalls, updates

See attached document for complaint

I am not a mechanic, but I know that my engine consumes 5-8 quarts of oil every 3000 miles. In addition to the engine oil consumption problem, I have noticed a severe burning smell in my car cabin, especially on takeoff, but it lingers. Unfortunately, I have to breathe this in every time I drive my car, and it is making my headaches much worse. I have taken my car to a private mechanic's shop, and the mechanic noticed the problem during two previous oil changes. I have not yet taken my car to the police or insurance company. There have been no warning messages or lights illuminated on the dashboard.

I purchased a 2017 Hyundai Tucson with a 1.6L Turbo GDI engine. After just one month, the engine developed bearing damage. It seems that this problem is common with this type of engine. Does Hyundai have a recall for this engine model?

The contact owns a 2017 Hyundai Tucson. The contact stated while driving uphill and depressing the accelerator pedal, the vehicle hesitated to accelerate. There were no warning lights illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and offered to cover 95% of the repair costs; however, the contact declined. The failure mileage was approximately 83,287.

The vehicle had 30,000 miles when purchased and has 62,0000 now using half a quart to quart of oil every thousand miles.

In June of 2023 at around 79,000 miles. I was driving on the highway and had a sudden loss in acceleration and would not go above 65 mph. During the inspection, the dealership ran the vehicle through 3 tests of oil consumption and it failed 2 out of 3 which did not result in a replacement of the oil pan system. My car continues to burn through oil at an increased rate (every 3000 miles). I know because the dip stick is completely dry when checking it. In July of 2024 at around 84,000 miles, while driving on the interstate, I experienced a loss in acceleration again. My Tucson would not accelerate over 65mph. I took it into the dealership and they found that my catalytic converter needed to be replaced. The replacement was estimated to cost around $5000. For each incident, there were no warning lamps that illuminated on the dash. The oil light did not come on nor did the engine light come on.

While driving home from work, my engine all of sudden started making a loud knocking noise sounded like you were going up a roller coaster. The oil light started flickering and then the engine light came on. I honestly didn't know if I was going to make it home due to the noise and the car was shaking while driving. I had to have it towed to the dealership. The dealership confirmed the engine needs replaced. I can't even get a new engine anywhere because no one can order one or find one in stock new. I feel it is a safety issue because the engine could have failed on the highway while driving putting myself and others at risk of an accident or maybe even death.

While driving home from a doctors appointment my engine all of sudden started making a loud knocking noise, the oil light flickered on and off and the check engine light came on. I honestly wasn't sure if I would make it home with the loud noise the engine was making and the car was starting to shake while driving. I did have it towed to the dealership (I have 2 2017 Tucsons both currently at the dealership with blown engines under 60000 miles) and they confirmed the engine needed replaced. I feel this is a safety concern because the engine could have failed while driving putting myself and others at risk of an accident or maybe even death.

As I was driving my 2017 Hyundai Tuscan to work, my vehicle would not accelerate when I pressed the accelerator. The engine would not function properly leaving me in the middle of moving traffic. I was able to pull off the main road to a safe place. My insurance company (Geico) sent an assessor out 7/22/24 who noted a blown engine due to a prematurely worn connecting rod bearing for which there is a noted recall on this particular vehicle model.

UNKNOWN the white paint is peeling off of my car causing it to rust the dealership took pictures and inspected it and started a good will claim and said it should be fixed under that and then came back a month later and said hyundai has now canceled all of there goodwill claims for paint repair

Constantly have to get oil changes. Initially when I would be due for another oil change, the mechanic mentions there is no oil. I started to come sooner than the due date and mileage and same issue. Oil is burning quickly. Car is stuttering and jerky on acceleration, but my car is not apart of that recall. The car headlights continues to change on it on and filters through the light settings on it’s on at random times.

The contact owns a 2017 Hyundai Tucson. The contact stated while driving at an undisclosed speed, the vehicle was shaking abnormally with an unknown warning light illuminated. The contact stated that the failure occurred while driving uphill. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 94,500.

The contact owns a 2017 Hyundai Tucson. The contact stated while starting the vehicle, there was a loud knocking sound coming from the engine. There was no warning light illuminated. The contact also became aware that the vehicle was consuming an excessive amount of engine oil. The vehicle was taken to the dealer and was diagnosed with engine failure. The contact was informed that the engine needed to be repaired. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 102,000.