2017 Hyundai Tucson complaints

No compression in one of the cylinders, oil blow by, oil consumption approx 1 quart per 1000 miles. Now has developed a serious miss in cylinders 2 and 4 and is undrivable.

I was driving home from the store a short distance from my home. The check engine light came on, the car ran rough, lost power and would not accelerate. I was able to get home. My husband checked the oil; it was 2 quarts low. He previously changed the oil 3000 miles prior. He connected a code reader and it read "DCT 1326". I drove slowly on the berm of the road & able to get home. Had I been on an interstate, my life could have been endangered. Top speed a rough 30-40 mph. After my internet search it appears that oil consumption and engine loss is a common problem. My car has less than 60K miles. No prior history and oil changed every 5K miles.I am very upset about the lack of responsibility on Hyundai's part. This is our 3rd Hyundai and we were loyal customers. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Oil consumption issues upon oil change no oil registered at all. It was confirmed no leaking and was advised to contact due to recall on this motor using oil. Also advised to request request a motor replacement due to this vehicle already showing signs of this issue to assure it doesn’t lock up.

My car became disabled due to engine failure on the highway. My vehicle is no longer drivable. My warning lights did not come on prior to the incident.

Sole owner of 2017 Hyundai Tucson with approx 55,700k miles. Check engine light on and car not accelerating properly. Had same acceleration problem a year ago without engine light, Hyundai dealership stated I needed software update on anti judder gds, update was completed by Hyundai and the issue has reoccurred.

The engine is failing. Our vehicle continues to experience tremendous oil consumption and it's all of a sudden gone into "limp mode" where we lose engine power even after the knock sensor recall update was performed. No check engine lights, no indication of what's happening and it just loses power on the highway as well as city streets. It's a danger to everyone around us and it's a danger for us as we try to drive the vehicle. The dealer / Hyundai had us do 2 oil consumption tests but would not do anything to fix the issue. They informed us they needed to replace the engine after the first oil consumption but then they backed off of that and didn't fix the issue. It’s just gotten worse. We also had a transmission service done and they said the transmission looked fine. We took it in for a diagnostic just after this as the power issue began in "limp mode" where we lose engine power. They are trying to say it needs a new transmission but with the known issues with the Hyundai oil consumption and engine issues where the vehicles go into power loss / limp mode, we’re reporting this issue for our safety and the safety of the community as it’s unsafe to drive this care. We hope you will push Hyundai to do a recall for the engine not just for us but for all Hyundai Owners who are dealing with the same issue.

Engine experienced a catastrophic failure. Driving (normal commute) and clicking noise start coming from the engine. Got louder over a short time, but no dash waring lights came on. Further along the check engine light came, and when it started flashing I pulled over and called for roadside assistance (tow). No other warning lights came on. Engine temp read normal throughout. After the dealer service team reviewed, said the engine block was cracked and metal noted in the oil and filter. I contacted Hyundai USA to see if they would cover engine replacement. After a few days of review and back and forth with the dealer, they declined any claim. Dealer service rep quoted us approx $20k for engine replacement. We opted to sell to salvage company and now need to buy another car. Just over 66,000 miles and complete loss.

Car is burning oil. Oil change done at 3k and no oil in vehicle at all. Transmission shakes violently on start up and first movement and slips shifting gears. No response sometimes when pressing gas pedal to go

Car went into limp mode on the highway because of high oil consumption. Car came to a complete stop.

While driving down the interstate the vehicle would not accelerate and the RPMs were fluctuating. We were luckily near an exit and were able to pull into a gas station. The check engine light came on. Once we parked the engine stalled and we were not able to restart. We had the vehicle towed to a AAA certified mechanic, they stated there was no oil and that the engine needed to be replaced. We did not receive any low oil indicators for the vehicle. We had the vehicle flat bed towed back to our home town where a 2nd mechanic indicated that there was still some oil in the vehicle but that the engine would need to be replaced. The VIN for this car shows no engine recall but this appears to be the same issue that has resulted in Hyundai engine recall with the 2.0 vehicles.

The contact owns a 2017 Hyundai Tucson. The contact stated while driving at an undisclosed speed uphill, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine oil warning light was illuminated. The vehicle hesitated, and the contact pulled over to the side of the road. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that there was oil leaking from the exhaust pipe. The contact related the failure to NHTSA Campaign Number: 21V727000 (Engine); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 117,000.

The contact owns a 2017 Hyundai Tucson. The contact stated while driving at an undisclosed speed, the vehicle failed to accelerate as intended while the accelerator pedal was depressed. The check engine and check engine oil warning lights were illuminated. The vehicle was taken to a local service shop where it was diagnosed with engine knock. The contact was informed that the engine needed to be replaced. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 21V727000 (Engine); however, the VIN was not included. The vehicle was towed to a local dealer, where it was diagnosed and determined that the engine needed to be replaced due to the knocking coming from the engine. The local dealer advised the contact that parts for the repair were not available. The manufacturer was made aware of the failure. The failure mileage was approximately 104,000.

I had my oil changed at a Hyundai dealership at 102,000 miles however even before the next oil change was due my engine had a bearing failure. The dealership could not fix my car for months and that I should find another Hyundai dealership to fix the issue. The next dealership told me that the cost was $14000k to fix and that the engine had oil sludge buildup. My Carfax report is shows consistent and provable oil maintenance every 3K - 4K miles. The engine had been consuming oil which I report to the dealership but sine there was not any check engine light they did not do anything about the consumption problem. I have not yet had the vehicle inspected by independent mechanic or anyone else. no warning lights ever came on that alerted me to low oil.

A knocking noise from the engine. The dealership is refusing to give us a warranty for the rebuilt of the engine that we will be covering 40% of the cost. Is this possible? For us to spend approximately $7K and not get a warranty on the work done?

See attached document for complaint.

There is metal shards in the oil from the engine. The oil burns up within a week or so. The guy at the oil change place said it was common in these make and model cars and I need a new engine. It can stall or catch fire which can pose a risk to me and/or other cars on the road. I drive around with a [XXX] son it's my daily car and the engine is not good. We are constantly having to put oil in it. Other vehicles from this company have been recalled for the same issue. Please have it inspected and fixed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine failed at 137,000 miles. The vehicle is available for inspection. The engine failed while driving with no warning lights, or indications that anything was wrong. It started with a knock that gradually got worse and worse over the course of 5 miles. Once it shut down it failed to ever restart again. Te vehicle was inspected by a Manufacturer Dealership, they did not give me specific insights as to what caused the engine to fail other than that there was no oil present in the engine at the time of inspection. However I have every oil change receipt, documenting regular, on time oil changes.

The contact owns a 2017 Hyundai Tucson. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact was topping off the oil weekly. The failure had become more persistent. While driving 65 MPH, the vehicle started shaking and was making a knocking sound at the front-end by the engine compartment. The check engine warning light was flashing. The contact coasted to the side of the road and checked the oil level. The oil level was low, and the contact added oil to the vehicle. The contact restarted the vehicle, and the vehicle began shaking, making a knocking sound from the front end, and there was white smoke coming from underneath the hood of the vehicle. The vehicle was turned off, the smoke ceased, and the vehicle was left parked in the parking lot at work. The dealer was not contacted. The manufacturer was not informed of the failure. The failure mileage was 100,000.

Since reaching approximately 79,000 miles on my vehicle (which I am the original owner of), I have noticed excessive oil consumption. Over the course of 3,000 miles between oil changes, the vehicle consumed about 4 quarts of oil, and the oil lamp came on. Additionally, I consistently experience the smell of burning oil inside the cabin whenever I back in or out of parking spaces/my garage, which poses a health risk. Beyond the health concerns, there are potential consequences, including engine damage, fire risks, reduced performance, and with that, an increased likelihood of accidents. While Hyundai acknowledges that this is a known issue, they have done little to offer a proper solution, merely attempting to keep the consumption within barely acceptable limits. Thank you for taking note of this problem.

My 2017 Hyundai tucson is consumeing oil at a steady rate. Took it to dealership roughly year to do oil consumption test. They said my headgasket, turbo, and pil pan was all leaking. They replaced those parts before starting oil consumption test would be performed. $3,300 later still consuming roughly 1 quart per 500 miles. It faild the oil consumption test and i was advised to do a combustion chamber cleaning next. $700 later and im burning 1 quart roughly every 1k miles. Took it back to them and said thats normal and it is fixed. I'm very concerned considering no car should burn that much oil in between 3k oil changes and only holds 5 quarts of oil. I also have 2 young children and wife that regularly drive the car and it's sluggish when getting on the gas like entering the highway and I'm worried the engine may just go out of nowhere. My local dealership doesn't really care nor does corporate. This is my last ditch effort to get something done. I know I and many, many, many, others are also dealing with this and something needs done soon. Thank you for your time.

My car has been burning oil for over a year. there is no leak. I have been putting three quarts in every 4 to 6 weeks. I have now replaced two coil packs and the spark plugs. my engine light is on because it said 3 and 4 was misfiring so i recently replaced those coil packs and now it said spark plug and i replaced it again as well. so the engine light coming on and what it says the problem is is wrong. now when i push the gas it is knocking or missing. not sure how to describe it. no one has looked at it other than a friend that is a mechanic and he says its probably the engine because this kind of car has these problems.

Excessive oil consumption, engine started knocking, dealer confirmed needs engine replacement which is covered under ONLY original 1st owner and NOT subsequent owner. Hyundai refuses help. Have not been able to drive my Tucson for a year. Still paying monthly payments and insurance

The contact owns a 2017 Hyundai Tucson. The contact stated while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. The contact stated that the oil light was flashing on the instrument panel while turning the steering wheel. The vehicle was taken to an independent mechanic where the contact was informed that the vehicle was consuming an excessive amount of oil. The vehicle was taken to a dealer for an oil consumption test and the oil was topped off. The contact was instructed to bring the vehicle back after 1,000 miles. Upon investigation, the contact discovered that the engine oil consumption failure was widely reported. The vehicle was taken back to the dealer as instructed, and the contact was informed that the engine had not consumed enough oil to be considered a defect. The contact was advised to purchase a factory-made oil filter from the dealer because the independent mechanic had not used the proper oil filter on the oil change. The contact stated that at the follow-up oil change, the independent mechanic used the factory oil filter; however, the failure persisted. The manufacturer was notified of the failure and the contact was informed that the vehicle was not under recall or warranty. The vehicle remained with the independent mechanic unrepaired. The failure mileage was approximately 98,000.

RIGHT REAR PASSENGER DOOR WILL NOT OPEN WHEN ACTUATING HANDLES INSIDE OR OUTSIDE THE VEHICLE. UNABLE TO REMOVE CHILD OR ALLOW PASSANGERS SAFE EXIT OF VEHICLE. IF YOU PULL THE HANDLES TWICE OR SIX TIMES IT WILL SOMETIMES OPEN. INTERMITTANT ISSUE, ACUATORS ALL APPEAR TO WORK AND BE IN GOOD CONDITION.

My vehicle began experiencing issues around 83,000 miles. The engine started burning oil, showed shuddering during acceleration, and there was a noticeable smell of gasoline inside the cabin. Eventually, the car wouldn’t start, so I had it towed to the dealership. The technicians confirmed it was running rough and behaving abnormally. The Hyundai dealership conducted a full inspection and diagnosed several issues. They replaced the spark plugs, performed a GDI-safe induction cleaning, replaced the coolant and brake fluids, completed a transmission fluid service, installed a new battery, carried out wheel alignments, and changed the cabin air filter. All of this work was completed in October 2024. However, in December 2024, I had to return to the dealership because the fuel smell inside the cabin persisted. Although they couldn’t find the source of the issue, the smell eventually disappeared after the visit. Following that, I was advised to check my oil every 3,000 miles due to the GDI engine's reputation for burning oil quickly. Despite this, the car began running rough again, and when I checked the oil, it was completely dry—well before reaching the 3,000-mile mark. I had to get another oil change sooner than expected. Unfortunately, the issue continued. I brought the vehicle back to the dealership for another inspection. They suggested starting a monitoring process where I would bring the car in every 1,000 miles to check the oil levels. After driving 1,000 miles, the oil l

My car is experiencing trouble accelerating, making it difficult to drive. Every time I come to a complete stop at a stop sign, my car struggles to regain speed. This issue becomes particularly dangerous on the expressway, as I can’t accelerate at a decent speed to merge onto the expressway, which poses a risk to both me and other drivers.

Car would not accelerate after getting on the interstate. Had to ease vehicle off exit ramp to side of road. Multiple engine lights on. Car would no longer start. Had independent mechanic shop evaluate as well as local Hyundai dealership. Both determined internal compression rod failure. Only solution is to replace engine. It is a 1.6L T for 2017 Tucson. The VIN for this car shows no engine recall but is the exact same issue that has resulted in Hyundai engine recall with the 2.0 vehicles.

Despite proper maintenance, at 100k miles the engine started knocking aggressively and the dealership advised me not to drive it or it would throw a rod in the very near future. It started burning oil around 80k miles. This is the Limited model with the gamma engine that was not included in the recalls of the other Tuscon engine, but seems to have the same problem.

My harmonic balancer went bad after 120,000 miles causing my camshaft pully to shear off and a bolt to come loose causing me to have to replace my entire engine. I was told by my mechanic that this is a very rare occurring issue. Could this have happened because of a faulty harmonic balancer?

The engine entered limp mode, lost oil pressure and began knocking. Vehicle was brought to a dealer where it remained for ~1 month. The dealer inspected the vehicle, and determined it to be a valve cover leak, which does not track given the issues. When picked up from the dealer, the engine seized shortly down the road. Upon my own inspection, it was found that the engine oil drain plug was missing. It is unclear if the dealer loosened the drain plug during their inspection, or if it fell out due to some other issue. In either case, the manufacturer and their representative (dealership) created a dangerous situation for the driver of that vehicle, which had to be pushed out of moving traffic during a busy time of day.

Structure issue, white paint is peeling off in chunks on hood, roof, and doors. There is a paint recall involving other hyundai vehicles of the same year and color. I am tired of having exposed unprotected metal being to rust and ruin the integrity of the part.

1. After driving the car and turning it off, I get a loud bang coming from a gas tank. 2. Sometimes when making a hard right or left turn steering wheel vibrates, and the warning light for all wheel drive system comes on. When I turn the car off and restart it, it goes away. 3. After software installs due to recalls, when I accelerate my radio occasionally shuts off on its own, and then we’ll come back on on its own. 4. After turning the car off when I restart it occasionally the clock in calendar revert to 00:00 for the time and the date resets to 1/1/20.

Within last oil change the engine had oil consumption and has a loud engine knocking sound. The upcoming oil change date had not been exceeded and/or miles had not been exceeded. The engine knock caused me to pull over immediately at a location on a highly traveled road and no shoulder or safe spot which was dangerous. Safety was a concern because I had to wait for a tow truck in cold winter weather. The local Hyundai dealership maintenance person said it was a known issue with that make and model and the repair wait time is 5 months because they don't have enough staff and cannot get parts. My tuscan just had an inspection at the last oil change on 10/22/2024. no report from Hyundai that the oil level was an issue or engine having problems. There not any warning lights or low level lights and/or noises until it suddenly happened.

Engine knocking began around 132,000 miles and caused intermittent loss of power while driving. This caused me to slow down at random intervals while on the roadway becoming a hazard for other drivers. Engine light activated shortly before the symptoms began. No inspections done yet.

Massive engine failure on well maintained vehicle. Vehicle has been inspected by two mechanics, one private and one dealership. Both recommend engine replacement.

KSDS system continuously going off saying the knock sensor needs to be replaced and puts the car in limp mode. The car continuously going into limp mode even after knock sensor is replaced.

So in December of 2022 the vehicle above was recalled for Service Campaign 966 by hyundai and was completed. In 2024 it had the same issues again and the knock sensor was replaced twice in 2024. We just purchased the vehicle in January 2025 and know are having the same issuse and code showing the knock sensor is having issues. We reported it to the dealer we purchased from long hyundai of chattanooga and they aren't helping to resolve the issue. All they did before we bought it was say it had a weak battery and supposedly replaced the battery.

The contact owns a 2017 Hyundai Tucson. The contact stated that several months after purchasing the vehicle, the vehicle was shaking abnormally while started. There was no warning light illuminated. The vehicle was taken to a dealer to be diagnosed. The contact was informed that there was an abnormal amount of carbon build up on the valves and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 90,000.

The transmission in my vehicle failed while driving and the car completely shut off while driving. Less than 4 months after replacing the transmission with a brand new transmission, the engine failed while driving on the highway. The engine started sputtering, then it started smoking, then the car stalled.

Greetings, I have had issues with the Hyundai Tucson 2017 I own for many months. Issues include among others an abnormal knocking noise from the engine, reduced engine power and/or hesitation, burning smell, oil leaking, and smoke coming out of the engine, misfires, and other issues. It happened many times on the highway and almost caused accidents and the last time it happened, the vehicle was towed, and recently the smoke coming from the engine forced me to pull over. I reported the issue to the dealer but they didn't recall or address the issue. The car has been maintained properly over time and now I fear for my life. It is totally unfair that about 100k of this brand have been recalled for the same issue, in my case it is just after I finished to pay in full the vehicle. I seek your support to have it addressed for safety

There is an intermittent problem with the transmission. It’s impossible to predict when the transmission will slip. When navigating traffic, it has happened multiple times trying to pull out across oncoming traffic, and the transmission begins slipping so badly in a couple of instances nearly causing a side impact. There are no recalls related to this, but the dealership confirms it is common… the fact that it is intermittent makes it worse. You get used to the transmission performing as it should… Next thing you know it slips when you can’t afford for it to slip..

I am constantly having to add oil to my car. It burns oil. It is not leaking oil. I have 81000 miles on my car. I get my oil changed regularly.

I was using the access road to get on the highway but when I tried to accelerate the car was slow to accelerate and I almost got hit by other cars. I don’t know what happened but now I have a steady check engine light. When I called a mechanic he said I have a TSB from 2021 for the Dual Clutch but I didn’t see anything for this and my SaferCar app doesn’t mentions it either.

My check engine light randomly started blinking and lost power. While driving

My car hesitates when leaving a stop sign or light. It is random and I have no power to continue. If I put car in park than go sometimes it works, sometimes push down on gas more or sometimes I have to turn car off than back on. 2 near miss accidents

The contact owns a 2017 Hyundai Tucson. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the failure persisted. The battery warning light was illuminated. The vehicle was towed to an independent mechanic, who was unable to duplicate the failure. The vehicle was not repaired. The vehicle was then towed to the dealer, who diagnosed a failure with the spark plugs. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V727000 (Engine); but the VIN was not included. The failure mileage was 86,000.

I am writing to report a serious issue with my 2017 Hyundai Tucson SEL 2.0 that poses potential safety risks. The vehicle is consuming more than 4 quarts of oil every 1,000 miles, which is far beyond normal and acceptable levels. The car has approximately 166,000 miles on it and has been regularly maintained, including timely oil changes. Despite proper maintenance, this excessive oil consumption leads to frequent low-oil warnings, risking sudden engine failure if not continuously monitored. This creates an unsafe driving condition, particularly on highways or during long trips, as the engine could seize without warning. Additionally, I am aware that many other owners of Hyundai vehicles with similar engines have reported comparable issues. This suggests a widespread defect in the engine design or manufacturing process. I am requesting the NHTSA to investigate this matter further to determine if a recall, warranty extension, or other corrective action is necessary to address this issue. Hyundai should be held accountable for resolving this problem, especially since it compromises the safety and reliability of the vehicle. Vehicle Information: Year: 2017 Make: Hyundai Model: Tucson SEL Engine: 2.0L VIN: [Your Vehicle Identification Number here] Thank you for your attention to this matter. I hope for a prompt investigation and resolution to ensure the safety of all Hyundai Tucson owners.

The contact owns a 2017 Hyundai Tucson. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact stated that the oil level was extremely low. The contact added oil and stated that frequent oil changes were needed. There was no indication of an oil leak. While driving over a bridge, the vehicle failed to accelerate over 25 MPH. The check engine and oil warning lights were illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 21V727000 (Engine). The vehicle was taken to an independent mechanic, who determined that oil was being burned by the piston rings. The vehicle was taken to the local dealer, who performed an oil consumption test. The dealer informed the contact that there was an oil leak. The vehicle then failed to start. The vehicle was not repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 70,000.

2017 Tucson no engine light came on no oil gauge light came on.Never received engine recall notice but engine rod bearing rubbing .Car is now Un drivable as it needs new engine

See attached document for complaint.