2016 Hyundai Tucson complaints

The contact owns a 2016 Hyundai Tucson. The contact stated that on three separate occasions, the window regulator for the front driver’s, front passenger’s, and rear driver’s side windows failed to operate as designed. The contact also stated that once the window regulators failed, the window would slide down independently while driving. The vehicle was taken to the dealer after each failure and the window regulators were replaced out of pocket. The manufacturer was notified of the failure, but no assistance was provided. The vehicle was also out of warranty. The failure mileage was approximately 28,000. The contact has had all 4 window motors replaced as well as purchased an extended warranty for the vehicle. The contact has notified by Hyundai that other Tucson owners were experiencing the same issues.

Window regulators failing on all windows. Drivers side is stuck open and will not close. All others are stuck closed and will not go down.

The contact owns a 2016 Hyundai Tucson. The contact stated while driving 70 MPH, the vehicle decelerated without warning. The contact stated that after several seconds the vehicle continued to operate normally. The vehicle was taken to the dealer to be diagnosed; however, the mechanic was unable to determine the cause of the failure. The failure persisted. The manufacturer was not contacted. The failure mileage was 2,400.

The contact owns a 2016 Hyundai Tucson. The contact stated while driving at 30 MPH, the vehicle began to stall and he saw smoke coming out from underneath the hood of the vehicle. Several unknown warning lights were illuminated. The contact veered to the side of the road and quickly exited the vehicle. The contact waited several minutes. The contact stated that upon opening the hood of the vehicle, he saw flames. The contact was able to extinguish the fire by shutting the hood closed. The contact stated that in the process of exiting the vehicle, he bumped his knee and twisted his ankle and received care from his caregiver. The vehicle was towed to the dealer where it was diagnosed that the engine needed to be replaced. The engine was replaced under an unknown recall. However, the contact stated that after the repair, the vehicle was experiencing rough starts and the engine was misfiring while driving. The vehicle was taken to a second dealer, Ron Tonkin Hyundai (675 NE Burnside Rd, Gresham, OR 97030), where it was diagnosed that the cylinder was misfiring. The dealer replaced the fuel injector, the spark plugs, and the cylinder head, and completed an oil change. However, the engine was knocking upon starting the vehicle. The dealer informed the contact that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and advised the contact that he would need to pay an Engine Control Unit (ECU) repair fee. The failure mileage w

Driver-side rear door fails to open from the inside or the outside. Currently, the passenger seated on that side of the vehicle has to enter and exit the vehicle using the door on the opposite side, which can easily be a safety issue. Thankfully, we have not been in an emergency incident or car accident where someone has had to use that door to get out of the car in a hurry. The failure to unlock the door and open seems to stem from an actuator mechanism that is faulty. (The same issue/complaint has been mentioned by other owners, including failure of more than one door latch, e.g. https://www.hyundai-forums.com/threads/help-16-tucson-limited-intermittent-door-unlock-fob-issue.690557/#post-6162832; https://www.carproblemzoo.com/hyundai/tucson/door-latch-problems.php, ) I contacted the local Hyundai dealer about this issue and was only able to get an appointment two months out (which will be tomorrow)! I will have more details regarding the repair associated with this issue after my appointment. But it seems like this should be a safety related recall given the potential danger of being trapped in a vehicle in the event of an emergency or an accident.

The window regulator spool has melted on all 4 windows. This vehicle has less than 65000 miles and this should not be an issue. This is a safety issue. We have read hundreds of comments online of the same issue.

On Oct. 14, 2022 I had to take my car in to repair/replace front passenger side window regulator. The window no longer would go up and down. $807.51. Yesterday, Oct. 20 my driver's side front window failed. Another $807 repair. I am a senior citizen (woman) on a fixed income also experiencing recent Ian hurricane damage and repairs. Am I to expect the rest of the windows to fail? Do I have some recourse with Hyundai?

Passenger Front door will not open from exterior upon unlocking. Can only open door from inside vehicle by reaching over and releasing inside lever.

Car suddenly lost significant acceleration power in normal conditions. According to Hyundai dealer inspection, the rod bearing failed and pressure in the engine was lost. Safety risk was causing an accident because of loss of power. No accident occurred due to being so close to the right shoulder. This would have been far more dangerous if this was on a 6-7 lane highway causing major accidents due to being an obstacle to normal traffic flow. No warning lights or lamps were displayed before incident.

Window stuck in down position - forums full of this defect with repairs costing $500+ per window; windows protect you from weather and debris and when stuck up or down present a safety hazard.

Rear passenger door became unable to be opened. Started out as only a some times issue, but the door can no longer be opened at all. I had a previous car, same year, make, and model that had the same thing happen to both rear passenger doors. Both times it happened the car was still under warranty so I did not have to pay to fix it. That car was totaled and now I have this one. This car is no longer under warranty now though. So this is the 3rd time this problem has happened between 2 cars that I have had that are the same year, make, and model

I have taken my car in to dealership a few times over the last couple years,Complaining about excessive oil burning and loss of power.The last time,The dealership told me the catalyc converter was clogged.I had it repaired but asked Dealership,If engine doesnt get repaired itll happen again.they told me its fine and engine was fine.Well,It isn't fine and went and spoke to a few auto repair shops and they told me if car is under warranty,Car needs to go back to dealershipto have engine looked at and repaired..I feel I'm definitely getting the run-around.I can not keep replacing a catalyc converter every year and the problem not being fixed.the situation of losing power while driving is putting myself and family at risk.this is very concerning and life threatening.Im still well within my warranty and feel unsafe and ripped off.

Car is burning engine oil at the rate of one quart a week after normal city driving. Usual and frquent oil changes and almost dry when going in for every 3000 miles oil change. Took to a private (non-Hyndai) mechanic shop Christian brothers in Colorado and told that perhaps that my car had some engine damage or problems due to burn of engine oil and not leaking. Next car began to have engine check light go on and off with never staying on for more than one day. Called Hyundai dealership and told that light had to be on solid and complete for inspection. This week car starting misfiring and dragging when acclerating. Black smoke coming out of exhaust and check engine light illuminated and stayed on. Could not get into delaership until November of 2022 and currently September of 2022. Once again took car to Christian Brothers for diagnostics and told car was full of carbon and misfiring and told unsafe to drive and would not work on car as they believed that engine was damaged/defective and needed to be replaced. Made appointment with PLanet Hyundai in Golden, Colorado where I purchased the car brand new. October 20th is my appointment and car will need to be towed. Undriveable and needing car to work to see my autistic clients in their homes. Final event with engine and misfiring happened at 104,000 just past the warranty time even though no one would look at the car despite my former complaints and concerns prior to the warranty expiration.

Last June at about 82k miles my car started making a knocking noise while in town. Decided to drive the short distance home and right as I pulled in the driveway the engine light flashed briefly but didn't stay on. First thing I did was check the oil and there was no oil in the engine at all. Called all around to dealers and since this was in the middle of the pandemic it was a nightmare and I had to wait like 4 weeks and get the car towed twice to a shop that had the shortest wait. The car had regular oil changes and wasn't overdue for an oil change. There was no oil spots that would suggest it had been leaking and zero smoke to show it was burning off the engine at any time, there also was no check oil light that came on at any time to warn that the oil was low. I wasn't able to be provided a loaner until they could diagnose the vehicle and confirm it wasn't my negligence. Turns out this is a regular issue with this model/engine. I can't imagine what it would have been like had I been driving 70mph down the freeway. Now the engine is at 101k miles and it came with only a 10k 12 month warranty and it is now going through a quart of oil every 1k miles it seems. Have an appointment AGAIN to have it looked at in but not until the first of November. So now I have to check my oil all the time to make sure it doesn't run dry again...

Window motors, modules and regulators go out frequently (shortly after warranty ends). This usually happens one window after another in short time & is a very costly fix of $500+ per window.

Window regulators inoperative on front left window and passenger window on 2016 Hyundai Tucson with only 23,635 miles. Windows remained in down position creating a dangerous driving condition. Prior to this, windows were only opened occasionally for drive up banking or pharmacy drive up.

My 2016 Hyundai Tuscon 1.6 liter Turbo threw a rod when I was driving home. All service lights turned on and we pulled over immediately just in time for the car to shut off completely. We had to push the car into a parking spot and saw that all of the oil had fallen out of the bottom. I have approximately 113k miles on the car. I have been religious with my service and maintenance. It was late at night and we were on a 2 lane levy road. Thank goodness the second the lights came on we were in front of 1 of the 2 spots in a 9 mile stretch to pull off. This was extremely scary and dangerous. We had the car towed to the nearest shop where they inspected it and let me know that they have seen several other Hyundai's come through with the same issue and they directed me to take it to the closest Hyundai Dealership so they could take care of it. It has been at Dublin Hyundai where they looked it over and neglected to cover the issue. It is still there now. Dublin Hyundai confirmed that I do need a new motor. They said that they will not cover it due to "Extreme Neglect" due to the Car Fax report. I am currently seeking out the rest of my maintenance records that were not reported. There are a total of 10 oil changes over the course of the past 5 years not reported but that have most definitely been done. There were no symptoms of this problem prior to the failure. This is my third Hyundai in a row and I have never had any issues prior. I have always been a happy Hyundai owner until

Three out of the four window regulators quit working over a two year period not all at once. The window motor and regulator still work, they just strip at the gear to lift them.

The Vehicle is a 2016 Hyundai Limited 1.6 Turbo. Back around the first part of May, we were driving down the interstate when the vehicle lost power, the check engine light came on, and the engine began to vibrate. The engine is also burning oil. There were no warning signs prior to the incident and the lights did not come on until the incident occurred. We took it to a dealership and they did a compression test. I was told, I would need a new engine. There has since been a recall on Hyundai engines, having the same issues mine has, but they did not include my vehicle in the recall. The 1.6 Turbo engine that my vehicle has, seems to be the same engine as the Hyundai Veloster which has been recalled. They also included the 2017 Hyundai Tucson in this recall. The vehicle in its current state is not safe to drive as it loses power while you are driving. This vehicle is available for inspection upon request.

The main power switch to the power windows is not operating properly. After extensive research into the problem I have noticed this is a frequent issue on the 2016 Hyundai Tucson. A severe thunderstorm had started and when I tried to put the passenger side rear window up it would not work. Now the front passenger window is doing the same thing. The individual switches work but not the main switch on the driverside door. It brings the window down but will not go back up. I have to use the actual window switch on that door to raise them back up. I have not been to the dealer yet about this issue but feel there needs to be a recall for this item as 100's of other owners are complaining of the same issue on Hynudai forum sites. The 2016 Hyundai Tucson model has been the center of several other recalls and I feel this needs to be addressed as soon as possible.

Driver Door and right rear door are having issues opening. Unable to open right rear passenger door at all which is a safety concern. Hyundai dealer stated nothing was wrong when I first reported the front door handle issues

The contact owns a 2016 Hyundai Tucson. The contact stated while driving approximately 35 MPH, the RPM increased; however, the vehicle failed to respond. There was no warning light illuminated. There was an update performed on the transmission control module before; however, the failure reoccurred. The vehicle was taken to the dealer for diagnostic testing; however, the mechanic was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact related the failure to NHTSA Campaign Number: 16V628000 (Power Train, Electrical System) however, the VIN was not included. The approximate failure mileage was 5,000.

Regulators and motor breaking in all windows without use. I can’t get a safety inspection with them not working. Many complaints on the internet. If I can’t get a safety inspection, this should constitute a recall.

My engine started stalling on me and has loss of power then out of nowhere I started getting a knocking noise which was followed by a check engine light. I had a oil light flashing before this occurred but oil level was good. Changed oil and filter and noise persisted along with stalling making it hard to drive anywhere safely. I haven't had it taken anywhere because I see this is a known issue on hyundai vehicles and newer models have recalls out on them. My vehicle only has 38,000 miles and shouldn't be having engine issues already.

Vacuum pump was recalled back in 2019 - T3C: TL Tucson Vacuum Pump (19-01-010H). My car was “repaired” to fix the seal/cap. However, today the vacuum pump needs to be replaced. The engine light, brake assist and traction control lights all came on and stayed on. After talking with Hyundai it appears as though back when the recall occurred, the minimum was repaired and proper replacement of the part was not taken. Hyundai says they are no longer required to remedy the problem because they already addressed the recall back in 2019. Is there any action enforceable to take toward Hyundai to honor a complete repair of the recall rather than just slap a band-aid on it?

Both the rear driver side and rear passenger side door lock actuators have failed, making it impossible to open either door from inside or outside the vehicle. This is very dangerous in general, but especially young children are in the backseat.

While back out of my driveway in my 2016 hyundai tucson, it suddenly accelerated on its own out of control rendering me helpless and just along for the ride. Finally stopped while in reverse the car went across the street crashing violently into my neighbors boat and engine was still reving until I shut it off after the crash. Both my car and neighbors boat had major damage.

On multiple occasions the transmission failed to engage at slow speed then lunges forward when it does. it happens when your at a stop accelerate slowly to about 10 mph get off the accelerator then re-apply it. the engine revs but the transmission acts like it goes into neutral then catches a gear and lunges forward. It is unsafe because the driver behind you can hit you from behind, which almost happened to me, or you can hit the car in front of you when it lunges or worst hit a pedestrian because of the unpredictability of the transmission/ engine power engagement. The so called fix was a software issue that didn't fix it. mine still has it and when i told the dealer they said they couldn't duplicate the problem BUT it has happened so many times to me that i can make it fail. Hyundai should be accountable for this but no one ever listens to the consumer until its to late. it asks below when it happened but it started shortly after i purchased the car and happened multiple times. but the one i absolutely remember was when i had my daughters in the car right after my daughters birthday.

I have a 2016 hundai Tucson limited 1.6 l turbo and have had a lot of problems with this car when I merge on a highway I put the foot on the gas and the car doesn’t move even though I have the foot to the floor and when I’m in stop and go traffic the car jerks like it wants to stall I brought the car to the dealership and told them what the problem is they could not duplicate my issue and they said there is nothing wrong with it and also they didn’t find any codes on the computer, next week I’m bringing my car back to the dealership for the same problem and I bet that they are not going to find any problems again. I’ve been driving over 45 years and never had this problem with any other car’s that I have owned, I’m afraid that one of this days I’m going to get hit from behind. I hope that the manufacture puts a recall on these cars soon, I’m ready to sell my car and never ever buy another Hyundai again.

Rear passenger door suddenly would not open from either the inside or outside. My child was in the car, and I could not get him out for some time. This was a safety concern even without an accident or emergency, and creates a potentially fatal situation if there is an accident or fire where a child would need to be retrieved from the vehicle. From internet searches, this is not an isolated incident, and should be addressed by the manufacturer. As a note, this is in addition to, and distinct from, the known issue of the front doors wearing out and not opening from the outside.

2 separate issues - oil is being consumed at alarming rate- not burning off and not leaking just disappearing at a rate of a quart every 200 miles -brake pedal is vibrating and clicking up while breaking, then goes straight to floor causing driver to release brake and then repress while stopping

Rear drivers side door latch stopped working unprovoked. The door was working fine and was parked for the night. The next morning the rear drivers side door would not open from inside or outside upon unlocking doors. This is a safety concern due to the fact that in the event of an accident emergency services would have a difficult time accessing the rear passenger area of the vehicle delaying any medical attention that would possibly be needed in the event of an accident.

Right Rear Tail Light Wiring Harness has short. Since right turn single bulb replaced twice, Passenger side rear door window stripped the Teflon Gear on door Interior panel and door handle is not operational! Since problem started, passenger door handle and window is non Operational, Drivers side door and Window is Not Operational! 2016 Hyundai Tucson with 31,000 miles! Dealership, Billingsley Hyundai and Ford refuse to repair saying it’s out Of Warrenty February’22! Vehicle has an electrical short and has had since 2019 when Right Turn Signal bulb continues to burn out!

I have made multiple complaints to Jenkins Hyundai of leesburg about my car hesitating and not going like it should and almost causing multiple accidents because it wouldn’t go when it should. However, they stated nothing was out of the ordinary and to just drive it in sport mode. Well I’m December of 2020, the turbo went out while driving home. They then wouldn’t fix it until I had a friend state that her dad worked at a diff location and that it was covered under warranty. They told me they had to do an investigation to see if it was covered under warranty or not. They kept my car for a few weeks before I got a phone call on New Year’s Eve stating my car was ready for pick up. Meanwhile, there was an active recall with the brakes from September of 2020, that they in fact did not fix while having my vehicle there. Fast forward to June 9, 2022, and my turbo went out again and there is water mixed with the oil in my car. I have made multiple reports along with others on the transmission issues and now making a report on the turbo. These vehicles are not safe, I don’t understand why they have not been recalled for these issues.

Door locks do not unlock. Cannot get out of the car from inside and cannot get in to the car from the outside.

I have a 2016 hyundai tucson and now that the vehicle is almost paid for, i am having issue with the blinker. when i put the let or right blinker on it stops blinking, also, my car smells like something is burning. i take good care of my car, i do routine maintenance on it when it is require, i have regular oil changes. i am taking to a hyundai shop this weekend

While driving the car started making a clicking noise. Then shortly after the noise started, the car would no accelerate over 40mph. Once pulled over after this, we discovered that there was no oil in the engine. There have been no signs of oil loss and we also get our cars oil changed regularly and we were towards the end and already had an oil changed scheduled. There were also no warring lights that ever became illuminated while this all happened so we had no idea of the issues until the car was already seizing up. This seems to be a common issue with 2016 Hyundai Tucson’s

Rear driver side door will not open from the inside or outside while unlocked.

My car would not accelerate over 20mph took into dealership in 5/2021 with 75,000 miles I was told I needed a new Catalyst converter I replaced it. My oil started leaking in 10/2021 was told my oil pan gasket needed resealed I completed it. In April of 2022 I was recommended to get oil pan gasket resealed still. In July of 2022 my car slows down then stop on expressway. It starts back up I’m only able to go 20m0ph on the expressway this is not safe at alll with my children in the car it was very scary. Dealership finally has an appointment 8/9 diagnoses car 8/11 stating my Catalyst Converter is clogged and need replacement that caused my car to stop and slow down as well as I need oil pan gasket burning oil/leaking oil. This is a safety problem the car is not 10yrs old and has less than 100,00 miles to stop without warning lightsss or anything on a moving fast expressway could have caused me and my kids life. This issue need to be taken serious and inspected because I continue to have the same issues with the car a little over a year!!

The contact owns a 2016 Hyundai Tucson. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed but the vehicle hesitated to respond while the RPM gauge was at 5000 RPM. Additionally, the vehicle emitted an abnormally loud sound and there was smoke coming from underneath the hood. The contact veered to the side of the road and noticed a trail of coolant and oil leak on the highway. The vehicle was towed to the contact's residence. The vehicle was not diagnosed or repaired. The dealer and the manufacturer were not made aware of the failure. The failure mileage was approximately 133,000.

My car seemed to be lagging severely when accelerating and then started coughing when accelerating and the check oil light came on even though I had plenty of oil and had just had it changed. I took it into the dealership and they said that the check engine light was also flashing just so fast I couldn’t see it. Several engine cylinders were apparently misfiring but it wasn’t covered by warranty. They installed new spark plugs and cleaned something to do with the fuel system and told me that would “be the starting place” several hundred dollars in. It worked fine. Fast forward 4 months I take it in for its regular oil change and mention how it’s been lagging again and here we go again. Same issue. According to my local mechanic a lot of these engines end up needing to be replaced completely to resolve the issue.

Door handles on vehicle not working. When you go to pull back on the door handle it won’t open. I couldn’t get my Nephew out of the car. Very frightening. Had to crawl through the hatch to get to him. It started one day with my driver door and I had to pull back at least twice or more before it opens. Now the front passenger’s side door will not open unless pulling the handle from inside to let them in. Back doors are not wanting to open from outside. The day my Nephew was trapped no door would open. Thank god the hatch opened. This is a serious safety issue. Makes me nervous that one day I won’t be able to open my car doors from the inside too. I had trouble with that yesterday on the front passenger door. I don’t have kids and it’s just me a single lady that lives 5 minutes from work. I typically don’t have kids in my vehicle, this was the first time. Made me look like a bad auntie putting my brother’s child in danger. There is hardly any wear on my vehicle, so there must be an issue with the door handles in general.

Window motors and regulators are prone to failure. All 4 of the window motors/regulators have failed within the past year. Apparently the regulator is made of plastic and falls apart easily. As a result, the windows can no longer be operated, and they can be moved up and down by hand from the exterior of the vehicle. Safety is at risk because the integrity of the windows are compromised. In some cases windows will fall down during normal operation of the vehicle. No warning lamps were illuminated during this failure. Note another complaint here: https://www.hyundai-forums.com/threads/window-regulator-2016-hyundai-tucson.671843/

3 of the 4 doors of my 2016 Hyundai Tucson are suddenly unable to be opened from the outside or the inside. There has been no damage to the vehicle. The driver door is able to be opened at this time. This is a major safety issue as passengers are not able to exit the vehicle in the case of an emergency/children passengers are not able to be removed from the vehicle. This seems to be a widespread issue for 2016 Hyundai Tucson customers. Internet thread included below: https://www.cargurus.com/Cars/Discussion-t57988_ds1084478

The passenger door will not open after being unlocked

While driving, the driver seat adjusted causing my seat to move up to the steering wheel. At the time I was on the expressway. I was too terrified to scream, I had to pull over to catch my breathe before I could continue driving to get home. I took my car to Hyundai and the service man stated that it didn't happen when he drove it and that they didn't find anything wrong. I filed a complaint before and never heard anything back. The car seat still adjusts. I don't drive it as much now.

All 4 window regulators have failed. The first two were replaced by dealer, but now are refusing to replace other two. Windows will not stay shut. Have them wedged up with small pieces of carpet. The back two doors will not open either. They said they are fixing those.

The contact owns a 2016 Hyundai Tucson. The contact stated that while operating the vehicle, a clicking noise was present coming from the steering column while turning the steering wheel in either direction. The vehicle was taken to the local dealer who indicated the ticking noise was caused by loosened steering column bolts. The bolts were re-torqued and the failure was remedied. The contact indicated that approximately 40,000 miles later the ticking noise reoccurred. The vehicle was taken back to the dealer who diagnosed that the steering column bolts had loosened again. The bolts were again re-torqued and the failure was remedied. The manufacturer was notified of the failure. The failure mileage was 14,037. The consumer stated the 2nd occurrence happened on 07/20/2022 at 55,053 miles.

Air Bag light is staying on constantly. Took it to the dealer and said it is the Air bag control module. Not covered under extended warranty. Called Hyundai and they said not covered since vehicle is at 69,000 miles. Noticed Hyundai has recalls for air bag modules on other vehicles.

Back passenger door will not open from time to time from the outside or inside. It unlocks and everything but you have to keep trying before it opens. I looked this up and it is common for the 2016 Hyundai Tucson. This is a defect that can be dangerous under certain circumstances.