2015 Hyundai Sonata Hybrid

Defect. Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.

Risk. An engine compartment fire while parked or driving can increase the risk of injury.

Remedy. Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.

Defect. Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. The seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.

Risk. If the seat belt linkage detaches from the seat belt anchorage, it can not properly restrain the occupant in the event of a crash, increasing the risk of injury.

Remedy. Hyundai will notify owners, and dealers will again verify the connection between the seat belt linkage and the pretensioner and additionally install a warning label to prevent future seat belt linkage detachment, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 169.

Defect. Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. In the affected vehicles, the seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.

Risk. In the event of a crash, if the seat belts detach from the anchor pretensioners, it can increase the risk of injury.

Remedy. Hyundai will notify owners and dealers will inspect the connection between the seat belt linkages and the seat belt anchor pretensioners, repairing them as necessary, free of charge. The recall is expected to begin April 7, 2017. Owner's may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for the recall is 160.

Defect. Hyundai Motor America (Hyundai) is recalling certain model year 2015-2016 Sonata Hybrid vehicles manufactured December 8, 2014, to August 18, 2015, and Hyundai Sonata vehicles manufactured May 28, 2014, to March 18, 2016, equipped with the panoramic sunroof option. Due to a bonding issue with the sunroof wind deflector, the sunroof panel on the affected vehicles may detach while driving.

Risk. If the sunroof detaches from the vehicle it could become a road hazard, increasing the risk of a crash.

Remedy. Hyundai will notify owners, and dealers will repair the wind deflector anchor plate, free of charge. The recall began December 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 152.

Recently got the engine rebuilt (2024) and then it broke down on me yesterday with the engine light flashing and a warning sign stating pull over don’t drive

The contact owns a 2015 Hyundai Sonata. The contact stated that while driving approximately 65 MPH, the vehicle failed to properly accelerate. Later, while attempting to accelerate from a yield sign, the vehicle suddenly stalled. The vehicle was later towed to the local dealer to be diagnosed, and it was determined that the engine bearings had failed and the engine needed to be replaced. The manufacturer was notified of the failure. The failure mileage was 97,000.

The contact's sister-in-law owned a 2015 Hyundai Sonata Hybrid. The contact stated that while the vehicle owner was driving 55 MPH, the owner noticed smoke coming from under the hood. The owner parked and exited the vehicle, and while attempting to inspect the vehicle, the owner noticed flames coming from underneath the hood, and the fire extended to the cabin of the vehicle. The Fire Department extinguished the fire and informed the owner that the fire had gone through the firewall and entered the interior of the vehicle. The front seats of the vehicle were completely burned. The vehicle was towed to a local tow yard and was deemed a total loss. The vehicle was under liability insurance. A Police report was filed. The contact sustained back pain from riding in the police officers vehicle. Additionally, the contact stated that the dealer had repaired the vehicle for ABS failure two weeks prior to the incident. The dealer was notified of the fire incident but informed the contact that an inspection could not reveal the cause of the fire. The manufacturer was contacted by phone, and a case was filed. The failure mileage was approximately 98,000.

The Hybrid system kept crashing ! Triggering the auto theft and would not connect to fob , told it was immobilzer, and/or shortage in EV battery!!!

Component Involved: Hybrid Propulsion System High Voltage Battery / EV Battery Electrical System Power Train Incident Summary: I am reporting a serious and repeated safety defect involving my 2015 Hyundai Sonata Hybrid. This vehicle has experienced three separate incidents where warning messages related to the EV/hybrid battery system appeared, followed by a sudden loss of forward propulsion. During these events, the vehicle would not move properly or lost the ability to accelerate safely. This defect creates a major safety hazard because it can occur while driving, increasing the risk of being rear-ended, stranded in traffic, collision, injury, or property damage. I transport my small children in this vehicle and no longer feel it is safe. Detailed Timeline: Initial Incident: Vehicle displayed warning messages involving the EV/hybrid battery system and lost the ability to move forward properly. Vehicle had to be shut off and restarted. Independent Mechanic Inspection: Vehicle was inspected by an independent mechanic who advised the hybrid battery system likely needed repair or replacement and recommended service through Hyundai dealership. Dealer Visit #1 – Stew Hansen Hyundai (3/18/2026): Vehicle was taken to authorized Hyundai dealer for diagnosis. Dealer stated they could not duplicate the issue and no repair was made. Second Failure: After release from dealer, same dangerous loss-of-power condition occurred again, resulting in towing and additional inconvenience. Dealer

Idle and warning to not drive, 2025 very subtle cut off now full warning

We pulled up at Hillgreen circle Cockysville MD To drop my boyfriend off at his apartment. I went to pull in the parking spot.I went to put the car into park and it had no brakes. I was slamming them and pumping them. It excellerated and took off. Jumped the curb,went down the hill and into the apartment building. A red light had came on the dash, right before it took off. Seemed like it was changing to gas or the electric mode,or the other way around. The airbag on the passenger side came out deflated,and filled with smoke going into the car. He was the belted front passenger and his elbow went in to the front window. You can tell by looking at it,the hole and spidered around it. He broke his right elbow. It is available anytime at the moment. It's at Hyundaii in Glen burnie. I need to get it to state farms lot,to get the Kelly blue book value. We look forward to hearing from you

The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated that while driving 5 MPH and making a left turn, the vehicle made an abnormal knocking sound. The contact stated that upon pulling into an apartment complex parking lot, the contact noticed that there was smoke coming out from underneath the hood. There was no warning light illuminated. The contact immediately parked and exited the vehicle. The contact stated that upon opening the hood, the contact noticed a small fire and was able to extinguish the fire with a water bottle. The contact was able to push the vehicle into a parking space with the assistance of her son. There was no injury sustained. No police report was filed. The vehicle was towed to an independent mechanic, where it was diagnosed that a fluid leak from an unknown hose had caused the fire, and there was a hole in the engine block. The contact also stated that there was a puddle of fluid on the ground. The vehicle was not repaired. The contact became aware that the VIN was included in NHTSA Campaign Number: 23V651000(Service Brakes, Hydraulic), which the contact related to the failure. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 115,395.

The contact owns a 2015 Hyundai Sonata Hybrid. The contact took the vehicle to the dealer to be repaired under NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) and Manufacturer recalls: 964 (Auxiliary Canister Installation), 966 (Engine Monitoring Module, ECU Software Update), and 994 (Hybrid Safety Fuse). The contact stated that after the repairs were completed while attempting to start the vehicle at the dealer, the vehicle failed to start. The vehicle remained at the dealer who was unable to determine the cause of the failure. The vehicle had not been repaired. The manufacturer was made aware of the failure and confirmed that the vehicle was not covered under warranty for any further repairs. The failure mileage was 170,000.

The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated while driving at various speeds, a message advising to pull over and to park the vehicle was displayed. The vehicle was taken to the dealer for diagnostic testing several times. The dealer replaced the HECU and the battery inverter assembly; however, the failure persisted. Additionally, the contact stated that while his son was driving at an undisclosed speed, the contact's son noticed that there was white smoke coming from the rear middle seat of the vehicle. An unknown warning light was illuminated. The contact's son pulled to the side of the road and turned off the vehicle. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the hybrid battery pack had failed, causing the hybrid battery to melt. The dealer determined that the hybrid battery pack needed to be replaced. The vehicle was not repaired. The contact related the failure to Hyundai Campaign Number: 994. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 37,000.

The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated while driving 45 MPH, the vehicle started overheating, and smelled an abnormal electrical burning odor inside the cabin. Several unknown warning lights were illuminated. The contact veered to the side of the road, turned off the vehicle and inspected under the hood. The contact stated that the vehicle failed to restart and was towed to the residence. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) which he related to the failure. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, the message "Turn off the Engine Immediately" was displayed. Several unknown warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. Later, the contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart with several unknown warning lights illuminated. The vehicle was towed back to the dealer, who then diagnosed failures with the ABS and transmission. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but provided no assistance. The failure mileage was unknown.

The contact owns a 2015 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available. A person stated the wrong email address is listed, never filed a complaint.

The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, several unknown warning lights were illuminated. The contact stated that while depressing the brake pedal, the brake pedal went to the floorboard. The contact stated that the warning light to turn off the vehicle was illuminated. The contact turned the vehicle off and the vehicle failed to restart. The vehicle was towed to the dealer; however, the dealer refused to service the vehicle. The vehicle was then towed to the residence. The vehicle was towed to another Hyundai dealer where the vehicle was diagnosed with a failed transmission and battery. The contact was informed that the transmission and battery needed to be replaced. The vehicle was repaired. The contact stated while driving away from the dealer, she heard an unusual knocking sound coming from the engine compartment. The vehicle was taken back to the dealer. The service technician accompanied the contact for a test drive and confirmed the knocking coming from the engine compartment. The contact was informed that the new transmission that was installed was defective, and the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 74,680.

The contact owns a 2015 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated while stopped in traffic, the vehicle independently jolted with a message indicating a Hybrid System safety failure. Additionally, there was a message to stop driving the vehicle with an alarm sounding. The contact veered to the side of the road. The contact was able to continue driving. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) the following day; however, the part to do the recall repair was not yet available. The contact stated that the failure recurred while driving. The contact veered to the side of the road. The vehicle was then taken to an independent mechanic, where it was test-driven; however, the mechanic was unable to duplicate the failure. The local dealer was contacted and informed the contact that the earliest availability was on December 23, 2023. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,500. VIN tool confirms parts not available.

The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated while driving approximately 60 - 65 MPH, the battery warning light illuminated. The charging system failure message was displayed. The vehicle was taken to the local dealer where it was diagnosed and determined that the system needed to be reprogramed. The vehicle was repaired; however, the failure persisted. While driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle stalled. The vehicle was taken to an unknown local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 75,000.

The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated while driving 45 MPH, there was a message that the vehicle was not safe to drive displayed on the instrument panel. The check engine warning light was illuminated. The contact stated that the vehicle began to stall; however, while depressing the accelerator pedal, the vehicle failed to accelerate. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing both batteries to be replaced. The vehicle was repaired but continued to experience the failure. The contact took the vehicle to a second local dealer: Interstate Hyundai (609 Constitution Dr, West Monroe, LA 71292, (318) 387-2667) where it was diagnosed with needing both Manufacturer Communications 964 & 966 to be completed. The dealer completed manufacturer repairs, but the vehicle continued to experience the failure. The manufacturer had not been informed of the failure. The failure mileage was approximately 95,000.

The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic who replaced the fuel cap and performed other tests on the engine. The check engine warning light disappeared however, two weeks later the warning light returned. The dealer was contacted and a message was left. The manufacturer was not contacted. The failure mileage was 134,298.

The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated while driving 20 mph, the vehicle loss motive power and the check charging system warning light illuminated before the vehicle stalled. The contact was able to coast and move the vehicle to the side of the roadway and waited for several minutes and restarted the vehicle. The contact continued to drive to his destination. The failure recurred several times. The local dealer was contacted and informed of the failure. The contact was informed that since the vehicle was experiencing the failure intermittently, the vehicle could not be diagnosed until the failure occurred and the vehicle was taken in with while the failure was happening. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure. The failure mileage was 29,000.

TL* THE CONTACT OWNS A 2015 HYUNDAI SONATA HYBRID. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, WITH THE AIR CONDITIONER ACTIVATED AND MAKING A TURN, THE VEHICLE HESITATED AND LOSS POWER. THERE WAS NO WARNING LIGHT ILLUMINATED. THE CONTACT CALLED HEADQUARTER HYUNDAI (985 RINEHART RD, SANFORD, FL 32771, (407)292-0000) HOWEVER, THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

TL* THE CONTACT OWNS A 2015 HYUNDAI SONATA HYBRID. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED AS THE "HYBRID SYSTEM WARNING, SAFELY STOP AND DO NOT DRIVE" WARNING MESSAGE APPEARED ON THE INSTRUMENT PANEL. DUE TO THE FAILURE, THE VEHICLE BEHIND HER ATTEMPTED TO AVOID HITTING HER; HOWEVER, THE VEHICLE BEHIND THAT VEHICLE COLLIDED INTO HIS WHICH CAUSED AN ACCIDENT. THE CONTACT WAS THEN FORCED TO RESTART THE VEHICLE IN THE MIDDLE OF TRAFFIC AND WAS ABLE TO RESUME NORMAL DRIVING. THE CONTACT THEN TOOK THE VEHICLE TO BUD CLARY AUBURN HYUNDAI (2807 AUBURN WAY N, AUBURN, WA 98002) WHERE THEY WERE UNABLE TO DUPLICATE THE FAILURE. SHE ALSO TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO WAS ALSO UNABLE TO DUPLICATE THE FAILURE ALSO. THE CONTACT STATED THAT THE FAILURE HAD OCCURRED TWICE SINCE THE INITIAL FAILURE. THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS 152,000.

TL* THE CONTACT OWNS A 2015 HYUNDAI SONATA HYBRID. THE CONTACT STATED THAT THE VEHICLE SHUT DOWN SEVERAL TIMES WITHOUT WARNING WHILE DRIVING VARIOUS SPEEDS. THE CONTACT WAS UNCERTAIN AS TO WHAT CAUSED THE FAILURE, BUT FELT IT MAY BE RELATED TO TSB NUMBER: 06-01-004-1. KEFFER HYUNDAI (9010 E INDEPENDENCE BLVD, MATTHEWS, NC 28105, (704) 247-5645) WAS MADE AWARE OF THE FAILURE AND PLANNED TO SCHEDULE A DIAGNOSTIC APPOINTMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2015 HYUNDAI SONATA HYBRID. WHILE DRIVING VARIOUS SPEEDS AND ATTEMPTING TO BRAKE, THE VEHICLE ACCELERATED. THE CONTACT DEPRESSED THE BRAKE PEDAL MULTIPLE TIMES AND WAS ABLE TO STOP THE VEHICLE. THERE WAS NO WARNING INDICATOR ILLUMINATED. IN ADDITION, THE VEHICLE INTERMITTENTLY FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE FAILURES RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO JIM CLICK MAZDA AUTO MALL (877-888-2760, LOCATED AT 700 W AUTO MALL DR, TUCSON, AZ 85705), BUT THE FAILURES COULD NOT BE DIAGNOSED OR DUPLICATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT PROVIDED.

TL* THE CONTACT OWNS A 2015 HYUNDAI SONATA HYBRID. WHILE DRIVING 20 MPH, THE FRONT PASSENGER SIDE COIL SPRING FRACTURED AND EXITED THROUGH THE FRONT PASSENGER TIRE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT COVERED UNDER WARRANTY. CASE NUMBER: 15697010 WAS PROVIDED AND THE CONTACT WAS REFERRED TO A DEALER. THE CONTACT STATED THAT THE FAILURE WAS SIMILAR TO NHTSA CAMPAIGN NUMBER: 15V629000 (SUSPENSION). THE FAILURE MILEAGE WAS 69,000.

I HAD TWO CASE NUMBERS WITH HYUNDAI RELATED TO MY BRAKES AND FUEL EFFICIENCY; THE FIRST WAS HYUNDAI CONSUMER AFFAIRS CASE#: 12894630 AND THE SECOND WAS HYUNDAI CONSUMER AFFAIRS CASE#: 15512885. BOTH CASES WERE CLOSED PRIOR TO ME HAVING ANY SAY IN THE DECISION (EMAIL/PHONE RECORDS SHOW THIS). AFTER MY BRAKING UNIT FAILS FOR THE SECOND TIME AND I NOTICED A SIGNIFICANT DROP OFF IN FUEL PERFORMANCE (MPG), I ASKED FOR ANOTHER HYUNDAI REP TO TEST MY FUEL CONSUMPTION. WHEN THE RESULTS PROVED TO BE BETTER THAN I HAD EVER SEEN MY CAR PERFORM, EVER, I ASKED FOR THE REST SPECKS. THIS WAS ESCALATED TO HYUNDAI CORPORATE, WHO RESPONDED 'UNFORTUNATELY YOUR CASE MANAGER CANNOT PROVIDE ANY TSB'S BECAUSE IT IS PROPRIETARY INFORMATION. AS FAR AS WARRANTY EXTENSION, REGRETTABLY THAT IS NOT AN OPTION. HOWEVER, IF YOU WERE TO HAVE BRAKE CONCERNS OUTSIDE OF WARRANTY, HYUNDAI WILL REVIEW FOR GOODWILL IF THE PROBLEM IS SOMETHING THAT WAS PREVIOUSLY REPAIRED UNDER WARRANTY.' THIS ANSWER FAILED TO CONSIDER THE MILEAGE I WAS ALREADY LOSING IN MY HYBRID WHICH PERFORMED WORSE THAN A NON-HYBRID MODEL WHENEVER THE BRAKES WERE FAILING. I MADE GOOD FAITH EFFORTS TO REPORT MY PROBLEMS IN THE HOPE HYUNDAI WOULD RESOLVE THEM.

I WAS DRIVING IN THE RAIN ON 1/16/19 WITH MY SON, ALL OF A SUDDEN MY CAR STARTS BEEPING AND MY DASH BOARD SAYS STOP DRIVING NOW AND CHECK YOUR CHARGER SYSTEM AND AFTER ONE HOUR IT COMPLETELY DIED, HAD TO GET TOWED HOME, NOW THE DEALER SAYS THE PROBLEM WAS THE HIGH VOLTAGE RELAY AND CONNECTOR THAT GOES TO THE HIGH VOLTAGE BATTERY ON THE CAR THAT CAUSED THE BATTERY TO FAIL AND CHARGER SYSTEM. NOW I'M TOLD I NEED TO BUY A NEW BATTERY AND I FEEL THIS SHOULD BE COVERED B THE WARRANTY SINCE THIS ISSUED CAUSED MY BATTERY TO DRAIN.

COMING HOME FROM A FUNERAL OUT OF TOWN. THE THE VEHICLE STARTED MAKING A CLICKING NOISE UNDER THE HOOD ON THE PASSENGER SIDE OF THE CAR. THEN THE VEHICLE STARTED SLOWING DOWN. WE WERE ABLE TO MAKE IT TO A GAS STATION AND THE VEHICLE STOPPED. THERE IS ALSO OIL LEAKAGE. IT WOULD TURN OVER, BUT STOP AGAIN. HAD TO PAY 700 TO TOW US AND THE VEHICLE HOME.

DRIVING IN RUSH HOUR TRAFFIC ABOUT 25 MPH AND CAR STUTTERED WARNING LIGHT CAME ON AND SAID TO PULL OVER, BUT EVERYTHING SHUT DOWN BEFORE I COULD. I BLOCKED TRAFFIC FOR 6 HOURS. DID NOT GET INTO AN ACCIDENT, BUT WAS VERY CLOSE TO ONE. EVERYTHING SHUT DOWN INCLUDING HAZARD LIGHTS. I WAS UNABLE TO EXIT VEHICLE DUE TO HEAVY TRAFFIC.

WAS DRIVING ABOUT 25 MPH AND IT SENT WARNING LIGHTS AND STUTTERED AND DIED IN FRONT OF RAILROAD TRACKS. VERY LUCKY IT DIDN'T DIE ON THE TRACKS.

WHILE DRIVING 65 MILES ON THE HIGHWAY, VEHICLE STARTED A RINGING NOISE AND AN ERROR MESSAGE APPEARED ON SCREEN "HYBRID SYSTEM WARNING! SAFELY STOP AND DO NOT DRIVE." AFTER THAT, "CHECK BRAKE ." APPEARED AND THE TWO MESSAGES KEPT SWITCHING BACK AND FORTH. THE VEHICLE THEN STARTED TO SLOW DOWN BY ITSELF AND THE BREAK PUSHED DOWN TO THE FLOOR BY ITSELF. THE BRAKES STARTED GRINDING AND I LOST CONTROL OF THE VEHICLE AND THE VEHICLE STOPPED MOVING, ON THE HIGHWAY, WITH A SEMI RIGHT BEHIND ME. THE VEHICLE DID NOT ALLOW ME TO SAFELY STOP, IT STOPPED ON IT'S OWN. IF IT HAD NOT BEEN FOR A SHOULDER CLOSE ENOUGH TO COAST TO IT, A MAJOR ACCIDENT WOULD HAVE OCCURRED. I WAS AN HOUR AWAY FROM HOME AND IN ORDER TO GET HOME I HAD TO KEEP PULLING OVER, CUTTING OFF VEHICLE, WAIT A FEW SECONDS, DRIVE AGAIN, PULL OVER, AND WAIT. I WAS ALMOST IN THREE ACCIDENTS. WHEN I GOT HOME, I DID SOME RESEARCH AND FOUND MORE HYUNDAI OWNERS WITH THE SAME ISSUE. I TRIED DRIVING IT BUT ONCE AGAIN, IT DID THE SAME THING, IN THE MIDDLE OF TRAFFIC. I HAD TO HAVE THE VEHICLE TOWED TO THE DEALERSHIP BECAUSE DRIVING THE VEHICLE IS A SAFETY ISSUE. THE DEALERSHIP CONTACTED ME AND SAID THAT THE VEHICLE IS NOT UNDER WARRANTY AND THAT I HAVE TO PAY $2700. SINCE THIS IS HAPPENING WITH OTHER VEHICLES, AND IT IS A SAFETY ISSUE, I FEEL HYUNDAI SHOULD FIX IT. I HAD A SIMILAR ISSUE A FEW MONTHS AGO WHERE THE VEHICLE COMPLETELY STOPPED WHILE I WAS DRIVING 45 MILES, IN TRAFFIC, WITH ERROR MESSAGE,HYBRID SYSTEM WARNING! SAFELY STOP

I WAS DRIVING THE CAR AND ALL OF A SUDDEN IS JUST DIED. NOT SURE WHAT PROBLEM WAS. CAN'T BE A BATTERY PROBLEM CAUSE THE CAR WAS RUNNING. ROADSIDE ASSISTANCE TRIED TO START THE BATTERY BUT THAT IS NOT THE PROBLEM. I HAVE READ ALL OVER THE INTERNET WITH COMPLAINTS OF THIS HYBRID CAR JUST SHUTTING DOWN WHILE DRIVING. THIS IS A SERIOUS SAFETY RISK AND A ONGOING PROBLEM. THE CAR IS A DEATH TRAP AND I REFUSE TO DRIVE IT ANYMORE. THE CAR ACCELERATION IS MET WITH A PAUSE WHEN TAKING OFF AS WELL. I WAS EXPLAINED ITS WHEN THE CAR SWITCHES FROM BATTERY TO ENGINE FOR POWER. IT'S A SAFETY ISSUE AS WELL GIVEN YOU COULD PUT YOURSELF OUT INTO A INTERSECTION AND NOT HAVE ENOUGH POWER OR THE HESITATION CAN PREVENT YOU FROM GOING. THE CAR IS THE WORST MADE CAR I HAVE EVER OWNED. I REFUSE TO DRIVE THIS CAR WITH ME OR MY DAUGHTERS LIFE IN JEOPARDY DUE TO THE PROBLEMS WITH THE VEHICLE. PLEASE FORWARD A COMPLAINT TO HYUNDAI CORPORATE OFFICE AS I WILL DO THE SAME. THANKS

TL* THE CONTACT OWNS A 2015 HYUNDAI SONATA HYBRID. WHILE DRIVING 65 MPH, A LOUD POP SOUND WAS HEARD COMING FROM UNDERNEATH THE VEHICLE ON THE FRONT PASSENGER SIDE. THE CONTACT NOTICED SMOKE COMING FROM THE FRONT PASSENGER SIDE FLOOR PANEL. THERE WERE NO WARNING INDICATORS. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, EXITED THE VEHICLE, AND NOTICED FLAMES UNDERNEATH THE CENTER OF THE VEHICLE. THE ENTIRE VEHICLE BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW LOT. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 35,000. THE VIN WAS NOT AVAILABLE. *TT UPDATED 9/26/18*JB

TL* THE CONTACT OWNS A 2015 HYUNDAI SONATA HYBRID. WHILE DRIVING AT AN UNKNOWN SPEED, THE CHECK ENGINE INDICATOR ILLUMINATED AND THE "SHUT OFF HYBRID SYSTEM" MESSAGE APPEARED. THE VEHICLE WAS TAKEN TO LAKE NORMAN HYUNDAI (20520 CHARTWELL CENTER DR, CORNELIUS, NC 28031, (704) 274-3145) WHERE THE CONTACT WAS INFORMED THAT THERE WAS AN UNKNOWN RECALL ON THE VEHICLE AND THE ELECTRIC WATER PUMP WIRING NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS 50,500.

HYBRID SYSTEM WARNING LIGHTS TURNED ON WHILE DRIVING ON THE HIGHWAY, ILLUMINATED "DO NOT DRIVE, PULL OVER SAFELY". TRIED TO PULL OVER SAFELY AND THE CAR STALLED AND WHEELS LOCKED. COULD NOT PULL OVER TO GET OUT OF TRAFFIC.

TRANSMISSION ACTS LIKE IT IS SLIPPING AND SHIFTS ABNORMALLY IN FORWARD AND REVERSE, DRIVER WINDOW UP/DOWN BUTTON DOESN'T WORK CORRECTLY IT ONLY MAKES THE WINDOW GO UP 1/4 OF THE WAY SO YOU HAVE TO LET GO AND PRESS IT AGAIN. THE RADIO KEEPS SHOWING AND ERROR MESSAGE WAITING TO GET INTO THE DEALER

TL* THE CONTACT OWNS A 2015 HYUNDAI SONATA HYBRID. THE CONTACT STATED THAT THE VEHICLE HAD PREMATURE ENGINE FAILURE DUE TO SLUDGE AND METAL FRAGMENTS ENTERING THE ENGINE ASSEMBLY. THE VEHICLE STALLED MORE THAN TWICE. THE VEHICLE WAS TOWED TO NORTH COUNTY HYUNDAI OF CARLSBAD (5285 CAR COUNTRY DR, CARLSBAD, CA 92008, (760) 929-4900) FOR THE FIRST REPAIR. THE DEALER INDICATED THAT THEY REPLACED THE GSI BELTS, BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE DEALER A SECOND TIME WHO INDICATED THAT THE HYBRID BATTERY DETACHED. THE DEALER RE-ATTACHED THE BATTERY, BUT THIS DID NOT PREVENT THE FAILURE. THE VEHICLE STALLED AGAIN AND WAS UNABLE TO BE DRIVEN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V568000 (ENGINE AND ENGINE COOLING). THE APPROXIMATE FAILURE MILEAGE WAS 88,000.

IT HAS OVERHEAT PROBLEM THAT HYUNDAI SERVICE COULDN'T FIX. IT BROKE DOWN 6 TIMES AND WAS 3 TIMES IN THE SHOP. 4/2/17, I WAS ON FASTEST LANE ON 101 FREEWAY IN DOWNTOWN LA. SUDDENLY THE CAR ALARM BEEPS. DASH BOARD DISPLAYED "HYBRID SYSTEM WARNING, SAFELY STOP AND DO NOT DRIVE". THE GAS PEDAL WAS HARD TO PRESS, (GUESS IT GOES INTO PROTECTION MODE. ) FORTUNATELY IT WAS IN RUSH HOUR TRAFFIC THAT NO CAR RAM INTO ME FROM BEHIND. I FORCED THE CAR SWITCHED LANES AND EXIT FREEWAY. AFTER I PARKED, THE CAR FROZED. I CAN'T TURN ON THE EMERGENCY SIGNAL. CAN'T SWITCH THE GEAR TO PARK, CAN'T TURN OFF THE ENGINE... I EXIT THE CAR AND WAVE CARS BEHIND ME MOVE AHEAD, THEN I GOT BACK THE CAR AND WAS ABLE TO TURN OFF THE ENGINE. AFTER IT WAS OFF FOR 30 SECONDS, I CAN TURN THE ENGINE BACK ON AND THE CAR FUNCTIONS LIKE NORMAL. IT WAS UNDER 18000 MILES. THE SERVICE DEPARTMENT SAYS THE COOLANT LEAK AND REPLACED IT. 5/15/17, WHILE DRIVING ON FREEWAY, I FELT THE CAR WAS INTO PROTECTION MODE, HARD TO PRESS THE ACCELERATOR. BUT THE ALARM DIDN'T SOUND OFF. I SENT IT IN AND THE SERVICE COULDN'T DUPLICATE THE PROBLEM SO THEY RESET THE COMPUTER OF THE CAR. 6/5/17 THE CAR WAS PARKED IN HOT SUN IN PS FOR 30 MINUTES WHILE ME AND MY REALTOR GO TO CHECK A HOUSE. I STARTED THE CAR FOLLOWING MY REALTOR. I TURNED ON THE AC AND THE ALARM GOES OFF, SAME WARNING SIGN DISPLAYED AND THE CAR JUST FROZE. HYUNDAI SENT A TOW TRUCK AN HOUR LATER. AFTER IN THE SHOP OVERNIGHT, THE SERVICE DEPT SAYS THEY FIXED IT. 6/14. IN PS AG

TL* THE CONTACT OWNED A 2015 HYUNDAI SONATA HYBRID. THE CONTACT STATED THAT WHILE STOPPED, THE VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE. THE CONTACTED STATED THAT THE FRONT SEAT PASSENGER SUSTAINED INJURIES TO THE LEFT SHOULDER, NECK AND BACK WHICH REQUIRED MEDICAL ATTENTION DUE TO THE SEAT BELT RETRACTING TOO TIGHT. THE DRIVER ALSO SUSTAINED INJURIES TO HIS NECK AND BACK WHICH ALSO NEEDED MEDICAL ATTENTION. THE CONTACT STATED THAT ANY INJURIES OF THE OTHER VEHICLE WERE UNKNOWN. THE CONTACT STATED THAT THE AIR BAGS DID NOT DEPLOY AND NO WARNING LIGHTS WERE ILLUMINATED. A POLICE REPORT WAS FILED. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO MENTIONED THAT ON SEVERAL OCCASIONS WHILE STOPPED, THE VEHICLE WOULD JERK WITH NO WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED AS THE CONTACT TRADED-IN THE VEHICLE AT ROUND ROCK HYUNDAI DUE TO THINKING THERE WAS A FAILURE WITH THE SEAT BELTS AS THEY WOULD RETRACT AGGRESSIVELY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE CONTACT MENTIONED THAT THE VEHICLE HAD TWO EXTENDED WARRANTIES BUT THE FAILURES WERE UNKNOWN. THE FAILURE MILEAGE WAS 10,000.

I WAS DRIVING ON THE HIGHWAY WHEN SUDDENLY THE CHECK CHARGING LIGHT SYSTEM WARNING CAME ON, ALL 3 LIGHTS FOR OIL, BATTERY, AND ENGINE CAME ON AT THE SAME TIME! THE CAR STALLED WAS NOT POSSIBLE TO STEAR AND BRAKES DIDN'T WORK... I HAD TO COAST LUCKILY I WAS ONLY IN SECOND TO RIGHT LINE AND EASILY GOT TO EMERGENCY LANE!! THIS HAPPENED ON 101 IN CALIFORNIA DURING A BUSY TIME!!!

ABOUT AN HOUR INTO DRIVING HOME ON THE FREEWAY, MY CAR ALERT SYSTEM WENT OFF AND THE CAR AUTOMATICALLY BEGAN TO DECELERATE AND THE DASHBOARD DISPLAY SHOWED INSTRUCTIONS TO CHECK HYBRID CHARGING SYSTEM AND TO CHECK SURROUNDINGS AND TO PULL OVER WHEN SAFE AND TO NOT DRIVE VEHICLE. THE CHECK ENGINE LIGHT, THE NEEDS MAINTENANCE LIGHT AND THE CHECK OIL LIGHT ALL CAME ON. AFTER ABOUT 15 SECS MY VEHICLE LOST ALL POWER BUT DID NOT TURN OFF; THE STEERING WHEEL BECAME LOCKED. I PLACED THE CAR INTO PARK AND RESTARTED IT AND THE WARNING ALERT ALARM CEASED, BUT NOW THE CHECK ENGINE LIGHT STAYED ON. THE STEERING WHEEL WAS MOVABLE AGAIN AND I WAS ABLE TO PULL TO THE SHOULDER WHERE A CALIFORNIA HIGHWAY PATROL OFFICER PULLED UP AND ASKED ME IF I WAS HAVING TROUBLE. AFTER OUR CONVERSATION, I WAS ABLE TO CONTINUE THE ADDITIONAL 40 MILE DRIVE HOME AS THE LOCAL HYUNDAI DEALERSHIPS WERE CLOSED UNTIL THE NEXT DAY, SATURDAY MARCH 18. I WAS ABLE TO DROP MY CAR OFF IN THE AFTERNOON BUT DUE TO THEIR BOOKED SCHEDULE, IT COULD NOT BE LOOKED AT UNTIL MONDAY MARCH 20TH AND STAYED OVER NIGHT. THE TECHNICIAN CALLED ME THAT DAY AND STATED THAT THE CAR TEST RAN ON IT CAME BACK PASSING AND NO ISSUES FOUND AND THAT THEY DROVE IT ABOUT 20 MILES AND NO ISSUES AND I WAS ABLE TO PICK UP MY CAR ON TUESDAY. HOWEVER, THE SAME SYSTEM ISSUE HAPPENED 3 MORE TIMES BEFORE I WAS ABLE TO TAKE IT BACK INTO THE DEALERAHIP LATER THAT WEEK AND IT HAS BEEN THERE AS OF 4/21/2017. I RECEIVED A CALL TODAY THAT A REPLACEMENT HYBRID BA

WHILE DRIVING MY CAR STARTED ALARMING SAYING CHECK CHARGING SYSTEM...IT IMMEDIATELY WENT TO 15 MILES AND HOUR WHILE I WAS ON I95 WHERE SPEED LIMIT IS 65 MPH. BY THE TIME I GOT HOME AND TURNED THE CAR OFF IT WOULD NOT TURN BACK ON. IVE HAD THIS CAR FOR A YEAR AND A HALF. I BOUGHT IT NEW.

A FEW MONTHS AGO THE VEHICLE STALLED AT A RED LIGHT. I FOUND COMPLAINTS OF THE SAME MAKE, YEAR AND MODEL STALLING ON OTHER OWNERS ON THE INTERNET. WENT TO DEALER AND AFTER NUMEROUS HOURS IN THE SHOP THEY COULD NOT FIND THE PROBLEM. TODAY MY 19 YEAR OLD DAUGHTER WAS ON A FOUR LANE HIGHWAY WITH NO PULL OFF LANES, ONLY CEMENT BARRIERS. THE VEHICLE STALLED AT 60 MPH. SHE ALMOST DIED FROM BEING HIT BY A TRACTOR TRAILER. SHE WAS MISSED BY ONLY A FEW INCHES. THE VEHICLE DID START AGAIN AND SHE GOT OFF THE HIGHWAY. MADE COMPLAINT WITH HYUNDAI CONSUMER AFFAIRS.

TL* THE CONTACT OWNS A 2015 HYUNDAI SONATA HYBRID. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED AND LOST POWER WITHOUT WARNING. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD AND WAS RESTARTED. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT NOTHING COULD BE DONE. THE FAILURE RECURRED AND WAS NOT REMEDIED. THE FAILURE MILEAGE WAS APPROXIMATELY 24,000.

AS I WAS DRIVING DOWN THE ROAD, A WARNING SIGN APPEARS IN MY DASH THAT SAYS DO NOT DRIVE.... MEAN WHILE IM ALREADY DRIVING.... CARS STARTS TO STALL AND WHEEL LOCKS. I GET THE CAR TOWED TO THE DEALERSHIP THAT NIGHT AND THE NEXT DAY... WHICH IS TODAY I AM WAITING FOR SOMEONE TO CALL AND ASK ME WHAT HAPPENS AND NOTHING... SO I DECIDED TO DRIVE THERE AND WHAT DO I SEE..... MY CAR SITTING ON THE SIDE LIKE NO ONE CARS THAT IS THERE... WHEN I GO IN I FIND OUT THAT THERE IS ONLY 1 PERSON THAT WORKS ON HYBRIDS AND THEY DON'T KNOW WHEN THEY WILL BE ABLE TO TAKE A LOOK AT IT... OH AND LETS NOT FORGET THEY DON'T DO LOANER CARS.. I JUST BOUGHT THIS CAR 1 YEAR AGO FROM THIS SAME DEALERSHIP...THEY CANT GIVE ME ANY TYPE OF ESTIMATE OF WHEN THE TECH WILL BE ABLE TO LOOK AT MY CAR... THIS IS VERY BAD SERVICE!!! WHY WOULD MY CAR STOP DRIVING AFTER HAVING IT ONLY A YEAR????? *TR

ON SAT, OCT 1, AT ABOUT 1 PM I WAS ABOUT TO COMPLETE PARKING THE VEHICLE IN THE PARKING LOT OF THE HUNTINGTON BEACH BRANCH OF CHASE BANK. I FORTUNATELY SELECTED A SITE ON FRONT OF A PLANTER SECTION WITH BUSHES, AS OTHERWISE THERE COULD HAVE BEEN INJURIES OR PROPERTY DAMAGE. I WAS ALMOST STOPPED AND WAS ABOUT TO PUT THE GEAR IN PARK, THE CAR SUDDENLY REVVED UP THE ENGINE AND ACCELERATED VIOLENTLY AND WITH GREAT FORCE, PROPELLING THE CAR OVER THE CEMENT CURBS OF THE PLANTER AND LANDED IN THE BUSHES. THE CAR COULD NOT BE REVERSED OUT OF THE BUSHES AS THE WHEELS WERE LODGED INSIDE THE PLANTER AREA. THE FRONT BUMPER, POSITION LIGHTS AND UNDERCARRIAGE WERE SERIOUSLY DAMAGED. AAA ROAD ASSISTANCE HAD TO BE CALLED TO PULL THE CAR OUT OF THE PLANTER. THE INCIDENT IS EXTREMELY SIMILAR TO OTHER SUCH INCIDENTS OF SUDDEN UNWANTED ACCELERATION DOCUMENTED IN YOUTUBE VIDEOS. WE HAVE OPENED A CLAIM WITH HYUNDAI, CASE # 962 9876.

ANTI-LOCK BRAKE SYSTEM IS NON-FUNCTIONAL. ON SEVERAL OCCASIONS WHILE IN MOTION ON THE HIGHWAY, I HAVE HAD TO APPLY THE BRAKES QUICKLY, WHICH HAS REPEATEDLY CAUSED THE WHEELS TO LOCK UP AND THE CAR TO SKID. DEALERSHIP CLAIMS THERE IS NOTHING WRONG, AND THAT THE BRAKES ARE ACTING NORMALLY.

I'VE YEARS OF EXPERIENCE WITH ABS SYSTEMS. MY CURRENT CAR CLAIMS TO HAVE ABS, BUT IF I SLAM ON THE BRAKES, THEY LOCK. THAT IS NOT ABS. I TOOK THE CAR IN TO HAVE IT LOOKED AT AND THE DEALER CLAIMED IT MET THEIR ABS STANDARDS. THE BRAKES DON'T MEET MY ABS STANDARDS. I HAVE HAD TO SLAM ON THE BRAKES ON SEVERAL OCCASIONS, SOMETIMES GOING AS SLOWLY AS 20 MPH AND THE BRAKES LOCKED AND THE CAR SKIDDED.

PUSH BOTTON START DOESNT A LOT OF THE TIME SEVERAL TIMES A WEKK START THE ENGINE. ALSO, THE SUSPENSION IS TERRIBLY ROUGH. YOU CAN FEEL EVERY BUMP!

BREAK PEDAL UNUSUAL SOUND: WHEN STANDING STILL AND APPLYING PRESSURE TO BRAKE PEDAL, UNUSUAL NOISE CAN BE CLEARLY HEARD. I BELIEVE THIS NOISE SHOULD NOT BE PRESENT. SOUND IS REAPPEARING MORE THAN ONCE THROUGHOUT ALL BRAKE PEDAL TRAVEL FROM UPPER POSITION TO ITS LOWEST POSITION. SOUND IS IF SOME METAL PART WAS RUBBING AGAINST EITHER ANOTHER METAL OR PLASTIC SURFACE.