2023 Hyundai Santa FE complaints

WHEN I WAS DRIVING TO WORK THE MORNING OF 5/20/2024, MY PANORAMIC SUNROOF EXPLODED OUT OF NOWHERE. PART OF THE GLASS FELL ON MY HEAD RESULTING IN A CONCUSSION.

Driving down the interstate yesterday & heard a very loud ‘POP!’ Looked when I got home to find that the sunroof glass had shattered (as has, apparently, happened to more than a few vehicles by Hyundai, as well as other manufacturers), & fell onto the fabric liner below it. Thankfully, I did not have any of my grandchildren in the back seat at the time, & the sunroof was closed. At the very least, Hyundai needs to replace and repair the glass, & be sure, before it’s returned to me, that it’s better than it was when it was new.

The contact owns a 2023 Hyundai Santa Fe. The contact stated that the vehicle was overheating while driving. Additionally, the contact stated that upon noticing that coolant was leaking onto the ground, he opened the hood and discovered that coolant was leaking from the radiator. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that a foreign object had struck the radiator, causing coolant to leak into the engine compartment. The dealer informed the contact that a failure caused by a foreign object was not covered under warranty. The vehicle was not repaired. The contact stated that upon examining pictures of the failure provided by the dealer, he noticed that there were rocks stuck in and near the radiator. The contact determined that the large gaps of the front grill were allowing foreign objects to strike the radiator. The manufacturer was notified of the failure and a case was opened; however, the case was later closed. The failure mileage was approximately 11,591.

I've been driving in Arizona on southbound [XXX] just south of [XXX] and noticed an issue that is very odd. I have a 2023 Hyundai Santa Fe that has Highway Driving Assist that does both speed control and distance from the vehicle ahead of me and Lane Keeping Assist. After I pass [XXX], but before an overpass for [XXX], my vehicle, if those systems are on, goes haywire and all those safety systems turn off. I have experienced it on at least 3 of the lanes on that stretch. It happens both early in the am and later regardless of sun. It doesn't happen on northbound. As more cars have these features, this interference should be looked in to. I have not experienced this on any other of our highways. Here's a link to the the rough location. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Unknown issue, but the car has auto braked 2x on the interstate going 65mph. No cars were around me nor any objects in the road. It stated auto braking and sensors going off. Resolved itself within 60 seconds, but did almost cause me to be rear ended because a tractor trailer was quickly approaching me.

See attached document for complaint

The harness does not stay tight on the child’s chest. The harness was adjusted to the correct fit, when pulled to check the tightness the harness does not stay taught. It releases without pushing the release button

While driving on [XXX] at 65 MPH, without warning the sunroof spontaneously exploded and shattered. It produced an extremely loud bang, like a gunshot, startling me to where I almost lost control of the vehicle. There were no vehicles in front of us, no vehicles behind us, and nothing above us (not traveling under a bridge or overpass). We were traveling in the state of Mississippi at the time and it was 58 degrees and raining, NO HAIL was coming down ever. The dealer cannot explain why this would happen but would not cover it under warranty. The vehicle is brand new with 4,100 miles on it when this occurred. Insurance company is paying for the repair which is now complete. The shattered sunroof is thrown away but I have pictures of it right after it happened. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Sunroof exploded at highway speed glass was contained by interior fabric. Sounded like tire or gun shot . Was able to stop but frightened. Took to dealer and left it. Car has less than 3500 miles on it.

I have taken my vehicle back into the dealership because my car will sometimes unlock itself, I am constantly having to check the doors to make sure they are still locked and most of the time it has unlocked itself. Most of the time I hear it unlocking as I am walking away. It is very disturbing. It also beeps as if another vehicle is going to crash into me and most of the time there aren't any vehicles anywhere near me. The phone charger does not work, i have been having issues with this from the beginning. The steering wheel also says I have to put my hands on the wheel when I have them on the wheel. I have a video of the car going a lot of rpms and it barely moved, a golf cart passed me up. The car also locks up sometimes when I am backing up. I drive my parents to San Antonio for their Dr. appointments and am a little fearful of staying stranded either direction. My father is very ill and I am their driver. The dealer insists my car is the only one having these issues but I have read on reddit and other platforms of other Santa Fe's with similar issues. These issues do not occur ALL THE TIME, but this does occur at the most inconvenience time.

Have read lot of complaints from the I Hyundai form and this is happening to my 2023 Hyundai Santa Fe that the Shifter system malfunction! Service Immediately light came on and it would not let the car park, reverse, go into neutral had to turn the car off. then car had to be restarted in order for it to go into park. the car only has 7388miles.The car is being worked on today 3/112023

Whilst driving the vehicle a number of warning lights appeared on the dashboard. This occurred after the vehicle was brought to a stop at a stop sign. There were no outside influences before or after the warnings began. The vehicle remained operable and was driving back to our residence approximately 1 mile away. I made an appointment with the local dealership to investigate the issue. The appointment was made for the following day. Whilst driving the vehicle to vehicle to the dealership on the following day the brakes became temporarily inoperable forcing me to leave the road and hit the right hand kerb. After pumping the brake pedal several times the brakes re-engaged and I was able to stop the vehicle. The dealership have explained that a rear wheel speed sensor (ABS) had failed and was sending messages to the the braking system which made the braking system inoperable. The dealership replaced the sensor and at this time the vehicle is operating as expected.

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving 70 MPH, the panoramic sunroof exploded. The panoramic sunroof glass and the shades were closed. No warning light was illuminated. The vehicle was taken to the dealer. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 9,100.

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving on three occasions, at approximately 60 MPH, the cruise control was engaged, and the contact attempted to accelerate using the toggle and the vehicle accelerated to over 110 MPH. The brake pedal was depressed, and the cruise control was deactivated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 140.

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving 50-65 MPH, the vehicle stalled and decelerated to a complete stop with several unknown warning lights flashing on the instrument panel. The vehicle was restarted and operated normally. The contact drove the vehicle to the dealer where several fault codes were reset. The contact continued to experience the failure and returned to the dealer where the dealer replaced the throttle assembly and later replaced a front camera with a hard code. However, the contact stated the failure persisted. The vehicle was with the dealer but was not repaired. The manufacturer was also notified of the failure and provided the contact with a case number and a case manager to assist with the failure. The approximate failure mileage was 1,700.

Incident: I have been almost rear ended numerous, numerous times despite having my turn signal on an appropriate distance from my turning point. Safety Issue: The rear signal lights are small and are only located on the bumper. The location of these signal lights are way too low for most driver's to even notice them! The signal lights also look like reflectors on the rear bumper especially in broad day light, making the detection of a signal even more difficult! I do like the Santa Fe, it is my second one, but had I known that the turn signal lights were located where they are, I would have NEVER purchased this vehicle as the risk of getting rear ended is too high.

While parking my 2023 Hyundai Sante Fe, I hard pressed the break and pushed the Park button. The engine revved up and the vehicle took off instead of going into park; smashing into a building. The parking block was 6ft from the building. The engine accelerated to a high enough speed that it totaled the vehicle completely out. The engine code readings after the vehicle was towed to a repair shop was P0112 and P0114. The mechanic says that's the initial cause of the accident. The insurance reps are supposed to be following up on the mechanics diagnostics currently. There were no warning lights or anything on before the issue occurred as this was a brand new vehicle with only 8,000 miles on it.

Vehicle does not detect motorcycles in the blind spot. I did not look over my shoulder and began moving left with a turn signal when I glimpsed a motorcycle next to my vehicle. The motorcycle quickly swerved to the left and I returned to the right lane.

While merging into the highway at approximately 49 to 52 mph, acceleration was applied to merge into the highway between moving vehicles. The vehicle responded by greatly increasing the rpm but not applying the power to the wheels. The engine revved up with very little acceleration. After 5 to 8 seconds, the power was finally transferred to the wheels and the vehicle sped up. The vehicle behind me had to apply the brakes since I basically cut them off. This was the second incident of this type.

Throttle randomly cuts off or hesitates. It has done it about 15 times Dealer says no problem found. There is a lot of reports on the internet of the same problem.

Sunroof exploded while traveling at highway speeds causing glass to fall into the cabin. No impact from rocks, just exploded out of nowhere. Massive loud explosions sound

This same scenario has happened 3 times since I purchased this vehicle - first event at mileage of 6273, 2nd event @ 7586 miles, and 3rd event @ 12,506 miles. All events were the same - while driving, dash board light start to flash and the vehicle looses all ability to accelerate. For each event, we have been able to coast out of traffic, turn the car off & restart. Once the car is restarted the acceleration works again, but the check engine light remains on along with an error code of P065312 Possible Power Train Issue. We have been very fortunate each time that we were on a road where we were able to coast out of traffic, but if this happened on a busy Interstate or Hwy traveling at high speeds we could have been rear-ended. The vehicle has been to the dealership twice for service and no problems have been found. The vehicle will be returned to the dealership tomorrow for 3rd service attempt.

This hard brake peddle pressure issue started out immediately on an occasional basis but now occurs almost every morning on first start of the day. Press on the brake pedal - it's very hard to deflect - and if you don't overpower it to deflect the pedal enough to activate the brake lights, it won't start. Once you get it started the first time, brake operation will be normal for the rest of the day. A specialty maintenance blog has covered this issue comprehensively. The Hyundai Maintenance website is apparently aware of this potential problem. According to [XXX] , it is likely caused by a malfunctioning brake booster or vacuum leak and recommends taking the vehicle to your dealer for diagnosis and repairs. This is apparently a common problem across multiple Hyundai models since there are several threads on this subject on [XXX] : [XXX] [XXX] [XXX] [XXX] [XXX] I took my vehicle to the dealer where I purchased it and left it with them for a couple of days, Said they had thoroughly tested the vacuum line and found no leaks or problems and that the vehicle was performing as designed. Don't know how serious this is, but I have concerns. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Windshield started to crack after 150 miles on the car from driver side spreading across whole line of sight. No visible or audible rock hit the windshield

While parking, the brakes failed. Although the brake pedal was correctly and completely depressed the car failed to stop until it hit the building causing damage to structure and injuries occurred to passengers. The brake pedal pulsated but the car did not stop. Prior to this, the brakes would sporadically pulsate while braking. There were vehicle health issues that were reported.

About three weeks after we bought the SUV, a small rock hit the windshield while we were driving on the freeway, causing a quarter-sized crack. We had it repaired. A week later, two more tiny chips appeared on the windshield. We didn't even notice anything hitting the windshield, and we only drove it on city roads with normal road conditions. The windshield seems to have very soft glass and gets cracked or chipped very easily in regular driving conditions. We've never encountered windshields this weak in our 20 years of driving experience. We feel it poses a potential visibility hazard for the drivers.

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving at various speeds, the Forward Collision Avoidance system erroneously activated, causing the braking system to activate and the vehicle to veer to the left. The contact stated that the failure was intermittent. The vehicle was taken to the local dealer on several occasions due to the failure however, a cause for the failure was not determined. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 1,000.

Upon braking hard and suddenly due to being cutoff on the interstate, it felt as if the antilock brakes did not properly engage but rather grabbed/grinded/scraped. Only when I let off the brake did they disengage. This happened the first time within 2 months of owning the car and with less than 2k miles on it, at highway speeds (65-70 MPH) and this sensation has happened probably 4 times in the 7 months I have owned the car under various scenarios of stopping quickly. In addition, it recently happened when driving 25-30 MPH and coming to a normal stop approaching a stop sign - where it felt as if the brake on the front passenger tire grabbed/grinded/scraped (but not on the 3 other tires). I have taken the car back for inspection at the dealer twice, neither time have they found any issues. In addition, one evening the stability control light flickered, sounded as if the dash was frying/sizzling with no reason - roads were not wet, no leaves, grass or other debris, etc. and speed was 25-30 - this happened twice within 3 miles. Dealer found no issue with car after performing visual inspection of wiring, check of system for code errors, nor driving test to reproduce issue. Had the brakes failed, I could have been in an accident causing serious harm to me/my passengers or whomever I could have hit. I believe the ABS system needs to be replaced or reprogrammed but the dealer refuses to acknowledge a problem exists. Online forums indicate similar (and worse) issues, also with peopl

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving at night with the low beam headlights illuminated, there was a dark shadow present in the top section of the illuminated light field causing a visibility hazard to the driver. The vehicle was taken to the local dealer who confirmed the issue was present but informed the contact that the headlights were operating as intended. The manufacturer was made aware of the issue. The failure mileage was 10.

When traveling along the front collision warning system is triggered even though nothing is around the vehicle. The car remains running, but there is no response from the gas pedal. I have to coast to the side if possible or stop and turn on flashers (very dangerous on interstate highway). Once safely stopped, turning off the car and then starting again reboots the system and it runs fine until it happens again randomly. The check engine light stays on for a day, but does not light up the next morning. The dealership does diagnostics, but nothing shows up as wrong. It happens so fast there is no way to take a picture or video before the warning disappears. So far I have been lucky as this has happened at least 6 times. It is dangerous and I am terrified someone will not see flashers and run into me at highway speeds.

My 2023 Hyundai Santa Fe have a recall to fix the trailer hitch, since that I notice some issues with the shifting with a loss of power while driving, my car is 15k miles and showed a check-engine light. I made an appointment for the dealership the next morning. After two days, I was told that the car needs a new transmission. After 3 days still waiting for the car to be fix.

The contact owns a 2023 Hyundai Santa Fe. The contact stated that on two separate occasions while driving at approximately 65 MPH, the vehicle decelerated. The check engine warning light illuminated, and a message displayed on the infotainment screen indicating “Engine System Emergency, Take Vehicle to the Nearest Dealer”. The contact was able to veer the vehicle into a parking lot where it was idled. The vehicle was then taken to the dealer where the contact was informed that no appointments were available; however, the technician used a code reader that retrieved message: “5 Volts drop to the ECM”. The contact stated that the technician then pressed the START/STOP button to restart the vehicle and reset the check engine warning light. The contact stated that he was able to drive the vehicle back to his location where he parked the vehicle. The following day he restarted the vehicle however, the failure recurred. The dealer was notified of the failure and the contact was advised that if the check engine warning light was not illuminated there was no need to have the vehicle diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure, but no further assistance was provided. The failure mileage was approximately 1,108.

My 2023 Hyundai Santa Fe Calligraphy with 14k miles showed a check-engine light. I had noticed some strange behavior in the shifting with a loss of power while driving at low gears. I made an appointment for the dealership the next morning. Was told today that the car needs a new transmission.

Vehicle has just over 4k Miles on it. Several times I tried to accelerate and while the engine RPMs would increase, the vehicle would not accelerate. Very dangerous when turning right on a red light and when merging into traffic. I came close to getting T-Boned on 4 occasions, and rear-ended on 3 occasions. This vehicle is not reliable and puts passenger lives in danger. Today the "Shifter System Malfunction-Service Immediately" warning came on and I was not able to shift into any gear and the vehicle put itself into neutral. Looking at the forums, this has been a problem throughout the Hyundia vehicle lineup for years with the DCT transmission. I don't understand how they can continue to sell these vehicles when there is a known safety issue with the DCT transmission. I have tried to contact Johnson Hyundia in Cary NC and left multiple messages with the service dept, but they have never returned my calls.

Occasionally the cruise control when accelerating will exceed the set speed and continue to climb and I will be going 20 miles faster than the set speed and climbing. The only way to sop this is to turn cruise off, slow down and restart. My thought is it happens after I have disengaged the cruise and then when safe reengage which is done by pressing the switch straight down. In my previous vehicles I would push the control up. I may be doing this by accident and giving the system an unknown command. Whatever I am doing to create tis situation is too easy to do and creates a safety issue. this has happened multiple times.

When I tried accelerate, the car jerked and then the transmission began to slip and I coasted to a stop. I cranked the car and slowly began to drive the car while it felt like the transmission was slipping. My first thought was that the transmission was low on fluid but later found that this is a sealed transmission. Luckily there was no traffic during this incident. There was no warnings lights or any warnings whatsoever.

I was driving on the freeway when it sounded like an explosion inside the vehicle occurred. I was not sure what it was at first, and then I started to hear glass rattling in the sunroof area. I pulled over and looked on top of the vehicle and the sunroof glass has exploded. Nothing hit the vehicle, so heat must have caused the sunroof to explode. It was approximately 103 degrees outside per the vehicle's thermometer.

I purchased a new 2023 Hyundai Santa Fe and on multiple occasions when trying to accelerate the vehicle has failed to go above 30 mph. I have put on about 6,000 miles. When I pull over and restart the car. The issue seems to resolve. This is quite dangerous when trying to get on the highway or accelerate to pass for myself, passengers in the car and others. The dealer has not been able to repeat the issue. No warning or error codes appear. After repeated returns to the dealer, the dealer has now refused to review the vehicle without a $200 charge to investigate. I am happy to make the vehicle available for inspection.

The front collision warning/assistance system on this vehicle does not appear to be working. The dealer claims that it is working. It seems that the protocol for testing for proper function is flawed and no one is tacking ownership of this issue. They are saying that in order to test the system a near collision must be imminent and to simulate this puts the technician at risk of injury (understandable); Nevertheless, I have been in situations where I should have at least received a warning and there was none. On a test drive by the service manager with me in the vehicle the front collision assistance was verified on and active. The cruise control function was tested and worked to adjust the speed of the vehicle appropriately which tells me that assistance is available. It appears that the either the collision sensor is not recognizing collision danger or the danger message is not getting to the warning trigger and possibly the assistance trigger. This situation should be reported to the appropriate department a Hyundai for review.

May 5th 2023 my car was broken in to.The back passenger window was broken out and the steering column was tour out .The car was undrivable. The car was towed May 18th to Nalley Hyundai.I just got my car back today Aug 11. I understand Hyundai is suing TikTok I was given a number.She said when they go to court.When .

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving approximately 35 MPH, the downhill assist, traction control, auto stop, blind spot, and ABS warning lights illuminated. The contact was able to pull over and called the local dealer and was informed that the vehicle was safe to drive. While driving at an undisclosed speed, the brakes independently activated. The vehicle was taken to the local dealer, where it was diagnosed that the wheel speed sensor needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 2,000.

When driving in the rain, the driver side (left) blind spot is not functional. When the right turn signal is used, the camera shows the right side of the car and the triangle on the right mirror lights up if there is vehicle in the blind spot. In the rain, the camera lens is as clear as when it is not raining. when the left turn signal is used, due to poor aerodynamics, there is a large drop of water on camera lens which prevents driver from seeing the blind spot on the left side. The large drop of water is displayed on the dash instead of the left side of the vehicle.

Driving at 25 mph and the vehicle alerted "shift to neutral" and came to a complete stop and stalled. Had no warning, couldn't even pull to side of road. Could not start again and had to be towed.

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving at 75 MPH, the vehicle stalled and decelerated to 25 MPH as several warning lights flashed on the instrument panel. After multiple attempts, the contact managed to restart the vehicle and drove to her destination. The contact sustained severe emotional trauma due to the failure but did not seek medical attention. The contact drove the vehicle to the dealer where they informed her that the throttle body was defective and needed to be replaced. The manufacturer was also notified of the failure. The vehicle had yet to be repaired. The failure mileage was 2,689.

I was recently involved in a front side swipe accident where a person ran a red light and hit me while I was passing through an intersection. The impact was all in the front of the vehicle where the air bag had deployed. The air bag caught on fire within seconds after it had deployed. Thankfully I was conscious to where I was able to unbuckle my seat belt quickly and someone came to my aid quickly enough to where I was able to exit the vehicle safely.

Over the last Tom th, I have encountered some pretty scary issues with my brand new Santa Fe purchased in April. Last week, while driving, after I turned on adaptive cruise control, the system alerted me that “smart crusade control conditions weren’t met” and kept trying to engage the front left brake — this occurred three days in a row. After turning off the smart cruise control and entering residential roads, the front left brake tried to engage in a manner that seemed consistent with ABS issue. I brought car in two days later to Dublin Hyundai and they said they couldn’t find anything wrong with it. I picked the car up yesterday morning and then last night while driving on the highway, it alerted me that I need to “check highway drive assist system” and a warning light came up. After about 5 minutes, the car jerked me incredibly hard to the left on the freeway and then athe light turned off. Then two days ago, I was driving my car on the highway the car randomly said “emergency braking system activated” twice, while going 70 on the freeway in the middle of nowhere. This was while driving safely and no cars nearby either time. I looked online and it appears this is a problem that’s occurred in many Santa Fe’s, so there is clearly an issue with manufacturing (which I’m assuming is the same case as the previous issues I’ve run into).

2023 HYUNDAI SANTA FE- Consumer states: I saw the notice on TV regarding a recall on my specific vehicle for the trailer hitch issue. I immediately contacted my local Hyundai dealership and scheduled an appointment. The Service Department concluded that my vehicle was included in the recall, I was told that they had not yet received a recommendation from Hyundai on a remedy for this fire hazard. My invoice indicates "your vehicle does have a Genuine Hyundai Towing hitch and 4-pin harness installed, there is currently no remedy available however you can continue driving the vehicle, but it is recommended that you park the vehicle outside until a remedy has been performed.April, 2023, I called the Hyundai Corporate Office and was assigned a case manager, Rohan. I suggested that Hyundai buy back the vehicle, with 5000 miles on it, because if I cannot tow my boat, it's useless to me, and also because I cannot park the vehicle in my heated 3 car attached garage. Rohan said he would try to find a local business to install a new hitch. I would have pay for it and submit the bill to Hyundai for reimbursement. The next time I heard from Rohan, he instructed me to find a local business to install the hitch. I did contact a couple local businesses and they all indicated that they wanted nothing to do with the Hyundai recall. My question to Rohan was, if he thought a private business could do the fix, why hadn't Hyundai come up with a timely fix, given the potential devastation that the

I was driving on the highway and the car phantom emergency braked for no reason at all.

Hello, I would like to point out a safety issue many new car manufacturers have actually implemented. I've witnessed this safety issue at two accident myself. Most automakers today lock your car doors automatically unnoticed by most drivers . The door locks are operated by electrical current only, if a accident destroys your car battery mechanically or by shorting out the battery in water, a person is unable to unlock their door. Thereby trapping them inside their car. In case your car is on fire or submerging in water you are trapped. There normally is a mechanical lock release if you are aware of how to use it, most people today if questioned have no idea how to do that. My son recently purchased a new Ford pickup that when the doors are locked the little plunger that you would pull up manually to release your door lock is recessed in the panel to the point you cannot grab hold of it. GMC truck owners are told to just pull the handle three times and the door will unlock, this is a true statement, if, the battery is connected. Research will show many people drowning and killed by automobile fire, When they have been perfectly physically capable of escaping the car If the door lock had not prevented them from escaping. It Is such a simple fix, just by redesigning the mechanical operation to only luck the door from the outside not the person inside. This auto lock future can not be changed on this car as i have requested. Please contact me with questions. Thank you for your he

The contact owns a 2023 Hyundai Santa Fe. The contact stated that the RPM would be elevated while the vehicle was idling. The failure recurred while the brake pedal was depressed. There were no warning lights illuminated. The failure recurred approximately 3-4 times within 30 days. The failure recurred approximately 15 times within 6 months of owning the vehicle. The contact took the vehicle to the dealer who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 12.