2023 Hyundai Santa FE complaints

Early March 2025 the vehicle was put car in park, got out of car to close yard gate, turned around to walk back to car but car was rolling forward and hit the flat bed trailer causing approximately $5000 in damage. It was put in park before getting out but jumped gear before getting back in. Another common problem is slamming the emergency brake on when attempting to drive. Was at a red lite left turn stop sign with foot on the brake. When the light turned green took foot off brake & put foot on accelerator to go forward, the car slammed the emergency brake on. This has happened approx 6 times in the 1-1/2 years of ownership.

The windshield showed a semi circular crack on the upper center directly below the rear view mirror cluster. It happened during a day of exceptional heat there is no indication of impact and the crack is symmetrical.The plastic cover of the rear view mirror broke simultaneously with the appearance of the windshield crack.

On [XXX], a 2023 Hyundai Santa Fe SEL (VIN: [XXX] ) spontaneously caught fire ~8 hours after parking, per fire report (Walla Walla Fire Dept.). The fire destroyed the hyundai santa fe sel engine compartment and totaled 5 vehicles with a total value of over $400,000 not including personal property to the parties involved. I was not the Hyundai’s renter/operator; the vehicle was rented by a third party from Enterprise. Despite no active recall for this VIN, the vehicle contained: Mando ABS module, Mando EPS module similar to known defective parts of the same year, and Hyundai Mobis tow hitch harness, all of which have known defect/recall history in similar make/Model equivalent vehicles. This case may involve VIN exclusion errors or latent product defects similar to recent defects INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Transmission caused vehicle to loose speed on grade posted speed 70mph I could not get over 35 Transmission stuck in 3 gear or would stay in 8th gear unable to gain speed almost got rear-ended vehicle has a 8 speed automatic transmission it will not shift properly loss of power account improper gear for speed

On two separate occasions, I was a stop light in high traffic. I was unable to drive my vehicle when the light turn green because of no power. A message display prompting me to "shift to P or N to start engine." Unfortunately, that didn't work. I had to sit there for a few mins, signaling other motorists to go around me. Eventually, I had to restart my vehicle. I panicked because I felt unsafe as I was blocking traffic. I took my vehicle to the dealer and was told that there were no code after the diagnostic test but yet the technician told me the door on the driver side is not aligned and I need to take it to a mechanic. I never got any alert that my door is open so that diagnosis didn't make sense. I took my vehicle le to the mechanic to check the alignment of the door who in return told me that there was no issue with my alignment. I am scared to drive my vehicle because I don't want to cause an accident.

The car loses power. The battery and key ignition light keep coming on. A message displays auto engine off. Please shift to n or p and start engine manually. After communicating and showing video proof of the incident, the dealership replaced the alternator and battery. The issues started around 5000 miles. The infotainment system lags and the car lags. Sometimes I am left on the road because the case refuses to cut on or off.

When accelerating from a stop, my car will not go over 20 mph. It just revs up like it’s not changing gears . I have to pull over and park it. It runs fine afterwards. This does not happen all the time. Usually it happens once a month. It’s been to the dealership 3 times. They drive it around the block and tell us that they can’t replicate the problem. Therefore, they don’t troubleshoot anything and return the car to me. I’m truly scared to drive it. I wrecked twice at a red light intersection.

My car won’t shift on the highway and all of a sudden I can’t drive more than 40mph. It also has not wanted to let me press on the gas and make it go as I’m driving bc Its jerking 4 or 5 times before it’ll register and go. Also, not too long ago, I was in a parking lot and went to leave and my car never notified me that there was a huge pillar next to me and I crashed into it, it was in my blind spot and couldn’t see it. My car has had many many other issues in which I can’t list, but I truly bought a lemon.

Driving on [XXX] in Victorville; sunroof shattered. Originally thought it was a tire blowout but there were no indications on the dash, no alerts, etc. Pulled over when safe to inspect vehicle and to make sure my kids were safe. Upon pulling over and exiting the vehicle, I started to make my way around the car to check the tires. All 4 tires were completely fine. Made a second round to double check everything, see if something went under the car, there was no sign of any damage. As I was getting into the car I noticed a huge hole in the sunroof, it was completely shattered. Safety of my family was at risk but fortunately it was a chilly morning and the sunroof was closed. Vehicle is available for request if needed but it currently located at the local Hyundai dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The purchase price was $35,800. As of today, I have paid a total of $24,590. The vehicle has a manufacturing defect that has significantly impacted its performance. The engine has been problematic, as it appears to be consuming oil, and it often fails to start on the first attempt, requiring me to press the button multiple times. The most concerning issue is that the car can unexpectedly shut off while I am driving. Additionally, there is an abnormal noise coming from the engine. I consider this situation serious, as it poses a significant risk to my safety. These symptoms appear on January 13/2025. I want to emphasize that I have completed all scheduled maintenance on time. I filled out reports regarding this issue, and I have attached two reports that confirm the vehicle is consuming 2 quarts of oil per 1,000 miles, vehicle is consuming oil due manufacturing defect. These reports were given to me by Safford Hyundai.

I had adaptive cruise control on and debris hit my windshield and I went into the rumble strip and eventually into the guard rail where the car essentially pingponged from there until it eventually stopped when the metal hit the front. It appears the emergency brake did not activate and the lane keep did not activate. My air bags did not deploy.

The car has shut down unexpectedly for at least six times while driving at roads and highways. When this happens, engine stalls and nothing works and all alarms and check lights turn on and activated. Driver has to pull the car to the roadside which cannot be imagined when in a highway with all cars driving at 65-70mpH and the car suddenly slows down to stop. The other problem is that when the car is turned off and on again, all alarm and faults go away, and it can be driven again! It clears all safety and alarm checks and lights and behaves like nothing has happened. Car was bought on June2023. The first incident happened on Aug2023 and the next one on Sep2023. The next incidents on Feb2024, Sep2024, Nov2024 and the most recent on March 2025. The car has taken to the Sport Durst Hyundai dealership (Durham, NC) after incidents, however dealership did not perform any repairs in first four times claiming they could not duplicate the incident! (service reports attached for 3) After the third incident, we opened a case with Hyundai company trying to invoke the Lemon law, but our request did not go through despite all evidence we provided. Shamefully, their final suggestion to us was to sell the car! This was around March/Apr 2024. (Final decision letter attached) On fifth time, the driver did not shut down the car and towed it to the dealership while leaving electrical system on. They checked the car and claimed they found the cause and changed a part from car claiming it has bee

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted. There was no warning light illuminated. The vehicle was towed to the dealer but was not diagnosed or repaired. The contact stated that the failure reoccurred, and the vehicle was towed to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 55,917.

The accelerator stuck and the vehicle crashed. The vehicle is totaled. It happened [XXX]. No one has yet inspected the vehicle. I notified Hyundai about 5 days ago. The phone number of the towing company is 516 433 1011. The following link is a YouTube video of the accident: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Every time it rains, one of the dual tone horns will fail. I have had the horn replaced 2 times. I am beginning to have a problem with the horn again after this last rain. It is a matter of time before it fails completely after a rain and becomes unusable. I feel this is a significant warning feature that MUST be reliable.

Took vehicle to the dealership on Jan 3, 2025 for the 15k mile oil change. They informed me they completed the multi-point inspection, with no issues discovered. Jan 10, 2025 I attempted to us the horn and discovered it didn't work, so I immediately went back to the dealership and scheduled a service, to troubleshoot the horn. Jan 20, 2025 dealership discovered both horns were defective and replaced both. Very strange for both horns to die so early. 🤔

The sunroof glass violently shattered/exploded while driving the vehicle. The manufacturer claims the window meets current standards and is not defective. The curtain or fabric cover was extended covering the glass panel otherwise the driver would have been covered with broken glass.

In January, 2024, my vehicle (2023 Hyundai Santa Fe) started shuddering when brakes were applied at high speed, on quick or hard stops, in stop and go traffic, and especially going downhill. I had only been driving the vehicle for about 5 months. I took the vehicle to an independent mechanic, who explained that my front rotors had burn spots. He recommended that I have them resurfaced. I did not want to pay for the problem to be fixed when I believed it was a factory defect and should be covered by warranty. I asked the Mission Hills Hyundai dealership Service Department to investigate and correct the problem, because I felt that my family's safety was jeopardized by faulty brakes. They showed me the burn spots on the front rotors and recommended resurfacing. They said I could wait for the pads to wear down and do the resurfacing at the same time as the pad replacement. Their estimate for resurfacing was higher than the one from my mechanic. I found a Hyundai Technical Service Bulletin, Number 23-BR-004H, which described the exact defects of my vehicle. I returned to the dealership with the TSB in February, 2024. They replaced the two defective front rotors and front disc pads at no charge. The shuddering was no longer evident, and I thought the problem was resolved. However, 10 months later in December, 2024, I once again experienced the shuddering while braking on the freeway while going downhill and when slowing for stops from high speed. Since I had been told that the new

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving at approximately 55 MPH, the horn was inoperative. No warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the horn needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 7,600.

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving 45 MPH, the message "Shifter System Malfunction - Service Immediately" was displayed. The contact stated that the vehicle failed to shift into the park or reverse. The contact activated the parking brake and turned off the vehicle. The vehicle was towed to the dealer but was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 18,192.

While travelling at highway speed, attempted to accelerate to pass slow traffic. Rather than accelerating, the car hunted for a gear, and wouldn't shift properly. The car downshifted but engine would not go beyond 4000 RPM and speed remained the same. This has happened multiple times. By unexpectedly not accelerating, this created a risky situation by not allowing car to pass slower traffic as expected creating a potentially dangerous situation. (Video of one of the instances exists). No warning lamps, messages or symptoms occurred up to that point. Car was brought to dealer but since no codes were contained in the computer, they said there was no trouble found.

Automobile approached and stopped at stop sign. When accelerator pressed to continue, car remained in place, shuddering (as if transmission were slipping),and making significant noise. Car would not shift out of gear, nor move. Operator shut off car and then restarted car. Car started normally and was in park without shuddering. Expectations at busy intersection was that it was my turn to move and did not do so, creating doubt on what my car might do next. Traffic flow was briefly confused and some drivers honked and were unsure what they should do. This could have caused an accident with an impatient driver re-ending my car, or with others going through the intersection "out of turn" and unclear on my situation. No lights or other warnings were displayed before this incident. It has not re-ocurred. I brought into the dealer who had no other reports of this type of behavior.

Horn Failed. Would not sound, making it impossible to warn people if car might hit them or their vehicles or about any other issue they would need timely reporting about. Car was brought into dealer and 2 horns assemblies were replaced as non-functional

I purchased my 2023 Santa Fe brand new off the show room floor in Jan 2024. After about 6k miles when braking on the highway the entire vehicle would shudder and shake including the steering wheel. I took it into the dealership where I was informed this is a KNOWN ISSUE with this year/make/model with the rotors. They claimed they would turn the rotors but if the issue persists they would replace them. About 2k miles later (apx 2 months) the shuddering happened AGAIN. So I made an apt to get them replaced where the new service tech tried to tell me again this is a KNOWN ISSUE but now I would be responsible for a $250 replacement of the rotors. I refused to pay as they are within the 12k or 1 year warranty and they refused to replace them. That service tech also said the day prior he had to deliver that news to 4 OTHER patrons about the replacement of their rotors. I feel extremely unsafe in this vehicle and the issue is still not fixed as I have a claim in process with the manufacture directly. The claim was put in on 12/7/24 where I was told I would be contacted within 2-3 BUSINESS DAYS by a manager due to my claim being escalated. It is now 12/15/24 and still NO CONTACT from Hyundai. The vehicle shuddering is increasingly worse and worse and I feel very unsafe in this suv.

Just purchased the vehicle one week ago. I bought it used from a Hyundai dealer. Just discovered that the horns don't work, either the high tone or the low tone. I discovered it when I went to use the horn to alert a driver who was coming into my lane, pushed the horn on the steering wheel and nothing! I've checked the fuse and it is fine. Internet research shows this to be a prolific problem with Hyundai's. Because the horns don't work, neither does the alarm system. I tested by pushing the panic button on the key fob. The lights flash, like the alarm is trying to fully work, except the horns don't sound. I will be bringing it to the dealer as it is still under warranty.

Shuddering Issue with Current Vehicle: - Problem: Progressive shuddering during take-off, accelerating, slowing down, and braking uphill.

First- it has been reported to dealer at least twice when car was in for other service. They said they could not reproduce. When speeding back up from a stop on near stop, especially in a right turn, the engine will not accelerate. After a second or two it finally takes off. During this time, I fear getting hit by another vehicle, either from behind or to the side. It is very scary and puts me and my passengers at great risk! There was no warning indication at all. The date mentioned was the most recent time, but the issue has been happening since the car was brand new. Again, NO help from the dealer.

Emergency brakes engage while driving for no apparent reason. This has happened on several occasions over the last 6 months.

The seat belt in the middle seat of the second row did not work. And it was not fastened. So when braking, my child was thrown toward the center console. I think it's a big safety issue if the seat belt doesn't work.

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while his wife was driving at approximately 65 MPH and depressing the brake pedal to slow for a vehicle that had passed and switched into the lane she was driving, the vehicle was shuddering. The contact stated that as soon as she had stopped depressing the brake pedal the shuddering ceased. The contact stated there was no warning light illuminated. The contact stated that the shuddering when the brake pedal was depressed was intermittent but was recurring at various speeds while slowing down. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the brake pads and rotors needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 18,756.

Brake rotors warped. Beginning at approximately 5k miles, the steering began exhibiting a juddering upon applying braking. Over time, the juddering became more pronounced. At approximately 15k miles, I took the vehicle to the dealer. The dealer confirmed that the brake rotors were warped. The defective brake components put my safety at risk, as well as the safety of my passengers and others traveling on the road by impairing my ability to safely stop the vehicle and impairing my ability to safely operate the vehicle while braking. There were no safety lights or warnings. I am aware that there has been a technical service bulletin for this exact issue for this model/year vehicle. Neither Hyundai nor the dealer ever altered me to the possibility that the brake rotors might warp due to defective components. Hyundai has thus far refused to cover the full cost of repairs, totaling over $1,400.00.

Currently have 518 Diagnostic History Codes (DTC)in memory. Additionally, I have 3 Active DTC’s. The codes are: DTC C160C87 DTC System CHASSIS DTC Sub System LKAS, and DTC C160C87 DTC System CHASSIS DTC Sub System SCC, and DTC C163881 DTC system CHASSIS DTC Sub System SCC FIRST OCCURRENCE: during actual assembly in Montgomery, AL plant. I have asked three Hyundai Service dealers for help. All have tried. Noting noted that contributes to the issues above. At first, my dealer replaced the front camera. Was told it was a heating issue. I have contacted Hyundai BLUELINK service for help. An information report was filed, TWICE. The first report I received feedback that Hyundai’s engineers had corrected the issue. On the following day, the codes returned. A second concern was filed with Hyundai BLUELINK. Hyundai Motor America Case#: [XXX] to wit: “Thank you for contacting Hyundai Motor America. We are in receipt of your e-mail and one of our representatives will get back to you shortly. Sincerely, Hyundai Motor America” Is my vehicle going to fail and cause me injury while operating it on an Interstate highway? This is quite concerning as I drive my car. All I want from Hyundai is to get this issue repaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SAFETY ISSUE: EXPLODING SUNROOF While driving my 2023 Hyundai Santa Fe Limited to work approximately at 6:15AM CST on 9/30/2024 on I-170 southbound in St. Louis, MO, the panoramic sunroof exploded. Car systems did not contain an indicator light or alert that the sunroof was stressed and about to explode. No debris (stone, rock, tree branch, item falling off a car or truck) or falling bird causing this sunroof damage. After the sunroof explosion, I continued driving. No other damage to my automobile or any other car on highway.

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving approximately 35 MPH and attempting to accelerate, the vehicle failed to respond or accelerate as intended. The vehicle started to decelerate and lost motive power. The contact steered the vehicle to the shoulder and parked the vehicle. After restarting the vehicle, the failure was self-corrected, and the vehicle operated normally. The contact stated that the failure reoccurred several months later. The vehicle was taken to the local dealer who was unable to duplicate the failure. The vehicle was not repaired. The failure mileage was 9,500.

The vehicle's software update initiates upon start-up without the option to delay to a different time. The three updates I've received this year have taken 20-30 minutes each to complete, while I'm traveling. These updates disable hands-free calling, all media and GPS. I can't confirm if any other vehicle safety components are disabled. I don't use them. I contacted my dealer and they stated that's how it works, and there is no option to delay the update. When the update initiates it states the update can continue without the vehicle "ON". Wouldn't it be safer to have the ability to schedule it to a later time when the vehicle isn't being used? Similar to a cellphone update?

The forward collision warning system engages and slows the car, often very abruptly, when on the highway and only when cruise control is on. It happens after we have been on the highway for a few hours, thus the dealer cannot reproduce the incident. It happens a few times on every road trip and is very disturbing when there are no other vehicles or obstacles in the road or nearby. We have reported this to the dealer several times and they can find nothing wrong. I provided a photo to the dealer of the dashboard showing the cruise control on, the forward collision system DISENGAGED, and the forward collision warning activated. Dealer states they have recalibrated the system but can replace no parts unless a part is found to be faulty. The latest suggestion yesterday from the dealer was to "get out" of the car before the issue gets worse.

I purchased a 2023 SantaFe brand new mid-January, In June I noticed an issue with the car. I called Steele Hyundai in June to get an appointment and was told by Margarita that they didn’t have availability until September. REALLY. So, I went online and filled out an appointment and got an earlier appointment for August. Crazy Right? I then contacted Hyundai corporate to file a complaint, and was given a case number and Tina is the case worker. I brought the car in on [XXX] and left it there till [XXX]. Problem ended up a transmission needed replacement. WOW, quality!! I picked the car up on that Friday and it sat in the garage during labor day weekend. I first got back in the vehicle on Tuesday, [XXX] and knew immediately it wasn’t fixed. I decided to go to a different dealership for service World Car Hyundai in San Antonio and made an appointment for [XXX]. I called [XXX], spoke with Todd and explained needing a loaner. He asked me what I was bringing it in for, told him I had the transmission replaced. He said to give it a week to get the computer to adjust to my driving. SAY WHAT? So, I did and no bueno. I called again on Thursday, [XXX] to bring it in to World Car and spoke with Justin and made an appointment for Tuesday [XXX]. On Saturday, [XXX], we took the car to Austin for my husband to determine what he thought, he said, “this car isn’t drivable”. On Monday, [XXX], I cancelled my appointment for World Car because Todd said Steele knows the history of what work they d

Vehicle sun/moon roof exploded/shattered while driving on the highway with no apparent external cause. Sunroof was closed, driving middle lane, slightly below speed limit. Fortunately the material blind was closed otherwise the glass could have struck the occupants. Drove to manufacturer dealership who insisted it was a stone and not a manufacturer defect and to claim through insurance, which means a $1000 excess. I know this happens on various vehicles, noted on many forums.

I was driving the car moving in reverse to exit my driveway. I placed the car in Park and while the engine was running I exited the car. Upon exiting the car, the car immediately started to roll forward and crashed through my garage door leveling it to the ground. The car continued moving forward into the garage and came to a stop blocked by built in shelving at the back end of the garage. I could have been injured had the car started to roll while I was exiting the car or had some been in front of the car. No warning lamps or messages prior to the incident. The car has a safety feature if moving in Drive or Reverse and the driver door is opened the car shifts into Park. That feature failed. The car was inspected by a Hyundai dealer and claim no error codes found and dismissed any other information as provided in this report

The contact owns a 2023 Hyundai Santa Fe. The contact stated that the horn was inoperable. The lower horn sound had dissipated. Then shortly after the higher horn stopped working. There was no sound when the horn pad was depressed. There were no warning lights illuminated. The vehicle was taken to the local dealer who informed the contact about the cost for the repair, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, opened a case, but no additional assistance was provided. The failure mileage was approximately 72,000.

Driving at a low speed and blind spot warning light comes on, then all warnings light up and car loses all power and goes into limp mode. Engine light stays on, but will start back up after it is shut off, open and shut car door and restart. Engine light stays on. Has happened to me three or four times. In the past, the engine light will eventually go off before I can get it to the dealership. Hyundai said they couldn’t duplicate the problem last time it was taken in, so nothing could be done. Gives error code P063512 each time and says EMS which I assume means emissions.

A few times recently our car has had a hard time starting even though it's only a year old. It's like it's having a hard time turning over. And then when driving, it has a hard time accelerating - it almost feels like the car is in neutral while trying to drive. It jerks and shimmies to the point where you have to pull over to see what's going on. We were on a pretty busy road and couldn't accelerate to the point of safely merging into traffic. An online forum said it was a "loose ground" that's causing the acceleration issues.

I was driving down the expressway and my sunroof exploded. It scared me so bad that I swerved and almost lost control of the car. I thought something hit me.

Driving up steep hill to my mom’s house car would not drive up, as it hesitated I pressed gas pedal to no avail. I turned off car, got out & nothing was blocking me. Turned car back on & accelerated, this time it went forward.

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving at various speeds, the Emergency Braking System was erroneously activated, causing the vehicle to abruptly stop in the middle of the road. During the failure, the message "Emergency Braking System Engaged" was displayed. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The manufacturer was not contacted regarding the failure. The failure mileage was unknown.

Horn does not function. Trip to the service department and was advised it’s a known issue and they will call me when one comes in. This car is one year old and the horn not working is a major safety concern for me. A search online shows this is an issue for several buyers without a recall notice.

There is an extreme amount of hesitation/delay from when you depress the accelerator and when the vehicle accelerates. I have had multiple incidences (both from a complete stop and while already moving) where I depress the accelerator and there is a concerning amount of lag time before the vehicle initiates movement. This has almost led to multiple accidents. This defect happens in all drive modes. This issue appears to have gotten worse over the time we have owned the vehicle. We did not notice this issue earlier on. We bought the vehicle brand new in Dec. 23.

Several times lately of extended crank. Saturday evening, car had been parked for 4 hours, did remote start and had extended crank of about 2 seconds. Car ran for about 3 minutes before we left. We left home and hit main road, tried to accelerate and vehicle seemed to go into limp mode. Would keep cutting the fuel out if tried to accelerate even above 40 mph. No check engine light came on. Put in neutral, could not get above about 3500 rpm. Vehicle was in smart mode where decides which mode to be in (normal, fuel economy or sport), when would try to accelerate it would try to change to sport as it knew power was not there. Was on a 6 lane highway and could not get up to speed. Finally was able to pull to side of road, shut engine off, waited a few seconds, restarted and issue went away, still no check engine light. I have contacted my local dealer, they said they have seen on another vehicle, was not sure of outcome, having service manager call me. Lots of complaints online forums of similar issues.

Tire inside sidewall blew out on rear right tire. No curb, no pothole. 40mph speed

I was driving at around 11 a.m. on a city road at about 30 miles per hour when front passenger tire suddenly popped and car began to swerve almost colliding with vehicle in adjacent lane. The TPMS alert showed up on dashboard after the tire popped. There were no potholes or any objects that the car hit. The car along with tires had been inspected during routine maintenance at the dealer five days prior to this incident and no issues were found on tires or any lights on the dashboard. There were also no symptoms leading up to the tire suddenly popping. I contacted the manufacturer who referred me to an authorized center. After submitting the claim at the authorized center, they provided a replacement 255/45R20 at 50 percent discount.