2023 Hyundai Santa FE complaints

Horn stopped working at 47,474 miles Check Tire Pressure System light is on, poor sensor at 45,650

My panoramic sunroof spontaneously blew while driving on freeway

Horn completely out, yes available. I was unable to warn another driver from entering my lane several times. Warn a pedestrian from stepping out into traffic. Confirmed by the dealer. The horn was Inspected replaced at my own cost on March 2025 by December 2025 the part is no longer operational. I asked the dealer to honor the warranty they declined saying the mileage was passed the warranty terms.

Fuel injectors are bad. The car misfires, I smell gas, runs rough. They fixed one the second week of December 2025. I had the same symptoms when my light came on again on December 23,2025, they said they couldn’t find anything and gave me the car back. On January 3, my engine light came on again, I had warnings sent to my email and phone app about potential engine failures they said today ( 1/6/26) that it was another fuel injector and was told they would not replace the rest until they went out. When I asked them how safe I would be on an upcoming trip, I was told to just check the car every day before I go!

I stopped to fill the gas on my road trip and the gas panel would not open. As a single women driving alone this is not ideal. It took 45 min of continuous unlocking/locking with pushing to get it to pop open. There needs to be an alternative/emergency handle to pull so this does not happen again. I was standing in 32 degree weather the entire time! NOT SAFE

Both horns have failed for the second time since the vehicle was purchased new in November 2023 and is currently showing 25,000 miles. The first set was replaced under warranty at a Hyundai dealership approximately 1 year ago. Not having a functioning vehicle horn is a safety hazard that would fail annual vehicle safety inspection testing in my state.

My back up camera is not working properly. The picture at times is scrambled and starts floating around on the screen. This was not the first time this has happened. I reported it to the dealership service department when I first noticed, about a year ago or longer. They updated the software and told me that would correct the problem. Clearly it did not correct the problem, if it is continuing to have issues.

Both horns on my 2023 Hyundai Santa FE have failed 3 times. The first set was covered under warranty (3/24), the second set cost $499.64 (3/25). Now both horns are nonfunctional after just being replaced this Spring. After reviewing many complaints on the Hyundai community form, it is very obvious there is a major issue with their horns ( and not just the Santa Fe model). Twice this week I was in need of my horn to alert other drivers but instead had to make quick maneuvers to avoid an incident. My vehicle currently cannot pass a state inspection.

The horn has broken 4 times. I was told that it is a design defect in the car and there is no permanent fix. Water gets in to the horn when it rains and because of the location of the horn it would have to be moved to fix it. Hyundai is aware of this safety issue and has not issued a recall because there is no permanent fix. They are supposed to be buying back my car but are dragging their feet. I'm sure this is an issue in more than just my car and it's very unsafe for the horn to just stop working.

The vehicle cannot pick up speed, and it is displaying the DTC- P1C2D03. This is similar to the issues that led to "Safety Recall 236 to repair a condition involving the 8-Speed Dual-Clutch Transmission (DCT) system" in earlier model years (till 2022) for certain Hyundai and Kia vehicles. NHTSA should issue a recall for 2023 model years also as Hyundai has not addressed this issue to the fullest extent in 2023 model years.

On a clear road a sencor comes on detect comes on says detection collision. The breaks come on when you are traveling on interstate or two lane roads. When you are traveling 75 mph and breaks come on all of a sudden on the highway. We are lucky we never got hit in the back of the car going that fast. We will stop 75 to 35 mph in 10 seconds.

At stop sign and car with auto start stop on and at the time of releasing the brake, car was not able to start engine. Car had to be shifted to parking position to start engine.

Horn has failed 4 times

Horn has needed to be replaced twice. Stops working for no apparent reason.

Component/System: Automatic Emergency Braking / Forward Collision-Avoidance (AEB/FCA) system and/or Electronic Parking Brake (EPB). The vehicle is available for inspection upon request. What happened: While driving my 2023 Hyundai Santa Fe (VIN: XXX) at highway speeds, the vehicle suddenly and aggressively applied the emergency braking system on two separate occasions within the same day (approximately 45–60 minutes apart). In both instances, the red emergency braking warning lights illuminated on the dashboard, and a warning sound activated. There were no vehicles, obstacles, or hazards in front of me either time. The braking was forceful and abrupt, causing rapid deceleration at highway speed. Both events occurred under normal, clear driving conditions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) Safety risk: My safety and the safety of other drivers were put at significant risk. Sudden unintended braking at highway speeds can easily lead to a rear-end collision since the deceleration was not caused by driver input and gave no warning. Reproduction / dealer confirmation: The dealer has not been able to reproduce the issue, and no diagnostic trouble codes have been found so far. The vehicle is currently at the dealership for inspection. Inspection: The vehicle has been inspected by the Hyundai dealership, but the cause has not been identified. No manufacturer field engineer, police, or insurance inspection has taken place yet. W

The sunroof on my 2023 Santa Fe exploded.

The vehicle's software was updated on Oct 21, 2025. The software has serious flaw. When driving on slight incline on the passing lane the vehicle will apply the brakes without warning. This has happened 3 times. At times, when vehicles were following me they also had to apply the brakes unexpectedly. Had they not applied their brakes, they would have rear ended me at highway speeds. I also recall that there were no vehicles either in front or to the right ahead of me when it occurred. Also there was a guardrail on the left side of the highway at the time. This did not occur with the previous installed software. Every time this happened, the vehicle was in cruise control and driver assist was ON to keep vehicle in the lane.

The vehicle front brake disks are not compatible for this vehicle. The action of braking causes heating of the disks. The disks warp due to the heat. The result is when braking at highway speeds, the entire front end vibrates excessively. This is unsafe in wet or snowy conditions as this greatly decreases the braking efficiency. The first time this was observed the vehicle had 22,000 miles and the dealership machined the rotors. The second time it happened at vehicle mileage of 32,000. Once again the rotors were 'machined' by the dealership. The action of braking at highway speeds and the resulting front end vibrations is a troublesome event. If this occurs a third time, I will try to find and install non-Hyundai disks.

Was driving at 10 MPH on highway car began to cut out run rough and produce an extremely pungent smell of gasoline.. then stalled.. vehicle serviced and low pressure fuel injector had a leak causing fuel to spill onto the vehicles starter causing it to fail as well.. both were replaced under warranty by dealer. Highly concerned about fuel leaking from injector system onto a hot engine and electrical components and the aerosolized fuel. Police advised not to start vehicle due to fuel leaking and smell.

I was in a car accident on September 30, 2025. I was hit from behind by a dump truck and was pushed into the car in front of me. My seat belt in my Santa Fe did not tighten, and my head hit the steering wheel. There is something wrong with the seat belts. I was going to take it to the dealer to check after repairs, but my car is a total loss. Just wanted you to know the seat belts failed, and it could happen to others who own this type of vehicle. The air bag did not deploy, but my understanding is that the car has to be going a certain speed.

Vehicles' charging side deck will heat up any phone we put in to charge inside that slot. We brought this to the dealers attention a couple times but they stated I needed to pay a service fee to have it looked at. It began happening a few weeks after we purchased the vehicle. We have not used the port ever since.

Horn No longer works in vehicle - A major safety issue

I have had 6 car appointments and on my 3rd horn replacement in this car. It goes completely out and it is a safety hazard to not have any horn. It loses both the high and low pitch horn

My 2023 Santa Fe Limited has 3,000 mils on it. At least four times it had low speed hesitation (lags then revs up for a few seconds). It’s a problem with the DCT (Dual Clutch Tranny) Hesitation pulling onto a highway poses a significant risk of a faster car colliding into my car. I called my car dealer and the service manager said they know they are having problems with this. He said they tried everything to remedy the problem but, there is no solution. They said the only way not to have the problem is to get a different car!!! Hyundai should have a recall on this hesitation matter before someone gets injured or killed. It’s a safety issue. The last time it happened will be the date of my incident report.

Driver and passenger seatbelts not always latching or becoming unlached while driving

On [XXX] in Rehoboth, DE, my 2023 Hyundai Santa Fe experienced a sudden and complete power failure while reversing out of a parking spot. All electrical systems shut down—including propulsion, dashboard lights, and emergency brake—causing the vehicle to roll backward into oncoming traffic. No warning lights appeared beforehand. After about an hour, power returned on its own. A passing police officer witnessed the situation and a report was filed with the Rehoboth Beach Police Department. On September 6th, Hyundai service performed a diagnostic scan of the engine and transmission systems. No fault codes were found, and the issue could not be replicated. After sitting overnight, the vehicle restarted normally and passed a road test. The dealership documented the incident but returned the vehicle without repair, stating: “Cannot duplicate concern at this time.” I was advised to tow the vehicle in if the issue recurs and, if rolling occurs again, to use a wheel chock. I purchased this vehicle new in 2023. It has only 40,000 miles and is covered under a 10-year bumper-to-bumper warranty. A failure of this magnitude—especially during a basic maneuver like reversing—poses a serious safety risk. Despite the dealership’s inability to replicate the issue, I do not feel safe operating the vehicle until the root cause is identified and resolved. I am currently in the process of escalating to Hyundai corporate for further investigation, including a buyback review, replacement evaluation,

Horn has stopped working. Seems to be a systemic issue when looking online in Forums etc... I have scheduled the problem to be fixed and it is not a fuse issue. It will be a month before the dealership is able to get me in to assess the problem. This is a safety related issue and this needs to be addressed with the manufacturer.

I was travelling at 50mph a car pulled in front of me and stopped unexpetedly. I braked hard. My car began to slow, but the brake pedal went to the floor and did not slow, AFter a few seconds, the brake pedal came up from the floor and braking was resumed. I held the pedal to the floor the whole time trying to stop. It was as though the braking system failed and recovered. There was no pulsing felt on the brake pedal typical of ABS working. After my car resumed braking thte collision avoidance system took over and the car stopped just inches from the stopped car in front of me. I had just taken the car in for dealer service at 24,200 and everything was supposedly checked out as required by maintenance. I have contacted Hyundai but have not gotten a response yet.

Horn has stopped working twice. Had it replaced under warranty in January of 2024. Same incident happened where horn of vehicle does not work. Seems to be a systemic issue. This is a safety related issue and this needs to be addressed with the manufacturer.

AC evaporator drain design problem June, 2024 approx. 3500 miles under warranty, AC evaporator drain line backed up into the passenger front right. Brought it to service - they unclogged and drained the line at no charge. June 2025 approx. 12,K miles under warranty, AC drain backed up again. The excess water drained onto my feet as a passenger and collected under the front seat, saturating the rug area, potentially causing additional mildew and respiratory causing irritation. Service required an appointment. drained it charged $88. Filed a complaint incl Hyundai Motors ; was told the $88 charge was irreversible - cause was weather. The CAR HEALTH HAZARD seems to stem from a major design flaw The air intake is in the windshield wiper cowl resulting in wet tree and leaf debris , bird droppings, etc collect even when the car is not in use. Thus, when heat or air conditioning is activated, air comes in through the air intake and then through the difficult to acces filter recessed behind the glove box , then into the passenger area When the AC drain hose is plugged, it backs up through the dirty filter and then out, to accumulate under the passenger seat allowing more mildew. Re:My 2024 mile blockage, the water was drained, but the filter was not mentioned. In 2025 with the $88 bill, the water was drained no mention the filter. Draining the water does not correct the problem. It should be required at every service the l drain hose is checked, water drained. and filter changed at n

On Saturday Morning (August 9th), I was driving this car with my family on I-495 heading to the shopping mall. The SunRoof glass broke suddenly without any impact from outside. I was so alarmed and exited the road and checked it. There was a crack in the front side glass. I drove back home and found that they had exploded and scattered. I drove a car to the Hyundai Car service center to claim it, but they ignored me. I claimed this on the Hyundai America site, but the answer is that they won't fix this under the warranty. This is a panoramic sunroof, and it should support our family in the car accident. But it is easily exploded without any impact from outside. It is a safety-critical issue, but Hyundai doesn't take care of this issue.

Horn not blowing. It started giving a low sound and now it has stopped working completely. I went online and saw where this problem is wide spread.

Car only has 20,000 miles and the horn already needs to be replaced

On two occasions, once at 70mph and once at 45mph vehicle suddenly lost power and displayed warning to check collision system, there were no vehicles close enough to warrant this. I had to limp the car to the side of the road as safely as possible and shut car off, wait a few minutes and restart vehicle to clear error and allow proper power/ acceleration again.

From a complete stop when pressing the accelerator, the vehicle does nothing. This can last 1 second or in longer episodes it can last 4-5 seconds. No lights on the dash. It’s random and happens sporadically. But when it’s bad, you have enough lag to count to 5 and turn on the hazards

At 22000 miles wheel speed sensor went out, all control system shut down and car became unstable. At 44000 miles fuel injector went out, was driving on freeway and car started shaking and losing power, then in parking lot would not start at all, had to be towed to dealer. This is way to many breakdowns for a car with such low mileage.

While driving to work today [XXX] on or around [XXX] on [XXX] from Riverview to downtown Tampa while doing about 68 MPH, my emergency brake deployed for about 6 seconds. The whole vehicle shook. There were no other vehicles around. Quite scary. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving the sunroof glass out of no where exploded.

While driving the engine dropped to 10 mph and would not respond to the pedal inputs. It is available for inspection. Dropping to 10 mph in traffic on a roadway doing 70 mph or even 35 puts everyone on the roadway in danger. The problem was not reproduced but was comfirmed by the dealer who inspected and serviced it. There was no warning before it happened but the dash displayed many warnings and even sent out an email when the engine failed. This was the first of five times that it has happened.

While driving the engine dropped to 10 mph and would not respond to the pedal inputs. It is available for inspection. Dropping to 10 mph in traffic on a roadway doing 70 mph or even 35 puts everyone on the roadway in danger. The problem was not reproduced but was comfirmed by the dealer who inspected and serviced it. There was no warning before it happened but the dash displayed many warnings and even sent out an email when the engine failed. This was the SECOND of five times that it has happened.

While driving the engine dropped to 10 mph and would not respond to the pedal inputs. It is available for inspection. Dropping to 10 mph in traffic on a roadway doing 70 mph or even 35 puts everyone on the roadway in danger. The problem was not reproduced but was comfirmed by the dealer who inspected and serviced it. There was no warning before it happened but the dash displayed many warnings and even sent out an email when the engine failed. This was the THIRD of five times that it has happened so far.

While driving the engine dropped to 10 mph and would not respond to the pedal inputs. It is available for inspection. Dropping to 10 mph in traffic on a roadway doing 70 mph or even 35 puts everyone on the roadway in danger. The problem was not reproduced but was comfirmed by the dealer who inspected and serviced it. There was no warning before it happened but the dash displayed many warnings and even sent out an email when the engine failed. This was the fourth of five times that it has happened so far.

While driving the engine dropped to 10 mph and would not respond to the pedal inputs. It is available for inspection. Dropping to 10 mph in traffic on a roadway doing 70 mph or even 35 puts everyone on the roadway in danger. The problem was not reproduced but was comfirmed by the dealer who inspected and serviced it. There was no warning before it happened but the dash displayed many warnings and even sent out an email when the engine failed. This was the fifth of five times that it has happened so far.

I purchased a brand new vehicle from Hyundai within 9 months the horn stopped working. It was replaced 10/2024 and now less than 1 year the horn has stopped working once again. Hyundai has not issued an extended warranty to the Santa Fe model when this has been a known issue with all there vehicles for this year.

There was a recall on the 21-22 santa fe for a issue with the transmission oil pump failure. I have a 23 which is not part of the recall but this is exactly what happened to me and now the transmission has failed completely with 68,000 miles

My wife was parking the car at carport, all of sudden unintended acceleration happened and hit through the wall. The damage on the car was $12478.57 and damaged the wall and storage on both sides of carport. My wife is scared to drive this car.

Engine died suddenly at various speeds and a beeping alarm was activated along with the Malfunction Indicator (Check Engine), Engine Oil Pressure, and Charging System warning lights on the instrument panel. The instrument panel also read, "Engine off! Shift to N, then start engine”. The car must then be coasted off the road to safety. When the car was brought to a stop, the Parking Brake and Brake Fluid warning light was illuminated alongside the other warning lights on the instrument panel. The instrument panel also showed that the car was in Neutral; none of the gear shift buttons were operable. Pressing the start/stop engine button restarted the car, removed all alarms and warning lights, and the car operated normally until the next occurrence. This scenario occurred five times: 4.05.25, 4.15.25 (twice), 4.22.25, and 5.28.25. The odometer readings were 12,250, 12421 and 12,425, 12,454, and 12,976, respectively. I have videos or photos of the instrument panel for all events but the first one, frightened as I was by that initial experience. The car was taken to Hyundai of North Charleston (HONC) for analysis 3 times: 4.16.25, 04.22.25, and 5.29.25. On 4.16.2025 the service advisor told me that they found 2 diagnostic codes, one of which related to the front radar, so it was replaced. I picked the car up on 4.22.25 and drove less than 3 miles when the problem recurred. I immediately returned to HONC. On this visit the front upper camera was replaced. My car was at HONC for 3

On May 15th, I was involved in a serious accident caused by a malfunction in a rental vehicle provided by Enterprise a 2023 Hyundai Santa Fe. After reversing into a parking spot, I placed the vehicle in “Park” and exited the car to retrieve belongings from the trunk. My young son remained in the back seat. To my shock, the vehicle suddenly began to move on its own despite being in “Park.” I immediately ran to the driver’s side and jumped back into the vehicle in an attempt to stop it. I pressed the brake pedal multiple times, but the car would not respond. I also pressed the “Park” button repeatedly, yet the vehicle continued to move uncontrollably. The steering wheel was unresponsive, and I was unable to redirect the vehicle or bring it to a stop. The car ultimately crashed into two other vehicles. During the collision, one of the vehicles pinned my left leg in its door, causing physical injury. I am now dealing with both physical and emotional trauma as a result. To be clear, this incident occurred on a flat surface. No airbag deployed upon impact, and there were no warning signs or alerts from the vehicle beforehand which is highly concerning, especially for a modern electric/hybrid vehicle. This car presents a major safety hazard and, in my opinion, should be recalled and removed from service immediately before it causes a fatality. I have contacted Enterprise multiple times to report this issue and urge them not to rent this vehicle to anyone else.

On [XXX] I was on [XXX] in Houston, TX southbound in the Woodlands area when my vehicle warning light for overheating went on. I pulled over on [XXX] and contacted Vehicle Assistance and the vehicle was towed to my dealer, Northwest Houston Hyundai. There was damage to a tube in front of the radiator and a/c condenser. The damage to the tube was approximately 1/16 of an inch in diameter and supposedly was caused by debris entering through the front grille which is designed like a large egg carton. The dealer spokesperson informed me that they had seen many vehicles like mine (2023 Santa Fe) with the same type of damage. I have been trying to settle this with Hyundai but they feel it is normal road damage and that the wide open grille design that allows it is not their problem. I can't even get them to approve a third party screen to protect the engine radiator from further design. They will not answer the question as to whether or not installing this item will void the warranty or not. It's dangerous to break down on a manor highway in a manor city particularly for us senior citizens. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Front brake failure at 3k miles. Rotors warped so badly they failed to properly stop the vehicle. Vehicle shaking immensely Transmission failure at 11k miles. While vehicle is in Drive mode the transmission is stuck in first gear and will not shift. The tachometer was redlining at 6k I had to use the paddle shifters to get the transmission to shift. I was driving the vehicle as a manual transmission when I own an automatic.