2007 Hyundai Santa FE complaints

TL*THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT NOTICED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED, CAUSING HER BRAKE LIGHTS TO MALFUNCTION WHEN THE BRAKES WERE DEPRESSED SIMILAR TO NHTSA CAMPAIGN ID NUMBER: 09V122000 ( SERVICE BRAKES, HYDRAULIC SWITCHES:BRAKE LIGHT). THE DEALER WAS NOTIFIED AND STATED THAT HER VEHICLE WAS NOT INCLUDED IN THE RECALL. THE CONTACT DID NOT INFORM THE MANUFACTURER NOR WAS THE VEHICLE REPAIRED. THE CURRENT MILEAGE WAS 87,843. THE FAILURE MILEAGE WAS APPROXIMATELY 87,800. THE VIN WAS UNAVAILABLE.

THIS COMPLAINT REFERS TO THE SRS AIRBAG SYSTEM IN THE SANTA FE. WHILE THE AIRBAG SYSTEM IS INTACT I HAVE BEEN TOLD BY A CERTIFIED HYUNDAI REPAIR CENTER THAT THE CLOCK SPRING AND THE JUNCTION BOX HAVE FAILED. GIVEN THE PREMATURE NATURE OF THIS FAILURE I BELIEVE THAT THIS SYSTEM IS FLAWED AND REPRESENTS A WIDESPREAD HAZARD TO THE AMERICAN PUBLIC. IN ADDITION, ALL FOUR BRAKE ROTORS AND THE SWAY BAR NEEDED TO BE REPLACED WITH LESS THAN 70,000 MILES DUE TO EXCESSIVE WEAR WHICH RENDERED THEM UNSAFE (ACCORDING TO THE AFOREMENTIONED CENTER).

ACCIDENT INVOLVED SUDDEN ACCELERATION AND OWNERS SUSPECT ELECTRONIC DEFECT IN THE CAR. FORTUNATELY DESPITE EXTENSIVE DAMAGE TO THE STORE AND VEHICLE, NO ONE INJURED. OWNERS ARE WORKING WITH BOTH INSURER AND VEHICLE MANUFACTURER TO REQUEST APPROPRIATE INVESTIGATION. DRIVER'S STATEMENT: "I WAS PULLING INTO A PARKING SLOT AT LOCAL STORE. EVERYTHING WAS GOING NORMALLY. I APPLIED PRESSURE TO THE BRAKES TO COME TO A COMPLETE STOP AND THE CAR RESPONDED AND SLOWED. BUT JUST AS I WAS ABOUT TO COME TO A COMPLETE STOP, THE ENGINE REVVED UP SOME AND THE CAR KEPT MOVING FORWARD. I PRESSED ON THE BRAKES HARDER, BUT THE CAR MOVED FORWARD EVEN FASTER. I HAD NO TIME TO SLIP INTO NEUTRAL OR CUT THE ENGINE. I FINALLY LIFTED MY FOOT FOR SECOND AND STOMPED ON THE BRAKE PEDAL HARD, BUT MOMENTUM CAUSED THE CAR TO JUMP THE CURB AND I SHATTERED A HUGE PLATE GLASS WINDOW IN THE FRONT OF THE STORE. THE CAR FINALLY CAME TO A STOP IN A HAIL OF GLASS SHARDS PARTIALLY INSIDE THE STORE, THE ENGINE STILL REVVING HIGHER THAN AT "IDLE" SPEED. I SHUT OFF THE ENGINE. AND THAT'S WHAT I RECOLLECT ABOUT WHAT HAPPENED IN THE FEW SECONDS IT TOOK FOR THE CAR'S FAILURE TO STOP AND RUNNING THROUGH THE WINDOW.

AT THREE YEARS AND 63000 MILES ALL FOUR BRAKE ROTORS REQUIRE REPLACEMENT DUE TO WHAT THE DEALER DESCRIBES AS "NORMAL" WEAR. THERE IS NO SCORING ON ANY OF THE ROTORS IT IS OUT OF SPEC BECAUSE IT DOES NOT MEET MINIMUM THICKNESS REQUIREMENTS. IDENTIFIED THROUGH LOUD NOISE AND POOR BRAKING. *TR

2007 HYUNDAI SANTA FE ~36,000 MILES. REAR BRAKES COMPLETELY REPLACED IN MAY 2010. WHILE DRIVING ON HIGHWAY, LOUD GRINDING BRAKE NOISE HEARD FROM REAR OF VEHICLE. LARGE AMOUNTS OF 'BRAKE DUST' ON RIM OF REAR DRIVER'S SIDE WHEEL. BROUGHT VEHICLE TO DEALER FOR INSPECTION. DETERMINED CALIPER WAS SEIZED UP DUE TO RUST. THEY WILL NOT REMEDY VIA WARRANTY B/C THEY DETERMINE THAT IT IS AN ENVIRONMENTAL ISSUE. (SALT/ROAD DEBRIS BUILDUP). NEW BRAKE PADS/ROTORS WERE DAMAGED AS A RESULT. THIS HAS TO BE A SAFETY ISSUE AS THE RIM OF THE WHEEL GOT EXTREMELY HOT DURING USE. COULD THIS EVENTUALLY LEAD TO A TIRE BLOW OUT WHILE DRIVING? NOT SURE!? SEARCHING ONLINE RESULTS IN A LOT OF CONSUMER COMPLAINTS ON BLOG/CAR SITES. SAME PROBLEM EVERYTIME: REAR DRIVER'S SIDE CALIPER IS STUCK RESULTING IN DAMAGE TO ROTORS AND PADS. *TR

2007 HYUNDAI SANTA FE. REAR BRAKES ( DRIVER SIDE ) CALIPER SIEGE, CAUSING PREMATURE WEAROUT OF BRAKE PADS ON LEFT SIDE. SOME ROTOR SCORING. REAR BRAKES REPLACED AND CALIPER LUBE AND CLEANED OF RUST. COST $153.58. *TR

TL*THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE TIRE PRESSURE MONITORING SYSTEM SENSOR WAS BREAKING OFF AT THE VALVE; THREE HAD PREVIOUSLY BROKEN OFF. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 44,500. THE FAILURE MILEAGE WAS APPROXIMATELY 44,400. UPDATED 12/23/10*LJ UPDATED 01/01/11

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTE FE. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG OFF WARNING LIGHT CONTINUED TO ILLUMINATE. THE DEALER ADVISED THAT THE OCCUPANT OF THE PASSENGER SEAT MUST WEIGH 110 POUNDS OR MORE IN ORDER FOR THE AIR BAG TO ENGAGE. THE CONTACT WAS CONCERNED BECAUSE FOR A SMALL STATURED PERSON, THE AIR BAG WOULD NOT ENGAGE IF NEEDED. THE DEALER ADVISED THE CONTACT THAT THEY WERE UNABLE TO MAKE REPAIRS TO ADJUST TO A PERSON'S WEIGHT. IN ADDITION, THE CONTACT STATED IF ON A SLIGHT INCLINE, THE EMERGENCY BRAKE WOULD NOT ENGAGE. THE DEALER ADVISED THE CONTACT THAT THE FAILURE WAS NORMAL IN HIS SPECIFIC YEAR, MAKE AND MODEL. THE VEHICLE WAS NOT REPAIRED FOR EITHER FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 105 AND THE CURRENT MILEAGE WAS 34,688.

DURING NORMAL DRIVING THE LEFT REAR DISC BRAKE BEGAN TO GRIND METAL ON METAL. I TOOK THE CAR TO THE DEALER FOR REPAIR. THEY FOUND "THE PADS WERE SEIZED IN THE CALIPER BRACKETS DUE TO RUST". THE REAR PADS AND ROTORS WERE REPLACED AT MY EXPENSE. NO INDICATION WAS GIVEN THAT THE DEFECT THAT CAUSED THE PRE-MATURE FAILURE WAS FIXED. *TR

I OWN A 2007 SANTA FE HYUNDAI. MY POWER SYSTEM WENT OUT ABOUT THREE MONTHS AGO. LUCKILY, I HAD JUST LEFT THE GROCERY STORE AND WAS STILL IN THE PARKING LOT. MY CAR AT THE TIME HAD 26,334 MILES ON IT. AT FIRST I THOUGHT IT WAS THE BATTERY, BUT I HAD SOMEONE JUMP START MY CAR, AND AFTER I DROVE IT ABOUT THREE FEET, I KNEW SOMETHING WAS WRONG. I COULDN'T STEER IT AND COASTED TO A STOP BY A WENDY'S RESTAURANT. I CALLED MY SON AND WHEN HE LIFTED THE HOOD, HE SAW A ROUND PART JUST HANGING THERE. I HAD TO HAVE MY CAR TOWED TO A DEALER IN WALDORF, MARYLAND. APPARENTLY, THE DAMPER PULLEY CAME APART. THEY REPLACED DAMPER PULLEY AND BELT. I WAS UNDER WARRANTY, BUT I STILL WORRY ABOUT IT HAPPENING AGAIN EVERY TIME I HAVE TO DRIVE IT ON A MAIN HIGHWAY AND IN A LOT OF TRAFFIC. *TR

I OWN A 2007 HYUNDAI SANTA FE SUV. THE SEAT BELT FOR THE PASSENGER REAR SEAT (40) DOES NOT STAY UP AND AVAILABLE TO NEW OCCUPANTS. IT ALWAYS FALLS DOWN THE SEAT BELT SLOT AND IS EXTREMELY DIFFICULT TO RETRIEVE FOR THE PASSENGER. PASSENGER INVARIABLY SEAT THEMSELVES INTO 60 PORTION OF THE SEAT DIRECTLY BEHIND THE DRIVER. THE ONLY WAY WHICH I HAVE FOUND TO RETRIEVE THE SEAT BELT AND MAKE IT AVAILABLE TO THE PASSENGER IN THE 40 SEAT IS TO LAY THE SEAT DOWN AT ABOUT A 30 DEGREES. REACH UNDER THE SEAT VARY CAREFULLY AND PUSH THE SEAT BELT UP FROM THE BOTTOM. THIS IS EXTREMELY DIFFICULT AND WITH THE BOLTS AND UNFINISHED METAL ON THE FLOOR POSES A SAFETY HAZARD IN ITSELF. I HAVE TAKEN THE VEHICLE IN TO THE DEALER TWICE AND ASKED ABOUT REPAIR OR RECALL AND THEY JUST KIND OF LAUGH WHEN I TELL THEM ITS A PAIN AND NEEDS FIXED. THEY JUST SAY "YOU AND ALOT OF OTHERS WOULD LIKE THAT". IT WOULD TAKE A SIMPLE FIX OF PUTTING IN A STIFF COLLAR LIKE THAT ON MOST VEHICLES OR A FLAT SLEEVE WHICH COULD KEEP THE BELT FROM RECEDING INTO THE ABYSS OF THE VEHICLE. I WOULD IMAGINE THAT MOST PASSENGERS IN THE 40 POSITION DO WITHOUT WEARING THE BELT, AND JUST HOLD IT IN THE LAP. CAN YOU FIRMLY SUGGEST TO HYUNDAI TO PUT A PERMANENT FIX TO THIS SAFETY ISSUE BEFORE SOMEONE GETS KILLED FOR NOT WEARING A SEATLBELT WHICH IS NOT AVAILABLE TO THEM BECAUSE OF A MANUFACTURES OVERSIGHT AND LACK OF CONCERN. *TR

TL*THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 5 MPH THE AIR BAG LIGHT ILLUMINATED ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE SHE WAS INFORMED THAT THE AIR BAG NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE CONTINUED TO RECUR. THE FAILURE AND CURRENT MILEAGE WAS 73,000. THE VIN WAS UNAVAILABLE.

THREE MAJOR COMPLAINTS. AT 18,000 MILES THE TOP SEAL OF THE ENGINE HAD TO BE REPLACED, REPAIRED UNDER WARRANTY. AT 21,000 MILE THE REAR BRAKE CALIPERS HAD TO BE REPAIRED FOR STICKING AND PADS REPLACED AT OWNERS EXPENSE. OWNER TOLD BY DEALERSHIP THE CAUSE WAS "PROBABLY FROM SALT USED TO TREAT ROAD SURFACES DURING SNOW REMOVAL". HYUNDAI REFUSED WARRANTY CLAIM AND WOULD NOT ADMIT IMPROPER MATERIALS USED FOR BRAKING SYSTEM. AT 27,000 MILES, MULTIPLE VISITS TO DEALERSHIP FOR REPAIR OF INOPERATING TURN SIGNALS. PARTS REPLACED IN ATTEMPT TO REPAIR INCLUDE ELECTRICAL BOX IN STEERING COLUMN, ALL BULBS,FLASHER UNIT,GROUNDING POINTS FOR SYSTEM. PROBLEM RECURRING AND DANGEROUS. *TR

THIS SAME PROBLEM HAS OCCURRED TWICE. ONCE WITH 850 MILES ON THE VEHICLE AND AGAIN WITH 46,000 MILES. HYUNDAI SANTA FE 2007. TRAVELING AT 70 MPH THE ENGINE TOTALLY SHUT DOWN AND WOULD NOT RESTART. AUTO WAS TOWED TO DEALER EACH TIME AND RESTARTED UPON UNLOAD. HYUNDAI CANNOT FIND PROBLEM NOR DOES DIAGNOSTIC COMPUTER INDICATE ANY PROBLEM HAS OCCURRED. FORTUNATELY THERE WERE NO ACCIDENTS ASSOCIATED WITH THIS PROBLEM BUT 7 HOURS OF TIME AND FORCED HOTEL STAYS WERE A RESULT. *TR

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 45- 50 MPH, THE ENGINE STALLED FOLLOWED BY THE "CHECK ENGINE" WARNING LIGHT ILLUMINATION. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO AN AUTHORIZED DEALER WHERE THE TECHNICIAN INFORMED THAT THE FAILURE WAS CONTRIBUTED TO THE OUTPUT SPEED SENSOR. THE FAILURE OCCURRED ON FIVE DIFFERENT TIMES. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 30,909.

AIR BAG SYSTEM FOR A 2007 HYUNDAI SANTA FE DISARM WHILE DRIVING OR WILL NOT ARM AFTER STARTING. MY WIFE WEIGHS 105 LBS. QUITE OFTEN TO ARM THE SYSTEM SHE HAS TO BEND OVER AND GET WEIGHT ON FRONT OF SEAT SYSTEM WILL ARM . AFTER TRAVELING SOME DISTANCE SITTING IN THE RIGHT POSITION THE AIR BAG LIGHT WILL COME ON AND STAY ON UNTIL MY WIFE BENDS FORWARD TO REAR SYSTEM THIS HAS BEEN OCCURRING SINCE THE CAR WAS NEW. *TR

OUR 2007 HYUNDAI SANTA FE HAS BEEN TAKEN TO CONICELLI HYUNDAI NUMEROUS TIMES AND COMPLAINED THAT THE PASSENGER AIRBAG IS NOT DETECTING MY WIFE SITTING IN THE PASSENGER SEAT WHO WEIGHS APPROXIMATELY 110 LBS. EACH TIME, THEY'VE TOLD US THAT THE WEIGHT REQUIREMENT IS SOMETHING DIFFERENT, YET ALWAYS ABOVE MY WIFE'S WEIGHT. I'VE RESEARCHED THIS AND HAVE FOUND MANY OF THE SAME COMPLAINTS (SOME WHERE PEOPLE HAVE BEEN SERIOUSLY INJURED IN AN ACCIDENT DUE TO THE AIRBAG NOT DEPLOYING). THE MECHANICS HAVE SUGGESTED THAT MY WIFE SIT IN THE BACK SEAT!!! THIS IS NOT FIXING THE PROBLEM! *TR

TL*THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE AIR BAG SENSOR BOX NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED WHEN THE COMPLAINT WAS FILED. THE CONTACT CALLED THE MANUFACTURER AND WAS OFFERED NO ASSISTANCE. THE CURRENT MILEAGE WAS 82,689. THE FAILURE MILEAGE WAS APPROXIMATELY 82,670.

ACCELERATING VEHICLE TO MERGE ONTO A MAJOR HIGHWAY, CAR RAPIDLY ACCELERATED AND WOULD NOT SLOW DOWN OR STOP DESPITE ATTEMPTS TO BRAKE OR SLOW DOWN. ATTEMPTED TO TAP BRAKE AND PUSH OFF BUTTON OF CRUISE CONTROL (ALTHOUGH THIS HAD NOT BEEN TURNED ON) CAR REQUIRED PUTTING INTO NEUTRAL, PULLING TO SIDE OF ROAD AND TURNING ENGINE OFF. THIS ACCELERATION ISSUE ALSO HAPPENED JUNE, 2009. COMPANY MADE DECISION THERE IS NOTHING WRONG WITH THE CAR AT THAT TIME. CAR WILL BE EVALUATED ON MONDAY, DESPITE MY REQUEST TO HAVE IT SEEN IMMEDIATELY. *TR

2007 HYUNDAI SANTA FE - MAY 27, 2010 I WAS DRIVING ON THE INTERSTATE AT 65MPH WHEN THE PASSENGER REAR WHEEL LOCKED UP CAUSING THE CAR TO FISHTALE - AS I MOVED OVER IN TO THE SLOW LANE, IT FISHTALED AGAIN. THE DEALER IT WAS TOWED TO SAID IT WAS THE YAW SENSOR WHICH THEY REPLACED. I INFORMED THEM AT THAT TIME THAT THE ECS OFF LIGHT HAD BEEN COMING ON TO WHICH THEY REPLIED IT HAD NOTHING TO DO WITH THE YAW SENSOR I CALLED THE WEEK OF JULY 4TH TO LET THE DEALER KNOW THAT THE ECS OFF LIGHT CAME ON AGAIN - THEY INFORMED ME THAT THIS HAS BEEN A PROBLEM FOR MANY SANTA FE'S AND THEY NEEDED ME TO COME DOWN (150+ MILES ONE WAY) TO HOOK IT UP TO SEE WHAT THE CODE TELLS THEM. ON JULY 19, 2010 DRIVING 75MPH ON THE INTERSTATE, BOTH REAR WHEELS LOCKED UP AND THERE WERE NO BRAKES. THIS CAR IS A DANGER TO MY LIFE! *TR

WEDNESDAY, JUNE 23, 2010: CAR WAS PARKED IN A STORE PARKING LOT. ON APPROACH TO CAR SMOKE WAS OBSERVED ON THE INTERIOR OF THE CAR. UPON OPENING THE CAR, SMOKE AND FIRE COULD BE SEEN CENTERED AROUND THE RIGHT SIDE SEAT WARMER SWITCH AND ELECTRICAL PORT. NOTHING WAS PLUGGED IN AND KEY WAS NOT IN THE IGNITION. FIRE WAS PUT OUT BY BLOWING ON IT. SEAT WARMER SWITCH WAS MELTED ON THE RIGHT SIDE AND THE ELECTRICAL PORT CAP WAS PARTIALLY MELTED AND BLOWN OFF INTO THE CONSOLE TRAY. SOOT AND DAMAGE TO BUTTONS AND CONSOLE ABOVE THE SEAT WARMER BUTTONS ALONG WITH BUBBLED, MELTED VINYL ON CENTER CONSOLE. RETURNED CAR TO HYUNDAI DEALERSHIP THE NEXT MORNING. SERVICE MGR SAID THAT IT WAS SOMETHING THAT WE HAD PLUGGED IN AND TOOK PICTURES. SERVICE MGR SENT PICTURES TO CORPORATE HEADQUARTERS. CORP HEADQUARTERS ALSO SAID IT WAS SOMETHING THAT WE DID. CONTACTED HYUNDAI CONSUMER AFFAIRS AND ASKED FOR INVESTIGATION BEHIND THE PANEL. JUNE 19, 2010 HYUNDAI INVESTIGATED AND SAID THAT THEY COULD NOT DETERMINE THE CAUSE OF THE FIRE SO IT MUST HAVE BEEN SOMETHING THAT WE DID. *TR

WHILE DRIVING ON THE HIGHWAY, THE DRIVER'S SIDE SUN VISOR FELL, AND BLOCKED THE VISION OF DRIVER. ALONG WITH BLOCKING THE DRIVER'S VISION, THE DRIVER WAS STARTLED CAUSING THE DRIVER TO SWERVE. THIS ALMOST CAUSED A CRASH. THE DRIVER HAD TO HOLD THE SUN VISOR UNTIL REACHING HOME (~15 MINUTES). UPON REACHING HOME, THE OWNER EXAMINED THE VISOR. THE VISOR HAS A VERY SMALL AND FRAGILE PLASTIC COMPONENT HOLDING THE VISOR IN PLACE. IT APPEARS THAT THE VISOR IS DESTINED TO BREAK. THE COMPONENT THAT BROKE IS ON THE ARM THAT SWINGS THE VISOR DOWN AND TO THE LEFT, AND IS EMBEDDED IN THE INTERIOR CEILING I.E., NOT ACCESSIBLE TO ANYONE WITHOUT TAKING THE VISOR APART WITH SCREW DRIVERS. THERE WAS 64,250 MILES ON THE VEHICLE AT TIME OF THE INCIDENT. THERE WAS A PASSENGER AT TIME OF INCIDENT, WHO CAN TESTIFY TO THE FACTS. *TR

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED WHILE DRIVING AT45 MPH AND ATTEMPTING TO ACCELERATE, THE INSTRUMENT PANEL FAILED AND THE VEHICLE WOULD INDEPENDENTLY DECELERATE. THE CONTACT MOVED FROM THE ROADWAY AND SHUT OFF THE VEHICLE. WHEN RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION. THE DEALER ADVISED THAT THE INTERNAL THROTTLE WAS DEFECTIVE AND WAS REPLACED AT THE CONTACTS EXPENSE. THE FAILURE RECURRED. THE MANUFACTURER STATED THEY HAD NOT RECEIVED ANY COMPLAINTS SIMILAR TO HIS AND WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 23,900 AND THE CURRENT MILEAGE WAS 35,900.

R.R. BRAKES FROZEN BY RUST & CORROSION AT 26,00 MILES. *TR

I WAS DRIVING ON THE HIGHWAY ABOUT 65 MILES AN HOUR AND THE FRONT WHEEL LOCKED UP. THE CAR PULLED TO ONE SIDE, LOST CONTROL, AND WENT OFF THE ROAD. I TOOK IT TO THE DEALER AND THEY TOLD ME IT WAS A SENSOR WITH THE CRUISE CONTROL, THE ESC, AND SOMETHING WITH THE STEERING WHEEL. *TR

MY 2007 HYUNDAI HAS A PROBLEM WITH THE WEARING ON THE FRONT TIRES. I PURCHASED IT IN JANUARY OF 2008, AND HAVE HAD TO REPLACE THE FRONT TIRES TWICE. THIS CAUSES THE VEHICLE TO SKID AND BRAKING IS SOMEWHAT DIFFICULT. I TOLD THE DEALER, BUT THERE WAS NO RESOLUTION. *TR

2007 HYUNDAI SANTA FE - THE TIRES ARE PREMATURELY WEARING OUT. EVERY 15 MONTHS OR SO THE TIRES MUST BE REPLACED. GOOD TIRES AND ROTATED REGULARLY. THERE IS SOMETHING WRONG. THERE ARE TOO MANY OTHER PEOPLE WITH THE SAME PROBLEM. THE DEALER HAS REPLACED SWAY/TIE RODS,ALIGNED TIRES, STILL TIRES WEAR OUT. VEHICLE IS STILL UNDER WARRANTY BUT THE COST OF THE TIRES COMES OUT OF MY POCKET. SOMETHING MUST BE DONE TO IDENTIFY THE CAUSE OF THIS. *TR

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED WHILE IN THE REVERSE POSITION, THE VEHICLE ABNORMALLY ACCELERATED WITHOUT WARRANT. THE VEHICLE CRASHED REAR END INTO A LOADING DOCK AND SUSTAINED SUBSTANTIAL REAR BODY DAMAGE. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS AWAITING A DIAGNOSIS OF THE FAILURE. NEITHER THE DEALER NOR THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 52,000. UPDATED 07/19/10 *BF THE CONSUMER STATED THE BRAKES FAILED. UPDATED 07/21/10*JB

VEHICLE HESITATES WHEN YOU STEP ON THE GAS. *TR

WITH ONLY 21,132 MILES ON THE VEHICLE, THE LEFT REAR BRAKE CALIPER STUCK RESULTING IN LOSS OF BRAKING WHEN PADS WORE OUT. BRAKES WERE INSPECTED LESS THAN 3000 MILES PRIOR TO LOSS OF BRAKING. *TR

WHEN MY WIFE IS SEATED IN THE PASSENGER SEAT THE AIR BAG SENSOR WILL NOT RECOGNIZE THAT A PERSON IS OCCUPYING THE PASSENGER SEAT. MY WIFE WEIGHS APPROXIMATELY 140 LBS. THIS HAS BEEN A REGULAR PROBLEM FOR THE LAST FEW YEARS AND HAS NOT GONE AWAY. IT IS THE SAME PROBLEM AS THE CURRENT NHTSA CAMPAIGN (08V161000) FOR 2006-2008 HYUNDAI SONATAS FOR WHICH HYUNDAI HAS ISSUED A RECALL. WE HAVE VISITED MULTIPLE DEALERSHIPS AND THEY HAVE ALL TOLD US THIS IS A COMMON PROBLEM WITH THE SANTA FE, HOWEVER SINCE HYUNDAI HAS NOT ISSUED A RECALL THERE IS NOTHING THEY CAN DO TO FIX THE PROBLEM. THIS IS A VERY DANGEROUS PROBLEM AS BOTH THE FRONT AND SIDE PASSENGER AIR BAGS WILL NOT DEPLOY IN AN ACCIDENT WHICH COULD RESULT IN SERIOUS INJURY OR DEATH TO A PASSENGER. WE CURRENTLY OWN A 2007 HYUNDAI SANTA FE WITH 37,000 MILES. *TR

I OWN A 2007 SANTA FE WITH 30,000 MILES. WHEN I AM SEATED ON THE PASSENGER SIDE THE AIR BAG SENSOR WILL STATE THAT IT IS INOPERATIVE, NOT RECOGNIZING ME AS A PASSENGER. I WEIGH 134 LBS WHICH SHOULD BE MORE THAN ENOUGH FOR THE AIR BAG SENSOR AND I AM REALLY CONCERNED SINCE THE FRONT AIRBAG WILL NOT WORK IN THE EVENT OF A CRASH. THAT COULD RESULT IN AN INJURY TO ME OR SOMEONE OF SIMILAR SIZE. I HAVE TALKED WITH TWO DEALERSHIPS ABOUT THIS ISSUE. BOTH RECOGNIZED THE ISSUE AS A COMMON PROBLEM. THE FIRST DEALERSHIP TOLD ME THAT NOTHING COULD BE DONE UNLESS HYUNDAI ISSUES A RECALL LIKE THEY DID FOR THE SONATAS (SEE CAMPAIGN ID 08V161000). THE SECOND DEALER OFFERED TO REPLACE THE SEAT (WHICH THEY DID BACK IN 2009), HOWEVER THAT HAS DID NOT SOLVED THE PROBLEM AT ALL. PLEASE CONSIDER RESEARCHING THIS ISSUE AS HYUNDAI HAS RECOGNIZED THIS PROBLEM WITH THE SONATAS ALREADY AND IT IS THE SAME ISSUE IN THE SANTA FE MODELS. *TR

LETTER REGARDING THE ELECTRICAL PROBLEMS HE HAS EXPERIENCED WITH HIS 2007 HYUNDAI SANTA FE. *TGW THE CONSUMER STATED WHENEVER HE PARKED NEAR ELECTRICAL TOWERS, THE LOCKS ON THE DOOR WOULD MALFUNCTION, THE CRUISE CONTROL LIGHT WOULD NOT GO OUT, THE WINDOWS WOULD NOT GO UP, THE GEAR BOX WOULD NOT DISPLAY WHICH GEAR THE VEHICLE WAS IN. THE CLIMATE CONTROL NEVER FUNCTIONED ACCORDING TO THE MANUAL. THE CRUISE CONTROL SOMETIME EXCEEDED THE SET SPEED OVER OR DOWN LONG INCLINES. THE DRIVER'S SEAT WHICH WAS ELECTRONIC SAT UP TOO HIGH. THE ROOF RACK CROSS BAR WAS TOO FAR, WHICH ALLOWED AIR TO PULL OFF THE LOADS. THE TIRE JACK WAS NOT SUFFICIENT FOR THE VEHICLE*JB

TL*THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, THE RUBBER HOUSING AROUND THE WINDSHIELD CAME OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP TO HAVE THE STRIP REPLACED. THE CONTACT WAS CONCERNED THAT BECAUSE OF THE FAILURE, THE WINDSHIELD COULD HAVE BECOME SEPARATED WHILE THE CONTACT WAS DRIVING. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000.

TOOK CAR IN FOR ISSUE UNRELATED TO BRAKES DURING COURTESY INSPECTION FOUND REAR BRAKES NEED REPAIR. SCORES PER WHEEL WHERE ARE AS FOLLOWS LF 10 RF 10 LR2 RR 8. THE VARIANCE SEEMS TO INDICATE AN ISSUE AND A BRIEF INTERNET SEARCH FOUND NUMEROUS SIMILAR COMPLAINTS.

FOLLOW UP TO COMPLAINTS #'S 10319062-10319460-10319463. VEHICLE POWER STEERING LOSS HAS BEEN CORRECTED BY HYUNDAI DEALER. BE ADVISED THAT THE CAUSE FOR THE LOSS OF THE POWER STEERING WAS (THE PULLEY SEPARATED DAMAGING BELT). (BALANCER FELL APART AND BALANCER AND BELT WERE REPLACED). VEHICLE ONLY HAD 12,869 MILES ON IT. *TR

BACK DRIVER SIDE CALIPER OVERHEATED ON A 2007 HYUNDAI SANTA FE WITH 32,000 MILES ON IT. THE BRAKE PADS WERE RUINED AS THE VEHICLE WAS BEING DRIVEN ONE DAY 3/15/2010. I DROVE OVER 200 MILES BEFORE I HEARD THE LOUD DRONING SOUND OF THE BRAKES. EVEN WHEN THE BRAKES WERE NOT ENGAGED THE CALIPER WAS STILL PRESSING AGAINST THE BRAKE PAD. SMOKE COMING FROM THE WHEEL AS WELL AS RESIDUE ON THE RIMS.THE DEALERSHIP WILL NOT FIX IT UNDER WARRANTY AS PER HYUNDAIS INSTRUCTIONS. THE COST WILL BE #300.00-$400.00 AND THEY SAID IT WAS CAUSED BY RUST WHICH THEY SAID THEY SAW IN OTHER SANTA FE'S. I BELIEVE THIS IS A SERIOUS DEFECT IN THE VEHICLE AS THE TIRE COULD CATCH FIRE AND EXPLODE CAUSING A DANGEROUS ACCIDENT. HYUNDAI DOESN'T SEE A PROBLEM WITH THIS AND WILL NOT WARRANTY THIS ISSUE. *TR

WHILE MAKING A RIGHT HAND TURN GOING FROM AN EASTWARD DIRECTION TO A SOUTHERN DIRECTION THE POWER STEERING ON MY VEHICLE WENT DEAD, THE RED DRIVER SEAT BELT LIGHT CAME ON AND IN A FEW SECONDS THE POWER STEERING CAME BACK AND THE EAT BELT LIGHT WENT OFF. TRAVELING AT A VERY SLOW SPEED IN A RURAL AREA OF TOWN.. AFTER INCIDENT I DROVE HOME WITHOUT ANY PROBLEM. *TR

WHILE DRIVING IN A SOUTHERN DIRECTION I MADE A LEFT HAND TURN IN AN EASTERN DIRECTION, AS I WAS MAKING THE TURN I HEARD A LOUD SOUND SIMILAR TO THE DROPPING OF A HEAVY OBJECT AND IMMEDIATELY AFTERWARD THE POWER STEERING ON MY CAR WENT DEAD AND THE RED BATTERY LIGHT IN THE DASH CAME ON. I WAS ABLE TO PULL THE CAR TO THE SIDE OF THE ROAD AND I STOPPED. THE RED BATTERY LIGHT WAS STILL ON, I THAN TURNED THE KEY TO TURN THE MOTOR OFF AND WHEN I STARTED THE CAR AGAIN THE RED LIGHT WAS STILL ON AND I DID NOT HAVE POWER STEERING. AS I WAS CLOSE TO MY HOME, I PROCEEDED TO DRIVE HOME AND PARK THE CAR IN THE DRIVEWAY, THE POWER STEERING WAS NOT WORKING AND THE RED BATTERY LIGHT WAS STILL ON. SINCE THIS IS THE THIRD TIME THAT I HAVE EXPERIENCED THE LOSS OF THE POWER STEERING I AM GOING TO HAVE THE CAR TRANSPORTED TO THE DEALERS SERVICE SHOP FOR INSPECTION. THE FIRST TIME THAT I EXPERIENCED THE LOSS OF THE POWER STEERING AN INSPECTION WAS MADE BY THE SERVICE MECHANICS OF THE DEALER, AND THEY AFTER KEEPING THE CAR SEVERAL DAYS COULD FIND NOTHING WRONG. IF THESE INCIDENTS WOULD HAVE OCCURRED WHILE I WAS DRIVING ON THE N.J. TURNPIKE I FEEL THAT THE OUTCOME WOULD HAVE BEEN MUCH DIFFERENT. *TR

WHILE MAKING A RIGHT HAND TURN GOING FROM AN EASTWARD DIRECTION TO A SOUTHERN DIRECTION THE POWER STEERING ON MY VEHICLE WENT DEAD, THE RED DRIVER SEAT BELT LIGHT CAME ON AND IN A FEW SECONDS THE POWER STEERING CAME BACK AND THE EAT BELT LIGHT WENT OFF. TRAVELING AT A VERY SLOW SPEED IN A RURAL AREA OF TOWN.. AFTER INCIDENT I DROVE HOME WITHOUT ANY PROBLEM. *TR

WHILE DRIVING AT A SLOW SPEED THE POWER STEERING WENT OUT AND CAR DASH LIGHTS WENT OUT AND CAR APPEARED TO HAVE STALLED AND WITHIN A FEW SECONDS THE POWER STEERING WAS AGAIN ENGAGED. THIS OCCURRED AS I WAS ROUNDING A CURVE IN THE ROAD. DEALER COULD FIND NOTHING WRONG WITH CAR. *TR

DRIVING ON THE GARDEN STATE PKWY IN NJ, THE CAR ACCELERATED TO 80MPH AND WOULD NOT SLOW DOWN OR STOP. DESPITE BOTH FEET ON BRAKE, THE CAR WOULD NOT SLOW DOWN. THE INCIDENT LASTED FOR 5-10 MINUTES AND DISENGAGED BY ITSELF. SERVICED FOR ABOVE BY DEALER ON 5/2/09-REMAINED UNTIL 5/6/10 AND IT WAS REPORTED THERE WAS NO MECHANICAL ISSUE-"IT MUST HAVE BEEN THE FLOOR MAT". CUSTOMER SERVICE WAS INVOLVED, GOING UP TO REGIONAL REP, WHO REITERATED THERE WAS NOTHING MECHANICALLY WRONG WITH THE CAR-IT WAS DRIVER ERROR. THEY ALSO SUGGESTED IT MAY HAVE BEEN AN ACCIDENTAL CRUISE CONTROL ENGAGEMENT BY DRIVER, BUT HAD NO EXPLANATION FOR WHY IT DID NOT DISENGAGE WHEN BRAKE WAS APPLIED. THEY MAINTAINED IT WAS DRIVER ERROR, PROBABLY THE FLOOR MAT. THE INCIDENT SEEMS SIMILAR TO THE RECENT TOYOTA PROBLEM. *TR

WHILE COMING TO A STOP THE CAR STARTED TO ACCELERATE ON IT'S OWN. I PUT MORE PRESSURE ON THE BRAKE, BUT WOULD NOT HOLD, I PUT THE CAR INTO NEUTRAL AND TURNED OFF THE KEY. WHEN I RESTARTED IT WAS OK BUT MY AIR BAG LIGHT WAS ON. WHEN I GOT HOME I PARKED AND PRESSED THE KEY REMOTE TO LOCK, THE DOORS LOCKED BUT THE LIGHTS DID NOT FLASH. I THEN RESTARTED THE CAR, SHUT IT OF AND RELOCKED. THIS TIME THE LIGHTS FLASHED BUT AFTER ABOUT 30 SEC. THE CAR ALARM WOULD SOUND. I AGAIN RESTARTED AND SHUT IT OFF, RELOCKED AND AGAIN THE ALARM. I THEN DISCONNECTED THE BATTERY AND RECONNECTED. EVERYTHING SEEMS TO BE WORKING PROPERLY NOW AND THE AIR BAG LIGHT ALSO WENT OUT. *TR

2007 HYUNDAI SANTE-FE PURCHASED NEW FROM PLAZA HYUNDAI, LTD, 2740 NOSTRAND AVENUE IN 2006, ON OCTOBER 3, 2007 WHILE SITTING IN VEHICLE I NOTICED SMOKE COMING FROM THE DASHBOARD AND THEN THE WINDSHIELD CRACKED. I TOOK THE VEHICLE TO PLAZA HYUNDAI, THEY INSISTED THE DAMAGE WAS CAUSED BY A ROCK AND SAID I SHOULD CONTACT MY INSURANCE COMPANY WHICH I DID, THEIR INVESTIGATION FOUND THAT THE DAMAGE WAS CAUSED BY A "DEFECTIVE WIRING IN THE DEFROSTER CAUSED A FIRE WHICH RESULTED IN DAMAGE TO WINDSHIELD." THIS REPORT WAS GIVEN TO THE DEALERSHIP AND STILL THEY REFUSE TO REPAIR MY VEHICLE. DUE TO SERIOUS HEALTH ISSUES, I HAVE NOT BEEN ABLE TO PURSUE THIS ISSUE AND THE VEHICLE HAS BEEN IN STORAGE. I HAVE RESUMED MY ATTEMPTS TO GET HYUNDAI TO TAKE RESPONSIBILITY FOR THE DAMAGES AND FIX THE FAULTY WIRING, AS OF 2/22/10 THEY STILL REFUSE TO EVEN INSPECT THE VEHICLE. THE VEHICLE IS DEFECTIVE AND I WAS ADVISED NOT TO DRIVE IT AGAIN UNTIL THE PROBLEM WAS SOLVED. I PAID OVER $30,000 FOR THE VEHICLE AND HAVE BEEN UNABLE TO USE IT. *TR

TIRES START CUPPING AROUND 6,000 MILES ON NEW TIRES. *TR

2007 HYUNDAI SANTA FE, WE HAD A PROBLEM WITH THE CAR ACCELERATE WHEN THE BRAKES ARE APPLIED. WE TOOK IT TO BOUCHER FOR REPAIR. THEY SAID NOTHING WAS WRONG BUT THEY REPLACED THE COMPUTER BOX. THE CAR STILL HAS PROBLEMS IN COLD WEATHER. THIS ALSO LEAD TO BRAKE PAD FAILURE. *TR

REAR BRAKE PROBLEM IN A 2007 HYUNDAI SANTE FE VEHICLE WITH 29K MILEAGE. LEFT REAR BRAKE CALIPER STICKS INTERMITTENTLY CAUSING HIGH PITCH SQUEALING/SCRAPING NOISE AND HOT WHEEL HUB. MULTIPLE OTHER CUSTOMERS REPORT THE SAME ISSUE ON WEBSITE FORUM @HYUNDAI SANTE FE CARSPACE AUTOMOTIVE FORUM. MANY WITH MUCH LOWER MILEAGE CLAIMS. MY DEALER INSPECTED AND SAID NOTHING COULD BE FOUND WRONG. ROOT CAUSE ANALYSIS POINTS TO REAR BRAKE CALIPER ASSEMBLY RUSTS FROM SALT CORROSION AND CAUSES THE CALIPER TO STICK ON THE BRAKE WHILE DRIVING WITH FOOT OFF THE BRAKE. PROBLEM RESURFACED 50 DAYS LATER. WAITING FOR MY APPOINTMENT TO HAVE DEALER LOOK AT THE ISSUE READDRESS THE PROBLEM. HYUNDAI TECHNICAL SAFETY BULLETIN 08-BR-002 DATED 12/2008 CALLS FOR CLEANING AND GREASING THE PAD CONTACT SURFACE OF THE CALIPER CARRIER TO RECTIFY THE CAUSE. THIS DOES NOT ADDRESS THE ROOT CAUSE OF MATERIAL DEFECT OF RUSTING ON REAR BRAKE CALIPERS. *TR

I OWN A 2007 HYUNDAI SANTA FE. I NOW HAVE 50K ON MY VEHICLE AND I AM GOING ON MY THIRD SET OF TIRES. THE LAST SET OF TIRES I BOUGHT COST JUST UNDER $900.00. IT HAS BEEN BACK TO THE DEALER THREE TIMES WITH ABOUT FIVE PHONE CALLS AND EVERY TIME THEY TELL ME THAT THEY KNOW NOTHING ABOUT THIS PROBLEM AND NO ONE ELSE HAS THIS PROBLEM. I HAVE HAD IT ALIGNED BUT NO CHANGES WERE MADE BECAUSE EVERYTHING IS WITHIN SPECS. JUST HAD IT BACK TO THE DEALER TO CHECK SUSPENSION AND AGAIN TO FIND THE SAME PROBLEM, BUT ONCE AGAIN THEY SAID NOTHING IS WRONG. BUT YET I AM WEARING THE INSIDES OFF OF MY TIRES ABOUT EVERY 20K. THERE HAS TO BE A FIX FOR THIS BUT HYUNDAI TELLS ME THERE IS NOTHING WRONG. THIS PROB HAS TO BE KNOWN ABOUT BECAUSE IT IS ALL OVER THE INTERNET. *TR

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTE FE. WHILE AT A STOP SHE WAS REAR-ENDED. AFTER THE CRASH SHE RECEIVED RECALL NOTICE NUMBER 09V122000(SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT) . THE DEALER WAS NOTIFIED, AND SHE WAS REFERRED TO HER INSURANCE COMPANY. THE VEHICLE WAS TAKEN TO A REPAIR FACILITY FOR BODY DAMAGES. THE FAILURE AND CURRENT MILEAGES WERE 46000.

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE DRIVER-SIDE SUN VISOR SUPPORT MECHANISM ATTACHED TO THE ROOF HAD FRACTURED. THE DEFECTIVE SUN VISOR OBSTRUCTED THE DRIVER'S VISIBILITY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE MECHANIC STATED THAT THE SUN VISOR REQUIRED REPLACEMENT. NO REPAIRS WERE MADE. THE FAILURE AND CURRENT MILEAGES WERE 43,000. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE.