2006 Honda VFR800

Defect. ON CERTAIN PASSENGER VEHICLES AND MOTORCYCLES, THE OWNER'S MANUALS CONTAIN INCORRECT CONTACT INFORMATION FOR THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S (NHTSA) VEHICLE SAFETY HOTLINE.

Risk. THE LANGUAGE IN THE OWNER'S MANUALS IS NOT IN ACCORDANCE WITH THE CURRENT MANDATORY REQUIREMENTS.

Remedy. HONDA WILL SEND A POSTCARD TO DEALERS AND OWNERS WITH THE CORRECT NHTSA VEHICLE SAFETY HOTLINE INFORMATION AND WITH INSTRUCTIONS TO INSERT THE CARD INTO THE "REPORTING SAFETY DEFECTS" SECTION OF THE OWNER'S MANUAL. THE RECALL BEGAN ON AUGUST 2, 2006. OWNERS MAY CONTACT HONDA AT 1-800-999-1009, ACURA AT 1-800-382-2238 OR HONDA MOTORCYCLES AT 1-866-784-1870.

MY MOTORCYCLE ENGINE STOPPED OPERATING FOUR TIMES, TWICE IN TRAFFIC AND I WAS UNABLE TO RESTART THE ENGINE. I COULD NOT RESTART THE ENGINE UNTIL I PLAYED WITH FUSES, AND NOTICED MAIN FUSE B (FUEL INJECTION SYSTEM) WAS EXTREMELY HOT. ONCE HOME, I NOTICED THAT THE WIRE COMING OUT OF MAIN FUSE B WAS SMALLER GAUGE THAN THE WIRE IT WAS CONNECTED TO, AND IT WAS BAKED FROM OVER HEATING SO BAD IT WAS TURNED BROWN WITH A TAN STRIPE INSTEAD OF RED WITH WHITE STRIP IT WAS SUPPOSED TO BE.

DRIVING DOWN STATE ROAD DOING APPROX 40 MPH WHEN BIKE SUDDENLY LOST POWER AND DIED. PULLED OVER AND AFTER A FEW ATTEMPTS IT RESTARTED. THIS HAPPENED 3 MORE TIMES IN MY 14 MILE COMMUTE TO WORK AT VARIOUS SPEEDS INCLUDING ONCE WHEN TURNING ACROSS TRAFFIC. AFTER FINDING A AFE PARKING LOT I DISCOVERED MY MAIN FUSE AND WIRES HAD MELTED AND WAS DAMAGED. MY STARTER RELAY CONNECTION WAS ALSO MELTED. THIS WAS A KNOWN FLAW FOR THESE BIKES AND HONDA HAS IGNORED THIS SAFETY ISSUE.

MOTORCYCLE POPS BACK THROUGH AIR CLEANER HOUSING, I AM AFRAID IT'S GOING TO CATCH FIRE. *JB