2022 Ford Maverick Hybrid complaints

My 22 Lariat Hybrid lost power last Wednesday while I was driving it. I believe the engine was still running, but I couldn't accelerate. I parked, turned the truck off, then back on, and drove home. I was able to drive it to the dealership the next day, no problem, It's at the dealership right now. I haven't heard anything yet.

I was going 70 mph on the interstate when I suddenly lost power. The engine wouldn’t respond. I had to quickly change lanes to get off of the interstate. Luckily there was space otherwise I could have been in an accident. The dash gave a warning of Advance Trac issue. The D on the selector was flashing. I got stopped and turned off the truck. Luckily after I gathered myself I searched and found it was a sensor issue and the truck did start and I drove 2 hours home. I was very scary though not having control of the vehicle at 70 mph.

I was driving [XXX] on [XXX] around [XXX] yesterday morning north . Without warning I lost control of the accelerator and the speed diminished to around 35 MPH. Several warning lights flashed onto the dashboard saying systems were failing. Check engine light came on and a "wrench" symbol appeared. The light on the transition control dial for "D" started flashing. I was in a construction area with no shoulder when it happened. I was able to creep into a niche on a partial turnoff around .5 miles later. I shut the car off and restarted it. Same problems. I noticed I was .25 miles from an exit and waited for traffic to clear from behind. Managed to get to 10-15 MPH and up the exit with traffic blaring around me. Parked at a McDonald's and wait for a tow truck that never came after 2.5 hours. Made an appointment with nice folks at Classic Ford in Columbia. I was told tow truck might be another 2.5 hours so I tried to restart car. This time only the "check engine" light stayed on. I drove the car slowly in electric mode around the parking lot and it seemed safe at lower speeds. I mapped out a "less the 45 MPH" route to Classic Ford and was able to reach there without further incident. However, the "check engine" light remained on the entire trip. The car is now being checked by Classic Ford. I have had no diagnosis yet. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

See attached document for complaint

The brakes are grabby during low speed driving (5mph). It occurs during slow turns, pulling into parking spaces, going through a restaurant drive-thru, etc. In this situation, you typically keep your foot on the brake pedal and slowly let off to move forward and then equally apply the brakes to stop. When this problem occurs, when you are trying to apply the brakes the normal amount of pressure isn't enough, so you press harder and harder until the vehicle stops in a lurch, many times accompanied by a loud "thunk" in the front end.

Driving down highway at normal speed. Car lost all engine power, still on but indicated gear shift was not in drive. Pulled off to side of highway. Put drive in park. Dash came up with a bunch of warnings. Turned off. Turned back on. Same warnings happened. Put it in drive and it just start going forward without any input. Was injured in power. Drove it to safe spot. Turned off called for tow. Tried turning it back on and returned to normal but check engine light was on. Very unsafe to loose power in the middle of the highway. My two friends died like that!

While driving at cruising speed on freeway/interstate, experienced sudden and unexpected loss of power and multiple error codes, including "gear selected will engage at low speed" and "service advancetrac", together with flashing service engine soon light. This occurred approximately 3 weeks after completing service recalls for power train control module (23E09) and turn signal outage detection failure and instrument panel cluster IPC Illumination

The contact owns a 2022 Ford Maverick. The contact stated that mold was forming inside the front of the cabin due to a leak from the windshield. The vehicle was taken to a dealer where the failure was confirmed. The contact stated that the mold was a hazard to the health of any occupant while inside the vehicle. The manufacturer was also notified of the failure. The vehicle remained in the possession of the dealer unrepaired. The failure mileage was approximately 20,000.

Took my maverick for the system softward update and when I drove it after the update my truck suddenly had a loss of total power while driving on the freeway at 70mph. The dashboard cluster had all the lights come on check engine, abs ect light up and I had limit power 5mph enough to get my to the side of the freeway and all of a sudden the brake engaged and the truck jolted to a stop. I took the truck back to the dealer and they uploaded the system update again and released the truck back to me and a couple of days later the same thing happened.

Driving at highway speeds, the vehicle started de-accelerating with a message on the dash saying to slow down to shift in selected gear. The vehicle did not respond to any accelerating to avoid traffic to get to the side of the road and only deaccelerated. The "D" indicator in the PRNDL was flashing as i pulled off to the side of the road. Once stopped, error messages appeared on the dash; "Hill Start Assist Not Available," "Service AdvanceTrac," "Pre-Colision Assist Not Available," and "Service Vehicle Soon." After waiting 5-7 minutes with the vehicle turned off, The vehicle was again drivable with the CEL illuminated. This issue generated two codes: U1011 - The automobile fault code U1011 indicates a problem with the Controller Area Network (CAN) communication harness, a faulty Engine Control Module (ECM), or a poor harness ground connection. The most common symptom is the Engine Light ON or Service Engine Soon Warning Light. U1028 - The automobile fault code U1028 indicates a communication issue between the vehicle’s modules. This is often accompanied by the engine light turning on. The cause of this fault code could be a faulty module, an open or shorted module harness, or a poor electrical connection in the module circuit.

The contact owns a 2022 Ford Maverick. The contact stated that while driving the vehicle in a parking lot at approximately 10 MPH, the engine shut off and the vehicle shifted into park(P) independently. The contact stated that several unknown warning lights were illuminated. The contact was able to restart the vehicle; however, the vehicle shuddered while in motion. The contact turned the vehicle off and restarted it after 15 minutes, and the vehicle operated as needed, however, the check engine light illuminated. The vehicle was taken to the residence where it stayed for 2 days. The vehicle was taken to the dealer, but the check engine light was no longer illuminated. The dealer stated that the failure could not be duplicated; however, the manufacturer application showed the messages, "Pre-Collision Assist Not Available", "Service Engine Soon Warning", and "Power Train Malfunction/ Reduce Speed". The vehicle was not repaired. The manufacturer was not aware of the failure. The failure mileage was approximately 30,473.

Was driving on the freeway and a ton of warnings suddenly appeared on the dash. Pre-collision assist not available, stop driving now, service engine soon, powertrain malfunction, etc. The truck would not accelerate when the gas pedal was pressed and slowly slowed down. The truck would auto-accelerate (without gas pedal input) to about 20 mph unless the brake was applied (limp-mode). I pulled over, disconnected the 12V battery and reconnected which seemed to fix the problem. The dealership could not figure out the issue. I believe that the 12V battery was somehow drained to a point where it fed a low-voltage to suite of safety sensors which all went haywire.

Car stopped moving although still on, then had many flashing warnings. the "D" on the drive knob was flashing. Turned the car off and on a few times and eventually gor it moving then it tried to engage in its own determined speed! I only had a mile to get home so made it home with out it stopping again. The errors codes ( Vehicle alert) showing on my "Ford" app are: 1.precollison assist not available 2.Powertrain malfunction/reduded power 3.service engine soon(the engine has detected a fault) there were others while this was first happening but i was overwhelmed with fear and don't remember The car is at the local Ford Dealer and they have yet to find the problem I see on some online sites others having this same issue - it appears that it after a recall which i have had a few fixed This is so terrifying and if I had been going 75 on the frwy I was headed to it could have been deadly...

Engine failed while driving on highway. No noises, just check engine and multiple other warnings on instrument panel turned on. The vehicle lost power but would still drive at about 25 mph. I was able to stop the car in a safe place and after turning it off for 10 minutes it started up again like normal.

I brought my 2022 Ford Maverick hybrid to Franklin Ford dealership on 10/2/23 for repair with battery issues I was having previously. At random times the car would not turn on from start despite the battery testing at full power. Franklin Ford installed software updates they said resolved the power issue and I drove off the lot with the car on 10/7. 15 minutes later I was driving on the highway at 70 mph and the entire dash panel lost power. I tried to accelerate and the engine had no power as well. Fortunately I was safely able to move to the break down lane and coast into a highway exit. Since the car had no power I removed the key and tried restarting which worked successfully. My engine light was on and I received about 10 engine and powertrain warnings in my Ford mobile app. This was a major and life-threatening malfunction that the dealership had no explanation for and neither did my case worker at Ford Customer Service. I had owned the car for less than 12 months at the time and it was extremely concerning knowing that the car could now shut off at a moments notice while driving. I returned the vehicle to the same Franklin Ford dealership where it received the software update that seemed to put the vehicle into failure. Their solution was to reroute the wiring harness through the engine since it was previously exposed to the wheel well and had corroded the external layer of the harness. I'm submitting this report because I have seen dozens of similar cases with the sam

Freeway driving - normal conditions. Vehicle suddenly loses most power and all the warning lights appear. After powering off for a couple minutes then it will act normal with check engine light on. This happens multiple times in a couple hundred mile drive.

Driving around 40 mph and suddenly my dash lights up light a Christmas tree. Car enters limp mode and slows down on its own. Notified via ford app of power train failure, pre collision and service engine (although my car was serviced a couple of weeks prior). Dropped my vehicle off at the dealership and they decided to hang onto it as they have no solution and are waiting for engineering to provide one.

I had my truck in for recall fixes. Since then it has intermittently gone into limp mode twice. No warning or notice. The first time it happened I was merging onto the freeway. This could have been a serious accident as I lost power and cars were flying around me at 60mph. I was left stranded twice while waiting for the tow truck and Lyft to pick me up. The dealership does not offer loner cars while yours is being fixed. So far the truck has been in the shop for this issue 18 accumulative days.

4 days after getting my truck back from work to complete recalls and the 1st incident of the truck going into limp mode, it happened again. Had to call a tow truck and tow to the dealership.

I experienced a loss of engine power/propulsion at 71 mph. There were no warning lights, messages or chimes to indicate something was wrong. I only noticed I was losing speed when the cruise control went to the standby/cancelled state from the 71 mph set point. The accelerator pedal was completely unresponsive. I coasted to the side of the freeway and performed a key cycle by powering the vehicle off, opening and closing the driver’s door to put the modules to sleep. Once the instrument panel cluster and center stack screens went dark, I restarted the vehicle and was able to proceed with my trip. It’s worth noting that I recently had the instrument panel recall repair performed which was a reflash of the IPC module. Other Maverick drivers have reported similar incidents after Ford 24C01/NHTSA 24V140 was “fixed.” I will be reporting this to the manufacturer as well.

This weekend I drove from home, Centerville, to Virginia and 3 TIMES the engine would shutoff or disengage the drivetrain. And I received this message: "Gear Selected will Engage at Low Speed". It happened on the highway at highway speeds. Each time I was going uphill. When it happened the first time, the check engine light came on and remained on for the duration of the trip to Virginia. Secondly, each of these times the gear shifter would start blinking and remain locked until stopping and shutting off. It seemed like the engine turned off as I could not hear it rev. Steering and braking worked like normal. Third, and this happened each time, as I was braking and stopping the truck would abruptly put itself into park just a half second before I came to a complete stop. upon restarting, the truck it put itself into grade assist mode, both against my wishes or the actual need for it. It took 2 to 4 tries for this to go away so I could drive like normal. The next morning I went for a short drive to get breakfast. Upon restarting, the engine light went back to normal and relit while driving. It has not come back on while driving since. Later, I went for a slightly longer drive and upon braking and coming to a complete stop for a stop light, the truck felt like I was driving over railroad tracks. This happened just that once. I ended up driving home through the rural but empty highways of West Virginia and through all that the above issues never returned. ~18K miles ~No idea if

One week after having recall [XXX] completed on [XXX] driving on [XXX] at about 70 miles per hour my truck slowed down to 10 miles an hour with my dashboard lighting up with a slew of warning lights blinking like crazy. I was able to get to the side of the road before it conked out all the way. Luckily my wife and did not get rammed into. Service engine now, powertrain failure, will not go into gear at this speed, collision assist warning lights all came on and were blinking. This was [XXX]. Luckily somehow I got the computer rebooted and drove home very carefully. I took it to dealer the following Monday, they had it for 2 days but warning lights were not on so they gave it back to me with nothing rectified. One week later this happened again on [XXX] a smaller highway, same warning lights but at a slower speed. Once again I got the computer to reboot but had to hold my foot on the brake because vehicle wanted to take off and the speed limit was 35. I took it into the same dealer the next day [XXX] and it has been their since. Today is March 29. The dealer finally was able to get Ford to admit this recall screwed up some software and they have no fix yet. No one should go ahead and get this recall done because someone is going to get killed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2022 Maverick shuts down without warning. Driving at highway speeds, 65mph, the car simply loses all power. This started happening after factory recall work was completed on 3-11-24. I have stranded 7 times on the shoulder.

After driving about 500 ft, check engine light appeared, propulsion stopped immediately and I was only able to pull off road with momentum. Fortunately, I was at a driveway. Otherwise, I would have been required to park in the road (due to steep shoulders) on a two lane road. If I had been followed closely by a heavy vehicle, it probably would have rear-ended me since the propulsion quit so abruptly. After I turned truck off and restarted, it had enough propulsion to return 500 ft home at about 10 mph. -Vehicle is available for inspection upon request. No inspections performed other than dealer for repair/reset. -Dealer reset was done and no further problems noted. No replacement parts needed. Dealer said they had one other Maverick with this problem.

Powertrain malfunction/reduced power, pre-collision assist not available, service engine soon warning, truck went into limp mode and was a hazard by reducing power and speed which cause a tariff hazard

Vehicle suddenly stopped accelerating while l was driving at 70 mph on a freeway and would not accelerate beyond 35 mph. Multiple warnings started flashing on dashboard - Powertrain malfunction / Reduced Power, Service engine soon, Pre-collision assist not available. I stopped on the shoulder, switched off engine, waited for 5 minutes and restarted engine then all warnings were gone and l was able to drive fine. But this was very scary experience as it was very dangerous to suddenly slow down from 70 mph to 35 mph in middle of fast traffic, l was lucky that there was no accident. Just few days before this incident, l had got few recalls repaired at Ford dealership that included updates to Power Control Module software.

While driving, the car severely jerked and all the lights on the dash lit up. I received the errors “Powertrain failure”, “vehicle in low gear mode”, “pre collision assist not available” and “service engine soon”. I quickly lost all power and was completely unable to accelerate. I happened to be going down hill so I coasted to a clear area where I could safely stop. After coming to a stop the car could not move forward and needed to be towed. I have not received any errors prior to this. However, I did recently complete a recall that involved a powertrain software update.

Vehicle lost all power while driving on the freeway. Had to pull over, find a safe place to park and while doing that, the engine sounded like a diesel engine.

We have been informed of this safety recall since june of last year and still do not have a solution for it. We have been parking outside to mitigate fire risk. The ford dealer in Olathe KS and Shawnee KS have both been unable to alleviate this risk for our vehicle.

While traveling on the highway at approximately 75mph the instrument cluster began to flash warnings, (Selected gear will be changed to when speed slows down, precollision assist not available, service engine soon) the accelerator pedal was unresponsive, and the vehicle began to slow. I parked the vehicle, shut the engine off, and restarted. upon restarting the vehicle would only move at approximately 10mph, the accelerator pedal was still unresponsive. I then parked the vehicle and called for a tow truck to take the vehicle to the dealership.

My vehicle was parked in a secure parking garage at work. I came out from work and noticed a hairline crack in the windshield. I took it to Safelite seeking to have it repaired and was told the entire windshield needed replaced and the windshield was “thin” and “dangerous”

Yes, I was driving around 75 mph [XXX] in Thousand Oaks, Ca and I lost power to the engine. No acceleration from the gas pedal. Was able to turn hazards on and make it off freeway. This issue now has happened over 5 times at all speeds. Truck is currently with Ford. Also this issue never happened until Ford fixed the CV axles that went bad. First time it lost power was the night I picked up from dealership from them fixing cv axles. They also did some recall updates with codes. I can say this is a very dangerous situation when losing power driving on a California freeway. Not having my truck is also causing me many issues with work and clients. The truck is my lifeline. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle had a sudden loss of power at ~40mph and began rapidly decelerating. Had there been a car behind me, the sudden deceleration could have caused a collision. Warning lamps and messages displayed on the instrument cluster instantly. I pulled the OBD codes and received U1011 and U1028 as active codes. These codes indicate a PCM software issue. It is important to note that this issue occurred after a PCM software update was performed as part of a recall. I power cycled the vehicle, cleared the DTC codes, and after multiple attempts, the vehicle worked normally again and I was able to drive it home. I have been unable to recreate the problem after clearing the codes. Prior to this incident, I have not had any problems from the vehicle. I suspect the the PCM software recall is what caused the problem.

Had recall updates completed 3-11-24. ..23C41, 24C01, 23E09, 23E07 3-12-24 Maverick dies on the interstate going around 65mph. It just stopped running. I was able to pull over and after waiting several minutes was able to continue driving with the check engine light on. Took it back to the dealer and was told nothing was wrong. It has happened 2 more times dyeing at 65mph. 3-13-24 and 3-19-24

I think it's a software issue. As of today, I've had the problem three times since having my BCM and PCM reprogrammed. The truck will suddenly loose power and go into some kind of limp mode. The dash screen starts throwing notices in quick succession: low gear only, check advancetrac, hill assist not available, powertrain malfunction/reduced power, pre-collision assist not available, the light indicating what drive mode (reverse, park, drive, etc.) starts flashing and then switches itself from drive to park, and then the parking brake turns itself on.

The contact owns a 2022 Ford Maverick. The vehicle was taken to the local dealer for recall repairs, of which three were completed. While driving 70 MPH on a five-lane interstate, the navigation screen began to ding, and alerts and messages were displayed. The service track was offline, the incline assist was offline, and the vehicle failed to accelerate above 20 MPH and went into LIMP Mode. The driver pulled over to the side of the road. The contact reset the battery and continued to drive. The service light was illuminated. The vehicle was taken back to the local dealer, who stated that the failure was not related to the recalls that were completed. The vehicle was not diagnosed or repaired. After approximately four days of driving at unknown speeds, the failure recurred. The vehicle was taken to another local dealer, Wyatt Johnson Ford (646 Thompson Ln., Nashville, TN 37204), who stated there were no codes and was unable to determine the cause of the failure. The dealer's recommendation was to download and update the software and test drive the vehicle. The vehicle was repaired. The manufacturer was not notified. The failure mileage was approximately 29,781.

After having two recalls done on 2/29 the next day my vehicle dashboard lit up like a Christmas tree. There was a message about low gear, the shifter was blinking, I lost collision assist, traction control, and something called bill start. I was able to pull over and shut it off. When I restarted a minute later it accelerated on its own with no input from me. Braking worked but it was slowly moving up in speed.

Vehicle is vibrating or shuddering strongly when accelerating at about 50% power. CV Joints are failing prematurely (35,000 miles,) as many others have reported.

The dealer said a hybrid part that transfers power failed. I was starting from a stoplight at a busy intersection and lost power and a warning popped up saying to turn my engine off immediately, luckily I was able to coast into a gas station. If I was on the highway it could have been catastrophic.

Just had a recall completed related to software programming in the past 3 weeks. Since then this has occured twice. While driving at highway speeds the vehicle quickly lost/reduced power and slowed down to 20 mph and produced a message that stated " Powertrain malfunction/Reduced power, engine service soon, and precollision assistance not available". This caused me to almost be rear ended and get into an accident with other vehicles on the road. It likely would have resulted in an accident/injury if not for light traffic that day. Ford has stated they cannot reproduce the issue.

Today I was driving on the highway when the precollision alert came on with no vehicles in front of me. About 5 minutes later I received a series of error messages and the vehicle went into a limo mode where it automatically drove at 20 MPH with no accelerator input from the driver. The following errors popped up on my screen. Check engine light Power train light (wrench)/reduced power Brake light pre-collision light/pre-collision unavailable Hill assist message Will engage in gear selected at low speed. Pulled over, shut it off, turned it back on, put in drive and it started accelerating on its own but only up to about 20mph, stopped and shut it off again. Turned back on and all the messages and light disappeared except check engine light remained on.

See attached document for complaint

After having recalls worked on, my truck became completely inoperable. The first failure warning was a message that said "Gear will engage at low speed." I lost the ability to control acceleration. I then got messages for "Powertrain malfunction" "Pre-collision assist not available" "Hill start assist not available" "Service AdvanceTrak" "Service vehicle soon" "Check Engine." Came to a stop. Truck then began accelerating on its own. Being unable to control the acceleration of my vehicle was scary and dangerous. The auto-acceleration was very unsettling, causing me to jerk back and forth by applying the brake to limp home. If this had happened on the highway, it would have been very bad news. This issue occurred twice. The first time the dealer released it and said it was fixed. The second time they released it without doing anything. The vehicle has been inspected by Ford Mechanics exclusively. No prior warnings occurred. The problem appeared seemingly out of nowhere. The truck drove perfectly for 49,000 miles. The day after the recalls were performed, it was inoperable. A week after getting it back, the failure happened again, this time stranding me in another city.

Driving on the freeway and lost gas engine power. Had to coast across several lanes of traffic without propulsion to get the the shoulder. Shut off the vehicle and restarted and it has worked fine for the past couple of months.

While towing my boat down the interstate my truck lost all power from the engine and the dash began flashing with all sorts of errors. There was zero warning of this. Thankfully, I was safely able to get to the side of the interstate thankfully but I was basically dead in the water. The truck would sort of drive on its own, no input from me at all, it would just start moving if I let off the brakes and get up to about 35mph. The dash had the check engine light on, ABS light, and the transmission light on. The following messages came up on the screen; service engine, service advancetrac, hill start assist disabled, and the pre-collision assist was disabled. Thankfully no one was injured but it was incredibly dangerous that the vehicle lost all power in 70+ mph traffic, especially while towing a boat.

Vehicle enters deep sleep and makes it unable to communicate with vehicle. All 12volt operations stop working such as dome lights, remote features, key fob. Sometimes vehicle is battery is dead and must be jump started.

The vehicle at a full stop such as a red light, will try to surge forward. It feels like someone is nudging you on the shoulder to get moving over and over. As if the vehicle is eager for the light to turn green.

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Engine completely fails while driving at highway speeds. Press on accelerator and no power. However Electronics, dash etc, are still on. It has happened 6 times in 2 weeks. Maverick has 26K miles. Each time I have had to coast to a safe shoulder or exit without any ability to accelerate. No warning lights, messages or other symptoms prior to occurrence. I have had it happen in "Normal" mode while using cruise control and lane assist. I have had it happen in "Normal" mode without using lane assist or cruise control. When it does happen, warning light says pull to safety, and check engine light remains on. I Am able to brake, place car in park, turn off car, restart, check engine light remains on and then am able to drive briefly again. It then happens again. Originally happened on Feb 14, 2024, then again on Feb 22, 2024, and then 4 times on February 25, 2024. Have taken back to dealer each time. Dealer cannot find anything associated with Code readings. Dealer is unable to duplicate. Ford has been unresponsive in providing any service bulletin. I am not the only Maverick Hybrid vehicle experiencing this. An outstanding engine failure and engine fire recall remains without resolution from Ford. I have given them permission to drive vehicle 100 miles, as that is when it first occurs. My vehicle is not safe to drive. My daughter and I were almost killed on high speed highway when the engine failed and 18 wheeler barreling down behind us. Ford has offered no solution or steps to