2018 Ford Fusion complaints

Losing coolant in the engine. No apparent leaks on ground or around engine. Rough running when first started but smoothed out after a few miles. Engine overheats if close watch isn't done on the coolant reservoir. I am worried the engine may catch fire if it gets too hot. Taken to mechanic who could not repair. Codes found P 3002 & P1299.

2018 Ford Fusion 2.0L ecoboost engine coolant intrusion issue at around 76000 miles. Took to dealer today to check for needing constant coolant topoffs and rough idle and check engine light. Dealer diagnosed as coolant intrusion in cylinders and into the engine, asked for full engine replacement (long block) at $7200 + tax bill. I called Ford customer service, they said no recall or customer satisfaction program to get a discount on the repair bill. Very disappointed at Ford quality, a whole engine replacement needed at less than 80k miles on a well maintained car. Requesting NHTSA to force Ford to issue a recall and cover the repairs since its a wide spread issue.

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic and was diagnosed with a failed EVAP purge system. The contact was informed that the EVAP purge system needed to be replaced. The vehicle was not repaired, and the failure reoccurred. The contact stated that the fuel tank made a vibrating sound before the vehicle stalled. Additionally, the contact stated that after refueling the vehicle, the vehicle failed to restart immediately. The contact stated that the vehicle restarted after several attempts. The dealer was contacted and made aware of the failure and a service appointment was scheduled. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 79,000.

The contact's wife owns a 2018 Ford Fusion. The contact stated that upon starting the vehicle; there was heavy white smoke coming from the exhaust pipe. The contact then stated that while driving at various speeds, the vehicle would hesitate upon depression of the accelerator pedal with the coolant and check engine warning lights illuminated. The vehicle was initially taken to an independent mechanic where a diagnostic test showed that there was coolant intrusion into one of the cylinders. The dealer was notified of the failure and the contact was informed that the vehicle was not included in a recall. The manufacturer was also notified of the failure and the contact provided the same information. The manufacturer referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 90,000.

The contact owns a 2018 Ford Fusion. The contact stated that upon starting the vehicle, the vehicle briefly vibrated before returning to normal functionality. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined there was a misfire in cylinder #2, requiring the spark plug to be replaced. The vehicle was not repaired. The vehicle was then taken to the dealer, who determined that coolant intrusion had damaged the engine block, requiring the engine to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 102,000.

The contact owns a 2018 Ford Fusion. The contact stated that while operating the vehicle, The check engine warning light illuminated off and on and the vehicle was driving rough. Upon inspection, the contact discovered that the engine coolant level was very low. The vehicle was taken to the local dealer who diagnosed a cylinder misfire caused by coolant intrusion in cylinder #2. The vehicle was not yet repaired. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The contact was informed that the vehicle did not qualify for the Extended Warranty coverage for the failure. The failure mileage was 50,000.

Went to store and placed vehicle in park Whe returned vehicle would not shift into gear Shift fault warning on dash see owners manual Had to have vehicle towed to dealer for repairs Informed bushing had failed

The contact owns a 2018 Ford Fusion. The contact stated that while driving at approximately 55 MPH, the check engine warning light illuminated. The vehicle was taken to a local dealer who determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 130,000.

The flex plate is cracked at 87,000 miles and causing the vehicle to make a loud rattling noise near the bottom of the engine toward the back of the transmission. While driving the vehicle it drags while accelerating on turns and gives a hard shift in gears from park. The vehicle was inspected by Aamco transmission and several Ford dealers where i was told that this seems to be a common issue with the ford fusions according to several ford dealers but the ford manufacturer is refusing to place a recall for this matter. There is no warning indicating the issue is near or has occurred until the flex plate has already caused damage.

Coolent intrusion cylinder 2 103000 miles car is undrivable sucking coolant in to cylinder within 30 minutes to an hour. paid 23,000 for a car I cannot drive. 2018 ford fusion out of warranty now for will not help or replace since no recall was placed on this vehicle. Something needs to be done there are so many others and car isn't even 7 years old.

The contact owns a 2018 Ford Fusion. The contact stated that while driving or while stopped at a traffic light, the vehicle stalled. The vehicle was sputtering while driving at various speeds. The check engine warning light was illuminated. The contact stated that after refueling, the vehicle failed to restart. The vehicle was taken to an independent mechanic, who informed the contact that the failure was due to the canister purge valve. The vehicle was taken to the local dealer, where it was diagnosed that the canister purge valve was stuck. The vehicle was not repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 113,000.

2018 ford fusion 1.5 L coolant intrusion at 65,000 miles. Ford refuses to help us in this matter. Our vehicle was not placed under their recall list which was for 2013-2019 escapes and fusion 1.5 L ecoboost motors for design flaw causing coolant intrusion. Our car has that EXACT motor and exact problem. It has a cylinder 3 coolant intrusion.

Upon shifting the gear to put the vehicle in park, the shifter automatically put itself in neutral and the parking brake enabled. A warning came on the dash, saying SHIFT SYS FAULT Service Required. A wrench light was illuminated as well. The bushing securing the shifting cable was gone, as if it crumbled to pieces. I have replaced this bushing a few times within the last year.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the spark plugs. The vehicle was repaired, but the failure reoccurred. The vehicle was then taken to the dealer, who determined that coolant intrusion had damaged the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 19B37. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 76,000.

The contact owns a 2018 Ford Fusion. The contact stated the vehicle was low on coolant and failed to start. The vehicle was taken to a local independent mechanic where it was diagnosed that there was coolant intrusion into the engine. The contact stated that there was an increase of white smoke coming from the exhaust. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 125,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the contact noticed white smoke coming from the tailpipe. Additionally, the check engine warning light was illuminated. The contact drove the vehicle to a safe location and parked the vehicle. The contact checked the oil level and confirmed that the oil level was adequate. The vehicle was taken to the dealer where it was diagnosed with a coolant leak into cylinder #3. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was informed of an unknown recall; however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 131,768.

The contact owns a 2018 Ford Fusion. The contact stated while driving 30 MPH, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to be restarted; however, the failure persisted. The contacted stated that the failure persisted, and the vehicle would not restart. The vehicle was taken to an independent mechanic where it was diagnosed as a malfunction with the gas cap. The contact was informed that the gas cap needed to be replaced. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 73,000.

Vehicle throws a system shift error when shifting vehicle. Due to loose transmission shift cable. Missing retention clip. Reported error on previous Ford fusion models. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2018 ford fusion is suffering an engine intrusion problem as a result of horrible engine design. Ford did NOT disclose or announce this very well known problem. My engine has overheated multiple times caused me to pull over on the HIGHWAY in fast moving traffic. Not only is the overheating a danger to my safety but so is sitting in a sedan on the side of the highway with tractor trailers passing me at speeds of 70mph.

The contact owns a 2018 Ford Fusion. The contact stated while driving 65 MPH, the temperature gauge displayed that the engine was overheating. The transmission warning light was intermittently illuminated. The contact pulled over to the side of the road, and the vehicle was towed to the dealer, who related the failure to Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion) associated with the VIN; however, the mileage exceeded the warranty coverage. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact was advised to file a complaint with the NHTSA Hotline. The failure mileage was approximately 89,000.

The contact owns a 2018 Ford Fusion. The contact stated that while her son was driving 70 MPH, the check engine warning light illuminated. The vehicle began to run rough, and the driver veered to the side of the road. The vehicle was towed to the local Nissan dealer, where it was diagnosed that there was no coolant in cylinder #2, and the head gasket was blown. The driver was referred to the local Ford dealer. The driver called the local dealer and was informed that there was no recall or Customer Satisfaction Program coverage for the repair. The vehicle was shipped back to the contact's residence. The vehicle was towed to the local dealer where it was diagnosed that an engine replacement was needed. The vehicle was not repaired. The contact stated that the manufacturer had been contacted and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 94,444.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was shaking abnormally. The contact stated there was white and black smoke coming from the tailgate and the hood area. The accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the temperature gauge indicated that the engine was overheating. The vehicle was driven to the shoulder of the roadway. The vehicle was towed to the residence. The contact stated that a family friend who is an independent mechanic diagnosed the vehicle with engine failure. The contact was informed that the engine needed to be replaced. The manufacturer was made aware of the failure and the contact was informed that the repair would not be covered under an extended warranty. The contact was also informed that there were no available recalls associated with the VIN. The failure mileage was approximately 88,000.

When driving our 2018 Ford Fusion on vacation my wife and I were 10 hours away from home when the motor began to fail. The check engine came in and began flashing, while driving at 75 mph on [XXX] near Tifton Georgia our engine lost all power and the car began smoking profusely. The car developed a very serious misfire and was struggling to stay running. My wife was driving and had to cross 4 lanes of traffic in a vehicle lacking power and profusely smoking from under the hood reducing visibility. Two service centers have now diagnosed the car with a bad head gasket and block and informed us that the engine will need to be replaced. Ford has now informed us that our vehicle qualified for the [XXX] customer satisfaction campaign but we were never notified and now they are refusing to cover the engine due to us being 10,000 miles over their qualifications. The vehicle had issues previously with engine oil level raising as driving. When questioning the dealership they told us it was normal and there was no coolant or fuel in the oil. We have now found records that the dealership reprogrammed the power train control module according to their [XXX] campaign and cleared codes related to these coolant intrusion issues. This issue was caught and we were blatantly lied to about the coolant going into our oil. Because of this and Ford’s failure to notify us my wife and I were put into a dangerous situation traveling at a high rate of speed in a vehicle that lost majority of its power s

My car has stalled out coming up to a stop sign. It makes a sound coming from gas tank. I can not turn it off while pumping gas because it will not start after pumping gas. It is the purge value according to my mechanic. I know the recall on this issue is on the focus models but the fusion is basically the same car

My car is over heating, having trouble starting, shacking, and blowing white smoke out of the tailpipe. It's saying mis fire so I replaced the spark plus and it's still doing it.

P302 code. P1299. Overheating, coolant in number 2 cylinder. Head gasket failure due to engine block design flaw. Catastrophic engine failure Not covered under warranty due to mileage limitations past 84,000 on vehicle and a repair cost beyond retail value of the car.

Failed transmission. Hard shift from 2-3, and 4-5. Also transmission is slipping. Only 40,600 miles on the car. Car is a dealership for evaluation, they recommend replacing the transmission.

I PURCHASED THE CAR [XXX], FEW WEEKS LATER THE CHECK ENGINE LIGHT CAME ON THEN DISAPPEARED, I WAS ALSO EXPERIENCING PROBLEMS WITH THE SEAT COOLING FUNCTION, AS THE TOUCH SCREEN CONTROLS WAS SHOWING THAT THEY WERE BOTH ON AND IT WAS STILL WINTER/RAINY SEASON OUTSIDE. I TOOK THE CAR INNTO FORD DEALER AT SAN BERNARDINO CA, THEY TOLD ME THAT MOST LIKELY IT WAS JUST A DASHBOARD LIGHT MALFUNCTION BECAUSE THE DIAGNOSTICS RESULTS CAME OUT FINE AND AFTER RESEARCHING IN OTHER MANUALS EVEN THOUGH THE SEAT COOLING FUNCTION WAS SWITCHED TO "on", THE CAR DID NOT COME EQUIPPED WITH SEAT COOLING ONLY HEATED SEATS. 3 WEEKS LATER AFTER TAKING MY CAR HOME, THE CHECK ENGINE LIGHT CAME ON AGAIN ON Y DASHBOARD, I BOUGHT AN OBDII DIAGNOSTIC TOOL, THE RESULT CAME BACK WITH 2 DIFFERENT POWERTRAIN CODES THAT WERE STRICTLY MANUFACTURER CODES. 1ST CODE WAS P1450 WHICH IS DEFINED AS UNABLE TO BLEED GAS TANK - EXCESSIVE VACCUM. 2ND CODE WAS P2196 WHICH IS DEFINED BY O2 SENSOR STUCK TRYING TO CORRECT 1ST CODE. THE P2196 EVENTUALLY CLEARED ON ITS OWN BUT THE P1450 BECAME PERMANENT. I HAD A DIAGNOSTIC MECHANIC TAKE A LOOK AT IT AND HE TOLD ME THE SAME THING, EXCEPT THAT THE MAIN CULPRIT IS THE PURGE FLOW VALVE, WHICH IS A RECALL ISSUE ON OTHER FORD FUSIONS. WHEN I PURCHASED THE CAR, I WAS SHOWED THAT THE CAR HAD NO RECALLS BUT THE "MYFORD" APP AND OWNERSHIP DIDNT TRANSFER TO ME RIGHT AWAY UNTIL 30 DAYS AFTER THE PURCHASE, WHICH IS WHEN IT FINALLY LET ME VIEWED THE CARS PRIOR SERVICE / MAINTANANCE HISTORY AND

The contact owns a 2018 Ford Fusion. The contact stated while driving 50 MPH after an oil change was performed on the vehicle, the check engine warning light illuminated, and the vehicle lost motive power an hour later. The contact was able to pull to the side of the roadway. The contact was able to restart the vehicle; however, the failure recurred while driving. The vehicle was taken to the dealer, where it was diagnosed that there was a coolant intrusion in the engine and the short block needed to be replaced. The dealer determined that the failure was related to Ford Campaign Number: 21N12. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered due to the mileage. The failure mileage was approximately 100,000.

The engine of my car is subject to a critical design flaw. Coolant intrudes into the cylinders and is consumed at an unusually high rate which may cause severe overheating and can lead to fire. Ford Technical Service bulletin 22-2229 shows that Ford is aware of this significant issue but is leaving customers to discover if their car engine is subject to the flaw. They are leaving the customer to pay for the only viable and very expensive fix, which is complete engine replacement.

The contact owns a 2018 Ford Fusion. The contact stated while his son was driving at approximately 55 MPH, the check engine and low coolant level warning lights illuminated. The contact stated that his son added coolant to the vehicle and was able to drive to the residence The vehicle was diagnosed by an independent mechanic, the next day. The independent mechanic tested the system for coolant leaks; however, no leaks were found. However, the head gasket was removed, and coolant was found in cylinder #3. The vehicle was not repaired. The vehicle was taken to the local Ford dealer for engine replacement. The manufacturer was notified of the failure and a case was opened. The contact stated that the manufacturer offered no assistance. The contact was informed that the case was closed and to call the NHTSA Hotline to file a complaint. The vehicle was at the dealer awaiting the repairs. The failure mileage was approximately 62,000.

Coolant reservoir is empty with no visible leakage and engine is no longer working

The contact owns a 2018 Ford Fusion. The contact stated while driving 25 MPH, the vehicle stalled and lost motive power and failed to restart; however, the contact was able to pull over to the shoulder of the roadway. The vehicle was towed to a local dealer where it was diagnosed that there was coolant intrusion into the engine which caused the engine to become damaged. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12 and 19B37, but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 101,000.

The contact owns a 2018 Ford Fusion. The contact stated that while checking the coolant level routinely, the contact noticed that the coolant was significantly lower than expected. The contact stated that while the coolant level was low the vehicle was driving rough while driving at various speeds. The vehicle was taken to an independent mechanic where it was diagnosed, and it was determined that coolant was leaking into the engine. The vehicle was not repaired. The contact became aware of Ford Customer Service Satisfaction Program Number: 21N12 (Vehicles Equipped with a 1.5L GTDI Engine – Short Block Replacement After Coolant Intrusion) however, the VIN was not included in the program. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 130,000.

Coolant leak into engine

The contact owns a 2018 Ford Fusion. The contact stated that the check engine warning light was illuminated intermittently. The contact stated that she had replaced the spark plugs herself; however, the failure recurred. Additionally, the contact stated while driving 45 MPH the vehicle decelerated independently, and the vehicle failed to exceed 40 MPH while depressing the accelerator pedal. The contact also stated that while driving from a complete stop, the vehicle jerked and failed to exceed 5 MPH. The contact pulled to the side of the road. The vehicle was towed to the residence. Additionally, the contact stated that the vehicle was experiencing excessive coolant consumption, but there were no signs of a coolant leak. The coolant temperature warning light was illuminated. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to Ford TSB Number: 19-2375. The failure mileage was mileage was approximately 113,000.

Went to got a normal free oil change. They told us they could not do a tire rotation because the lug nuts were swollen. On a 2018 car the cheap 2 piece lug nut swollen so a normal 19mm socket could not fit over to took off the tire. No recall and no free fix at the Anderson SC Ford Dealer.

See attached document for complaint

The contact owns a 2018 Ford Fusion. The contact stated that while driving out of the driveway, the check engine warning light illuminated. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 85,000.

I have a 2018 Ford Fusion titanium 2.0. Upon start up thick white smoke was coming from the exhaust. Coolant level in resevoir dropping very low. Added coolant and five minutes of driving my check engine light comes on with code p0301 car ran sluggish and overheating light came on. I immediately pulled over and turned it off. Sure enough very low coolant in resevoir. No signs of leakage outside. I then took the car to a ford dealership for diagnosing. Sure enough I have coolant intrusion on number 1 cylinder. I reached out to FORD manufacturer and they will not assist with repairs/replacing the engine and all components that have been damaged due to the coolant intrustion. It will cost $9742.90 to replace all components and engine. My car only has 118013 miles on it. I am very disappointed with FORD knowing that they are aware of this coolant intrusion problem, yet do not want to fix their flaws. Enclosed is also a photo of the coolant intrusion on cylinder 1.

The contact owns a 2018 Ford Fusion. The contact stated while driving approximately 36 MPH, the vehicle failed to respond while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was driven to a local dealer to be diagnosed. The contact was informed that the engine needed to be repaired or replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 19,000.

My car started with the Ck engine light coming on, then white smoke from the exhaust randomly, then my temperature gauge randomly going up then back down, my car then losing coolant but not leaking any coolant under my car when parked. Then it started acting like it was gonna stall while at a stop or in park. I thought at first I got bad gas somewhere. These are all things I’ve never experienced since purchasing my car new in 2018. I took my car this week to the Ford dealership to get a diagnosis. They told me my car had some coolant intrusion that was a defect with my engine. They told me that Ford was replacing the engines but that my car didn’t qualify because it was over the 84,000 miles. I couldn’t believe it. So a vehicle I bought brand new( my first ever brand new vehicle) and I just paid off early in January of 2024 now needs a new engine. To say I was mad and disappointed would be an understatement. I only have my income as my husband passed away 9 years ago. I’m not old enough to collect his pension as I was only [XXX] when he passed. I also took in my 2 nieces 6 years ago when my sister passed away. I can’t believe Ford does not have to repair these vehicles. Why should mileage matter if it’s a defect on their part. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Torque converter ar60,000mi and needs whole transmission at 104000 mi

At 100,000 miles the vehicle has experienced coolant intrusion in the engine resulting in the engine being seized. I was told by the Ford service rep that this is a known issue on this vehicle, but there is no type of warranty offered.

Terrible car, after long thinking about it the last accident in this car I think was caused from the transmission literally as soon as I put it in reverse it acted as if I was accelerating and proceeded out of the parking spot a little bit, another scary thing I pulled out of a parking lot and almost got hit because the car acted as if it was in neutral when the car was in drive with on coming traffic!!!!!!!! One time it wouldn't allow me to go into drive it started rolling back wards. Transmission was replaced in 2020 and the car has been parked since late 2022 because of this issue while still peeing $6,000 on a damn car I can't even drive and seeing the same similar issue about this stupid car everywhere is ridiculous and I don't see how there's not a recall on this transmission or buy back issue or something how do you go buy a almost $30,000 car and every 60 thousand miles the transmission goes out if your able to even walk away from an accident to be able to even get the damn thing fixed

So first and foremost, this has been a issue before, first time I had this vehicle serviced because the car was shifting terrible I would be driving and the car would slip out of gear and act as if it's in neutral which does not allow the car to accelerate, which occured driving on the highway and everywhere!!!! Ford helped fix the first transmission and I had to assist on partial amount, Going 65 miles an hour and then have to merge and the car is in drive but did a jerk and it was just cruising and acted as if the car was in neutral and just reving the engine almost got me hit because a car was behind me!!! Like I said Ford assisted with the first one!!!! NOW IT HAS HAPPENED AGAIN!!! I OWE $6,000 ON A CAR I CANT EVEN DRIVE THAT JUST SITS IN MY DAMN DRIVEWAY! IVE ASKED FORD WHAT I SHOULD DO AND NO ONES REACH BACK OTHER THAN GETTING IT LOOKED AT AND NOT ASKING ABOUT ANY HELP AT ALL!!! This time because I've already dealt with this issue once I noticed it started to mess up again I pulled out of a parking lot to a main street, cars were coming but I was clear to go and had plenty of room!! WHY DID THE CAR DO THE SAME THING AND ACT AS IF IT WAS IN NEUTRAL AND THEN DIDNT ACCELERATE to where I had to hurry turn my hazards on and then after I did that the car jerked real hard and like threw me back and it went I tried to drive it a month or so ago to see if it still did it and the car wouldn't go in reverse wouldn't go in drive nothing!!!!!!!!!! SO A BRAND NEW CAR I BROUGHT NOW IS

Purchased my car on 1/16/21. In mid-2023, I was having issues with hearing water running in my dashboard. During this time no warning messages appeared. Soon after my car started shutting off without notice again with no warning messages. It would shut off while driving or when stopped. Then it also started running hot with warning messages. Due to this, I took my car to a repair shop and was told that turbo boost oil had leaked into my engine. I was told I needed a long-block engine replacement for $12,000. I have never been in an accident that would impact my engine. I kept up on the maintenance of my car. After research, I learned that this is a problem for Ford's turbo boost engine and that Ford was aware of the possible issue.

The contact owns a 2018 Ford Fusion. The contact stated while starting the vehicle and attempting to move the gear shifter, the gear shifter remained stuck in park (P). The contact stated that he disconnected the battery for 10-15 minutes, and the computer was reset. The contact stated that the vehicle then operated as needed. The contact stated that the failure recurred on another occasion, and the vehicle was towed to the dealer, where it was repaired; however, the failure recurred 30 minutes later after parking the vehicle. The vehicle was towed to the dealer, where the vehicle was diagnosed, and it was determined that the gear shift module (GSM) needed to be replaced. The GSM was replaced; however, the failure persisted. The dealer determined that the transmission gear shifter assembly needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 105,000.

Coolant is leaking into the engine, , Service Advisor (Lapalce Ford) said engine would need to be replaced, Said no warrantly would cost $10,000.00 to replace, Issues began in early 2023 with spark plug miss fire, Had a tune up done, but problem persisted, An engine warning light came on indicating that misfire in one of the coils, Had the spark plug and coil replaced during June of 2023, Problem persisted and warning light came on again, brought to ford to look and as was told that it was coolant leaking into the engine and that it would need to be replaced September of 2023.--I got a second opinion from Roy's Auto Tech in Marrero la and had them replace the engine with a new ford engine. $9720.59. Other than this issue this vehicle is was like new. --It has to be a mechanical defect with the design of the engine, and ford is aware as there have been multiple complaints of the exact same issue long before my problems arose.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated on the instrument panel. The vehicle was taken to an independent mechanic, who determined that coolant intrusion into the engine had damaged the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12, but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 164,000.