2018 Ford Fusion complaints

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the message “Low Engine Oil Pressure” was displayed. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion into the cylinders. The contact was informed that the engine block needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion); however, the vehicle was not covered. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 54,000.

Accident caused by brakes slipping and failing to stop even when pushed all the way down to the floor. Air bags failed to deploy. Resulting in a total loss estimate after accident.

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the engine overheated with the check engine warning light illuminated. The contact stated that the message that the engine was overheating was illuminated. The vehicle was restarted after the contact added coolant to the reservoir. The contact stated that after adding coolant to the reservoir, the failure recurred. The vehicle was taken to an independent mechanic, where it was diagnosed that coolant had leaked into the cylinders, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired, and the contact was referred to the dealer for further assistance. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was 155,000.

I was driving as normal I went to make a turn and out of nowhere my car would not turn and almost got smashed on the side of the car would not have swerved out of the way. There was no warning signs lights symptoms or anything one minute it was normal the next was what could have been a deadly situation. After getting a mechanic to diagnose it after removing the steering wheel, because initially was thought the steering column went out or broke, it was found out to be the middle of the steering wheel where it connects to the column that is suppose to be the shape of an Alan wrench was almost completely worn down to almost a flat circle. I cannot stress enough how scary and deadly this could have been to me and other motorist. This was verified by mechanics this is not normal wear and tear this has to be a defect.

Unknown. Car will not start.

Unknown. Car will not start, dashboard says overheating, white smoke was coming out of muffler but stopped and etc.

What component or system failed or malfunctioned, and is it available for inspection upon request? The engine experienced coolant intrusion, which is a known defect in certain Ford EcoBoost engines. My independent mechanic diagnosed the issue after I noticed significant engine performance problems. The affected components, including the engine block and cooling system, are available for inspection upon request. How was your safety or the safety of others put at risk? Coolant intrusion can lead to engine overheating, misfires, and in severe cases, engine fires. This significantly increased the risk to my safety and that of others on the road. Had I not addressed the issue promptly, a fire could have occurred while driving. Has the problem been reproduced or confirmed by a dealer or independent service center? The problem was confirmed by an independent, certified mechanic—not by a Ford dealership. The dealer failed to properly diagnose or even acknowledge the problem, which appears to be common based on other consumer complaints. Ford did not identify what was truly going on with the vehicle, despite clear symptoms. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Ford has not inspected the vehicle. The manufacturer was notified, but they declined to take responsibility or offer a solution. There was no inspection by police or insurance representatives, as the issue was caught before a fire or accident occurred. Were

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power. The check coolant and engine warning lights were illuminated. The vehicle was inspected by a local independent mechanic who diagnosed a misfire coming from the engine. The vehicle was not repaired. The vehicle was later towed to a local dealer, where it was diagnosed with a coolant intrusion in cylinders #1 and #2. The vehicle was not repaired. Upon further investigation, the contact related the failure to Customer Satisfaction Program: 21N12, 22-2134, and 19b37; however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 98,207.

The engine is losing coolant on a daily basis; I keep gallons of it my car to keep it from running out. The safety risk is the vehicle hoses burst while driving in rush hour traffic and causing a worse delay and maybe injury to myself and passengers. I had the vehicle checked by an independent service station and they recommend a head gasket replacement or engine replacement, and the dealer just brushed me off with the head gasket may need replacing but it is not a recall item. It has not been inspected by any other agency. The check engine light is an on and off again problem -- and that's when the coolant is low the light comes on and when I refill it, it goes off. The vehicle coolant system is losing coolant every two days -- as of this date 4/28/2025, smoke comes from the oil filler cap area but none from the tailpipe. This is a frustrating situation and lawsuit waiting to happen situation that could easily be avoided -- They know it's a problem and want the consumer to reveal this frustrating and potential mega colossal problem to grow out of control.

The check engine light came on and something about the cooling system. I can’t totally remember. The Service desk confirmed the eco boost engine has known issues of the cooling system which may cause the engine to go bad. Reported I needed a new engine and transmission. Then after they had started that job and after I put $1,500 down they called me back and said the radiator has issues from it all and needed changed as well. I asked him if all fords only lasted approximately a 100,000 miles or just this one and he responded that it is a known issue by ford and happens with this engine. It cost me approximately $15,000 out of pocket to get the car fixed. Within a week there were more “issues” with the engine and I am now being charged over $300.00 to fix this part that they didn’t change even though they put in a new engine.

Driver was driving at 55 miles per hour engine light illuminated. Car began to sputter and not drive. Ford Dealership mechanic,” DRIVEABILITY CONCERN, CUSTOMER STATES VEHICLE WILL NOT GO OVER 40 MPH AND HAS A MISFIRE PLEASE CHECK AND ADVISE. verfied engine is misfiring, hooked up scan tool and ran dets and found p0302 and p0316, #2 cylinder misfire and misfire and the first 1000 rev, ran a relitive compression test and found cylinder #2 is 25% diference than the other cylinders. pulled spark plug and put a boar scope in the cylinder and found a exhaust valve is missing a piece of the valve and the engine has ate the valve. recommend a ford long block” Owner was quoted $8553.37 for a used engine. Happened at 95,405 car is not drivable and unfixed. When owner asked what was the main cause the answers was “these cars just have bad engines”

The contact owns a 2018 Ford Fusion. The contact stated while driving at 35 MPH, the check engine light illuminated. The contact stated that the failure was related to Customer Satisfaction Program: 21N12. The vehicle was taken to an independent mechanic who determined that there was a coolant intrusion into the engine and the long block needed to be replaced.The local dealer was contacted, who confirmed that there was no recall on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 95,308.

We have a 2018 Ford Fusion EcoBoost. The engine started to run hot, we made an appointment to bring to dealer. Morning of the appointment car would not start. We had it towed to dealer. After several hours at the dealership they called to tell us the engine needed to be replaced, quote was $14,000. The issue they explained was coolant in the engine that corroded the engine and all parts. Not salveable, needed to be replaced. We have excellent service records on our car, always keep up with routine maintenance and have owned at least 10 Fords various makes and models. Never had an issue.

Engine throws misfire code on cylinder accompanied by loss of coolant with no visible leaks. Coolant intrusion into the cylinder has begun due to Ford’s engine block design flaw.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the engine overheated with the check engine warning light illuminated. The vehicle was able to restart. The vehicle was taken to an independent mechanic where it was diagnosed and determined that there was coolant intrusion into the engine, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not diagnosed or repaired. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.

While maneuvering in parking lot car would not shift from Reverse to Drive after backing out of parking place, error on dash stated shift module failure. Tow truck driver manually engaged shifter to drive, too car to Freeman Ford. Upon inspection shifter grommet at transmission had worn not allowing car to change gears, $4 in parts, $300 in labor to fix. Fortunately the car was just blocking a post office parking lot, if this had been a maneuver in an intersection it could have caused an accident. There was no indication this failure was going to occur.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at various speeds, a warning light indicating that the engine was overheating was illuminated. The contact added coolant to the vehicle; however, the failure persisted. The contact stated that the vehicle was experiencing an excessive coolant consumption. The vehicle was taken to Advance Auto, where it was diagnosed with a misfire in cylinder #3. The vehicle was taken to the dealer and was diagnosed with coolant intrusion in cylinder #3. The dealer determined that the short block needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 91,000.

The contact owns a 2018 Ford Fusion. The contact stated that after his girlfriend was occupied and parked in the residence, while attempting to reverse the vehicle the gear shifted independently into park. The contact mention he lifted the front end of the vehicle, and he noticed the shifter cable detached from the transmission shifting arm. The contact was able to attach the shifter cable on the transmission shifting arm but also noticed the shifter cable bushing has detached from the transmission as well. The vehicle was not taken to be diagnosed. The vehicle was not repaired however the contact mention the vehicle will be getting repaired on March 29th. The contact related the failure to the NHTSA Campaign Number: 22V413000(POWER TRAIN). The insurance company had not been contacted yet. The manufacturer was made aware of the failure they informed the contact that NHTSA calls the manufacture to have recalls on their VIN. The contact was referred to NHTSA to file a complaint on the failure. The failure mileage was 102.000.

Car will crank, but will not move into gear. Getting an service message "Shift System Fault". Some days it will move and other days (like today) it will not. I believe the 2018 fusion (my car) was missed from the list of recalls for this service message. I contacted a Ford dealer near me. Either they don't have a transmission tech or it will take days before my car can be looked at.

My car had a bad shifting linkage which I paid for out of pocket. My 2.0 Ecoboost engine is leaking coolant into my oil and makes a very loud concerning ticking noise, along with reduced engine power and sporadic/random loss of brakes. There has been recalls for these issues on most other Ford Fusion models and this one NEEDS TO BE RECALLED. My engine is going to blow any day now and I will be stuck paying for the rest of my car loan for a vehicle I cannot drive. All of the Ecoboost engines should be recalled for poor design.

The contact owned a 2018 Ford Fusion. The contact stated that while driving at 65 MPH, the front driver side seat belt did not buckle appropriately, another vehicle driving at an unknown speed moved to the left lane, then the other vehicle changed lanes again moving in front of the contact, and the other vehicle abruptly depressed on the brakes causing the contact to rear end him. The vehicle came to a stop and merged into the shoulder. The vehicle was damaged on the front driver's and passenger's side. There were no warning lights illuminated. The driver’s and passenger’s side air bags did deploy however the seat belt did not retract the contact, causing the contact to be injured. There was no property damage. A police report was filed. The contact sustained a concussion and his eyes swelled shut. It was unknown if the other driver in the other vehicle sustained any injuries. The insurance company towed the vehicle to an impound lot and then towed it to Copart. The vehicle was deemed a total loss by the insurance company. The manufacturer was not notified of the failure. The dealer was not made aware of the failure. The failure mileage was 89,000.

While driving about 60 miles per hour the vehicle started to buck and loose speed. The check engine light came on and I pulled over. The vehicle was taken to the dealership where I was told that I have a coolant leak. The leak caused a break in cylinder 2 and the engine would have to be replaced.

Was driving and car started overheating. Looking at coolant levels, they were low. Refilled coolant and car started fine. Next day driving the vehicle, the engine shut down completely. Took the vehicle to Parks Ford dealership in Hendersonville NC to find the problem. I received a call from a service representative and he said there is a coolant intrusion into the cylinder or cylinders and the engine needs to be replaced. I asked to check for recalls and he stated none were found. I did my own research and found many vehicles with the 1.5 liter Ecoboost engine have had this issue and have had a recall in the past. I. Short, Ford has said they will not have my vehicle fixed due to the fact the 3 year warranty has expired and or 85,000 miles have been passed. I have financed this vehicle starting [XXX]. As of now my vehicle has almost 110,000 miles. Doing more research into this Ford has offered a fix for this. A new midi small block replacement and head gasket replacement. Doing more research into this, I have found the vehicle engine could possibly catch on fire if the coolant intrusion is not corrected. The Ford dealership quoted me $9,000 without tax to replace the engine. This just isn't doable. How can this not be a safety issue if the vehicle can and will shut off while driving and potentially catch on fire? Ford should replace the flawed engine design that they have been very well aware of. I am still making payments on this vehicle to own and I cannot risk driving it b

The contact owns a 2018 Ford Fusion. The contact stated that while starting the vehicle, the check engine warning light illuminated, and the "WRENCH" symbol was displayed. The contact was unable to shift the transmission into drive(D). The contact had to wait for approximately 15 to 20 minutes before attempting to restart the vehicle before shifting into drive(D). The contact stated that the failure recurred, and the vehicle was towed to the dealer. The dealer was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 95,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, there was white smoke coming from the exhaust pipe. The check engine warning light was illuminated. The vehicle was taken back to the residence. A dealer was contacted and informed the contact that the failure was a known issue and that the engine needed to be replaced; however, there was no recall on the VIN for the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 120,000.

At 135,815 miles, my 2018 Ford Fusion SE experienced a sudden transmission failure while driving, with no prior warning signs. The vehicle was towed to Certified Transmission, where technicians confirmed: Transmission fluid level was correct but black/degraded. Multiple failure codes were present. Transmission pump whined and stopped functioning. Diagnosis: Internal transmission failure (6/17/2024). The shop stated this issue is common in these transmissions. The entire transmission had to be replaced. At 141,164 miles, just 5,349 miles later, the engine shut off on the highway while driving, again with no warning lights. After pulling onto the shoulder, it restarted after 10 minutes but was smoking heavily. Coolant was critically low in the reserve tank. Diagnosis: Cracked cylinder head due to coolant intrusion, a known defect in 1.5L EcoBoost engines. I contacted Ford Customer Care about CSP 21N12, but they refused assistance since my vehicle exceeds 84,000 miles, despite this well-documented defect. Safety Concerns: Unexpected transmission & engine failure while driving creates a serious risk. Engine shutoff on the highway could have led to an accident. Coolant intrusion in 1.5L EcoBoost engines is a known issue, yet Ford has failed to notify all owners. This issue affects many owners and creates major safety risks. I urge the NHTSA to investigate and consider a mandatory recall to prevent further incidents.

No power stearing, Steering Gearbox malfunction. Power steering going out while driving is a major safety issue. Yes dealership confirmed issue and ordered parts for repair Ford dealership inspected issue and said that it needed repaired. Power steering went out while driving almost causing an accident. No warning, lights came on when the power steering went out saying that there was a power steering fault.

Transmission cable shifter bushing was defective and popped off of transmission shifter. This subsequently caused the transmission control module to overwork and fail.

On 4 occasions, the car has shut off while moving and in traffic. A dashboard message appears, saying "full accessory mode". After coming to a stop, the car will immediately restart. My obd reader shows no error codes. The car has 18,000 miles on it and this problem occurs randomly. It happened first when the car was a few weeks old. I took it to dealer and they found no problem. Ot has happened 3 times since then. This problem has been reported at least 15 times on the ford fusion sport forum.

The contact owns a 2018 Ford Fusion. The contact stated while driving 15 MPH, the check engine warning light illuminated, and the vehicle started hesitating. The contact attempted to restart the vehicle and the vehicle failed to respond as needed. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion in cylinder #2, and the engine needed to be replaced. The dealer was contacted. The vehicle was not repaired. The contact related the failure to TSB: 20-2100 (Coolant in Cylinders, White Exhaust Smoke, And/or Illuminated MIL); however, the VIN was not included in the service bulletin. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the TSB. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 150,000.

The contact owns a 2018 Ford Fusion. the contact stated that there was excessive movement in the steering when the steering column was making a clicking sound while turning to the left. The contact stated that while turning to the left, the steering wheel was seized, and the contact had to use excessive force to turn the steering wheel to the left. While pulling out of a parking space, the advance track mode and power steering loss messages were displayed on the instrument panel. The vehicle was taken to a certified mechanic who diagnosed that the steering had failed and replaced the lower control arm, tie rod, and rack and pinion on the driver's side of the vehicle; however, the failure persisted. The dealer was contacted and confirmed that the VIN was not under recall. The manufacturer was made aware of the failure and confirmed that the VIN was not under recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 111,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving at 35 MPH, the temperature gauge began to indicate that the vehicle was overheating, prompting the contact to discontinue driving the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that coolant intrusion into various cylinders had resulted in damage to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 103,500.

The contact owns a 2018 Ford Fusion. The contact stated that the engine was misfiring with white smoke coming from the exhaust pipe. The size of white smoke coming from the exhaust pipe had increased over time. The “WRENCH” warning light remained illuminated. The check engine warning light was illuminated intermittently. The vehicle was hesitating while attempting to start. The vehicle was taken to a certified mechanic who diagnosed that the engine block had coolant intrusion in two cylinders and was causing the misfire. The contact replaced the coils and spark plugs; however, the failure persisted. The contact became aware of NHTSA ID Number: 10213732 (Engine and Engine Cooling) which was linked to the failure. The dealer was contacted and confirmed that the vehicle was not included due to the mileage. The manufacturer was made aware of the failure and confirmed that the vehicle was not covered under the NHTSA ID Number. The manufacturer referred the contact to the NHTSA Hotline to file a safety complaint. The failure mileage was 119,000.

The contact owns a 2018 Ford Fusion. The contact stated that while at a stoplight, the vehicle hesitated and jerked. The contact depressed the accelerator pedal, but the vehicle hesitated and lost motive power. The service vehicle message was displayed. There was a highlighted rectangle displayed. The vehicle was taken to the local dealer, where it was diagnosed and DTC: P0218/P177S was retrieved, and it was determined that the transmission needed to be replaced. The vehicle was not repaired. The vehicle was taken to another local dealer, Academy Ford Sales (13401 Baltimore Ave, Laurel, MD 20707); where it was diagnosed that the transmission, intermittent clutch, and shaft needed to be replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic who determined that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 70,000.

The contact owns a 2018 Ford Fusion. The contact stated that while starting the vehicle, the vehicle shuddered with white smoke coming from the exhaust pipe. The check engine warning light was illuminated. The failure had occurred on several occasions. The vehicle was taken to an independent mechanic where it was diagnosed with coolant leak into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and filed a complaint. The vehicle remained at residence unrepaired. The approximate failure mileage was 140,000.

Engine overheated multiple times during high speed/high traffic situations due to a design flaw within the engine. Ford was aware of these issues in this engine for years and still knowingly sold them to American consumers, myself included. This is wrong and erodes the trust myself and others have in the American auto industry.

The contact's son owns a 2018 Ford Fusion. The contact's son stated while driving at an undisclosed speed, the vehicle shuddered and white smoke emitted from the exhaust pipe. The check engine warning light was illuminated. The failure occurred on several different occasions and the coolant level was abnormally low. The vehicle was not taken to a dealer. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 90,000.

The contact owns a 2018 Ford Fusion. The contact stated that while driving 30 MPH, the vehicle hesitated, and the transmission failed to shift into third gear. The contact stated there was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 74,433.

The car was taken to the repair shop due to reduced speed and shaking. The repair shop mentioned that a bulletin for the car indicated that coolant could leak into the engine. They reported that the coolant had indeed leaked onto the engine, causing the gasket to blow. The dealer was contacted and was informed that it was an extended warranty of up to 84000/ 7 years. so I was referred to NHTSA Case S3H0j5

Shift system fault

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, there was a knocking sound coming from the engine. There was no warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to the dealer and was diagnosed with coolant intrusion into the cylinder, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 115,000.

During traffic on the highway, my car had a slight rumble to it but no warning lights were on and there were no weird sounds or smells coming from my car. After I cleared the traffic, the rumbling dissipated but as I accelerated my check engine light turned on and began flashing. I immediately exited and pulled over. After popping my hood, it smelled of burnt oil and the entire engine bay looked like it had been misted with oil. Auto shop scanned the engine light and said I had a cylinder 2 misfire. Another auto shop had said my engine was out of commission and I’d need a new one.

EVAP system leak. Vapor leak causes car to not start after putting gas in the tank. It takes several tries before the car starts up. Engine light stays on which causes car fob not to auto start.

While waiting at a red traffic light in drive and on a slight incline, engine shut off by itself and car started rolling backward with my foot on the brake pedal. The pedal felt harder than normal to push but didn't stop the car. A car stopped behind me was put at risk of impact with the rear of my vehicle. I could see I was getting closer and closer to hitting the other car. As this was happening, i pushed the start button and managed to restart the engine and put it in drive to pull away just before impact. Problem hasn't been reproduced by anyone. Vehicle or components haven't been inspected by anyone. No warning light lamps or other symptoms of the problem prior or during remaining drive home. I don't know if this is related but the car does have a random no start symptom due to a battery discharge condition while parked overnight. This happens very rarely and is not reproducible when the battery is charged. Ford has a TSB ref.17-2192 on this failure that is applicable to my VIN but they will not cover it since my car is out of warranty (Time and 73K miles). The dealer further stated that there is no guarantee that this re-programming of the PCM will fix the problem. The Ford dealer gave me an estimate of $214 for the re-programming of the PCM and it does not include a new battery if it needs it. I have an appointment to get it done on 11/22/24 but I'm reluctant to pay for something that may not fix the parasitic PCM draw on the battery. Any advice would be appreciated. T

Transmission issues, I had my transmission replaced right out of warranty so Ford assisted 4 grand to assist the repair because the dealership took a mmtj to get my car in, i didn't know it was going to go over the trade in program replacements in miles. The car shifts weird, in drive the vehicle acts as if it was put in neutral randomly and it jerks you hard into gear throwing you and passengers into the back of the seat a,pay got hit two times it also when you start the car, put it in drive it throws it's self back into park then you put it back into drive or reverse and it grooms and goes as if I'm accelerating which i got hit once backing out of a sppt because of this i hagea friend who has the same issues why is theee not a recall on their ford fusions or them getting sued????

The contact owns a 2018 Ford Fusion. The contact stated while driving 40 MPH, the vehicle started shuddering significantly and the engine overheated. The check engine warning light was illuminated. The contact continued driving at 20 MPH. The vehicle was driven to the residence. The vehicle was then taken to the dealer, where it was diagnosed and determined that there was a coolant intrusion in the engine. The dealer determined that the engine needed to be replaced and related the failure to Ford Campaign Number: 21N12 and TSB Number: 22-2134. The vehicle was not repaired. The manufacturer was notified of the failure but denied assistance in covering the cost of the repair. The failure mileage was approximately 110,000.

On [XXX], My car began attempting to overheat. This caused me to stop, and park the car until it cooled down, multiple times. (Unsafe) All of my fluids have been filled and checked occasionally prior to this. After multiple roadside trips, I presented my car to AutoNation FORD which is located on Philips Highway in Jacksonville, Florida. An inspection was performed on my vehicle over the weekend which proved my car in fact has a coolant intrusion which is the Latest Recall for the Ford Model. The dealership informed me that my car does not qualify under the recall due to the mileage of the vehicle which is currently 130k. This seems so unfair because I did not do anything wrong that led to this. I am unable to drive my car a mile or 2 without it trying to overheat. This is a risk and I do not feel safe operating this vehicle. It was also very displeasing hearing that operating the unsafe vehicle is my only other alternative besides coming out of pocket with 14k. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle experienced rough idling. The check engine warning light was illuminated. The vehicle was taken to the dealer, where the spark plugs were replaced, but the failure persisted. The vehicle was taken back to the dealer, and the contact was informed that the fuel injector in cylinder #3 needed to be replaced. The vehicle was then taken to Terrebonne Ford (339 St Charles St, Houma, LA 70360), where it was determined that there was coolant intrusion into the cylinder block and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 80,000.

The contact owns a 2018 Ford Fusion. While the contact's daughter was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the check engine warning light and several other unknown warning lights were illuminated. The vehicle was taken to several independent mechanics; however, the vehicle was not diagnosed. The vehicle was not repaired. The vehicle was towed to the dealer where it was diagnosed with a coolant leak in the engine and engine failure. The contact was informed that the engine and the cylinders needed to be replaced. The vehicle was repaired. The contact was informed of an Extended Warranty Program; however, the contact was informed that the mileage had been exceeded by 9,000 miles. The contact was informed that the repair was not covered under the extended warranty. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 93,451.

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle was driving rough. In addition, the contact noticed that the engine was consuming an excessive amount of coolant. The failure progressed, and the engine started overheating. The vehicle was towed to the dealer where it was diagnosed with a cracked engine and coolant intrusion. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and provided no assistance. The contact referenced Technical Service Bulletin: 22-2134; however, the contact was informed that the repair was not covered under the program. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 27,800.