2013 Ford Fusion complaints

Lug nuts are swollen and required excessive time and labor at the Ford dealer to remove them and replace them. If I required road tire repair I would not be able to remove a tire. I was at dealer for oil change and tire rotation. Total time at dealer was 4 hours.

The contact owns a 2013 Ford Fusion. The contact stated while driving approximately 35 MPH, the vehicle produced a high pitch sound coming from the transmission. The contact was able to pull over. Upon restarting the vehicle, the vehicle would not shift out of park. The contact stated no warning light was illuminated. The contact called a mechanic to the vehicle and the vehicle was diagnosed with needing the shifter cable replaced. The vehicle was not repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 18V471000 (Power Train) however, the VIN was not included. The vehicle was taken to a local dealer where it was diagnosed with needing the shifter cable replaced; however, the vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to NHTSA. The failure mileage was approximately 191,000.

My coolant has been disappearing at an exceptional rate in my 2013 Ford Fusion with a 1.6L Ecoboost engine. About once every week or so my "Coolant Level Running Low" message comes on and I have to add more coolant. This went on for several months, no dangerous problem, just buying coolant regularly and wondering where it's all going. No sign of coolant under my car. I was driving to work when the warning message "Engine Coolant Overtemperature" came on and my car stalled. Thankfully I was able to pull over safely. The coolant was low again and the engine overheated. I read other people with the same year, make, model, and engine also had the same issue - coolant vanishing causing the car to overheat and stall, some resulting in fire. I believe this is due to the coolant leaking into the hot exhaust system as safety recall 12S41 describes. Because my car was manufactured in 2013 and not 2012, my VIN is not listed to be recalled despite the same issue on my same make, model, and engine. The Ford dealership would not fix it as a recall. I'm grateful mine didn't result in a fire this time unlike some other unlucky folks in my same position.

The steering locked up 2 times. Had I been driving when this happened it could have caused a serious accident. The problem has not been inspected by anyone at this time. I received a Steering Assist Malfunction message both times when starting my vehicle. After shutting the car off and waiting a little while and then starting the car back up the message is no longer there and the steering seems to be fine. But again if this happens when Im driving it, it could result in a serious accident.

The contact owns a 2013 Ford Fusion. The contact stated while driving approximately 25 MPH, the steering wheel became difficult to turn. The contact stated that the “Power Steering Disabled” message was displayed. The vehicle was taken to a local mechanic where it was diagnosed with needing the power steering control module replaced however, the vehicle was not repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 15V250000 (Steering) however, the VIN was not included. The manufacturer was informed of the failure and confirmed that the VIN was not included. The failure mileage was approximately 120,000.

Just before the December holiday, my car was making a notable noise. My local mechanic has diagnosed it to be a transmission failure at 99k miles. The local Ford dealership still has not looked at it and can't for weeks to come because of Covid (1/3 of the mechanics plus the Service Manager and assistant are out). They told us that the tool needed to repair this problem will not be available until April because it needs to be manufactured and distributed. I am left without a car, thrown into the market 2 years ahead of my financial plan, without assets from my car and having difficulty getting a loan because of the hyperinflation of car prices, particularly used. I am quite stranded.

The contact owns a 2013 Ford Fusion. The contact stated that while driving at 10-15 MPH uphill and making a turn, the vehicle made an abnormal sound and was hesitating as if the transmission was in neutral. There were no warning lights illuminated. The contact stated that as the vehicle started rolling backward, she depressed the accelerator pedal and was able to move forward and made the turn. The contact continued to drive; however, the failure reoccurred while driving and the vehicle was making abnormal sounds. The vehicle was taken to an independent mechanic who test drove the vehicle and diagnosed that the transmission had shifted into fifth gear and would not shift out of fifth gear. The independent mechanic diagnosed that the transmission had failed and needed to be replaced. The vehicle was towed to the residence. Then, the vehicle was towed to another mechanic who diagnosed that the transmission had failed and needed to be replaced. The manufacturer was notified of the failure and informed the contact that the VIN was included in NHTSA Campaign Number: 19V362000 (Power Train) and to take the vehicle to the dealer for a recall repair. The vehicle was towed to the dealer who informed her that the vehicle would be repaired at her expense since the VIN was not included in the recall. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was unknown.

2.when it came on this time it said “Power steering assist fault” see manual then shut completely off on me. I cranked it back up and it ran for about 30 seconds and shut off again. I cranked it up again and the wrench illuminated and stayed on so I drove it home and parked it Sunday. Now I am bringing it in to you all. It seems to be some serious power/electric issues going on with this car.

Recall issued by Ford 15S14 stating "If the bolts corrode, the steering gear motor may detach from the gear housing resulting in a loss of power steering assist. Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash." This recall was performed July 8th 2015 at Twin Hills Ford dealership at approximately 30k miles. This exact same problem has happened again at approximately 60k miles and though talking with Ford they will not admit fault to a poorly designed steering motor with an identically poorly designed safety recall solution. This is a safety issue that I feel I should not have to pay upwards of 2500 to repair. Especially after the "solution to the safety hazard" has been performed. This issue puts others in danger and was not adequately resolved.

The contact owns a 2013 Ford Fusion. The contact stated while driving at an undisclosed speed with his son inside the vehicle, he smelled an abnormal fuel odor. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the fuel delivery module was cracked and needed to be replaced. The contact was notified of NHTSA Campaign Number: 13V227000 (Fuel System, Gasoline) however, the VIN was not included. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 87,000.

When I pull out the gearbox it makes a medium loud noise in the transmission, I try to call because I received notifications, number and description of the 19S16 campaign but it turns out that the automated call does not recognize the numbering

The mechanism and cable to unlatch the hood corroded to the point that the hood to the car was unable to be opened. This could be a hazard in the event oil needed or antifreeze needed to be added to prevent engine damage. Or if the hood were to somehow become ajar, it could potentially cause the hood to open up while driving, creating a visual obstruction and increasing the risk for a motor vehicle crash.

My 2013 Ford Fusion SE had the high pressure fuel pump start leaking and dripped fuel on the exhaust and started the car on fire while driving down the road. This caused about $7,000.00 in damage but could have easily gotten out of control and caused injury or death to occupant(s). I reached out to Ford Motor Company and did a chat log asking for assistance and to make them aware. Ford Motor Company Case number CAS-34734107-H6J0Z5. What is dangerous about this design is that Ford chose to design and install a secondary high pressure fuel pump directly above the exhaust manifold and the engineers surely would have known the durability and longevity along with possible outcomes due to normal use over time. For the same reason you are not to refuel a hot engine, a fuel pump should not be placed directly over the exhaust manifold. I believe Ford Motor Company should be held accountable for their finished product liability. This is dangerous enough that they should remove these vehicles from service until a safe solution is available and deployed in my opinion.

Engine shut off while driving, and a "transmission not in park" message was displayed. Car was able to restart after several tries. Looking online I found a lot of people with the same issue, but no answered questions.

The shift cable bushing in my 2013 Ford Fusion Hybrid degraded and broke apart from the gear shift cable. This resulted in me being unable to shift gears while the vehicle was in park. Fortunately the car was parked at the time but this could have been a serious safety concern had the vehicle been moving. The vehicle was repaired by a Ford dealership by replacing the entire gear shift cable. This repair was considerably more expensive than just replacing the bushing itself which they claimed was not possible. No warning lights or messages were indicated before the failure. This part failure is the exact same issue involved in NHTSA CAMPAIGN NUMBER: 18V471000.

Went to turn the car on and the message "power steering assist fault" kept blinking on the dashboard. Luckily wasn't driving or this could have turned into an accident. Sat in the car for a couple minutes and turned the car off and on. Message didn't appear again, but I'm nervous to drive longer distances than the 6 mile trip from my place of work to my house. I've read that there is a recall on other fusions in the same year as mine. However, I don't know if the VIN is included. I think they need to 1.) send out a notice to all fusions of that year for a recall and 2.) include other VINs in this recall. I now am nervous about driving this car and I plan on having this looked at by a Ford Dealership promptly. Please get this addressed.

Drove my car to work just fine and my wife got in it to go home and power steering assist fault light came on looked it up and found out that are vin is not recalled looked up how to fix it and there was at least 200 people that has the same issues that’s a lot more then the 23 recalls for that car

The transmission keeps jerking and when waiting for a light to change car jerks. Also makes a noise that sounds like water boiling but it is something with the Moter.

While driving, the vehicle flashed the "Service Power Steering" warning. After arriving at my next destination and restarting the vehicle, the alert changed to "Service Power Steering Now", and the power steering became completely unresponsive. According to the dealership, the power steering assist has failed and the entire rack and pinion assembly will need to be replaced, a roughly $2000 repair. After doing some research, this issue has resulted in recalls on other Fords, including Fusions, within the same year model, but not my specific VIN. And judging from the other feedback on NHTSA I'm not alone. It's quite apparent the recall needs to be expanded to include this model.

Car was parked in the driveway and when started after 4 days, a message came "Active Power Steering Assist Fault". Steering became too hard to operate. This could have happened while driving and would have resulted in a collision. There are recalls for the same issue for 2013 Fusions but not my VIN. I think this recall should be expanded to include more VINs as I am reading similar complaints. Vehicle only has 72000 miles on it.

Our transmission thinks the car is always in drive. It won’t start, and shifts very roughly. There was a recall for this, but not sure why our specific vehicle wasn’t included.

On 10/31/21 at approximately 7:30 pm my dashboard alerted me with a steering assist fault after making a turn on a rotary on Mystic valley Pkwy Somerville Ma 02144. After entering the rotary my vehicles steering wheel become stiff and hard to move and staring moving towards the left side close to the curbs. I was traveling at around 20mph. I was able to move the vehicle to a near by park that was located on the same street as the rotary (Dilboy stadium). After parking the vehicle, I shut it off and restarted it. After doing so, the alert disappeared and I was able to drive the vehicle normally. After leaving the park 5 minutes later the alert popped back again. I was driving in a straight line so the steering assist did not cause much of a problem, however I could feel the stiffness of the steering wheel. When I arrived to my destination, after performing a left turn my vehicle once again starting leaning towards the left side almost causing me to hit the curb. At around 9:00pm I had towed the vehicle to a Fords dealership. On Monday the 1st I was able to drive the vehicle with same steering wheel conditions to an independent dealership who performed a check and received a fault code of C200D:49 with the solution of replacing power steering rack with module which could only fixed at a Ford dealership due to the module. In the situation described above I was very fortunate that I was not driving at high speed in an area with high traffic, as an accident would’ve most likely oc

November 1, 2021 I noticed that all of a sudden the warning light for power steering came on. I managed to get the car to the house and now the steering is locked. I have no remedy. I have been nervous about the car every since. I need my car repaired. The warning should come before all out failure! That’s not a warning it’s an ambush!!

The contact's daughter owns a 2013 Ford Fusion. The contact stated while driving at various speeds, excessive force was needed to steer the vehicle. There was no warning light illuminated. Neither the dealer nor the manufacturer was notified of the failure. Upon investigation, the contact discovered NHTSA Campaign Number: 19V632000 (Steering) which he linked to the failure. The vehicle was not repaired. The failure mileage was unknown.

2013 Ford Fusion with 54K miles. The vehicle overheated and the coolant light indicated to add fluid. Fluid was added however, the coolant light keeps coming on to add more fluid. Coolant has been added about every 2 weeks but the level is just below the max fill line each time with plenty of fluid in the unit. The car was taken to Ken Grody Ford (KGF)in Buena Park, CA and the radiator was flushed, and inspection revealed there were no leaks or damages. Within a week the coolant light came back on and was returned to KGF for reinspection. At this time a pressure test was done and we were told the temp sensor and bypass hose needs repair. A Ford Mechanic, not at KF advised this may be related to 2 recalls on the car 17S09, which was supposed to have been addressed in 2019, and/or 12S41 which is an old recall we were never advised of and the repair was not done. Per KGF, 12S41 was never entered in their system for recall, however this was confirmed on NHTSA. Ford Customer Service said they will not repair if it is not in their system and will not review NHTSA to confirm our VIN was impacted. Most complaints on NHTSA regarding cooling have the same symptoms as our car. Both recalls are a safety hazard causing the engine to catch fire and endanger driver/passengers. I have no way of confirming the work was performed as we were previously advised and yet Ford will not take responsibility to ensure the current issue is not related to the recalls and perform the necessary repairs. I

Power steering failure in parking lot. Steering did not return to center like normal after turning, shortly after while pulling into parking spot the power steering failed. Power steering reset tried and failed. Computer reset tried and failed, vehicle has no power steering or lane keeping capabilities.

The contact owns a 2013 Ford Fusion. The contact stated while driving at 30 MPH, the contact noticed a warning light illuminated on the vehicle stating engine overheating. The contact pulled the vehicle to the side of the road, where the contact noticed black smoke coming from the engine. The contact then drove the vehicle across the road into a mechanic shop where the mechanic who used a fire extinguisher to extinguish the smoke fire from the engine. The contact had the vehicle towed to a local dealer who diagnosed the failure as the engine was damaged and needed to be replaced The dealer replaced the engine, however, the contact was still experiencing issues with the coolant system on the vehicle. Sometime after the contact received a recall notification NHTSA campaign number: 17V209000 (engine and engine cooling) which the recall stated they would place a coolant sensor on the vehicle however the local dealer did not add the sensor on the vehicle they only replaced the coolant control valve. However, after the repair, the vehicle still experienced failures. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 107,000.

The contact owns a 2013 Ford Fusion. The contact stated while his girlfriend was driving at an undisclosed speed, the power steering assist warning light illuminated, and the vehicle lost power steering functionality. The contact stated that assistance was needed for the driver to steer the vehicle into a parking space. The driver restarted the vehicle however, the vehicle did not regain power steering functionality. The vehicle remained in the parking space. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 94,000.

The contact owns a 2013 Ford Fusion. The contact stated while driving 75 MPH in the rain, the vehicle inadvertently lost power steering functionality. The power steering assist warning light illuminated and the message to "Pull Over" appeared on the instrument panel. The contact stated she veered to the side of the road and turned off the vehicle. The contact restarted the vehicle, but the power steering warning light remained illuminated. The contact stated she was able to continue to drive the vehicle at a lower speed and manually steer the vehicle. The manufacturer was notified of the failure and informed the contact that the vehicle could not be repaired under NHTSA Campaign Number: 15V250000 (Steering) because the VIN was not included in the recall. The dealer was notified of the failure and advised the contact that she would be responsible for the cost of diagnosis and repair of the vehicle. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 107,000.

When my fuel tank is filled the vehicle won't start and while driving the vehicle will stall out. The code on the check engine light comes back as P1450. This is telling me the canister purge valve needs replaced. After researching online I see this is a common problem for the 2013 Ford Fusion.

No warning light. Rpm’s surge high, low then engine shuts off while driving or idle. I could be in the middle of an intersection and my engine will shut itself off. Major safety issue and this car needs to be recalled. Happens even after taking it to the dealer “fixing” the “problem.” I’m not sure they even know the issue. They just try replacing things for a short term fix yet still having issues long term.

The car would stop after the warning of over heating so the car would just shut down go into what is called limp mode was told that is to protect the engine so we was told that in order for them to check we first had to purchase ford parts to get it started which we did but about 30days later same problem took it back they charged me another fee to put on the diagnostic machine which we did. That still didn't take care of the problem this went on from April 2021 well in May received a recall for the coolant system on this car make and model made appt took it in well they failed at fixing this with the car having to be left there weeks at a time it is still there they couldn't repair it they now are saying it is the engine do we want it repaired I don't no how when they can't even fix what it was there for now all of a sudden it's on me and the agent that called first said the transmission they have no clue they are just trying not to be responsible for this car even towing company knows where to take the car I have been put down all over town. This has been a nightmare I am afraid of the car and no trust with the people that's fixing the recall because they don't know how.

Lug nuts on wheels are swollen and cannot be removed with the wrench provided with the vehicle. This prevented me from being able to remove my flat tire and install the spare. I was forced to drive the car with the deflated tire to a mechanic in order to get it forcefully removed. This represented a dangerous situation

2013 Ford Fusion 1.6 car system started to read low coolant level while driving parked. Checked level it was filled just fine. Cut car back on same thing then over temp. Code came up as well, turned car off checked under the hood fluids all over the front end. My car was fixed in 2019 for recall 17s09 for engine coolant problems that caused this before as well as 5 other recalls

The contact owns a 2013 Ford Fusion. The contact stated while driving approximately 75 MPH, the vehicle decelerated independently to 20 MPH. In addition, the engine overheated message was displayed on the instrument panel. The contact mentioned that there was a loud growling noise coming from the vehicle. in addition, the vehicle was placed in Park and the vehicle rolled backwards. The contact stated that the parking brake was activated to stop the vehicle. The vehicle was taken to the dealer where it was diagnosed that the transmission needed to be replaced. The vehicle was taken to an independent mechanic where it was diagnosed that the transmission temperature sensor needed to be replaced. The vehicle was taken back to another dealer where there was a diagnosis taken but the failure was unknown. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 77,000.

The contact owns a 2013 Ford Fusion. The contact stated that after starting the vehicle, the vehicle failed to shift into gear without warning. The vehicle was towed to the local dealer and the contact was informed that the mechanic was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 158,097

My car doesn't start after getting gas, it stalls while driving (which is very scary), feels like it's not getting enough gas at times and then will jump forward like it got too much gas at times. I took it to get it tested and was told it's the purge valve. This has been recalled in older models of the Fusion, as well as the Ford Focus. I have the same issue, but the 2013 isn't included in the recall. It needs to be covered under the recall because I'm sure my vehicle is not the only one. It's a huge issue, as it's not safe to drive.

Car consistently tries to pop the trunk while driving while also unlocking and locking doors. The seat always goes back to a default position. Does it so much I had to unplug the trunk actuator because it wouldn’t even let me drive off without opening the trunk. Lights flicker all weird when it does it. It does this idling and driving all the time. I can’t use photos to describe but I do have a video but your platform won’t let me upload videos.

The contact owns a 2013 Ford Fusion. The contact stated since purchasing the vehicle, while driving, the vehicle failed to exceed 40 MPH. There were no warning lights illuminated. The vehicle was taken to the dealer who diagnosed the vehicle but did not inform the contact of the diagnostic result. The contact stated that the vehicle was repaired however, upon starting the vehicle, the accelerator pedal was depressed but the vehicle failed to respond. The vehicle was taken to the mechanic who diagnosed that the transmission had failed. The contact stated that the vehicle was repaired however, the failure persisted. The vehicle was taken back to the mechanic and the valve body, the computer system, and the transmission were replaced. The contact stated that the failure had been reoccurring and the check engine light was illuminated. The manufacturer was not made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 99,000.

While driving on the interstate, the power steering on the car suddenly stopped working and has not come on since. This was a major issue as I was driving 80 mph on the interstate and had trouble steering after it gave out. After taking this to the Ford Dealership I was told that it would be a $3,100 fix. There were not any warning signs before this event and the car had been in perfect condition.

The contact owns a 2013 Ford Fusion. The contact stated that upon parking his vehicle in his driveway, the contact placed the gear shifter into the park however, the dashboard read that the vehicle was in neutral. As the contact exited the vehicle, the vehicle began to roll backwards without warning. The contact immediately re-entered the vehicle and forcefully applied the brakes and activated the parking brake. Since the failure, the contact had been unable to drive the vehicle as the gear shifter remained stuck in park as the dashboard continued to read that the vehicle was in neutral. The contact had notified both the dealer and the manufacturer of the failure and both informed him that his vehicle was not included in NHTSA Campaign Number: 18V471000 (Power Train) which he linked to the failure. The vehicle was not repaired. The failure mileage was approximately 143,000.

The contact owns a 2013 Ford Fusion. The contact stated that when the vehicle was started, the power steering failed to operate as designed. The contact took the vehicle to the dealer and was informed that the EPAS gear failed and needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA for assistance. The approximate failure mileage was 79,000.

The steering wheel attachment bolt has not maintained torque. As a result, the steering wheel has loosened over time. I fear the steering wheel may separate from the steering column shaft, increasing the risk of a crash while driving.

Had been shopping all day, with no indication of a problem. Stopped to gas up vehicle and put the gear shifter in park, then removed the key (No warning or indicator there was a problem). Before exiting the vehicle, when releasing the brake pedal, the car started to roll forward. Brake pedal was immediately pressed again, before possibly colliding with another vehicle parked in front of my vehicle. I put the key back into the ignition to attempt to start the vehicle and it would not start. I looked at the gear indicator and it stated the car was in reverse, but the shifter was in park. Gear shifter override did not change the indicator on the dash either. Vehicle was able to roll forward and backward with gravity or pushing. I kept on the emergency brake and upon inspection of the engine compartment by the mechanic with the tow company, it was discovered that the gear shift cable had disconnected. Reconnection was attempted, but it would not stay connected. There is a current recall for this exact problem, but my VIN number was not included in the recall.

The contact owned a 2013 Ford Fusion. The contact stated while he was parked on the side of the road, he noticed dark smoke coming from underneath the hood of the vehicle. The contact stated as he turned off the vehicle, the vehicle caught on fire. There were no warning lights illuminated. There were no injuries sustained. The contact was able to extinguish the fire with the assistance of the emergency units. A police report was filed. The vehicle was towed to a tow lot, where it was deemed a total loss. The dealer was made aware of the failure and advised the contact that they could not assist. The manufacturer was made aware of the failure and informed the contact that they could not assist due to the severity of the fire. The manufacturer stated that the failure was not related to NHTSA Campaign Number: 12V551000 (Engine and Engine Cooling). The approximate failure mileage was 140,000.

The contact owns a 2013 Ford Fusion. The contact stated while driving 20 mph, she heard an abnormal sound coming from the fuel tank. The contact stated that the check engine warning light was illuminated. The contact was able to drive to her residence. The contact took the vehicle to an independent mechanic and was informed the evap purge valve needed to be replaced. A dealer was not contacted. The vehicle was not diagnosed or repaired. Upon investigation, the contact associated the failure with NHTSA campaign number: 15V793000 (Fuel System, Gasoline) however, the VIN and the vehicle year was not included. The manufacturer had been informed of the failure. The failure mileage was unknown.

Transmission made noise and stopped running. Need replacement at a cost of $8,000.00.

Vehicle suddenly lost power steering and warning messages appeared about "steering assist fault" and "service AdvanceTrac". Dealer diagnosed the issue as a failed electric power steering rack but claimed the issue was not covered by recalls. These two Ford recalls appear to describe the exact scenario: 19S26 (19V-632) & 15S14 (15V-250)

I was driving my car and my power steering assist fault came on and the steering wheel locked up. If I would have been turning at the time I would have wrecked. The vehicle had to be towed to the Ford dealership. Since I have on the car the light has came on a couple times but immediately turns off. It is at the dealership where they are telling me it is $2400 to fix.

While on vacation in NW Ohio my power assist failure light came on and I lost my power steering. It was terribly hard to turn and scared me. My sister looked up to see if there were recalls on my 2013 Ford Fusion SE for this problem as we were together and found 17 recalls and over 1500 complaints for this same car year and problem but my VIN was not listed. My VIN needs to be included and I should be reimbursed. This malfunction happened on Sat afternoon July 17, 2021. I got my car into Taylor Kia dealership on Monday on July 19, 2021. My friend is the Sales Mgr. there and got my car in and gave me a loaner to use. they checked for recalls too but none found. It had to be fixed so I told the service dept to go ahead. While the car was there when I had to return home I had them put my back brakes and rotors on and 2 filters I needed. The first assembly parts were damaged and had to reorder. That came in Monday July 26 and repairs were made and finished July 27. I wasn't able to get back up until Friday to exchange the loaner for my car. I had them bag up the bad rack and pinion and brought it home in case you or Ford need it to validate this power steering failure for recall.