2012 Ford Fusion complaints

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE ATTEMPTING TO ACCELERATE FROM A STOP LIGHT, THE VEHICLE JERKED AND SOUNDED AS IF IT WOULD STALL. THE VEHICLE SUDDENLY ACCELERATED AND WAS TAKEN TO A LOCAL DEALER, BUT NO FAILURES COULD BE FOUND. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA TO FILE A COMPLAINT. THE FAILURE MILEAGE WAS 25,000. THE VIN WAS NOT PROVIDED.

AT 50,000 MILES THE LEFT FRONT INSIDE DOOR HANDLE FAILED TO OPEN THE DOOR. THE CAR HAS BEEN VERY WELL MAINTAINED AND HAS NEVER BEEN IN AN ACCIDENT. INABILITY TO OPEN THE DOOR FROM INSIDE THE VEHICLE COULD CREATE A VERY SERIOUS SAFETY ISSUE IN THE EVENT THAT THE VEHICLE WAS SUBMERGED AND THE POWER WINDOWS WERE NO LONGER OPERATIONAL. I FIRST NOTICED THIS DOOR HANDLE FAILURE WHILE PARKED ON A CITY STREET. THE FORD PART # IS 1 60FOZ04.

PULLING OUT OF DRIVEWAY...NOTICED THE STEERING WAS NOT FEELING RIGHT. TURN LEFT, TURN RIGHT BOTH WAY IS A HEAVY "CLICKING" FEEL. TOOK TO FORD FUSION 2012 TO DEALER, THEY SAID THE STEERING GEARBOX WAS BAD.....THEY ARE WAITING TO FIX IT IF EXTENDED WARRANTY PAYS FOR IT. THIS SHOULD BE A FORD RECALL, FIXED FOR FREE. IT IS CLEARLY A DEFECT IN THE PRODUCT. MY FUSION DOESN'T EVEN HAVE 20K MILES ON IT YET.

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STARTED THE VEHICLE AND EXPERIENCED A LOSS OF POWER STEERING WITHOUT WARNING. THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING); HOWEVER, THE FAILURE RECURRED AFTER THE REPAIR WAS PERFORMED. THE CONTACT MENTIONED THAT THE REMEDY WAS INSUFFICIENT. THE VEHICLE WAS TOWED TO THE DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.

I PURCHASE THIS CAR USED WITH 15000 KM ON, ISSUE OCCURRED AT 73000KM. FORD FUSION 2012 SEL AWD I WAS DRIVING TO WORK AND THE STEERING LOCKED UP, IT WAS EXTREMELY HARD TO STEER. I DROVE IT DIRECTLY TO THE DEALERSHIP. BENTON FRY FORD BELLEVILLE, ON THEY INSPECTED IT AND INDICATED THAT THE CONTROLS ARMS NEEDED TO REPLACED. I TOLD THEM TO GO HEAD THE APPROX.. COST WAS $1000.00. HOWEVER IT IS STILL POSSIBLE THAT I WOULD NEED TO REPLACE THE POWER STEERING RACK WHICH WOULD COST $2200.00. THE RESOLUTION WAS THAT THEY WOULD REPLACE THE CONTROLS ARMS AND NOT DO THE ALIGNMENT, TO SEE IF THE POWER STEERING WOULD GO AGAIN WITHIN A WEEK. I DROVE IT FOR A WEEK AND FOUND NOTHING WRONG WITH IT. SO I DROP IT OFF FOR THE ALIGNMENT TO BE COMPLETED. AT THE DEALER SHIP THE MECHANIC TEST DROVE IT AND FOUND THAT THE POWER STEERING RACK NEED TO REPLACE. I WAS ADVISED THAT MY CAR WAS OUT OF WARRANTY AS OF JUNE 13, 2015. THE SERVICE ADVISOR OFFER TO INVESTIGATE FURTHER TO SEE IF THERE WAS ANYTHING THEY COULD DO ON THEIR END. THEY WERE NOT ABLE TO HELP IT WAS SO THEY DIRECTED TO FORD CUSTOMER SERVICE WHO THEN ESCALATED THE ISSUE TO FORD REGIONAL MANAGEMENT, WHO IN TURN OFFERED TO OVER 55% OF THE $2200.00 AS A FINAL OFFER. WHO TREATED ME LIKE I SHOULD BE SOOOO GRATE FOR THIS. THIS ISSUE HAS BEEN RECALLED ON MAY 27, 2015 BY FORD IN 2011 TO 2013 FUSION. SINCE FORD STATED THIS CAR IS NOT PART OF THEIR RECALL, THEY DEFLECT THEIR RESPONSIBILITY OF SELLING ME A DEFECTIVE PRODUCT. THE ISSUE OCCURRED JUST LIKE T

COMPLETE POWER STEERING FAILURE ON A CAR WITH 20000 MILES. CAR WAS STATIONARY WHEN I TURNED IT ON THE THE WARNING CAME ON. I COULD NOT DRIVE IT

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED AND SHOOK VIOLENTLY AFTER THE WRENCH WARNING INDICATOR ILLUMINATED. THE VEHICLE DID RESTART AFTER SEVERAL ATTEMPTS WITHOUT SHAKING VIOLENTLY, HOWEVER, THE FAILURE RECURRED ON SEVERAL OCCASIONS WHILE DRIVING AT 40 MPH AND OVER. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS INFORMED THAT THERE WAS AN EXTENDED WARRANTY, HOWEVER, THEY COULD NOT REPAIR THE VEHICLE UNLESS THEY COULD DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE STEERING WHEEL BECAME EXTREMELY DIFFICULT TO MANEUVER WITHOUT WARNING. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V3400000 (STEERING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 78,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE TRACTION CONTROL AND POWER STEERING WARNING INDICATORS ILLUMINATED. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING GEAR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE FAILURE MILEAGE WAS 65,000. THE VIN WAS NOT AVAILABLE. UPDATED 02/10/16*LJ UPDATED 05/14/18*JB *CN

HOOD LATCH HAS BROKEN AFTER 40K MILES CAUSING THE HOOD TO OPEN ON ITS OWN WHILE DRIVING.

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING AT AN UNKNOWN SPEED, THE POWER STEERING FAILED AND TWO WARNING LIGHTS ILLUMINATED. THE CONTACT HAD TO RESTART THE VEHICLE TO LOOSEN THE STEERING WHEEL. THE FAILURE RECURRED FIVE TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BALL JOINTS AND TIE ROD NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 21,000.

2012 FUSION AND WE HAVE ALREADY CHANGED THE ROTORS... && MULTIPLE TIRES... ALWAYS GETTING THE TIRE PRESSURE SYMBOL && NOW THERE IS AN ELETRICAL PROBLEM FOR THE POWER STEERING... MANY OF THE FUSES ARE MISSING FROM WHERE THE MANUAL SAID THEY SHOULD BE... MAY HAVE TO PAY THOUSANDS TO GET IT FIXED && STILL ITS JUST A 2012... ID EXPECT SOMETHING LIKE THIS ON A CAR THATS 7-10 YEARS OLD BUT NOT 3...

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING 10 MPH, THE STEERING WHEEL SEIZED AND THE CHECK POWER STEERING FLUID LIGHT ILLUMINATED. THE FAILURE OCCURRED TWICE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING CONTROL MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.

DRIVERS HEATED SEAT GETS TO HOT AND THEN SOME TIMES DOESN'T WORK.

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE POWER STEERING ASSIST WARNING LIGHT ILLUMINATED. THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING GEAR MIGHT NEED TO BE REPLACED AND THE CODE NEEDED TO BE CLEARED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 67,000.

STICKY, NOTCHY STEERING ACCOMPANIED WITH LOUD GRINDING SOUNDS. THIS STARTED FOR NO REASON. THE DEALERSHIP TOLD ME THE CAR HAS A BAD STEERING RACK AND IS UNSAFE TO DRIVE. NO ERROR CODE IS SHOWING, SO FORD IS NOT REPLACING THE PART.

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING 60 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,071.....UPDATED 03-31-16 *BF...UPDATED 04/25/18*JB *TR

DEVELOP A CLUNKING NOISE IN STEERING SYSTEM AT 82000 MILES. TOOK THE CAR TO A ASE MECHANIC IN MY TOWN AND IT WAS DIAGNOSED AS A FAILED EPAS (POWER STEERING RACK.) THE BILL FOR THIS IS GOING TO BE BETWEEN 1400-1600! I HAVE READ ELSEWHERE ONLINE OF FORD RECALLING THE FUSION FOR TROUBLE CODES IN THE SAME STEERING RACK FOR FAILED SENSORS AND LOSS OF POWER ASSIST SUDDENLY MAKING THE CAR DIFFICULT TO STEER AND RISKING A CRASH AS A RESULT. MY CONCERN IS COMPLETE MECHANICAL FAILURE DUE TO THE CLUNKING LIKE SOMETHING IS EITHER BROKEN OR ABOUT TO BREAK. THIS WOULD RESULT IN COMPLETE LOSS OF CONTROL OF VEHICLE AND A POSSIBLE CRASH. I REALIZE THINGS BREAK OUT OF WARRANTY BUT THIS IS A SAFETY ISSUE FIRST AND FOREMOST. MY DAUGHTER DRIVES THE CAR AND MY CONCERN IS FOR HER SAFETY. IF THERE IS NO RECALL ISSUED I WILL BE FORCED TO REPAIR OR TRADE THE CAR AND LOSE WHAT LITTLE EQUITY I HAD IN THE CAR BECAUSE OF ITS REPAIR BILL. THE CAR HAS BEEN WELL MAINTAINED. THIS IS NOT AN ABUSE ISSUE. MY OPINION IS THAT THIS A FAULTY PART. WHEN I TOOK IT TO MY LOCAL FORD DEALER, I WAS TOLD THERE WERE NO RECALLS ON THE CAR AND I WOULD HAVE TO PAY THE BILL OUT OF POCKET.

TRANSMISSION SLAMS INTO GEAR FROM FIRST TO SECOND, THEN SECOND TO THIRD OCCASIONALLY. I'VE HAD 3 BRAKE CALIPERS SEIZE AND 3 ROTORS REPLACED AS A RESULT. BRAKE WEAR IS BEYOND PATHETIC. REAR TURNING SIGNAL/BRAKE LIGHT BULB GOT SO HOT THAT IT MELTED MY ACTUAL TAILLIGHT. PAINT FLAKES OFF FENDERS FROM JUST WASHING WITH A BRAND NEW SPONGE.

I WAS DRIVING STRAIGHT AND IN THE MIDDLE OF ACCELERATION WHEN MY 2012 FUSION SEL BEGAN TO MAKE NOTIFICATION SOUNDS. I READ TWO NOTIFICATIONS. THE FIRST ONE INCLUDED A WARNING LIGHT FOR "SERVICE ADVANCETRAC". THE SECOND NOTIFICATION READ "SERVICE POWER STEERING NOW". I CONTINUED TO DRIVE NORTHBOUND TO THE HIGHWAY. UPON TURNING AND BREAKING TO BOARD THE FREEWAY, I REALIZED THE STEERING WHEEL WAS EXTREMELY TIGHT. IT WAS NEARLY IMPOSSIBLE FOR ME TO STEER MY CAR TOWARDS THE FREEWAY WITH SEVERAL OTHER CARS DRIVING AT SPEEDS BETWEEN 35-50 MPH BEHIND US. I HAD TO USE BOTH ARMS AND BODY WEIGHT TO TURN RIGHT TO GET ON THE FREEWAY. I WAS AFRAID TO CONTINUE ON THE HIGHWAY AS I HAD NOT EXPERIENCED THIS BEFORE AND MY TWO DAUGHTERS WERE IN THE BACKSEAT. I WENT TO A DEALERSHIP TO DIAGNOSE THE ISSUE. I WAS TOLD THE STEERING GEAR WOULD NEED TO BE REPLACED. I RESEARCHED THIS ISSUE. THERE ARE RECALLS ON FUSIONS MADE BETWEEN 2011-2013 FOR THIS EXACT ISSUE. HOWEVER, MY VEHICLE IS NOT INCLUDED IN THE FORD RECALLS. THIS IS A SAFETY ISSUE FOR MYSELF AND OTHERS, ESPECIALLY WHEN I AM ON THE HIGHWAY OFTEN. FORD MOTOR CO. HAS TOLD ME THREE TIMES THAT MY CAR WASN'T INCLUDED IN THE RECALLS, IT WAS NOT MADE IN THE SAME FACTORY AS THOSE RECALLED, AND IT WAS MADE MONTHS AFTER THE RECALL. THE CARS INCLUDED IN THE RECALL WERE MADE IN FEBRUARY 2012 WHILE MY CAR WAS MADE IN JUNE 2012. THIS IS A HORRIBLE WAY TO HANDLE CONSUMERS. SAFETY OF CONSUMERS DOES NOT APPEAR RELEVANT TO FORD MOTOR COMPANY. THERE NEEDS TO BE

DRIVING ABOUT 45 MPH AND THE STEERING BEGAN TO FEEL "CATCHY". A COUPLE OF MINUTES LATER THE SERVICE POWER STEERING LIGHT CAME ON AND ALTERNATED WITH THE SERVICE ACCUTRAC.

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT WHILE AT DRIVING 50 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PARKED AND RESTARTED BUT THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE LOWER CONTROL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT INCLUDED IN THE NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 74,600.

DRIVING AT 10 MPH TURNING INTO A CITY STREET AND THE CAR STALLED. I SHUT OFF THE CAR AND RESTARTED IT AND IT WORKED TO GET ME TO MY DRIVEWAY (~400 FEET).

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING 20 MPH, THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER AND ELECTRICAL FUNCTIONALITY. ALL THE WARNING INDICATORS ILLUMINATED AND FLICKERED UNTIL THE VEHICLE LOSS POWER. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BATTERY FAILED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS RETURNED TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE GEM MODULE MALFUNCTIONED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT IT WAS NOT A SAFETY ISSUE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 109,000.

SATURDAY, OCT 31ST, THE LOW TIRE PRESSURE WAS INDICATED AND VERIFIED THE RIGHT-FRONT TIRE WAS LOW WHEN THE CAR WAS STARTED. I DROVE THE CAR 3000 FEET ABOUT 25 MPH AND SERVICE ADVANCETRAC AND POWER STEERING ASSIST FAULT DISPLAYED. BROUGHT THE CAR TO THE DEALERSHIP AND THEY CLAIM THE TIRES NEED REPLACING. EXCLUDING THE LOW PRESSURE IN ONE TIRE, THERE SHOULD HAVE NOT BEEN A FAILURE AND THE TIRES ARE NOT BALD.

I BOUGHT THIS CAR USED IN JUNE OF THIS YEAR, 2015. THE DRIVERS SIDE DOOR WILL NOT LOCK OR UNLOCK BY USING THE REMOTE. SOMETIMES IT WILL UNLOCK WITH REMOTE BUT NEVER WILL LOCK!

RAPID UNCONTROLLED ACCELERATION FOLLOWED BY SUDDEN LOSS OF POWER. SPEED IS REDUCED TO UNDER 10 MPH, THE WRENCH LIGHT TURNS ON WHEN THIS OCCURS. POWER IS RESTORED AFTER TURNING THE VEHICLE OFF AND BACK ON. THIS PROBLEM HAS OCCURRED TWICE IN THE LAST WEEK, IN RUSH HOUR TRAFFIC, AND NEARLY RESULTED SERIOUS ACCIDENTS INVOLVING BOTH OUR VEHICLE AND VEHICLES BEHIND US TRYING TO AVOID OUR ALMOST STALLED VEHICLE. THIS IS A VERY DANGEROUS DEFECT! THE CAR BEHIND US SWERVED IN FRONT OF A SEMI TRUCK WHICH NEARLY CAUSED A CHAIN REACTION CRASH IN 70 MPH TRAFFIC. THE SECOND VEHICLE, BEHIND THE ONE THAT CUT OFF THE SEMI, NEARLY REAR ENDED US AS WE LIMPED ALONG AT UNDER 10 MPH. IT WAS ALMOST IMPOSSIBLE TO GET THE VEHICLE TO THE SHOULDER FROM THE CENTER LANE IN BOTH INSTANCES. WE PURCHASED THE VEHICLE USED ALMOST TWO YEARS AGO AND HAVE NOT RECEIVED A SAFETY NOTICE CONCERNING THIS DEFECT.

THE CONNECTOR TO THE AIR CONTROL RELAY OVERHEATS. WOULD SMELL AN ELECTRICAL BURNING SCENT. CHECKED ONLINE FOUND PICTURES OF MELTED WIRING UNDER DASH. TOOK PICTURES OF THAT AREA UNDER DASH AND FOUND THE SAME THING. THE CONNECTOR TO THE AIR CONTROL RELAY IS MELTED. THE BLOWER FAN HAS QUIT WORKING. FORD DEALERSHIPS WANT 500.00 PLUS TO FIX THIS. I WOULD CALL THIS A SAFETY DEFECT. IT ONLY SEEMS TO HAPPEN TO CARS EQUIPPED WITH THE DUEL CONTROL AUTO CLIMATE. THIS INCIDENT DID NOT CAUSE A FUSE TO TRIP AND COULD LEAD TO A FIRE IN THE DASH. IT NOT UNCOMMON BECAUSE IT WAS QUICKLY AND EASILY FOUND ON YOUTUBE. FORD WAS AWARE OF THE PROBLEM, BUT DENIED IS WAS ANYTHING OTHER THAN A MAINTENANCE ISSUE.

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING 20 MPH, THE STEERING WHEEL SEIZED AND AN UNKNOWN WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE STEERING WHEEL REQUIRED EXCESSIVE FORCE IN ORDER TO STEER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRIC POWER STEERING ASSIST SYSTEM FAILED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,300.

I LIVE IN ALTON, TEXAS THIS IS THE SECOND TIME I HAVE THIS INCIDENT. 1. TIME IT HAPPENED THE STEERING WHEEL WAS HARD TO MOVE AT FIRST THEN WAS IMPOSSIBLE TO MOVE. I WAS ON THE ROAD CLOSE TO HOME AND I WAS ABLE TO PARK HALFWAY IN THE DRIVEWAY. CAR WAS TAKEN TO DEALER AND WAS "FIXED". 2. TIME IT HAPPENED I WAS AT THE PARKING LOT BARELY GOING TO AVENUE I DECREASED SPEED AND WAS ABLE TO GET HOME LIGHT WENT ON STEERING WHEEL WAS SLIGHTLY HARD TO MOVE

WHILE TURNING INTO A PARKING SPACE THE STEERING STARTED MAKING LOUD NOISES AND WAS DIFFICULT TO STEER (HAD NO POWER STEERING). I TOOK IT TO A FORD DEALER IN MY TOWN. I EXPLAINED WHAT IT WAS DOING AND HE ORDERED A PART FOR IT WITHOUT EVEN LOOKING AT THE CAR. HE SAID THE PART ALONE WOULD BE APPROX. $1200. HE SAID IT WAS A POWER STEERING RACK. HE ALSO SAID OTHER 2012 FORDS WERE ON A RECALL FOR THAT PROBLEM BUT MINE WAS NOT ONE OF THE RECALLS. I CALLED THAT DEALERSHIP THE NEXT DAY AND CANCELLED THE ORDER. HOW COULD THEY KNOW WITHOUT LOOKING AT MY VEHICLE? I THEN TOOK MY CAR TO ANOTHER FORD DEALER IN THE TOWN WHERE I WORK (APPROX. 20 MILES FROM MY TOWN). THEY ALSO SAID IT WAS THE POWER STEERING RACK (THEY DID EXAMINE THE CAR) BUT THEY SAID THE PART WAS ON BACK ORDER. THEY ALSO SAID THE PART ALONE WAS $1200 AND THE TOTAL BILL WOULD BE APPROX. $1550. IT TOOK 2 WEEKS TO BET THE PART IN. MEANWHILE I HAD TO CONTINUE TO DRIVE MY VEHICLE WITH NO POWER STEERING BECAUSE THEY HAD NO LOANER CARS TO GIVE ME. THEY ALSO SAID MY CAR WAS NOT ON THE RECALL LIST EVEN THOUGH IT HAD THE SAME PROBLEM AS THOSE THAT WERE RECALLED!! I BOUGHT THIS VEHICLE IN AUG 2013 AND IT HAD 28,000 MILES. NOW 2 YEARS LATER AND THE MILEAGE @ 45,000 I HAVE A BILL FOR FOR $1550. I TRULY DO NOT UNDERSTAND WHY FORD HAS NOT INCLUDED MORE VEHICLES IN THE POWER STEERING RACK RECALL SINCE IT APPEARS THAT MANY MANY MORE VEHICLES HAVE BEEN AFFECTED. I WOULD LIKE TO KNOW WHY CERTAIN ONES ARE RECALLED AND OTHERS ARE NOT . I AGREE W

ON SEPTEMBER 5, 2015 I WAS ON MY WAY TO A FUNERAL TRAVELING ON 695 IN OWINGS MILLS MARYLAND AND EXPERIENCED THE LOST CONTROL OF MY VEHICLE. WHILE TRYING TO STEER BACK THE STEERING WHEEL DID ABSOLUTELY NOTHING AND ALSO THE TRYING TO SHIFT INTO GEAR WAS ALWAYS A MAJOR PROBLEM. THE GEAR SHIFT WOULD STICK OR SOMETIMES HARD TO PUT BACK IN PLACE. FROM THIS MY CAR WAS TOTALLED.

I WAS DRIVING MY 2012 FORD FUSION HOME FROM WORK AND WAS STOPPED AT A STOP LIGHT. WHEN I RESUMED DRIVING WHEN THE LIGHT TURNED GREEN, MY POWER STEERING SUDDENLY MALFUNCTIONED WHILE DRIVING AND I WAS NO LONGER ABLE TO TURN THE VEHICLE CAUSING ME TO CRASH INTO A POLE. THERE WAS NO WARNING, JUST TOTAL POWER STEERING FAILURE WHILE DRIVING. IT IS EXTREMELY DANGEROUS, AND FORD HAS RECALLED HALF A MILLION VEHICLES FOR THE SAME ISSUE, BUT FOR SOME REASON MY MODEL WASN'T INCLUDED. IT MAKES DRIVING TERRIFYING.

2012 FORD FUSION. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO VEHICLE DEFECT ASSOCIATED WITH RECALL NOTICE. *SMD THE DRIVER OF THE VEHICLE WAS INVOLVED IN A SINGLE CAR ACCIDENT. CONSEQUENTLY, THE DRIVER WAS BURNED TO DEATH. THE LAWYER ON BEHALF OF THE DRIVER, BELIEVED THE ACCIDENT WAS DUE TO A DEFECT ASSOCIATED WITH THE VEHICLE THAT WAS RECALLED. THE LAWYER REFERENCED RECALL # 15V340. *JB..*TR.....UPDATED 12/29/15 *BF *CN

ENGINE LIGHT CAME ON. CAR IS 38 MONTHS OLD, 24,818 MILES. FUEL FILLER NECK CORRODED THROUGH. $800 REPAIR AS IT WAS JUST OUT OF WARRANTY

MY STEERING WHEEL POWER IS FLASHING IN MY DASH BOARD AND IT IS HARD TO TURN MY WHEEL. I WAS PUTTING AIR IN MY TIRE AND WHEN I STARTED THE CAR BACK UP THE POWER STEERING APPEARED AND I WASNT ABLE TO TURN THE WHEEL.

POWER STEERING FAILED SUDDENLY WHILE MY DAUGHTER WAS DRIVING ON ROADWAY. ALMOST INVOLVED IN CRASH DUE TO INABILITY TO STEER!

MID 2014 THE AIRBAG INDICATOR ON DASH BOARD ACTIVATED WHEN I STARTED THE CAR AND REMAINED LIT WHILE DRIVING. AT NEXT OIL CHANGE THE DEALER STATED THE RESTRAINT CONTROL MODULE NEEDED TO BE REPLACED. LOCATED AN ACTIVE RECALL FOR THIS ISSUE ONLINE, BUT IT IS ONLY FOR MODEL YEARS 2013-2015. MY CAR IS 2012 AND PER THE DEALER NOT INCLUDED IN RECALL. AD TO THAT, THE RESTRAINT CONTROL IS A SPECIFIC EXCLUSION TO THEIR WARRANT CONTRACTS INDICATING THEY KNEW THERE WAS AN ISSUE WITH THE PART. I UNDERSTAND THAT THE CONTROL MODULE SHORTS OUT.

LOSE OF POWER STEERING WHEN DRIVING IT CAME UP AS POWER STEERING ASSIST FAULT. SAME THING HAPPENED TO FORD FUSION 2012 THAT WENT TO FEB, AND WAS RECALLED. MY VEHICLE SHOULD BE ON RECALL ALSO BEFORE AN ACCIDENT OR DEATH OCCURS.

TURNED ON A/C AND IT ONLY WOULD BLOW HOT AIR. TRIED SEVERAL TIMES, SOME TIMES HOT, SOME TIMES COLD. TECH AT FORD REPLACED BLEND DOOR ACTUATOR, SAID ACTUATOR WAS NOT MOVING. FIX LASTED 5 MINUTES, THEN STARTED BLOWING HOT AIR AGAIN.

2012 FORD FUSION. CONSUMER WRITES IN REGARDS TO BRAKE SYSTEM PROBLEMS. *SMD THE CONSUMER STATED SHE COMPLAINED TO THE DEALER ABOUT A CLICKING SOUND. AFTER SHE STARTED THE VEHICLE, PUT IT IN GEAR, WITH HER FOOT ON THE BRAKE, THE SOUND COULD BE HEARD. AT THAT TIME, IT WAS SPORADIC. EACH TIME SHE VISITED THE DEALER, THEY WERE UNABLE TO FIND ANYTHING WRONG. *JB

DRIVING AT APPROXIMATELY 45 MPH ON HIGHWAY 4 DOWNHILL INTO RUTLAND VT (8:15PM) CHIME ALERT AND DASH SCREEN ALERTED TO "SERVICE POWER STEERING NOW! AND "SERVICE ADVANCE TRAC", IMMEDIATELY LOST ALL POWER STEERING. VEHICLE EXTREMELY DIFFICULT TO STEER. MECHANICALLY INCLINED, INVESTIGATED ISSUE,. BUT NO FIX AND WAS FORCED TO CAREFULLY CONTINUE THE DRIVE HOME. FOLLOWING DAY CHECKED ALL FUSED LINKS CONCERNING POWER STEERING COMPONENTS, ONE FUSE BOX UNDER HOOD (FUSE AREA 50) AND ONE FUSE BOX WAY UP TO LEFT IN DRIVER'S SIDE COMPARTMENT, FUSE AREA 42) FUSES ALL GOOD. CALLED FORD DEALER SERVICE DEPARTMENT REPRESENTATIVE AND GAVE VIN NUMBER AND NO RECALLS WERE ISSUED FOR THIS PROBLEM. FURTHER RESEARCH ON FORD FORUM POSTINGS REVEALING THIS TO BE A COMMON PROBLEM, AND WITH OTHER FORD PRODUCTS BESIDES FORD FUSION.

I MOVED THE TURN INDICATOR LEVER UP TURN RIGHT AND THE QUICK BLINKER SOUND BEGAN. FROM PAST EXPERIENCE, I KNEW THAT A LIGHT BULB MAY BE BURNED OUT. THE BULB COULD NOT BE CHECKED ALONE BECAUSE IT WOULDNT COME OUT OF THE SOCKET; THE BLACKENED BLOWN BULB WAS FUSED TO THE SOCKET. I REPLACED THE ENTIRE SOCKET/BULB SET ($30.13 SOCKET AND $6 FOR A SET OF 2 BULBS). THE NEXT DAY, I MOVED THE TURN INDICATOR LEVER DOWN TO TURN LEFT AND THE QUICK BLINKER SOUND BEGAN AGAIN. AGAIN, THE BULB ALONE COULD NOT BE REMOVED. THE LEFT BLACKENED BLOWN BULB AND SOCKET ARE FUSED. I HAVE NEVER HAD A BULB FUSE INTO THE SOCKET BEFORE, LET ALONE HAVING IT HAPPEN TO TWO IN A SPAN OF 24 HRS. THE FUSES TO THE LIGHTS WERE NOT BURNED OUT - THERE WAS NO WARNING DISPLAYED TO ADVISE OF A POTENTIAL FIRE HAZARD. WE SPOKE TO OUR SALES REPRESENTATIVE, SINCE THIS WAS PURCHASED BY US 3 MONTHS AGO AS A PREOWNED VEHICLE W/A 12MONTH WARRANTY. HE SAID HE WAS UNAWARE OF ANY ISSUES AND DIRECTED US TO THE SERVICE DEPT. OUR CALL WAS DIRECTED TO AN ANSWERING MACHINE. WE WILL FOLLOW THROUGH.

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE THE VEHICLE WAS PARKED, THE FRONT DRIVER SIDE DOOR FAILED TO LOCK ELECTRONICALLY. THE CONTACT HAD TO LOCK THE DOOR MANUALLY. IN ADDITION, WHILE DRIVING 20 MPH, THE DOOR OPENED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THE FRONT DRIVER SIDE DOOR LATCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 15V246000 (LATCHES/LOCKS/LINKAGES) HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 36,000.

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED AND THE ASSIST NOW WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000.

WHILE DRIVING AT 45-50MPH THE ENGINE LOST ALL POWER AND THE WRENCH LIGHT CAME ON. I PULLED OVER AND THE CAR STARTED TO SKIP AND TURNED OFF. I SAT A FEW MINUTES AND CRANKED THE CAR AGAIN. THE LIGHT WAS OFF AND THE CAR WENT WITH NO PROBLEM.I TOOK IT TO A SHOP TO SEE IF ANY CODES WOULD SHOW IN THE COMPUTER. NOTHING SHOWED. THE FOLLOWING DAY I WAS DRIVING AT 60MPH AND IT DID THE EXACT SAME THING. I TOOK IT BACK TO THE SHOP A CODE P2111 "THROTTLE ACTUATOR CONTROL SYSTEM STUCK OPEN" SHOWED. ON THE WAY HOME, DRIVING AT 50MPH IT DID THE EXACT SAME THING AGAIN.

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

WHILE LEAVING MY PLACE OF WORK THIS AFTERNOON THE VEHICLE WENT INTO 'HOME MODE', DRASTICALLY REDUCING THE SPEED AND RESPONSE (NONE OR VERY LIMITED ACCELERATION AVAILABLE). I GOT OFF THE ROADWAY AND USED A WIRELESS SCANNER AND IT REPORTED NO DTC CODES, BUT AN ACCELERATOR ACTUATOR STUCK OPEN. AFTER REMOVING THE SCAN TOOL DONGLE AND TURNING KEY COMPLETELY OFF, IT ALLOWED ME TO DRIVE 45 MILES (MY DAILY ONE WAY COMMUTE) WITH NO ISSUES. I'M CERTAINLY CONCERNED OF THIS HAPPENING ON A BIGGER, FASTER HIGHWAY. AND, NO, I DIDN'T GET NO NOTICE BEFORE THE NO-RECALL RECALL HAPPENED.

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE DECELERATED TO APPROXIMATELY 5 MPH, THE WRENCH WARNING INDICATOR ILLUMINATED. THE CONTACT MERGED OFF THE ROAD, TURNED OFF AND RESTARTED THE VEHICLE, AND DROVE TO THE DEALER. THE DEALER STATED THAT THE THROTTLE BODY HAD TO BE REPLACED BECAUSE IT WAS DAMAGED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.

TL* THE CONTACT OWNS A 2012 FORD FUSION. WHILE DRIVING APPROXIMATELY 55 MPH, THE POWER STEERING BECAME INOPERABLE WITHOUT WARNING. THE FAILURE RECURRED ON ONE OCCASION. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 16,000. UPDATED 02/05/16*LJ *CN