2017 Ford F-350 SD complaints

The contact owns a 2017 Ford F-350. The contact received notification of NHTSA Campaign Number: 22V644000 (Back Over Prevention) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not yet contacted. The contact stated that the camera image was very distorted and cloudy. The failure mileage was 30,000. VIN tool confirms parts not available.

The contact owns a 2017 Ford F-350. The contact stated while driving 70 MPH, the vehicle drove over a speed bump and started shaking violently. The vehicle had experienced the death wobble. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was 90,000. The VIN was not available.

The contact owns a 2017 Ford F-350. The contact stated that after a freezing rainstorm, the front driver’s side and front passenger’s side doors would not latch properly and the doors would not remain closed. The cause of the failure was not determined. The manufacturer and local dealer were notified of the failure. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 17V652000 (Latches/Locks/Linkage). The contact stated that the vehicle had experienced the failure listed in the recall. The approximate failure mileage was 150,000.

The contact owns a 2017 Ford F-350. The contact received notification of NHTSA Campaign Number: 22V644000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

On March 17th, 2023, my 2017 Ford F-350 and I experienced a catastrophic failure of the CP4 high-pressure fuel pump. According to a TriStar Ford (Kittanning, Pennsylvania) diesel mechanic, the CP4 pump literally exploded (mechanically blew apart). At the point of failure on the road, the result was diesel fuel EVERYWHERE on Rt. 422 about 15 miles SE of Kittanning, in the pouring rain. The vehicle stopped on the uphill side of a very steep long slope. The entire engine compartment was flooded with diesel fuel, and the roadway had diesel fuel pooled under the truck, and later, down the storm-water management ditch for several hundred feet. Yes, the diesel-fuel contaminated area was greater than 1600 square feet. CP4 pumps fail all of the time, and Ford knows this. So do YOU! These kinds of failures are SAFETY ISSUES (EXTREME fire hazard!!), and you and Ford have known this for YEARS! You need to make Ford recall ALL vehicles with this CP4 pump installed!

Steering stabilizer/damper. Truck has the death wobble going over 50 mph.

The contact owns a 2017 Ford F-350. The contact stated that on various occasions, the camera displayed a hazy and distorted image. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the rearview camera needed to be replaced; however, the failure could not be duplicated. The contact received notification of NHTSA Campaign Number: 22V644000 (Back Over Prevention). The manufacturer was made aware of the failure. The approximate failure mileage was 55,000.

The contact owns a 2017 Ford F-350. The contact stated while driving 80 MPH, the driveshaft detached. The contact related the failure to NHTSA Campaign Number: 22V880000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 38,000. VIN tool confirms parts not available.

The contact owns a 2017 Ford F-350. The contact stated that the vehicle was idling rough. Additionally, the vehicle had smoke coming from the tailpipe and the contact smelled an abnormal odor. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The contact received notifications of NHTSA Campaign Number: 22V644000 (Back Over Prevention) and 22V880000 (Power Train) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The failure mileage was 74,000.

When you hit a bump at road speeds (45 mph+), the steering wheel shakes wildly and you have to slow down immediately to avoid losing control. First happened about 12 months ago. Was not a common issue until more recently. Now it seems to be nearly every time I drive it. Ongoing issue now.

The contact owns a 2017 Ford F-350. The contact received notification of NHTSA Campaign Numbers: 22V880000 (Power Train) and 22V644000 (Back Over Prevention) however, the parts to do the recall repairs were not yet available. The contact stated that the rearview camera image was foggy. Additionally, the vehicle was shuddering while driving and the vehicle would hesitate to respond upon depressing the accelerator pedal. The power train warning light was illuminated. A message indicating a steering failure was displayed. The contact related the failure to the recalls. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact also stated that the tailgate of the vehicle would open independently while driving. The contact stated that the failure had been occurring intermittently. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 10,000. VIN tool confirms parts not available.

The contact owns a 2017 Ford F-350. The contact stated while driving 67 MPH and going over a bump on the roadway, the vehicle started sharking uncontrollably. The contact was able to stop on the side of the road and waited until the vehicle stopped shaking before the vehicle started to operate normally. The vehicle was taken to the dealer and the front-end of the vehicle was repaired however, the failure continued. The vehicle was taken to the dealer and the contact was informed that the steering dampener needed to be replaced. The vehicle was not repaired due to parts not being available. The manufacturer was not contacted. The failure mileage was 139,000.

Steering wobble - I was driving on I-5 at 70 mph and ran over a small pothole. The steering started violently and uncontrollably shaking. It caused the truck to drift into the left lane but fortunately no other vehicle was along side. I was able to regain control by cautiously slowing down to about 35 mph. At that point the shaking stopped and steering went back to normal. Checking the tpms, the tires were properly inflated at the time. I went on to drive another 200+ miles without further incident. The 2017 F350 truck had 28,328 miles at the time and has only been driven on paved roads. I have noticed in the past that hitting a bump in the road seems to resonate rather than just an initial “bump” like other vehicles I’ve owned. The truck is well taken care of and has never been in an accident.

The contact owns a 2017 Ford F-350. The contact stated that while driving 65 MPH, the driveshaft fractured, causing both the passenger’s and driver’s side rear tires to detach from the vehicle. The vehicle was towed to a dealer awaiting a diagnostic test. Upon investigation, the contact became aware that the VIN was included in NHTSA Campaign Number: 22V880000 (Power Train) however, parts for the recall repair were not yet available. The vehicle not repaired and remained in the possession of the dealer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 140,000. VIN tool confirms parts not available.

While driving at freeway speeds, I hit a bump with the front tires and the whole truck starts shimmying to the point I can hardly keep it on the road. I have to rapidly deaccelerate to a speed between 25 mph and 50 mph ( it varies on each occasion) to keep control of the vehicle. This has happened 5 times in the last week. The truck just turned over 28,000 miles. I'm afraid to drive it now. After the 1st occurrence I had the tires inspected and balance Che ked but was told they were OK.

Traveling on the highway at approximately 65mph. Encountered a bridge expansion joint and the front tires and steering wheel began shaking violently which resulted in loss of steering and brake control. Apparently, this is a known issue with these trucks.

While driving on the freeway at approximately 60 mph the left front wheel hit a small pothole. The truck immediately begin shaking violently. The extreme shaking involved the entire front end of the truck and the steering wheel. The shaking lasted for approximately 30 seconds and stopped once the speed was reduced to about 40 mph. No warning lights or warning indicators came on before, during or after the incident. I am very fortunate that I was able to maintain enough control of the vehicle to not hit the center median on the freeway or other cars to my right. EXTREMELY DANGEROUS SITUATION!

The front end of my Ford F350 can cause a forceful wobble when going over small bumps. The last time this occurred was on 11/26/22 while driving on the highway at 65 mph and I drove over one of the seams in the pavement. The front end began to wobble so forcefully, I had to slow down to around 30 mph, putting me and anyone behind me at risk of a rear end collision. I haul a travel trailer and if this were to happen while hauling, it could have more catastrophic effects. I've not been able to get it in to Ford to troubleshoot due to their long delays (7 to 9 weeks) in servicing vehicles. I'm trying again this week to take it in. It's not been inspected by anyone yet. There's no warning when this occurs. The first time this happened was either in the Fall of 2021 or early Spring of 2022.

We were driving and noticed a few white puffs of smoke. The next thing that happened was a loud bang from the engine and the cab of the truck filled with black smoke. Within 5 minutes, the entire truck was engulfed in flames, as well as our camper. There was no warning indication on the dash. The insurance company had investigators look at the remains. However, since the truck was aluminum and the fuel filter housing and low pressure side of the fuel system was plastic, everything totally melted. The truck was properly serviced prior to our travels.

The contact owns a 2017 Ford F-350. The contact stated that while driving at approximately 5 MPH, the front driver’s side door was erroneously unlatched and opened. The contact indicated that on several occasions, the door would not remain latched. On other occasions, the door would not open as needed, causing the driver to use the front passenger’s side door to exit the vehicle. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The contact was informed that the vehicle was not included in the NHTSA Campaign Number: 17V652000 (Latches/Locks/Linkages). The contact indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 290,000.

The contact owns a 2017 Ford F-350. The contact stated that a "water in the fuel system" warning message appeared on the instrument panel. The contact watched videos online that showed him how to drain and prime the fuel system to correct the failure; once he performed the repair, the warning light disappeared. When the contact refueled the vehicle, the warning message displayed, and the vehicle began to hesitate upon depression of the accelerator. The vehicle was towed to the dealer and the contact was informed that there was DEF (Diesel Exhaust Fluid) in his fuel tank which caused the failure. The contact disputed the diagnostic result and stated that he did not place def fluid in the fuel tank. The manufacturer was notified of the failure and referred him to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 68,000.

Okay, been hearing a lot of noises up underneath it, got under there and looked at my heat shields, that are just flaking off everywhere. I'm scared that my truck is going to catch on fire at this point. All of the heat shields around pretty much everything are disintegrating and falling apart. I've already filled out several of these and I went and tried to turn the truck in and to no avail. They have done everything in their power to not fix nothing on my truck. Nothing. I need some help. Please give me a call [XXX] The linkage, the power door locks and the door handles leaking, are all problems that I have and every one of them they know about and I'm scared that the front end is going to fall apart because of that linkage problem.. I can't get them to do nothing for me. I'm so tired of dealing with them and I was going to buy another truck from them and now I'm on the verge of not buying another one from them cuz they won't even fix the problems on this one. I would really appreciate if somebody would reach out to me and help me. Someone please give me a call and let me know what steps I need to do to get this taken care of. Thank you very much. I firmly believe that with your help they will do the right thing. Thank you have a blessed day INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The tailgate has been malfunctioning since day one and I had it kind of working here and there but then it ended up coming apart completely and the backup camera has been lost due to that and I just seen that that is a problem that they've had with many of these vehicles and I would love to get that fixed. Also because I do not have no backup camera on this truck it's just crazy. I mean I use it for work and I pull a lot of trailers and it was just you know. I don't even know what to say. I would please love it if somebody could help me get these problems fixed with Ford. I have tried and tried to no avail. I think they're trying to wait for me to get many many miles on my truck. I started trying to get this stuff fixed when I was back at $65,000 mi. You know and they was will not fix nothing. I realized that the door had water in it way back then and they just won't fix it. The tail lights do the same thing. My number is [XXX]. Thank you INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The engine block heater cord is malfunctioning and it's also hanging down. I've tried over and over to get it to stay up and that is a problem. And also it's got a problem with a corroding and I plugged it in one time and it sparked so I need that fixed also. God I hope these people will finally do something. I've had a real problem with them and I spent a lot of money with them. This is the third vehicle I bought from Ford

I've already done one on the linkage but I mean the steering damper. But now the steering is wanting to try to get real stiff on me sometimes right in the middle of turning and come to find out it's got a recall on something another in the steering which may cause it to lock up while I'm driving and I need to get this stuff fixed. I mean this is crazy. I've been noticing this for a while. I just didn't know that there was a recall on it until now. I've been trying to deal with these people for quite a while now to get some of this stuff resolved and they've done everything under the sun to blow me off. Please help. [XXX] thank you! INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Third time returning my Ford F350 to the Friendly Ford dealership where it was purchased because of death wobble. Vehicle is driving at high speeds all three times has been on the freeway and all of a sudden it shakes violently and almost loses control of vehicle. The first time happened in January 18 of 2020 the second time happened June 25 of 2022 and then just three days ago October 12, 2022. The vehicle was almost crashed the last two times it happened. The shaking was so violent on the last time did it caused my fuel line to come loose and spell diesel fuel all the way back into town. again it has been to the dealership three times now to fix the problem and was told this last time that everything looked OK and that I had to test drive it and re-create the situation in order for them to diagnose it. Extremely dangerous to re-create the death wobble. during the second incident when my wife was driving with my three children in the back she narrowly avoided colliding with a concrete barrier. The most recent incident with my self driving and my three children in the back and my wife in the front seat almost caused an accident with a semi driver And the person behind me as it shook violently and I tried to get off the road to stop shaking. There were no warning lights messages or other symptoms of problem prior to the failure. Vehicle has been inspected three separate times by Friendly Ford of Las Vegas at 660 N. Decatur Blvd., Las Vegas, NV 89107. Do not feel safe driving t

The contact owns a 2017 Ford F-350. The contact stated that while hauling a trailer and reversing, the powered tailgate erroneously opened and struck the trailer. During the failure, the tailgate and the trailer were damaged. The cause of the failure was not yet determined. The manufacturer and local dealer were not notified of the failure. The VIN was not available. The failure mileage was 103,000.

On Aug 25, 2021, my son took the truck to Crestview Ford in Crestview, FL with 32k miles on it. The Fuel filter on the engine was spraying diesel from a crack in the housing - Have a video and service records available for review. Crestview Ford replaced the fuel filter housing. On Oct 22, 2021, He was traveling to the Stark Fl area with a 4-wheeler in the back of the truck. He started smelling diesel really bad and pulled over and when he stepped out the steps were covered in diesel. When he pulled the hood release the engine compartment flamed up and filled the cab with smoke. He stepped away and called 911. The truck burned to the ground. I have pictures and fire department report available for review (see attached file). The truck had approximately 44k miles. My research has shown that this is a common problem in 2017 + super duty Ford diesel trucks.

Truck has was is called a DEATH WOBBLE. At highway speeds the steering will vibrate violently after crossing an expansion joint or bump in the road. Braking or rapid slow down will resolve the shaking. The issue seems to be getting worse. The truck was taken to the dealership for repair. The repair will cost several hundred dollars and not covered by the warranty. the mileage of the truck is 80,112 and is 90% highway miles.

Ford claims fuel was contaminated and redid whole fuel system when in fact I have read and was told by my mechanic that the lining in the fuel tank was flaking off due to new diesel Ford was aware of this problem and is making lots of money replacing the whole fuel system did not cover under warranty

Traveling down the road at or around 62 -65 mph and you hit a bump truck goes into a violent shake that can only be stopped by slowing down below 40 mph. You have to immediately start slowing down, and it there is someone following that isn’t paying attention it going to get us rear ended on the highway. The truck has 54,000 miles on it. Ford should own the problem.

Death Wobble started to occur around August 2021. No prior incidents. After the first time it would continue to happen anytime driving between 45-60 MPH and hitting a bump in the road. Once you found a bump that would trigger the death wobble, you could EASILY recreate the problem. Once the death wobble starts you have to slow down to 5-10 MPH before it’ll quit. During the wobble it is IMPOSSIBLE to control the vehicle as the steering wheel shakes violently and it feels like all wheels are bouncing opposite of one another creating a very scary and violent situation. I had a repair shop go in and replace anything that could be related and had 2 different alignment shops look into the problem. Ultimately nothing solves the issue.

The contact owns a 2017 Ford F-350. The contact stated that while driving at highway speeds, the vehicle experienced a death wobble. The contact took the vehicle to the dealer for wheel balancing and alignment; however, the failure persisted. The contact returned the vehicle to the dealer who diagnosed that the front stabilizer and the drag links needed to be replaced. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 36,000.

There was a recall, NHTSA Recall 19V864, for an "unintended tailgate opening" when the electrical parts became wet. I had the recall performed, but the tailgate continues to fall when water gets in the tailgate. Ford needs to readdress this issue to replace the tailgate from an electrically operated to a manual tailgate. I had to start securing the tailgate with a device to keep it from falling down, especially when towing my RV. I am afraid it would have fallen down damaging it just like it did when I was towing my Son's RV causing over $600 damage to the RV cargo doors and damaging the Truck's tailgate. The tailgate has fallen down at least five (5) times since the recall repair. Last one was today during a thunderstorm. The truck was sitting still, other times driving down the road.

Back-UP and 360 degree cameras have failed and are malfunctioning. They have been replaced twice and safety issue still exists. The cameras are foggy and especially at night and are not very clear. Safety hazard has occurred on several occasions where a child, person or object behind the vehicle are not clearly seen. There is a safety recall for 2019 super duty trucks but not for the 2017 models. This safety issue is very common according to internet searches and several vehicles all have the same issues and concerns. God forbid that a child or person is hurt because of the low visibility of these cameras. It is not only the back-up rearview camera but all of the cameras that are part of the 360 degree view of visibility. The side cameras as well as the forward facing camera all have the same issue. Ford should recall and remedy this issue before anyone gets hurt or killed if it hasn't already happened because of this issue.

Ford trucks have a known issue of cameras fogging up with condensation. Becomes very difficult to see where you’re backing into. The condensation gets so bad you can’t see at all sometimes. These trucks are big and need the cameras to assist in and out of tight spaces or keep you from rolling over something without knowing it.

The contact owns a 2017 Ford F-350. The contact stated while driving approximately 15 MPH, the tailgate fell. The contact indicated there was no warning prior to the tailgate falling on several occasions. The contact also stated the four rear outer aluminum rims were constantly allowing the tires to lose air pressure. There were no warning lights illuminated. The vehicle was taken to the local dealer and diagnosed tailgate failure was confirmed. The dealer repaired the tailgate; however, the failure recurred. The manufacturer was notified of the failure. The approximate failure mileage was 10,000.

When hitting bumps around 50 mph the vehicle front end begins to shake violently and a sudden slow down or stop is required.

Squirrel/Rodent damage. Fuel vent tube eaten, had to replace fuel tank

Restricted CCV Separator causing excessive crankcase pressure buildup. 2017-2019 models of this engine have this CCV design, but the Crankcase Oil Separator (containing this part) was redesigned from 2020 forward for the same engine due to excessive complaints of buildup and costly secondary effects such as Charge Air Cooling Tube splits/failures. This modification was never offered to 2017-2019 model year vehicles with this engine. Servicing Dealer indicated that this failure, and secondary failures led to loss of engine oil, which leads to catastrophic engine failure while driving. There are no indications via OBD codes or dash warnings indicating there is an issue, giving a false sense of security to the driver, especially when towing large loads. This problem was discovered on this vehicle during a routine oil change when low engine oil was observed (less than 2 quarts out of 13 quart capacity present in the engine upon attempting to drain).

2017 FORD F-350. CONSUMER WRITES IN REGARD TO VEHICLE SHAKING WHEN HITTING A BUMP IN THE ROADWAY. THE CONSUMER STATED THE VEHICLE WAS REPAIRED ON MULTIPLE OCCASIONS, BUT THE FAILURE RECURRED. THE CONSUMER REQUESTED ASSISTANCE ON DISCOVERING WHAT WAS THE CAUSE OF THE FAILURE.

That the intersection of 1010 and Rhodes Road 6204 Ten-Ten Rd, Apex, NC 27539.. I have been driving it and steady crossing my fingers hoping to God my tires don’t fly off and hurt somebody or kill somebody or me… I just can’t do it anymore, I have got to get the thing in the shop it’s got the death wobble and is just starting to scare me.. I love my truck I was trying to give them the benefit of the doubt but it’s definitely got a problem I honestly think it may be several different things but at any rate it needs to be fixed

After completing the tailgate recall, the vehicle tailgate opens while vehicle is in drive. There is no indicator on the dash for the tailgate being open, and also when you put the truck in reverse with tailgate open the camera defaults to the tailgate camera which stares at the bumper and is unsafe. I was towing a trailer during the last event and the tailgate was crushed between the trailer and truck causing around $5000 in damage. Also some items fell out of the bed on the highway.

Sunday, April 3, 2021, I was driving from Rte 95 to Rte 128 and the 2 lanes began to merge, but as I was driving the truck hit a bump and I got the death wobble. I had to come to, almost, a complete stop on the highway, with another car coming in behind me. I got through this one, but as I was beginning to accelerate onto Rte 128, the truck began once again to shake violently. It did happen again during this one trip. This also happened 2 other times, in March. Our mechanic replaced tie rod end-right lower outer and steering stabilizer on, Thursday, March 31, 2021.

Purchase the truck used from a Ford dealership February 15, 2022 w/39K miles that came with Blue Oval Certified Gold warranty that had an instant inspection. Took delivery February 25 was a online purchase. A week later March 5 driving thru a construction zone at 55MHP at high volume traffic and right front tire hit a high spot of the interstate in the right lane and the trucks steering wheel went into a valent movement/shaking left and right that it was so difficult for me to hold on the steering wheel. This death wobble didn't stop till I was able to exit the interstate at a 40MPH speed. Its obvious the previous owner didn't address this issue. Thank God I was driving because my wife wouldn't been able to hold on the steering wheel as it was purchase to tow our 5th wheel camper. It fears us now towing the camper safety. It's unbelievable Ford never issue a recall for this issue. Its obvious someone must lose a life before a recall is issued.

My truck started to have a death wobble.

I have experienced the very common problem of Death Wobble several times. Uncontrollable shaking of the steering wheel.

March 1st 2022 driving at highway speed on Rt 495 S in Massachusetts truck suddenly began to violently shake front end side to side. I was forced to brake, slow down till shaking stopped. Luckily cars behind me and to my right side were able to avoid hitting me. I pulled off highway and checked for something broken or loose. In forward and reverse I couldn’t find anything obvious. Will take my truck to shop today to have front end checked. During violent shaking it was all I could do to hang onto the steering wheel. If I’d only been using one hand who knows what would have happened.

Ford Death Wobble occurs at highway speed when hitting a bump in road. Vehicle is uncontrollable until reducing speed below 45MPH.

I experienced a “Death Wobble” several times .Ford freelanced my ball joint on right side. When the issue began again Ford replaced my stabilizer bar. It happened again so I replaced both steer tires. Occasionally I still get a wobbly when I hit a rough spot in the road way.