2020 Ford F-250 SD complaints

The contact owns a 2020 Ford F-250. The contact stated while driving at undisclosed speeds, the transmission was shifting hard, and the vehicle was jerking. The failure recurred intermittently while the contact waited for the recall repair. The contact was notified of NHTSA Campaign Number: 22V256000 (Power Train) and the recall was repaired; however, the dealer notified the contact that the valve body in the transmission was failing. The failure recurred after the contact came to a stop, and the vehicle shifted hard from tenth gear to first gear. The maintenance required message was displayed. The vehicle was restarted, and the vehicle was taken to the dealer where the valve body was replaced; however, the vehicle was diagnosed with a clutch pack failure. The vehicle was not repaired. The failure mileage was approximately 105,000.

Malfunctioning component is transmission safety has been affected by hesitation in shifting during normal driving, no catastrophic failure yet though vehicle has been inspected by dealership no warning lamps or DTCs issues are ongoing and stated this is "normal" for this transmission (was not an issue the first 65000 miles)

Truck turned off while driving on freeway and would not turn on was told it was battery replaced it did not fix it turn off while pulling trailer took it back to dealer after further search thwy foumd a bulletin and its a fuse box that gets corroded not properly sealed moister gets in and causes problem a safety problem people can wreck you from behined or catch on fire for electrical short in fuse box.

Intake Manifold failure. 2/5

The contact owned a 2020 Ford F-250. The contact stated that while driving at an undisclosed speed, the vehicle entered LIMP Mode, and inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the CP4 fuel pump and informed the contact that there was rust on the fuel pump because of water damage, even though the water sensor failed to detect the presence of water within the fuel system. The vehicle was repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 89,000.

The transmission went out at 115000 miles. There is metal all in the pan and damaged the valve body. After valve body replaced the transmission still would not go into gear correctly and its an internal failure known to occur in the 10-speed 2020 10r140. This needs to be a recall.

Delayed shifting are not shifting at all they reset the transmission numerous times but still having the same issue. It’s all part of the adaptive learning transmission system that Ford has.

The contact's fiancé owns a 2020 Ford F-250. The contact stated while the driver was driving 70 MPH, the vehicle shut off inadvertently. The contact's fiancé was able to pull to the side of the road. The battery warning light was illuminated. The vehicle failed to restart and was towed to an independent mechanic, where it was diagnosed that the Bosch CP4 high pressure fuel injector pump had failed and there were metal shavings in the fuel filter, which caused the vehicle to stall. The vehicle was being repaired. The dealer was notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 100,000.

Component: Battery Junction box then affecting other parts. water intrusion into battery junction box affecting and shorting out other components. Items shorted out due to water in battery junction box include: Battery Junction Box itself, Left rear Blind Spot Monitor, Left rear Brake Light, Drivers seat control (shorted all seat heated components, All lumbar and massaging components fully inflated and would not deflate) , Windshield wiper motor shorted and stopped working, Rain sensor stopped working. Both Tow Mirrors would Randomly deploy to the furthest out position. Main Safety Concerns were Windshield Wiper Motor Stopped Working and Seat Randomly adjusting, Inflating, Deflating. Vehicle is currently at for dealership ( Sam Packs 5 star Ford Lewisville TX) who has diagnosed the issues. The only warning lamp was for the Driver Side BLIS when the incident would occur.

BUSHING SLIDING DOWN THE CDF CLUTCH HUB CAUSING FLUID PRESSURE TO BLEED BY ON SEALING RING CAUSING MULTIPLY/POTENTIAL PROBLEMS. VECHILE WAS INSPECTED BY FORD AFTER GOING IN FOR A RECALL THAT WAS ALREADY ON THE TRANSMITION DUE TO THE PLANETARY 4 ASSEMBLY AND THIS PROBLEM WAS FOUND. THE RECALL DIDN'T FAIL THIS PART DID AND PUT DEBRIS THROUGHOUT THE TRANSMITION. WHEN TAKEN IN, IT HAD A HARD SHIFT WHILE DRIVING AND WHILE PUTTING IT IN GEAR. TRUCK HAS 98,500 MILES, BUT HAD BEEN DOING THIS FOR ABOUT 5 TO 6 MONTHS. FORD REQUIRED US TO DROP OF THE TRUCK FOR 4 TO 6 WEEKS BEFORE THEY WOULD LOOK AT IT. WE COULDN'T MAKE AN APPOINTMENT FOR THE RECALL.

[XXX] watch?v=4QLrqlCd3c0 * This video is about the South Texas taillight theft rings that local Ford Dealers are aware of and not notifying the customers to protect their property. The Tail lights only take 30 to 45 seconds to steal and cost between $3,500.00 to $4,200.00 to buy plus install and coding. They are in shortage according to local Ford dealer because of the thefts. So, you have to go out to Facebook Market Place and buy your lights back from a host of characters reselling these lights. The consumers are out a lot of money and time dealing with , body shop, insurance company, and a host of characters. It's the next Ford part theft ring that cost folks money they cannot spare ....This is BS Ford Motor and Dealers!!!!!. The thieves easily bypass the alarm because of Ford's design that allows tailgate to be open from inside after easily removing inspection cover (4 screws) and remove the lights in 30 seconds (two screws per tail light). The theft of the Tail Lights makes the truck undriveable. The Ford Light Theft is so bad that there are a shortage of lights and Body Shop long lead-times if you try and order and install through Ford Body Shop. Could be all corrected if factory alarm would go off when tail gate drops after being set and using $10.00 worth of anti theft screws. Ford is not notifying F150/f250 customers when they know this is happening. Cost to consumer $4,500 to $5,000.00 and months of waiting for your truck. The thieves are advertising the lights on

The truck slips out of gear for no reason, suffers very hard shifts causing the truck to jerk, and skips gears making it impossible to drive safely. Also, I lost power on the freeway several times and the truck would up shift and down shift erratically causing issues maintaining speed in traffic. I took the truck to the Ford dealer and was told I needed a new transmission. Ford has issued a recall for the Diesel truck with this transmission but refuses to repair other trucks with the same faulty transmission. This truck costs almost $60,000 new, was built in January 2020 with a faulty and dangerous transmission but ford is refusing to help their customers.

Electronic tailgate release has stopped working in a similar manner as my 2018 F150 which was recalled.

Transmission failed after 106k miles, incurring $7k of repair costs. The failure caused the vehicle to seriously hesitate and could have resulted in an unexpected slow down while driving. There was no warning ahead of time outside slight hesitation on accelerating which my auto repair shop determined was spark plug related. Then suddenly when driving my son home from a friends house the check engine light came on and hesitation was significant on 12/23/23. There are several bulletins regarding the 10 speed transmission in Ford Trucks and Expeditions, I've owned several Ford Trucks in the past and never had a transmission fail after 100k miles, conveniently after the warranty. These trucks should go 150-200k before having major mechanical issues. Ford will not recognize the issue and do the right thing ie: a full recall.

The contact owns a 2020 Ford F-250. The contact stated that after turning the ignition switch to the off position and removing the ignition key, the engine remained running. Additionally, the maintenance wrench icon illuminated, and the warning message "Reduced Power Mode" was displayed. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 50,000.

The contact owns a 2020 Ford F-250. The contact stated that while reversing, he became aware that the rearview camera displayed a blurred image, severely compromising the back-over prevention system. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

Driving on the interstate at speed limit after hitting a bump the driving straight the truck began to shake or ocellate violently to the point I did not have full control of the vehicle. Almost forced me off the pavement. THis is a known problem known by Ford but they are not going to recall it becuse no one has died YET! [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Mirrors are extending out while driving and will not return. Causing unsafe driving conditions.

The contact owns a 2020 Ford F-250. The contact stated while driving at various speeds, the vehicle shuddered from the front end to the rear end. The contact stated that the failure diminished while decelerating. The contact was able to continue driving. The contact stated while driving 70 MPH, the failure recurred increasingly. The contact stated that the failure decreased while decelerating, and he was able to continue driving. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 38,000.

The contact owned a 2020 Ford F-250. The contact stated that while driving 63 MPH, several warning chimes and alarms began to sound off and the warning message stating, "Traction Control Failure," had illuminated. At the same time, the steering wheel had suddenly seized which caused the vehicle to veer off the side of the road and further into the woods. The contact was unsure of how the vehicle came to a stop due to being knocked unconscious during the incident. Due to injuries, the contact was unable to recall details. The air bags failed to deploy. The contact received head, back, and leg injuries The vehicle was towed and totaled. There was a police report filed. The vehicle had not been taken to the dealer, diagnosed, or repaired. The manufacturer had been made aware of the failure and opened a case regarding the failure. The approximate failure mileage was 66,000.

The contact owns a 2020 Ford F-250. The contact stated that while driving at 60 MPH, the vehicle began to shake violently. The contact was able to safely pull to the shoulder of the roadway. After restarting the vehicle, it returned to normal functionality but has since become a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who determined the tie rods and ball joints were loose. The vehicle was not repaired. After investigating the failure, the contact related it to Customer Satisfaction Program 20N04, but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA hotline for assistance. The failure mileage was 51,000.

The contact owns a 2020 Ford F-250. The contact stated while attempting to reverse out of a parking space, the rear-view camera display was foggy or displayed a distorted image. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin: 22S51, but the vehicle was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 10.

Was driving on the highway when my truck(2020 f250) dash lit up, steering got extremely heavy, no abs, no drive modes, lost of collision emergency braking, lost all trailering functions, lost auto 4 wheel drive, hill assist, hill decline assist while hauling 10,00lbs. Ran diagnostics and it appear to be a wheels speed sensor. However, it went away and is now an intermittent issue. I understand parts fail on a truck but I am extremely concerned that I lost all of my safety features as well as all my towing features while towing on a highway, yet the truck still drives. I couldn't imagine towing max capacity (22,500lbs) and losing all those functions, it would almost guarantee a crash. How can a vehicle this new be rendered useless with a small sensor malfunction and continue to drive.

The contact owns a 2020 Ford F-250. The contact received notification of Recall 22E-004, after which the vehicle was repaired. The contact stated that while driving at an undisclosed speed and towing a camper, he became aware that the vehicle had lost significant motive power and was struggling to tow as expected. No warning lights were illuminated. The vehicle was taken back to the dealer, who advised that the vehicle had been reprogrammed according to Ford's specifications. The vehicle was not repaired. The manufacturer was notified of the failure but was unable to assist. The failure mileage was 8,000.

The contact owns a 2020 Ford F-250. The contact stated that while driving up a slight incline and pulling a trailer a burning type odor was suddenly present inside the cabin and the check engine light had flashed on before the vehicle began to lose power and stalled. After lifting the hood smoke and flames were present coming from the engine compartment. The contact attempted to extinguish the flames using a fire extinguisher but was unsuccessful and the flames intensified and began to spread to the cabin of the vehicle. Eventually the vehicle was completely destroyed from the flames. A fire report was taken at the scene and the vehicle was towed away. A police report was not taken. The cause of the failure was not determined. The local dealer was notified of the incident. The contact also indicated that a motorist observed fuel leaking from under the vehicle prior to the incident. The failure mileage was 28,000.

My blind spot cross traffic system alert activates and deactivates on its on and warning of electrical issues post to my Ford App. Air Bag warning comes on send message to Ford App stating Air bag not functioning due to electrical issues. Alarm goes off multiple times throughout the day sending messages to Ford App stating Hood Open when hood is not open and some messages state electrical issues.

You are driving and when the transmission goes to change gears it has like a dead spot in it an hesitates sometimes a couple seconds sometimes a little longer but it could cause you yo get rear ended then it will kick in real rough and go . There are recalls on the ford trucks transmission but not for my year of truck but its the same transmission the 10 speed and its doing the exact say thing as the complaints in the recall. I took it up around two months after i bought it and they told me this is how these trucks shift that is not correct at all . My warranty has just ran out and ford does not want to stand behind it. They should be made to cover any truck with this transmission in it just not certain trucks .

About a year after I purchased the truck, the transmission started shifting extremely hard on occasion making a loud bang and the truck lunges on the shift. The truck shifts so hard on occasions that it sounds like it could explode. Transmission failure could cause numerous safety issues for myself, passengers and other drivers; flying parts sudden stop and/or loss of control while driving to mention a few. I have mentioned the shifting problem on at least two occasions when the truck has been at a Ford dealership for regular maintenance but I was told it not shift hard for them and that nothing is wrong with it. I am 71 years old and worked on vehicles all my life and the occasional extremely hard shifting is not normal and is an indicator to me that something is not right. No warning lights come on prior to, during or after the hard shift to my knowledge. I have read numerous complaints by other F250 owners, recalls to repair Gen 1 trannys and in a lot of instances the Gen1 transmission was replaced with Gen 2. I would prefer a “new” transmission. Thank you.

The contact owns a 2020 Ford F-250. The contact stated that while using the remote key fob to unlock the doors, the doors failed to unlock. The contact had to manually unlock the doors. The contact then stated that the electrical system started malfunctioning and the A/C unit, the radio, and the Blind Spot Monitoring (BSM) light failed to operate as designed. The vehicle was taken to the dealer where the technician noticed that the rear passenger’s side taillight was filled with 3-inches of water. Additionally, the bliss module was corroded due to the water intrusion. The contact was informed that the tail lamp seal and the taillight assembly needed to be replaced. The water was drained; however, the vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 51,997.

My truck engine does not start after idling in the driveway. The gauges have power, but there is a no crank/no start situation. I used an OBD reader, and there is no communication with the computer. I researched recalls for similar vehicles, and there was a battery junction box recall on several VIN characters, but not mine, I believe this is a larger problem that affects more characters than what is currently listed. My truck is currently in the repair shop at ukiah Ford.

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V256000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Evaporator purge valve Ford part number LC3Z-9B325-A. It has been changed by local Ford dealer once, inspected twice more in a 7 month period by the same dealer. Causing erratic idle and engine pause during accelerating. Engine warning light repeatedly appears, during dealer inspection, dealer reports passing test and turns engine warning light off.

The contact owns a 2020 Ford F-250. The contact stated that on several occasions while driving at speeds over 45 MPH, the vehicle experienced the death wobble with several unknown warning lights illuminated. The vehicle was taken to a local dealer, where it was diagnosed that an unknown cable needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the dealer, where it was diagnosed that an alignment was needed and that the dual damper kit, drag link, and tie rod link needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.

The contact owns a 2020 Ford F-250. The contact stated that the rear-view camera was blurry, hazy, and cloudy. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The contact stated that the failure was related to NHTSA Campaign Number: 22V644000 (Back Over Prevention). The manufacturer was contacted and referred him to the NHTSA Hotline for assistance. The approximate failure mileage was 69,000.

I want to file a formal complaint against Sunland Ford in Victorville California about not remedying this safety recall for my vehicle in a timely manner. A letter was sent out to me on May of 2022 regarding this recall and I have contacted Sunland Ford several times to get this recall resolved and here we are almost a year later and it still hasn't been fixed. I was in snowy conditions in Montana in March and I just about wrecked because of the became inoperable for a short period of time so I need someone to please get Sunland Ford to hurry up and get this fixed asap.

Experienced “the death wobble” going 68 mph on a highway after hitting a small transition.

The clock spring in my truck has been replaced two times now and is now failed for a third time. I’ve heard from other owners, and they are also experiencing problems with their steering wheel clock springs.

There is a pinging noise coming from engine. Sounds like a loud lifter(s)

Traveling on the highway when I would hit rough road or potholes the front end would shake violently enough to scare me, like the front end was loose. I did not lose control, but it was at the point where I thought I could. I have never felt anything like it. After doing some research and finding many others with the same issue enough that the common name for it was the Ford "Death Wobble"! My Pickup is an F250 2020 with 60000 miles on it should not have that problem this soon. But in my research, I found that it was happening as low as 20,000 miles and that the repairs would only hold for about 25,000 miles. To verify I took it into the local Ford dealership who did a diagnostic check up on it and said the drag links were shot. They said it was a common thing and that they replace several a week to the tune of about $1500 plus dollars.

While driving highway speed (approx. 65 MPH) on a paved Farm Market Road, the front end of the truck started vibrating so bad that I temporarily lost control of the truck. The vibration and bucking of the front end of the truck pulled me into the other lane but fortunately there was no oncoming traffic. I reduced my speed and pulled to the shoulder and examined my tires and undercarriage. Upon examination everything appeared to be intact and no damage was observed. There were no previous warnings or indications of an issue prior to the incident. I have since driven the truck approx.100 miles with no issues. This truck is well maintained and had no previous issues!

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V250000 (Visibility). The dealer was made aware of the issue and declined to perform the recall repair unless the windshield wiper arms were faulty. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Transmission locks rear wheels when it shifts 3rd to 4th gear nearly caused accident. Cannot get parts to repair for 6 months or more. Can on get a rebuild for $5500. Plus labor. I see hundreds of complaints on this transmission not good for an $85.000 truck VERY UNSAFE

Transmission stuck in 7th gear three times. Transmission failed and is not fixable. Transmission has to be replaced. Ford has several recalls on the transmission but my truck doesn’t fall under the VIN recall list.

Purchased this truck used on 2/18/23. Test drove with no problems. Drove home 80 miles with no problems. Drove around home 30 miles with no problems. This morning 2/20/23 I drove the truck to work and just a few miles from home while traveling approximately 55 m.p.h. the front end of the vehicle started shaking violently, and I had to apply braking and almost come to a stop before it stopped. Once it stopped I continued to work, 30 miles away with no further issues. On the way home from work, I made it to near the same area where the shaking happened this morning and it occurred again, at around the same speed. A couple of hours later, I drove back over the same section of road and going away from home no issues, but coming back it happened again in approximately the same location that it had returning from work. I returned home picked up my wife and it did not occur in this spot going either direction, but we continued up the road after passing our home and turned onto another somewhat rough road. After about a mile it occurred for the forth time in this one day. My wife was very frightened. No warning lamps were lit, and the vehicle has not been in for service yet since this is only my second day driving the vehicle, which only has 8 months of warranty left.

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V250000 (Visibility) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The VIN was unavailable.

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V256000 (Power Train) however, the parts for the repair were unavailable. The dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that while driving at various speeds, the vehicle would hesitate and jerk upon the depression of the accelerator pedal without warning. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The failure mileage was approximately 62,000. VIN tool confirms parts not available.

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V250000 (Visibility) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the driver's side windshield wiper failed to operate and then detached. The dealer was made aware of the failure but confirmed that parts were not yet available. Mac Haik Ford Lincoln (7201S I-35 Frontage Rd, Georgetown, TX 78626) was also made aware of the failure and scheduled an upcoming appointment. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 25,800. Parts distribution disconnect.

The contact owns a 2020 Ford F-250. The contact stated while driving approximately 55 MPH, the vehicle experienced a death wobble. The front-end of the vehicle was shaking uncontrollably. The contact pulled over and regained control of the vehicle. There were no warning lights illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not contacted about the failure. The failure mileage was approximately 24,000.

The contact owns a 2020 Ford F-250. The contact stated while driving 70 MPH, the vehicle experienced hard shifts while jerking. There was no warning light illuminated. The contact slowed down until the failure ceased. The contact then resumed normal driving. The contact stated that the failure had been reoccurring while driving at various speeds. The dealer was notified of the failure and informed the contact that the VIN was not included in NHTSA Campaign Number: 22V256000 (Power Train). The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 140,000.

While driving on the highway at approximately 70 mph the truck's check engine light came on followed by a message "reduced power" on the dash cluster. The truck shut off almost instantly after this.