2017 Ford F-250 SD complaints

The contact owns a 2017 Ford F-250. The contact stated while driving 65 MPH and hauling two horses in a horse trailer, the vehicle stalled inadvertently. The contact was able to pull over to the side of the road, where the check engine warning light illuminated, and the message "Reduced Engine Power" was displayed. The vehicle failed to restart and was towed to Lee’s Body Shop, where it was diagnosed that the CP4 fuel module had failed. The autobody repair shop recommended that the CP4 fuel module, the fuel lines, and the particulate filter be replaced. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a related recall. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was unavailable.

The Fuel Pump Failed , yes it is available for inspection upon request. Truck cut off in middle of busy road way , unable to move to shoulder creating a high risk to be hit or someone to be hit . Independent service center diagnosed was made aware this is a common problem . No warning lights or previous symptoms before engine cut off . We have been informed this is a recurring issue with Ford F250 creating a dangerous enviorment when driving for the driver and all other vehicles on the road .

While driving I made a left hand turn and when straightening the steering wheel it was 90 degrees out of alignment which caused the truck to steer to the right almost striking another vehicle. The dash had a warning message come on stating adaptive steering fault service required. I have taken it in for service and the steering wheel needs replaced which is a recall on some ford super duty’s the same year but this one was not included

Driver door will not latch Door could swing open while driving

⁠The contact owns a 2017 Ford F-250. The contact stated while driving at approximately 40 MPH, the vehicle lost automotive power. The contact related the failure with Manufacturer Campaign Number: 21m01. The contact stated that the dense sensor indicated diesel emission fluid was full when it was not. The check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with a reductant level sensor failure. The local dealer was contacted; however, the vehicle was not repaired due to costs. The contact stated that the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 108,000.

Uncontrollable shaking wobble in steering known as death wobble.

I was on the freeway and doing about 70 and I hit some bumps in the road and my vehicle started to violently shake and I was unable to control my vehicle. I had to hit the breaks and slow down to regain control of my vehicle. This the second time this has happened. Vehicle was repaired about 2 years ago for the same thing. Ford repaired the damper steering linkage last time this incident happened. AKA DEATH WOBBLE.

2017 f250 death wobble when I hit a small bump on the interstate

2 years ago both batteries needed replacement on my 2017 diesel f250. I noticed passenger positive battery cable at battery had a large amount of what I can only describe as large amount of gray cottage cheese on the passenger positive battery connector and cable. Dealer suggested a wire new battery cable which is actually a wiring harness ($2300) if they could not repair the issue. Luckily they were able to clean the cable connector and down the cable which was also affected. They also treated the cable and connector so it would not corrode further. Unfortunately the design of the cable is flawed as approximately 1 to 2 inches of bare cable before the connector is exposed without the red rubber coating to the battery gasses which causes the corrosion to travel down the cable/harness. During the last 2 years I monitored the cables for corrosion and they have held up well with no corrosion. Recently I noticed starting becoming a little sluggish plus I got an alert that said Adaptive Steering Fault Service Required. This also caused the steering wheel to turn to the left to the 10 o’clock position when going straight. Noticed on google that voltage could affect the adaptive steering component. Assuming my batteries need replaced luckily under warranty the dealer inspected the truck. Their verdict so far is that I need a new Positive Battery Cable Wire Harness at an outrageous cost of $4596.59! A price increase of $2296 in 2 years. They also want to charge $465.88 to diagnose th

After driving for a short distance in my 2017 F250 Diesel (75k miles) I pulled into a store. Turned off truck. Upon return and starting truck I got a dash alert that said Adaptive Steering Fault Service Required. When I began to drive I noticed my steering wheel was turned left to the 10 o’clock position while driving straight down the road. I drove to the dealer as I felt my batteries were sluggish at starting and needed both replaced. Luckily batteries were covered but dealer said I need new Battery Cable Harness for $4596.59! I did some research and found the Adaptive Steering Fault is a known issue with several people as is the Battery Cable Harness. I also read where a voltage issue can cause the Adaptive Steering Fault alert which is why I mention the wire harness. I’ve also known others with the battery cable issue and there is a recall on other years not mine. The dealer wants $465.88 just to diagnose the adaptive steering so who knows what cost would be to replace at this point. This all is extremely dangerous as I don’t know if the adaptive steering controls will decide to start working and adjust my steering while driving causing an accident. There have been recalls on both issues but not my model and year. Truck is currently at dealer and I filed complaint with Ford Consumer to no resolution at this point.

The contact owns a 2017 Ford F-250. The contact stated that while his son was operating the vehicle, the check engine warning light was illuminated. The vehicle was taken to an unknown local dealer, where the engine sensor was replaced, but the failure later reoccurred. No further information was available. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 74,000.

1 .Driver's side door will not close in cold weather due to frozen actuator. TSB has been issued on this problem; Ford will not repair due to vehicle being out of warranty. 2. Backup/vehicle camera's do not always work when truck is in reverse. TSB has been issued on this problem; Ford will not repair due to vehicle being out of warranty. 3. Ford inadvertently installed a substantially smaller fuel tank on my specific vehicle. TSB has been issued on this problem; Ford will not repair due to vehicle being out of warranty.

The contact owns a 2017 Ford F-250. The contact stated that while driving at various speeds, the tailgate would unexpectedly open without warning, causing material to fall out of the vehicle. Additionally, the contact stated that the tailgate would fail to open when pressing the button on the key fob or when attempting to manually open the tailgate. Upon investigation, the contact discovered NHTSA Campaign Number: 19V864000 (LATCHES/LOCKS/LINKAGES) which was linked to the failure. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be serviced or repaired. The failure mileage was approximately 90,000.

The contact owns a 2017 Ford F-250. The contact stated while driving approximately 65 MPH, there was a sudden explosion, and the glass sunroof panel was ejected from the vehicle. The contact retrieved the sunroof from the road and the vehicle was later taken to the dealer. The cause of the failure was not determined. The vehicle was not yet repaired. The failure mileage was 116,000.

The contact owns a 2017 Ford F-250. The contact stated while driving 55 MPH, the transmission unexpectedly downshifted, and threw the contact forward. The contact then stated that the vehicle began to hesitate upon depression of the accelerator pedal with the “WRENCH” symbol displayed. The vehicle resumed normal operation soon after the initial failure; however, the failure returned as the contact drove up a driveway incline. The vehicle began to hesitate upon depression of the accelerator pedal before the contact was able to safely park the vehicle. The dealer was notified of the failure and the contact was informed that there were no recalls on the VIN for the failure. The vehicle was then taken to an independent mechanic where the vehicle was diagnosed with a defective lead frame. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 125,000.

The contact owns a 2017 Ford F-250. The contact stated that while driving at unknown speeds, the alarm system warning light was illuminated. The hood ajar message was displayed. The vehicle was taken to the local dealer, where it was diagnosed that the knock sensor and wiring harness needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 96,000.

On about Sep 23 on the afternoon I hit a pothole in the road and my back window fell out of the truck. The whole assembly that keeps the rear sliding window in place just failed.

The CP4 fuel pump began failing with the truck just over 100K miles. When taken in for routine service there were traces of metal shavings in my fuel. This is a widely known problem with the CP4 and is still being used in Ford trucks. The cost of repairs is substantial. The best case is you catch it early and it only costs between $3-6,000. If I had not caught this and the entire fuel system had been damaged, my local Ford dealership informed me it could cost close to $16,000. This is a devastating amount of money to pay for a well known issue in Ford trucks.

Death Wobble. Was driving speed limit of 65mph and vehicle started a violent, uncontrollable shuddering and bouncing movement to the left almost hitting the dividing wall on the interstate. I had little control over steering of vehicle and was barely able to avoid slamming into wall. Finally got vehicle stopped. Has happened before at lower speed. Has happened several times before with less violent shuddering after hitting bumps in roadway. Now understand how very dangerous and scary the less severe incidents have been after this latest incident!

The contact owns a 2017 Ford F-250. The contact stated while driving approximately 50-60 MPH and hauling a trailer, the vehicle drove across uneven pavement, and the vehicle went into the death wobble and the vehicle became difficult to steer. The contact pulled over to the side of the road but found no cause for the failure. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the steering dampener had failed and needed to be replaced. The steering dampener was replaced. The dealer confirmed that the vehicle had been repaired under Customer Satisfaction Program: 20N04 (Steering, Equipment) but the VIN was not included. The manufacturer was made aware of the failure and confirmed that the VIN was not included the Customer Satisfaction Program. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 78,699.

I hit a small bump at around 45mph and my truck began shaking violently. I was unable to control the truck and had to come to a complete stop. They call it the death wobble. It truely was frightening and I could have killed someone..

The contact owns a 2017 Ford F-250. The contact stated while driving approximately 65 MPH, the transmission unexpectedly downshifted from six gear to first gear, causing the vehicle to abruptly decelerate, causing the driver to almost lose control of the steering wheel. The vehicle was later examined by an independent mechanic who diagnosed and determined that the power train control module needed to be reprogrammed. The power train control module was reprogrammed, and the vehicle operated normally. The manufacturer was notified of the failure, but no assistance was provided. The local dealer was not contacted. The failure mileage was 102,900.

Doors will not lock or unlock from remote or inside switch. If an accident was to occure a person's can not get out of the vehicle.

The contact owns a 2017 Ford F-250. The contact stated that several attempts were needed to start the vehicle. The failure occurred intermittently. The check engine warning light was illuminated. The contact learned that it was a known failure; however, there was no recall for the failure. The vehicle had not been taken to the dealer to be diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not under recall. The manufacturer had referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 140,000.

The contact owns a 2017 Ford F-250. The contact stated that while driving over a bump at various speeds, the vehicle experienced the death wobble. The failure caused the front of the vehicle to shake uncontrollably, causing the contact to temporarily lose control of the vehicle. Recently, the contact was notified of Customer Satisfaction Program: 20N04 (Steering Linkage Damper Extended Coverage). The dealer and the manufacturer were notified of the failure but offered no assistance with the repair. The vehicle was not repaired. The failure mileage was approximately 12,000.

The contact owns a 2017 Ford F-250. The contact stated while driving 55 MPH, the vehicle unexpectedly downshifted to first gear and then resumed functionality. There was no warning light illuminated. The contact stated that the failure recurred while driving on several occasions. The vehicle was taken to the dealer, where it was diagnosed that the lead frame had failed and needed to be replaced; however, the part to repair the vehicle was on backorder. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under recall nor warranty. The failure mileage was approximately 64,000.

The contact owns a 2017 Ford F-250. The contact stated that after driving approximately 50-65 MPH and pulling into a business parking lot, the contact became aware that there was a trail of fuel on the ground. The contact inspected the vehicle and became aware of fuel leaking underneath the front of the vehicle between the tires. The contact drove to the nearest independent mechanic, where it was diagnosed that the upper fuel filter had fractured and was leaking. The mechanic replaced the fuel filters, and the vehicle was repaired. The dealer was not contacted. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 136,942.

The contact's son owns a 2017 Ford F-250. The contact stated that while her son was driving at an undisclosed speed, the vehicle made an abnormally loud sound. There was engine oil leaking onto the ground, and unknown engine parts had detached and fallen to the ground. The vehicle then lost motive power. The contact's son coasted the vehicle to the side of the road and called the contact. The contact and her husband arrived at the scene and towed the vehicle to the son's workplace. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was opened. The contact was advised to file a complaint with the NHTSA Hotline. The failure mileage was approximately 30,000.

The hose connecting to the fuel filter in the engine compartment came off and dump fuel all over the engine. Luckily we turned it off before a fire started. This has happened 3 times now.

I have been made aware of the probe involving 2015-2021 Ford Super Duty pickups where the fuel filter housing and fuel lines have cracked. I wanted to make you aware that in November 2023, my vehicle suffered the same part failure. Park Ford in Tallmadge Ohio did the repair and I paid for it out of pocket. It was significant and I had diesel fluid leaking profusely. My vehicle is a 2017 Ford F-250 with the diesel engine and at that time only had approximately 50,000 miles on it. I thought it was odd that this part failed. I see it may not have been an isolated occurrence. I wanted to add my complaint to those being investigated by your agency.

Driving down the freeway at 65 mph, hit a small pot hole with the right front tire, which caused the front end the shake back-and-forth uncontrollably. I was able to pull over, and upon slowing down the wobbling stopped and we were able to proceed with our drive. We could have hit other vehicles on the road if anyone had been near us. We also could have been thrown off the road. No inspections have been done and no warnings have occurred.

This is the third time i have had to tow this vehicle in less than a year and half for a Long Crank no start. The fixed a melted wiring harness the first time. Second time couldn't tell me what the problem was but got it running and then now its back at the dealership again for the same problem.

The contact owns a 2017 Ford F-250. The contact stated while driving at an undisclosed speed, the back over prevention camera displayed a black screen. In addition, the back over prevention screen displayed an unknown error message. The contact stated that the failure occurred intermittently. The vehicle was taken to the dealer where it was diagnosed with a failed back over prevention camera and faulty wiring. The contact was informed that the wiring and back over prevention camera needed to be replaced. The vehicle was being repaired. The manufacturer was not made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 75,000.

My truck has the Death Wobble . It has been worked on for the incident It happened again yesterday at least 4 times within 30 minutes We turned around and came are parked the truck. Am going to talk to the Dealer where I Purchase the vehicle and want some answers and to fix this major problem with my Ford Superduty 250 2017

The contact owns a 2017 Ford F-250. The contact stated that the sunroof failed to close immediately as needed. After several attempts, the contact was able to close the sunroof while pressing the close button. The vehicle was taken to the dealer, where it was diagnosed that the sunroof and tracks needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 173,000.

The contact owns a 2017 Ford F-250. The contact stated while driving at an undisclosed speed, the vehicle failed to exceed 20 MPH, with the vehicle losing motive power. The contact stated that the gas light pump icon and the engine power reduced message were displayed. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the high-pressure fuel pump had imploded, resulting in metal being found in the fuel system. The mechanic stated that the fueling system needed to be replaced. The vehicle was not repaired. The dealer was contacted but no diagnostic test was performed. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 142,000.

THE FORWARD FACING CAMERA HAS BECOME CLOUDED. THIS PRECLUDES ME FROM SEEING DIRECTLY IN FRONT OF THE TRUCK WHEN PULLING OFF. THIS IS A SAFETY ISSUE FOR YOUNG CHILDREN AND ITEMS THAT MAY BE DIRECTLY IN FRONT OF THE TRUCK.

The contact owns a 2017 Ford F-250. The contact stated while driving 60 MPH, the vehicle shut off. The reduced engine power warning light was illuminated. The vehicle was towed to a dealer service center. The vehicle was diagnosed stating the fuel injectors needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 140,000.

I took my truck into the dealership Ford of Upland for recalls on [XXX] (136923 miles) outstanding field service actions [XXX], [XXX] , [XXX] , 21M05, [XXX] . I called to make an appointment and confirm if parts are needed for these recalls that they had them and nothing was on backorder. Cabral Lillian let me know they had everything the truck would be done in 1.5 days at most. About 2hours before they closed on day 2 i called to see when i could pickup. She told me they just started the [XXX] and it would be ready in one hour. When i went to pick up I was informed that was the only recall that they did. I asked why she said they did not have the other parts, i explained to her when i made the appointment she they had everything. She just said they would call me when they have the parts. I called a handful of times to check status of the parts , kept saying they dont have them. Finally i emailed Lillian [XXX] and [XXX] no reply. I went ahead and emailed all the main people in the service department [XXX] Steven Isip service director said he would look into this. All that happened was he had Lillian call me and said they had the camera [XXX] ) and i could make an appointment it would take 2 day to complete. My husband called citrus Ford to see if they could do the recalls. They set the appointment [XXX] ( 147665 miles) had it done same day. I didn't look over all the paperwork and didn't see that the other recalls were not addressed. Until [XXX] the tailgate opened on its own

Regarding customer satisfaction program 21M05. My tailgate has had numerous recalls for the electrical tailgate. I have been to two different dealerships and they have not fixed the recall now my truck has major electrical issues. The tailgate opens up all the time on its own. Something to do with the wiring system that's connected to that is making all my exterior lights and horn go off constantly. The truck is at the dealership down. They're trying to diagnose the electrical issues. They now want me to be responsible for a diagnosis if Ford will not cover it.

The cab roof clearance lights leak water when it rains. The water leaks into the electronics in the overhead console and down the A-pillar. Dealer advises it is a nonwarranty issue under extended warranty and a commonly known issue on these. trucks.

WHEN TEMPERATURE DROPS BELOW FREEZING MOISTURE GET IN DOOR PANELS AND FREEZES THE LOCKING SYSTEM SO THAT THE DOES WILL NOT STAY CLOSED, MAKING MY TRUCK UNSAFE TO DRIVE. THIS HAS HAPPENED MULTIPLE TIME WHEN ON THE ROAD WAS AFRAID FOR PASSENGER AND ANIMALS IN THE TRUCK.

The contact owns a 2017 Ford F-250. The contact stated that while driving at an undisclosed speed, the contact heard an abnormal ticking sound emanating from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the intake manifold. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 49,000.

The engine light activated on the dash randomly while driving. My truck was experiencing loss of power and for the next few days and reduced fuel mileage. I checked the engine code and learned it is a common error with 2017 Ford Super Dutys with the 6.7L diesel engine. The code is “DTC P203B”, sometimes indicated as P203B00 is an OBD diagnostic trouble code indicating a manufacturer-specific fault with the vehicle powertrain (i.e. engine and gearbox). This code identifies an error with the air/fuel mixture causing reductant level sensor circuit range/performance. I believe this error in manufacturing is a safety risk because it is common within these trucks and can leave motorists stranded or potentially disable the vehicle in the roadway causing a traffic hazard.

My truck has only 39806 miles. I ran over a rut on the expressway and the steering g wheel shook violently. I almost had to come to complete stop to stop it and continue driving.

Death Wobble at highway speed

Good afternoon, 1.5 weeks ago, we had 4 serious issues that our Ford F250 Truck from 2017 with 55.000 miles on stalled during driving almost causing an accident because the steering system was not supporting anymore. We stopped the vehicle on the side of the road, yellow engine light came on with the fault message “All sensor” (attached). After several times cycling the ignition the Diesel engine started up with the yellow engine light on. This happened 4x. Luckily, we made it home. The next day the truck did not show any ignition neither did the engine start. I checked the battery power which was 12.8V and found a loose minus bar connection beside the positive bar beside the battery junction box. I thought I found the root cause, installed the missing nut but nothing changed. We had to organize a tow truck for 160US$ transferring the vehicle to the Ford Dealer Mall of Georgia in Buford after confirming an appointment for Monday [XXX], 2024, [XXX]. We confirmed the complaint with a Ford Service technician name Scott Tackabury, left the keys under the assumption that Ford will investigate the root cause. Since this is our only vehicle, we had to take a rental car due to business obligations. Unfortunately, the truck got not inspected until [XXX], 2024. WE had to call several times to get an update and were told that “… it is like a doctor appointment… ur in line”!!?? Again [XXX] 2024, we did not receive a call, we had to call to see what’s going on. Investigation result: -IDS

Frozen door locks and latches. Door freezes in cold temperatures and when the door is opened the door locks freeze in the open position not allowing the doors to close and latch properly or at all.

My truck experienced death wobble during a recent trip multiple times on the interstate on our way home. With no warning, the truck started shaking violently at 70 mph. I had to immediately slow down in traffic and work my way over to the right lane. We stopped to confirm there was no tire issue or other notable visual problem before proceeding. It occurred again shortly after stopping and I had to do the same thing. We stopped again and found no visible issue, so we continued at a much slower pace. The truck wobbled a few more times but not as violently as the first two. There were no warning lights displayed.

The contact owns a 2017 Ford F-250. The contact stated that while driving approximately 50-55 MPH the steering wheel began aggressively shaking causing them to crash into another vehicle. The air bags did not deploy. Both the vehicles received damage to the driver-side view mirror. The vehicle was able to be driven from the scene. There were no warning lights illuminated. A police report was filed. There were no injuries and no medical attention was needed. The vehicle was taken to the dealer where it had not been diagnosed. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was 111,000.