2021 Ford F-150 complaints

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while the vehicle was idling, the engine shut off and the vehicle failed to restart. A mobile mechanic was called to the residence and diagnosed the vehicle with fuel pump failure. The vehicle was not yet repaired. The failure mileage was approximately 31,000.

Within the last 6 months, the driver's side front door, the driver's side rear passenger door, and the passenger side rear doors actuators stopped working and the doors do not lock. The doors do not lock manually with the key fob or lock automatically when the truck reaches 13 mph. This is a safety issue as passengers could inadvertently open the doors when driving when the doors should be locked. This also prevents the factory installed alarm to work properly. it seemed odd that the 3 actuators seem to stop working around the same time.

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted from fourth to first gear. There was no warning light illuminated. The contact pulled over and waited before restarting the vehicle. The contact stated that two days prior to the failure, a message was displayed indicating that an over-the-air software update was performed under NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The vehicle was taken to the dealer, who determined that an unknown sensor inside the transmission had damaged the transmission and that the unknown sensor needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 82,449.

Vehicle Information 2021 Ford F-150 XL Supercrew approximately 35,000 miles. While traveling southbound on [XXX] near [XXX], Ok, I was operating my 2021 Ford F-150 XL at approximately 75 mph with the cruise control engaged. As I approached slower traffic ahead, I attempted to disengage the cruise control by pressing the cruise control cancel/off button on the steering wheel. Despite pressing the button multiple times, the cruise control would not disengage. Same thing while tapping the brakes it would not disengage. The vehicle continued to maintain speed, and the cruise control system remained unresponsive to my commands. In response, I applied the brakes to safely reduce speed, I did not perform a panic stop or abrupt braking maneuver. Once I had the vehicle slowed, I moved safely onto the shoulder of the highway, well away from traffic. I then shifted the vehicle into park, shut off the engine, and restarted the truck. After restarting the vehicle, I elected not to use the cruise control system for the remainder of my trip, which lasted approximately eight additional hours to Houston, Texas, I have not used the cruise control since the incident because I am concerned that the condition could recur and create a safety hazard. No collision, property damage, or injuries occurred. However, the apparent failure of the cruise control system to disengage when commanded raises significant safety concerns and warrants investigation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF I

The contact owns a 2021 Ford F-150. The contact stated that the windshield wipers failed to activate as needed. No warning lights were illuminated. The local dealer was contacted; however, the vehicle was not diagnosed. The contact was informed that the VIN was not under recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact associated the failure with NHTSA Campaign Number: 22V842000 (VISIBILITY). The failure mileage was 97,000.

My 2021 F-150 has been diagnosed with a failed electric steering gear Code PSCM C1B00 49 2F. I understand there was a recall on some 2021 trucks with similar steering issues, although my VIN is not included. The part is on national backorder and my dealer says there are approximately 150 vehicles ahead of mine. This is a safety-related steering component, part number "ML3Z3504G"

I own a 2021 Ford F-150, VIN [XXX]. NHTSA recall 25V455 / Ford recall 25S75 affects my vehicle because of a potential fuel-pump failure that can cause loss of fuel pressure and an engine stall while driving. The recall was issued XXX, and my vehicle still shows an unrepaired recall with the remedy not yet available. I am concerned about the length of time that has passed without a repair being available for a safety-related defect that could cause the engine to stall while driving. I am requesting that NHTSA review the continued delay in providing a remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Adaptive cruise control, truck keeps trying to change from lane swerves left and right outnof control sometimes. Automatic Braking Rear camera did a reset after changing the battery and the 360 cameras alignment misaligned and truck send a message When placed on reverse , cameras are misaligned on the screen.

My vehicle was left rendered unable to steer during use. It was taken to a local shop All Japanse Auto, who found the damage was consistent with Ford Saftey Recall 21S28. Upon speaking to AutoFair Ford of Haverhill service they informed me Ford did not include my truck in the recall despite it matching year and model and they would not be addressing the issue for me. Loss of steering mid use is amazingly careless and should be cause for taking more aggressive action

Due to a dangerous design flaw in the 2021 Ford F150, I was put in a potentially dangerous situation by completely losing all power in the vehicle on a backroad. Design flaw is the DCN module, which floods into the vehicles electrical system/body of vehicle through the cowel drain that can supposedly be blocked by a singular piece of pine straw. Due to the design flaw, the vehicle completely lost all power and all electronics failed while driving down the road at 45 mph, putting both me and my father (riding passenger seat) in immediate danger. Ford knows and is aware of the design flaw and has refused to issue a recall, not only affecting my safety, but now I am going back and forth with ford over the fix to the tune of $2800 that they refuse to fix (vehicle is a gold certified cpo, has extended warranty). When asked how to prevent in the future, ford was and is not aware of how to prevent in the future, and I can not get to the cowel drain clog without professional equipment and ford performing. There is no way to tell the cowel drain is clogged or not, and there is not anything in the ford owners manual related to maintenance of the cowel drain. Again, due to the inappropriately designed drain, this caused water leakage into my truck, posing an immediate threat to my life and others around me. I have all of the videos and pictures needed to show the failure of the system to provide to move this forward to get resolved. I had complete loss of power and electronics on the ro

See attached document for complaint

I believe my vehicle is exhibiting the same transmission issues leading up to the failure of transmission components identified in NHTSA Recall #: 26V402. My vehicle is having hard downshifts at low speeds, usually between 3rd and 1st gear, while comping to a stop. It seems to happen randomly. My VIN number was not found to be in the effected vehicles when searching on the NHTSA Recall page.

The contact owns a 2021 Ford F-150 used for hauling a trailer. The contact stated that while reversing, the vehicle became stuck in neutral. The vehicle failed to shift into the intended gear. The contact stated that the gear selector was inoperable. The contact stated that the vehicle continued moving and rolled into the water and became submerged in water up to the door. No warning lights were illuminated. There was no injury sustained. The contact stated that the failure was associated with NHTSA Campaign Number: 26V402000 (Power Train). The vehicle was towed to the residence and then towed to the local dealer, and it was confirmed that there was no recall coverage on the VIN for the vehicle. The vehicle was not diagnosed or repaired. The vehicle was eventually towed back to the residence. The manufacturer was contacted and opened a case and confirmed that there was no recall coverage on the VIN for the failure. The failure mileage was approximately 60,000.

I received codes p2888, p288a, p0c2c all within the current recall parameters however my vin is not listed in the recall currently but falls within the same guidelines for those model years, engine, and trim package. It is the parking/pawl codes. I cannot currently drive my vehicle and I am about to face very heavy charges with getting a repair for my vehicle. As of now the Ford service writer at Platinum Ford North in Pilot Point, Texas has told me it is unsafe to drive and repairs will need to be made and that the repairs are currently not within any safety recalls for my specific VIN.

My truck is having transmission problem , hard shifting , going into neutral while driving, same problem with other 1080R transmission ford has on the recall list, I have had it in the shop before at Five Star Ford Stone Mtn Georgia, they said it was the battery, they put a new battery in it, same didnt fix the problem, now they are saying I need a new transmission , they know there is a problem with the 10 speed 1080R transmission, ford needs to recall all of these 10 speed transmission.

When backing up, the rear camera display shows a gray filter over the rear image on the display cluster and the right side warning sensors indicate a blue trapezoid on the cluster for the right side of the vehicle. The driver dashboard also has an alert that the rear brake assist feature is inactive

On June 20, 2026, my 2021 Ford F-150 5.0L V8 suddenly lost engine power while I was driving on the freeway. The vehicle became disabled and had to be towed. The vehicle was towed to an authorized Ford dealership on June 23, 2026, where it remains. The dealership inspected the vehicle and confirmed that it is affected by Ford Recall 25S75 / NHTSA Recall 25V455 and advised that there is currently no available repair or remedy for the fuel pump issue. Ford Customer Service has also opened a case regarding the vehicle and provided a loaner vehicle, but no repair or estimated date for a remedy has been provided. The sudden loss of engine power while traveling on the freeway created a significant safety hazard. The vehicle could no longer maintain normal speed or acceleration, creating a risk of being struck by other vehicles traveling at highway speeds and a risk to surrounding motorists. Ford's recall identifies this fuel pump issue as capable of causing an engine stall while driving. The vehicle remains at the Ford dealership and is available for inspection upon request. To my knowledge, it has not been inspected by police or an insurance representative. There were no known warning symptoms prior to the failure; the vehicle was operating normally until it suddenly lost engine power on June 20, 2026. The failure is particularly concerning because the recalled component appears to have failed in the exact manner described in the recall, leaving the vehicle disabled while driving.

I've noticed that the vehicle struggle when acceleration, specially at full stop (stoplight and intersection). Feels like the engine is going to die out if I step on gas pedal.

Daytime Running Light failure in headlight assembly. Second time it occurred. Had the first headlight assembly replaced while under warranty. I am now outside of the warranty mileage and the other side's headlight DRL has failed.

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and referred the contact to the NHTSA Hotline for assistance. The contact had not experienced a failure.

The contact's son owns a 2021 Ford F-150. The contact stated that after her son shifted from park(P) to drive(D), the vehicle failed to respond as needed. Several unknown warning lights were illuminated. The contact's son was able to drive to the residence nearby after several attempts. While at the residence, the failure recurred after shifting to drive(D), and the vehicle made an abnormal grinding sound. The vehicle was towed to an independent mechanic, and it was determined that the passenger’s side rear axle was fractured. The failure was associated with NHTSA Campaign Number: 23V896000 (Power Train). The vehicle was towed to a dealer, where the diagnosis was confirmed; however, parts were unavailable for the recall repair. The vehicle remained unrepaired, and no rental vehicle was provided. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 100,650.

My F150 10R80 transmission is throwing a P076F code. And the shifting has become very harsh and eratic all across the 10 gears. Hesitations, high revs, hard shifts, etc. This is a known issue by Ford and they have issued TSBs on the issue. They acknowledge that it is a design flaw within the transmission and have issued fixes. But if you are outside of the 60,000mi warranty, the burden of the costs falls on me, the owner. $9400 to replace the transmission with a new Ford transmission here in Colorado. This is a known problem in the design but Ford is not stepping up to help. They let the burden fall on the owner.

I have had this at the dealer for the recall 4 months with no fix insight

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Left side headlight went dark. Started dimming now is full out

The contact's son owns a 2021 Ford F-150. The contact stated that while the vehicle was parked, the owner attempted to start the vehicle; however, the vehicle failed to start. The owner replaced the battery, and the vehicle was towed to the dealer and was diagnosed with a fuel pump failure. The contact was informed that the fuel pump needed to be replaced. The contact was informed that parts were unavailable for the repair. Additionally, the owner was informed that the repair could be paid for out-of-pocket and a request for reimbursement could be made when parts became available. The owner declined to pay out of pocket for the repair. The vehicle was not repaired. The dealer requested that the vehicle be removed from the dealer lot. The vehicle was towed to an alternative dealer for storage because the vehicle was inoperable. The owner then received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The manufacturer was made aware of the failure, and two cases were filed. The failure mileage was approximately 66,000.

Electronic power steering rack failed. Vehicle matches the build date and Dearborn plant of Recall 21S28 but VIN is excluded.

This recall has been going on for over a year. I don't know how long these usually take, but this recall - Manufacturer Recall Number25S75 NHTSA Recall Number25V455 Recall StatusRecall Incomplete, remedy not yet available My truck runs rough at times which I believe is a direct result from the fuel pump on this recall, and it doesn't give me much confidence on my daily driver truck, especially going on long trips. I don't know if this message carries any weight in the timeline on this recall, but I would really like this fixed soon so I don't have a stall incident with my family in the vehicle.

On-going issue with 1080R transmission acting weird. Hard downshifts when truck is cold, even slightly warmed up. Lazy shifts, like transmission gets lost shifting from 2nd to 3rd. It pauses the shift and takes about 5 or 6 seconds to find 3rd gear. Seems to be in line with tons of known Ford 1080r cdf drum issues based on info I read online. Dealer has noted and replicated some of the issues. They've done a relearning procedure which temporarily seems to help it but then goes back to issues within a few hundred miles.

THIS TRUCK THAT I HAVE PURCHASED FROM PALM COAST FORD HAS A RECALL EVERY MONTH THAT KEEPS ME FROM UTILIZING THE VEHICLE. THE LATEST RECALL THAT THERE IS NOT A FIX FOR YET, I WAS TOLD IS A COMPLETE RISK AND I SHOULD NOT EVEN DRIVE THE TRUCK. I REQUEST THAT YOU LOOK INTO ALL OF THE RECALLS THAT HAVE BEEN LISTED ON THIS PARTICULAR VEHICLE AND KNOW THAT I AM TAKING THIS UP WITH FORD, BUT ALSO WANTED TO INFORM YOUR DATABASE OF THE ISSUES AS WELL. I HAVE ONLY HAD THE TRUCK FOR ABOUT A YEAR AND IT HAS BEEN RECALL AFTER RECALL AND THIS ONE THERE IS NOT EVEN A FIX FOR IT TILL NEXT YEAR, AND I AM NOT SUPPOSED TO EVEN DRIVE IT CAUSE IT IS HAZARDOUS.

Both factory LED headlamp assemblies are experiencing premature LED failures. The vertical LED/DRL section has failed on both headlights, and the horizontal LED section has failed on one and is beginning to fail on the other. These are factory-installed upgraded LED headlamps and the LED components are not individually replaceable, requiring replacement of the complete headlamp assembly. The failures occurred before the vehicle reached five years old. Ford was contacted regarding the issue and declined goodwill assistance. I am concerned about the premature failure of the factory exterior lighting and the potential safety implications if additional portions of the headlamp assemblies fail. It does affect viability for other vehicles and both went out within 3 months of each other. I have noticed several other vehicles on the road specifically with my headlights with the same issue.

The safety daytime running lights are failing prematurely. My car has 32,000 miles and my DRL is burnt out on the passenger side. Online forums confirm that this is happening to many, many people. It’s a safety hazard for other drivers because the cost to repair is substantial and people aren’t fixing them. Ford should fix this as a recall.

The contact owns a 2021 Ford F-150. The contact stated that the vehicle failed to start whenever the outside temperature was hot. The contact stated that the vehicle stalled. The vehicle started and then shut down. There were no warning lights illuminated. The local dealer was contacted and informed the contact that parts for NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) were on backorder. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 65,000.

Was wanting to know if or when this recall will have a fix it has been 14 months when the recall was issued. I bought my auto thinking it would be drivable for long trips and ford is still selling new auto. Not right for the people with the recall. Thanks

I am reporting a safety-related transmission problem I experienced with my 2021 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly downshifted hard, with a jolt that shook the whole truck, then went into emergency limp mode, where I had to pull over to the shoulder, on Interstate 240 in heavy traffic. I was attempting to accelerate to merge into merging traffic. Because of this it created a dangerous situation because the truck did not respond as expected when I needed predictable acceleration or propulsion. Other times I have had hard shifting, but did not result going into limp mode. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This condition can result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This is a safety concern, not merely a transmission quality or reliability issue. Unexpected loss of propulsion or unpredictable shifting while merging, accelerating into traffic, crossing an intersection, turning, or traveling at highway speed can create a collision hazard. Because I personally experienced this unexpected transmission event, I request that NHTSA investigate the 10R80 CDF clutch-cylinder/sleeve condition in Ford F-150s. Please revi

The contact owns a 2021 Ford F-150. The contact stated that while parking the vehicle, the vehicle unexpectedly lost power steering functionality. The contact opened and closed the driver's side door to reset the vehicle, and the power steering function was restored; however, the failure recurred while driving. The vehicle was towed to an independent mechanic, where it was diagnosed with a PSCM internal failure and steering mechanism ball retainer failure. The mechanic determined that the failure was associated with NHTSA Campaign Number: 21V407000 (Steering) and referred the contact to the dealer for assistance. The vehicle was towed to the dealer, and the issue was confirmed after a diagnostic test, but the contact was informed that parts were not yet available. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 79,000.

The contact owns a 2021 Ford F-150. The contact stated that while driving at various speeds, there was an abnormal clicking sound coming from the vehicle. The local dealer was made aware of the issue and upon inspection of the rear passenger’s side wheel end hub bolt, the dealer discovered the bolt was fractured. The contact later received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was not yet available. The contact was advised that the vehicle should not be driven until the vehicle was repaired under the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue but confirmed that parts were not yet available. The contact was provided a case number. The failure mileage was approximately 52,000.

My vehicle is having bad shifting and jerking from 1st to 2nd. It has now gotten worse and does the jerking through all gears at 81,000 miles. A certified Ford dealer is doing a diagnosis on it. But Ford wont cover anything as the transmission it has is widely know issue. The CDF drum is only a bulletin no full recall. This issues occures while driving and will shoot up to gear 8 and try to shift its self to 1st gear at 5 miles per hour struggling.

Outer LED light burned out. Makes for lights to seem dimmer at night while driving.

Intermittent hard downshifts when going from 3rd to 2nd gear. When merging onto the highway or periods of brief acceleration the transmission fights to find the correct gear.

I am reporting a safety-related transmission failure I experienced with my 2021 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly failed to engage and then shifted violently, causing an unexpected loss of power and then a change of propulsion. This occurred while merging at highway speed, creating a potentially dangerous situation because the truck did not respond as expected when I needed acceleration. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information for 2021–2022 F-150s identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This can result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This is a safety concern, not merely a transmission quality issue. Unexpected loss of propulsion while merging, accelerating into traffic, crossing an intersection, or turning could leave a driver unable to accelerate as expected and create a collision hazard. An unexpected downshift or lurch can also abruptly alter vehicle behavior. Because I personally experienced this unexpected transmission event, I request that NHTSA investigate the 10R80 CDF clutch-cylinder/sleeve condition in 2021 F-150s. Please review Ford warranty claims, dealer repair records, transmission replacements, consumer complaints, and field-failure

My truck has spent 80 days in the shop over 11 visits attempting to repair the transmission since 2023. The truck has a hard downshift from 5-4, 4-3, and sometimes 3-1 while light braking coming to a stop. Sometimes it’s several times per day and sometimes not in an entire week. On average it occurs 2-5 times per week. I drive 40 miles to work mostly on the freeway with little traffic with two stop signs going and one stop sign + 4 lights returning so I don’t have that many locations for the condition to be repeated which means the frequency it occurs is pretty high. It is an hard enough downshift where it clunks real bad and sometimes shutters the truck. The transmision cannot last long term and is likely loosening / damaging other components. One of the hardest downshifts I have felt occurred 2 months ago. It shuttered so bad, it felt something could have been damaged. The same day I was holding speed going downhill and it had a hard shift from 3-2. On several occasions in the last 3 years it had a clunk from 5-6 while accelerating on the freeway. Every few weeks it has a hard shift from 4-3 going uphill for power. The adaptive tables have been reset multiple times. Sometimes that helps for a little bit, sometimes not. Long term it is not a solution. The pan was dropped at one of the last visits and a repair made inside. This did not make any significant changes. The hardest downshift I have ever felt (above) occorred several days after this.

For about a year the transmission has been having an issue that has resulted in it now needing to be replaced. Started as periodic hard downshifting between 4th and 3rd gears. Now it periodically up and down shifts hard or skips gears between 2nd and 4th gears.

I am reporting a safety-related transmission problem I experienced with my 2021 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly violently jerks from 2nd to 3rd gear I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and

I am reporting a safety-related transmission problem l experienced with my 2021 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly will shift gears violently, unexpectedly downshifted. This occurred while accelerating, merging onto a highway, turning, crossing an intersection, traveling at highway speed, stop-and-go traffic, creating a potentially dangerous situation because the truck did not respond as expected when I needed predictable acceleration or propulsion. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This condition can result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This is a safety concern, not merely a transmission quality or reliability issue. Unexpected loss of propulsion or unpredictable shifting while merging, accelerating into traffic, crossing an intersection, turning, or traveling at highway speed can create a collision hazard. Because I personally experienced this unexpected transmission event, I request that NHTSA investigate the 10R80 CDF clutch-cylinder/sleeve condition in Ford F-150s. Please review Ford warranty claims, dealer repair records, transmission replacements, consumer complaints, and field-failure data to d

I am reporting a safety-related transmission problem I experienced with my 2021 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly downshifts aggressively resulting in the rear tires locking up and sliding for a moment. This occurs while driving in stop and go traffic as well as coming to a stop light/sign, creating a potentially dangerous situation. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This condition can result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This is a safety concern, not merely a transmission quality or reliability issue. Unexpected loss of propulsion or unpredictable shifting while merging, accelerating into traffic, crossing an intersection, turning, or traveling at highway speed can create a collision hazard. Because I personally experienced this unexpected transmission event, I request that NHTSA investigate the 10R80 CDF clutch-cylinder/sleeve condition in Ford F-150s. Please review Ford warranty claims, dealer repair records, transmission replacements, consumer complaints, and field-failure data to determine whether this is a safety defect requiring a recall. I believe owners should not have to wait for a potential

I am reporting a safety-related transmission problem I experienced with my 2021 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly slammed into the next gear, i had never felt that before, it happens when it shifts from 2nd gear to 3rd, and someone’s after i have already been driving at highway speeds for a while it will rev up as if it’s slipping or missing a gear. This occurred while driving on a main highway, and also happens right when i leave my driveway, creating a potentially dangerous situation because the truck did not respond as expected when I needed predictable acceleration or propulsion. A loss of power in the middle of busy traffic could cause an accident. This happens every single time i drive my truck, currently my truck has less than 55k miles. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This condition can result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This is a safety concern, not merely a transmission quality or reliability issue. Unexpected loss of propulsion or unpredictable shifting while merging, accelerating into traffic, crossing an intersection, turning, or traveling at highway speed can create a collision hazar

I am reporting a safety-related transmission problem I experienced with my 2021 Ford F-150 equipped with the 10R80 automatic transmission. While driving, the transmission would unexpectedly hesitate before engaging the selected gear and then shift harshly with a noticeable bang. On multiple occasions, the engine RPM would flare before the transmission engaged, resulting in delayed or inconsistent acceleration. The transmission has also exhibited harsh shifts, delayed engagement, and unpredictable gear changes. These events occurred during normal driving, including accelerating from a stop, merging into traffic, and driving at highway speeds. The transmission did not respond as expected when I needed predictable acceleration, creating a potentially dangerous situation. Delayed engagement and sudden harsh shifts make it difficult to judge available power when entering traffic or changing lanes. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks, resulting in harsh or delayed engagement and shifting. This condition can cause slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This is a safety concern, not merely a transmission quality or reliability issue. Unexpected hesitation, delayed engagement, or loss of propulsion while merging, accelerating into traffic, cr

Day Running Lights in headlights fail. The side LED fails completely requiring the entire headlight housing needing to be replaced. This is a common failure and Ford is not doing anything to help the thousands of customers this is affecting. This failure is widely reported online, in forums and chat rooms. Dealer acknowledges it is a part failure but Ford will not pay for replacement even though it is a design or manufacturing problem with this particular year and style of headlights.

*Brake system failure, complete shut down of vehicle. *Vehicle unable to start. *Vehicle was taken directly to Peoria Ford ( 9130 W Bell Rd, Peoria, AZ 85382) via tow truck on XXX Confirmed when dropped off of brake system failure and vehicle not functioning. *Vehicle was inspected on XXX which we were originally told it was the battery. Although the vehicle was in for trailer software recall on XXX and during inspection at that time battery was in good health. *No warnings until attempting to use the vehicle on XXX and received the brake system failure alert. Vehicle would also not lock. *After battery was replaced by Peoria Ford I was then told the brake system would not release and would need Actuator misalignment reset/replaced.