2016 Ford F-150 complaints

LOW BRAKE FLUID LIGHT CAME ON. WAS ABLE TO GET TO PARKING LOT. WHEN I WENT TO DRIVE THE TRUCK A FEW HOURS LATER IT HAD ABSOLUTELY NO BRAKES!!! HAD I DRIVEN ANY FURTHER I WOULD HAVE SURELY CRASHED AND DIED SINCE I WAS ON A HIGHWAY. NO FLUID WAS LEAKING. HAD TO TOW TO DEALERSHIP. NEED TO RECALL THE 2016'S TOO.

DRIVING IN RESIDENTIAL TYPE AREA, DOWN HILL. BREAK WARNING CAME ON (40MPH). TRIED TO STOP BUT PEDAL WENT TO FLOOR. I SAID TO MY FAMILY TO HOLD ON WE HAVE NO BREAKS AND WE'RE APPROACHING A STOPED CAR MAKING A LEFT. AS THEY WERE SCREAMING IN FEAR I STEPPED ON THE EMERGENCY BREAK AND DOWN SHIFTED TO FIRST. WE ARE LUCKY I KNEW WHAT TO DO. ANOTHER FAMILY MAY NOT BE SO LUCKY. THE FORD DEALER SAID THE MASTER CYLINDER IS LEAKING THROUGH. 2016 FORD F-150 3.5 ECOBOOST

I WAS DRIVING DOWN THE HIGHWAY WHEN MY BRAKE SYSTEM ALERT STARTED GOING OFF AND BRAKE ALERTS ON DASH, A MINUTE LATER I WENT TO BRAKE AND HAD NO BRAKES, I WAS ABLE TO GET OFF THE HIGHWAY AND TO A PARKING LOT. I OPENED UP THE HOOD AND THERE WAS NO BRAKE FLUID, I BOUGHT MORE FLUID AND ATTEMPTED TO DRIVE 3 MORE BLOCKS AND ALL THE ALERTS WENT OFF AGAIN AND NO BRAKES, I GOT PULLED OVER, CHECKED THE FLUID AND IT WAS GONE. THERE WAS NO SIGNS OF LEAKS AND ALL THE FLUID WENT INTO THE BOOSTER AND ENGINE, CAUSING A THICK CLOUD OF SMOKE I CALLED A TOW TRUCK AND IT WAS TAKEN TO A FORD DEALER. THEY SAID IT WAS NOT COVERED BECAUSE I WAS JUST OVER THE WARRANTY PERIOD. IT IS COSTING ME OVER $800. I AM VERY LUCKY IT WASN'T A BAD ACCIDENT. THIS NEEDS TO BE ADDRESSED. ALL THE FLUID WENT INTO THE BOOSTER AND INTO THE ENGINE. THE FORD DEALER WILL HAVE ALL THE INFORMATION AND ARE REPAIRING IT NOW. I COULD ADD IT LATER IF NEEDED.

TOTAL BRAKE FAILURE

BEHAVIOR MATCHES THE ISSUES DESCRIBED IN FORD RECALL 16B32. WHEN I ACCELERATE THE VEHICLE THE ENGINE OCCASIONALLY STOPS ACCELERATING AND GOES INTO A FAILURE MODE WHERE I CANNOT ACCELERATE. A FEW WARNINGS SHOW UP ON THE DASHBOARD RELATED TO HILL START ASSIST AND BEING DISABLED AND TO SERVICE ADVANCE TRACK. TURNING THE CAR OFF AND BACK ON RESOLVES THE PROBLEM, BUT THIS IS VERY DANGEROUS AS I'M USUALLY ACCELERATING TO GET ONTO A HIGHWAY WHERE IT'S NOT SAFE TO HAVE MY VEHICLE STOP. FROM THE DESCRIPTION OF THE RECALL MY VEHICLE SHOULD BE INCLUDED IN 16B32 (MANUFACTURED BETWEEN 8/31/15 TO 4/27/16 IN KANSAS CITY), BUT FORD TELLS ME MY VIN IS NOT LISTED AS AFFECTED. THIS PROBLEM HAS OCCURRED TWICE NOW AND IT IS UNPREDICTABLE IN WHEN IT WILL OCCUR. A QUICK GOOGLE SEARCH OF "HILL START ASSIST FAILURE" SHOWS A LARGE NUMBER OF OTHER FORD OWNERS WITH THE EXACT SAME PROBLEM.

ON STARTING STATIONARY VEHICLE RECEIVED AUDIBLE WARNING OF LOW BRAKE FLUID. BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. VEHICLE HAD BEEN DRIVEN NORMALLY 2 DAYS PRIOR WITH NO INDICATION. OPENED HOOD AND OBSERVED BRAKE FLUID IN RESERVOIR BELOW MIN. ADDED BRAKE FLUID TO BETWEEN MIN AND MAX. RESTARTED VEHICLE AND PRESSED BRAKE PEDAL AGAIN TO FLOOR. OBSERVED FLUID LEVEL LOWER WITHIN RESERVOIR, BUT NO FLUID OBSERVED COMING FROM VEHICLE. CONTINUED TO ADD FLUID, PUMP PEDAL AND OBSERVE FLUID DRAINING, BUT NO FLUID LEAK FOUND. TOTAL FLUID ADDED - 36 OZ. VEHICLE TOWED TO DEALER. SERVICE DEPARTMENT CONCURRED WITH SELF-ASSESSMENT THAT MASTER CYLINDER HAD FAILED AND DRAINING FLUID WAS COLLECTING IN BRAKE BOOSTER HOUSING. SERVICE DEPARTMENT QUOTING $1000 TO REPAIR. VEHICLE 37 MONTHS OLD, 47000 MILES - JUST OUT OF WARRANTY. HAD VEHICLE HAD BEEN IN MOTION I FEEL CONFIDENT COLLISION WOULD HAVE OCCURRED / INJURIES LIKELY. MY GRAVEST CONCERN IS THAT FAILURE OF MAJOR SAFETY SYSTEM DID NOT HAVE ANY PRECURSOR NOR EXTERNAL SYMPTOMS. HARD FOR LOW AGE/LOW MILEAGE VEHICLE TO HOLD VALUE WITH THIS ISSUE.

WHILE HEADING TO THE DENTIST YESTERDAY I WAS DRIVING AND THE LOW BRAKE FLUID LIGHT CAME ON, THOUGHT MAYBE A SENSOR FAULT AND KEPT DRIVING, NEXT THE BRAKE LIGHT INDICATOR IN THE INSTRUMENT CLUSTER CAME ON. SO I PULLED OVER AND THE PEDAL WENT TO THE FLOOR. I BARELY STOPPED IN TIME BECAUSE THERE WAS A STOP SIGN. I POPPED THE HOOD AND THERE WAS NO FLUID IN THE MASTER CYLINDER. I LOCKED THE TRUCK UP AND WALKED 3 BLOCKS TO A ACE HARDWARE TO GET SOME MORE FLUID. I GOT BACK TO THE TRUCK AND CHECKED FOR LEAKS BUT DIDN'T FIND ANY. SO I FILLED UP THE FLUID AND PUMPED THE BRAKES, I HAD ENOUGH TO GET ME HOME SAFELY. WHEN I GOT HOME I CHECKED AGAIN AND FOUND THE FLUID TO BE ALL GONE AGAIN. THAT WAS WITHING A 5 MILE DISTANCE TO WHERE I FILLED IT UP LAST. I CHECKED FOR LEAKS ONCE AGAIN AND DIDN'T FIND ANY. SO I PULLED THE VACUUM SENSOR OFF THE BOTTOM OF THE BRAKE BOOSTER AND ALL OF THE BRAKE FLUID POURED OUT. THE MASTER CYLINDER FAILED AND KEPT PUSHING THE BRAKE FLUID INTO THE BOOSTER.

I TURNED ON THE REAR DEFROSTER & THE CABIN STARTED SMOKING. I PULL OVER TO GET OUT TO BREATHE, ONE MINUTE LATER THE BACK WINDSHIELD SHATTERS COMPLETELY.

MY TRUCK LOST COMPLETE POWER ON 8/3/19. SEVERAL DIFFERENT WANING LIGHTS CAME ON. FORTUNATLEY, I WAS LOST POWER ON A STRAIGHT STRETCH OF ROAD AT ABOUT 30 MPH. I WAS ABLE TO "LIMP" MY TRUCK BACK HOME. I HAVE A CODE READER AND IT SHOWED CODE P2112 "THROTTLE ACTUATOR CONTROL SYSTEM STUCK CLOSED". I SEARCHED ONLINE AND FOUND A FORD CUSTOMER SERVICE LETTER FROM 2016-2017 ADDRESSING THIS ISSUE WITH AN EXPIRATION NOTICE OF SEPTEMBER 2017. I PURCHASED THE VEHICLE USED IN DECEMBER 2016 AND WAS NEVER SENT ANY NOTICE. I FIND IT INCREDIBLE THAT FORD KNOWS ABOUT A DEFECT THAT CAUSES A VEHICLE TO LOSE POWER SUDDENLY, AND ADDRESSES IT WITH THIS BANDAID LEVEL OF SERVICE. IT IS A SIMPLE AND INEXPENSIVE FIX. I FIXED IT MYSELF IN LESS THAN AN HOUR WITH A PART PURCHASED FROM FORD THAT WAS LESS THAN $200. MY CONCERN IS THAT FORD DID NOT NOTIFY ME AND WILL NOT STAND BY THIS DANGEROUS DEFECTIVE ISSUE. THEY HAVE TOLD ME THERE WAS AN EXPIRATION ON THAT LETTER AND THEY WILL NOT HELP ME. PLEASE FORCE THEM TO DO AN ACTUAL RECALL ON THIS ISSUE BEFORE SOMEONE IS KILLED! THANK YOU FOR YOUR TIME.

ON JULY 18, 2019 VEHICLE (2016 FORD F150 WITH 51,721 MILES) DRIVEN UNDER HIGHWAY CONDITIONS EXPERIENCE A 'LOW BRAKE FLUID' WARNING FOLLOWED AFTERWARDS WITH COMPLETE LOSS OF BRAKES WHEN ATTEMPTING TO SECURE THE VEHICLE TO A SAFE CONDITION. FORTUNATELY THE DRIVING SITUATION ALLOWED THE VEHICLE TO BE SECURED SAFELY. UPON INSPECTING THE VEHICLE THERE WERE NO INDICATION OF BRAKE FLUID LOSS THROUGH BROKEN BRAKE LINES OR SYSTEM LEAKAGE. SUBSEQUENTLY TRANSPORTED THE VEHICLE TO THE VEHICLE OUR ORIGINATING FORD DEALERSHIP, THE SHOP DIAGNOSTIC RESULT WAS THE 'FAILURE OF THE MASTER BRAKE CYLINDER REAR CUP SEAL'. ADDITIONAL DAMAGE INCLUDED THE BOOSTER PUMP DUE TO BRAKE FLUID CONTAMINATION. ISSUES: THIS IS THE SAME FAILURE TO WHICH FORD MOTOR PREVIOUSLY RECALLED 2013 - 2014 F150'S. AT 51K MILES, THE FAILURE OF A MASTER CYLINDER IS PREMATURE. DURING ROUTINE MAINTENANCE, INSPECTION OF THE MASTER CYLINDER DOES NOT READILY LEAD TO INDICATION OF POTENTIAL FAILURE OR NEED FOR REPLACEMENT. THIS FAILURE COULD BE CATASTROPHIC UNDER THE RIGHT CONDITIONS IF PROPER OPERATOR CONTROL IS NOT FOLLOWED - LOWER SPEED BY REDUCING GEARING AND USING THE EMERGENCY BRAKES. THE REPLACEMENTS ARE OEM FACTORY PARTS; POSSIBLY THE SAME MANUFACTURE AS THAT REPLACED WHICH COULD BE POTENTIAL FOR FUTURE FAILURE (THIS COULD NOT BE CLARIFIED BY THE FORD SHOP AT THE TIME OF THE WORK)! THE PRIMARY CONCERN OF COURSE POTENTIAL FOR RELAPSE OF THE SAME EVENT. SECONDARILY IS THE PREMATURE EXPENSE OF MASTER BRAKE CYLINDER AND BOOST

MY VEHICLE WAS IN MOTION AT APPROXIMATELY 65 MPH WHEN IT SUDDENLY ENTERED A LIMP MODE, INDICATED BY MULTIPLE DASH WARNING LIGHTS AND AN ABRUPT LOSS OF POWER. THE VEHICLE WAS INCREDIBLY UNSAFE TO OPERATE IN SUCH CONDITION. FORD HAS A KNOWN PROBLEM WITH THE ELECTRONIC THROTTLE BODY USED ON THESE MOTORS, BUT HAS FAILED TO ISSUE A RECALL ON A PART THAT COULD CAUSE GREAT BODILY HARM AND INJURY IF IT SHOULD FAIL IN HEAVY TRAFFIC SCENARIOS.

COMPLETE BRAKE FAILURE WITH LIMITER WARNING. DRIVING AND BRAKE FLUID LEVEL LIGHT CAME ON. STOPPED AT A GAS STATION REFILLED BRAKE FLUID. LOST BRAKE PRESSURE AFTER DRIVING LESS THAN A MILE FROM GAS STATION. REFILLED BRAKE FLUID. NEXT MORNING STARTING SEEING WHITE SMOKE IN EXHAUST. ALL OF THE BRAKE FLUID DRAINED OUT OF BRAKE FLUID OUT AND LEAKING FROM MASTER CYLINDER

ON THE NEWER FORD F150'S THE MASTER LOCK SITS OUTSIDE OF THE DOOR FRAME. CRIMINALS CAN BREAK THIS LOCK AND GRAIN ACCESS TO THE VEHICLE IN LESS THAN 30 SECONDS. I HAVE HAD MY TRUCK BROKEN INTO 3 TIMES NOW DUE TO THIS SECURITY ISSUE. FORD REFUSES TO ACKNOWLEDGE THE ISSUE THEY ENGINEERED INTO THE F150. I DO NOT FEEL SAFE IN MY TRUCK AND WILL IMEDIETLY BE LOOKING FOR A REPLACEMENT THAT IS NOT A FORD.

TL* THE CONTACT OWNS A 2016 FORD F-150. WHILE DRIVING ON THE INTERSTATE, THE BRAKE WARNING INDICATOR ILLUMINATED. WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE FAILED TO STOP. THE CONTACT HAD TO APPLY THE CAMPER BRAKE TO REACH THE NEXT EXIT. THE CONTACT TOOK THE VEHICLE TO MURDO FORD (219 MAIN ST, MURDO, SD 57559, (605) 669-2391) WHERE IT WAS DIAGNOSED THAT THE VACUUM BOOSTER SUCKED THE SEAL OUT OF THE MASTER CYLINDER AND ALL THE FLUID WENT TO THE BOOSTER. THE TECHNICIAN ADDED FLUID TO THE BRAKE MASTER CYLINDER AND DISCONNECTED THE BOOSTER. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE AND LATER TOOK IT TO THUNDER BASIN FORD (1100 W 2ND ST, GILLETTE, WY 82716, (307) 682-4735), BUT WAS NOT DIAGNOSED OR REPAIRED DUE TO THE LENGTH OF TIME IT WOULD TAKE FOR THE REPAIR. THE VEHICLE WAS ALSO TAKEN TO JACKSON FORD OF DECATUR (455 E PERSHING RD, DECATUR, IL 62526, (844) 846-7281) WHERE A REPAIR APPOINTMENT WAS SCHEDULED. THE CONTACT ALSO TOOK THE VEHICLE TO RICK RIDINGS FORD (1817 RIDINGS DR, MONTICELLO, IL 61856, (217) 762-2521) AND WAS INFORMED THAT THERE WERE NO RECALLS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 32,000. *BF *AS

STARTED DRIVING AM FOR ABOUT 5-7 MILES AND GETTING ON AN ON RAMP TO FREEWAY VEHICLE SUDDENLY HAD NO POWER AND IDLE VERY ROUGH/ COULD NOT ACCELERATE AND SERVICE ENGINE LIGHT, HILL ASSIST NOT ACTIVE AND ANOTHER SERVICE LIGHT CAME ON. PULLED OVER TO THE SIDE OF ROAD AND SAT FOR ABOUT 30 SECONDS, TURNED VEHICLE OFF AND RE STARTED, NO FAULT WARNING LIGHTS WERE ON AND ALL WAS FINE. DROVE 22 MILES TO DEWEY FORD IN ANKENY, IOWA TOLD THEM WHAT HAPPENED AND THEY ASKED IF ANY FAULT LIGHTS WERE STILL ON AND I SAID NO AND THEY TOLD ME THEY WOULDN'T BE ABLE TO DIAGNOSE THE PROBLEM WITHOUT A FAULT LIGHT BEING ON. THEY SAID IT COULD BE WATER IN THE FUEL AND SUGGESTED A COUPLE CANS OF SEA FOAM AND TO TOP FUEL OFF WITH PREMIUM/NO ALCOHOL. DID THAT, DROVE AN ADDITIONAL 22 MILES WITH OUT ANY PROBLEMS. RESEARCHED SIMILAR PROBLEMS BY OTHERS AND ELECTRONIC THROTTLE BODY CAME UP. WILL UPDATE IF I HAVE ANOTHER INCIDENT.

TL* THE CONTACT OWNS A 2016 FORD F-150. WHILE DRIVING 30 MPH, THE LOW BRAKE FLUID WARNING INDICATOR ILLUMINATED AND THE BRAKE PEDAL WAS DEPRESSED TO THE FLOORBOARD, BUT FAILED TO ADEQUATELY SLOW DOWN THE VEHICLE. THE PARKING BRAKE WAS ACTIVATED AND THE VEHICLE SLOWED TO A STOP. A TOWING SERVICE WAS CONTACTED; HOWEVER, THE VEHICLE WAS STILL WAITING TO BE TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT STATED THAT BRAKE FLUID WAS ADDED TO THE BRAKE RESERVOIR; HOWEVER, AFTER SEVERAL SECONDS, THE BRAKE RESERVOIR WAS EMPTY AGAIN. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 23,000.

UPON PULLING OUT OF PARKING SPACE, LOW BRAKE FLUID LIGHT CAME ON AND BRAKE PEDAL LOST ALL PRESSURE. WENT BACK INTO STORE TO PURCHASE MORE BRAKE FLUID. REFILLED AND LOW FLUID LIGHT CAME BACK ON BEFORE LEAVING PARKING LOT. DROVE TO ANOTHER LOT AND REFILLED RESERVOIR AS IT WAS EMPTY AGAIN. NO SIGNS OF EXTERNAL LEAKS. UPON VIEWING OTHER IDENTICAL COMPLAINTS, I BELIEVE IT IS LEAKING INTO BRAKE BOOSTER, WHICH HAS NOT YET BEEN RECALLED FOR THIS MODEL YEAR. F150 ONLY HAS 61,000 MILES.

WHILE DRIVING TOTAL LOSS OF BRAKES, PEDAL TO THE FLOOR. NO FLUID IN MASTER CYLINDER. MASTER CYLINDER FAILED AND FLUID LEAKED INTO BOOSTER AND BURNED OFF IN ENGINE

TL* THE CONTACT OWNS A 2016 FORD F-150. WHEN THE CONTACT ACTIVATED THE REAR DEFROSTER, THE REAR WINDOW EXPLODED AND BEGAN TO PRODUCE SMOKE. THE CONTACT AND OTHER PASSENGERS EXITED THE VEHICLE UNHARMED. THE CONTACT DISCONNECTED THE REAR DEFROSTER THE FOLLOWING DAY. THE VEHICLE WAS DRIVEN TO BONNELL FORD (353 CAMBRIDGE ST, WINCHESTER, MA 01890, (781) 729-9700) AND A DIAGNOSTIC APPOINTMENT WAS SCHEDULED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 38,000. THE VIN WAS UNKNOWN.

WHILE DRIVING ON A US HIGHWAY AT 65 MPH, I HAD A NEED TO SUDDENLY APPLY THE BRAKES ON MY 2016 FORD F-150 AND THERE WAS A SUDDEN FAILURE. THE BRAKE PEDAL HAD TO BE DEPRESSED THE ENTIRE DISTANCE TO THE FLOOR TO FINALLY GET THE VEHICLE TO DECELERATE. AFTERWARDS A WARNINGS LIGHT CAME ON INDICATING LOW BRAKE FLUID. DESPITE ADDING FLUID TO THE RESERVOIR THE BRAKES WOULD STILL NOT ENGAGE. THE VEHICLE HAD TO BE BROUGHT FOR SERVICE WHERE IT WAS DETERMINED THAT THERE HAD BEEN A FAILURE IN THE MASTER BRAKE CYLINDER. FORTUNATELY THIS DID NOT RESULT IN AN ACCIDENT OR INJURY.

TL* THE CONTACT OWNS A 2016 FORD F-150. WHILE DRIVING APPROXIMATELY 65 MPH, "SEE SERVICE MANUAL, TRACTION CONTROL NOT AVAILABLE, CHECK ENGINE" ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE LOST POWER AND THE ACCELERATOR PEDAL DID NOT RESPOND. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD TO A COMPLETE STOP AS IT BEGAN TO SHAKE. WHEN THE VEHICLE WAS TURNED OFF AND RESTARTED, ALL THE WARNING INDICATORS WENT AWAY AND THEN ILLUMINATED AGAIN. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. RICH FORD (8601 LOMAS BLVD, ALBUQUERQUE, NM 87112) WAS CONTACTED VIA PHONE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 49,500.

WHILE DRIVING TO WORK A RED BRAKE WARNING LIGHT CAME ON THE DISPLAY AND I TRIED THE BRAKES. THE BRAKE PEDAL WENT TO THE FLOOR AND I HAD NO BRAKES. I PULLED OVER IN A SAFE SPOT CHECKED THE BRAKE RESERVOIR AND IT WAS COMPLETELY EMPTY. I STARTED THE VEHICLE AND SMOKE STARTED POURING OUT OF THE EXHAUST. HAD IT TOWED TO A FORD/LINCOLN DEALER AND THEY SAID THE MASTER CYLINDER AND BRAKE BOOSTER NEEDS TO BE REPLACED $890.00. THERE IS NO FORD RECALL FOR 2016 F150S WHICH IS UNBELIEVABLE SINCE THIS IS A SERIOUS SAFETY ISSUE. DID SOME RESEARCH AND THERE ARE MULTIPLE LAWSUITS FOR THE SAME ISSUE ON 2013-2018 FORD F150S. I CALLED FORD HAD A HARD TIME UNDERSTANDING THE REP AND SHE CREATED A CASE NUMBER. CALLED THEM THE NEXT DAY AFTER SPEAKING WITH FORD DEALER AND THERE WAS NO CASE TO BE FOUND. THE SECOND FORD REP MADE A CASE # CAS22180343, WAS VERY HELPFUL AND THE REP SAID FORD WILL MAKE IT RIGHT. THIS REMAINS TO BE SEEN. MEANWHILE I'M WITHOUT A VEHICLE. I HAD A 2005 TOYOTA TACOMA AND NEVER HAD ANY TYPE OF ISSUES. HOPEFULLY THIS HELPS AND GETS FORD TO RECALL 2016 F150S SO NO ONE GETS HURT. ALSO HAD TO REPLACE ALL BRAKES, ROTORS AND PADS FOR $924.72 ON A 50K MILE VEHICLE IS VERY QUESTIONABLE. THANK YOU

I HAVE OWNED MY 2016 FORD F-150 SUPER CREW LARIAT FOR ALMOST 3 YEARS. I PURCHASED IT BRAND NEW FROM A DEALER IN PALM BEACH COUNTY FLORIDA. I AM ON TOP OF MY ROUTINE MAINTENANCE AND HAVE JUST HAD MY TRUCK SERVICED 3 WEEKS AGO. ON 7/20/19 MY TRUCK'S BRAKES COMPLETELY FAILED WHILE DRIVING FROM MY HOUSE ON A RESIDENTIAL ROAD. I HAD TO USE MY EMERGENCY BRAKE TO STOP MY VEHICLE FROM GOING THROUGH A STOP SIGN. THANKFULLY, I WAS NOT INVOLVED IN AN ACCIDENT. MY MASTER CYLINDER HAD LOST ALL ITS FLUID BUT THERE WERE NO SIGNS OF LEAKS. I ADDED BRAKE FLUID AND I COULD SEE IT LEAVING THE RESERVOIR. IT APPEARS TO BE LEAKING INTO THE BRAKE BOOSTER. I HAD TO HAVE MY TRUCK TOWED TO THE DEALERSHIP AND I'M WAITING TO HEAR BACK FROM THE SERVICE DEPARTMENT.

WHILE DRIVING NORMALLY ERROR/MAINTENANCE ALARMS GO OFF AND THE TRUCK WILL DROP TO A ROUGH IDLE (TOTAL LOSS OF POWER), IS NOT RESPONSIVE TO THROTTLE INPUT, AND MULTIPLE ALARM MESSAGES ARE DISPLAYED. IN EVERY CASE, I HAVE HAD TO PULL OVER, SHUT THE ENGINE DOWN, WAIT UNTIL ALL SYSTEMS HAVE POWERED DOWN, AND RESTART THE TRUCK. IN THE PAST AND THE MOST RECENT OCCURRENCE, SOMETIMES THIS ONLY OCCURS ONCE BUT IN A COUPLE OF INSTANCES IT WILL OCCUR A COUPLE OF TIMES IN A ROW BEFORE RESUMING NORMAL OPERATION. THIS IS A VERY DANGEROUS CONDITION- TOTAL LOSS OF POWER WHILE IN TRAFFIC ON BUSY ROADS. FORD HAS DIAGNOSED AS AN ELECTRONIC THROTTLE BODY FAILURE AND REFUSED TO COVER THIS ON WARRANTY (OUT OF WARRANTY 3 MOS) AND IT HAS TAKEN MUCH RESEARCH ON MY PART TO DISCOVER THAT THIS IS A KNOWN ISSUE WITH FORD ETB'S GOING BACK SOME TIME WITH OVER 60K FAILURE REPORTS OVER MANY DIFFERENT VEHICLES.

VEHICLE OPERATING NORMALLY UNTIL PROBLEM NOTED 7/13/2016. VEHICLE PURCHASED USED FROM CERTIFIED FORD DEALERSHIP ON 5/16/2018. CURRENTLY HAS APPROXIMATELY 44,800 MILES ON ODOMETER. VEHICLE HAS BEEN PARKED OVERNIGHT AND UPON AM STARTUP AND BACKING UP SUFFERED COMPLETE LOSS OF BRAKING ABILITY WHEN BRAKES WERE APPLIED. LOW BRAKE RESERVOIR INDICATOR LIGHT ON. VISUAL CHECK REVEALED RESERVOIR LEVEL WELL BELOW MINIMUM MARK AND LEVEL WITH INLETS FOR THE BRAKE LINES. REFILLED, PUMPED BRAKES AND ABLE TO OBTAIN MODERATELY FIRM PEDAL. STARTED VEHICLE, LET IDLE FEW MOMENTS, TESTED BRAKE PEDAL BUT FOUND SOFT PEDAL AGAIN SINKS IMMEDIATELY TO FLOOR AND RESERVOIR LIGHT ON AGAIN. VISUAL CHECK SHOWS FLUID AGAIN HAS EMPTIED AS DESCRIBED ABOVE. VEHICLE HAD NOT BEEN MOVED. A VISUAL TRACE OF ALL BRAKE LINES SHOWS NO EXTERNAL LEAKAGE ALONG LENGTH OF THE LINES NOR AT ANY BRAKE COMPONENT. FLUID IS OBVIOUSLY BEING DRAWN INTO THE VACUUM BOOST RESERVOIR. VEHICLE HAS NOT BEEN ALTERED IN ANY WAY FROM DATE OF PURCHASE. THIS IS AN EXTREME SAFETY ISSUE WITH A HIGH PROBABILITY OF LOSS OR LIFE AND/OR SEVERE INJURY TO PASSENGERS AND/OR COLLISION WITH OTHER VEHICLES OR OBJECTS DUE TO THIS SUDDEN, TOTAL BRAKE FAILURE. THIS IS A CATASTROPHIC FAILURE OF THE MASTER CYLINDER SYSTEM THAT PRODUCES A FAILURE OF THE REDUNDANT BRAKING ARRANGEMENT (I.E. SEPARATE FRONT AND REAR BRAKE SYSTEMS). THIS APPEARS FROM A QUICK GOOGLE SEARCH OF OTHER COMPLAINTS TO BECOMING A KNOWN PROBLEM. PROMPT ACTION IS URGED BY NHTSA TO INITIATE A

THE WRENCH LIGHT FIRST CAME ON AROUND 42,000 MILES, BUT WOULD SHUT OFF WHEN THE VEHICLE WOULD BE TURNED OFF. IT CAME ON A SECOND AND THIRD TIME AROUND THE 50,000 AND 51,750 MILES. SOMETIMES IT WOULD COME BACK ON WHEN DRIVING AGAIN AND SOMETIMES NOT. THEN THE ENGINE LIGHT CAME ON AT ABOUT 52,000 MILES. WHEN THIS CAME ON, IT WOULD STAY ON. THE TRUCK WOULD SEEM TO LOSE A LOT OF POWER AND THE RPM'S WOULD BEGIN REVVING HIGHER WHILE DRIVING. THIS WOULD BE DRIVING ON ALL ROAD CONDITIONS, HIGHWAY OR CITY, UP AND DOWN HILLS. WE HAD THE TRUCK IN TO CHECK AND THE CODE IT PROVIDED WAS 'DTC S-P0741 TORQUE CONVERTOR CLUTCH SOLENOID CIRCUIT PERFORMANCE STUCK OFF. WILL HAVE TO REPLACE TCC AND IF CONDITION STILL EXISTS, REPLACE THE MAIN VALVE BODY.' THE FIRST FORD DEALER (WHILE ON VACATION) MADE THE REPAIR, BUT THIS DID NOT REPAIR THE TRUCK. (THE WRENCH LIGHT CAME BACK ON AGAIN 131 MILES AFTER THE REPAIR AND THE ENGINE LIGHT CAME BACK ON AGAIN 40 MILES LATER OF THE WRENCH LIGHT WARNING.) TOOK THE TRUCK BACK TO THE FORD DEALER WE PURCHASED THE TRUCK AT AND THEY ARE STILL TRYING TO DETERMINE THE CAUSE TO THE ISSUE. THE FIRST TIME THE WRENCH LIGHT CAME ON, WAS UNDER NORMAL DRIVING CONDITIONS AND NOT TOWING A CAMPER. ALL THE REMAINING TIMES THE WRENCH AND ENGINE LIGHT CAME ON WAS WHILE TOWING A CAMPER. (NOT SURE IF THIS IS POSSIBLE CAUSE OF THE ISSUE OR NOT, BUT FEEL IT IS WORTH NOTING.) ACCORDING TO THE OWNER'S MANUAL, THE AUTO START/STOP FEATURE IS TO AUTOMATICALLY DISABLE WHEN A CAMPER IS HOOK

IT IDLES ROUGH AT STOP LIGHT SOMETIMES SHUTS DOWN ,RADIO SCREEN IS BLANK SOMETIMES W RADIO OR PHONE CALL. ELECTRICAL BURNING SMELL ENOUGH TO MAKE ME NAUSEOUS. THE COMPUTER READS NO CODES. THIS HAPPENS EVERY COUPLE OF DAYS, IT HAS BEEN AT 2 DIFFERENT SHOPS UP TO WEEKS AT A TIME THEY HAVE CHANGED SEVERAL PARTS BUT NONE HAVE FIXED IT.

AFTER 71K MILES, THE BRAKE MASTER CYLINDER NEEDS REPLACED DUE TO BRAKE FLUID INTERNAL LEAKING TO THE BRAKE BOOSTERS. LOST ALL CONTROL OF BRAKING POWER. $1100 REPAIR TO REPLACE MASTER CYLINDER AND BRAKE BOOSTERS. THIS HAPPENED ON 7/6/2019 WHILE DRIVING HOME. THE LOW BRAKE FLUID LIGHT CAME ON WHILE DRIVING AND NOTICED SUBSTANTIAL LOSS IN BRAKING POWER AND HAD TO PUSH BRAKE PEDAL ALL THE WAY DOWN TO SLOW THE TRUCK TO A STOP AT STOP SIGN.

I WAS DRIVING HOME FROM WORK AND VEHICLE WAS FUNCTIONING NORMALLY. UNEXPECTEDLY THE "LOW BRAKE FLUID" WARNING APPEARED. APPROXIMATELY 1 TO 2 MINUTES LATER I STEPPED ON THE BRAKE AND IT WENT TO THE FLOOR. THE FIRST TIME I PRESSED IT SLOWED THE VEHICLE SLIGHTLY. I IPRESSED ON THE BRAKE AGAIN AND IT DID NOT REGISTER. IT WAS TERRIFYING AND I FELT FORTUNATE TO BE ABLE TO MAKE IT TO THE SIDE OF THE ROAD WITHOUT COLLISION. THIS HAPPENED ON A MAJOR CITY STREET MOVING ABOUT 40 MPH.

WHILE SLOWLY PULLING OUT OF A DRIVE WAY THE DRIVER APPLIED THE BRAKES BUT THE PEDAL WENT TO THE FLOOR. A MECHANIC'S INSPECTION DETERMINED THE BOOSTER FAILED CAUSING BRAKE FLUID TO FLOW INTO THE MASTER CYLINDER. WITH NO FLUID IN THE LINES THERE IS NO STOPPING ABILITY.

TL* THE CONTACT OWNS A 2016 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 17V652000 (LATCHES/ LOCKS/LINKAGES) AND 18V568000 (SEAT BELTS, STRUCTURE). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. LAMARQUE FORD (3101 WILLIAMS BLVD, SUITE F, KENNER, LA 70065, (504) 443-2500) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

IF TRUCK IS NOT DRIVEN IN A FEW WEEKS THE GAS FEED STICKS IN REVERSE, I HAVE NOT HAD IT STICK IN FORWARD. ONLY IN REVERSE, MY WIFE HAD A ACCIDENT WITH THIS TRUCK. I'VE HAD IT STICK ON ME BUT I'M LOOKING FOR IT. FORD AND THE INSURANCE COMPANIES SAY THAT THERE IS NOTHING WRONG. IT HAS OCCURRED SEVERAL TIMES WITH ME AND I DON'T LET MY WIFE DRIVE THE TRUCK.

TRUCK HAD 36335 MILES ON IT AND WE HAD COMPLETE BRAKE FAILURE. JUST ARRIVED IN PANAMA CITY FLA AND COMING OUT OF GROCERY STORE LOST ALL BRAKES WHILE IN MOTION ON CITY STREET

INSTRUMENT PANEL LIGHTS UP WITH VARIOUS FAULT MESSAGES RELATED TO TRACTION CONTROL, DOWNHILL DESCENT, ETC... WITHIN SECONDS THE VEHICLE BEGINS TO STUTTER, FAILS TO RESPOND TO ATTEMPTS TO ACCELERATE BY PRESSING GAS PEDDLE, AND EVENTUALLY LOSES POWER. HAPPENED TWICE WHILE TRAVELLING AT HIGHWAY SPEEDS RESULTING IN A DANGEROUS SCENARIO OF PULLING TO THE SIDE OF THE HIGHWAY.

REPORTED MY ISSUE ALREADY 11229377 BUT WANTED TO POINT OUT THAT AT A QUICK GLANCE THERE ARE ANOTHER 30+ NHTSA SAFETY COMPLAINTS FOR MY SAME ISSUE. 11022233, 10955596, 11174190, 10870553, 10887486, 11165975, 11150176, 11139022, 11101604, 11048673, 1102997, 11174190 TO NAME A FEW. FORD HAS ALSO ISSUES SEVERAL TSB AND SSM FOR THIS ISSUE. TSB16-0139, TSB17-2124, SSM46829, TSB16B23-S1. AT WHAT POINT DOES NHTSA PUT PRESSURE ON FORD TO RESOLVE THESE ISSUES? WILL IT REQUIRE A DEATH TO BE ASSOCIATED TO THIS ISSUE? A FIRE, ACCIDENTS? THERE ARE ALSO COUNTLESS ONLINE FORUM POSTS ON THIS ISSUE. I CAN FIND NUMEROUS LINKS SHOWING THIS BUT I THINK THE SHEER NUMBER OF COMPLAINTS ON HERE COUPLED WITH WARRANTY NUMBERS FOR THIS ISSUE SHOULD BE SUFFICIENT TO OPEN AN INVESTIGATION. I PLAN TO WRITE A LETTER TO MY LOCAL NEWS OUTLETS AND GOVERNOR.

I WAS PARKED AT A RETAIL STORE WHEN THE CHECK BRAKE FLUID LIGHT CMAE ON. I CHECK THE FLUID AND IT WAS ALMOST EMPTY. THE BRAKE PEDAL WAS GOING ALL THE WAY TO THE FLOOR. I PURCHASE FLUID AND REPLACED IT AND DROVE HOME ABOUT TWO MILES AWAY. BY THE TIME I GOT HOME THE LIGHT CAME ON AGIN AND THE PEDAL WAS GOING TO THE FLOOR WITH VERY LITTLE BRAKES. I CALLED MY MECHANIC (WHO WORKS FOR FORD) AND HE SAID TO CHECK BECAUSE HE THOUGHT THERE MIGHT BE A RECALL ON THE BRAKES. THERE IS NOT ONE BUT THERE ARE A LARGE NUMBER OF COMPLAINTS ON THE ISSUE. IT IS SO BAD THE MASTER CYLINDER IS ON BACK ORDER WITH NO TIMEFRAME GIVEN ON WHEN IT WILL COME IN. I ALSO CANNOT GET AN AFTER MARKET PART FROM SOMEONE ELSE DUE TO BACKORDERS. IT IS OBVIOUS THERE IS A MASS PROBLEM THAT FORD IS IGNORING A SAFETY ISSUE.

TL* THE CONTACT OWNS A 2016 FORD F-150. WHILE THE VEHICLE WAS BEING SERVICED BY ANTELOPE VALLEY FORD (LOCATED AT 1155 AUTO MALL DR, LANCASTER, CA 93534, (888) 415-0959), THE CONTACT WAS INFORMED THAT THE BRAKE BOOSTER, BRAKE CYLINDER, AND BUSHINGS NEEDED TO BE REPLACED. THE FAILURE OF THE BRAKE COMPONENTS RENDERED THE BRAKES INOPERABLE. IN ADDITION, THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,178.

WHEN BACKING THE TRUCK DOWN THE DRIVEWAY AT A LOW SPEED. THE STEERING WHEEL LOCKED AT THE MOMENT YOU HAVE TO CUT LEFT TO AVOID A NEIGHBORHOOD WATCH SIGN THAT SITS ADJACENT THE DRIVEWAY. THE LEFT MIRROR BROKE OFF, IMPACTING THE LEFT FRONT QUARTER PANEL RESULTING IN APPROXIMATELY $1,500 DAMAGE TO THE VEHICLE. I ALSO DAMAGED THE COMMUNITY SIGN REQUIRING REPAIR. AS NOTED IN OTHER NHTSA REPORTS, DIAGNOSTIC TESTS WERE VOID OF STEERING CODES. BATTERY FAILURE WAS NOTED HOWEVER EVEN THOUGH A BATTERY INDICATOR LIGHT ON THE INSTRUMENT PANEL NEVER APPEARED. THE DEALERSHIP DOCUMENT NOTED 'LOAD TESTED BATTERY FAILED ' RECOMMEND BATTERY ' CAN CAUSE ELECTRICAL ISSUES.' IN OTHER WORDS, EPAS FAILED OR LOCKED DUE TO A BATTERY ISSUE THAT WAS NOT DISPLAYED ON THE CONSOLE.

ONE WEEK AGO LEFT WORK AND TURNED ON TRUCK. WHEN STARTING TO PULL OUT OF PARKING SPACE ABS LIGHT CAME ON DASH. AFTER GETTING HOME AND CALLING DEALER TO HAVE INSPECTION, WAS INFORMED IT WOULD BE 2 WEEKS TO GET IN FOR SERVICE. AS VEHICLE IS DAILY DRIVER CONTINUED TO DRIVE AROUND TOWN AND TO WORK, A FEW DAYS AFTER REGULAR USE STEERING COLUMN STARTED GETTING HARDER TO TURN AND DEVELOPED CLICKING SOUND. CALLED ANOTHER MECHANIC TO GET IN SOONER AND BEFORE COULD MAKE THAT APPOINTMENT SCHEDULED FOR TWO DAYS LATER ENTIRE STEERING COLUMN LOCKED UP AND VEHICLE IS UNUSABLE. BEING TOWED TO REPAIR SHOP TODAY. LUCKILY WAS NOT DRIVING WHEN COLUMN LOCKED UP. HAD STARTED VEHICLE IN DRIVEWAY AND WAS PLANNING ON GOING TO STORE WHEN UNABLE TO BACK UP BECAUSE STEERING COLUMNS/WHEEL WOULD NOT MOVE. NOW AWAITING WORK FROM REPAIR SHOP ON DOAGNSOSTICS AND ISSUE TO REPAIR. VERY FRUSTRATED AS VEHICLE LESS THAN 3 YEARS OLD AND WITH ONLY 70K MILES.

TL* THE CONTACT OWNS A 2016 FORD F-150. WHEN THE VEHICLE WAS TAKEN TO SUNSET FORD (314-843-4431, LOCATED AT 11700 GRAVOIS RD, ST. LOUIS, MO 63127) FOR AN OIL CHANGE AND TIRE ROTATION, IT WAS DIAGNOSED THAT WATER SLIPPED THROUGH THE CHROME SEAL ON THE LUG NUTS, WHICH CAUSED THE LUG NUTS TO SWELL. THE DEALER INFORMED THE CONTACT THAT IF THE TIRES NEEDED TO BE CHANGED IN AN EMERGENCY SITUATION, THE LUG NUTS COULD NOT BE REMOVED. THE DEALER STATED THAT THE FAILURE WAS A KNOWN ISSUE AND THERE WAS NO RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND CONFIRMED THAT THE FAILURE WAS A KNOWN ISSUE AND THAT ACTION WAS ALREADY TAKEN AGAINST THE SUPPLIER. THE CONTACT WAS NOT COMPENSATED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS REPORTED TO NHTSA AND THERE WOULD BE NO REIMBURSEMENT. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. THE FAILURE MILEAGE WAS 49,658.

THROTTLE BODY FAILURE: FIRST OCCURRED ON ORIGINAL THROTTLE BODY (OEM PART) IN 2018. VEHICLE WAS TURNED ON AND STATIONARY IN A PARKING LOT. HEARD A LOUD KNOCKING, DIAGNOSED AT FORD DEALERSHIP. REPLACED ORIGINAL THROTTLE BODY WITH NEW OEM THROTTLE BOTTLE. SECOND OCCURRENCE ON REPLACEMENT THROTTLE BODY (OEM PART) IN JUNE 2019. VEHICLE WAS IN MOTION ON AN INTERSTATE, WRENCH LIGHT CAME ON, PUTTING THE TRUCK IN LIMP MODE AND THE TRUCK STALLED. I PULLED OVER ON THE SIDE OF THE INTERSTATE, TURNED THE TRUCK OFF, WAITED SEVERAL MINUTES AND TURNED VEHICLE BACK ON. CLEARED THE FAULT AND WAS ABLE TO CONTINUE DRIVE WITH LOUD KNOCKING SOUND OCCURRING LIKE IN THE FIRST INSTANCE.

3 MILES INTO MY TRIP WITH SEVERAL STARTS AND STOPS. LOW BREAK FLUID WARNING LIGHT. PULLED OVER WITH WORKING BREAKS BUT RESERVOIR WAS ALMOST EMPTY. LOSS OF BREAKS AFTER A COUPLE MORE STOPS. TOPPED OFF BREAK FLUID RESERVOIR. RAN MOTOR 5 MIN BEFORE LOW FLUID WARNING LIGHT, NO SIGN OF EXTERNAL LEAK. LEAKING APPEARS TO BE FROM MASTER CYLINDER TO VACUUM BUSTER. PULLED VACUUM LINE FROM VACUUM BUSTER ELIMINATED THE LOSS OF FLUID. AND WAS ABLE TO LIMP HOME WITH MANUAL BREAKS.

I WAS DRIVING ON THE NORTH TEXAS TOLLWAY TODAY. GET A LOW BRAKE FLUID WARNING LIGHT. WHEN I TRIED TO SLOW DOWN THE BRAKES WENT TO FLOOR. 0% BRAKING. FORTUNATELY, COASTED TOT A STOP ON THE INSIDE SHOULDER OF A HIGH SPEED TOLLWAY - DANGEROUS. EVENTUALLY TOWED TO PARK CITIES FORD (DALLAS, TEXAS). HAD I TAKEN THE NEXT EXIT I WOULD HAVE ENTERED A BUSY MULTIPLE LANE HIGHWAY SYSTEM FROM AN ELEVATED OVERPASS. VERY LIKELY WOULD HAVE BEEN A MAJOR ACCIDENT WITH HIGH LIKELIHOOD OF INJURY. THIS IS A WELL MAINTAINED VEHICLE. RECENT SERVICE. NO WRECKS. NO BRAKE FLUID SEEN WHERE THE TRUCK WAS PARKED PRIOR TO TODAY'S EVENT. ABSOLUTELY, NO WARNING.

I WAS DRIVING TO WORK AND ON MY WAY ABOUT 7 MILES INTO MY DRIVE, I RECEIVED A NOTICE ON THE INSTRUMENT PANEL INDICATING MY BRAKE FLUID WAS LOW, I CLICK THE OK BUTTON AND CONTINUED DRIVING, UMMIEDIATELY UPON COMING TO THE NEXT LIGHT TO STOP MY BRAKE PEDAL WENT TO THE FLOOR AS I PRESSED HARD TO STOP, THE TRUCK DID NOT STOP AND I RAN THE RED LIGHT BUT MAKING A TURN AND NEARLY HITTING ONCOMING TRAFFIC. THE TRUCK CAMED TO A ROLLING STOP AND I PRESSED THE EMERGENCY BRAKE AND STOPPED ON THE SIDE OF THE ROAD. THIS TRUCK I PURCHASED LAST YEAR IN FEBRUARY OF 2018 AND HAS ONLY 32,000 MILES BUT FORD SAID THE TRUCK WARRANTY HAD EXPIRED AND THE COST WAS $1235.41. I AM FIGHTING FORD AND HAD OPENED A CASE BUT THEIR INVESTIGATION DETERMINED THEY ARE NOT AT FAULT! I AM HERE TO SEE IF NHTSA CAN HAVE THEM RECALL THEIR BRAKES.

PURCHASED FROM MULLINAX FORD PALM BEACH ON 4/13/2018. THE VEHICLE IS A 2016 FORD F150. I HAVE OWNED THIS VEHICLE SLIGHTLY OVER A YEAR AND HAVE EXPERIENCED COUNTLESS ISSUES, MOSTLY WATER LEAKS INTO THE TRUCKS CAB THAT IS WETTING THE CARPETING CAUSING HUMIDITY AND MOLD ISSUES, MULLINAX FORD TAKES THE VEHICLE IN FOR REPAIR, SUPPOSEDLY REPAIRS THE VEHICLE AND RETURNS IT TO ME, THE ISSUES ARE STILL PRESENT AFTER MULTIPLE VISITS TO THE DEALERS SERVICE DEPT. I REACHED OUT TO FORD MOTOR CO CUSTOMER RELATIONS IN REGARDS TO A BUY BACK, FORD DENIED THE CLAIM, THE REPAIRS HAVE BEEN SUB PAR AND PER MY OWN RESEARCH FROM OTHER SERVICE ADVISORS AT OTHER DEALERS ARE NOT THE CORRECT FIX. I REACHED OUT TO THE SALES DEPARTMENT FOR ASSISTANCE, THEIR ASSISTANCE WAS MINIMAL, OFFERING BELOW MARKET VALUE AND NO ASSISTANCE IN PRICING FOR A REPLACEMENT VEHICLE, THE CARPETING IS WET CAUSING MOISTURE MOLDY SMELLS, AND MULLINAX HAS YET TO CONTACT ME WITH AN AVAILABLE APPOINTMENT TO FIX THESE ISSUES AND FORD CUSTOMER RELATIONS HAS NOT RETURNED MY EMAIL BUT IS SUPPOSEDLY SUPPOSED TO CONTACT ME WITH ON FRIDAY TO TOUCH BASE. I HAVE RECORDS OF ALL SUPPOSED REPAIRS, AS WELL AS PICTURES AND VIDEO DOCUMENTING ALL THESE ISSUES. REPAIRS: INTEGRATED WHEEL END REPAIR ATTEMPTS: 1 SUNROOF LEAK REPAIR ATTEMPTS: 3 (ISSUE STILL PRESENT) BROKEN SUNROOF GUIDES (BROKEN BY TECH) REPAIR ATTEMPTS: 1 HIGH MOUNT BRAKE LIGHT LEAK: REPAIR ATTEMPT: 1 CARPET SHIELDING REWORK REPAIR ATTEMPT: 1 VAPOR MANAGEMENT VALVE REPAIR ATTEMPT: 1

GAS TANK FUEL PUMP AND FUEL PUMP DRIVER WENT BAD AT 56,000 MILES. WOULD START WHEN CRANKING THEN IDLE ROUGH FOR A FEW SECONDS AND SHUT OFF

HORN ASSEMBLY IS NOT WORKING WHILE IN MOTION OR PARKED. THE AFTER THE MONTH BUMPER TO BUMPER WARRANTY WAS UP THE HORN STOP WORKING, INCLUDING SOUND WHEN USING THE KEY TO LOCK/UNLOCK TRUCK, AND THE PANIC ALARM DOES NOT SOUND. WAS INFORM FROM DEALERSHIP WE WILL HAVE TO PAY TO HAVE THIS CORRECTED 433.83. GOES BACK TO FORD DEALER SHIP ON JULY 15 2019

RADIO/AUDIO DOES NOT WORK INTERMITTENTLY ON 2016 F150 PLATINUM SYNC SYSTEM. THIS IS WIDELY NONE PROBLEM WITH THESE TRUCKS AND FORD IS NOT DOING ANYTHING ABOUT IT. THIS IS RELATED TO NHTSA ID #10091432. FORD TSB #SSM 45945. THIS WAS A $70,000 AND FORD IS ACCEPTING RESPONSIBILITY TO FIX A SIMPLE RADIO ISSUE.

LIGHT CAME ON BRAKE FLUID LOW THEN IMMEDIATELY NO BRAKES GOING DOWN THE ROAD. BAD MASTER CYCLINDER.

I HAVE CONTACTED GUS JOHNSON FORD NUMEROUS TIMES TO HAVE MY RECALLS FIXED THEY ALWAYS TELL ME THEY ARE ORDERING THE PARTS. THIS STARTED OVER A YEAR AGO IN THE WINTER WITH MY DOOR UNABKLE TO CLOSE. I NEED MY RECALL FIXED ASAP